2015 Ford Explorer complaints

DRIVING ON A TWO LANE HIGHWAY AND THE POWER STEERING COMPLETELY FAILED. WE WERE TOLD BY THE DEALERSHIP WHERE WE PURCHASED THE CAR TO BRING IT IN BUT IT SOUNDED LIKE "STEERING ASSIST FAULT" SINCE THAT WAS THE ERROR MESSAGE, DUH.IT WAS COST $500 FOR AN ALIGNMENT? REPLACED FAULTY RACK AND PINION GEAR AND CHECKED ALIGNMENT(SHOULD BE OK SINCE THEY ALIGNED IT THE SAME DAY) TOTAL BILL $2291.00 THIS IS A 2015 EXPLORER LIMITED THAT HAS BEEN IN THE SHOP SEVERAL TIMES FOR CAR A CARBON MONOXIDE LEAK IN THE CABIN OF SUV FOR REPAIRS, POWER SEAT REPAIRS AND INTERIOR DOOR PANEL COMING APART.

WHILE DRIVING, FORD EXPLORER DASH WRENCH LIGHT INDICATOR TURNS ON THEN SUDDENLY YOU LOOSE POWER AND CONTROL AND BRAKING, TECHNICAL DISABLED. YOU HAVE TO COME TO A ROLLING STOP. THEN TURN ON CAR AGAIN TO REMOVE WRENCH LIGHT.

I WAS DRIVING MY 2015 FORD EXPLORER SPORT ON A ROAD. SUDDENLY, THE CAR SHOWED AN ERROR STEERING ASSIST FAULT AND SERVICE ADVANCE TRAC MESSAGE ON DASHBOARD. THE STEERING WHEEL BECAME VERY HARD TO ROTATE AND I AVOIDED THE ACCIDENT. THE CAR WAS UNCONTROLLABLE AND BECAUSE OF THIS, THE TURN INDICATOR KNOB HAD SOME ISSUES. I HAD TO KEEP HOLDING THE INDICATOR KNOB IN ORDER TO TURN ON RIGHT/LEFT INDICATION. I HAD TO PUT SO MUCH EXTRA FORCE TO ROTATE THE STEERING WHEEL DURING TURNING. THIS WAS A VERY DANGEROUS SCENARIO. I STOPED THE CAR IN A PARKING LOT, TURNED OFF THE CAR, AND WAITED FOR 5 MINUTES TO TURN ON. AFTER THAT THE CAR WORKED WELL FOR FEW MORE MINUTES. THE SAME ERROR AND ISSUE STARTED HAPPENING AGAIN AFTER FEW MINUTES SO I TOOK THE CAR TO FORD DEALERSHIP. THEY CHECKED THE CODE AND FOUND STEERING GEAR ISSUE, FAILURE CODE U2011:49. THIS IS A MAJOR ISSUE RELATED TO SAFETY. IT CAN CAUSE FATAL ACCIDENT BECAUSE OF UNCONTROLLABLE STEERING WHEEL ISSUE.

TL* THE CONTACT OWNS A 2015 FORD EXPLORER. THE CONTACT STATED THAT WHILE HIS WIFE WAS DRIVING 25 MPH, THE STEERING WHEEL CEASED WITHOUT WARNING. THE STEERING WHEEL WAS AGGRESSIVELY TURNED TO THE LEFT AND TO THE RIGHT AND RESUMED NORMAL OPERATION. THE VEHICLE WAS TAKEN TO WORLD FORD PENSACOLA (6397 PENSACOLA BOULEVARD, PENSACOLA, FL 32505) TO BE DIAGNOSED WHICH WAS STILL PENDING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT TO FILE A COMPLAINT WITH THE NHTSA. THE FAILURE MILEAGE WAS APPROXIMATELY 107,000.

DRIVING AT 20MPH OVER A BRIDGE, MY TOE LINK SNAPPED, CAUSING ME TO LOSE CONTROL AND VEER OFF THE ROAD LOSING CONTROL. I LOST COMPLETE CONTROL OVER MY STEERING AND TIRES REMAINED TURNED, LOSING ALL CONTROL AND ABILITY TO DRIVE. THE TOE LINK WAS SERVICED BECAUSE THERE WAS A RECALL. HOWEVER, THIS WAS THE SECOND TIME THE TOE LINK WAS FIXED ON THIS VEHICLE. NOW, ONLY MONTHS AFTER PURCHASING THIS VEHICLE, THERE IS ANOTHER ISSUE REGARDING THE TOE LINK AND BUSHINGS. FORD AND DEALERSHIP REFUSE TO COVER THE CHARGES BECAUSE RECALL HAS ALREADY BEEN SERVICED. MY CONCERN IS THAT THE PROBLEM WILL BE FIXED TEMPORARILY FOR A FOURTH TIME AND WILL SNAP AS I AM GOING FASTER SPEEDS THAN THE 20 MPH I INITIALLY LOST CONTROL AT. THERE NEEDS TO BE ANOTHER RECALL ON MY ALREADY RECALLED PART, OTHERWISE THERE WILL NEVER BE ANY SAFE DRIVING DISTANCE IN THIS VEHICLE. *TR

TL* THE CONTACT OWNS A 2015 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING AT 80 MPH, THE DRIVER'S SIDE DOOR KEYPAD DETACHED. THE VEHICLE WAS TAKEN TO FORD OF KENDALL (15551 S DIXIE HWY, MIAMI, FL 33157, 305-238-9211) AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT COVERED UNDER WARRANTY. THE CONTACT WAS PROVIDED AN ESTIMATE OF $512 TO REPAIR THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

STEERING ASSIST FAULT LIKE CAME ON WHILE DRIVING. I WAS UNABLE TO STEER. LUCKILY NOBODY WAS HURT. BUT THIS COULD HAVE BEEN DEADLY FOR MYSELF, GRANDDAUGHTER AND ANYONE ELSE AROUND. THERE WAS NO WARNING. NO SOUNDS NOTHING. I SEE FORD HAD RECALLS FOR UP UNTIL 2013 FOR THIS PROBLEM, BUT I DON'T SEE ANY FOR 2015. AND FROM READING INFORMATION IT HAS CAUSED ACCIDENTS INJURING PEOPLE. I WOULD LIKE TO SEE A RECALL ON THIS

AIR BAG LIGHT CONSTANTLY STAYS ON. WINDSHIELD PILLAR CAME FLYING OFF AT 70 MILES AN HOUR. *TR

TL* THE CONTACT OWNS A 2015 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING AND ATTEMPTING TO MAKE A LEFT TURN, THERE WAS AN ABNORMAL SOUND COMING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO CARRIAGE FORD INC (908 E. LEWIS AND CLARK PKWY, CLARKSVILLE, IN 47129, (612)284-4444) TO BE DIAGNOSED. THE STRUT BEARINGS WERE REPLACED HOWEVER, AFTER TEST DRIVING THE VEHICLE, THE CONTACT WAS INFORMED THAT THE RACK AND PINION NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED AT A COST OF $2,300. THE CONTACT WAS CONCERNED THAT THE FAILURE WAS DUE TO A DEFECT IN THE MANUFACTURING OF THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 54,000.

TL* THE CONTACT OWNS A 2015 FORD EXPLORER. THE CONTACT STATED THAT THERE WAS FLUID LEAKING FROM THE POWER TAKE OFF UNIT. THE VEHICLE WAS TAKEN TO JIM TIDWELL FORD (2205 BARRETT LAKES BLVD, KENNESAW, GA 30144), TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE POWER TAKE OFF UNIT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 108,000. *LN*JB

POWER STEERING STOPPED WHILE DRIVING. THIS IS NOT A TYPICAL POWER STEERING PUMP, IT IS ELECTRONIC. WHEN A NORMAL ONE FAILS, YOU CAN STILL STEER EASILY WHEN MOVING. IT ONLY BECOMES HARD WHEN STOPPED OR MOVING SLOW. THE ELECTRONIC ONE GETS EXTREMELY HARD EVEN AT HIGHWAY SPEEDS. I HAVE BROUGHT IT TO THE DEALERSHIP WHICH DIAGNOSED IT AS THE RACK AND PINION. I HAVE SEEN ONLINE THAT THERE ARE MANY THAT HAVE FAILED WITH THE SAME ISSUE FOR MULTIPLE YEARS FROM AROUND 2011 ON WHICH TELLS ME IT IS FAIRLY COMMON EVEN ON VEHICLES WITH LOW MILEAGE. *TR

FRONT END POPPING NOISE WAS NOTICED AFTER 50,000 MILES. WAS TOLD TO DISREGARD, IT WAS NORMAL. AT 67,000 NOISE BECAME LOUDER, SENSATION IN STEERING WHEEL FELT, LOSS OF STEERING MOMENTARILY. THIS HAPPENS WHEN SITTING STILL, WHILE DRIVING AND ESPECIALLY WHILE MAKING SHARP TURNS. FORD JUST QUOTED $2100 TO REPLACE. I'VE SEEN MANY MORE COMPLAINTS RELATED TO THIS. THIS IS A HUGE SAFETY CONCERN AND A RISK FOR ANYONE WHO DRIVES THE VEHICLE. WHY HASN'T THERE BEEN A RECALL ISSUED YET? *TR

THE PAINT IS STARTING TO BUBBLE IN SEVERAL SPOTS ON THE FRONT EDGE OF THE HOOD. I SEE NO RUST OF ANY KIND JUST BUBBLING PAINT. I METICULOUSLY CARE FOR THIS CAR REGULAR WASH AND WAXES. *TR

DRIVER DOOR: THE DOOR BLACK TRIM PANEL IS COME OUT AND IT WONT LET ME OPEN AND CLOSE MY WINDOW PROPERLY. I HEAR ABOUT THIS ISSUES IN THE DEALER, BUT I DIDN'T RECEIVE ANY RECALL ABOUT IT. PLEASE, I NEED YOU FIX IT, THIS ISSUES, IT IS 2015 FORD EXPLORER, AND I HAVE OTHER VEHICLE OF 2006, IT DOESN'T HAVE ANY ISSUES ABOUT THE INSIDE OF THE BODY. *TR

MY AIR BAG LIGHT IS ON AND WON;T GO OFF SO I TOOK IT TO A FORD DEALERSHIP AND THEY TOLD ME THAT THE BACK AIR BAGS WIRE WERE LOOSE AND IT WOULD COST ME $600.00 TO CONNECT THEM BACK. *TR

I WAS DRIVING DOWN THE HIGHWAY AND ALL OF A SUDDEN THERE'S A SNAP NOISE AND THEN I SEE THIS RUBBER FLAPPING AT THE WINDSHIELD ON THE PASSENGER SIDE. WHEN IT FIRST STARTED HITTING THE WINDSHIELD IT SCARED US HALF TO DEATH. I GOT OFF THE HIGHWAY AND PULLED OVER TO LOOK AND SEEN THE PASSENGER WINDSHIELD PILLAR HAD COMPLETELY BROKEN IN HALF WHILE I WAS DRIVING, FLEW OFF AND WAS GONE. I LATER FOUND OUT THAT THIS IS VERY COMMON IN THE FORD EXPLORERS, THAT THESE WINDSHIELD PILLARS FLY OFF. IM DISAPPOINTED THAT THERE HASN'T BEEN A RECALL TO FIX THIS PROBLEM SEEING IT HAPPENS QUITE FREQUENTLY TO THESE CARS ACCORDING TO LOTS OF PEOPLE ON CARCOMPLAINTS.COM AND IM VERY THANKFUL IT DID NOT FLY AND HIT SOMEONE ELSE'S CAR OR CAUSE AN ACCIDENT. HONESTLY I THINK FORD SHOULD PAY FOR THE REPLACEMENT NOT ME. SAD BECAUSE I JUST BOUGHT THIS CAR A LITTLE OVER A MONTH AGO AT CARMAXX. *TR

WHILE DRIVING CAR SUDDENLY STARTED TO SPUTTER AND I COULD NO LONGER ACCELERATE.. HAD ROLL TO A COMPLETE STOP.. ONCE STOPPED I LET IT SIT FOR A MOMENT AND IT RESTARTED AND I WAS ABLE TO MAKE IT HOME.. IT HAS HAPPENED ON AT LEAST 3 OCCASIONS.. AND ON THE DASHBOARD IT DISPLAY A YELLOW WRENCH AND SAYS SEE MANUAL.. THIS IS VERY DANGEROUS BECAUSE I WAS IN TRAFFIC ON ALL 3 OCCASIONS. *TR

I WAS DRIVING ON HIGHWAY 45 IN ILLINOIS IN MY 2015 FORD EXPLORER AND WAS SLOWING DOWN FOR A RED LIGHT WHEN MY POWER STEERING FAILED AND A WARNING CAME ON IN THE VEHICLE INFORMATION DISPLAY STATING "STEERING ASSIST FAULT " SERVICE REQUIRED. I WAS THREE BLOCKS FROM THE FORD DEALER AND DROVE THERE. STEERING WAS VERY DIFFICULT AND I WAS FORTUNATE TO BE SO CLOSE TO THE DEALER. A TECH DID A PIN POINT INSPECTION ON THE VEHICLE AND THE NEXT DAY I WAS TOLD THAT THERE WAS CORROSION IN THE POWER STEERING CONTROL MODULE TERMINAL CONTACTS. GREASE WAS APPLIED AND I WAS CHARGED $323.00 . I WAS ADVISED THAT IF THIS HAPPENED AGAIN THAT I MAY NEED TO REPLACE THE POWER STEERING CONTROL MODULE ON THE VEHICLE AND THIS WOULD COST $2300.00. THIS VEHICLE HAS 33500 MILES ON IT AND IS GARAGE KEPT WITH REGULAR MAINTENANCE . I ASKED WHY THE TERMINAL CONTACTS WEREN'T CHECKED DURING REGULAR MAINTENANCE WHICH WAS DONE THREE MONTHS AGO AND WAS TOLD IT IS NOT PART OF THE INSPECTION .

POPPING SOUNDS COMING FROM RIGHT SIDE WHEEL. TOOK TO FORD DEALER TO BE SERVICED AND THE TOLD ME THE GEAR STOP IN THE RACK AND PINION AS BROKEN OFF AND NEEDS TO BE REPLACED AND WOULD PUT ME AT $2100. THEY ALSO TOLD ME IF I DID NOT WANT TO REPLACE IT AT THIS TIME I COULD LEAVE IT ALONE AND CONTINUE WITH THE POPPING SOUND OR THEY COULD CUT IT OFF BUT THEN I WOULD NEED TO BE CAREFUL AND NOT OVERLY TURN THE STEERING WHEEL. *TR

REAR TOE LINK - REAR SUSPENSION MAY HAVE WELD CRACK AT BUSHING HOUSING ATTACHED TO THE FRAME -NO INCIDENT YET. *TR

IT IS THE SAME PROBLEM BACK AS BEFORE. WHEN YOU ACCELERATE OR GO UP A HILL YOU HAVE AN HORRIBLE EMISSION ODOR. I HAVE HAD THIS FIXED, BUT IT IS BACK. *TR

THE DOOR, WINDSHIELD, AND EXTERNAL WINDOW SEALS ARE RAPIDLY DETERIORATING, THE PAINT ON THE CAR HOOD IS BLISTERING AND ABOUT TO PEEL OFF LIKE PAINT DID ON CARS SEVERAL AGO, LEAVING BARE METAL VISIBLE UNDERNEATH. *TR

THIS CAR HAS STARTED SHOWING ALL SIGNS OF CORROSION ON THE FRONT HOOD. I HAVE DONE MY OWN RESEARCH AND FOUND THOUSANDS OF OTHER EXPLORERS WITH THE SAME ISSUE. EVERY OUTCOME HAS BEEN DIFFERENT FROM EACH DEALERSHIP TO ANOTHER. HERE IS A COPY OF THE NHTSA ID NUMBER WITH THE CORRESPONDING TSB AND SUMMARY I AM ALSO ATTACHING SEVERAL PICTURES FOR EVIDENCE. (ALL PICTURES WERE TAKEN BY AN AUTHORIZED FORD DEALERSHIP- METRO FORD IN OKLAHOMA CITY, OK) NHTSA ID NUMBER: 10156863 MANUFACTURER COMMUNICATION NUMBER: TSB 19-2026 SUMMARY SOME 2000 AND NEWER FORD, LINCOLN AND MERCURY VEHICLES EQUIPPED WITH ALUMINUM BODY PANELS MAY EXHIBIT CORROSION CONCERNS APPEARING AS BUBBLED AND/OR PEELING PAINT WITH OR WITHOUT ACCOMPANYING WHITE DUST. PANEL REPLACEMENT IS RECOMMENDED. FOLLOW THE SERVICE PROCEDURE STEPS TO CORRECT THE CONDITION. *TR

STARTED HEARING POPPING SOUND ON PASSENGERS SIDE WHEN BACKING AND TURNING AND NOW IT HAS ADVANCED TO STEERING FEELS LIKE IT CATCHES OR BINDS FOR A SECOND WHILE DRIVING DOWN ROAD. *TR

I BOUGHT THIS VEH. IN 2016 WHEN IT HAD 17,000 MILES ON IT. WITHIN 2 WEEKS I GOT A WARNING LIGHT FOR THE AIR BAG SYSTEM. TOOK IT TO THE DEALER AND WAS ADVISED THAT THE SENSOR GIVING TROUBLE WAS IN THE SEAT BELT AIRBAG FOR THE REAR PASSENGER SEAT. I WAS REPAIRED UNDER WARRANTY FOR TECHNICAL SERVICE BULLETIN TSB-0001 PUBLISHED JANUARY, 2016. I HAVE HAD TROUBLE OFF AND ON EVER SINCE WITH THE AIRBAG WARNING LIGHT. IT WOULD STAY ON FOR A LITTLE WHILE AND THEN GO OFF. I HAD THE DEALER CHECK IT AND THEY COULD NOT FIND A PROBLEM WITHOUT THE LIGHT BEING ON. THIS WEEK IT STAYED ON SO I HAD THE DEALER CHECK IT. IT HAD THE CODE B141B WHICH WAS THE SAME CODE REPAIRED IN 2016. SINCE THE REPAIR WAS WARRANTEED FOR 12 MONTHS THE DEALER WANTS $797 TO FIX THE CURRENT ISSUE, WHICH IS THE SAME ONE FROM 2016. I VERY SELDOM USE THE BACK SEAT AS I HAVE NO CHILDREN IN MY HOUSE. I WOULD RATHER NOT SPEND THAT MONEY, SINCE I AM RETIRED, BUT IF I DON'T GET IT FIXED ALL OF THE OTHER AIR BAGS IN THE VEHICLE WILL NOT WORK. I CONFIRMED WITH A SERVICE ADVISOR THAT NONE OF THE AIRBAGS IN THE VEHICLE WOULD DEPLOY IF THAT LIGHT IS ON. I ASKED HIM IF THERE WAS A WAY TO BY-PASS IT IN THE SYSTEM SO THE LIGHT WOULD GO OFF AND HE SAID IT IS A FMVSS THAT COULD NOT BE MODIFIED AND MUST BE FIXED THE RIGHT WAY. I FEEL LIKE I AM BEING HELD HOSTAGE IN AN UNSAFE VEHICLE UNLESS I PAY THE $797 TO GET IT FIXED (AGAIN).

AFTER SITTING FOR 1 MONTH, I WENT TO START AND BATTERY WAS DEAD. AAA GOT CAR RUNNING, AND BATTER WAS RECHARGED. SORT TIME AFTER, POWER STEERING BECAME INOPERABLE AND HAS BEEN FOR 6 WEEKS. STEERING NOW MANUAL AND VERY STIFF. *TR

AS I WAS DRIVING MY VEHICLE ON THE FREEWAY, THE DRIVER SIDE DOOR STARTED TO SWING OPEN AS I WAS TURNING AND WOULD NOT STAY CLOSED. I HAD TO HOLD THE DOOR SHUT UNTIL I COULD SAFELY PULL OVER. WHEN I GOT OUT OF THE VEHICLE TO INSPECT THE DOOR I NOTICED THAT THE EXTERIOR DOOR HANDLE WAS LOOSE. I WAS ABLE TO GET THE DOOR TO REMAIN CLOSED AFTER PUSHING THE HANDLE BACK IN AND LOCKING THE DOOR.

MY WIFE PULLED OUT OF THE DRIVEWAY INTO TRAFFIC GOING TO WORK ONE DAY. WHEN SHE PULLED OUT THE CAR SHIFTED HARD THEN WENT INTO NEUTRAL. MY WIFE'S QUICK THINKING TO PULL OF THE SIDE OF THE RD SAVED HER FROM GETTING REAR ENDED. SHE PUT CAR IN PARK THEN SHIFTED TO GO AGAIN. AT THAT MOMENT IS WHEN THE CAR STARTED HOPPING AS SHE DROVE DOWN THE RD. SHE PULLED OVER TO CALL ME. I INSTRUCTED HER TO GO HOME AND NOT TO WORK. I GOT HOME HOURS LATER FROM WORK I THEN DROVE OUR 2015 FORD EXPLORER. IT SHIFTED HARD THEN STARTED TO HOP I TOOK IT HOME AND DID A VISUAL INSPECTION ON THE FLUID LEVEL TIRES AND SHOCKS. I DIDN'T SEE ANYTHING ABNORMAL. THE NEXT DAY I TOOK IT TO FORD DEALER THEY DROVE IT AT 96000 MILES SAID THEY COULDN'T DUPLICATE IT. FAST FORWARD WE HAVE 105000 MILES ON IT PROBLEM PERSISTENTLY GETTING WORSE WE TOOK IT BACK TO VILLAGE FORD. THEY DROVE IT AND SUSPECTED THE TRANSMISSION. THE NEXT DAY THEY CALLED SAYING IT WAS THE TRANSMISSION AND IT WOULD BE 5500.00 $ TO FIX IT. THEY COULDN'T PUT IT ON A DIAGNOSTIC MACHINE BEFORE WARRANTY WAS OUT BUT THEY COULD WHEN OUT OF WARRANTY. NOW I FIND MYSELF SPENDING 4500.00 DOLLAR AUTO REPAIR THAT COULD'VE BEEN DETECTED IF THEY WOULD'VE DIAGNOSED IT PRIOR TO NOW. REGGIE THE SERVICE MANAGER AND THE SERVICE TEAM AT VILLAGE FORD FAILED ME

PURCHASED THE VEHICLE 4 MARCH, WAS GONE FOR 10 DAYS. IN THE DAYS SINCE THEN, I HAVE EXPERIENCED EXHAUST SMELLS IN THE VEHICLE MULTIPLE TIMES, TO THE POINT THAT I HAVE BECOME LIGHT-HEADED. USUALLY, THE SMELLS ONLY HAPPEN WHEN THE VEHICLE IS RELATIVELY STATIONARY (I.E. STOP SIGN, PARKED BUT ENGINE STILL RUNNING IMMEDIATELY FTER GETTING HOME, DURING ACCELERATION FROM A STOP, REGARDLESS OF THE SETTING ON THE HVAC SYSTEM. I'M ATTEMPTING TO RETURN THE VEHICLE AT THIS TIME AFTER RESEARCHING MULTIPLE LAWSUITS AGAINST FOR FOR THE FAULTY DESIGN. DUE TO THE ELUSIVE NATURE OF THE PROBLEM, I CAN'T PROVIDE PHOTOGRAPHIC EVIDENCE. ALSO, ON-GOING SHIPPING PROBLEMS IN AMERICA (DUE TO COVID 19 PROBLEMS) HAVE LED ME TO NOT BEING ABLE TO SOURCES PARTS TO PROVE THERE IS ALSO CARBON MONOXIDE IN ADDITION TO THE NORMAL AROMA OF CAR EXHAUST.

MY DAUGHTER IN LAW WAS DRIVING THE VEHICLE WHEN THE POWER STEERING ASSIST FAULT CAME ON THE SCREEN AND STEERING BECAME VERY HARD. SHE WAS DRIVING IN TOWN AROUND 30 MPH AND WAS ABLE TO PULL OVER AND STOP THE VEHICLE. WHEN SHE RESTARTED IT THE FAULT WAS GONE AND SHE WAS ABLE TO DRIVE HOME. I FOUND THAT THERE WERE MANY CASES OF THIS HAPPENING ON THE INTERNET AT SPEEDS FROM SLOW TO FAST. I TOOK THE VEHICLE TO THE LOCAL DEALER WHO TOLD ME THE STEERING GEAR HAD TO BE REPLACED. HE ALSO SAID THERE WAS NO RECALL ON MY FORD EVEN THOUGH SEVERAL COMPLAINTS WERE ON THE WEB. THEY ARE ORDERING THE PART FOR IT AND THE PARTS AND LABOR ARE OVER 2000$. WILL FORD WAIT TIL SOMEBODY GETS KILLED BEFORE THEY RECALL THE VEHICLES?

TL* THE CONTACT OWNS A 2015 FORD EXPLORER. THE CONTACT STATED THAT THE AIRBAG WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE RODEO FORD LOCATED AT (13680 W. TEST DRIVE, GOODYEAR, AZ 85338, (623)298-3900) WHO NOTICED AND INFORMED THE CONTACT THAT THERE WAS A PINCHED WIRE UNDERNEATH THE REAR SEAT OF THE VEHICLE, WHICH WOULD CAUSE THE AIRBAG TO FAIL TO DEPLOY IN THE EVENT OF A CRASH. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE HOWEVER, NO ADDITIONAL ASSISTANCE WAS PROVIDED. THE APPROXIMATE FAILURE MILEAGE WAS 50,000.

SLOWLY PULLING OUT OF NARROW PARKING LOT EXIT LANE, THROUGH OPENED GATE. RAPID UNEXPLAINED ACCELERATION, SEEMED TO LAUNCH CAR ACROSS ONE WAY CITY STREET INTO RESTAURANT BUILDING. PASSENGER SEAT BELT (FASTENED, LEFT BRUISES) RELEASED UPON IMPACT; PASSENGER DASH BOARD AIRBAG DID NOT DEPLOY; DRIVERS' AIRBAG WEAK. PASSENGER HOSPITALIZED FROM LOWER AIRBAG, BROKEN LEG, SEVERE LACERATION.

OUR VEHICLE HAS EXHAUST ISSUES, THE CAR IF LEFT IDLING FOR VERY LONG AT ALL WILL MAKE THE ENTIRE VEHICLE SMELL. THIS CAUSES PASSENGERS TO HAVE A HEADACHE AND SOMETIMES BECOME SLEEPY. THE SMELL IN THE VEHICLE HAS BEEN SO BAD AFTER IDLING FOR A WHILE AND THEN DRIVING WE HAD TO PULL OVER AND OPEN ALL DOORS.

DRIVER INTERIOR DOOR PANEL HAS SEPARATED

WHILE DRIVING AT ANY SPEED, THE CAR WILL SUDDENLY STOP ACCELERATING. ONCE YOU ARE ABLE TO GET COMPLETELY STOPPED AND TURN THE CAR OFF AND RESTART IT, IT WILL DO OK UNTIL THE SAME THING HAPPENS AGAIN WITH NO WARNING. WHEN IN TRAFFIC OR WITH NO PLACE TO PULL OFF OR COAST TO, THIS IS EXTREMELY DANGEROUS. HAS HAPPENED TO ME ABOUT 10-20 IN THE PAST 2 -3 YEARS. AFTER RESEARCHING ONLINE, I READ MANY OF THE SAME SITUATIONS. TOOK TO LOCAL DEALER AND THEY DIAGNOSED IT AS THE THROTTLE BODY AND SAID THERE WERE NUMEROUS EXPLORERS WITH THE SAME PROBLEM.

THERE WAS A RECALL ON MY 2015 FORD EXPLORER FOR THE TOE LINK SUSPENSION REPLACEMENT. I HAD OT FIXED ON 1/7/20 AND ON 2/14/20 I WAS DRIVING ON 106 IN SPRINGFIELD VERMONT DOING 50 MILES PER HOUR AND THE TOE LINK SUSPENSION THEY REPLACED BROKE AND I LOST TOTAL CONTROL OF MY SUV. ALL MOST HAD HEAD ON COLLISION I WAS ALMOST KILLED. I HAD IT TOWED TO FORD DEALERSHIP AND THEY TOOK IT APART AGAIN AND STATED THAT THE REASON THE TOE LINK SUSPENSION CONTINUES TO BREAK IS DUE TO THE NUCKLE AND BUSHINGS. AND FORD CORPORATION SAID IT WAS NOT COVERED AND THERE FOR I WAS RESPONSIBLE FOR THE REPAIRS AND TOTAL COST. WHICH IS $2,411 I DO NOT HAVE THAT KIND OF MONEY. MY SUV IS STILL AT FORD DEALERSHIP. NEED HELP RESOLVING THIS ISSUE AND GET MY SUV FIXED AS IT IS THERE CAUSE OF THE BREAKAGE. PLEASE TELL PEOPLE NOT TO DRIVE THERE VEHICLE IF THERE TOE LINK SUSPENSION IS BAD CAUSE WHEN IT GOES YOU HAVE NO CONTROL OF YOUR STEERING. AND YOU NEVER KNOW WHEN ITS GONA HAPPEN. IT'S LIKE SLIDING ON ICE SIDE WAYS. VERY SCARY. NEVER WANT TO GO THOUGH THIS EVER AGAIN. THIS HAPPEN ON A BUSY STREET WITH ON COMING VEHICLES THAT SOME HOW I DIDNT HAVE HEAD ON COLLISION. I DO NOT HAVE PICS AS MY VEHICLE WAS TOWED TO FORD DEALERSHIP. HIDE TIRE ON PASSENGER SIDE POINTED OUT AND WOULD DRIVE SIDE WAYS AND THAT'S WHAT I WAS DOING AT 50 MILES AN HOUR. NOT A GOOD FEELING

THE AIR BAG WARNING LIGHT TURNS ON FOR NO REASON

I HAVE RECENTLY HEARD A POPPING SOUND WHEN I TURN THE STEERING WHEEL. THIS HAPPENS WHEN STATIONARY AND IN MOTION. I HAVE HAD A MECHANIC LOOK AT MY VEHICLE AND STATE THAT THE RACK SYSTEM NEEDS TO BE REPLACED AND THAT THERE IS A CHANCE THE STEERING CAN LOCK UP WHILE DRIVING. I DID RESEARCH AND FOUND THERE ARE RECALLS ON FORD EXPLORERS FOR 2011 TO 20014 BUT NOT 2015. WHY? IT IS THE SAME ISSUE JUST A DIFFERENT YEAR.

AIRBAG LIGHT STAYING ON. DEALER DIAGNOSED REAR SEAT ISSUE AND $911.00 TO REPAIR. FORD ISSUED TSB 16-0001 DUE TO IT BEING A COMMON PROBLEM. DUE TO THE HIGH COST OF REPAIR SOME CUSTOMERS DO NOT HAVE THE REPAIR COMPLETED RESULTING IN AN UNSAFE SITUATION. SINCE THIS INVOLVES AN IMPORTANT SAFETY ISSUE A MANDATORY RECALL SHOULD BE REQUIRED SO THE MANUFACTURING DEFECT CAN BE RESOLVED.

STEERING STARTED MAKING A "KNOCKING" NOISE WHEN MOVING THE STEERING WHEEL. THIS OCCURS WHILE IN PART OR IN MOTION. I WAS TOLD BY THE REPAIR SHOT AND MY 2015 EXPLORER WITH 45K MILES ON IT NEEDS TO HAVE THE RACK AND PINION REPLACED AT A COST OF $2100. NOT COVERED UNDER WARRANTY AND APPARENTLY NO RECALL FOR THIS DANGEROUS SITUATION.

THE DRIVER AND PASSENGER SIDE DOOR ARM RESTS ARE COMING APART AT THE SEAMS AS IS THE CENTER CONSOLE. THE INTERIOR OF MY 2015 EXPLORER WITH 45K MILES LOOKS TERRIBLE. LOOKS LIKE IT'S 20 YEARS OLD. I AM SHOCKED.

SINCE OCTOBER 2019 I HAVE HAD MY CAR IN 4 AUTO SHOPS FOR A PROPANE SMELL,, SO STRONG IT WOULD MAKE YOU FEEL SICK DRIVING. THE 4TH AUTO SHOP SAID IT WAS THE TURBOS LEAKING. WE CHANGED THOSE. NOW THE SMELL IS LESS BUT YOU CAN NOT SIT IN IDLE BECAUSE IT GETS VERY STRONG. MIND YOU THIS CAR WAS A 1 OWNER BEFORE ME, AND I BOUGHT IT USED FROM A DEALER JUNE 2019. DROVE ONLY 4 MONTHS AND NOW 4 MONTHS OF NOT BEING ABLE TO DRIVE IT BUT HAVE TO MAKE PAYMENTS ANYWAY. IM AT A LOSS! HOW CAN FORD NOT HANDLE THIS? REALLY, COPS HAVE EVEN GOTTEN IN ACCIDENTS. I CAN'T JUST DRIVE IT RISKING OUR HEALTH OR LIVES. I REALLY HOPE THEY RECALL THE WHOLE VEHICLE, IT'S NOT RIGHT TO RISK EVERYONE'S LIVES.

FRONT PASSENGER SIDE WINDSHIELD MOLDING BECAME LOOSE AND BROKE OFF WHILE DRIVING ON HIGHWAY. THE WINDSHIELD SEAL ALSO FLEW UP AND APPROXIMATELY 3 FEET OF THE THE SEAL CAME OFF AND WAS FLAPPING AGAINST PASSENGER WINDOW BEFORE COMING COMPLETELY DETACHED. IT LOOKS LIKE SOME OF THE WHITE CLIPS ARE BROKEN ON THAT SIDE WINDSHIELD PANEL SO WE ARE UNSURE HOW TO FIX THIS. SO NOW WE ARE MISSING THE ENTIRE SIDE WINDSHIELD MOLDING, AND ABOUT 2 TO 3 FEET OF WINDSHIELD STRIPPING. NOW WHILE TRAVELING ON THE HIGHWAY, THERE IS ALSO A VIBRATION AND SOUND LIKE AIR IS COMING IN FROM AROUND THE WINDSHIELD. THIS ALL HAPPENED IN THE UPPER 30,000 MILE RANGE WHEN I HAD THE VEHICLE FOR ONLY 3 MONTHS.

THE FUEL GAUGE ON THE INSTRUMENT PANEL IS READING THAT THE FUEL TANK IS ALMOST FULL, HOWEVER WHILE DRIVING THE LOW FUEL WARNING SENSOR CAME ON AND WE NEARLY RAN OUT OF FUEL. THE GAUGE WAS STILL READING ALMOST FULL. WE BARELY MADE IT TO A GAS STATION. AFTER PUTTING IN A FULL TANK OF GAS, THE FUEL GAUGE WAS SHOWING A COMPLETELY FULL TANK. SINCE THEN, THE GAUGE IS ALWAYS SHOWING ALMOST COMPLETELY FULL AND WILL GO DOWN ONLY TO ALMOST FULL, NOT QUITE AS LOW AS 3/4 FULL TANK, EVEN IF YOU HAVE DRIVEN OVER 300 MILES. NOW WE HAVE TO RE-SET THE TRIP ODOMETER EVERY TIME WE GET GAS, SO WE CAN CALCULATE APPROXIMATELY HOW MANY MILES WE HAVE DRIVEN SINCE THE FUEL GAUGE ONLY GOES DOWN SLIGHTLY BELOW FULL. THIS OCCURRED AROUND 50,000 MILES.

THE AIRBAG WARNING LIGHT CAME ON WITHOUT WARNING OR INCIDENT (NO ACCIDENT OR IMPACT, JUST STARTED MY CAR ONE DAY AND THE LIGHT STAYED ON). PER RESEARCH DONE ONLINE WITH SAME WARNING LIGHT, MAKE AND MODEL OF VEHICLE, ISSUE APPEARED TO BE WITH THE REAR/2ND ROW SEAT BELT AIRBAGS DISENGAGING AND THIS CAUSES NONE OF THE AIRBAGS TO WORK IN THE VEHICLE IN THE EVENT OF A CRASH. AT THE TIME THE LIGHT INITIALLY CAME ON I HAD ABOUT 72K MILES ON MY CAR, AND IT APPEARS THIS IS ABOUT THE SAME MILEAGE OF ALL OTHER EXPLORER OWNERS WITH THIS ISSUE. I TOOK IT IN FOR SERVICE FOR THE LIGHT AND INCURRED REPAIRS TOTALING JUST UNDER $1,000 TO HAVE THE PARTS REPLACED AND THE AIRBAGS FUNCTION AGAIN. THE FACT THAT I DID NOTHING (OTHER THAN TURN ON MY CAR WHEN IT WAS APPROACHING THE 70-75K MILEAGE MARK) TO CAUSE MALFUNCTION OF THE AIRBAGS BUT HAD TO PAY $1,000 TO FIX IT AND HAVE AIRBAGS WORK IN MY CAR IN THE EVENT OF AN ACCIDENT IS DISAPPOINTING. FORD NEEDS TO ISSUE A RECALL FOR THIS, IT'S UNACCEPTABLE TO HAVE OWNER AND PASSENGER SAFETY COMPROMISED THROUGH NO FAULT OF THE OWNER, AND HAVE TO INCUR COSTLY REPAIRS TO MAKE THIS RIGHT. I KEPT MY RECEIPTS AVAILABLE TO PROVE CAUSE AND COST OF AIRBAG LIGHT ISSUE.

IN DECEMBER 2019 WHILE DRIVING AT ABOUT 70 MPH UPHILL ON INTERSTATE HIGHWAY AT NIGHTIME, THE ENGINE SUDDENLY LOST POWER. DEPRESSING THE ACCELERATOR PEDEL HAD NO EFFECT AND THE TRANSMISSION ACTED AS IF IT WAS SHIFTED TO NEUTRAL EVEN THOUGH IT WAS STILL IN DRIVE. THE ENGINE RPM SEEMED TO DROPP TO IDLE SPEED. I LOST FORWARD MOTION RAPIDLY. I HAD TO CROSS TWO LANES OF HIGH SPEED TRAFFIC TO PULL ONTO SHOULDER. IT WAS A VERY DANGEROUS MANUEVER AS THERE WAS CONSIDERABLE TRAFFIC AND I HAD TO REACT QUICKLY. I HAD TO CUT IN FRONT OF CARS MOVING MUCH FASTER THAN I WAS, CAUSING THEM TO HAVE TO BRAKE HEAVILY. THE ENGINE CONTINUED TO RUN FOR A WHILE AT ABOUT IDLE SPEED ONCE I REACHED THE SHOULDER, BUT WOULD THE VEHICLE WOULD NOT MOVE FORWARD. ALL LIGHTS ON VEHICLE, INCLUDING EMERGENCY FLASHERS, WORKED FINE. WITHIN ABOUT A MINUTE OF GETTING TO THE SHOULDER, THE ENGINE STARTED RUNNING ROUGH AND THEN SHUT DOWN ENTIRELY AND WOULD NOT RESTART. I LIFTED THE HOOD AND SAW NOTHING OBVIOUSLY WRONG. AFTER SEVERAL MINUTES, I ATTEMPTEDD TO RESTART THE ENGINE. THE ENGINE RESTARTED IMMEDIATELY AND RAN WITH NO PROBLEMS AND I WAS ABLE TO CONTINUE WITH MY TRIP.

EXHAUST ODOR COMING FROM CLIMATE CONTROL VENTS. WHILE DRIVING WITH THE HEATER ON, NOTICED THAT WHEN WE'D COME TO A STOP A MILD EXHAUST ODOR WAS COMING FROM THE HEATER VENTS. PASSENGERS CONSISTED OF MYSELF, TWO TODDLERS AND PREGNANT WIFE. AFTER AN 8 HOUR DRIVE MY WIFE AND I HAD HEADACHES. NOT SURE THE SOURCE OF THE HEADACHE.

DOOR PANEL IS LIFTING. THIS SHOULD BE DEFECTIVE

I HAVE READ THAT THERE WERE RECALLS REGARDING PARKING BRAKES HOWEVER MY SPECIFIC MODEL 2015 BASIC MODEL EXPLORER WAS NOT ON THE LIST BUT MY PARKING BRAKES GAVE OUT AS I TRIED TO BACK OUT OF MY DRIVEWAY. THE BRAKE HANDLE POPPED UP AND I WAS UNABLE TO USE IT EVER SINCE AND I CANNOT DRIVE THE VEHICLE WITHOUT THE ALARMS GOING OFF WHICH INTERFERES WITH MY HEARING AIDS. TOOK IT TO DEALERSHIP AND THE DIAGNOSIS WAS THAT I NEEDED A BRAND NEW REPLACEMENT KIT, A COST OVER $700.

ON MY 2015 FORD EXPLORER XLT, THE WATER PUMP WHICH IS ENCASED INSIDE THE CYCLONE/DURATEC ENGINE, BROKE AND LEAKED COOLANT WHICH WAS MIXED WITH THE OIL, TGE OIL PAN AND THE OIL PUMP CAUSING COMPLETE ENGINE FAILURE. THERE WAS NO ADVANCE WARNING AND FORD HAS NOT ISSUED A RECALL ALTHOUGH A NUMBER OF MODELS HAVE BEEN AFFECTED. THIS CAUSED ME TO HAVE TO REPLACE MY ENGINE AT MY EXPENSE. FORD MOTOR COMPANY HAS NOT TAKEN ANY STEPS TO RESOLVE MY OR THIS ISSUE WITH THE VEHICLE OWNER HAVING TO RESOLVE THE ISSUE AT THEIR OWN EXPENSE.