2013 Ford Explorer complaints

Popping/Grinding Noises: experienced popping or grinding sounds when turning the steering wheel, especially at slow speeds. Steering Wheel Seizure: There have been instances where the steering wheel has seized, accompanied by error messages such as “service power steering now” and “service advancetrac,” indicating a potential failure of the rack and pinion system. Difficulty in Steering: A tight steering wheel, grinding noises, or shaking, particularly at higher speeds, can be symptoms of worn-out bushings or bearings in the rack and pinion. these issues are causing somuch more due to that steering wheel has play and i need to constantly get alignment, my tires are wearing out and tires are expensive to replace too, its causing me to spend absurd amount of money that i do not have

The contact owns a 2013 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the front windshield trim on the driver’s and passenger’s sides fractured. The contact stated that the windshield trim was flopping loosely across the front windshield. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 140,000. VIN tool confirms parts not available.

The contact owns a 2013 Ford Explorer. The contact stated that while driving at 25 MPH during rainy weather conditions, the rain started to enter through the windshield. The dealer was not contacted. The vehicle was not diagnosed or repaired. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure and confirmed that the recall parts were not yet available. The failure mileage was unknown. VIN tool confirms parts not available.

The contact owns a 2013 Ford Explorer. The contact stated that while driving at various speeds, there was an abnormal flapping sound coming from the driver's side of the front end of the vehicle. The vehicle was taken to the used car dealer, where it was inspected, but the cause of the failure could not be determined. The contact stated that the failure occurred intermittently. Additionally, the contact later became aware that the VIN was included in NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 154,000. VIN tool confirms parts not available.

The contact owns a 2013 Ford Explorer. The contact stated that anti-freeze was leaking from the vehicle. While driving at unknown speeds, the message that the engine was overheating was displayed. The vehicle was taken to an independent mechanic, who replaced the water pump. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 140,000.

A-pillar applique trim clip attachments are not properly engaged due to improper assembly or repair.

The contact owns a 2013 Ford Explorer. The contact stated when his wife was driving the vehicle she became sleepy from the exhaust fumes. The contact stated his wife would feel fine when she was not in the vehicle. The were no warning lights illuminated. The vehicle was taken to a local mechanic who informed the contact's wife to drive with the windows down and not to drive passengers. The vehicle was not repaired, but the mechanic discussed replacing both exhaust manifolds. The manufacturer was made aware of the failure and referred the contact to NHTSA Hotline for assistance. The approximate failure mileage was 119,000.

Exterior A pillar trim three off the vehicle while driving.

The power steering failed and almost caused me to get into an accident. My safety was put at risk because I almost crashed into on coming traffic making a left hand turn. There are thousands of other who have complained about this issue from 2013-2017 models. Power assist fault light came on and I lost full control of the steering of the vehicle. This is absolutely ridiculous this hasn't been one of the biggest recalls of all time. 10's of thousands of these Explores have had the same situation happen and because my build date was out of the initial 14s06 recall I had to pay out of pocket over $2000 dollars. This is a major safety concern that needs to be addressed. I work at a Ford dealership and one of the employees just bought a 2017 Explorer a week ago and the steering gear just failed on that one. Recall 14s06 needs to be extended to all Explorers from 2013-2017.

Carbon monoxide leaking into cabin causing carbon monoxide detector to go off.

UNKNOWN. My sister had went to town in her car. She had came back home and parked the car in the driveway. After doing so her and her husband we inside, heard a rumbling sound went outside and car was on fire. The neighbors say they saw the car just catch on fire in her driveway. She had purchased the car less than 60 days ago in Manhattan, ks from CSM AUTO.

The contact owns a 2013 Ford Explorer. The contact stated that the front driver's side exterior door handle cover and keyhole detached while opening. Additionally, the front driver's side door failed to latch, and the contact had to force the door to close. The dealer was made aware of the failure; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The contact related the failure to NHTSA Campaign Number: 15V171000 (Structure) however, the VIN was not included in the recall. The failure mileage was approximately 106,000.

My power steering just stopped working while I was driving at 45 mph. Then all my warning light were going off saying faulty break system faulty hill decent something about my charging system. This has happened 4 times now where my power steering goes out WHILE I’M DRIVING.

See attached document for complaint

The contact owns a 2013 Ford Explorer. The contact stated while driving 65 MPH, the windshield exterior A-pillar trims detached and were hitting against the vehicle. The contact stated that she pushed the trims back into the original position. Additionally, the contact stated that she noticed that water was leaking inside the vehicle through the windshield, while it was raining and while the vehicle was at the car wash. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The failure mileage was unknown. VIN tool confirms parts not available.

Power steering became very hard and got stuck suddenly while driving, very dangerous. Was very difficult to steer the car or move the steering even an inch. Good that was driving at low speed, otherwise could have been an accident. After 2 days it started showing warning message about power sterring but at time of steering got stuck there was no warning. In process to repair, it's very dangerous as steering got stuck out of no where and expensive to have it fixed (approximately 1600 dollars).

The Electronic Power Steering Assit (EPAS) has had a failiure. When the failiure happens it completely locks up the steering without prior warning.When that happens the cars steering cannot be controlled as norrmal, and the driver cannot easily steer the vehicle. The first time this happened I was pulling into a gas station, the EPAS went out and I almost hit pedestrians, a fuel pump and other vehicles. Had it not been for my years of driving experience this could have inured or even killed several people. The issue has been confirmed by my local Ford dealerships service department. The service manager told me that this car has had recalls on it, but upon checking my VIN found that Ford Motor Company did not include my vehicles vin under the recall. Even though this issue is known with my make and model. This issue has also been reported on many Ford Explorer group pages for others who have had the issue but were missed under the recall umbrella. The failiure message only appears after the acutal failure, meaning the steering is already gone by the time the warning is shown

The contact owns a 2013 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the A-pillar applique trim was loose and had damaged the windshield gasket. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 115,000. VIN tool confirms parts not available.

Rear backup camera stopped working a year ago. the rear of the car is a huge blind spot and have had a few close calls with pedestrians and other vehicles' when backing out of parking spots. My son also has a 2013 Explorer and his rear camera stopped working several years ago.

The driver side exterior A-pillar applique trim detached from the vehicle in early 2020. I assumed the failure was a chance occurrence, but a recently reported recall identified this as a manufacturer's defect. I had to have the repair done myself at a cost of $335.81.

Both the rear door lock actuators on my 2013 Ford Explorer broke within a month of each other. I am aware of actuator recalls on different Ford vehicles and I believe these broke for the same reasons as the other Ford actuators were recalled.

The contact owns a 2013 Ford Explorer. The contact stated that upon starting the vehicle, the steering wheel locked with the "Steering Assist Fault Service Required" message was displayed. The contact stated that upon restart of the vehicle, the vehicle returned to normal operation; however, the failure returned later. The vehicle was taken to a dealer where the contact was informed that the vehicle was not included in NHTSA Campaign Number: 14V286000 (Steering). The manufacturer was notified of the failure and provided the contact a case number. The vehicle was not repaired. The failure mileage was unknown.

My vehicle was purchased new from Ford dealer with factory tow option, which comes with an undercarriage cover with integrated air scoop to help cool engine & transmission while towing. This cover (Ford # BB5Z-9910494-A) is designed with quarter tern thumb screws to hold it on to the undercarriage. While driving on highway, this part fell off and was not recovered. Now my vehicle is at risk of serious damage to either transmission or engine, or both in not having this key part. The weak design for fastening this metal part to the vehicle is a serious safety hazard, and Ford should provide a resigned replacement part through recall.

Vehicle steering stopped working and was towed to my mechanic. Mechanic was great and said that this was a Ford recall, however the dealer informed me that the vin number didn’t match. They have had a recall for Explorer that were manufactured 3 months prior to ours. This was expensive and new parts are unavailable because of so many issues, had to use rebuilt ones and installed at dealers. Please reopen the recall on explorer steering failure and see if maybe more explorers should be added to recall. Thanks for reading I hope this helps me and many other Explorer owners with same issue.

2013 explorery EPS system randamly will go out causing very hard steering to the point you almost crash. It don't matter if it's dry or wet hot cold it'll randomly come on and it'll pull you to the side. There's been a recall for this couple times but I'm told my vehicle isn't in the recall well I don't understand why it's not because I've had the Ford dealership come out and reflash my PSCM and still it comes on and I lose power steering almost killing myself and my family multiple times now I don't know what to do it cost way too much for me to buy new parts all the time they say the recall won't apply to it but I don't understand why it won't it's been recalled that's confirmed recalled why can't I get my vehicle fixed on my family is safe

We own a 2013 Ford Explorer XLT AWD 3.5L with an Odometer reading of 150,507 that we bought used from a private owner and owned for over a year. In the recent weeks of 1/5/2024 - 2/9/2024 the Power steering assist has gone out while maneuvering in and out of our garage multiple times. With a restart, the power assist comes back and seems to be ok for a few days until recently while driving, multiple times the steering wheel became locked in the 12:00 position and it took extra effort to turn the wheel from center. It appears as a faulty or sized rack and pinion. Also recently noticed audible noise while turning the steering wheel from lock to lock coming from the steering rack. I am an Automotive Technician in the field for 30+ years. That next morning I raised the vehicles front wheels off the ground and rotated the steering wheel with engine off to investigate the issue. I noticed a severe binding issue while rotating the steering wheel where the steering wheel will come to a binding stop and it takes 2 hands to get past the binding. At this point I knew this is a major safety concern and to not have my wife drive this vehicle anymore until repaired. I have researched the Technical Service bulletins on this issue and searched the internet as well. Obviously this has become a very common issue on these Explorers with all the filed complaints and the lack of availability of a replacement Rack and Pinion. I went to the Ford dealer to inquire about this known issue and safety c

The power transfer unit defective and I almost lost control of my vehicle without warning The vehicle has been inspected

Steering is very tight sometimes on turns and there is a lot of play in the steering wheel itself, i changed out almost all suspension and steering related parts and still have this issue. Also the steering wheel somehow always is off center and crooked even after multiple alignments

The contact owns a 2013 Ford Explorer. The contact stated that while attempting to start the vehicle, the steering wheel was locked. The contact stated that there was a message displayed that the steering wheel was locked. The vehicle was towed to a local mechanic where a diagnostic test was performed. The mechanic stated that the power steering had failed. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 159,000.

The contact owns a 2013 Ford Explorer. The contact stated that while driving at an undisclosed speed, the contact heard an abnormal sound. The contact became aware that the power steering was inoperable. The contact stated that the steering was extremely difficult to turn due to the failure. However, the vehicle was safely driven to the residence. The vehicle was towed to an independent mechanic however, the vehicle was not diagnosed or repaired after remaining with the mechanic for two weeks. The vehicle was towed back to the residence. The contact stated that there was an open recall for the failure, but the VIN was not included in the recall. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 135,000.

I bought the car from auction. The car was Represent like "Run and drive". But the car come with a lot of rust into the frame and this problem means a structural damage. The car it is not good for driving and it is not possible to be registered.

The contact owns a 2013 Ford Explorer. The contact stated while driving at approximately 30 MPH, while turning the steering wheel to the right to follow the road, the steering seemed to seize, and extra effort was needed to turn the steering wheel. The contact arrived at her destination and parked the vehicle. When the contact returned to the vehicle and restarted the vehicle, the power steering functionality had not returned. The contact stated no warning light was illuminated. The contact had not taken the vehicle to a dealer or an independent mechanic. The vehicle was not diagnosed and was not repaired. The manufacturer was not informed of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 14V286000 (Steering). The failure mileage was approximately 150,000.

Every time it rains, water comes inside the vehicle on the back side, noticed water coming from the third row seat belts, that cause a bad smell inside the vehicle and cost a lot of money to get that fix, Unknow how to fix, I called the Dealer the stated that is a known problem with this vehicles .

Last year I had to replace my front rack and pinion costing me a couple thousands of dollars. While driving the power steering went making it very difficult to steer and have good control of the vehicle. No safety lights or warnings came on at this time. One year later just a few days ago the same exact thing happened. No warning, no lights. I called my local ford dealer because I researched and seen a recall for power steering issues. The dealership told me my vehicle was not included in the recall. I am worried that this is not only an issue that I have but others on the road driving these lemons. I have had nothing but issues with this vehicle. It is unsafe at this point. I am unaware of what determines recall eligibility but the model I am driving most certainly needs to be included. I cannot afford to replace another rack. This vehicle is not even paid off yet. So frustrating and concerning. Ford needs to step it up before someone really gets hurts.

The windshield makes a loud cracking sound (for the last 4 months- this is how ong ive owned it) and a few weeks ago, the sound happened and the window cracked from the frame toward the center (about 7").

The electronic power steering system seems to be failing causing extremely hard steering. This seems to be a common issue among the explorer family. It is not causing any warning lights or check engine lights to appear on the dash. This could potential cause crashes due to intermitent failures. I have had it inspected by a local mechanic who stated this is a common problem that was recalled on some explorers but mine did not qualify. Mechanic stated the repairs could be extremely pricey.

We purchased a 2013 Ford Explorer in June of 2023. I had changed the rear wheel bearings on the vehicle and we had an alignment done at a local Firestone Auto Repair shop after the bearings were replaced. The Firestone shop did the alignment and the steering wheel felt stiff after. We drove the vehicle for two days after the alignment and around August 1, 2023 then the power steering went out on my wife when she had our infant son in the car. She said the service advance track light was flashing red and power steering light was flashing as well. She had no steering at all and luckily she was able to park the vehicle and get a ride home safely. I took the vehicle to a local Ford Dealer and they said the alignment computer showed the steering wheel was 30 degrees off. They re calibrated the alignment but could not confirm that was the reason the power steering went out but gave me a quote to repair the power steering unit. When they pulled it out of the shop, the power steering came back on. We drove the vehicle until around August 30 2023 and the power steering went out again when my wife was driving the vehicle. We had an independent shop look at it and when they hooked it up to the scan tool, it said power steering fault. When they pulled it out of the shop, the power steering came back on. We drove the vehicle until November 3, 2023 when the power steering went out again while driving and had a different Ford Dealer look at it. The diagnoses was intermittent power steering

Power steering failure. I noticed appeared on the instrument panel briefly before the vehicle power steering seized. I was unable to move the steering wheel in any direction without significant force. I was not driving thankfully or else this may have resulted in a serious accident due to inability to steer vehicle on public road.

Driving on a two lane highway with the cruise control set, tapped brake to eliminate the cruise as a truck had pulled onto highway ahead of us. Accelerated to pass the truck and resumed the cruise control to maintain previous speed. The vehicle began increasing speed as if the gas pedal was floored. Tapping brakes didn’t stop it nor did shutting the cruise off on the steering wheel, car was going 80-90 mph. Had to ride the brakes while the throttle seemed to be wide open until we could get it in neutral and pull of on the shoulder. Restarted the vehicle after it was shut off and the throttle was wide open again. The third time I started it, it appeared to be running normal. I did not engage the cruise control after that. At the time there was no engine light or warning light on. About a week later the engine light came on then a couple days later it was not on. Then it randomly would come on. I had scheduled an appt and it was determined the throttle body, gasket and purge valve needed replaced. This was an extremely scary situation and I would like to know if this has been an issue and could it possibly happen again? This could’ve caused a serious accident when you have zero control of the speed and it’s approaching 90mph on a highway. I did get repairs that were an expense over $500. Is there an explanation as to why this happened and can it randomly occur again??

The contact owns a 2013 Ford Explorer. The contact stated while driving 5 MPH from a parking spot and turning the wheel to the left, the steering wheel seized. The steering wheel failed to turn left or right. The contact was able to reverse into a parking spot. The traction control warning light was illuminated. The vehicle was towed to the local dealer, where it was diagnosed that the steering needed to be replaced. The manufacturer was contacted, and the contact was informed that the vehicle was not covered under recall. The contact stated that the failure was related to NHTSA Campaign Number: 14V286000 (Steering). The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was 105,000.

I was driving and the steering wheel seized up and locked while I was turning to the left. The car continued to turn left despite my best efforts to straighten the wheel or turn it in any other direction. I just slammed on the brakes to stop from hitting someone or something. Eventually, the steering wheel loosened and I was able to park. During the parking, the steering wheel continued to stay tight and was difficult/almost impossible to turn. I called a tow truck and got the vehicle taken to my local Ford Dealership. I looked online to see what the issue might be and that's when I noticed many complaints/concerns about power steering in 2013 Ford Explorers. This is what I found: "Ford recalled certain model year 2011-2013 Ford Explorers, saying these vehicles “may experience an intermittent connection in the electric power steering gear, which can cause a loss of the motor position sensor signal resulting a shut down of the power steering assist.” This is the exact problem that I have but I never received a recall notification. I contacted Ford and they said my car wasn't made in the same plant that the recall vehicles were made. However, other articles point out that it was widespread and continuous. "Ford Motor Co. announced three safety recalls in North America, including nearly 775,000 Explorer SUVs for an issue that may result in loss of steering control and thus increase the risk of a crash." The recall number was 14S06 but I am being told I don't qualify for the reca

My vehicle was struck by a tractor trailer at 55-60 mph while sitting still. The impact caused my vehicle to spin and be embedded into the guardrail. None of the airbags deployed.

I started to notice a slight “slipping” or “sliding” feeling when driving on wet roads or if I hit a pothole or man cover just right. Then while my kids and I were on vacation over Christmas break, I hit a small wet spot on the road and began to fishtail. Luckily we avoided an accident. I was unable to drive over 20mph without feeling like I would lose control. When we had it checked by a mechanic we were told it the toe link on both rear tires were snapped, an issue Ford has recalled several times, as recently as 2020. We spoke with a Ford mechanic and were told my vehicle didn’t have any active recalls related, the toe link had been recalled previously but was supposedly fixed in 2019, just months before the most recent recall. As a result, we had to pay the almost $600 repair bill.

The contact owns a 2013 Ford Explorer. The contact stated that while driving at approximately 50 MPH, the vehicle started shaking abnormally. Additionally, the contact stated that the A/C unit was inoperable. The vehicle was taken to the dealer where it was diagnosed that the air compressor and the CV joint had failed and needed to be replaced. The vehicle had not been repaired by the dealer. The vehicle was then taken to an independent mechanic where it was diagnosed that there was a leak of Freon. The mechanic also diagnosed that there was a strong odor of carbon dioxide coming into the cabin of the vehicle. The vehicle had not been repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 109,000.

The contact owns a 2013 Ford Explorer. The contact stated that while driving at an undisclosed speed, the vehicle made an abnormal sound. Additionally, the steering wheel was loose while driving. The vehicle was taken to an independent mechanic, who diagnosed that the front axle needed to be replaced. The vehicle was not repaired. The contact stated that the transfer case had previously been replaced. The manufacturer was made aware of the failure and informed the contact that there was no recall associated with the VIN. The failure mileage was approximately 198,000.

The contact owns a 2013 Ford Explorer. The contact stated that while opening the trunk lid, he became aware of the liquid. The vehicle was taken to the dealer where it was stated that the leak was coming from a cracked weld seal near the liftgate. No warning light was illuminated. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 170,000.

ELECTRICAL RACK AND PINION - LOCKED UP STEERING WHEEL. Wife driving car could have been hurt. Was inspected by independent service person. No warning !!

The contact owns a 2013 Ford Explorer. The contact stated that there was water leaking inside the vehicle while her mother was driving and while the vehicle was parked in the rain. The contact stated that water was leaking in the driver's side of the vehicle and in the trunk. The contact stated that water was settling in the front driver's side floorboard and in the trunk. The contact stated that her mother had removed approximately a gallon of water out of the vehicle on one occasion. The vehicle was taken to the dealer several times. The dealer informed the contact that the failure could be due to a clogged drain plug. Several unknown repairs were performed on the vehicle; however, the failure persisted. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was unknown.

The left and right windshield panels flew off of my Ford Explorer truck.

The contact owns a 2013 Ford Explorer. The contact stated that after starting the vehicle the Electronic Power Steering had malfunctioned and the steering wheel was difficult to turn in either direction. After restarting the vehicle the failure had self corrected and the vehicle operated as normal. The failure was intermittent but eventually the failure became a permanent problem. The vehicle was taken to the local dealer who diagnosed that the Steering Rack Assembly was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure but no assistance was offered. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 14V286000(Steering). The contact indicated that the vehicle had experienced that same failure listed in the recall. The failure mileage was 120,000.