2020 Ford Escape Hybrid complaints

The contact owns a 2020 Ford Escape. The contact stated that the front driver's door arm assembly was fractured and made it hard to open and shut the door. The vehicle was taken to an independent mechanic, where it was diagnosed with a fractured door and arm assembly, and the door and arm assembly needed to be replaced; however, the vehicle was repaired. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 33,000.

The contact owns 2020 Ford Escape. The contact stated that upon reversing out of his driveway, the vehicle shut off with a green LED light on the start button flashing. The contact called an independent mechanic and scheduled to have the vehicle towed. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 26,000.

The driver door made a loud noise when I opened it. I took it to my Ford dealer and they told me the door hinges had broken. Now my window will not go down and the Ford dealer suggested I take the car to a weld shop to fix.

My front left drivers side door wouldnt close, I noticed the spot welds holding the door strap component in place had broke free and was now being pushed into the door shell. I took my car to the dealership and they said it is not covered. I have since looked on line, on how to repair this defect and see this is a known issue to the make and model year of my vehicle.

Vehicle would not shift out of park from a cold start. Dial shifter would not rotate. Vehicle could start but could not be driven. Problem has not been confirmed by dealer or independent service center. There were no warnings. Vehicle had been sitting in the sun in a parking lot on an 89 degree day for two hours. Cooling the vehicle cabin with A/C for 1/2 hour allowed the dial shifter to operate.

THE MANUFACTURER WELDS ON THE DOOR CHECK ARM FAILED. THIS PREVENTED THE DRIVER SIDE DOOR FROM CLOSING. INSPECTED BY DEALERSHIP AND THEY ACKNOWLEDGED THAT FORD WAS AWARE OF THE PROBLEM. THEY HAVE HAD MANY SIMILAR FAILURES ON BOTH THE ESCAPE AND EDGE VEHICLES. FORD HAS SAID THEY WILL NOT MAKE "OUT OF WARRANTY" REPAIRS. THE REPAIRS ARE AT OWNERS OWN EXPENSE AND FORD WILL NOT ISSUE A RECALL FOR WHAT IS A MANUFACTURING DEFECT. FORD'S SOLUTION, REPLACE ENTIRE DOOR AND ASSEMBLY. MY OPINION, FACTORY WELDS SHOULD NOT FAIL.

Opened driver side door making a popping noise coming from stop arm. found that spot welds broken off and stop arm will not allow me to open door not allowing me access to get into driver side door. found ssm 50150 on the internet. this is a safety issue and needs to be a recall.

The contact owns a 2020 Ford Escape. The contact stated that while opening and closing the driver's side door, there was an abnormal crunching sound coming from the door. The contact stated that he observed that the welds on the door and the check arm were fractured. The contact stated that the driver's side window no longer raised or lowered as designed. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the driver's side door needed to be replaced. The vehicle was repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 40,000.

THE "SPOT WELD" ON THE DRIVERS SIDE DOOR FAILED NOT ALLOWING THE DRIVERS SIDE DOOR TO OPEN OR CLOSE. THIS PROBLEM IS OCCURING ON BOTH THE FORD EDGE AND FORD ESCAPE ACCORDING TO JARRETT'S REPAIR PEOPLE. MINE IS A 2020 ESCAPE AND CANNOT BE REPAIRED. FORD WILL NOT ALLOW IT, AND WILL ONLY FIX IT IF IT FALLS UNDER THE 3 YR, 36000 PART OF THE WARRANTY. MINE IS OUTSIDE OF THE 36 MONTH WARRANTY AND THEY WANT TO BILL ME OVER $2000 TO REPAIR IT BY BUYING A NEW DOOR, NOT ACCEPTABLE. THIS IS A MANUFACTURER DEFECT AND FORD SHOULD FIX IT, WELDS SHOULD NOT FAIL.

A panel under the moon roof that is used to deflect water in case water leaks through the moon roof suddenly fell down on the back seat of the car while we were driving with the moon roof open. Upon inspection we discovered that this panel is glued to some foam pads and apparently the adhesive had lost it's grip. We were able to put the panel back in place. But the next time we opened the moon roof it came down again this time bouncing off the back seat and hitting my wife (the passenger) in the head. Fortunately, she was not injured. Had it hit me (the driver) it could have caused an accident with unknown consequences. Ford's response when we addressed it with Dealer was to replace the panel and install it using the same method of adhesive and foam pads. I believe this is an engineering failure because it was not secured with screws or nuts & bolts. Pictures of the part number and part are attached.

I was opening the front driver’s side door, the door failed to open completely. I had to forcefully pull the door handle for the door to open and heard a loud clicking noise. Took car to dealer and became aware that the latch was welded incorrectly and welded area broke. The dealer stated that the front driver’s side door needed to be replaced. The vehicle was not repaired because the door cost is $2,500 and my warranty had just expired 4-30-23. I called Ford customer service to tell them the door check broke out of door to see if they had some assistance for the cost. They said they did not. The failure mileage was 32,100. You can see with the pictures attached the right front door bracket is not broke and the Drivers side front door bracket is broke with three welding holes that broke off the bracket. The bracket cost $47 to $50, but they say the whole door needs to be replaced. $2500 cost is not fair to a owner when a small part breaks with the only fix and whole new door. If all four of my doors break soon the cost would be $10,000.00. This needs to be considered a RECALL so Ford can fix and bare the cost for a part that has gone bad and there are many complaints on this same issue. Thanks for looking into it.

Broken weld points inside the front driver-side door. There was no accident or impact to the door. The door was used properly and never overextended or caught by the wind to my knowledge. I am the primary driver. My spouse occasionally drives the car and he doesn’t recall any such incidents either. I opened it to get in one day and started hearing a popping sound. Immediately after the popping sound, I was not able to close the door. Ultimately, I was able to close the door but there are creaking and grinding noises every time I use the door.

2020 Ford Escape drivers door had the check arm fail due to the inner reinforcement bracket breaking off of the outer door shell. The failure caused the check arm to lodge into the window track and the door would not close and the vehicle couldn’t be driven or secured. The door made a popping sound just 1 time before the failure. Ford states an issue with the check arm welds failing in SSM 51553 but doesn’t have a remedy other than replacing the door. I worry a new door will fail in the same way unless it’s been redesigned.

The contact owns a 2020 Ford Escape. The contact stated that while refueling the vehicle, fuel started to spill out of the filler pipe onto the ground. The contact stated that during the failure, no fuel had entered the fuel tank. The vehicle was taken to the local dealer who diagnosed that the fuel tank filler pipe had failed and needed to be replaced. The fuel tank filler pipe was replaced, and the vehicle was fixed. The manufacturer was not notified of the failure. The failure mileage was 15,400.

The welds securing the check arm on driver's side door detached without prior warning during normal use, making the door nearly impossible to close fully, and keeping the window from going down more than about an inch. The dealer says they have seen multiple instances of this on the 2020 Escape, and there are many reports of the same thing on the internet. The body shop that repaired it has also seen it many times, always with the 2020 model. Ford appears to have strengthened it in subsequent model, but hasn't issued a recall and won't cover the cost the repair. Obviously, having a door (or even a window) that doesn't operate well, especially on the driver's side, is a safety issue. This detached check arm also allowed the door to swing out uncontrollably if caught by the wind or on a downhill slope, which could damage other cars in a parking lot.

On the driver's side door are spot welds that are breaking away and preventing the window from coming down. As documented in SSM-50150.

My driver’s side door top hinge the spot welds let go, I already had the door replaced by Ford under warranty back in 2021 my car is not under warranty anymore I have about 156,000 miles on it. I got a estimate at a body shop it will cost me about $1820 to replace the door.

Door started squeaking. Dealership checked and found that, "Door skin spot weld is broken under door weather strip near door check." Door has never been damaged by owner.

Welds holding driver's side door broke inside the door, door makes a crunching noise, is hard to close and window can't be rolled down. Door was not caught by wind or any other strain, no abnormal use. The car has 26,000 miles and the welds just gave out.

The driver's side front check arm welds inside the door broke loose, and the door can't be closed.

On the drivers side doir, the 3 spot welds for the door stop failed. Now it makes a horrible cracking sound. I was told the whole door needs to be replaced and I'm out of warranty. I've had the vehicle just over 3 years.

NHTSA ID Number: 10201603 Manufacturer Communication Number: SSM 50150 Summary Some 2020-2021 Escape vehicles may exhibit cracks or broken spot welds in the left front door at the check arm attachment point in the door assembly. Ford has been provided feedback from fleet customers of this condition on some vehicles with high usage profiles. The door assembly and door check arm replacement is the appropriate repair for this condition. Refer to the parts catalog and Workshop Manual (WSM), Section 501-03 as required to complete the repair. For claiming, use casual part 7823552 and the applicable labor operations of Section 12 and 13 of the Service Labor Time Standards (SLTS) Manual.

Pulling up to a stop sign going slowly as I was in a shopping center parking lot. When I applied the breaks they felt mushy and I had to pump the pedal. A red light flashed but quickly went out as I stopped. I believe it was the break warning light, but I was concentrating on stopping so can't be sure. Driving home all was well but the next day the break light came on and stayed on. I had the vehicle towed to the dealer, but noticed as I backed out of the driveway for the tow the break light was off. The dealer could not reproduce the issue and said there were no fault codes present.

While attempting to fuel the vehicle, thinking the hood latch was the fuel door release, the hood latch was pulled (twice). After completing fueling we re-entered the roadway and at about 45 mph, the hood flew up and backwards over the windscreen. We were able to stop the vehicle and close the hood without further incident although there is damage to body panels and the windscreen. Although an operator error was made by confusing the hood latch with the fuel door release, it seems like a poor and dangerous design to be able to completely unlatch the hood (no manual safety under the hood as is customary) allowing it to fly up while underway. Upon further investigation, we determined that the newest generation of these vehicles simply require two pulls of the hood latch to completely release it. The more typical method of one pull of the latch followed by manual release of the safety by reaching under the hood has been abandoned in this design.

The welds on the bracket inside the drivers door that attatch to the check arm broke, leaving me with 3 holes in my door and unable to close the door.

2020 FORD FOCUS. CONSUMER WRITES IN REGARDING UNINTENDED ACCELERATION.

Vehicle has gone stone dead on two occasions with no electrical response of any kind. Physical key was required to unlock. First was 11/21/22 at 9,733 miles. Vehicle spent 10 or so days in the shop while problem was traced and some warranty work was done. Second was 3/11/23 with same symptoms. Dead first thing in the morning. Mileage was 12,470. Based on first experience, purchased a robust charger and brought the car to 100 charge and problem solved for the short term. Online forums mention this as a common problem for this and the 2021 Escape hybrids. Fix seems to be getting a larger AGM battery which, with its greater capacity and faster charging capacity can better handle the parasites in the electrical system. In the runup to both 'deaths' the vehicle's computers began shutting down accessories such as remote start, handle touch unlocking, etc. All I ask is a replacement of the 12 volt battery with the larger 70aH AGM battery (Ford part BAGM48H6760). My wife and I have one car. She has a disability. I purchased this car to give her easier entrance and exit. It never occurred to me that it would not start reliably.

Vehicle enters deep sleep mode within minutes of parking and won’t start again until it is jump started. This software problem has left me stranded three times.

For no apparent reason, Driver side door malfunctioned in early March 2023. Every time the door was opened it would make a horrible popping sound. No accidents or incidents at all with the car, was bought new in Feb. 2021. This morning when the door was opened it sounded like something snapped, now the door will just swing wide open so I have to hold the door and barely open to squeeze in and out or it won't shut correctly. Called Ford Dealership and was advised to take to a body shop for repair, which would involve replacing the left front door check arm and door because the spot welds break on the driver door check arm attachment point, at a price point of over $2K. They stated that is is a common occurrence on the 2020 Escapes, because of a manufacturer defect. This is mentioned in the NHTSA ID #10201603. If a door will not properly shut or window properly open it won't pass a safety inspection for any state.

The contact owns a 2020 Ford Escape. The contact stated that the driver's side door failed to close, and the window failed to operate as needed. The vehicle was taken to the dealer, where the failure was diagnosed as a spot weld failure. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 10,500.

The contact owns a 2020 Ford Escape. The contact stated while having an annual inspection on the vehicle, the inspector informed her that the computer was not reading the vehicle and advised her to contact the dealer. The vehicle was taken to the dealer and the dealer stated that an unknown module needed to be updated. The contact was unsure of what module needed to be updated. The vehicle was not repaired. The manufacturer was contacted, and the manufacturer advised her to file a complaint with the NHTSA Hotline. The failure mileage was 140,800.

Reoccurring simultaneous failures of safety systems "Cross Traffic System Fault ", "Blind Spot System Fault", complete climate panel failure (defroster, heater, ventilation, ...), accompanying failures of power windows, power seats and most recently the ability to open the rear hatch of the SUV. Warnings about intermitent "Drive Mode Not Available". All of the above can occur suddenly when driving or at starting. Windows fog suddenly.

Driver door brake bracket spot welds failed preventing driver door from closing. Fortunately for me the event happened when I arrived home buy renders the vehicle unusable because the driver door is hanging nearly wide-open. I see via the internet thay others with this same vehicle are having the same issue and the repair requires the door to be replaced but there are no doors available. There are only 3 tiny spot welds securing this bracket to the door. The car has 49 thousand miles on the odometer and to my knowledge has never been wrecked. I purchased it in 2020 with 4 thousand miles on the odometer from Greene Ford in Gainesville Georgia.

This has happened a few times sporadically since I have owned the vehicle in 2020. As I am driving it will alert me to stop safely now. The car will loose power and not allow me to go past 15 mph. The screen will go blank and the ac will not throw cool air. This is concerning because since the car looses power, it is dangerous if I am at a fast speed. Once I pull over, sometimes I cannot turn off the car. And if I do turn it off, I cannot turn it back on for a few minutes.

I get the message to Stop Safely Now and then car turns off in the road. Will not turn back on. Also get messages for Deep Sleep Mode and Low Voltage. I do not feel that it is safe for the car to stop in the road and not be able to move. It has been to a dealership now this is the 3rd time for the issue. The light first appeared in November 2021. It was taken in for service then, again on Oct 18 2022 and now on Oct 26 2022.

The contact owns a 2020 Ford Escape. The contact stated while driving 76 MPH with the cruise control activated, the vehicle inadvertently decelerated without warning. The contact deactivated the cruise control feature and attempted to accelerate; however, the vehicle failed to accelerate as needed. The contact pulled over safely, turned off, and restarted the vehicle, and the vehicle operated as intended. The vehicle was taken to the dealer but was not diagnosed or repaired; however, the mechanic stated that the power module was possibly inoperable. The vehicle was not repaired. The manufacturer was contacted, and a case was filed, and stated that the vehicle needed to be diagnosed. The failure mileage was 19,500.

On June7th I was driving home in my 2020 hybrid escape when the motor quit and the car came to a stop, then smoke started coming out from under the hood, I opened the hood and flames shot out at the back side of the motor on the passenger side, oil was leaking on to the road and on fire, I called the fire department, when they got there all the fire finally went out as the oil burned up. I had the car towed that day to Purchase ford in Mayfield KY. where it is still at. At first I was told this would be a warranty covered job, the car had 37500 miles, the power train and motor are good for 60,000 miles. It was apparent this would take a long time to fix, and I told Ford I did not want the car back as it would be depleted in value with a history of a fire, In July I got a recall 22V484 for the very reason my car caught on fire. Come to find out the motor failed and thru a rod and a hole in the block let the oil leak out and catch on fire. I asked for a loaner but they did not have one, I rented a car and Ford finally paid for most of it but I'm still out $500.00, I have returned the rental car. I have made five months of payment on this car without having it. At first Ford said they would do a buy back, then they emailed me saying this was denied due to KY. guidelines? I also asked for another car of equal value and that will not happen. Finally Ford told me to accept the repairs on my car and take it back or they were closing my case. My case # is [XXX], my contact was custom

I was driving on the NYS Thruway with lane assist and cruise control enabled. This is after already having an issue with my computer where the car a couple of months ago just stopped in the middle of the road. This morning I was driving on the Thruway when suddenly, if felt like the collision impact system was engaged and the car shifted to the right slamming into the car next to me. No airbag deployment but extensive damage and collision system was completely engaged. The car issued no warnings or other issues afterwards. NYSPD arrived and completed report. Another car was involved. Only side damage.

The contact owns a 2020 Ford Escape Hybrid. The contact stated while driving 25 MPH, the accelerator pedal was depressed; however, the vehicle failed to respond. The contact stated that the vehicle rolled downhill into another parking lot and the contact parked the vehicle. The message "Drivability Unsafe" was displayed. The vehicle was towed to the dealer where it was diagnosed that the battery had failed and needed to be replaced. The dealer sent a diagnostic report to the manufacturer who declined to cover the battery replacement and advised the dealer to replace several unknown parts connected to the battery. The contact followed up with the manufacturer and a case was opened. The vehicle was not repaired. The failure mileage was approximately 15,000.

The contact owns a 2020 Ford Escape. The contact stated that upon opening the front driver's side door, the track arm of the door failed to catch, causing the contact to hold the door by the door handle. The contact stated that the failure had been reoccurring. The dealer was notified of the failure and informed the contact that the vehicle had to be repaired out-of-pocket as the vehicle was out of warranty. The contact referenced Ford Technical Service Bulletin Number: 10184651. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 48,000.

This is a hybrid and now (8/29/2022) 2nd incident of loss of power while driving on a busy highway along with error message Stop Safely Now. The gas motor fails to turn on and the electric motor and battery are too small to power the vehicle for more than a few hundred feet. The dealer performed TSB20-2365 back in November, 2020 to fix this problem. But now 22 months later it has returned. Like before, put the selector in Park and it locks up, can't even shift to Neutral to push the vehicle off of the highway. Someone is going to get killed due to this problem.

Windows operating intermittently. Repeatedly the dashboard flashes "Cross Traffic System Fault", "Blind Spot System Fault", "Blind Spot Left/Right Sensor Fault" occasionally "Cannot Access Memory While Driving". The lower center display panel on the instrument panel goes completely BLACK, and one cannot operate the defroster or air conditioner. The problem occurs intermittently, but when it starts it is more or less continuous for long periods of time. Ford (DeMontrond Ford) has now worked on the problem at least seven times, but safety issues do not stay fixed. Date below is when most recent series of issues occurred.

While normal driving received check engine light. Review message on ford pass received a exhaust gas recirculation system error. Had car repair at dealer with new sensor jul 15. Within a week had error reappear and clear. Approximately 5 weeks later the same error code is in again.

I contacted Fred Beans of Langhorne on 7-20-2022 about recall datedJul 07,2022 Manufacturer Recall Number22S47 NHTSA Recall Number AWAITING# Recall Status Recall Incomplete the associate said they had no fix at that time I am going to put the car in for regular maintenance in two weeks and will see if they are going to take care of this then this is described as a fire hazard

The contact owns a 2020 Ford Escape. The contact stated while getting into the vehicle she heard a loud noise when opening and closing the driver's side door. The contact stated that the driver's side door failed to open as needed and the driver's side window failed to roll down as needed. There was no warning light illuminated. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the door needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 48,010.

Repeatedly the dashboard flashes "Cross Traffic System Fault", "Blind Spot System Fault", "Blind Spot Left/Right Sensor Fault" occasionally "Cannot Access Memory While Driving". The lower center display panel on the instrument panel goes completely BLACK. The problem occurs intermittently, but when it starts it is more or less continuous for long periods of time. Ford (DeMontrond Ford) has now worked on the problem at least six times.

The contact owns a 2020 Ford Escape. The contact stated while attempting to start the vehicle, the key fob would not unlock the door. The contact attempted to manually start the vehicle however, there was no electrical power and the engine was not cranking. The contact jump started the vehicle. The contact stated that the failure was intermittent. The contact drove the vehicle to a local dealer, where it was diagnosed and determined that the connectors between the battery, the Power Train Control Module (PCM), and the battery needed to be replaced. The dealer stated that the battery connectors were wet due to severe weather in the area prior to the failure. The vehicle was repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 53,000.

All four brake rotors show premature signs of corrosion, rears worse than fronts, needed to have rotors replaced after 24 months.

2020 Ford Escape Titanium Hybrid - Battery does not start. Occurrence: twice at 15K and 21K. Total mileage on vehicle: 21K. Turning the ignition key of the Escape Hybrid, the electric motor is supposed to be activated. The electric motor, in turn, starts the gasoline engine. At this point, there is total failure.

This is a Bluetooth issue. When you’re talking on the phone, after period of time you begin to sound like a robot. You have to take your phone off of Bluetooth and put it back on Bluetooth taking your eyes off the road. Many times it’s while you’re on the highway. My husband works for a company who purchased 600 cars for their last project and everyone he knows has the same issue. It’s definitely widespread. The Ford company says you have to have a radio person to deal with it and they don’t have a radio person on staff at some locations and others they’re only there for certain days of the week. this is a dangerous situation.