2000 Chevrolet Malibu

Defect. This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.

Risk. If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy. GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.

Defect. SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Risk. DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy. SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Defect. CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.

Risk. FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.

Remedy. DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

Defect. CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.

Risk. WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.

Remedy. DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.

Defect. CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THE FUEL FILL FITTING IS NOT PROPERLY SECURED TO THE FUEL TANK. IN THAT CONDITION, FUEL LEAKAGE WOULD EXCEED THE PERMISSIBLE AMOUNT IN AN FMVSS TEST. FUEL LEAKS MAY OCCUR, PARTICULARLY AFTER REFUELING OR WHEN THE TANK IS MORE THAN HALF FULL.

Risk. IF AN IGNITION SOURCE WERE PRESENT, A FIRE COULD OCCUR.

Remedy. DEALERS WILL INSPECT THE FUEL TANK AND REPLACE IT IF NECESSARY.

Gm conducted a recall (NHTSA recall number 03v327) on model year (my) 2000-2001 alero, grand am and malibu vehicles to replace defective hazard switches that cause the turn signals and hazard lights to fail.the recall covered vehicles built from february 2000 through may 2001 (depending on model).odi opened this investigation based on 64 reports alleging turn signal failure on my 1999-2000 alero, grand am and malibu vehicles not covered under the recall and built prior to february 2000.in december 2004, GM will issue a special policy for my 1999-2000 alero, grand am and malibu vehicles not …

By letter dated august 27, 2003, GM notified the agency that it is conducting a voluntary safety recall (NHTSA recall no. 03v327) involving certain model year (my) 2000-2001 chevrolet malibu, oldsmobile alero, and pontiac grand am.GM's recall covers 670,740 vehicles manufactured beginning february 1, 2000 through may 1, 2001 (alero and grand am) and february 1, 2000 through may 31, 2001 (malibu).GM reports that turn signal failure is due to solder joint cracking in the hazard switch, and has identified rapid temperature transitions of the hazard switch and the soldering process as the cause …

Odi opened ea 02-028 to review complaints of consumers reporting that their fuel gauge was incorrectly displaying the amount of fuel in the gas tank.the fuel gauge receives an electrical signal from a fuel tank sending sensor circuit card.a float arm in the tank moves electrical contacts that rub against the card as the level of fuel rises and falls.disruption of the electrical signal (such as caused by corrosion of the circuit card) will cause incorrect readings to register on the fuel gauge.GM reported in their response to odi dated january 13, 2003 that the primary cause of erratic fuel …

Odi opened pe02-066 to evaluate the scope and consequence of engine power-loss due to fuel starvation induced by in-tank modular fuel pump strainer restriction.the subject pumps use an external ?sock? Strainer to filter fuel flowing to the pump inlet.this filter can sometimes become clogged, resulting in a reduced flow of fuel to the engine.GM has subsequently modified the strainers to reduce this restriction.analysis of the odi complaint database shows that despite these restrictions, the subject vehicles stall at a rate that is comparable to those of many peer vehicles.additionally, none of …

Odi opened the investigation based on 9 complaints of turn signals operating sporadically on the 2000-2001 chevrolet malibu.the turn signals quit working without warning and may occur while the vehicle is in motion or standing still.GM identified the hazard switch as the root cause of this problem.electrical current to the turn signal passes through the hazard switch.failure of the hazard switchresults in loss of turn signals and hazard lights.GM reports 318, 184 and 201 consumer complaints for the malibu, alero and grand am respectively.GM also reports the following models have the same …

There is no summary currently available

There is no summary currently available

Vehicle Wide Programming (VWP) is a new process to update software on GM Vehicles. It provides the ability via a single selection within Techline Connect to first identify which modules need updating and then proceed to updating affected modules (with some exceptions). The updating of modules is completed in parallel instead of the technician needing to …

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

ABS PUMP RUNNING WHEN NOT NEEDED. *NJ

INCORRECT OUTER BACKING PLATE. OUTER BACKING PLATE HAS SHORT CENTRE PROTUSION. OUTER BACKING PLATE SHOULD HAVE TALL CENTER PROTRUSION. *KB

REVISED BRAKE SYSTEM SPECIFICATIONS. *TT

THE ANTI-LOCK BRAKE SYSTEM INDICATOR IS ILLUMINATED AND DIAGNOSTIC TROUBLE CODE C1236 IS STORED. *TT

BRAKES CALIPER NOISE ON APPLY. *EH

TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE CONTACT SHIFTED THE VEHICLE INTO NEUTRAL, TURN THE SWITCH TO THE OFF POSITION THEN BACK TO THE ON POSITION AND THE VEHICLE STARTED. THE CONTACT ALSO STATED THAT WHILE DRIVING 45 OR 55 MPH, THE VEHICLE LOSS MOTIVE POWER AND STALLED WITHOUT WARNING. THE CONTACT STATED THAT SEVERAL ATTEMPTS WERE NEEDED TO RESTART THE VEHICLE. ADDITIONALLY, THE CONTACT STATED THAT THE VEHICLE WOULD LOSS POWER BEFORE SHE COULD SHIFT OUT OF PARK INTO REVERSE. THE CONTACT STATED THAT SHE HAD RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM) AND HAD THE VEHICLE TAKEN TO WEST CHEVROLET, INC., (3450 AIRPORT HWY, ALCOA, TN 37701) WHERE THE VEHICLE WAS REPAIRED UNDER RECALL. THE CONTACT STATED THAT THE IGNITION SWITCH WAS NOT REPAIRED UNDER THE RECALL CAMPAIGN. THE VEHICLE WAS NOT TAKEN BACK TO THE DEALER. THE CONTACT CALLED THE SAME DEALER AND INFORMED THEM OF THE FAILURE AND WAS ADVISED TO SCHEDULE AN APPOINTMENT. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 104,000.

TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE CONTACT STATED THAT THE TURN SIGNALS WOULD MALFUNCTION OR FAIL INTERMITTENTLY. THE CONTACT STATED THAT AFTER FIDDLING WITH THE HAZARD LIGHT SWITCH, THE INDICATOR WORKED INTERMITTENTLY. STEVENS CREEK CHEVROLET (3640 STEVENS CREEK BLVD, SAN JOSE, CA 95117; (408) 490-0013) WAS CONTACTED AND INFORMED THE CONTACT THAT THERE WERE NO RECALLS ON THE VIN. THE FAILURE WAS RELATED TO NHTSA CAMPAIGN NUMBER: 03V327000 (EXTERIOR LIGHTING). THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 84,900.

I'VE REPLACED BATTERY, HEAD GASKETS, OVERFLOW TANK, AIR SYSTEM CONNECTORS, WATER PUMP, PCV VALVE, EVAP CANISTER, SPARK PLUGS, SPARK PLUG WIRES, RADIATOR, CAMSHAFT SENSOR, COOLANT TEMP SENSOR, BUT MY CAR IS STILL LEAKING COOLANT FROM UNDERNEATH LOWER INTAKE MANIFOLD AND ISN'T TRYING TO START. I'VE SPENT OVER $2000 AND STILL HAVEN'T SEEN RESULTS OR GOT IT TO FULLY FUNCTION. LAST TIME I DROVE IT WAS ON REGULAR GEORGIA ROADS GOING TO AND COMING HOME FROM WORK WHEN IT OVER HEATED TWICE GOING BOTH WAYS. *TR

I WANTED TO LET YOU KNOW ABOUT AN EXPERIENCE AT DISCOUNT TIRE 580 W TELEGRAPH WASHINGTON UTAH. AND YOU CAN FORWARD THIS TO ANY REGULATING AGENCY.FROM MY KNOWLEDGE, WHEN TWO TIRES ARE PURCHASED NEW, IT IS REQUIRED TO MOUNT THEM ON THE FRONT OF THE VEHICLE IF IT IS FRONT WHEEL DRIVE. AND MOVE THE LOWER TREAD TIRES TO THE BACK.WHILE AT THIS LOCATION, THE PERSON RUNNING THE SHOP STATED THEY ARE NOT ALLOWED TO TOUCH TIRES OR ROTATE THEM IF THEY HAVE LOW TREAD.AND THEY MOUNTED THE TWO NEW ONES ON OPPOSITE CORNERS (FRONT DRIVER AND REAR PASSENGER). AND TRIED TO SELL 2 ADDITIONAL TIRES.THIS IS AGAINST THE LAW. I WANT THIS BUSINESS REVIEWED FOR THEIR LICENSE. *TR

TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE CONTACT SMELLED FUEL WHEN THE VEHICLE WAS PARKED IN THE GARAGE. THERE WAS NO WARNING INDICATOR ILLUMINATED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 137,000.

GAS FUEL TURNED BLACK AND WAS SPILLING OUT WHILE I WAS DRIVING THEN TURNED OFF ON ITS OWN IN THE INTERSECTION OF PALM ST N MAIN STREET SANTA PAULA CA.

TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. WHILE DRIVING AND ATTEMPTING TO SWITCH LANES, THE TURN SIGNALS AND HAZARD LIGHTS FAILED TO FUNCTION. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 03V327000 (EXTERIOR LIGHTING); THEREFORE, THEY DID NOT ASSIST. THE APPROXIMATE FAILURE MILEAGE WAS 167,000.

"TAKATA RECALL" I CURRENTLY OWN THIS VEHICLE AND I'M NOT ABLE TO USE THE BLINKERS OR EMERGENCY LIGHTS WHEN YOU TURN THEM ON ALL YOU HEAR IS A LOUD ALARM SOUNDING NOSIE. THEY DO NOT COME ON WHEN THIS HAPPENS. I KNOW THEY WORK SOME TIMES BUT IT'S VERY FEW AND IN BETWEEN . I SEEN THERE HAS BEEN RECALLS IN THE PAST FOR THIS ON THIS CAR BUT THE ELDERLY LADY WASN'T AWARE OF THEM . IS THERE ANYTHING I CAN DO UNDER THE RECALL TO GET THIS FIXED. I HAD A MECHANIC LOOK AT IT AND THERE NOT SURE HOW TO FIX IT.

LEAKING FUEL UNDER CAR BETWEEN DRIVER SIDE DOORS. JUST NOT SURE IF PART OF FUEL SYSTEM RECALL THAT HAS BEEN ON OTHER MALIBU

MY CAR SHUTS OFF WHILE I'M DRIVING IT, WHEN I TRY TO TURN IT ON IT WON'T TURN ON. I COULD SMELL GAS BUT IT WON'T TURN ON. IT'S A HAZARD WHEN I'M ON THE HIGHWAY AND IT JUST CUT OFF ON ME AND I'M STUCK IN THE MIDDLE LANE WITH INCOMING TRAFFIC. I TOOK IT TO A MECHANIC AND COULD NOT FIND ANY ISSUES WITH ANY OTHER PARTS OF THE VEHICLE MY FUEL PUMP IS IN GREAT CONDITION MY TUNE UPS ARE UP TO DATE I DON'T KNOW IF IT IS THE ANTI-THEFT AFFILIATED WITH MY KEY IGNITION PLEASE ADVISE.

EMAIL FROM SENATOR NELSON ON BEHALF OF CONSTITUENT RE: REIMBURSEMENT FOR REPAIRS ON 2000 CHEVY MALIBU DUE TO GENERAL MOTORS RECALL 14350 UNINTENDED IGNITION KEY ROTATION. *LD THE CONSUMER STATED THE DEALER RELAYED INVALID INFORMATION PERTAINING TO THE RECALL REPAIR. THE DEALER INFORMED THE CONSUMER THAT THE VEHICLE'S KEY NEEDED TO BE REPLACED AND THAT IT WAS NOT THE IGNITION THAT NEEDED TO BE REPAIRED. *JS

HAS ISSUES THAT ARE RECALLED ON OTHER 2000 MALIBU'S. BLINKERS STOPPED WORKING ON & OFF ONE DAY. THEN STOPPED TOTALLY NEXT DAY, CHANGED FUSE NOTHING HELPED. DOESN'T EVEN SHOW ON INSTRUMENT PANEL. CAR REFUSES TO START AT TIMES, TAKES ANY WHERE FROM 3-5 TRIES TO START. ALSO HAD RECALL DONE ON IGNITION, DIDN'T HELP, I REPLACED WHOLE IGNITION SWITCH AFTER THE DEALER 'FIXED' IT. BATTERY KEPTED ON DRAINING BEFORE THAT.

TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE FAILED TO START WITHOUT SEVERAL ATTEMPTS TO TURN THE IGNITION KEY. THE VEHICLE WOULD ALSO STALL AT VARIOUS SPEEDS WITHOUT WARNING. THE CONTACT TOOK THE VEHICLE TO THE GANLEY CHEVROLET DEALER WHERE THE IGNITION SWITCH WAS REPLACED IN SEPTEMBER OF 2016; HOWEVER, THE FAILURE RECURRED. THE DEALER STATED THAT THE IGNITION SWITCH WAS REPLACED AN ADDITIONAL FOUR TIMES IN THE PAST SIX YEARS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OPENED CASE NUMBER: 8/3107401633. THE MANUFACTURER ADVISED THE CONTACT TO RETURN THE VEHICLE TO THE DEALER FOR FURTHER DIAGNOSTIC TESTING. THE APPROXIMATE FAILURE MILEAGE WAS 81,000.

TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE CONTACT STATED THAT THE LEFT AND RIGHT TURN SIGNALS FAILED TO ACTIVATE. THE CONTACT TOOK THE VEHICLE TO THE SOUR LAKE CHEVROLET DEALER WHERE IT WAS DIAGNOSED THAT THE HAZARD WARNING SWITCH FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OPENED CASE NUMBER: 8/2983536744. THE MANUFACTURER ALSO INFORMED THE CONTACT THAT THE FAILURE WAS RELATED TO NHTSA CAMPAIGN NUMBER: 03V327000 (EXTERIOR LIGHTING); HOWEVER, THE VIN WAS NOT INCLUDED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

2000 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO THEFT SYSTEM LIGHT MALFUNCTION CAUSES VEHICLE NOT TO START, HAS HAD IGNITION CYLINDER/PASSLOCK SENSOR REPLACED SEVERAL TIMES AND PROBLEM STILL EXISTS. *SMD THE CONSUMER STATED THE VEHICLE TAKES 10 TO 25 MINUTES BEFORE THE THEFT SYSTEM LIGHT TO GO OFF. UPDATED 03/31/2017*JS

IGNITION WILL NOT GO TO OFF POSITION, STICKS IN ACC CAUSING THE BATTERY TO RUN DOWN.

IGNITION WILL NOT TURN OF AND SOMETIME STEERING WILL LOCK HAVE A HARD TIME GETTING THE KEY TO TURN I HAVE TALK TO SO MANY PEOPLE WITH THE SAME PROBLEM CHEVROLET SHOULD BE ASHAME AND DO A RECALL TO FIX THESE PROBLEMS.

TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. WHILE DRIVING 65 MPH, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART IT AFTER SOME TIME. MULTIPLE WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. IN ADDITION, THE CONTACT NOTICED COOLANT LEAKING AND HAD TO CONTINUOUSLY REFILL THE VEHICLE WITH COOLANT. AFTER TURNING OFF THE VEHICLE, THE KEY FAILED TO EJECT AND REMAINED IN THE ACCESSORY POSITION. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 157,323. UPDATED 05/16/17*LJ UPDATED 7/9/18*JB *TR

TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. AFTER PARKING THE VEHICLE, IT FAILED TO TURN OFF. THE CONTACT FORCED THE GEAR SHIFTER INTO PARK TO ALLOW THE IGNITION TO TURN OFF. THE CONTACT HAD TO OPERATE THE IGNITION WITH A SCREWDRIVER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 147,000.

TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. WHILE DRIVING OVER A BUMP IN THE ROAD, THE KEY WOULD RELEASE FROM THE IGNITION SWITCH. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

2000 CHEVROLET IMPALA. CONSUMER WRITES IN REGARDS TO VEHICLE FIRE AND ENGINE OIL MAY DEPOSIT ON THE EXHAUST MANIFOLD RECALL NOTICE. *SMD THE CONSUMER STATED THE VEHICLE CAUGHT OF FIRE. *JB

TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. WHILE DRIVING AT AN UNKNOWN SPEED, THE IGNITION KEY WOULD DISENGAGE FROM THE VEHICLE INTERMITTENTLY WITHOUT WARNING. THE CONTACT MENTIONED THAT THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM); HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE AND VIN WERE NOT AVAILABLE.

AS DRIVING ALONG THE HIGHWAY THE CAR COMPLETELY SHUT OFF AND WOULD NOT START UP AGAIN AND HAS NOT STARTED UP SINCE. THE CAR WAS IN MOTION, I WAS ON THE HIGHWAY, TRAVELING ON I-10 HIGHWAY.

CHEVY ISSUED A RECALL (14350) WHICH STATES THEY WILL REPAIR MY IGNITION KEYS. THEY ALSO HAVE A RECALL FOR OTHER CHEVY VEHICLES THAT NOT ONLY REPAIR THE KEYS, BUT REPLACE THE IGNITION SWITCH AND KEY CYLINDER. MY CYLINDER AND SWITCH ARE DAMAGED, SO FAR I HAVE GONE THROUGH AN ALTERNATOR AND BATTERY TRYING TO ISOLATE TH PROBLEM WHICH SHOWS ON THE SCANNER AS BEING THE CYLINDER AND THE SWITCH. CHEVY WILL NOT REPLACE THESE ITEMS, EVEN THO THEY ARE CAUSED BY THE UNINTENDED MOTION ISSUE.

TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. ON OCCASION, THE VEHICLE FAILED TO START. THE CONTACT HAD TO WAIT APPROXIMATELY TEN MINUTES FOR THE VEHICLE TO START NORMALLY. THE FAILURE OCCURRED INTERMITTENTLY FOR TWO YEARS. THE VEHICLE WAS NOT DIAGNOSED BY AN INDEPENDENT MECHANIC OR DEALER. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 125,000.

TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE CONTACT STATED THAT THERE WAS A FUEL ODOR AND DISCOVERED THAT FUEL WAS LEAKING FROM UNDER THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO INSPECTED THE VEHICLE AND INDICATED THAT THERE HAD BEEN FUEL LEAKING ON THE FUEL LINES. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 99V302000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 152,000.

TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. WHILE DRIVING 30 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO BE RESTARTED. THE FAILURE RECURRED. WHEN THE CONTACT ATTEMPTED TO REMOVE THE KEY FROM THE IGNITION, IT WAS STUCK AND COULD NOT BE REMOVED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT COULD NOT BE DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 196,600.

TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE CONTACT STATED THAT THE ANTI-THEFT SYSTEM ACTIVATED CAUSING THE VEHICLE TO BE UNABLE TO START. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000.

TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT ALSO STATED THAT THE VEHICLE WOULD SOMETIMES NOT START AFTER BEING UTILIZED AND TURNED OFF. THE CONTACT STATED THAT THE VEHICLE WOULD EVENTUALLY TURN ON AFTER APPROXIMATELY TEN MINUTES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE THEFT SYSTEM FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 190,000.

SUBFRAME RUSTING AWAY ON THE DRIVER SIDE FRONT. CAN'T REPLACE DUE TO THEY DISCONTINUED MAKING THE PART. EVEN IF THE PART WAS FOUND IT WOULD COAST ABOUT $900.00 THEN THE TIRODS WOULD NEED REPLACING. IN ALL AFTER NEW TIRES AND ALL IT WOULD COAST $2000.00 TO FIX.

RACK AND PINION MOUNT BRACKET RUSTED OUT

TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE CONTACT STATED THAT THERE WAS EXCESSIVE RUST BELOW THE FUEL TANK. IN ADDITION, THERE WERE HOLES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 94,625.

2000 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH RECALL NOTICE ISSUES. *SMD THE CONSUMER STATED THE DEALER MADE AN ADJUSTMENT TO IGNITION. HOWEVER, IT WOULD NOT TURN IN THE IGNITION. THE SERVICE DEPARTMENT GRIND THE KEY AGAIN. HOWEVER, IT ONLY WORKED ONE WAY. THE NEW KEY MUST BE FORCED AND IT ONLY FIT THE DOORS AND TRUNK ONE WAY. *JB

TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. WHILE DRIVING AT APPROXIMATELY 30 MPH AND MAKING A TURN, THE TURN SIGNALS LAMPS FAILED TO RESPOND WHEN ACTIVATED. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE CAUSE OF THE FAILURE COULD NOT BE DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 03V327000 (EXTERIOR LIGHTING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS INVALID. THE APPROXIMATE FAILURE MILEAGE WAS 92,000.

TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE CONTACT STATED THAT THE HAZARD ONE SWITCH FAILED AND CAUSED THE TURN SIGNALS TO STOP WORKING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 188,000.

WHEN MAKING A TURN MY STEERING WHEEL LOCKED UP AND COULD NOT CONTROL MY CAR I HAD TOWED TO A MECHANIC THAT TOLD ME THAT THE SUBFRAME TO RACK BRACKET WAS RUSTED OUT AND THAT THE SUBFRAME AND THE RACK NEEDED TO BE REPLACED AND THE REPAIR COST WILL START AT ABOUT $2000.

FRONT TO REAR BRAKE LINES ARE HEAVILY CORRODED AND ERODED AND STARTED LEAKING. THE RESERVOIR DESIGN ALLOWED ALL THE BRAKE FLUID TO DRAIN OUT LEAVING NONE AVAILABLE TO SAFELY BRAKE THE CAR WITH AIR BEING INTRODUCED INTO THE WHOLE SYSTEM. ALL THAT WAS LEFT WAS THE PARKING BRAKE WHICH IS A PRESS ON AND PRESS OFF TO RELEASE STYLE. FORTUNATELY THE CAR WAS CLOSE TO HOME AND THERE WAS NO DAMAGE TO PERSONS OR PROPERTY.

TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE CONTACT STATED THAT THE BRAKE PEDAL WAS DEPRESSED, BUT THE VEHICLE ACCELERATED ON ITS OWN. AS A RESULT, THE CONTACT CRASHED INTO THE PRECEDING VEHICLE. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO AN UNKNOWN LOCATION FOR DIAGNOSTIC TESTING. THE MECHANIC REPLACED THE WATER PUMP AND THE BODY CONTROL MODULE, BUT THE FAILURE RECURRED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 53,000.

THERE ARE THREE SAFETY PROBLEMS THAT HAVE OCCURRED. THE FIRST IS THAT THE TURN SIGNALS SOMETIMES WORK AND SOMETIMES DON'T. THE SECOND IS THAT THE ENGINE WILL AT TIME ACCELERATE ON IT'S OWN WHILE DRIVING AND WHILE IDLE. THE THIRD IS THAT THE ENGINE SOMETIMES COMPLETELY SHUTS OFF WHILE DRIVING WHEN IT RAINS. A CAR REPAIR SHOP HAS IDENTIFIED PROBLEMS WITH THE THROTTLE POSITION SENSOR AND THE IDLE AIR CONTROL MOTOR. SEARCHING ON THE INTERNET REVEALS THAT THIS PARTICULAR CAR HAS PROBLEMS WITH THE EMERGENCY LIGHT CONTROL THAT CAUSES TURN SIGNAL PROBLEMS. I PERFORMED A RECALL SEARCH AND THE ONLY RECALL I FOUND WAS FOR AN IGNITION SWITCH MODIFICATION WHICH DOESN'T SEEM TO RELATE TO MY PROBLEMS.

TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. WHILE DRIVING 45 MPH, THE VEHICLE STALLED. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 109,000.

TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE CONTACT STATED THAT THE ANTI THEFT SYSTEM FAILED. THE ANTI THEFT WARNING LIGHT ILLUMINATED WHEN THE IGNITION SWITCH WAS TURNED TO THE ON POSITION CAUSING THE ENGINE NOT TO START. THE CONTACT HAD TO WAIT SEVERAL MINUTES FOR THE ANTI THEFT LIGHT TO DISENGAGE TO BE ABLE TO START THE ENGINE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO INFORMED THAT THE VEHICLE COMPUTER SYSTEM NEEDED TO BE REPROGRAMMED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 138,000. MA 10/14

TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE CONTACT STATED THAT THE KEY FAILED TO RELEASE FROM THE IGNITION SWITCH. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM), BUT THE RECALL REPAIR WAS UNABLE TO BE PERFORMED. THE CONTACT ALSO STATED THAT THE KEY WAS UNABLE TO BE REMOVED WHEN THE GEAR SHIFTER WAS PLACED IN PARK ON NUMEROUS OCCASIONS. AFTER SEVERAL ATTEMPTS, THE KEY WAS ABLE TO BE RELEASE FROM THE IGNITION SWITCH. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE IGNITION SWITCH; HOWEVER, THE FAILURE RECURRED ONE MONTH LATER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

I BOUGH THE 2000 CHEVY MALIBU USED IN AUGUST 2014 SINCE THEN I HAVE BEEN SEEING THE SAME THING I HAD HAPPENING WITH THE 2003 SATURN VUE I BOUGHT IN 2012 PRE OWNED , THE KEY IN THE IGNITION COMES OUT AND DOES NOT TURN OFF THE CAR . THE KEY COMES OUT WHILE THE SWITCH AND CAR IS STILL RUNNING THE KEY ALSO DOES NOT TURN OVER AS IT STICKS INSIDE OF THE IGNITION SWITCH AND I HAVE A HARD TIME GETTING CAR STARTED ALSO . THIS IS VERY DANGEROUS AND NEEDS TO BE REPAIRED I ALREADY HAD THE SATURN VUE REPAIRED SINCE IT WAS RECALLED THIS CAR NEEDS TO BE REPAIRED AS WELL. PLEASE ISSUE A NATIONAL RECALL ON THE 2000 CHEVY MALIBU CARS TO GET FIXED ASAP. I WOULD LIKE TO GET THE CAR FIXED ASAP THIS IS NOT SAFE AND ALSO IT IS GETTING HARDER TO TURN THE CAR ON AND THE KEY IS FALLING OUT A TIMES ALSO WHILE THE CAR IS BEING DRIVEN SINCE THE SWITCH IS STICKING . I WOULD LIKE TO ADD THAT WHEN I HAD TWO PREVIOUS SATURN'S A TURQUOISE COUPE AND SL2, IT HAPPENED TWICE AND THIS IS THE FIRST TIME I ACCIDENTALLY TOOK ANOTHER PERSONS CAR IN THE PARKING LOT OF A MOVIE THEATER SINCE THE KEYS TO THE SATURN'S OPEN THE DOORS OF CARS LIKE THE SAME CAR I REALIZED IT WAS NOT MY CAR AND IMMEDIATE TOOK IT BACK AND GOT MINE THANK GOD THE MOVIE WAS STILL GOING OR I COULD HAVE BEEN ACCUSED OF STEALING THE CAR THIS IS ANOTHER MANUFACTURE DEFECT AND DANGEROUS TO PEOPLE SHOULD THEY EVER FIGURE OUT THAT THE KEYS ALL WORK ON THE SAME MAKE AND MODELS . I ALSO LOCKED MY KEYS IN MY CAR AND ASKED ON MAN TO OPEN MY DOOR WITH HIS KEY

TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. WHILE DRIVING AT APPROXIMATELY 30 MPH, THE VEHICLE STALLED AND THE ANTI THEFT DEVICE LIGHT ILLUMINATED. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP AND THE FUEL REGULATOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE CONTACT STATED THAT THE ANTI-THEFT SYSTEM ILLUMINATED. WHEN THE KEY WAS IN THE IGNITION, IT WOULD NOT REGISTER THE VEHICLE AS BEING IN THE ON POSITION, EVEN IF THE ENGINE WAS RUNNING. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS REPAIRED UNDER A RECALL BY A PIECE OF PLASTIC BEING PLACED IN THE KEY TO MAKE THE HOLE SMALLER; HOWEVER, THIS DID NOT REPAIR THE VEHICLE. THE MANUFACTURE WAS NOT NOTIFIED OF THE FAILURE. THE NHTSA CAMPAIGN NUMBER WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 170,000.

HELLO.. MY NAME IS [XXX] .. I AM WRITING YOU ABOUT MY SISTERS CAR.. IT IS A 2000 CHEVY MALIBU .... THE CAR KEEPS HAVING PROBLEMS STARTING.... IT RUNS GOOD THEN WITHOUT WARNING SHE WILL BE SOMEWHERE AND CUT THE CAR OFF AND IT WON'T START BACK... IT TURNS OVER BUT WON'T START.. AFTER AWHILE IT WILL START.... THIS HAS HAPPEN SEVERAL TIMES... WE HAVE SENT IT TO THE SHOP AND SPENT SEVERAL HUNDRED DOLLARS ON IT AND IT IS STILL HAPPENING.. I LOOKED ONLINE FOR ANSWERS AND FOUND THAT THIS IS A VERY COMMON RECURRING PROBLEM ON THESE CARS... MY SISTER IS DISABLED AND IT IS VERY UNSAFE FOR THIS TO BE HAPPENING WITH HER CAR.... EVERYONE ON THE FORUMS SAY IT SHOULD BE A RECALL AND FIXED BY CHEV. YOU ALREADY HAVE THE VIN NUMBER FOR THE CAR LISTED ABOVE... MY SISTERS NAME IS [XXX] ..... HOPEFULLY SOMEONE HERE CAN HELP HER GET THIS ISSUE FIXED.... PLEASE LET US KNOW... THANK YOU INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

LETTER FROM CONGRESSMAN HANNA ON BEHALF OF CONSTITUENT RE 2000 CHEVROLET CLASSIC SAFETY RECALL NOTICE (ATTN: TARA GITTER). *SMD

TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE CONTACT STATED THAT THE KEY WAS GETTING STUCK IN THE ACC AND ON POSITIONS. THE CONTACT INDICATED THAT THE KEY COULD ALSO BE REMOVED AND THE ENGINE REMAINED RUNNING. THE CONTACT ALSO APPLIED THE BRAKE PEDAL AND IT WENT TO THE FLOORBOARD CAUSING THE CONTACT TO HAVE TO APPLY FORCE NUMEROUS TIMES TO GET THE VEHICLE TO COME TO A COMPLETE STOP. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM) BUT WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS UNABLE TO BE DRIVEN. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 180,000.

TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. WHILE THE VEHICLE WAS PARKED, A STRONG ODOR OF FUEL EMITTED OUTSIDE THE VEHICLE. THERE WAS A RECALL REGARDING NHTSA CAMPAIGN NUMBER: 99V302000 (FUEL SYSTEM, GASOLINE); HOWEVER, THE VIN WAS NOT INCLUDED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

2000 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH PROBLEMS. *SMD THE CONSUMER STATED THE IGNITION SWITCH WAS REPLACED TWICE. IT WAS REPLACED ON NOVEMBER 30, 1999 AND MARCH 19, 2014. THE CONSUMER STATED WHILE DRIVING, THE VEHICLE THE STEERING AND BRAKES FAILED. ALSO, THE OIL PRESSURE SWITCH AND THROTTLE BODY WERE REPLACED. *JB