1993 Chevrolet K3500

Defect. CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.

Risk. THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

Remedy. HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).

1993 CHEVROLET K3500. RUST ISSUES. THE VEHICLE IS SUCH A RUST BUCKET THAT THE METAL THAT THE PLASTIC REAR BLINKER SCREWS INTO RUSTED AWAY AND THE BLINKER FELL OUT. I DON'T KNOW HOW LONG I DROVE BEFORE I NOTICED IT HANGING BEHIND ME. FURTHERMORE, THE FRAME HAS THROUGH RUST HOES AND THE BODY HAS TREMENDOUS AMOUNTS OF RUST AS WELL. *TR

MALFUCTIONING WINDSHIELD WIPERS:993 CHEVROLET K3500  WIPER PROBLEM. WAS INFORMED BY A RELATIVE ABOUT A RECALL EFFECTING THEIR TWO TRUCKS CONCERNING A WIPER FAILURE. THIS FAILURE IS DUE TO DETERIORATION OF A SOLDERED CONNECTION ON THE CONTROLLER CIRCUIT BOARD. THE FAILURE MODE IS THAT THE WIPERS JUST QUIT WORKING INTERMITTENTLY. THE RECALL (J#97CZT02054 I BELIEVE) WAS FIRST INITIATED TO COVER 98 AND UP. IT WAS LATER EXTENDED TO COVER THE 94-97 MODELS. THE 98 RECALL NUMBER IS 98043 I BELIEVE. I ASSUME THAT I HAVE THE SAME PART IN MY 93,: 12463090 MODULE 16.067, AND SEALANT 12345739, AS MY WIPERS FIRST FAILED JUST THIS LAST SUMMER AND THEY NOW WORK INTERMITTENTLY. UNFORTUNATELY THIS IS ONLY A PROBLEM WHEN ITS RAINING/SNOWING!! I HAUL A 10,000 LB HORSETRAILER WITH HORSES IN IT SO THIS IS AN EXTREMELY HAZARDOUS SITUATION. THE FIRST TIME IT FAILED I WAS ABLE TO PULL OFF THE ROAD. I LIFTED THE HOOD AND PECKED ON THE CIRCUIT BOARD HOUSING AND THE WIPERS STARTING UP AGAIN. THE PROBLEM CONTINUES. IT WOULD SEEM TO ME THAT IF GM IS RECALLING OVER 1.5 MILLION VEHICLES, THAT THEY EXTEND IT FURTHER TO COVER ALL MODELS WITH THE KNOWN DEFECTIVE PART. THAT YOU FOR THE OPPORTUNITY TO MAKE MY COMPLAINT, AND I HOPE THERE IS ENOUGH OF A BACKLASH TO FORCE GM TO EXTEND THE RECALL. [XXX] 1993 CHEVROLET, K3500-VIN: [XXX] AUTHORIZED DEALER WHERE TRUCK WAS PURCHASED NEW: BOB HOOK CHEVROLET, 4144 BARDSTOWN RD., LOUISVILLE, KY (502) 499-8900. *AK INFORMATION REDACTED PURSUANT TO THE FREEDOM OF IN

CONSUMER CALLED COMPLAINING ABOUT ENGINE PROBLEMS. ENGINE INTERMITTENTLY STALLS WHILE DRIVING. MANUFACTURER WAS CONTACTED, BUT HAD NO ANSWERS TO THE CONSUMER. DEALER STATED THAT HE COULD NOT FIND ANYTHING WRONG WITH THE VEHICLE UNLESS THEY TOOK THE ENGINE APART.*AK

WINDSHIELD WIPER MOTOR FAILS AT DIFFERENT TIMES. I HAVE CHECKED AND FOUND THAT LATER TRUCKS HAVE HAD A RECALL ON THE SAME WINDSHIELD WIPER MOTOR. I HAVE DRIVEN OFF THE ROAD ON AT LEAST ONE OCCASION WHEN THE WIPER FAILED WHILE DRIVING. YOU CAN GET THE WIPER MOTOR TO START AGAIN BY REACHING UNDER THE HOOD AND JIGGLE THE WIRING HARNESS THAT CONNECTS TO THE WINDSHIELD MOTOR. THAT SOMETIMES WILL START THE WINDSHIELD WIPERS WORKING BUT WHEN IT DOES IT TYPICALLY WILL ONLY OPERATE IN THE HIGH SPEED MODE.*AK