2023 Chevrolet Bolt EV

Defect. General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. This recall includes certain vehicles previously repaired incorrectly under NHTSA recall number 22V-930. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.

Risk. A fire increases the risk of injury.

Remedy. Dealers will inspect both front seat belt pretensioners and, if necessary, install metal foil at the carpet near the pretensioner exhaust. Certain vehicles will also need a pretensioner cover installed. Repairs will be performed free of charge. Owner notification letters were mailed January 24, 2024. These vehicles were previously recalled for this same issue under recall number 22V-930 and will need to have the new remedy performed. Owners may contact GM EV Concierge at 1-833-EVCHEVY (1-833-382-4389) (TTY 711 / 1-800-833-2438) or Customer Service at 1-800-222-1020. GM's number for this recall is N232421970.

Defect. General Motors, LLC (GM) is recalling certain 2022-2023 Chevrolet Bolt EV vehicles. The instrument panel may be missing the perforation on the underside of the panel cover that allows the passenger-side air bag to deploy properly.

Risk. An air bag that does not deploy properly in a crash increases the risk of injury.

Remedy. Dealers will replace the instrument panel, free of charge. Owner notification letters were mailed December 21, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N232414710.

Defect. General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.

Risk. A vehicle fire can increase the risk of injury.

Remedy. Dealers will install metal foil at the carpet near the pretensioner exhaust, and install a pretensioner cover as necessary, free of charge. Owner notification letters were mailed between January 23, 2023 and April 25, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N222383790.

Both front wheel drive shaft anti-click washers on my 2023 Bolt EV fractured at 18,269 miles. The failure caused a repeatable click/clunk from the front of the vehicle on torque application — accelerating from a full stop, from a slow roll under 5 mph, or accelerating out of a coast at about 20 mph. A Chevrolet dealer confirmed both anti-click washers were cracked (Repair Order 652900). The repair required removing both front half-shafts, replacing the washers (GM P/N 42754282) and drive shaft nuts (GM P/N 13208079), and reinstalling the axles. The noise was eliminated. This is a safety issue because GM has documented in writing that this exact failure can damage the ABS wheel speed sensor, which sits directly in-line with the washer on the outboard joint of the half shaft. GM TSB 22-NA-089 (Bolt EV) and TSB 19-NA-103 (Volt) both state the fractured washer causes "possible collateral damage to the ABS wheel speed sensor," that ABS, Traction Control, and StabiliTrak lamps may illuminate intermittently, and that those systems "may be deactivated/shut off for that ignition cycle," setting DTCs P215B and C0035-C0051. Loss of anti-lock braking and stability control is a direct safety hazard. My core concern is scope. GM acknowledged this defect in 2019 (Volt, MY2016-2019) and 2022 (Bolt EV, MY2017-2019), but capped the bulletins at model years that exclude my vehicle. My 2023 Bolt EV suffered the identical failure of the identical part, fixed by GM's identical specified procedure

Known issue with " anti click washer on Bolt EV " and resulting damage to related components can cause loss of control acceleration, stopping and major damage and cost, no warning lights or TSB other than for previous gen but same design and same defect, inspected by dealer shows broken anti click washer and damage to other components https://gmauthority.com/blog/2022/07/heres-why-your-chevy-bolt-ev-may-have-a-clicking-sound/

The vehicle suffers from severe, unresolvable electrical failures causing recurring loss of propulsion, shifting lockouts ("No Driving Conditions" / stuck in Park), complete exterior lighting failures, and loss of communication with the Restraints Control Module (RCM) and airbag impact sensors. The primary failure involves short circuits, open circuits, poor terminal contact, and thermal damage with melted, charred wiring and exposed copper in the main harness[cite: 6]. On May 25, 2026, OnStar telematics issued a critical red alert for the Regenerative Braking System[cite: 7]. All damaged components and diagnostic reports are available for inspection upon request[cite: 6, 7]. Safety risks include sudden loss of propulsion at highway speeds, total headlight and tail light loss during night driving, and potential non-deployment or malfunction of airbag restraint systems during a collision. The issues have been repeatedly reproduced and confirmed by an authorized dealership through 7 repair attempts between Sept 2024 and Apr 2025. Diagnostic steps included opening GM TAC Case 9-13634782861, consulting GM engineers, and testing 33 ground points. On Oct 28, 2024, the dealer and an insurance adjuster officially confirmed the failures are covered under GM warranty and unrelated to any accident[cite: 8]. Symptoms first appeared on Sept 10, 2024 (at 5,144 miles) with a "Waiting initialization to shift" message, blown Fuse 58, and loss of power to the ECM. Warning signs prior to subseq

While driving a 2023 Chevrolet Bolt during a turn maneuver, one of the two bolts (nearest the driver) holding the lower control arm (to the vehicle on the front driver side) sheared completely. An inspection of the joint suggests a fatigue failure likely due to inadequate factory assembly clamping force (pretension). Because the joint lacked the required factory torque, the joint interface slipped under normal operational loads, shifting cyclic shear and bending forces directly onto the bolt threads and shank—loads the fastener was not designed to carry alone—resulting in a fatigue fracture. The sudden failure of a primary front suspension control arm fastener while the vehicle is in motion is a safety hazard. It causes steering instability and risks a loss of vehicle control. The problem was confirmed and repaired by an independent service center/mechanic who replaced the control arm sub-assembly. The sub-assembly has been retained and is available for inspection upon request. The vehicle and failed component have not yet been inspected by the manufacturer, police, or insurance representatives. There were no warning lamps, dashboard messages. We had noticed the tire was rubbing on the wheel well during certain maneuvers for months beforehand, but we thought the wheel well liner was sagging. In hindsight this was due to the control arm not being firmly held by the bolt. When the bolt sheared my wife reported hearing a loud pop, the vehicle was still drivable but unstable, as

Steering rack failure, does not return to center most of the time. Every once in a while it will. Loud clunking in steering, started right around 36k mile warranty expiration, but I didnt know what it was so did not report it right away.

Vehicle infotainment system on 2023 Chevrolet Bolt completely stopped functioning in May of May of 2026. Screen/radio/bluetooth and associated components had no functionality, including backup camera, safety warning features, etc. Dealership confirmed that the system needed replacement entirely and was non-functional. Vehicle was not inspected by any other parties but it was confirmed by the dealership that this is a "common issue" for Chevrolet vehicles, even newer models. There were no warnings prior to the issue - the system simply did not work one day and never functioned again.

The steering has become harder to turn and will not return to center after turning a corner. When driving the steering wheel will stay in the position you have turned it to. I feel like this is dangerous and a safety risk especially at highway speeds. I have taken it to my local Chevrolet dealership and they said the rack and pinion steering is bad and needs to be replaced. $2365 parts and labor and realignment. The vehicle had 50058 miles on it when I noticed it. It now has approx. 52,500 miles on it. There were no warning lamps or safety messages.

I bought my 2023 Bolt EV new on Dec 2024. Around Jan 2025 I start hearing clicking behind the steering wheel when I turn to make parking maneuvers. By April 2025 the clicking is loud and a common occurrence. The steering no longer returns to center and it is noticeably hard to turn the steering wheel. I brought it to the dealership and was repaired under factory warranty for being a faulty part. The issue, which was a leak causing the steering rack to bind, was fixed. See the attached Chevrolet dealership documentation for further details. I have not noticed any further issues after driving for month after repairs were done.

Without any warning or physical impact, the central infotainment screen completely blanked out and suffered an irreversible hardware failure. This screen acts as the mandatory display terminal for the vehicle's rear-visibility backup camera, as well as the audio generation module for the vehicle's driver alerts. Because of this component failure, the vehicle is in direct non-compliance with Federal Motor Vehicle Safety Standards (FMVSS): 1.FMVSS 111 (Rear Visibility): The vehicle completely fails to display a rear-view image when shifted into reverse, creating an immediate blind-spot hazard for pedestrians. 2. FMVSS 101 (Controls and Displays): All critical audible safety alerts, pedestrian alerts, and driver warning chimes have been entirely silenced. The manufacturer (General Motors) and the authorized franchise dealership (F.H. Dailey Chevrolet) have acknowledged the failure and have the part on backorder, but refuse to fully cover the safety restoration under warranty or provide a temporary loaner vehicle. This forces the primary driver, a [XXX] senior citizen, to choose between total isolation or operating a hazardous, federally non-compliant vehicle. This appears to be a systemic manufacturing or design defect inherently tied to the internal HMI module architecture on the late-model Chevrolet Bolt EV platform, rather than individual wear and tear. A formal investigation is requested to mandate a safety recall and enforce full manufacturer accountability. INFORMATION RED

The steering wheel does not return to center after turning while driving the car (unlike every other car). It has been reproduced by an independent service center. There are no error codes or warnings. This is a continuous problem that always happens and makes steering the vehicle more difficult.

Recurring electronic transmission shift control failure on a 2023 Chevrolet Bolt EV. The Electronic Transmission Shift Control Pushbutton Circuit Board (GM part designation K212) has failed twice within approximately 9,300 miles. First failure occurred at approximately 45,695 miles in July 2025. The dashboard displayed a malfunction indicator and a "Service Transmission" warning. Diagnostic trouble code U18D2 was set: Lost Communication with Transmission Range Selector Control Module on the Powertrain Sensor CAN Bus. The selling Chevrolet dealer replaced the K212 pushbutton circuit board and reprogrammed the HPCM2 module. Second failure occurred at approximately 54,969 miles in March 2026, only about 9,300 miles after the first repair. Same diagnostic code family, including the identical U18D2 code, plus U0076, U18C6, and U240E. The same dealer replaced the same K212 pushbutton circuit board a second time. The repair was processed under manufacturer warranty. Safety risk: when the failure occurs, communication with the transmission range selector is lost intermittently and without warning, leaving the vehicle unable to be reliably shifted into Drive, Reverse, or Park. This creates a clear hazard in traffic, parking lots, and on inclines. The failure mode is sudden and the warning lamps appear only after the malfunction has begun. The component is located beneath the center cup holder area. There is no visible waterproofing or moisture isolation around the circuit board, despi

I have a 2023 bolt ev. Right where the odometer it started to go black. I touched it and made it worse. Right now it is not getting bigger but I am worried it will get worse. There is about 75,000 miles, I can't tell miles without the odometer. What would cause this? How do I fix this? Would I be able to resale it like that? How much would it be to get it fixed? I need the car to last intil I can buy a Slate Automotive pickup. Please see attached picture. Thank you! Is there another way to read the miles? Thank you!

The steering sticks when making turns and does not return to center. This causes the steering to drift on the highway and reduces the ability to steer in a straight line. I have not reproduced or confirmed it with the dealer. No inspection and no warning lamps. This issue occurs for a large number of Chevrolet Bolt owners.

While driving at approximately 45 mph, the regenerative braking feature of the vehicle suddenly failed, and also generated a master caution light on the dashboard display. This is the second time this has happened while driving and resulted in a sudden, alarming change in vehicle dynamics. Regenerative braking is the normal operation regime of the vehicle, with the traditional mechanical-hydraulic brake pedal available for added braking, as demonstrated by the Chevrolet dealership during a test drive and confirmed with the vehicle manual. Furthermore, the vehicle will no longer shut itself off and could pose a fire risk when stored in a garage, parking deck, other vehicles, etc. These issues happened in November 2024. The car was returned to the dealer for warranty repair. Even after extensive repairs to the electrical system, the car has repeated the alarming failure mid-drive. This indicates that there is a serious problem with the electronic and poses a serious safety risk.

Steering, Rack and Pinion is failing after 44k miles, Steering gear is binding internally

Steering wheel does not return to center, requiring driver input to do so. Force needed to turn the steering wheel continued to increase throughout the past year, getting abnormally difficult and unlike any other vehicle. Had the steering rack replaced, which corrected the problem.

Steering wheel fails to return to center after turns — potential steering gear defect 2023 Chevrolet Bolt EV steering wheel fails to return to center after completing turns, particularly at low speeds. Steering requires manual input to re-center the vehicle after every turn. No warning lights or audible alerts. The issue is not attributable to alignment, tires, or tire pressure, as I have had new OEM-spec tires installed and an alignment performed without any improvement to the steering. I brought the vehicle to the dealership to address this safety concern. They stated unable to replicate the issue and sent me away without performing repair. The dealership charged me for an alignment but provided only post-alignment figures — no before measurements, making it impossible to determine whether any corrective action was actually taken or whether the alignment was a contributing factor. This is a safety concern as it requires constant driver correction after every turn, increasing risk of overcorrection, unintended lane departure, and delayed response in emergency situations. Condition is hazardous in low-speed environments such as parking lots, intersections, on/off ramps, and residential streets where frequent turns are made and rapid corrections may be necessary. Issue is not isolated to my vehicle or model year. Owners of 2017-2019, 2022, and 2023 Chevy Bolt EVs have reported identical symptoms across multiple owner forums, with hundreds of documented complaints. Community re

The Chevy Bolt steering wheel has a skip track and previous track button mounted to the left-rear side of the steering wheel. These buttons often become unresponsive for extended periods of time (up to 30 minutes) when a media device is connected. When pressed, they will display an error on the instrument panel screen that says “Action Unavailable While Indexing”. Although media controls are not explicitly safety related, the frustration caused by these unresponsive buttons can cause the driver to become distracted or look for unsafe methods of adjusting the media playback that the buttons are supposed to perform.

Steering is failing at only 43,800 miles like many others. It is failing to return to center which makes it dangerous to drive, it doesn't come out of a turn. It is clicking and fails to return to center.

Clicking/Clunking under driver's feet