2019 Chevrolet Bolt EV

Defect. General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. This recall includes certain vehicles previously repaired incorrectly under NHTSA recall number 22V-930. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.

Risk. A fire increases the risk of injury.

Remedy. Dealers will inspect both front seat belt pretensioners and, if necessary, install metal foil at the carpet near the pretensioner exhaust. Certain vehicles will also need a pretensioner cover installed. Repairs will be performed free of charge. Owner notification letters were mailed January 24, 2024. These vehicles were previously recalled for this same issue under recall number 22V-930 and will need to have the new remedy performed. Owners may contact GM EV Concierge at 1-833-EVCHEVY (1-833-382-4389) (TTY 711 / 1-800-833-2438) or Customer Service at 1-800-222-1020. GM's number for this recall is N232421970.

Defect. General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.

Risk. A vehicle fire can increase the risk of injury.

Remedy. Dealers will install metal foil at the carpet near the pretensioner exhaust, and install a pretensioner cover as necessary, free of charge. Owner notification letters were mailed between January 23, 2023 and April 25, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N222383790.

Defect. General Motors LLC (GM) is recalling certain 2017-2019 Chevrolet Bolt EV vehicles previously recalled under NHTSA recall number 20V-701. The high voltage battery could catch fire when charged to full or nearly full capacity.

Risk. A battery fire increases the risk of injury.

Remedy. Owners are advised to take the following interim steps: Activate either the Hill Top Reserve (2017 and 2018 models) or Target Charge Level (2019 models) feature in their vehicle to limit the charge level to 90%, charge their vehicle more frequently, avoid depleting the battery to 70 miles range remaining, park outside after charging, and do not charge the vehicle indoors overnight. Defective battery modules will be replaced by GM, free of charge. Interim notification letters notifying owners of the safety risk were mailed on August 13, 2021. Owner notification letters were mailed on August 13, 2021. Owners may contact the Bolt EV Concierge Team at 1-833-382-4389. GM's number for this recall is N212343880.

Defect. General Motors LLC (GM) is recalling all 2017-2018 and certain 2019 Chevrolet Bolt EV vehicles. The high voltage battery could catch fire when charged to full or nearly full capacity.

Risk. A battery fire increases the risk of injury.

Remedy. This recall has been superseded by recall number 21V-560. Vehicles previously repaired under 20V-701 will still need to have the new remedy under recall 21V-560. GM will notify owners, and as an interim repair, beginning on November 17, 2020, dealers will reprogram the hybrid propulsion control module 2 (HPCM2) to limit the full charge to 90%, free of charge. Owners are advised to activate either the Hill Top Reserve (2017 and 2018 models) or Target Charge Level (2019 models) feature in their vehicle to limit the charge level to 90%, or park outside, until the software update is completed. Owners were notified of the interim repair beginning November 17, 2020. The second notice was mailed on May 11, 2021. Owners may contact the Bolt EV Concierge Team at 1-833-382-4389. GM's number for this recall is N202311730.

Defect. General Motors LLC (GM) is recalling certain 2019-2020 Chevrolet Bolt EV vehicles. The door-handle cable inside the rear doors may be too long, allowing contact with the window when it is opened, possibly damaging the cable. A damaged cable may cause the rear door to open unintentionally when the rear window is opened. Additionally, it may cause the rear inside door handle to not work.

Risk. If the rear door opens while driving, or the door handle fails to open the rear door, there is an increased risk of injury to the rear passengers.

Remedy. GM will notify owners, and dealers will replace the rear inside door-handle cables, free of charge. The recall began April 17, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is A202298320.

Defect. General Motors LLC (GM) is recalling certain 2018-2019 Chevrolet Equinox, Impala, Cruze, Volt and Bolt EV vehicles, GMC Terrain vehicles, Buick Lacrosse and Regal vehicles, Cadillac XTS and XTS Professional vehicles and 2018 Chevrolet Malibu vehicles. The rear brake caliper pistons may have an insufficient coating causing gas pockets to form, potentially reducing rear brake performance.

Risk. A reduction of braking performance can increase the risk of a crash.

Remedy. GM will notify owners, and dealers will bleed the vehicle's brake system, free of charge. The recall began October 11, 2018. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 18279.

A rear passenger side door handle/latch stopped working. The door cannot be opened from the inside, only from the outside. It’s a safety issue and it has affected other 2019-2020 Bolts which resulted in their recall. Why not this one?

Steering wheel does not return to center on turns when driving at low speeds.

Steering wheel does not return to center after making a turn. Over time the steering rack fails leading to a steering wheel that will not return to center even when force is applied to wheel. The dealership is charging $3-4k to fix this safety issue.

When driving my car from the airport at Bradley International in CT (parked for a week), I experienced a terrible vibration in the steering wheel which has been intermittent. The vibration went away at lower speeds. I brought the car in to the shop on 5/18/2026 with 74,000 miles on the car. They told me I had to replace rotors, brakes, calipers, brake fluid, and do a front end alignment because the rotors have failed internally. The EV doe not use braking as frequently and this was taken from the Chevy forum: ISSUE: Frozen or Seized Calipers The Issue: Because Bolt drivers heavily rely on regenerative braking, the physical brake pads and calipers are used far less frequently than in gas-powered cars. This can cause rust and debris to build up, leading to frozen calipers, uneven pad wear, or a sticking/grabbing brakes. The Fix: Have a trusted mechanic or a dealer regularly inspect and service the friction brakes. Regular preventive maintenance like flushing the brake fluid every few years is highly recommended to prevent moisture accumulation and seized calipers. The resultant failure is a safety issue and Chevy has decided to call it a PM problem. This is not acceptable and is all over the forums as an issue for these cars. I saved all parts and had them record everything on the car, except for the fluid. There are other recalls for this component. I would like it investigated and determination made on the issue. The invoices will be in my possession tonight.

The steering wheel takes more effort to turn than it should and does not return to center after making a turn. It has been like this since I bought the car used, and I did not realize until recently that it should not be like this. Comments on some online forums indicate that this is a common issue with Chevy Bolts, usually requiring a steering rack replacement. This is a complex operation requiring certified EV technicians (I am told) and very expensive. I am not sure if GM has addressed this issue in any way.

The steering wheel locks and stiffens on turns to the left or right refusing to come back to center on its own. In the middle of the turn the wheel locks up. Been told by multiple dealerships and forums I've read online it's a known issue with the car needing a steering gear replacement. A job that costs $4-5k per GM based on labor. There's no warning lights. GM has reproduced issue And based on this forum multiple accounts of this have happened to others [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Issue: Total failure of Frontview Camera ADAS sensor, disabling Automatic Emergency Braking (AEB), Front Pedestrian Braking, and Lane Keep Assist. Technical Evidence: GDS2 telemetry confirms a "No Communication" status for the camera hardware. Core safety modules including the Electronic Brake Control (EBCM) and the Inflatable Restraint (Airbag) Sensing Module report active communication failures (DTC U026A/U216A). These safety-critical modules are currently unable to receive the sensor data required for crash avoidance and occupant protection. Forensic Timeline: Vehicle NVRAM reveals a manual "Clear Codes" event occurred at 46,838.3 miles—exactly 0.4 miles after the sale contract was signed. The fault reappeared with a 0 km offset (immediate return) and has been active for 162 ignition cycles, proving the defect existed throughout the dealership's possession. Dealer Response: The selling dealer delivered the vehicle with an unsigned 125-Point Inspection. Despite being presented with GDS2 telemetry proof of the braking and airbag communication blackout, management refused repair, mischaracterizing the disabled emergency braking system as a "luxury feature" and claiming the vehicle is "safe" to drive. Symptoms: "Service Front Camera" warning, intermittent loss of HVAC controls, and gear display (PRNDL) blackout due to systemic serial data bus interference caused by the hardware failure.

What component or system failed or malfunctioned, and is it available for inspection upon request? The steering gear in this vehicle began to fail around 40K miles. It clunks at low speed, doesn't roll out of turns, and recently has begun to oscillate during straight driving. I will keep the old part for inspection once replaced. How was your safety or the safety of others put at risk? The cars steering does not return to center during a turn. Now, the steering is shaking violently during driving. It will likely seize if left unfixed. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. I also have video. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? This is a well documented issue with Chevy steering. I will include an AI overview screenshot.

Steering gear and torque sensor failure at 39,000 miles. Car is unsafe to drive and costs over $3500 to fix. The problem has been diagnosed at a dealership. No warning lights or codes apparent, problem is worsening and the car is becoming unsafe to drive. Steering gear or rack could be available for inspection.

Vehicle steering wheel fails to return to center after sweeping turn. Found it’s a common issue and is incredibly dangerous and should be recalled!

The steering on my car is sticking and failing. When I make a turn, the steering wheel does not go back to the center on its own. I have to physically pull it back, otherwise the car will keep turning. When driving straight, the steering wheel gets "stuck." I have to use extra force to make small adjustments, which makes the car jerk. The steering also makes clunking noises. This is extremely dangerous because it makes the car very hard to control, and I could easily drift into another lane, overcorrect, or crash.

Water has infiltrated the lower trunk area and fried the sound amplifier. The result is no sounds can be heard from the speakers. This includes sounds and warnings from the safety systems. Seat belt, ADAS, BLIS, OnStar, Turn Signals, Radio. The rear hatch seals seem to be intact and it is unclear how water is entering this lower area as there is no evidence of water anywhere else in the rear cargo area. A google search reveals many other Bolt owners are experiencing the same issue

As with other Chevy bolts, the rack and pinion steering completely broke no longer able to steer vehicle.

Steering will not return to center. After going around a turn, or even a curve like an exit ramp, the steering will remain locked in position and not re- center. It requires close attention and considerable force to return it to center and continue along a straight road.

Steering will not return to center. After going around a turn, or even a curve like an exit ramp, the steering will remain locked in position and not re- center. It requires close attention and considerable force to return it to center and continue along a straight road.

The steering wheel does not return to center. This appears to be a common issue on Chevy Bolts based on various forums, for example https://www.chevybolt.org/threads/steering-wont-return-to-center-bad-steering-gear-steering-sticking-in-one-direction.42988/. One has to be very aware of the steering issue as it requires the driver to actively force the steering wheel to return to center. This can be an even bigger issue when having to react to avoid debris or sudden breaking. There are no warning lights. The manufactuer claims that this is not a prevalent issue.

So I bought a used Bolt and the steering is sticking, at moderate speed (50mph) sweeping corners it lightly wants to pull harder into the corner and won't return to center if you let off the wheel, regardless of direction, you must always forcefully guide the steering wheel back to center. This is wrong, if your Bolt does this your steering rack is likely failing. This is a malfunction, in the GM service manual for the Bolt there is a diagnosis for "POOR RETURN OF STEERING WHEEL" which is described as "After completing a turn, extra steering input is required for the steering wheel to return to center."

Steering rack is binding, not returning to center after completing a turn. Only 50,000 miles on it.

Steering wheel does not return to center after making sharp turns. Steering wheel must be manually returned to center to avoid crashing.

Power steering fails go return to center intermittently causing unexpected handling characteristics while turning that could cause to over/undershoot a turn. Haven't taken it to the dealer to check and there are no warnings or lights.