2003 Toyota Sequoia

Defect. Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Risk. An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy. Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.

Defect. Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2002-2005 Lexus SC and Toyota Sequoia, 2003-2005 Toyota Corolla and Tundra, and 2003-2007 Pontiac Vibe vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation.

Risk. An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy. Toyota will notify the Toyota and Lexus owners. General Motors will notify the Pontiac Vibe owners. Depending on the vehicle model, dealers will replace the front passenger air bag inflator with an alternate inflator, or replace the air bag assembly that includes an alternate inflator, free of charge. The recall began January 23, 2019. Owners may contact Toyota customer service at 1-888-270-9371, Lexus customer service at 1-800-255-3987 or Pontiac customer service at 1-800-762-2737. Toyota's numbers for these recalls are J0A (Zone A Toyota), J0B (Zone B Toyota), J0C (Zone C Toyota), JLI (Zone A Lexus), JLJ (Zone B Lexus), and JLK (Zone C Lexus). Note: This recall includes vehicles that have had their air bag previously replaced under an earlier air bag campaign.

Defect. Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015, that they are recalling 2005-2007 Lexus SC, Toyota Corolla, Corolla Matrix, Sequoia, and Pontiac Vibe, and 2005-2006 Toyota Tundra vehicles that were originally sold, or ever registered, in Florida, along the Gulf Coast, Puerto Rico, Hawaii, the U.S. Virgin Islands, Guam, Saipan and American Samoa. On June 16, 2015 Toyota expanded the recall to cover an additional 769,055 vehicles, including certain model year 2002-2004 Lexus SC, Toyota Sequoia, 2003-2004 Toyota Corolla Matrix, Toyota Corolla, Pontiac Vibe, and Toyota Tundra vehicles, as well the vehicles covered by the May 13, 2015 notification in the portions of Georgia, Alabama, Louisiana, Mississippi and Texas that were not previously included. The inflators in the front passenger air bags are susceptible to rupture in the event of a crash necessitating the deployment of the front passenger air bag.

Risk. In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Remedy. 2003-2004 Corolla and Corolla Matrix vehicles that are recalled under both 15V-043 and 15V-286 are under a Do Not Drive advisory. Owners of these vehicles are advised not to drive their vehicles until the recall remedy has been completed. Toyota will notify their owners. Pontiac Vibe owners will be notified by GM. Dealers will replace the passenger side front air bag, free of charge. Owners may contact Toyota customer service at 1-800-331-4331. Toyota began the recall on July 13, 2015. Pontiac Vibe owners may contact GM at 1-800-762-2737. GM began the recall on June 29, 2015. NOTE: This recacll supersedes recall 14V-655 in its entirety. For vehicles located in the U.S. states not listed above, please see Toyota recall 15V-285 which covers all other U.S. states.

Defect. Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015 that they are recalling certain model year 2004 Sequoia vehicles manufactured August 18, 2003, to August 19, 2004, and 2003-2004 Tundra vehicles manufactured March 18, 2003, to August 25, 2004. On June 16, 2015, Toyota expanded the recall to include an additional 1,270,468 vehicles, including model year 2002-2003 and 2005-2007 Sequoia, 2005-2006 Tundra, 2003-2007 Corolla, 2003-2007 Corolla Matrix, 2003-2007 Pontiac Vibe and 2002-2007 Lexus SC vehicles. This is to address a safety defect in the passenger side frontal air bag inflator which may produce excessive internal pressure causing the inflator to rupture upon deployment of the air bag. This recall addresses both the passenger side frontal air bags that were originally installed in the vehicles, as well as replacement air bags that may have been installed as replacement service parts. A replacement air bag may have been installed, as one example, if a vehicle had been in a crash necessitating the replacement of the passenger side frontal air bag.

Risk. In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Remedy. 2003-2004 Corolla and Corolla Matrix vehicles that are recalled under both 15V-043 and 15V-285 are under a Do Not Drive advisory. Owners of these vehicles are advised not to drive their vehicles until the recall remedy has been completed. Toyota will notify their owners. Pontiac Vibe owners will be notified by GM. Dealers will replace the front passenger air bag. The recall began on July 13, 2015. Toyota owners may contact Toyota customer service at 1-800-331-4331. Pontiac owners may call 1-800-762-2737. NOTE: This recall supersedes recall 14V-312 in its entirety.

Defect. TOYOTA IS RECALLING CERTAIN MODEL YEAR 2003 SEQUOIA PASSENGER VEHICLES MANUFACTURED FROM APRIL 1, 2002 THROUGH APRIL 17, 2003. THE CENTER POSITION OF THE STEERING ANGLE SENSOR (SAS) MAY NOT BE STORED CORRECTLY DUE TO IMPROPER LOGIC OF THE SKID CONTROL ECU PROGRAMMING. THE VEHICLE STABILITY CONTROL (VSC) SYSTEM COULD ACTIVATE AT LOW SPEED FOR A FEW SECONDS DURING ACCELERATION FROM A STOPPED POSITION.

Risk. SHOULD THIS OCCUR, THE VEHICLE MAY NOT ACCELERATE AS QUICKLY AS THE DRIVER EXPECTS, INCREASING THE RISK OF A CRASH.

Remedy. TOYOTA WILL NOTIFY OWNERS AND DEALERS WILL REFLASH THE ECU. IF THE REFLASH CANNOT BE COMPLETED ON A PARTICULAR VEHICLE, THE ECU WILL BE REPLACED WITH A NEW ONE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Defect. CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk. WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy. CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.

Defect. ON CERTAIN SPORT UTILITY VEHICLES, DUE TO A MANUFACTURING ISSUE IN THE FRONT SUSPENSION LOWER BALL JOINT, THERE IS A POSSIBILITY THAT THE SURFACE OF THE BALL OF THE JOINT MAY HAVE BEEN SCRATCHED. THE BALL JOINT MAY EVENTUALLY EXPERIENCE EXCESSIVE WEAR AND LOOSENESS, RESULTING IN INCREASED STEERING EFFORT.

Risk. THE LOWER BALL JOINT MAY SEPARATE FROM THE KNUCKLE CAUSING LOSS OF STEERING CONTROL AND A CRASH COULD OCCUR.

Remedy. DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS FREE OF CHARGE. THE RECALL BEGAN ON JULY 5, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at …

The Office of Defects Investigation (ODI) opened PE14-016 in June 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in Florida or Puerto Rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by Takata, a tier-one supplier of automotive air bag systems.During the course of PE14-016, ODI determined that five additional vehicle manufacturers used inflators of a similar design and vintage also supplied by Takata. No evidence of field …

The Office of Defects Investigation (ODI) opened PE14-016 in June 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in Florida or Puerto Rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by Takata, a tier-one supplier of automotive air bag systems.During the course of PE14-016, ODI determined that five additional vehicle manufacturers used inflators of a similar design and vintage also supplied by Takata. No evidence of field …

On April 28, 2010, Toyota Motor North America submitted a Defect Information Report (NHTSA Recall No. 10V-176) to NHTSA describing a problem in the Vehicle Stability Control (VSC) system in approximately 50,000 Model Year (MY) 2003 Toyota Sequoia vehicles.According to the report the centering position of the Steering Angle Sensor (SAS) in the MY 2003 vehicles may not be stored correctly due to a logic problem with the Skid Control Computer programming.The VSC system uses the information from the SAS to calculate the driver's intended vehicle direction.This information is cross referenced to …

Odi has received 64 consumer reports and toyota has received 96 reports that allege incidents of inappropriate activation of either the electronic stability control system [toyota nomenclature: vehicle stability control (vsc)] and/or the traction control system in model year (my) 2003 toyota sequoia vehicles.during the activation of either system the driver loses throttle control and one or more brakes may apply causing the vehicle to slow suddenly.during these activation events the brake lights are not illuminated to signal to following traffic that the vehicle is slowing.some of the …

SPECIAL SERVICE CAMPAIGN 50J - PHASE I - FRONT SUSPENSION LOWER BALL JOINT MAY EXPERIENCE EXCESSIVE WEAR AND LOOSENESS CAUSING INCREASED STEERING, EFFORT, REDUCED VEHICLE SELF-CENTERING, AND NOISE IN THE FRONT SUSPENSION. *TT

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

A key part to maintain the proper function and safe operation of the vehicle's braking system is to perform a visual inspection when installing brake pads, calipers, and discs. The following recommendations are intended to provide general tips for the inspection and/or installation of Toyota Complete Maintenance Care (TCMC) front brake pads and discs. …

M.I.L. ON DTC C1247 & C1310: SKID CONTROL COMPUTER LOGIC CHANGE. *TT

ABS WITH EBD & BA & TRAC & VSC SYSTEM REPAIR MANUAL CORRECTION FOR THE 2003 SEQUOIA. 00400-RM959-U1. *TT

I was on the highway going 45 to And T-bone somebody who pulled out onto the highway the driver airbag did not deploy the seatbelt is the only thing that caught me and cause severe trauma to my chest neck and back for The car is totaled and it is being held at my insurer’s State Farm lot here in Southern Arizona I assume it can be inspected There was a police report filed at the scene.

My 2003 Sequoia was in the garage for a check on the brakes. I also asked them to check the frame for any rust issues, because I had previously been concerned about it earlier. They reported to me that the car should be off the road because the rust in the frame was so severe. They said they would not put it up on the lift anymore because it could break in half. The stabilizer was barely connected at one end. There were holes completely through the frame at several places. I know from my research that Toyota issued safety recalls for 2003 Sequoia and Tundra vehicles. This an issue that Toyota should repair.

Once again the rear latch system has failed and I am unable to open my rear hatch door. So I am unable to remove my spare tire. And can not acsess the failed charcoal canister Toyota is screwing up my life with all their failed parts preventing repair on other parts

Can not acsess the failed charcoal canister due to rear door failing and am unable to open . So I can not drop the spare tire and acsess the canister

Can not get BSC, TRC engine lights off traction control kicks in and locks steering and brakes . Unsafe can not smog after spending thousands replacing parts

Front end in rolled shacking. Tires wearing extremely fast and uneven image. Unable to drive

Traction control warning lights, VSC warning lights. These lights have been on for 2 years, resulting in check engine light on. I have replaced every sensor possible, fuses, gas cap, and reset the system multiple times but can not get these lights to stay off. Since lights have been on, when driving on a muddy, wet, icy or slippery road way, my steering locks up, the brakes stop working and there is complete loss of vehicle control. All without warning. This is an extreme hazard and very dangerous. This has been on going since 2017 and is still a major problem . It started at around 200,000 miles.

This Vehicle's frame had an extended warranty on it for excessive rust damage in the northern cities. There are holes in the frame, very close to welding points that may break at anytime while driving. And cause an accident.

So in few words when check engine light is happening then immediately traction control and skid control and maybe other safety features are automatically goes off, which almost made me crash with all my family during rain. I definitely don’t like it and I don’t think it’s a good idea if one of the non critical sensors broken then you have to die in crash. I think Toyota should check it because it’s doesn’t sound right.

UNKNOWN I'm unsure of what is causing it but it is a very common issue with the 03-04 sequoia. The brake light will come on like on mine and apparently it's a failure in one of the brake components. It's either the brake booster or the master cylinder in most cases is starting to g out. I've done research on this issue and it's a very common problem costing people thousands to get fixed. I feel like if it's that huge of a problem like I've seen with sequoia owners than it's needs to be addressed in a better manner

The lock actuators in the doors are notorious for going on more than normal it's another very common issue with the seqouia. My driver one is bad right now. And clearly the window motors are faulty cuz I had 3 bad at once I fixed one but my sunroof and back tailgate window both do not work. It is also a very common problem

I want to bring attention to the a fatal flaw designed into Toyota truck frames. I understand Toyota denied my claim and I am out of luck with the repairs on my truck. However it is morally responsible for me to bring awareness to this deadly issue. Since most owners don't know they have a problem until the frame breaks, it is worth raising awareness to save human life. This is not a cosmetic issue, its a life or death issue for the consumer. The frame on my truck is completely rusted. In 2013, a Toyota dealership did a frame inspection on my 2003 truck per the recall notice to the previous owner. Toyota had a safety recall for a two step frame replacement for 12 years. The inspection noted an excessive amount of corrosion and rust on the frame components. In 2014, another Toyota dealership decided to spray a sealer over the rust instead of replacing the frame. The sealer trapped moisture and accelerated the oxidation process. This made the problem worse and the rust spread and destroyed the metal to a point its not repairable or safe to drive. The frame of the truck is only 20 years old and was garage kept. However it was operated in a cold climate where salt is applied to the roadways. After filing a several cases with Toyota US I was told its the consumers responsibility and the case was denied. Me and the previous owner did follow the guidelines set forth by the safety frame recall. Since Toyota worked on the frame during the time of the recall they should be held respons

I recently purchased my 2003 Toyota Sequoia SR5 4WD that had the manufacturer’s undercoating done as a result of the LSC in 2013. The coating has failed and water was able to seep in causing massive rust on the frame. It is a safety hazard to drive at this point.

I have a 2003 Toyota Sequoia 167k miles that has major frame rust. This is now becoming a safety issue and Toyota needs to be held accountable!

The contact owns a 2003 Toyota Sequoia. The contact stated while parking the vehicle, the contact noticed smoke coming from under the hood of the vehicle. The contact stated while depressing the brake pedal, he felt the vehicle made a sudden stop. The contact checked under the hood and noticed that the VSC box was melting. The contact disconnected the battery to the vehicle and the smoke stopped. The vehicle was not diagnosed. The manufacturer was not contacted. The failure mileage was 200,000.

Undercarriage frame found to be badly rusted, by a AAA Driver who came to my roadside assistance following a brake failure due to rusted and leaky brake lines.

"VSC OFF, VSC TRAC, and ABS" indicators on the dash. YAW sensor failure which controls wheel speed which will cause vehicle to decelerate and possibly cause an accident. Toyota should issue a nationwide recall. Toyota is aware of the issue but has failed to issue a nationwide recall.

Abnormal rust all over underside of vehicle including frame, structural components, brake lines, steering components … etc. FRAME and steering/suspension components rusting out. Rear differential rusting out. Cab mounts rusting out. Spare tire hardware rusting out. Transmission cooler lines about to burst from corrosion. Rear tow assembly rusting out. Entire underside is rotting out. Known issue which has plagued hundreds of owners, but Toyota has not recalled this model year. Extremely dangerous; one brake line has already gone out resulting in a loss of braking. Toyota applied an undercoating circa 2013 but they just sprayed over an already rusted frame and other components without proper preparation which actually accelerated the corrosion and rot. Deceptive and unethical business practices. Vehicle cost over $50,000 new in 2003 and only has just over 120,000 miles on it. This should NOT be happening. Please help. Please investigate.

Hello, I am writing to you to have an investigation started on 2003 Toyota Sequoia, I own one and there has been concerns with the Frame of the vehicle rotting out, there was Warranty Enhancement Program sent out in United States to cover frames of 2001 to 2004 Toyota Sequoias which replaced severely rusted out frames at the dealership. I use this vehicle for my family and I do not want to endanger the lives of them and the people around the community where the frame may break due to rust and cause a severe accident. Please take a look at the details below and get back to me. Subject: Limited Service Campaign (LSC) CSD Certain 2001 through 2004 Model Year Sequoia Vehicles Frame Inspection I am located in Canada would like NHSTA to investigate and see if this program can be administered to vehicles in Canada since I have severe rotting of the frame and I have had to have it welded many times to not compromise the safety of the vehicle

Unknown

The latch hook/truck door release has a defect. It has been replaced 3 times after purchase of my vehicle , by the following Toyota dealerships (Tejas Toyota in Humble Texas (2x); Maund Toyota in Austin, Tx (1x). Each dealership service said it was/is manufacture defect with the latch hook and it stops “un latching when the vehicle the button is pressed to unlock and the handle can not open the hatchback” This time I was traveling out of state with my pet in the kennel and when we stopped for restroom break the latch would not open to retrieve the pet to let out the kennel. We were traveling with a vehicle full of items, which the entire inside of the vehicle had to be emptied I ordered to let all the seats down and try to maneuver to try to get my dog out of kennel I. Such a small confined space that was hard to open because it was in the side. It took over and hour to cut the cage at the top to retrieve my pet. The sad part is there was no warning because we were traveling a 13 hour trip, stopping every couple hours for breaks and stretches, and the couple hours before we open the hatchback just fine. This is more than a safety concern for the animal. This is also the ares for retrieving the spare tire underneath the vehicle when the spare has to be released. I have replaced the part 3 times and I am charged $600 cost for parts and labor, when Toyota is aware of the defect. I just had the part replaced 19 months ago and Toyota only gives a 12 warranty on the part. This is l

My gas gauge sensor consistently drops below the “E” marker when the truck has gas in it and especially when it is filled up. After driving about 50 miles or so, the gauge will move up some ; however, I have been relying on my DTE monitor to let me know about gas. I have taken it to the dealer twice and both said “the gas tank needs to be dropped in order for repair” I was About to pay for the service but was told I had to make an appointment. However the service advise ask had I had it replaced before because there was a recall on that particular part several years ago. Please note I have never received any notice about a recall regarding the issue. Please advise.

The contact owns a 2003 Toyota Sequoia. The contact stated that the vehicle was rusted and towed to the local dealer and diagnosed that the rear differential casing and steering column needed to be replaced. The manufacturer was contacted however, no further assistance was provided. The failure mileage was 240,000.Note: While driving, a loud grinding noise was heard and the vehicle was shaking. 1 pulled over and had the car towed. It was determined the rear differential casing was completely rusted and the oil leaked out. It-was also determined the Steering column was completely rusted. The vehicle was recalled in 2012, due to rust issues. The dealership stated they would do the recall work but the vehicle was in poor shape. When I contacted Toyota, they said it was a courtesy recall and will not do any further. Consumer is asking for assistance with the cost of repair due to poor workmanship.

WHEN TAKING MY 2003 SEQUOIA TO HAVE THE POWER STEERING ISSUE I WAS HAVING, I WAS TOLD THE FRAME WAS SO RUSTED OUT IS WAS UNSAFE TO DRIVE. I CALLED TOYOTA CUSTOMER SUPPORT AND WAS TOLD THERE WAS NOTHING THEY COULD DO TO COVER ANY COSTS INVOLVED IN REPAIRING OR REPLACING THE FRAME.

TL* THE CONTACT OWNS A 2003 TOYOTA SEQUOIA. THE CONTACT STATED THAT WHILE ENTERING AND EXITING THE VEHICLE, THE AIR BAG COVER WOULD DETACH WITHOUT WARNING. THE CONTACT CALLED PASSPORT TOYOTA (5001 AUTH WAY, CAMP SPRINGS, MD 20746, (301) 899-6000) HOWEVER, THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.

TL* THE CONTACT OWNS A 2003 TOYOTA SEQUOIA. THE CONTACT STATED THAT WHILE HAVING A TIRE REPLACED ON THE VEHICLE, THE TECHNICIAN NOTICED THAT THE DRIVER'S AND PASSENGER'S SIDE UNDERNEATH THE VEHICLE WAS EXTREMELY CORRODED. THE TECHNICIAN DEEMED THE VEHICLE UNSAFE TO DRIVE. THE VEHICLE WAS NOT REPAIRED. NO DEALER WAS CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT UNDER RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 235,000.*DT*DT

TL* THE CONTACT OWNS A 2003 TOYOTA SEQUOIA. THE CONTACT STATED THAT WHILE THE VEHICLE WAS IN FOR ROUTINE SERVICE, IT WAS DISCOVERED THAT THE FRAME OF THE VEHICLE HAD EXPERIENCED RUSTING AND CORROSION. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE LOCAL DEALER HENDRICK TOYOTA LOCATED AT 9505 W 67TH ST, MERRIAM, KS 66203 AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE HOWEVER, NO ASSISTANCE WAS OFFERED. THE CONTACT INDICATED THAT THE VEHICLE WAS INSPECTED IN 2013 UNDER A MANUFACTURERS CAMPAIGN REGARDING THE FAILURE HOWEVER, NO FAILURE WAS FOUND. THE FAILURE MILEAGE WAS 181,000.

RUSTED THROUGH OF FRAME. COMPLETELY UNSAFE TO DRIVE, VEHICLE COULD LITERALLY BREAK IN HALF. OUTSIDE OF THE YEARS TOYOTA INCLUDED IN THE CLASS ACTION LAWSUIT PREVIOUSLY FILED

ON 12/21/2020, AFTER RUNNING ERRANDS, I PUT MY VEHICLE INSIDE MY LOCKED GARAGE AT 10:30 A.M. AND ALL WAS FINE. AT AROUND 9:00 P.M. THAT SAME NIGHT, I OPENED MY GARAGE TO FIND IT FULL OF SMOKE. AFTER INSPECTING EVERYTHING, I SAW NOTHING WAS STILL ON FIRE AND WAITED UNTIL THE MORNING TO INVESTIGATE THE PROBLEM. I FIRST TRIED TO START THE VEHICLE AND IT HAD BATTERY POWER BUT WOULD NOT TURN OVER. I THEN PUT IT IN NEUTRAL AND BACKED THE VEHICLE AWAY FROM THE FRONT OF THE GARAGE TO OPEN THE HOOD. I SAW THE ENGINE HAD BURNED UP FROM SOMEWHERE ON THE PASSENGER SIDE BUT HAD PUT ITSELF OUT. THE FIRE CRACKED THE EXTERIOR HOOD, BURNED HOSES, ELECTRICAL AND OTHER AREAS OF THE INSIDE OF THE ENGINE. BLACK SOOT HAD ALSO DROPPED ON THE FLOOR OF THE GARAGE UNDERNEATH WHERE THE FIRE WAS. THE WOOD BEAMS INSIDE MY GARAGED WERE ALSO SCORCHED BLACK FROM THE INTENSE HEAT FROM THE FIRE/SMOKE BUT LUCKILY HAD NOT CAUGHT FIRE. I HAD IT TOWED TO MY MECHANIC WHO SAID I SHOULD HAVE MY CAR INSURANCE TAKE OVER. MERCURY HAS NOT DETERMINED THE CAUSE OF THE FIRE BUT I AM PUSHING FOR THE EXACT CAUSE SINCE IF IT'S RELATED TO A RECALL ISSUE, THEN TOYOTA SHOULD BE HELD ACCOUNTABLE AND I SHOULD BE COMPENSATED. MY VEHICLE HAS 37,200 MILES LESS THAN THE AVERAGE AND I HAVE A SPREADSHEET OF ALL SCHEDULED MAINTENANCE, SMOG CHECKS AND RECALLS COMPLETED. THERE WAS NO REASON THIS VEHICLE SHOULD HAVE SPONTANEOUSLY COMBUSTED INSIDE MY GARAGE. LUCKILY, I WASN'T DRIVING, WASN'T HURT, AND NO OTHER PROPERTY WAS DAMAGED DUE TO THI

AS I CAME RO STOP AUTO THEN PRESSED THE ACCELERATOR THE AUTO ACTED AS IF IT DIDNT WANT TO MOVE BUT STARTED OUT SLOW . THIS OCCURED EVERYTIME I STOPPED AND PRESSED TO ACCELL THE AUTO. THE AUTO WAS IN MOTION , DURING TURNING.

I TOOK MY SEQUOIA TO HAVE AN AIRBAG RECALL FIXED AND A RECALL THAT HAS SOMETHING TO DO WITH THE SKID CONTROL MODULE BEFORE I TOOK IT TO HAVE THESE RECALLS DONE MY 2 VSC LIGHTS (VSC OFF LIGHT AND VSC TRAC LIGHT) ON THE DASH WERE ON AND SO WAS THE ENGINE LIGHT I THOUGHT MAYBE THE SKID CONTROL RECALL WOULD FIX THE VSC LIGHT BUT NOW BOTH OF THE VSC LIGHTS ARE STILL ON AND MY BRAKE LIGHT IS NOW ALSO COMING ON WHEN I START MY VEHICLE WHEN THIS HAPPENS MY BRAKE POWER IS DIMINISHED AND MY VEHICLE SHAKES BAD WHEN HITTING MY BRAKES TO SLOW DOWN TO MAKE A TURN OR JUST TO SLOW DOWN IN GENERAL AT A STOP LIGHT OR STOP SIGN THIS HAPPENS ON THE HIGHWAY OR WHEREVER I'M DRIVING MY VEHICLE AT THE TIME BUT AS LONG AS THE VSC LIGHTS AND THE BRAKE LIGHT AREN'T ALL LIT UP ON MY DASHBOARD AT THE SAME TIME MY BRAKES AREN'T AS DIMINISHED BUT BOTH OF THE VSC LIGHTS STAY ON AND MY VEHICLE STILL SHAKES WHEN I'M SLOWING DOWN TO MAKE A TURN. ALSO WHEN BOTH OF THE VSC LIGHTS ARE ON ALONG WITH THE BRAKE LIGHT MY VEHICLE WANTS TO SPIN THE BACK TIRES WHEN I'M TAKING OFF FROM A DEAD STOP I HAVE TO LET OFF THE GAS COMPLETELY FOR A SECOND THEN PROCEED.

I HAVE GIVEN BY VEHICLE INFORMATION TO SPRINGFIELD VA. TOYOTA IN SEPTEMBER 2019. FOR URGENT SAFETY RECALL. THEY SUPPOSED TO CALL ME BUT, TILL TO-DAY NOTHING. I CALL TOYOTA WOODBRIDGE, VA BUT, THEY ARE NOT COOPERATING. PLEASE HELP ME OUT.

MY 2003 TOYOTA SEQUOIA HAS RUST HOLES THROUGH MY FRAME TO THE POINT WHERE IT IS UNSAFE TO DRIVE. I HAVE TO DRIVE IT AS IT'S MY ONLY VEHICLE AND I HAVE 2 SMALL CHILDREN THAT I HAVE TO TAKE WITH ME. TOYOTA USA SAID THEY PERFORMED A TREATMENT TO THE GRAM IN 2012 AND THAT THEIR IS NOTHING FURTHER THEY WILL DO TO RESOLVE THIS BLATANT SAFETY ISSUE. THE FACT SO MANY SEQUOIA OWNERS ARE REPORTING THIS AND NOTHING IS BEING DONE BY TOYOTA IS APPALLING. I HAVE SUBMITTED PICTURES OF AN AREA NEAR THE DRIVERS SIDE FRONT WHEEL. THE SWAY BAR IS BARLEY BEING HELD ON DUE TO THE RUST.

EVERYTHING UNDER MY TRUCK IS RUSTY. EVERYTHING IS FULL OF CORROSION, ESPECIALLY THE FRAME, AND SOME PARTS ARE STARTING TO FALL. AND THE FRAME TO BREAK, TOYOTA SHOULD BE ABLE TO REPAIR THIS IMMEDIATELY

TRAC OFF VSC TRAC OFF LIGHTS ILLUMINATE. SEEMS TO BE FAULTY SENSOR. BRAKE LIGHT PERIODICALLY COMES ON WITH NO ISSUE WITH BRAKES. BRAKES HAVE BEEN REPLACED AND EVERYTHING CHECKED. ON 2 OCCASIONS WHEN THE BRAKE LIGHT IS ON, THE ANTISKID CONTROL ACTIVATES WHEN THE CAR IS GOING LESS THAN 30 MPH SLOWING DOWN FOR A TURN. THE CAR IS HARD TO CONTROL AND SHAKES. AFTER THE CAR IS TURNED OFF FOR AWHILE THE BRAKE LIGHT DOES NOT ILLUMINATE THE NEXT TIME YOU DRIVE BUT WILL COME BACK ON RANDOMLY. TRAC OFF AND VSC TRAC LIGHTS ILLUMINATE ARE ON.

WHEN DRIVING ABOUT 45 OR 60 MPH THE STEERING WHEEL SHAKES REAL BAD AN VIBRATES FEELS LIKE I GOT A FLAT TIRE OR FEELS LIKE I'M GONNA HAVE A TIRE COME OFF WHEN I BOUGHT IT ALSO CONSUMES A LOT OF GAS UST TO GET REAL GOOD GAS MILEAGE BUT NOW NOT SO GOOD JUUST TO FILL UP TWICE A WEEK BUT NOW SOMETIMES 3 TO 5 TIMESWHICH IS WEIRD DIDN'T KNOW I HAD A RECALL WARRANTY I HAVE HAD TO REPLACE A LOT OF THINGS ESPECIALLY IN THE EMISSIONS PART FOR CAR BOUGHT NEW FUEL LINE SOLENOIDS , PURGE SOLENOID, NOW IT SAYS I NEED A NEW VALVE VENT SOLENOID. THERE IS A VACUUM LEAK OTHER THAN THAT RUNS GOOD DOESN'T OVER HEAT OR BREAK UNLESS I NEEDED TO BUT USES A LOT OF GA SHAKES REAL BAD I DON'T WANNA DRIVEMORETHAN 70 MPH ALL THE TIRES ARE AT 41 PSI

TAKATA RECALL. THE PARKING LIGHT WOULD COME ON INTERMITTENTLY, AND WE HAD IT LOOKED AT BY A TOYOTA DEALER. THEY RECOMMENDED TO REPLACE THE ECU, WHICH WE DID. THIS DIDN'T FIX IT. THE CAR GOT WORSE AND STARTED SHAKING WHEN I DROVE AND WHEN I STOPPED IT WOULD SHAKE AND MAKE A GRINDING NOISE. WE HAD IT LOOKED AT AND THE BRAKING SYSTEM SERVICED. THE PROBLEM IS STILL THERE. THIS IS A COMMON PROBLEM WITH THIS YEAR AND A DANGEROUS FLAW IN THESE VEHICLES.

TOOK VEHICLE TO LOCAL TOYOTA DEALERSHIP DUE TO STEERING ISSUE - WHEN I WOULD HIT A BUMP I WOULD LOOSE CONTROL OF THE STEERING. INSPECTION SHOWED THE VEHICLE UNDER BODY AND FRAME HAS COMPLETELY RUSTED, THERE ARE SEVER HOLES AND THE TRAILING ARM HAS SEPARATED FROM THE FRAME. I AM NOT THE ORIGINAL OWNER, BUT TOYOTA HAD A RECALL ON THE FRAME DURING THE PRIOR OWNERSHIP AND THE VEHICLE WAS SERVICED MULTIPLE TIMES AT A TOYOTA DEALERSHIP DURING THE RECALL AND THE PROBLEM WAS NOT ADDRESSED. TOYOTA REFUSES TO OFFER ANY ASSISTANCE AT THIS TIME.

WHILE EXECUTING A SLOW SPEED LEFT TURN(10-15MPH) I BRAKED LIGHTLY TO EXECUTE ANOTHER LEFT TURN WHEN THE PARKING BRAKE AND TRACTION CONTROL LIGHTS LIT UP ON MY DASHBOARD ALONG WITH DIMINISHED BRAKE POWER AND A GRINDING NOISE. I APPLIED THEM AGAIN A LITTLE MORE AGGRESSIVE TO STOP MY VEHICLE..SAME RESPONSE. I COASTED TO ABOUT 2-3MPH AND THE LIGHTS WERE STILL SHOWING BUT I RECOVERED BRAKE POWER. AT MY DESTINATION(3 BLOCKS AWAY) I TURNED OFF THE VEHICLE. ON MY RETURN TRIP BACK HOME, THERE WAS NO SIGN OF DASH WARNING LIGHTS AND I HAD FULL BRAKING POWER. @HOME I IMMEDIATELY CALLED TOYOTA USA AND THEY DID NOT ACKNOWLEDGE ANY ONGOING PROBLEM. AFTER GOING ON AN ONLINE FORUM I DISCOVERED NUMEROUS COMPLAINTS ABOUT THE SAME PROBLEM...SOME OF THEM ACTUALLY GOING TO TOYOTA FOR THE PROBLEM, AND SOME OF THOSE STATED THE PROBLEM RETURNED..MY SON RAN AN OBDII DIAGNOSTIC TO FIND NUMEROUS CODES FOR THE ABS ANS ECU AND BRAKEBOOSTER SYSTEM.FIXES RANGE FROM LOW BRAKE FLUID TO A COMPLETE REPLACEMENT OF SAID SYSTEMS COSTING THOUSANDS OF DOLLRS. I FEEL THIS IS A SERIOUS SAFETY ISSUE THAT TOYOTA SHOULD ADDRESS. [DATELINE PROBLEM HAPPENED 6-27-19...]I HAVE NO CHOICE NOW BUT TO WARILY TRUST TOYOTA TO RUN A DIAGNOSTIC ON MY VEHICLE FOR SOLUTIONS....PLEASE HELP

TL* THE CONTACT OWNS A 2003 TOYOTA SEQUOIA. WHILE WASHING THE VEHICLE, THE CONTACT NOTICED SEVERE RUST ON THE FRAME. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 145,000.

TWO WEEKS AGO WE WERE TOLD THAT THE FRAME HAD RUSTED THROUGH AND THE CAR WAS UNSAFE TO DRIVE. AFTER DOING RESEARCH WE FOUND OUT THAT TOYOTA HAD A LIMITED FRAME REPAIR OFFER BUT WE MISSED THE DEADLINE. WE WERE NEVER TOLD BY TOYOTA OR THE DEALERSHIP SERVICE TEAM ABOUT THE RECALL OR THE DAMAGE TO OUR TRUCK. WE HAD OUR CAR SERVICED AT THE DEALERSHIP NUMEROUS TIMES. THE MECHNIC THAT TOLD US ABOUT THE RUST TOLD US IT WAS DANGEROUS TO DRIVE. THE TRUCK ONLY HAS 120K MILES AND WE ARE THE ORIGINAL OWNERS.

TL* THE CONTACT OWNS A 2003 TOYOTA SEQUOIA. THE CONTACT TOOK THE VEHICLE TO DAVENPORT TOYOTA (LOCATED AT 1501 E 53RD ST, DAVENPORT, IA 52807, (563) 391-4106) FOR A NOISE THAT WAS COMING FROM THE CHASSIS WHILE DRIVING. THE DEALER DIAGNOSED THAT THE FRAME WAS BADLY CORRODED THROUGH. THE VEHICLE WAS NOT REPAIRED. THREE HOURS AFTER LEAVING THE DEALER, WHILE DRIVING 55 MPH, THE FRAME FRACTURED AND THE REAR OF THE VEHICLE SHOOK VIOLENTLY LEFT AND RIGHT. THE CONTACT WAS ABLE TO COAST THE VEHICLE TO THE SIDE OF THE ROAD. THE CONTACT DROVE THE VEHICLE SLOWLY TO HIS RESIDENCE. ONCE THE CONTACT ARRIVED HOME AND LOOKED UNDERNEATH THE VEHICLE, HE NOTICED THAT THE REAR PASSENGER SIDE WAS COMPLETELY CORRODED THROUGH. THE CONTACT STATED THAT THERE WAS NO COATING ON THE FRAME, WHICH CAUSED THE METAL TO CORRODE BADLY. THE VEHICLE WAS TAKEN BACK TO DAVENPORT TOYOTA WHERE IT WAS INSPECTED AND THE CONTACT WAS INFORMED THAT THE FRAME WAS CORRODED THROUGH AND THERE WAS NO RESOLUTION FOR THE REPAIR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED A CASE NUMBER. THE APPROXIMATE FAILURE MILEAGE WAS 186,000.

TL* THE CONTACT OWNS A 2003 TOYOTA SEQUOIA. THE CONTACT STATED THAT THERE WAS EXTENSIVE RUST AND CORROSION WITH AT LEAST THREE SPOTS ALONG THE BOTTOM OF THE FRAME NEAR THE WELDS. DUE TO THE FAILURE, THE CONTACT WAS UNCERTAIN IF THE FRAME WOULD FRACTURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT INCLUDED IN ANY FRAME RECALLS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 102,000.

I HAVE HAD PERSISTENT PROBLEMS WITH THE FRONT BRAKES ROTORS WARPING. NEW ONES DO NOT LAST VERY LONG BEFORE THEY WARP. MY VEHICLE HAS APPROXIMATELY 155,000 MILES. MY I HAVE ASKED MY TRUSTED SERVICE MECHANICS TO USE TOYOTA PARTS. THE DEALERSHIP PARTS DEPARTMENT TOLD MY MECHANICS THAT THEY DO NOT RECOMMEND REPLACING THE ROTOR WITH A THE ORIGINAL TOYOTA PART AS THEY HAVE BEEN WARPING. THEY RECOMMEND UP SIZING THE ROTORS, WHICH IS WHAT TOYOTA HAS DONE ON SOME VEHICLE. I HAVE TALKED TO A TOYOTA SERVICE DEPARTMENT ABOUT REPLACING THE FRONT ROTORS AND BRAKES. THEY GAVE ME A QUOTE BUT SAID THEY WOULD NOT GIVE ANY WARRANTY ON BRAKES. I TALKED TO TOYOTA'S 800 NUMBER THEY SAID THERE WERE NO RECALLS OR ELIGIBLE UPGRADES AND THAT MY VEHICLE WAS NOT PART OF THE CAMPAIGN THEY HAD FOR THE BRAKES. THEY WOULD NOT ELABORATE IF ANY OF THE 2003 SEQUOIAS WERE PART OF THE CAMPAIGN. THEY GAVE ME A CASE NUMBER. MY PRIMARY CONCERN IS THAT THE BRAKES OR BRAKE COMPONENTS ARE UNDERSIZED WHICH IS MANIFESTED BY THE REPEAT WARPING OF THE ROTORS. THE UNDERSIZED BRAKES COULD BE A HAZARD UNDER CERTAIN CIRCUMSTANCES.

THE FRAME ON THE CAR IS RUSTING AWAY WITH ONLY 40K MILES ON IT. IT WAS GARAGE KEPT.

THE TRUNK LATCH/HANDLE/LOCK. I HAVE HAD IT REPLACED 3 TIMES BY A TOYOTA DEALERSHIP. THERE'S IS CLEARLY A MANUFACTURE DEFECT AND THERE'S NEEDS TO BE A RECALL. THE LAST TIME THE TOYOTA DEALERSHIP I. AUSTIN TEXAS REPLACES IT I HAD A 12 MONTH WARRANTY. IN EXACTLY 14 MONTHS THE SAME THING OCCURRED AGAIN! THIS IS RIDICULOUS TO SAY THE LEAST AND I AM TIRED OF PAYING 600 (PARTS/LABOR) TO REPAIR, WHEN TOYOTA IS AWARE OF THE PROBLEM! NOTE: WHEN THE HANDLE BREAKS THERE IS NO ACCESS TO THE SPARE TIRE BECAUSE YOU HAVE TO LIFE THE TRUNK TO ACCESS THE SPARE TIME. I HAVE HAD MY VEHICLE TOWED TWICE SCORN TIRE ISSUES BECAUSE THE SPARE COULD NOT BE ACCESSED. THE LAST OCCURRENCE I WAS STRANDED ON SIDE OF THE ROAD AT 2AM.

TL* THE CONTACT OWNS A 2003 TOYOTA SEQUOIA. THE CONTACT STATED THAT THERE WAS EXTENSIVE RUST AND CORROSION ON THE FRONT AND REAR PARTS OF THE FRAME. THE CONTACT STATED THAT THE RUST COULD CAUSE THE FRAME TO FRACTURE. ARLINGTON TOYOTA (2095 N RAND RD, PALATINE, IL 60074, (847) 485-1200) INDICATED THAT THE VEHICLE WAS INCLUDED IN A MANUFACTURER CAMPAIGN, BUT THE CONTACT WAS NOT NOTIFIED. THE DEALER STATED THAT THE STATUTE HAD EXPIRED TO PROVIDE A REMEDY. THE DEALER AND THE MANUFACTURER EXPECTED THE CONTACT TO REPLACE THE FRAME. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER REFUSED TO PROVIDE ASSISTANCE OTHER THAN HAVING THE DEALER REPAIR THE VEHICLE. THE APPROXIMATE FAILURE MILEAGE WAS 256,000. *BF*JB

TAKATA RECALL. RECALL STATES THAT VEHICLE WILL BE REPAIRED AT NO COST TO CONSUMER, DEALERSHIP WILL NOT GIVE ME RIDE HOME OR LOANER AND STATES THAT IT IS A 4.5 HOUR JOB BUT I MUST LEAVE ALL DAY. TOYOTA OF NORTH AMERICA HAS FAILED TO PROVIDE REMEDY! THIS IS THE 3RD TIME THE VEHICLE HAS BEEN RECALLED FOR THIS PROBLEM.

THE HANDLE ON THE TRUNK IS BROKEN AND I AM NOT ABLE TO OPEN THE TRUNK. IT WON'T OPEN WITH THE KEY OR THE REMOTE FOR THE VEHICLE. 2003 TOYOTA SEQUOIA LIMITED

MY VSC/VTC LIGHTS HAVE BEEN ON SINCE I HAVE OWNED MY VEHICLE. I ALSO HAVE A BRAKE LIGHT THAT COMES ON CONSTANTLY. I AM ONLY ABLE TO RESET THE BRAKE LIGHT BY TURNING OFF MY VEHICLE AND RESTARTING. I HAVE REPLACED ALL 4 ROTORS, CALIPERS AND FUEL LINES MORE THAN 3 TIMES SINCE BUYING THE TRUCK NEW. BRAKE PADS ARE CHANGED IN THE FRONT TIRES CONTINUOUSLY! THERE IS A SERIOUS PROBLEM WITH THE BRAKE SYSTEM IN THIS TRUCK! I WAS TOLD BY MANY MECHANICS THAT THE ONLY WAY TO GET THE SKID CONTROL / TRACTION CONTROL LIGHTS TO TURN OFF IS TO HAVE TOYOTA FIGURE OUT WHAT IS WRONG WITH THE BRAKE SYSTEM IN THE SEQUOIA'S. ALSO, I BELIEVE THERE SHOULD BE ANOTHER WAY TO OPEN THE BACK HATCH TO THIS VEHICLE OTHER THAN THE PLASTIC HANDLE ON THE OUTSIDE WHICH BREAKS REPEATEDLY!! IF THERE WERE AN EMERGENCY ON THE INSIDE OF THE TRUCK AND THE ONLY EXIT WERE THE REAR OF THE VEHICLE, THERE IS NO WAY TO OPEN THE REAR TAIL GATE FROM INSIDE!!! ONCE THAT STUPID PLASTIC HANDLE ON THE OUTSIDE OF THE VEHICLE BREAKS, YOU CANNOT OPEN THE REAR HATCH ON THE SEQUOIA!! IT BECOMES A DEATH TRAP IN THE THIRD ROW SEATING AREA!!