2014 Toyota FJ Cruiser

Defect. Toyota Motor Engineering & Manufacturing (Toyota) recalled certain 2018-2019 4Runner, Highlander, Camry, Land Cruiser, Sequoia, Sienna, Tacoma and Tundra, and Lexus RC 300, RC 350, GS 350, GX 460, IS 300, LC 500, LS 500, LX 570, RX 350L, and 2019 Toyota Avalon and Corolla, and certain Lexus NX 300, and ES 350 vehicles on January 13, 2020. On March 4, 2020, Toyota expanded the recall to include certain 2014-2015 Toyota 4Runner and Land Cruiser, 2018 Avalon, Corolla, 2014 FJ Cruiser, 2017 Sienna and Lexus 2018 ES 350, 2018-2019 GS 300, 2013-2014 GS350, 2014-2015 GX 460, IS 350 and LX 570, 2014 IS F, 2018-2019 IS 350, LC 500H and LS 500H, 2013-2015 LS 460, 2015 NX 200T and RC350, 2017 RC 200T and RX 350. Toyota also removed the 2018-2019 Toyota 4Runner and Land Cruiser and 2018-2019 Lexus GX 460 and LX 570 and 2019 NX300 from inclusion in this recall. On March 19, 2020, Toyota expanded the recall to include 2015 Lexus GS350 vehicles. The low-pressure fuel pump inside the fuel tank may fail.

Risk. If the fuel pump fails, the engine can stall while driving, increasing the risk of a crash.

Remedy. Toyota will notify owners, and dealers will replace the fuel pump, free of charge. The recall began May 4, 2020. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are 20TB02 and 20TA02 for Toyota vehicles and 20LB01 and 20LA01 for Lexus vehicles.

Defect. Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2014 FJ Cruiser vehicles manufactured August 7, 2013, to August 20, 2013. In the affected vehicles, the intermediate steering shaft which connects the steering wheel and the steering gear box may have an inadequate weld.

Risk. If the intermediate steering shaft weld fails, there would be a loss of steering control, increasing the risk of a vehicle crash.

Remedy. Toyota will notify owners, and dealers will replace the intermediate steering shaft, free of charge. The recall began on March 6, 2015. Owners may contact Toyota customer service at 1-800-331-4331.

Defect. Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2014-2015 Toyota 4Runner, Tacoma, FJ Cruiser, Land Cruiser, RAV4, Scion FRS, and XB vehicles. The affected vehicles may have accessories installed by SET, such as running boards or other items, that were incorrectly installed. The accessory attaching fasteners were not tightened with the proper torque, possibly causing the accessory to detach from the vehicle.

Risk. Accessories that detach from a vehicle may result in a vehicle crash and/or personal injury.

Remedy. SET will notify owners, and dealers will inspect and tighten the affected bolts, free of charge. The recall began February 23, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-14B.

Defect. Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2014 FJ Cruiser vehicles equipped with an optional "Trail Teams Ultimate Edition" package, in which the front shock absorbers and springs were replaced at vehicle processing centers. In some of these vehicles the bolts which secure the front lower ball joint to the steering knuckle and/or the front suspension lower arm to the front cross member assemblies might have been tightened with insufficient torque when the front shock absorbers and springs were replaced during the installation process.

Risk. In this condition, one or both bolts could become loose during driving and fall out. If both bolts fall out from the front lower ball joint or the front suspension lower arm, these components could detach from the steering knuckle or the front cross members, causing a loss of steering control, which could increase the risk of a crash.

Remedy. Toyota will notify owners of vehicles with the optional package installed, and dealers will inspect the torque of the bolts. If the bolts are found to be loose, dealers will retighten them to the proper torque. For any missing bolts, dealers will install new ones. The recall began on November 7, 2014. Owners may contact toyota at 1-800-331-4331.

Defect. Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2008-2014 FJ Cruiser and Tacoma vehicles equipped with accessory wheels and tires installed by Toyota or dealers prior to the vehicle's first sale. The affected vehicles may list incorrect spare tire size and/or cold tire inflation information on the tire placard. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard No. 110, "Tire Selection and Rims for Passenger Cars."

Risk. If the spare tire is inflated to the incorrect pressure provided on the placard, tire failure may occur while it is being driven on, increasing the risk of a crash.

Remedy. For the involved vehicles, overlay stickers to correct the tire placard will either be mailed to owners or provided to dealers for placement over the incorrect information on the placard. The recall is expected to begin in September 2014. Owners may contact Toyota customer service at 1-800-331-4331.

Intermediate Steering Shaft Weld Failure: Recall concern. My car was built 7/25/2014. Recalls were initiated for FJ’s within the following date ranges 8/7/2013 - 8/20/2013 for this issue. My FJ has the same issue confirmed by three Toyota Dealership Service Departments. Revisiting the Recall Status is needed. Thank you for your attention.

The contact owns a 2014 Toyota FJ Cruiser. The contact stated that while cleaning underneath the vehicle, the contact discovered that the subframe was severely corroded. The dealer was made aware of the failure; however, the vehicle was not diagnosed or repaired. The manufacturer made aware of the failure and advised them contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 120,000.

Mice or rats consume the soy-based wires. They consumed one of the fuel injection wires on my 2014 FJ. The Toyota dealership charged me $896 for the new connector that was located under the intake manifold.

Excessive frame rust causing safety issue with suspension and crash danger. Yes my vehicle is available for inspection. My safety as well as other drivers safety are put at risk if the suspension fails causing my vehicle to veer into on-coming traffic. The problem is on going and can be confirmed by a dealer or independent service. My vehicle has not been inspected by the manufacturer, but is available for inspection upon request. No warnings lamps. This is an undercarriage issue that is hidden by the tires and the body that sits on the frame.

Extensive rust in frame

FRAME IS SEVERELY RUSTING. WE TOOK TO TOYOTA DEALER TO GET A LOOSE SKID PLATE ATTACHED, AND MECHANIC TOLD US THAT THEY HAD TO REMOVE IT BECAUSE "THERE WAS NOTHING LEFT TO ATTACH TO AS THE FRAME HAS RUSTED AWAY. THE FRAME, ATTACHMENT POINTS, SUPPORTS, AXLES AND SUSPENSION PIECES ARE EXTREMELY RUSTY. WE WERE ADVISED BY MECHANIC TO DISPOSE OF THE CAR BECAUSE IT WOULD SOON BE UNDRIVEABLE. 98000 MILE, 9 YEAR OLD, BABIED, DEALER MAINTAINED CAR.

Rear Body Mount rotted, frame very rusted and thin, could pose issue with structure. All the times bringing to dealer, nothing was mentioned regarding how bad the frame was.

Frame corrosion and complete frame failure. The area compromised affected the steering of the vehicle. Luckily, the failure was discovered before failure at Highway speeds . No warning of any kind prior to failure. The vehicle is currently at a Toyota dealership awaiting a complete frame replacement . Should the failure have occurred at Highway speed, this would have been a catastrophic event as the front end/ steering would have been dramatically affected

Notable frame rust and corrosion. Available for inspection upon request. Safety risk if any parts of frame are rusted through and vehicle has no structural support. Confirmed by independent service center. Inspected during each Toyota service, including one done in March 2021 prior to purchasing vehicle. Documentation does not mention frame/structural rust anywhere. Initial photographs of frame rust done prior to first oil change in July 2021. Was told it was just surface rust and could be "sanded down" and it would be good as new. No warning messages.

CONDITION IS CONTINUOUS: WHEN VEH. IS IN MOTION OR PARKED WITH MOTOR RUNNING OR MOTOR IS NOT RUNNING.. BACK DOOR OF VEHICLE CANOT BE UNLOCKED WITH A KEY AS SUGGESTED ON PAGE 40 OF OWNERS MANUAL.. OR WHEN USING WIRELESS REMOTE, OR DOOR SWITCH.THIS CONDITION WAS FIRST NOTICED WHEN THE VEHICLE WAS PARKED AND MOTOR NOT RUNNING.. DRIVER AND PASSENGER DOORS DO WORK PROPERLY WITH THE KEY. BOTH SIDE DOORS WORK PROPERLY USING A KEY AS DESCIBED ON PAGE 35 OF THE OWNERS MANUAL., THE GLASS HATCH CANNOT BE OPEND WITH A KET AS SUGGESTED ON PAGE 45 OF THE OWNERS MANUAL, I DO NOT KNOW THE CAUSE OF THIS MALFUNCTION.,THESE CONDITIONS ARE A SAFETY HAZZARD.

THE VEHICLES FRAME IS CONSIDERABLY RUSTED WHEN TAKING INTO ACCOUNT THE AGE AND USE OF THE VEHICLE, IT HAS LESS THAN 50K AT THE TIME OF SUBMISSION.

TL* THE CONTACT OWNS A 2014 TOYOTA FJ CRUISER. THE CONTACT STATED WHILE THE VEHICLE WAS AT A STAND STILL, THE REAR TAILGATE DOOR WAS UNABLE TO OPEN. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED NOR REPAIRED AS OF YET. A DEALER WAS NOT CONTACTED. THE MANUFACTURER HAD BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS 35,000.

TL* THE CONTACT OWNS A 2014 TOYOTA FJ CRUISER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V012000 (FUEL SYSTEM, GASOLINE). THE CONTACT CALLED THE DESERT TOYOTA OF TUCSON LOCATED AT 7150 E 22ND ST, TUCSON, AZ 85710, (520) 296-8535, AND IT WAS CONFIRMED THAT PARTS WERE NOT YET AVAILABLE FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

TL* THE CONTACT OWNS A 2014 TOYOTA FJ CRUISER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V012000 (FUEL SYSTEM, GASOLINE) HOWEVER THE PART TO DO THE RECALL REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE VEHICLE WAS TAKEN TO CRESTMONT TOYOTA (730 NJ-23, POMPTON PLAINS, NJ 07444) DUE TO AN ABNORMAL FUEL ODOR OF FUEL. TOYOTA OF MANHATTAN (645 11TH AVE, NEW YORK, NY 10036) AND CRESTMONT TOYOTA (730 NJ-23, POMPTON PLAINS, NJ 07444) AND THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND INFORMED THE CONTACT THAT PART WOULD BE AVAILABLE MAY OF 2020. THE FAILURE MILEAGE WAS APPROXIMATELY 68,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2014 TOYOTA FJ CRUISER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V012000 (FUEL SYSTEM, GASOLINE) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. AN UNKNOWN DEALER WAS CONTACTED AND IT WAS CONFIRMED THAT THE PART WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

I BOUGHT MY 2014 FJ CRUISER BRAND NEW WITH 5 MILES ON IT. 6 MONTHS INTO OWNING IT THE DRIVER DOOR LOCKS STOPPED WORKING. THE DEALER REPLACED IT UNDER WARRANTY. ABOUT A YEAR LATER THE PASSENGER LOCKS STOPPED WORKING AND THEY REPLACED THOSE UNDER WARRANTY. ABOUT 1-1/2 YEARS LATER THE DRIVER LOCK (THAT WAS ALREADY REPLACED) STOPPED WORKING AGAIN. I HAD 34,000 MILES ON IT AND THEY TOLD ME THAT IT'S NO LONGER COVERED UNDER WARRANTY. I TOLD THEM THAT THE LOCK THEY REPLACED WENT OUT BUT THE DEALER SAID THE REPLACEMENT WARRANTY IS ONLY GOOD FOR 1 YEAR AFTER THE REPAIR! SHORTLY AFTER THE PASSENGER LOCK WENT OUT AGAIN AS WELL. AND NOW THE BACK DOOR WONT EVEN UNLOCK WITH THE KEY FOB OR EVEN MANUALLY WITH THE KEY. THE DOOR LOCK ACTUATORS ON THE CARS ARE TERRIBLE! I WENT TO THE DEALER AND THE SERVICE MANAGER TOLD ME THEY WERE HAVING A LOT OF ISSUES WITH THE TOYOTA LOCKS AND FOR ME TO KEEP AN EYE OUT FOR A RECALL! IT'S BEEN 3 YEARS NOW THAT I'VE BEEN WITHOUT LOCKS AND NO RECALL! DEALER QUOTED ME $900 TO FIX ONE DOOR! $360 FOR THE PART AND THE REST LABOR. RIDICULOUS ESPECIALLY BECAUSE THEY HAVE ALREADY REPLACED THESE PARTS IN THE PAST UNDER WARRANTY!! WHAT GOOD IS IT TO PAY FOR THE SAME PART THEY ALREADY 'REPLACED' JUST FOR THEM TO GO OUT SO SOON!!!

TL* THE CONTACT OWNS A 2014 TOYOTA FJ CRUISER. THE CONTACT STATED THAT WHILE COMING TO A STOP AND PULLING INTO A DRIVE THRU, THE VEHICLE STALLED WHILE THE CHECK ENGINE WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE FAILURE RECURRED MULTIPLE TIMES. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 20V120000 (FUEL SYSTEM, GASOLINE). THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN.

FRAME IS RUSTING REALLY BAD. TOYOTA ALREADY REPLACE THE TRD COIL SPRINGS ON EACH SIDE DUE TO RUST

HAD VEHICLE IN SHOP, NEW TIRES AND BALANCE. ALL FOUR TIRES HAD TO BE REBALANCE. HAD BRAKES DONE,( ROTORS AND PADS AND ALL FOUR TIRES REBALANCE). ONE MONTH LATER STEERING STARTED ACTING UP. STIFFING UP. NOW DEALERSHIP SAIDS NO RECALL. DIFFERENT SITES SAYING STEERING SHIFT NEEDS A WELT. DEALERSHIP WANTS TO CHARGE TO FIX IT.(600.00).

TL* THE CONTACT OWNS A 2014 TOYOTA FJ CRUISER. THE CONTACT STATED THAT THE FRONT OCCUPANT CLASSIFICATION SYSTEM FAILED. WHEN A PASSENGER WAS SEATED IN THE FRONT PASSENGER SEAT, THE FRONT PASSENGER AIR BAG WAS OFF AND THE FRONT PASSENGER SEAT BELT WARNING INDICATOR ILLUMINATED THAT THE SEAT BELT WAS OFF. THE VEHICLE WAS TAKEN TO GRAND BLANC TOYOTA MOTORCARS, LTD (9000 HOLLY ROAD, GRAND BLANC, MICHIGAN, (810) 695-4400) SEVERAL TIMES FOR THE AIR BAG FAILURE. THE DEALER PERFORMED A DIAGNOSTIC TEST AND RECALIBRATED THE FRONT PASSENGER SEAT SENSOR; HOWEVER, THE FAILURE WAS NOT CORRECTED. THE VEHICLE WAS TAKEN BACK TO THE DEALER AND THEY REPLACED THE FRONT PASSENGER SENSOR, WIRING HARNESS, AND SEAT CAGE; HOWEVER, THE FAILURE WAS NOT CORRECTED. THE DEALER WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE MANUFACTURER WANTED TO REIMBURSE THE CONTACT FOR THE REPAIRS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS NOT AVAILABLE.