2023 Rivian R1s

Defect. Rivian Automotive, LLC (Rivian) is recalling certain 2022-2027 R1S, 2022-2026 R1T, and 2027 R2 vehicles. The rearview camera image may be obstructed by a notification when in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

Risk. An obstructed rearview camera image can reduce the driver's view behind the vehicle, increasing the risk of a crash.

Remedy. Rivian has released an over-the-air (OTA) software update, free of charge. Owner notification letters are expected to be mailed November 9, 2026. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1866. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov on November 9, 2026.

Defect. Rivian Automotive, LLC (Rivian) is recalling certain 2022-2025 R1T and 2022-2026 R1S vehicles. The bolts that secure the second-row driver and passenger side seat belt retractor assemblies may be improperly tightened.

Risk. An improperly secured seat belt retractor may not adequately restrain the seat occupant, increasing the risk of injury during a crash.

Remedy. Rivian will inspect and tighten the bolts as necessary, free of charge. Owner notification letters were mailed March 2, 2026. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1795.

Defect. Rivian Automotive, LLC (Rivian) is recalling certain 2022-2025 R1S and R1T vehicles that previously had service performed. The toe link may have been reassembled incorrectly during service procedures performed before March 10, 2025.

Risk. The toe link joint may separate, increasing the risk of a crash.

Remedy. Rivian will replace the rear toe link bolts, free of charge. Owner notification letters were mailed February 17, 2026. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1794. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning February 24, 2026.

Defect. Rivian Automotive, LLC (Rivian) is recalling certain 2022-2025 R1T and R1S vehicles. The D-ring bolts for one or both front seat belt anchorage assemblies may not have been properly installed.

Risk. An improperly secured seat belt may not restrain an occupant as intended, increasing the risk of injury during a crash.

Remedy. Rivian will inspect and properly secure the seat belt anchorage assemblies as necessary, free of charge. Owner notification letters were mailed July 8, 2025. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1681.

Defect. Rivian Automotive, LLC. (Rivian) is recalling certain 2022-2023 R1S and R1T vehicles. The maximum vehicle capacity weight value on the tire placard label is incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."

Risk. A vehicle with an incorrect maximum capacity weight value may be overloaded, which can increase the risk of a crash.

Remedy. Rivian will mail owners a corrected overlay tire placard label, free of charge. Owner notification letters were mailed August 8, 2024. Owners may contact Rivian customer service at 1-888-748-4264. Rivian's number for this recall is FSAM-1491.

Defect. Rivian Automotive, LLC (Rivian) is recalling certain 2022-2024 R1T and R1S vehicles. The attachment clips on the upper B-pillar and/or C-pillar trim panels may have been damaged during a service procedure.

Risk. Damaged pillar trim panel clips can result in improper side curtain air bag deployment, increasing the risk of injury during a crash.

Remedy. Rivian will replace the pillar trim panels, free of charge. Owner notification letters were mailed July 16, 2024. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM 1464.

Defect. Rivian Automotive, LLC. (Rivian) is recalling certain 2023-2024 EDV, R1S, and R1T vehicles. The headlights may be improperly aimed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamp, Reflective Devices and Associated Equipment."

Risk. Improperly aimed headlights can result in insufficient illumination of the road, decreasing the driver's visibility and increasing the risk of a crash.

Remedy. Rivian will inspect and adjust the headlight alignment as necessary, free of charge. Owner notification letters were mailed June 28, 2024. Owners may contact Rivian customer service at 1-888-748-4264. Rivian's number for this recall is FSAM-1445.

Defect. Rivian Automotive, LLC (Rivian) is recalling certain 2022-2023 R1T and R1S vehicles. A software update may have deactivated the defroster and defogger system controls.

Risk. The inability to operate the windshield defrosting and defogging system can decrease the driver's visibility, increasing the risk of a crash.

Remedy. Rivian has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed December 21, 2023. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1331.

Defect. Rivian Automotive, LLC (Rivian) is recalling certain 2022-2023 R1S vehicles. The reverse light beam may not be visible from certain angles. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Risk. Reduced visibility of the reverse lights increases the risk of a crash.

Remedy. Rivian will repair or replace the reverse lights, free of charge. Owner notification letters were mailed July 12, 2023. Owners may contact Rivian customer service at 1-855-748-4265. Rivian's number for this recall is FSAM-1216.

Defect. Rivian Automotive, LLC (Rivian) is recalling certain 2022-2023 R1S vehicles. The fasteners that secure the right and left side curtain air bags may be improperly secured.

Risk. Improperly secured side curtain air bags may not perform as intended, increasing the risk of injury during a crash.

Remedy. Dealers will secure or replace the side curtain air bags as necessary, free of charge. All owners have been notified and all vehicles will be repaired by March 15, 2023. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1185.

Rear view camera is super buggy and takes forever to load when car put in reverse. General infotainment is laggy

Backup camera failed to display while backing up. Proceed to drive after leaving home and the display went blank. The failure of the backup camera to display at all was very alarming and unsafe, fortunately no one was around and I was able to safely backup. No warning signs that the display screen was going to go blank. This appears to be related to the most recent software update on my vehicle this month. I have been noticing the screen has been sluggish when attempting to adjust controls.

The specific failed component is UNKNOWN. My 2023 Rivian R1S has experienced recurring intermittent Limited Performance/loss-of-propulsion-type events since within months of delivery. The events involve unexpected reduction of available propulsion, reduced maximum speed, warnings, restarts, system/display restarts, and at times inability to move or change gears. Rivian documented Limited Performance while driving in January 2024. In March 2024, Rivian documented loss of propulsion and an approximately 10 mph maximum speed; a reset and sleep cycle did not correct the condition. Rivian later stated it could not reproduce the concern. In March 2026, Rivian documented Limited Performance while driving, the vehicle coming to a stop, and multiple restarts before it would move. On September 4, 2026, the vehicle again entered Limited Performance and would not exceed approximately 20 mph. After a restart, it operated normally. Rivian received the vehicle for service on September 7. On September 9, Rivian stated that initial testing did not duplicate the Limited Performance telltale, that it had no confirmed repair, and that it proposed an extended approximately 100-mile test drive to try to reproduce the issue. I retained photos and videos of additional events involving reduced speed, warnings, restarts, and inability to move. The intermittent loss or reduction of propulsion while driving can affect my ability to maintain safe speed and creates a potential crash risk. There was no cra

The contact owns a 2023 Rivian R1S. The contact stated that the vehicle was taken for service, and the service tech stated that all three rear seat belts had a wire that had been severed from the buckle. Additionally, the vehicle failed to detect an occupant seated in the rear seats. The dealer stated that the seat belt buckles needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, and a complaint was filed. The failure mileage was 29,000.

I own a 2023 Rivian R1S, early production vehicle #531, with approximately 93,000 miles. While driving, I noticed the vehicle's suspension was not functioning normally. After parking, the front passenger side of the vehicle dropped significantly lower than the other side, leaving the vehicle visibly uneven. I also received suspension warnings indicating that the suspension system was too hot and needed to cool. I brought the vehicle to a Rivian Service Center. Rivian diagnosed a failed/leaking damper and a failed air compressor. I was informed that only one damper had failed, but that all four dampers must be replaced because Rivian changed the manufacturer of the dampers and the replacement components are not compatible with the original dampers installed on my vehicle. The estimated repair cost is approximately $8,000. I am concerned that this may represent a safety-related failure of the early-generation R1S suspension system rather than normal wear. The suspension failure resulted in a substantial and visible change in the vehicle's ride height and occurred after I had experienced suspension behavior changing while driving. I have also found reports from other Gen 1 Rivian owners describing leaking hydraulic dampers, damper failures, suspension sag or collapse, multiple damper replacements, and air-compressor failures. Some owners report Rivian replacing their original dampers with subsequently revised components. I am particularly concerned that Rivian has informed me th

On XXX, at approximately 12:19 PM, I was in the drive-through lane at a Chick-fil-A in [XXX], with my child as a passenger. I was using one-pedal driving mode and had come to a complete stop with my foot off the accelerator. I turned briefly to hand my child an ice cream cup, and when I looked back at the road, the vehicle was accelerating at full power with no contact from either pedal. To avoid striking the vehicles stopped ahead of me in the drive-through line, I swerved left into the Chick-fil-A building, causing a collision with the building. This put myself, my child, and nearby pedestrians and drivers at serious risk of injury. Cedar Park Police Department responded to the scene and a report was filed. I have video footage of the incident. The vehicle is available for inspection upon request. I believe the accelerator pedal and/or its sensor malfunctioned, possibly related to a known issue some other Rivian owners have reported involving cabin temperature affecting the pedal sensor; this has not yet been confirmed by a dealer or manufacturer. I am requesting that the manufacturer pull the vehicle’s black box/EDR data and perform full diagnostics on the pedal and sensor. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

When an adult passenger is in the vehicle passenger seat, the passenger airbag light shows "airbag off" Approximate weight 130 pounds

Tension noise and creaking coming from suspensions. Special washers were needed in order to fill gaps in build tolerances.

The vehicle experiences recurring, uncommanded high-speed steering "lurches" where the Lane Keep Assist (LKA) system initiates aggressive, sudden steering inputs at highway speeds (65+ mph). These inputs force the vehicle out of its lane and require immediate, significant manual driver counter-steering to prevent collisions. These events occur without warning, despite no perceived environmental triggers. This issue involves the vehicle's automated steering and Lane Keep Assist software suite. This safety defect renders the vehicle inherently dangerous to operate at highway speeds for the driver, occupants and everyone on the freeway. This issue is not isolated to this vehicle; numerous owners have reported identical, terrifying high-speed steering shoves on public forums for over a year. There is credible evidence indicating that the manufacturer's executive leadership, including the CEO, has been aware of these fleet-wide issues for well over a year. Despite this knowledge, the manufacturer continues to characterize these life-safety events as "Operating as Designed" or "No Fault Found" (NFF). This issue has been reported to the manufacturer’s service center repeatedly over several months by myself and other owners. Despite the manufacturer claiming to be "diagnosing" or "duplicating" the steering failure, telemetry data from the vehicle (including odometer audits) confirms that the vehicle remains stationary at the service facility for extended periods with zero diagnostic

Right rear toe link to knuckle bolt snapped off while driving causing a deadly situation.

While driving at city speeds, I heard a rubbing/grinding noise from the right rear of the vehicle and noticed that the suspension no longer felt normal. After stopping to inspect the vehicle, I found that the right rear wheel had shifted rearward within the wheel opening and was contacting the wheel liner. The condition appeared suddenly without prior warning messages or warning lights. I do not recall any curb strike, pothole impact, collision, off-road event, or other significant impact prior to the failure. The vehicle was towed to a manufacturer service center and inspected. The manufacturer determined the damage was impact-related and not covered under warranty. Recommended repairs include replacement of the right rear knuckle, upper longitudinal link, toe link, hub bearing, and halfshaft. The failure resulted in a significant change in rear suspension geometry and raised concerns about vehicle safety. The damaged components are currently in the possession of the manufacturer service center and may be available for inspection.

I am submitting this complaint after learning through a recent TechCrunch article regarding the NHTSA investigation PE26004 into Rivian rear suspension / rear toe link failures that my incident appears substantially similar to the failures currently under investigation. On March 2, 2024, at approximately 1:29 AM, my son [XXX] was driving my 2023 Rivian R1S (VIN [XXX] ) in [XXX] . While making a normal right turn from [XXX] onto [XXX] and accelerating normally afterward at approximately 30 mph, the vehicle suddenly suffered what appeared to be a catastrophic rear suspension failure. According to the driver, the left rear portion of the vehicle suddenly jolted downward, a loud mechanical breaking sound was heard, and the vehicle immediately became uncontrollable. The rear suspension appeared to collapse instantly. The vehicle then began sliding uncontrollably across the roadway and crossed into the opposite traffic lane. The driver attempted to release the accelerator and correct steering input, but the vehicle did not respond normally. Steering control was effectively lost and the vehicle could not be controlled. The vehicle ultimately impacted a tree on the left rear/driver-side rear area before coming to rest perpendicular to the roadway. Importantly, the loss of control occurred BEFORE impact with the tree. The impact was a consequence of the apparent suspension failure and resulting loss of vehicle control, not the initiating cause of the event. There was no rain and road

The vehicle's infotainment, driver gauge cluster and on display safety systems all fully lock up and reboot after about 30 minutes of driving. If you have highway ADAS engaged, warning sounds will occur but no display explaining the warnings. If you're using the vehicle's safety systems you suddenly do no have blindspot monitoring, or enabled ADAS. Additionally, navigation will not be available causing immediate confusion.

Toe link failed on the driver rear side. My vehicle went out of control, veered over adjacent lanes, over the bike path, onto the side walk and back onto the road and side walk. I was left with a sore neck for several days, my apple watch kept trying to call 911 thinking I was in an accident. Anyone one the sidewalk or bike lane or adjacent vehicle lane would have been impacted. The problem has an outstanding recall with Rivian but my vehicle isn't part of the recall. Rivian is repairing the broken components. No warning lamps, messages, or other symptoms before the failure. I was traveling at ~50MPH through and intersection when as soon as I exited the intersection the vehicle turned to the right / banked to the right in an aggressive manner which I could not control. I went across and adjacent lane that was unoccupied sideways and onto the sidewalk then back onto the road.

The contact owns a 2023 Rivian R1S. The contact stated that while driving at various speeds, the message "Electrical System Fault - Contact Rivian Service Immediately - Avoid Fording" was displayed along with a picture of the vehicle in water. The vehicle was taken to the dealer, where it was diagnosed that there was an internal short circuit in the HVAC system due to water intrusion or condensation from the HVAC system. The dealer determined that the HVAC system needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 69,000.

The driver seat has preset settings for seat adjustments but they do not have Obstruction Detection. We have a rear facing car seat that was placed behind the drivers seat that had to be replaced (by us) as the seat auto adjusted and did not detect the back of the car seat and snapped the car seat out of its base. We contact Rivian over phone and they did not have a remedy (over a year ago, cannot recall exact date). It happened several times where we had to force stop the adjustment to prevent damage to new car seat. Eventually we decided to place the new rear facing car seat behind the passenger car seat instead. The back of the drivers seat has permanent damage from it pushing against the car seat. I did not think about filing a complaint here until I read about the recent Hyundai incident.

Yesterday was the 3rd time in 2 months that the vehicle displayed a "Airbag System needs service - Drive with caution until serviced" warning. I have taken it to Rivian 2 times where each time they replaced various components of the airbag system and it was reported to be fixed. Yesterday the warning returned. I am extremely concerned that Rivian does not have the ability to properly diagnose and or fix whatever the underlying issue is regarding my airbag system. I am now scheduled to take my vehicle in for the 3rd time for them to "try to figure it out".

On five separate occasions the airbag system on my car has become inoperable. Starting in July 2025 I noticed an airbag error on the display of the vehicle. I brought the car in for service and they replaced the steering wheel. The airbag error occurred again in August, this time requiring replacement of a different wiring harness. The error occurred again and again went in for service in November, this time replacing the front seats, seatbelt control modules, and the airbag module. This past weekend the air bag alert appeared again. Rivian seems unable to fix the issue with the airbags on my vehicle creating a significant safety concern.

The horn is far to quiet to be heard by other drivers. This creates a dangerous situation in many common circumstances on the road and highway.

I pulled into my semicircle, long driveway as I do every morning, and stopped at the top by releasing my foot off the accelerator (no need for brakes as it is an EV). I opened the garage door and slowly stepped on the accelerator, but it started to go fast, and I felt out of control. I immediately released my foot off the accelerator (which should have stopped the vehicle) and slammed on the brakes (there is proof in my driveway with tire marks leading up to the accident) but still did not stop. I quickly realized I was going to crash into the garage, and possibly into the house, so I steered away as much as I could to only drive into and through the side of the garage wall. The space I had would have given me enough time to stop had the car not been driving at a fast speed. Even the neighbors heard braking and ran outside to see what was happening. There is a recording on a ring cam, and you can hear him say "I heard brakes". Oddly, the massive impact did not deploy the airbags. Also, the car usually records all incidents with time before and after (it has successfully done this before when I was rear ended and will if you get too close to anything), but for some reason it recorded what was labeled "incident" and you can only see me pulling into the driveway, the garage door going up, and then the video stops - no record of the crash. The car should have also detected the house. The car only stopped after driving through concrete and stucco, and up the stairs. House has mass

Front driver wheel had a hub bolt back out rendering the vehicle unable to drive. The car made a loud grinding noise and was unsteady. I had to pull over and was unable to drive any further. It required replacement of the hub bolt and axel. This is a known problem for rivian's and has not been addressed or checked. I reported a grinding sound when I turn 2 months ago and was told that the soonest Rivian could service my car was 2 months away. This known problem and complaint should have flaggged an immediate intervention and this needs a recall.

Front passenger airbag is inactive for long periods of time while a passenger is seated in the vehicle during operation. This is indicated by the message displaying the airbag as being off. This occurs regularly with an adult seated normally in the seat while traveling at highway speeds, for long periods of time. I reported this to Rivian and they said the car is functioning normally but it does not seem safe that the airbag is turned off with a passenger present in the vehicle during operation. I am listing the latest incident date here but this has been persistent since I purchased the car new in 2023.

I am experiencing an ongoing and unresolved steering column defect in my 2023 Rivian R1S, which creates a serious safety risk while driving. Issue Details: The steering wheel drops unexpectedly when weight is applied, even lightly. This occurs both while the vehicle is stationary and while driving, including when hitting small bumps in the road. The issue compromises steering stability and could lead to a loss of vehicle control. Repair Attempts & Rivian’s Response: I have taken the vehicle to Rivian Service Centers four times for this issue. Rivian has replaced the steering column three times (May 2024, July 2024, January 2025), but the issue persists. Rivian has now claimed this is a "normal characteristic" of the vehicle, despite previously acknowledging it as a defect and attempting multiple fixes. I requested a written statement regarding their refusal to fix the issue further, but they have not responded. Safety Concern: My father currently drives the vehicle, and I am deeply concerned that the steering column could fail while he is driving, leading to an accident. The steering instability may cause loss of control, particularly at higher speeds or in emergency maneuvers. Rivian’s failure to fix this issue despite multiple repair attempts indicates a potential systemic defect that could affect other Rivian R1S vehicles. Requested Action: I am filing this complaint to document this safety hazard and request that the NHTSA investigate whether this defect affects other Riv

The sensitivity of the airbag sensor on the passenger seat is not functioning properly in my opinion. there are times when there is a passenger present and seated, the car is showing that the passenger airbag is off. I took the car to Rivian service center. They indicated that they could not replicate the problem and that to make sure the passengers are over 110 lbs. They also noted that with future software update, they may make it better, which indicates to me that they know there is a problem. I know for a fact that my passengers have been over 110 lbs.

On our drive back from Yosemite, we began descending from Groveland, CA after leaving the Rivian charging station. Due to heavy rain, the car ahead of me was moving cautiously, limiting my speed to about 20 mph while maintaining a safe distance during the descent to Moccasin, CA. Thanks to the regenerative braking, I didn’t need to apply the brakes, as the car automatically slowed when I wasn’t pressing the throttle. However, my windows started to fog up, so I turned on the defoggers. Shortly after, I noticed the car’s door locks repeatedly unlocking and locking by themselves. As we neared the bottom of the descent, I began to smell something burning from the vents. This prompted me to step on the brake pedal for the first time, but it felt unusually stiff, with little travel. The car didn’t slow down, and the burning smell intensified. I pressed the brake pedal repeatedly, but it felt stuck, and the car did not decelerate. Eventually, I was able to roll to a stop. I pulled over to a side street where the issue persisted. I turned off the defogger and contacted Rivian via SOS. We were able to replicate the brake issue on the side street: as I maneuvered the car, the brake pedal sank on its own when the defogger was on. Once I turned it off, the pedal returned to normal. There were no warning lights or alerts from the car system. When I got out of the car, the burning smell was strong near the front wheels. It was clear that my family’s safety was at risk, including 3 young ch

The passenger seat airbag turns off when a passenger is sitting in the seat. I have taken the vehicle to the service center twice for this issue and they insist it is working as intended. This is a major safety issue for myself and children when we are sitting in the passenger seat. Please help in resolving this!

1> What component or system failed or malfunctioned, and is it available for inspection upon request? * The sensors don't detect the object sometimes. There were 2 incidents when the car sensors did not detect the object a> In my office parking lot the rear sensors did not detect the fire hydrant and did not make the beep noise resulting in a collision. b> I was driving in my neighborhood; I was blinded by the sun and couldn't see the road ahead. Again, the sensors did not detect the car in front i ended up in a collision. 2> How was your safety or the safety of others put at risk? * I had a collision with another car parked by the curbside. Luckily no one was in the other car but both cars had severe damages. I had bruises on my left-hand forearm. 3> Has the problem been reproduced or confirmed by a dealer or independent service center? * When the first incident happened, I was not able to provide Rivian accurate date and time of the incident and the gear guard did not record the collision although it was supposed to record. So I went back to my office parking lot and i reproduced the problem 1 time after trying several attempts and shared the video with Rivian. I have had too many email exchanges with Rivian to help address the issue but they did not help. 4> Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? * When i reported the first-time issue first time, Rivian inspected the sensors on May 29th 2024 and they sa

I purchased my vehicle new from Rivian Automotive in November 2023. My rear tire went flat (to 4 PSI) while driving on the freeway on Dec 11, 2023. There was no warning message on the dash that my tire was even low. The truck kept swerving left and right between the lane markers like the lane assist was malfunctioning. Another driver got my attention to let me know my tire was flat. I had my SUV towed to America's Tire where they confirmed that there were no punctures in the tire and that it was defective. This could have resulted in a serious accident simply because I was not given proper warning about the tire pressure.

One of the bolts that attaches the electric motor to the front wheel (internal, under the vehicle) backed itself out. That seems really dangerous and I am hopeful the condition does not exist on the other wheels. I sent pictures to Rivian and they are taking the vehicle to their service center for further inspection.

Our son no matter how we try and position him his chin is touching his chest and starts to bubble during our car rides in the mesa max. He also seems to overheat in it and comes out sweaty even with the shortest car ride. We contacted the mfg and they told us he was too big for infant inserts and too small in the bucket itself.. and to wrap a dish towel around the crouch buckle to help keep him push back more. We then met with a company rep who added additional padding in the back of the seat to help position him better. None or these “fixes” really seemed to help in my opinion, as he still screams and bubbles when in this seat.

Horn is extremely underpowered and not audible to other drivers at highway speeds in particular. This has not been inspected by Rivian because all R1S vehicles are like this since they removed the second horn that was originally shipped in earlier builds.

What component or system failed or malfunctioned, and is it available for inspection upon request? — ACCELERATOR PEDAL. YES, AVAILABLE FOR INSPECTION. How was your safety or the safety of others put at risk? — DUE TO ACCELERATOR PEDAL DEFECT, IT RESULTED IN ONE CASUALTY AND ONE INJURY. Has the problem been reproduced or confirmed by a dealer or independent service center? — YES, SERVICE RECALLS HAVE BEEN FOR THE SAME ISSUE WITH PRIOR MODELS. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? — CURRENTLY IN POLICE CUSTODY Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? — NO WARNING SIGNS.

I received a critical safety recall regarding side air bags from Rivian regarding my 2023 R1S on June 14. After multiple attempts by me to connect with their Customer Service, I was informed that a mobile service technician would come to fix the issue on August 26, 2024. This would be more than 60 days after Rivian's initial notification. Additionally, on July 6 2024, when I turned on the vehicle, I was notified of multiple system failures. I promptly created an incident ticket with Rivian on this but have to yet hear back from Rivian. Rivian's lax attitude on getting such critical issues fixed is of great concern. The vehicle is barely over a year old since I have owned it and I feel distrustful of this company and thoroughly disappointed by their nonchalant approach to getting these critical issues fixed.

My right front passenger seat does not detect adult occupants reliably, and therefore does not enable the airbags. My wife is approximately 105 pounds and sits in the seat in a standard upright fashion without leaning back. Her legs are not crossed and are just resting on the floor. it is rare that the vehicle detects her presence and therefore she is rarely protected by the safety restraint system in the event of an accident. I brought the vehicle into Rivian Service and they inspected and said the sensor is working properly and is designed to detect occupants roughly 105 to 110 pounds. They said there is nothing that they can do about it. Every other vehicle I currently own and have owned in the past properly detects her presence for the SRS system.

The Rivian is designed to kill fat people. The Airbag for the passenger seat does not function if there is a large person in the seat or the seat is very far forward with a normal person. When someone sits in the passenger seat the lower left corner of the central display changes from “Passenger Airbag Off” to the passenger climate control display. If you pull the seatbelt all the way out the display reverts back to the “Passenger Airbag Off” sign. The seat belt has to retract about 6 inches back into the B pillar for the climate control display to come back on. If the seat belt can’t retract far enough back into the B pillar, you have to drive around with an inoperable passenger seatbelt. I have been able to duplicate this feature on every Rivian I have tried it on. This has been reported to Rivian. A mechanic was sent to my house to repair this. It couldn’t be repaired as expected. I was told the problem would be elevated to a safety issue and sent to engineering. That was in the beginning of February 2024. No answers or fix yet. I have video of the problem, but mp4 files are not accepted below. Please contact me if you would like video.

The passenger side airbag shows that it is turned off about 50% of the time that my wife is riding in the passenger seat. She meets the minimum weight requirement for passenger airbag deployment. If she moves around in the seat the airbag off light will go out temporarily but usually comes back on within several miles of driving. This vehicle is available for inspection. When this happens my wife or any other passenger is at risk of not having an airbag if an accident was to occur. This issues has been looked at several times by the manufacturer and I was told that the vehicle is operating as intended. No resonable solution was offered. The only solution from the manufacturer was to have the passenger move around or adjust the seat until the airbag came on. Then have the passenger stay in that position for the duration of the ride. We’ve tried this and it doesn’t work the airbag still turns off.

The contact owns a 2023 Rivian R1S. The contact stated that while the vehicle was parked in the driveway, there was a shadow on the middle console. The contact stated that when the driver's door was opened, there was a crack in the sunroof. The contact stated that there was no impact that could have caused the crack. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 1,100.

Since the vehicle was new, I have had a problem with the air bag being off when a large person is in the passenger seat. I have reported this to Rivian. Rivian has sent a technician out to fix this. The technician indicated that he could not fix this as planned and would submit it to engineering as a safety issue. I have made multiple inquiries since then and received no information on when this will be resolved. I have also had 3 software updates since then and the problem has not been resolved. I have been able to duplicate the problem on another R1S. If you sit in the passenger seat the passenger climate controls will become available. If you pull the seatbelt all the way out of the B pillar, the passenger climate control will go away and you will get the passenger airbag off notification. If the seatbelt can go back into the B pillar about 8 inches, the climate control setting will return. If you are a large person or have the seat forward and the seatbelt can't retract that far, you are passenger without airbag protection.

My wife does not shows up as a passenger in the front seat about 30% of the time with the seatbelt fastened. She is 105~108 lbs. This is a continuing problem with no fix in sight. Not registering when seated means two key things: 1) no airbag support in case of an accident 2) passenger side climate control doesn't function separately from synced mode. After multiple attempt with the Rivian service center/mobile service, all they can only say that it's within spec. Rivian SC staffs say that SW fix is coming. That was 4 over the air firmware updates ago. Unfortunately the problem is so small in terms of affected population, they have done nothing to date.

Passenger occupancy system seems flaky when my fiance sits in the passenger seat - sometime it takes 30 seconds to register she is there, sometimes it goes off while we are driving if she makes slight adjustments in the seat (while sitting straight and not in any awkward position), which can be dangerous if we were in a near crash situation, her weight shifted causing the airbag not to deploy. Although she is on a smaller side (5’5’’ 110lb) we never had this issue with any car we owned or rented.

Every time my wife gets into the front passenger seat the sensor in the seat doesn’t recognize her sitting down and doesn’t active the passenger side airbag also the climate control is inactive. Rivian claims that there is a seat weight limit but my wife weighs 145 lbs. this happens all the time until my wife moves around enough to activate it. Then sometimes it turns off in the middle of a drive as if there wasn’t a passenger in that seat. This has also occurred with some heavier passengers. Rivian claims nothing wrong with the vehicle. I took delivery at the end of October and the problem still continues.

Longstanding issue with R1S and R1T’s not recognizing a front passenger is present. Many reports in online forums regarding the same problem and ours does not even see a 6’4” 450lb passenger regularly. Other complainants are reporting feedback that it’s ‘within spec’, ‘it’s safer for smaller passengers’, and that ‘you need to sit in the seat properly’(?!). Please do something about this serious safety issue. Thanks.

(1) Q: What component or system failed or malfunctioned, and is it available for inspection upon request? A: "Critical Battery Issue" + "Electrical Hazard Possible; Drive to service center immediately. Avoid driving through water" + "Coming to emergency stop soon; Steer to safety and park" (2) Q: How was your safety or the safety of others put at risk? A: (1) The car abruptly stopped near a corner in middle of street blocking the street, police had to intervene with traffic *potential for collision/pedestrian strike (2) The car had no electrical, completely blacked out and HAZARD lights didn't work when Police asked to turn them on, nothing would turn on **potential for collision (3) Car was blacked out with all windows down, doors unlocked and unable to get into compartments of vehicle to remove personal items of value due to all electrical being backed out *potential safety / theft concern Police ended up towing due to Rivian being unable to locate a tow in a timely manner the incident occurred at 4:30pm and Police politely waited for Rivian until her 6:30 and then called their local tow yard for secure space for unresponsive unit blocking street (3) Q: Has the problem been reproduced or confirmed by a dealer or independent service center? A: Not sure - It took Rivian until 11:30am the next day to coordinate a pick up from local tow yard where Police mandated tow due to Rivian being unable to clear a hazard blocking the street (4) Q: Has the vehicle or component been inspec

Horn is too weak and inaudible when there’s other noise around or if someone is listening to music in their car. Other vehicles don’t seem to hear the horn in case of emergencies.

The passenger airbag does not consistently turn on or stay on with passengers in the seat.

The system does not turn on the airbags for driver or passenger under 140 pounds. This is a safety hazard.

The passenger seat doesn’t recognize a passenger in the seat. Happpens all the time for my wife, who ways 120lbs… there are hundreds of folks who also have this problem with the Rivian passenger seat/driver seats. Huge safety issue.

Intermittently does not register a passenger in the passenger seat (even with a seatbelt on and seat upright in a normal position) such that the airbags are turned off and climate controls are not activated. Passenger weighs more than 120 lbs.

A passenger of lighter weight will not trigger the passenger seat’s weight sensor, rendering the passenger side airbag disabled. The passenger must sit up perfectly straight and center their weight on the center of the seat for them to be properly detected. A service center visit claimed the seats are working as designed, but there is clearly an issue.

Vehicle routinely (>90% of the time) fails to detect occupancy of front passenger seat resulting in disabled airbags and other related safety systems. Our particular vehicle experiences the issue with passengers ranging from 150-425lbs resulting in a significant safety concern. Searching online indicates this is a common issue and repair requests are routinely denied with claims that it is operating correctly. Others have been told it is due to posture or seating position…I’ve never had a vehicle whose safety features were disabled due to poor posture?!