2022 Rivian R1s

Defect. Rivian Automotive, LLC (Rivian) is recalling certain 2022-2025 R1T and 2022-2026 R1S vehicles. The bolts that secure the second-row driver and passenger side seat belt retractor assemblies may be improperly tightened.

Risk. An improperly secured seat belt retractor may not adequately restrain the seat occupant, increasing the risk of injury during a crash.

Remedy. Rivian will inspect and tighten the bolts as necessary, free of charge. Owner notification letters were mailed March 2, 2026. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1795.

Defect. Rivian Automotive, LLC (Rivian) is recalling certain 2022-2025 R1S and R1T vehicles that previously had service performed. The toe link may have been reassembled incorrectly during service procedures performed before March 10, 2025.

Risk. The toe link joint may separate, increasing the risk of a crash.

Remedy. Rivian will replace the rear toe link bolts, free of charge. Owner notification letters were mailed February 17, 2026. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1794. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning February 24, 2026.

Defect. Rivian Automotive, LLC (Rivian) is recalling certain 2022-2025 R1T and R1S vehicles. The D-ring bolts for one or both front seat belt anchorage assemblies may not have been properly installed.

Risk. An improperly secured seat belt may not restrain an occupant as intended, increasing the risk of injury during a crash.

Remedy. Rivian will inspect and properly secure the seat belt anchorage assemblies as necessary, free of charge. Owner notification letters were mailed July 8, 2025. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1681.

Defect. Rivian Automotive, LLC. (Rivian) is recalling certain 2022-2023 R1S and R1T vehicles. The maximum vehicle capacity weight value on the tire placard label is incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."

Risk. A vehicle with an incorrect maximum capacity weight value may be overloaded, which can increase the risk of a crash.

Remedy. Rivian will mail owners a corrected overlay tire placard label, free of charge. Owner notification letters were mailed August 8, 2024. Owners may contact Rivian customer service at 1-888-748-4264. Rivian's number for this recall is FSAM-1491.

Defect. Rivian Automotive, LLC (Rivian) is recalling certain 2022-2024 R1T and R1S vehicles. The attachment clips on the upper B-pillar and/or C-pillar trim panels may have been damaged during a service procedure.

Risk. Damaged pillar trim panel clips can result in improper side curtain air bag deployment, increasing the risk of injury during a crash.

Remedy. Rivian will replace the pillar trim panels, free of charge. Owner notification letters were mailed July 16, 2024. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM 1464.

Defect. Rivian Automotive, LLC (Rivian) is recalling certain 2022 R1T and R1S vehicles. The accelerator pedal may not detect when the driver releases the pedal, failing to activate "auto-hold" or "park" as intended.

Risk. Failure to activate "auto-hold" or "park" can result in unintended vehicle movement, increasing the risk of a crash.

Remedy. Rivian has released an over-the-air (OTA) software update. Rivian will also replace the accelerator pedals, free of charge. Owner notification letters were mailed January 18, 2024. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM 1342.

Defect. Rivian Automotive, LLC (Rivian) is recalling certain 2022-2023 R1T and R1S vehicles. A software update may have deactivated the defroster and defogger system controls.

Risk. The inability to operate the windshield defrosting and defogging system can decrease the driver's visibility, increasing the risk of a crash.

Remedy. Rivian has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed December 21, 2023. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1331.

Defect. Rivian Automotive, LLC (Rivian) is recalling certain 2022-2023 R1S vehicles. The reverse light beam may not be visible from certain angles. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Risk. Reduced visibility of the reverse lights increases the risk of a crash.

Remedy. Rivian will repair or replace the reverse lights, free of charge. Owner notification letters were mailed July 12, 2023. Owners may contact Rivian customer service at 1-855-748-4265. Rivian's number for this recall is FSAM-1216.

Defect. Rivian Automotive, LLC (Rivian) is recalling certain 2022-2023 R1S vehicles. The fasteners that secure the right and left side curtain air bags may be improperly secured.

Risk. Improperly secured side curtain air bags may not perform as intended, increasing the risk of injury during a crash.

Remedy. Dealers will secure or replace the side curtain air bags as necessary, free of charge. All owners have been notified and all vehicles will be repaired by March 15, 2023. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1185.

Defect. Rivian Automotive, LLC (Rivian) is recalling certain 2022 R1T and R1S vehicles. A faulty automatic locking retractor (ALR) sensor in the front passenger seat belt system may incorrectly report as ON when it is actually OFF, causing the suppression or improper deployment of the air bag. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk. Failure of the air bag to deploy as intended increases the risk of injury to the front passenger during a crash.

Remedy. Dealers will inspect and replace the front passenger seat belt system components as necessary, free of charge. Owner notification letters were mailed April 5, 2023. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1166.

Vehicle was inoperable and over 100F in our driveway, with a flashing "critical high voltage battery fault". My wife injured her hand attempting to get in the vehicle. The service center has claimed that moisture inside the HVAC system caused the High Voltage (HV) battery system to fail, throwing a critical high-voltage battery fault. Rivian is attempting to deny warranty coverage based on this moisture. Linkage to Warranted Component: At 85,690 miles, my vehicle is fully covered under Rivian’s 8-year High Voltage Battery Limited Warranty. The critical high-voltage fault and subsequent component failures were directly caused by water entering the electrical/battery system. Proximate Cause via Known Manufacturing Defect: Rivian has an active Technical Service Bulletin (TSB) regarding moisture ingress via the HVAC assembly for 2022–2024 R1S models. The moisture that caused the battery fault is a documented, inherent design defect of the vehicle, not user negligence or external environmental damage. An inherent defect in an out-of-warranty system cannot be used to void coverage for a failure it causes inside a component that is still heavily protected by an active warranty. The photograph provided by the service center does not depict superficial 'moisture in the HVAC' causing external damage. It shows severe fluid ingress and terminal corrosion inside the Woory Industrial High Voltage Cabin Heater assembly. Because this is an internal, high-voltage powertrain component operatin

All sensors failed. Once vehicle was parked completely and seatbelt was removed, the car automatically took off. It began accelerating on its own, full throttle (Rivian logs were retrieved to show this), then began crashing into multiple cars while still gaining speed. Logs also show that the breaks were applied during this time, but the accelerator was still engaged at full throttle. The car then launched itself into a light post. The car was able to clear the 2-3ft concrete base of the post and the metal beam crashed into the glass roof of the car (which was shattered and thankfully the surfboard racks prevented it from fully crashing into the vehicle - but the racks are completely crushed), the metal post then launched itself into two more vehicles as well as the car itself. Airbag was not deployed at any point, car was going over 30 mph when it finally stopped (the concrete base likely pierced the battery to make the car stop). Logs didn't even note that there was a crash and the vehicle is totaled. We have salvage holding off on destruction so that the EDR can be salvaged and retrieved.

In the R1S, there is a crossmember for the 3rd row seating. On low VIN vehicles, there appears to be a trend, including mine personally, that have crossmember bolts that were mis-installed during assembly and have disconnected the threaded inserts from the body and remain unscrewed and loose. This is a primary mounting point used to secure the seating in the vehicle. The service center confirmed that this has occurred and a video was provided to Rivian when requesting repair. (This video is no longer accessible in the app) Rivian's stance is that contrary to online reports of similar issues on low VIN R1S vehicles and mine, this is caused by the end user. Given the number of occurrences, this appears to be a faulty installation issue from unskilled labor.

Passenger airbag sensor does not detect passenger reliably. My 13 year old son and my wife both have issues. They are both over 120 lbs, so I think they should trigger the sensor. I have had it serviced for this issue, but it did not fix the problem. It also will detect a person in the seat during a drive and turn off later in that same trip without stopping the car. It seems to me that the sensor needs to be more sensitive. And, once it detects a person in the seat, it should keep the airbag on until the car is stopped and door opened. My wife does not feel safe in the car as it stands now.

When I am driving, my passenger sometimes does not trigger the airbag to activate. Depending on how they are sitting, many times the passenger airbag is set to "off" because it can not detect a passenger. The Rivian service center has investigated and mentioned there is no problem and that the passenger needs to sit more upright, but this still seems like a safety issue if we are driving and fail to notice that the passenger airbag is not activated

On Monday, December 11, 2023 Myself, my girlfriend, and our two dogs were headed across the I-182 bridge coming out of Pasco, WA to Richland, WA. We were in the far left or center lane (I am not sure which). The highway is three lanes each way. We were at highway speed (the speed limit is 70 mph). About ¾ of the way across the bridge, the vehicle felt like all 4 wheels locked. The vehicle then skidded, turned 90 degree towards the concrete bridge barrier. We struck the bridge barrier nearly head on. The vehicle then rotated off the barrier and landed upright in the far right lane. Airbags fully deployed. There were numerous witnesses who reported seeing what looked like the vehicle’s wheels lock and then the events as described. No other cars were impacted. About 20 minutes prior to the crash I commented that the vehicle alignment was off. I had to keep the wheel at 10:00 or 11:00 for the vehicle to travel straight. I found that odd as the vehicle alignment was fine prior to that. Everyone walked away from the accident although both us were injured.