2017 Ram 3500 complaints

ABS module is bad. Didn’t last long and shut cruise control off. And makes hard to brake with trailers

ABS Module/HCU replaced 3 times defective yet again. This is a safety issue because Anti-lock brakes, traction control, and cruise control do not work

My abs and traction control lights come on and electronic brake service messages along with the chime Had the truck scanned by a personal mechanic and the abs pump is not working

Replace abs module code

The truck had a recall done on its steering system. The steering part affected is the drag link. The drag link connects to the steering wheel to the tie rod . The recall fix was to weld the drag link jam nuts so they wouldn't come loose and cause a steering loss. Since the recall the vehicle s drag link can't be aligned correctly with the tie rod the drag link is attached to the steering wheel so when the truck is aligned it backs one side out to far to keep the steering wheel straight. This drag link that was recalled is a (safety issue) it's a bad design and causes the vehicle to sway all over the road and if it fails the truck looses all steering and goes where ever it wants to go Wich will cause a horrible accident and harm innocent family's on the highway including my own family it can lead to the death of people in my vehicle and around my vehicle it's a serious safety issue and a horrible recall fix on rams end. I have a appointment at the ram dealership to get new tires on but I don't want the new tires put on until this issue is fixed as the truck needs alignment and this safety issue aka the welded drag link replaced with the correct fix that the new rams have the new style drag link . It's a safety hazard. And innocent people can get hurt by the horrible recall fix. It's in acceptable. And very unsafe it's hard to keep the truck in a straight line on the roads it's all over the place like a drunk driver .

Check engine light came on. Got a code C0020-01. abs pump motor control. Opon further research I found out this is a common issue and I was told to report it to nhtsa for there investigation. I did not have it fixed yet.

Third time the ABS module has been replaced in 29,000 miles. Took months for our dealer to acquire the part. Second one with the "AB" suffix. Truck only used for livestock towing hence the low mileage. When the ABS-STC go out the warning indicators come on along with a "Service Electronic Braking" system message. When this occurs, not only are the two mandated important safety systems inoperative, four wheel drive wont engage. I don't use cruise control but hundreds of reports state it also is inoperative. Why is Stellantis and NHTSA dragging their feet on getting this issue resolved and recalled once and for all. Not having Anti Lock Brakes and Stability Control are dangerous. I don't get it.

Abs and traction control lights come on, simultaneously canceling cruise control. Vehicle speed immediately slows, and traffic behind me catches up quickly as it takes a few seconds to react and get the vehicle back up to speed. Also, no abs in wet condition, etc. Bumps in the road cause the system to go out and come back on. It's become such a problem that I've had to pull the fuse for abs, which means no more cruise control. But also activates the red brake warning light. So if another problem comes up, I won't know as the brake light is already on.

Beginning in 2018, the ABS system will stop working intermittently and a number of trouble lights will come on, such as "Service ABS system" and, at the same time the cruise control and 4 wheel drive will stop working. I took it to a dealer while still under warranty and they claimed the ABS system was fine, and they could find no problem with the ABS, which had to be a lie since a code would certainly have shown up. I will go months without a problem then it will start intermittently going out for weeks at a time. This happened once in a snow storm near Denver, CO and I nearly went into the ditch because the 4wd suddenly stopped working. My research shows this is a common and serious problem with the 2017 and 2018 Rams and the manufacturer is well aware of the defective HCU that causes this safety issue. It needs to be repaired in a recall. An OBT scan shows that the ABS control unit intermittently suffers a "complete electrical failure" in the hydraulic control unit of the ABS.

The contact owns a 2017 Ram 3500. The contact stated while driving 40-45 MPH, the vehicle started shuddering. An unknown warning light was illuminated. The contact continued driving uphill and the vehicle stalled. The vehicle failed to restart. The contact was able to push the vehicle to the side of the road with assistance. The vehicle was towed to an independent mechanic, where it diagnosed that the emission control system had failed. The mechanic replaced the EGR cooler, the EGR valve and the temperature sensor. Additionally, the mechanic performed other unknow repairs. The vehicle was repaired out-of-pocket. The local dealer was notified of the failure. The contact stated that she had received an unknown recall notification related to the failure. The manufacturer was contacted for reimbursement; however, the reimbursement claim was denied. The manufacturer was notified of the failure. The failure mileage was unknown.

The contact owns a 2017 Ram 3500. The contact stated while driving approximately 10 MPH and coming to a stop, the brake pedal felt abnormally loose, causing the braking distance to be extended. The ABS and traction control warning lights were illuminated. The vehicle was taken to a local dealer where it was diagnosed that the ABS control sensor and ABS control module needed to be replaced. The vehicle was repaired. The contact stated that several weeks later the message "Trailer Brake Connected - Go to Vehicle Settings - Check Vehicle Wiring" was temporarily displayed. The manufacturer was made aware of the failure, but no assistance was provided. The failure mileage was approximately 26,000.

Tire Size: LT235/80R17. Tire installed [XXX]. Tire Dated Stamp: 4619. Mileage on tire: Approx 23K. Vehicle: 2017 Ram 3500 Laramie Longhorn Dually w/6.7L Diesel. Road Surface: Smooth. Hazards: none. Weather Condition: Excellent. Front right tire blow out occurred on [XXX] approx 10 miles east of Leesville LA. No indication of tire failure prior to blow out. Initial tire inflation was 80 PSI. Approx $8k damage to front right fender area. Front tires were rotated and balanced annually. Vehicle was traveling at 65MPH pulling a 20 ft empty cargo trailer. Contacted Goodyear and shipped them the tire for analysis, Goodyear File #[XXX]. Goodyear stated: "Tire condition occurred dure to an impact causing overdeflection of the tire and a fracture of the steel belt package, and/or fabric piles and/or line. No workmanship or material related condition contributed to the initial air loss." I have the tire in question. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Heading down a mountain grade on [XXX] came around a turn on the down grade and all the sudden warning lights starting going off. Tried braking harder but almost no brakes on the pickup. Managed to press the emergency brake, thankfully we were going at a slow enough speed. So many messages on the dash that I was having trouble getting to the trailer brakes to increase the gain so I could use them to help us get stopped. How was my safety and my Wife's at risk, brake failure on a mountain grade could have been bad. Taking it to a Ram Dealer on Tuesday, June 25,2024 in Hanover, PA. I was told by a mechanic that he scanned the system and pulled Code C0020. Was also told probably Hydraulic Control Unit or ABS Control Unit failure which is a common problem. At the time of the incident here are the warning lights and messages : Service Electronic Braking System, service abs, service trailer brakes. service rear park sensors, traction control disabled & trailer brakes disconnected ( had to unplug and replug to get back). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Warning lights for ABS and anti skid lights on intermittently

The abs control module and pump has been going out for the last 4 years with intermittent alarm every 30-44seconds. Every time I call dodge dealer the part is on back order for 4 years now I finally found a remanufactured one on eBay. This is a serious problem, very unsafe and I have talked to a lot of people with dodge ram trucks 2017-2018 that have the same issues and a couple people that have had bad accidents they believe is because now no traction control. Dodge needs to be held accountable for the parts they put in the truck and for not having a replacement ready to go.

I've been waiting for replacement parts for Technical Service Bulletin S2005000004 for over 8 months. It's my understanding from the dealer I visited that I could have a complete failure of electronics and/or brakes. Many warning lights and warning messages are displayed on the dashboard. Dodge has not issued a recall. I've been towing an 18,000lb RV around the country off and on for a number of years and was never made aware of this danger.

The service emergency braking system warning randomly goes off. Some times it will go in the morning or maybe while driving. Might beep at me for a few minutes and then goes away

Service abs system. Had repaired but now came back. Abs control module No parts available national backorder ram needs to address this and fix my truck for free.

ABS warning lights lights keeps intermitting keeps going on and off. The ABS light and traction control lights flashes on and off, speed control goes off as well as a bell alarm. Had the ABS pump replaced under warranty at 22000 miles and now at 59000 mile same issues.

The ABS System has failed twice since i have owned this vehicle. The first time on [XXX] 2022. I brought the vehicle in for repair at Victory Ram in Shallotte, NC. They replaced the ABS Module and it failed again in January of 2024. This part is not available now so I must wait for a new part to be designed. I am driving this vehicle with a malfunctioning ABS System. I believe this should be a recall as it is a safety hazard and an expensive repair that the consumer should not be responsible for. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My truck has 22,780 miles on it. This truck is currently in the shop having the Fifth ABS Module, ABS Control and ABS Hydraulic unit. The First time that this occurred was on 11/26/2018, 6,199 miles. I had owned the truck 16 months at this time. The Second time was on 7/6/2020, 11,982 miles (They called it an Axel Actuator this time, but it was the same error message on the dash panel as before). The Third time was on 12/14/2020, 14,930 miles. The dealer waved the deductible charges, this time, since the truck was just out of the regular warranty and this was an ongoing problem. The Fourth time was on 1/19/2024, 21,348 miles. Again, having to use extended warranty and pay the deductible. It's currently in the shop being repaired for the Fifth time for the same problem, 5/6/2024, 22,780 miles, Not even 4 months and less than 1,500 miles since the previous repair. The Dealer also said that the Brake Pedal sensor is bad this time in addition to all of the ABS parts. Once again, having to use extended warranty and pay the deductible. If I count the original ABS Equipment, this will make the Sixth ABS Equipment that has been on my truck. This is a MAJOR Safety issue due to the fact that I pull a 15,000 lb. fifth wheel RV and often times I have to come down mountains after it has failed. The Dealer has said that this an ongoing problem with the Ram 3500 & 2500 trucks. I have never had any vehicle in my entire life that has had an ABS problem, let alone this many times. Something ne

The contact owns a 2017 Ram 3500. The contact stated while the vehicle was undergoing DOT inspection, the DOT inspector advised the contact to shift in neutral (N), and to activate and squeeze the brake controller manually. The contact was then advised to shift into drive (D) and to release the brake pedal while squeezing the brake controller. The contact stated that upon following the instructions, the vehicle moved forward. The DOT inspector determined that the brake controller was malfunctioning because the trailer brakes failed to prevent vehicle movement when manually activated. The contact stated that the company's mechanic replaced the 7-way pins, the 7-way pin trailer cable, the 7-way pin wiring harness box, and module, the brake controller assembly, the wiring on the front and rear axles, the brake assemblies; however, the failure persisted. The contact stated that when the brake controller was set at the max 10, the brake wire connector displayed 6.5 Volts, while the voltage should be 13.2 Volts. The dealer and the manufacturer were not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 162,388.

I purchased a 2017 RAM 3500 in 2018 brand new, directly from a dealer. Within the first week of ownership, truck started alerting me that there is an issue with the automatic brakes and to service the vehicle. I took the truck to my local dealer in October 2018. They confirmed issue was with the ABS system. I was told to take a rental car because it would take some time to get the parts and I wouldn’t be allowed to take my truck because it wouldn’t be safe to drive. The parts came in after some time and the truck was repaired. Almost 24 months later (September 2020), the same ABS alerts began presenting itself. The dealer confirmed that the issue was again the ABS system and I was provided with a rental car until the part was replaced. Again, 24 months later (October 2022), the ABS alerts began to persistently display and make a chime many times over and over while driving. The dealer once again confirmed the ABS was at fault and ordered parts. I was told there were no parts available and to expect several months before the truck could be serviced. This time, the dealer would not provide a rental because the truck was not considered under warranty. Six months passed (March 2023) and the dealer called to report that a part had arrived and to bring the truck for service. The dealer later called and said when the box was opened, the part appeared damaged and could not be used and to wait for another part. I waited another 5 months (August 2023) to call the dealer and ask if any

The anti lock brake controller is failing and keeps the traction controller and cruise control from working properly.

Issue with reoccurring Electronic Brake System Failure message along with ABS and Stability Control faults. This is now the third time this error has appeared. Twice they replaced both the ABS controller and hydraulic unit.

On Cummins Diesel Engine installed on this vehicle, On the Intake Air Heater assembly, there is a nut/bolt that has voltage applied to it to heat incoming air, this bolt/nut can melt and then eventually drop into #6 cylinder which will damage engine and possibly freeze/stop engine while driving thereby creates a safety hazard while driving. In my case engine warning light came on before the bolt dropped into cylinder and was repaired before damage occurred. Also see the following Utube link for video on issue. [XXX] Dodge Ram needs to recall these vehicles to check and repair this, also to redesign it so that it can't happen INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2017 Ram 3500. The contact stated that while driving at unknown speeds, the ABS and traction control warning lights were flashing and turning on and off. The contact was unable to haul a trailer. The vehicle was taken to the local dealer, where it was diagnosed that the ABS module needed to be replaced. The vehicle was repaired under warranty. The vehicle was taken to the local dealer, Checkered Flag Chrysler Dodge Jeep Ram (12629 Jefferson Ave., Newport News, VA 23602), where it was diagnosed that the hydraulic assembly and ABS needed to be replaced. The vehicle was repaired, but the failure recurred. The vehicle was taken to an independent mechanic, who informed the contact that the traction control module and ABS needed to be replaced. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 29,000.

Driving 2017 Ram 3500 ABS light and traction control light. Problem with Hyrdraulic control unit and ABS control module. No parts available for repair. No accident report ABS problem condition that can't be fixed

The abs brake warning light and the traction control light goes on and off constantly. a "warning beep also goes on. this has been going on for over a year. we have been told it is under "engineering review". we have been trying to get a fix but keep being told part is on backorder. have called ND texted Ram multiple times and they refuse to do anything. This is a break problem-not an insignificant safety problem. is therr anything you can do about this?

Potential Grid Heater defect that can cause major engine failure and/or fire. The bolt connecting the Heater Grid to the intake plenum can heat up and break off, fall into the intake, and get pulled into a cylinder causing major damage.

ABS light came on at 13,000 miles and was repaired under warranty. At 27,000 miles (2.5 years later), ABS has failed again, code C-020, but vehicle is out of warranty. Contacted FCA and was told "sorry, its out of warranty, pay for it yourself and keep your receipts, just in case it goes to recall". This is a know safety issue as cruise control and traction control are also tied to the ABS. Driver distraction should also be mentioned due to the entirely random but frequent chimes going off due to ABS failure. When the truck was "repaired" the first time, the bad parts were replaced with identical parts, i.e. not a redesigned, more dependable part, but the same poor design as stock.

ABS control module has failed and is not available from the dealer,this is a known problem on 2017 and 2018 model year ,Part number 68347098AA, been told this will not be available untill 08/2024 at the earliest, there is a nation wide back order for a replacement part.

This issue is related to 2017 Ram 3500 truck with 6.7L Turbo Diesel motor: The warning lights for the ABS and the Cruise Control intermittently activate and there is an audible alarm ding noise along with them. This ABS warning light going off intermittently indicates that if a situation arises that requires the ABS system, it may not activate as designed. Which in turn could contribute to loss of control or accident with the vehicle. This problem has been confirmed by Villa Rica Auto in Villa Rica, GA. This vehicle has been inspected by Villa Rica Auto. They advised that the problem is with a defective HCU and that part is on back order with no ETA available. This problem first appeared a few days after buying the truck from Gravity Autos Atlanta. This truck was not involved in a crash.

Truck broke engine while driving in downtown Atlanta, GA towing a trailer. After having a certified diesel mechanic diagnose the problem, it was discovered that the grid heater has malfunctioned causing it to melt a bolt and break off into the engine thus causing a total engine loss. After researching online and speaking with the mechanic, this is apparently a common problem that we were unaware of. Had we been informed, we could have been proactive in preserving the engine. What could have been a pretty cheap fix has turned into a $15-$20k dollar repair job and could’ve ended with us in a wreck had we not been able to exit the road in time. I’m aware that there are no current recalls on this particular VIN. However, I would like for you to investigate the problem further because it could save consumers a lot of money and possibly their life.

ABS brake warning lights are on and cruise control will not work. I was told by the dealer the module had to be replaced. This truck only has 34691 miles on it now and this problem started over a year ago. Dealer said this part was not available because of supply chain issues. I have several friends with the same 2017 or 18 truck and are having the same issue. Obviously this is a defective part and is a significant safety concern being the brake system on a heavy truck

The ABS and traction control lights keep chiming and flashing. This condition disables the cruise control as well and possibly the 4WD system. Parts aren’t available at this time from the dealership and after doing research, this seems to be a very common problem with the 2017-2018 Ram 2500/3500 models.

ABS or EBS warning light. Dealer unable to resolve.

ABS unit is malfunctioning for the third time on the truck. The dealer has already replacement it twice but it keeps beeping for notification and flashing the ABS indicator. The Hydraulic Control Unit doesn't work, because of this I can't use Cruise Control or the 4x4 component of the truck. The Traction Control System light is on making it difficult to break properly in wet surfaces. There are thousands of people waiting for the replacement of the ABS unit, due to the 2017 and 2018 models having this issue.

ABS Module and traction control do not work. Cruise control does not work. The ABS and traction control continually blink on and off. Was told that there is no replacement part for the ABS module and that is it unavailable indefinitely.

ABS control module has failed part number 68347098AA this part has been on back order for over a year dealers do not have a firm date on the delivery, This is a safety issue that dealers can not repair.

Abs and traction control lights come on and off at intermittent times while driving, cruise control is lost when these lights come on, this has been an on going problem for about a year now but is a near constant every time I drive now starting about November 2023.

Grid heater bolt failure. Vehicle is currently located at the dealership and the is labeled “Do not start”. Part of the grid heater bolt can fall into vehicle intake and cause catastrophic engine failure. Check engine light came on after bolt failure. This has been a known issue but nothing has been done to resolve it.

Service antilock brake system. This problem appeared about one year and a half ago, I took it to the Dodge dealership where after diagnosis, they replaced a valve in the hydraulic system. the cost of the repair was, $800.00. Now as of 12/28/2023, I am having the same problem with the same code and dash brake light and stability control. We need a recall, which will repair these problems, or redesign the parts associated with this system. Now, I am driving a vehicle that is probably unsafe to use. The vehicle is a 2017 Dodge Ram 3500 6.4 liter engine, SRW. Thank you

Abs failed 2nd time less than 10000 miles after first failure. First failure just before 36000 miles repaired under warranty. 2nd failure just before 46000 miles. No parts available est for repair $1000 to $2000 dollars. Truck now has 52869 on odometer. Failure affects cruise control, and maybe trailer brakes and traction control

I am getting the C-0020-01 ABS code. The ABS module and HCU have been replaced and have failed again. This is making the vehicle dangerous to stop in damp conditions.

The ABS module/HCU has failed again. I originally failed in August of 2021, it was replaced with mopar OEM parts, it has now failed again.

On many occasions, the backup camera on my 2017 Ram 3500 DOES NOT FUNCTION when placed in reverse. I had my vehicle serviced and the Dealer said no problem with the camera could be found, but they did check all of the connectors were OK. The problem usually happens on wet or high humidity days, but also occurs during nice weather at random times. When the problem occurs, the display just shows random scrambled signal like a TV tuned to a channel with no signal. I noticed a recall that does not affect my model year. I am curious if the recall can be extended to my model year. The campaign for backup cameras is 23V654.

Vehicle alarms indicating loss of anti-lock and traction control systems. Failure results in loss of both anti-lock braking and traction control safety functions Have twice had the ABS control module and Hydraulic Control unit replaced by Ram dealer. Failure returned for third time in July 2023, and have been waiting on same replacement parts since (manufacturer backorder). Vehicle has approximately 83k miles, and this issue has been ongoing since 2019.

2017 Ram 3500 intermittently displayed service anti-lock brake system and service electronic braking system notifications on the dash display while parked and driving. A local dealer diagnosed the fault it as an ABS hydraulic controller/pump failure and stated the replacement part is on backorder with an unknown timeline for arrival. They have informed me that the truck may not perform braking safety functions as intended and advised I should not drive the vehicle until the problem has been corrected.

Abs lights keep going off.