2020 Ram 1500 complaints

I own a 2020 RAM 1500 Big Horn 4WD with the 5.7L HEMI eTorque system. The vehicle began making a whining noise while running. A certified diagnosis confirmed the failure of the engine generator unit, part number 68623194AB, which is required to keep the eTorque system functional. This part has been on nationwide backorder for an extended period with no estimated time of arrival from Mopar or the dealership. The vehicle is currently undriveable and unsafe, and I have not been given a timeline or support for alternative transportation. The unavailability of this critical hybrid powertrain component has made my vehicle unusable for weeks, and I’ve seen numerous reports from other RAM owners experiencing the same issue with no resolution. There is a serious risk to safety and reliability if this continues to be ignored. I am requesting that NHTSA investigate this widespread part shortage and potential manufacturer defect. There should be a recall or mandated parts response for affected vehicles if the manufacturer cannot supply replacement components for a core electrical system.

The contact owns a 2020 Ram 1500. The contact stated while driving 60 MPH, the message "Service High Pressure Fuel Pump" was displayed. The check engine warning light was illuminated, and the vehicle lost motive power. The contact was able to pull over to the right side of the roadway. The contact turned off and restarted the vehicle, and the vehicle operated as intended. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 22V767000 (Fuel System, Gasoline, Engine); however, the repair failed to fix the vehicle. The failure reoccurred after the recall repair. The manufacturer was not notified of the failure. The failure mileage was 35,000.

The contact owns a 2020 Ram 1500 Promaster. The contact stated that after parking and turning the vehicle off, he left it for approximately 10 minutes. The vehicle spontaneously caught fire. The contact was alerted that his vehicle was on fire. The contact noticed that the passenger-side headlight had smoke and flames four feet high. There were no warning lights illuminated prior to the failure. The contact and a bystander extinguished the fire. There were no reported injuries. A call was made to 911 emergency services regarding the incident. The fire and police departments were on the scene. The vehicle was towed to an independent mechanic who determined the failure was due to the wire harness and headlight assembly. A claim was submitted to the insurance company. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted regarding the failure and left 7 voicemails along with emails but no response as of yet. The failure mileage was approximately 67,168.

While driving my 2020 Ram Rebel, the driver side seat belt locked up and will no longer retract. I took the vehicle into the Larry H. Miller Chrysler dodge dealership and they attempted to fix it but they were not successful. My truck only has 58,809 miles on it and they stated that it was no longer under warranty and that I would have to pay to replace it (roughly $750). Prior to the seatbelt locking, there were no indications that something was wrong. I believe not having a seatbelt that works properly puts myself or anyone else that would drive my vehicle at great risk if there was an accident.

My control knob is not responding to my truck and I cannot open doors or turn it on and it’s asking me for anti theft code all of a sudden. I took it to the dealer and they say alote of trucks are having the same problem. They say It could be the module reader. Now my truck is not reacting to nothing at all.

The turn signal was stuck blinking to the right even in the neutral position. The only way to make it stop was to click it into the left turn indicator. This rendered the lane blind spot inoperative.

I am writing to report a serious and dangerous issue with my 2020 Ram 1500. The vehicle has been randomly shutting off while I am driving, often accompanied by a strange acceleration or revving sound just before the engine dies. This has occurred multiple times without warning, creating an extremely unsafe driving situation. The issue happens at random and cannot be easily reproduced on demand, which I understand may make it difficult to diagnose. However, it is important to emphasize that this is a major safety risk that could easily result in a crash or injury.

The contact owns a 2020 Ram 1500. The contact stated while driving at an undisclosed speed, the steering wheel failed to turn in the intended direction. In addition, the “Service Power Steering” warning light was illuminated. The contact stated that the vehicle stalled in the middle of a busy roadway. The contact stated that her small children were occupants of the vehicle during the failure. The contact was able to get the vehicle over to the shoulder of the roadway. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure and a case was filed. The contact referenced a recall with a similar failure; however, the VIN was not included. The failure mileage was approximately 109,857.

Parts number 68623194AB, generator kit for alternator. This part went out on my Ram, Ram is backed up for months on this part. There are more than 10,000 vehicles with this problem. Im also being told that the product is not being produced at the moment, which puts my vehicle out of commission until the part arrives.

Ram issued a TSB 23-098-23 REV. A for the rear window leaking. Water has soaked the inside around the air bags all down the rear seats and floor. I’m concerned the issue could have damaged my air bags and the electrical in the vehicle. Vehicle rear window has been replaced in 2023. Still leaking water in around the rear airbags.

Power steering light continually goes on and off. Took it to dealership and they said they’ve had many many new models of this Ram come in with the same problem. They quoted me for a gear rack saying it’s some kind of defect and the whole thing would need replaced (2,000$ +). I’ve looked through forums and countless drivers have reported the same issue. I’ve had this truck for just over 100,000 miles, with regular maintenance to every aspect of it. I don’t feel we should be responsible for a fault of the manufacturer. Please help!

The contact owns a 2020 Ram 1500. The contact became aware of coolant fluid stains on the ground. The contact stated that while driving 40 MPH, there was an abnormal sound coming from the radiator fan. Upon inspection, the contact noticed that coolant fluid had accumulated on the fender under the radiator. The vehicle was taken to the dealer where it was diagnosed that the radiator seal had failed. The contact was advised that the radiator needed to be replaced. The vehicle was not repaired due to the cost. The contact stated that the failure persisted. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was approximately 60,000.

The dashboard leather on my 2020 Ram Longhorn (VIN [XXX] ) has severely bubbled and separated from the underlying structure. The warping creates dangerous glare and distortion in the windshield, compromising forward visibility. Additionally, the deformation extends over the passenger side airbag panel, raising serious concerns about whether the airbag can deploy correctly. This is a well-documented defect on 2019–2020 Ram Longhorn dashboards due to adhesive failure, not wear and tear. FCA/Stellantis is aware of the issue and has issued technical bulletins, but many vehicles remain unrepaired. This should be treated as a safety issue and addressed via recall or extended coverage. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Cracked exhaust manifold. I know of three people, besides myself, with the 2020 Ram with 5.7 literally Hemi that have had cracked exhaust manifold. Mopar has a technical service bulletin, but the cost to repair is on me.

Software issue with 12' display unit. The issues began occurring over the past several months. Sirius XM radio frequently searching for signal lasting for hours, and nothing else would play, not the radio nor the Pandora app with UCONNECT. The backup camera displayed on the screen when in D. Then, on 6/10/2025, the backup camera stopped working altogether. When shifted into R, 12' display shows a blue screen with "Camera System Unavailable." The camera control buttons are fixed in position. On 6/11/2025, the 12' display showed Sirius XM subscription update and left me with the Sirius preview screen even though I have a subscription. This lasted several hours. Upon, restart, Sirius shows loading again. Still no backup camera.

Replaced the RFH Hub twice in this vehicle do to water damage. 1st time under warranty, the 2nd out of pocket. Noticed the second time they replaced the Backlit light seal under an extended warranty (XL1 Warranty) where the water came in from. Both repair receipts enclosed and a picture of another vehicle they were replacing the seal while picking up my repaired vehicle. Investigation revealed, they use to fix the back siding window seal which cost $1300, but they replaced the Backlit at $25, now I'm on the hook for $1081.71 and change. $936.71, for the repair, $144.00 for the tow, the same spot it was towed from the first time it happen. Both times it had rained heavily. Filed a reimbursement case with FCA, Case#93175918, they have yet to get back to me.

The contact owns a 2020 Ram 1500. The contact stated that upon starting the vehicle, the steering wheel started vibrating. The contact attempted to restart the vehicle and after the vehicle started, the “Power Steering Service” message was displayed on the instrument panel. The vehicle was taken to a local dealer where the vehicle was diagnosed, and the contact was informed that the steering assembly was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 62,250.

When filling up the gas nozzle shut of and fuel will spill out. I have to listen for the fuel in the neck b4 it gets to top. It takes forever to fill.

Currently Ram has extended its warranty on the back break light due to a leaking/sealant issue on certain models and years. The truck also leaks through the window frame that crakes in these vehicle's. It seems that maybe this isn't being looked at as a safety concern and think it should be. Water leaking in due to this issue is now causing stagnant water. I have 2 kids that sit in the back of the truck and have been subject to breathing in the mold that has built up. I believe the result of mold growth is a great safety concern. I have seen this complaint all over the internet and even on the 5th generation website. I think a full investigation on this should be done immediately. It also seems Ram is aware of the issue because they no longer install this window. We have always had the issue but never understood why the truck had a bad smell to it. It took a very long time to finally realize the smell was coming through the back window and into the cabin but behind the seats. My truck is a 2020 Dodge Ram Laramie 5th generation with less then 25,000 miles on it. I attached a list of webites that immediately pop up when you type Dodge back window leak

My truck would engage the emergency braking without any objects near. Battery needed to be replaced due to not charging. The etorque is making noise and vibrating.

The power steering froze and caused me to lose control. Almost hitting my car port. Thank goodness I wasn’t on the highway. Up to that point it operated perfectly. According to internet common problem that has caused accidents. Factory will not repair. Truck currently unmovable

Loss of stability control,power steering,anti lock brake system,air bags,speed control. Has been at Dodge Dealer multiple times with the exact reoccurring problem.

While driving power steering warning lights come on and power steering goes out. The power steering warning lights come on and go off with loss of power steering intermittently but only after unit heats up. Loud noise such as a fan comes on prior to the steering warning lights coming on and power steering going out. Had a mechanic diagnose the issue and he said the power steering rack and pinion needed to be replaced and cost would be around $3800 Very dangerous especially when power steering goes out while turning. New OEM power steering rack & pinion ordered today 5-21-2025

The contact owns a 2020 Ram 1500. The contact stated while driving 65-70 MPH and towing a trailer, the traction control engaged, and the vehicle went into LIMP Mode. The Police had aided with getting the vehicle off the roadway. The traction control and engine warning lights were illuminated. The vehicle was taken to the local dealer, and two unknown local dealers were unable to determine the failure. The vehicle was not diagnosed or repaired. The brake control was previously replaced. The manufacturer was contacted and referred the contact to the dealer and the NHTSA Hotline for assistance. The failure mileage was approximately 2,500.

Sitting in traffic, truck started overheating. Gauge was jumping all over. Truck had to be turned off

Exhaust manifold is ticking after only hitting 47k miles. Of course the warranty has been out for a month now. The dealership won’t cover it quoting me $3,200 to replace both of them.

The contact owns a 2020 Ram 1500. The contact stated that whenever the weather was below 50-degrees, after refueling the vehicle, the gasoline started spilling out of the fuel filler neck. The contact stated that refueling the fuel tank slowly prevented the gasoline from spilling out of the fuel filler neck. There was no warning light illuminated. The vehicle was taken to a local dealer to be diagnosed, and the contact was informed that the fuel pump and gas tank were faulty and needed to be replaced. The vehicle was repaired; however, the failure persisted. The manufacturer was notified of the failure. The approximate failure mileage was 30,000.

The windshield wiper system is currently pumping wiper fluid but not on the windshield, instead it is somehow sending it to the passenger side of the front hood and draining directly on the ground. I took it to the dealer and was told several other vehicles came in with the exact same issue and was told it would be addressed but as of now it has not

Spring of the driver side strut collapsed at 34,000 miles.

There was a griding under the hood and may lights went out. The dealer said my ETORQUE/alternator needed to be replace. That was done approximately 4/10/25 under an extended MO PAR warranty. Since getting the truck back, it has stalled on me 3 separate times, all at red lights. Twice when the 'auto stop' was engaged and then the car lurched forward after the stall had occurred for about 2 seconds, the third time the 'auto stop' was off, and the stall occurred for about 4 seconds, the car rolled backwards even though it was in drive and then it lurched forward and went. Dealership can't replicate the issue so they are telling me can't fix anything. I am very worried that the car will stall on me at another light or on the highway and something very terrible will happen.

Due to the recall Z96/NHTSA 22V-767 my fuel pump failed in 2023, causing my check engine light to come on due to a fuel injector warning. The dealership replaced the fuel pump, but nothing else was replaced or checked. In April 2025, my check engine light came back on for a #4 Glow Plug issue. The truck at this point had 56k miles on it, and was out of warranty. I took it to a local mechanic, who found the glow plug had shrapnel on it, causing it to fail. He believes it is due to the high pressure fuel pump failure the previous year, releasing debris into the fuel system. This is a safety issue due to the loss of engine power, and if multiple cylinders are affected could cause the vehicle to go limp.

Have a whirring, whining noise and at my Feb 2025 service, was told it was the e-torque assembly bearing and it was loose. Part is on back order for months since this is a common issue and will cost over $1400 for part alone. Was told not covered under warranty but believe that the dealership is wrong BUT am reading it was recalled in the 2021 RAM 1500 but I am having same issue with my 2020 and I am reading I am not alone.

So I am driving on the freeway 70mph and I get a message on my dash that says service shifter then every single light on the dash came on and started to make a beeping noise. I pulled over on the side of the freeway and then all the lights dissappear except check engine. I continued to drive to next exit and this time all lights came on again and truck appeared to be shutting off and turning back on while driving, steering wheel got hard to move all while all lights turning on, on dash. I have taken to shop 3 times first time they told me it was battery so I purchased battery and diagnostic fee for 600. Still continued to have issues even after replacing battery. Then they tell me they don't know what's causing this issue and the truck hasn't been fixed. I'll let the truck sit a few days and check engine light is gone and it will drive normal until the issues pops up again. I just don't know what to do about issue and have lost hope nobody seems to know what's causing thr issue. I have videos of this happening multiple times and I show to shops and they are just im awe and can't figure out what is happening. This happened to me yesterday 4/25/25 and while driving the truck started to show all lights on dash and immediately put itself into park while I was driving about 20 mph. Turned the truck off and started it back on again and got the service shifter message and drove home slowly and truck sat in driveway. I've taken in the truck multiple times and nobody seems to know wha

The contact owns a 2020 Ram 1500. The contact stated while stopped at a traffic light, there was an abnormal rattling sound coming from the engine. The contact pulled over to the right side and attempted to restart the vehicle; however, the vehicle failed to respond. The contact stated that the vehicle was taken to Town and Country Garage. A dealer was contacted. The vehicle was towed to a dealer where it was diagnosed that the engine had failed and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure but offered no assistance. The approximate failure mileage was 61,000.

MGU failure leading to car battery being completely drained and unable to run until replaced. Started with bearing noise coming from MGU alternator. Then check engine light came on. Before long a low voltage alarm appeared and was able to safely pull over before truck died. Truck is now unable to be driven until replacement of MGU. Dealer has been unable to source part for over a month and could be at least another month before part is ready to come in. Issue appears to be pretty common on 5.7 L Hemi E-torque Ram 1500's as was told part on back order at this time for over 3,000 other customers

The alternator generator is making us squeaky noise. I’m afraid that it’s gonna seize as I drive and I’ll lose power of the brakes and the steering checked with the dealer. They don’t have the part. They don’t know when they’re gonna be able to get it the part. I called junkyards call other auto parts stores. No one has got it’ I also went in the Mopar website and they also don’t have it

Steering became sluggish, jerky and erratic. Started sounding like the power steering pump was struggling/straining. I put it in the shop and they claim it’s the eps and rack and pinion gone bad. It is being replaced. How unsafe is this at low or highway speed? How many other complaints are there on this same subject and part? 2019 eps was recalled. How do I find out if I have 2019 parts in my 2020. I know sometimes they are interchangeable. I look forward to hearing from you.

Driving down the road, my auto start stop failure light appeared on dash, followed by a check engine light and a battery light. Tried to pull over on the side of the road when I lost all electrical components including power steering, ac, radio etc. the truck slammed itself into park abruptly and turned itself off. I was stranded on the side of the road and nearly got hit by passing cars several times as I was in a curve in the road. After further investigation it has been determined that the bearings inside of the generator (part number: 68623194AB) went out. The part needed to fix the truck is not being made by the supplier and I have been nearly 2 months and counting paying for a truck to sit and look pretty as the truck is completely unusable. One dealership told me this part was on back order for over Five thousand customers.

The contact owns a 2020 Ram 1500. The contact stated that while driving 25 MPH, the vehicle shut off; however, the vehicle kept running for several more feet. The contact attempted to bring the vehicle to a stop. There were no warning lights illuminated. The vehicle was towed to the residence. While the vehicle was at the residence and turned off, the alarm sounded. The vehicle was then towed to a dealer, but it was not yet diagnosed. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 77,000. The VIN was not available.

Suddenly engine light, tps and shifter turned on , I restarted the vehicle and disappeared but later my truck did not start and it is dead

The contact owns a 2020 RAM 1500. The contact stated that while driving at an undisclosed speed, the rear windshield inexplicably shattered. No warning lights were illuminated. The vehicle was taken to the dealer, but refused to inspect the vehicle for unknown reasons. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 20,000.

The 48V Belt Starter Generator failed on my 2020 Ram 1500 with the 5.7L eTorque system. It caused my truck to stall in the middle of a busy intersection at a red light. The battery drained fast, and I couldn’t move the truck out of the way. I was stuck in a dangerous spot cars were coming around a turn at 45–55 mph, and since my hazard lights started dying too, I had to get out in the rain and wave people away so they wouldn’t hit me. I was honestly afraid for my life. I ended up calling 911 and my insurance to get towed out of there. Before it happened, I saw a battery warning and something about the battery system. A mechanic and a dealer confirmed the issue was the 48V generator. I started calling around for the part, and every dealer I spoke with told me it’s on national backorder. One told me there were over 2,600 people already waiting for it, another said over 3,000 are on the list and no one has any idea when they’ll get them. There are a lot of people dealing with this, and it’s not just an inconvenience it’s dangerous. This part failing leaves people stranded in traffic, sometimes without power or lights. Something needs to be done. A recall would be the right thing.

Truck was responding perfectly fine until we stop to watch a movie at the theater last night. After the movie I turn on the truck and notice my power steering was not working and everything else on my truck works fine.

The motor generator has effected the ess (engine start stop) system and at a stop it does not restart the vehicle when you let off the brake. It startes and then jumps forward creating a safety hazard if there is a vehicle in front of you or a pedestrian in the crosswalk. This is a concern that seems to happen with this system frequently through web searches that I have seen. My truck is at a dealer now to diagnose the problem with the system.

The contact owns a 2020 Ram 1500. The contact stated that the driver's side sun visor was fractured, causing the sun visor to fell and obstruct the contact's view while driving. The contact stated that the driver's side sun visor had previously been replaced three times, and the passenger's side sun visor had been replaced four times; however, the failure persisted. The vehicle was taken to the dealer, who determined that the driver's side sun visor needed to be replaced again. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 41,000.

The Back Window By Factory Default. The model with One Big back window with mini Slide window in middle.Its been Verified By Authorized Mechanic and Autobody Shop.Have Documents but need Mopar or NHTSA help to fix this Safety issue.I now have water seeping into Cab.Ruining my Interior.Please help me

There is a high whining noise followed by a loss of power steering. There is a recall for the EPs system that stopped in 2019; however, 2020 is still using the same part. The recall should be extended to cover all vehicles manufactured using the part numbers associated with this issue. My truck is only at 50k miles, never off-roaded or abused, and maintained religiously by my personal mechanic. I was driving at 78 mph, and the steering locked up due to this issue. This created a hazardous scenario for me. The wheel released moments later, causing me to overcorrect and almost hit another car traveling on the highway in the adjacent lane. This has happened several times over the past week. I have adjusted my driving style until I can afford this VERY costly repair.

This is the second time this has happened (03APR25). The first time this occurred, 20JUL25, I had to pay (Bill attached) to have the ABS Module replaced. Today several service lights came on not limited to: Service 4wd, 4wd Trans Case overheat, stabilization system, and the traction control light came on along with the 4wd High light and both the 4wd High and 4wd Low indicator lights were all flashing. When parked the emergency parking brake was automatically set. (break) I have all the documentation from the first occurrence and an additional recall notice (Attached) of which states contact the dealer, whom said that it was not their responsibility. Then I contacted Stellantis recall office, and they said they would get back with me and never have and today most all the sensor faults flashed on the display. The truck locked in 4 high up until I parked it.

1. Safety Issue 1: Cracked Exhaust Manifold & Exhaust Leak Description: Loud knocking noise on startup, strong exhaust fumes entering cabin. Dealer Diagnosis: Both exhaust manifolds cracked, multiple broken bolts. Risk: Potential carbon monoxide poisoning, engine damage, and fire hazard. Dealer Response: Refused repair, quoted $3,500. No assistance from Chrysler. Pattern Failure: Online forums show many owners with identical issues—clearly a manufacturing defect. 2. Safety Issue 2: Dashboard Delamination & Toxic Fumes Description: Dashboard surface peeling, strong chemical odor in cabin. Risk: Toxic off-gassing causes headaches/nausea; peeling material obstructs visibility. Pattern Failure: Widespread reports for this model/year—faulty adhesive is to blame. Manufacturer Negligence: Chrysler and dealerships are aware but refuse responsibility, blaming "wear and tear." Exhaust leaks and toxic interiors are unacceptable safety hazards—yet no recall exists. Request to NHTSA: Investigate these defects for potential recall. Force Chrysler to acknowledge and repair affected vehicles. Urgency: Driving this vehicle is a health risk. NHTSA must act before more are harmed.

The Alternator Generator (MGU) failed and I was driving on the road when it happened causing the electronics to start going dark one after the other then dark screen and lost power steering. Thank God I was close to the side of the road and rolled out of traffic's way. The truck was towed to the mechanic who confirmed it is the MGU. The problem is that this part is on back order with no ETA. So I have a 2020 RAM Laramie with 39,000 miles only sitting in the shop. If this happened on the highway, an accident would have been guaranteed. I was simply lucky.