1998 Pontiac Sunfire

Defect. DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.

Risk. IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy. DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.

Defect. CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.

Risk. FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.

Remedy. DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

Defect. CERTAIN DELPHI AFTERMARKET FUEL PUMP MODULES / MODULE RESERVOIR ASSEMBLIES (MRA) THAT WERE SOLD FOR USE ON THE ABOVE LISTED VEHICLES. DURING PRODUCTION THE MRAS VENT AND FUEL RETURN TUBES WERE REVERSED. THIS CONDITION CAN RESULT IN THE VEHICLE NOT RUNNING CORRECTLY (IDLE ROUGH AND/OR STALL) DUE TO AN OVERLY RICH FUEL BLEND OR THE VEHICLE'S EVAPORATIVE EMISSION CARBON CANISTER MAY LEAK FUEL.

Risk. A STALLED VEHICLE CAN INCREASE THE RISK OF A VEHICLE CRASH. A FUEL LEAK CAN RESULT IN A FIRE.

Remedy. DELPHI WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE MRAS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2007. OWNERS CAN CONTACT DELPHI AT 1-877-335-7443.

Defect. CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk. WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy. PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

Defect. ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.

Risk. IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED. THE FIRE COULD SPREAD TO THE INTERIOR OF THE CAR, WHICH COULD INJURE OCCUPANTS OR CAUSE DAMAGE TO ADJOINING STRUCTURES.

Remedy. DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH, AND CHECK THAT YOUR CAR WILL START WITH A PROPERLY CHARGED BATTERY AND, IF NECESSARY, REPLACE THE IGNITION SWITCH. OWNER NOTIFICATION WILL BEGIN ON MARCH 1, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, BUICK AT 1-866-608-8080, OR OLDSMOBILE AT 1-800-630-6537. CUSTOMERS CAN ALSO CHECK THEIR VEHICLE ONLINE BY GOING TO WWW.MYGMLINK.COM AND ENTERING THE VEHICLE'S IDENTIFICATION NUMBER.

Defect. CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.

Risk. IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.

Remedy. DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.

Defect. VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE WHEEL LUG NUTS WERE NOT TIGHTENED SECURELY RESULTING IN A FRACTURE OF THE WHEEL STUDS.

Risk. THE WHEEL COULD SEPARATE FROM THE VEHICLE. IF THE VEHICLE WERE IN MOTION, A VEHICLE CRASH COULD RESULT.

Remedy. DEALERS WILL INSPECT THE TORQUE OF ALL WHEEL NUTS AND, IF NECESSARY, TIGHTEN ANY THAT MAY BE BELOW REQUIRED TORQUE.

WHILE DRIVING THE VEHICLE WILL SHUT DOWN AND THE THEFT SYSTEM LIGHT WITH START FLASHING WILL START AGAIN AND BUT SHUT DOWN AGAIN I WAS DRIVING ON A CITY STREET AND HAD IT AT A DEALER THEY REPLACED THE ECU THE GAUGES AND THE IGNITION THEY REPLACED THE ECU 3 TIMES WITH NO AVAIL THIS HAS HAPPENED TO ALL 4 OF MY PONTIACS

CARS BATTERY CONSTANTLY RAN DOWN. BATTERY WAS CHECKED AND WAS OK AS IT WAS THREE MONTHS OLD. REPAIR STATION SAID THE HORN WAS SHORTED AND THE AIR BAG IS PART OF THE HORN SWITCH AND MUST BE REPLACED.

BRAKE LIGHTS, TURN SIGNALS, HAZARD LIGHTS, AND REAR DEFROSTER ALL STOPPED FUNCTIONING. PROBLEM INITIALLY HAPPENED ABOUT 5 MINUTES AFTER STARTING VEHICLE, BUT NOW IS PERSISTENT AND NONE OF THESE ITEMS FUNCTION POSING A MAJOR SAFETY HAZARD.

TL* THE CONTACT OWNS A 1998 PONTIAC SUNFIRE EQUIPPED WITH DOUGLASS X-TRAC A-W TIRES, SIZE 205/55R16 (NA). THE CONTACT PURCHASED ONE TIRE IN NOVEMBER OF 2013 AND ANOTHER IN JANUARY OF 2014. THE VEHICLE WAS TAKEN TO WAL-MART IN FEBRUARY OF 2014, WHERE THE TIRES WERE PURCHASED, AND IT WAS DIAGNOSED THAT THE TIRES WERE LEAKING. THE VIN AND DOT NUMBER WERE UNAVAILABLE. THE APPROXIMATE VEHICLE AND TIRE FAILURE MILEAGE WAS 88,000. UPDATED 7/1/15*CN UPDATED 7/23/15*CN THE CONSUMER STATED ALL THREE TIRES WERE PURCHASED A DIFFERENT TIMES AND HAD LEAKS. UPDATED 07/28/15*BF...UPDATED 10/15/15 *BF UPDATED 10/16/2017*CN

TL* THE CONTACT OWNS A 1998 PONTIAC SUNFIRE. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE SHIFT CABLE WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 101,000. UPDATED 12/21/12 *CN UPDATED 1/14/2013 *JS

THE ACCELERATOR PEDAL STUCK WHILE DRIVING. WHEN TRYING TO USE THE BRAKE THE CAR STILL WILL NOT STOP. *TR

APPARENTLY, THEIR IS A KNOWN ISSUE W/THE 98 PONTIAC SUNFIRE STEERING RACK AND PINION GEAR MAKING IT FEEL LIKE THEIR IS A TOTAL LOSS OF POWER STEERING, EVEN THOUGH THE POWER STEERING PUMP IS WORKING PROPERLY. I PURCHASED THIS CAR IN JANUARY OF 2011 OFF A LITTLE OLD LADY, WHO KEPT IT IN A GARAGE AND BARELY DROVE IT, THE CAR ONLY HAD 51,000 MILES ON IT. SHE ADVISED THAT SHE DIDN'T KNOW OF ANY RECALLS, SO SHE DIDN'T TAKE IT IN FOR ANY OF THE RECALL REPAIRS. I HAVE CHECK THE NHTSA WEBSITE AS WELL AS SEVERAL OTHER REPUTABLE SITES AND HAVE FOUND THEIR HAVE BEEN SEVERAL RECALLS ON THIS VEHICLE. HOWEVER, UPON CALLING PONTIACS RECALL HOTLINE, THEY ARE TELLING ME THAT THESE RECALLS ON YOUR WEBSITE NEVER EXISTED FOR MY 98 PONTIAC SUNFIRE AND WENT ON TO SAY THAT YOU CAN BELIEVE EVERY THING YOU READ ON THE INTERNET (HOW FUNNY, YOUR AVERAGE MORON COULD HAVE FIGURED THAT OUT). BUT REGARDLESS, IT APPEARS THAT PONTIAC IS SAYING THAT THEY WILL NOT FIX THESE RECALLS. PLEASE INVESTIGATE AND LET ME KNOW IF MY CONCERNS ARE LEGITIMATE. I DON'T WANT TO PAY FOR A REPAIR, WHEN THE CAR SHOULD HAVE BEEN FIXED UNDER THEIR RECALL. THANKS. *TR

1998 PONTIAC SUNFIRE GT ANTI-THEFT SYSTEM WON'T DISENGAGE, CAR IS DEAD. (WHEN THE ANTI-THEFT SYSTEM IS TRIGGERED, THE FUEL PUMP IS SHUT OFF) IT MAY HAVE BEEN TRIGGERED BY USING A COPY OF THE ORIGINAL KEY. FOLLOWING MANUFACTURER'S INSTRUCTIONS (TURN ON IIGNITION FOR 10 MIN, TURN OFF AND TURN ON AGAIN) DOESN'T WORK. AN INTERNET SEARCH REVEALED THAT THERE ARE 1000S OF PEOPLE WITH THE SAME PROBLEM WITH SUNFIRE AND OTHER GM CARS. I WOULD LIKE GM TO ACKNOWLEDGE THE PROBLEM AND REPAIR THE FAULTY SYSTEM. *TR

TL*THE CONTACT OWNS A 1998 PONTIAC SUNFIRE. WHILE DRIVING LESS THAN 15 MPH, THE CONTACT WAS UNABLE TO TURN LEFT. THE CONTACT VEHICLE BECAME DIFFICULT TO STEER. THE CONTACT HAD TO REVERSE AND REPOSITION THE VEHICLE TO MAKE THE TURN. THE CONTACT CALLED THE DEALER WHO REFERRED HIM TO THE MANUFACTURER. THE CONTACT REFERENCED RECALL 02V286000 (STEERING: RACK AND PINION) BUT THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT INCLUDED. THE FAILURE OCCURRED SEVERAL TIMES IN A DAY. THE VEHICLE HAD NOT BEEN REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 97,000.

VEHICLE WAS BLOWING 30 AMP FUSE GOING TO REAR DEFOGGER GRID. FOUND MELTED INSULATION ON 12 VOLT LINE AND GROUND RESULTING IN SHORT CIRCUIT. DEFOGGER GRID STILL DRAWING ENOUGH CURRENT TO MELT INSULATION OF 12 VOLT LINE. DISCONNECTED REAR DEFOGGER GRID TO PREVENT POSSIBLE FIRE IN DASH. *TR

LOST BRAKES IN MY 1998 PONTIAC SUNFIRE WHEN BRAKING ON AN EXPRESSWAY EXIT RAMP. THIS WAS A VERY UNSAFE CONDITION, BUT WAS ABLE TO AVERT A COLLISION. THE LEFT REAR BRAKE LINE (HYDRAULIC) CORRODED THROUGH AND CAUSED A LARGE LEAK, LEAVING MARGINAL BRAKES.*TR

I OWN A 1998 PONTIAC SUNFIRE AND HAVE A PROBLEM WITH THE DAYTIME LIGHTS STAYING ON EVEN WHEN THE SWITCH IS TURNED TO HAVE THE NIGHT TIME HEADLIGHTS ON. IT GOES BACK AND FORTH FROM DAY TO NIGHT LIGHTS AND WILL NOT STAY ON NIGHT WHEN DRIVING. *TR

1998 SUNFIRE BEGAN TO MAKE CLUNKING NOISES ON FRONT RIGHT SIDE. UPON VISUAL INVESTIGATION, IT WAS FOUND THAT THE FRAME COMPONENT WAS COMPLETELY RUSTED THROUGH AND SEPARATED. THIS COULD BE A VERY DANGEROUS PROBLEM UNDER THE RIGHT CIRCUMSTANCE. I HAVE SENT DIGITAL FILES TO YOUR WEBMASTER EMAIL TO SHOW EXACTLY WHAT HAS HAPPENED AS I FEEL THAT THERE SHOULD BE A RECALL IMMEDIATELY , AS THIS IS A SERIOUS SAFETY MATTER. *TR

COOLANT HAD BEEN LEAKING FOR OVER 3 MONTHS OFF AND ON. PUT IN STOP LEAK FOR A TEMP FIX. HOWEVER DEXCOOL CONTINUED TO EAT AWAY AT MY COOLANT SYSTEM. CAR HAS OVERHEATED ON MANY OCCASIONS. FINALLY ABLE TO USE JB WELD TO FIX LEAK . *TR

DT*: THE CONTACT STATED SIX TO EIGHT MONTHS AGO, WHEN TURNING LEFT, A POP WAS HEARD IN THE STEERING COLUMN. SINCE THAT TIME, THE STEERING HAS BEEN HARDER TO MANEUVER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHO DETERMINED THE RACK AND PINION AND POWER STEERING HOSE NEEDED TO BE REPLACED.

1998 PONTIAC SUNFIRE MAKING A RIGHT TURN 30 MPH WHEN ALL WHEEL LUG BOLTS BROKE ON RIGHT FRONT WHEEL AND WHEEL CAME OFF. WHEEL GOT STUCK UNDER CAR. NO STEERING AND BRAKING WAS LIMITED. CAR WENT OFF THE ROAD. WITH THE HELP OF THE REAR EMERGENCY BRAKE THE CAR WAS STOPPED. FORTUNATELY NO INJURIES. DAMAGE TO DISK BRAKE, LARGE DENT IN FENDER AND BUMPER. NHTSA RECALL 97V219000 INDICATES SIMILAR PROBLEM FOR 1998 PONTIAC SUNFIRE. WHEEL HOLES WERE PERFECTLY ROUND INDICATING THE WHEEL NUTS WERE NOT LOOSE. CAR FRONT WHEELS HAD BEEN SERVICED 6 MONTHS EARLIER FOR NEW BRAKES. WHEN I CALLED PONTIAC AT 1-800-762-2737 THEY INDICATED THERE WAS NO RECALL FOR THIS CAR INVOLVING WHEEL LUG BOLTS AND SAID THERE IS NOTHING THEY CAN DO. *NM

I OWN A 1998 PONTIAC SUNFIRE. THE FAILURE IS WITH THE HEADLIGHTS/DAYTIME RUNNING LIGHTS. .. THE DAYTIME RUNNING LIGHTS WORK FINE, BUT AT NIGHT, WHEN I TWIST THE LEVER TO TURN THE HEADLIGHTS ON, ONLY MY DAYTIME RUNNING LIGHTS STAY ON AND MY HEADLIGHTS REMAIN AT ABOUT 1/2 BRIGHTNESS AND THE DAYTIME RUNNING LIGHTS INDICATOR STAYS ON. (IN OTHERWORDS, NO CHANGE IN THE BEAMS...) BUT THEN WHEN I EVER SO SLIGHTLY PULL THE LEVER BACK TO GO TO FLASH MY HEADLIGHTS, THE DAYTIME RUNNING LIGHTS INDICATOR DISAPPEARS AND MY HEADLIGHTS BRIGHTEN TO "NORMAL, NIGHTTIME BRIGHTNESS, THEN IF I PULL LEVER BACK TOWARDS ME EVEN FARTHER, THE HIGHBEAMS COME ON)... BUT THE PROBLEM IS... THE LEVER WON'T STAY ON EITHER NIGHTTIME OR HIGH BEAM MODES AT ALL. ONCE I LET GO OF THE LEVER IT RETURNS TO DAYTIME RUNNINGLIGHTS, EVEN WITH THE LEVER TWISTED ALL THE WAY TO HAVE THE HEADLIGHTS ON.... I STILL ONLY GET THE DAYTIME RUNNING LIGHTS (DRL)... . ON OCCASION THE HEADLIGHTS WORK OK TO BEGIN WITH, BUT AS I AM DRIVING THE "NORMAL" LIGHTS CLICK BACK OFF AND ITS ONLY THE DRL THAT ARE ON. ITS VERY DANGEROUS BECAUSE THE NIGHTIME TAIL LIGHTS ARE NOT ON WHEN THE DRL ARE ONLY ON. I ALSO HAVE A FRIEND WITH A 97 PONTIAC SUNFIRE AND SHE IS HAVING THE SAME PROBLEM WITH HER DRL/ AND HEADLIGHTS. I HAVE NOT YET CORRECTED THE PROBLEM, AND I HAVE RESEARCHED IT ON THE INTERNET AND OTHERS SEEM TO BE HAVING THE SAME PROBLEM.

A CLICKING NOISE WAS COMING FROM THE STEERING COLUMN. THE CONSUMER TOOK THE VEHICLE TO THE DEALER FOR REPAIRS TWICE, AND RESULTS INDICATED THAT THE STEERING COLUMN NEEDED TO BE GREASED, OTHERWISE THE CONSUMER COULD LOSE STEERING WHILE DRIVING. *AK THE NOISE WAS THE SOUND OF METAL ON METAL. GM WAS AWARE OF THE PROBLEM. *SC *JB

NHTSA RECALL CAMPAIGN 02V286000; GENERAL MOTORS ISSUED A STEERING ASSEMBLY RECALL. THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. BUT AT CERTAIN TIMES THE POWER STEERING FAILED WHEN MAKING TURNS, MAKING THE ABILITY TO MANEUVER THE VEHICLE DIFFICULT, AND INCREASING THE RISK OF A CRASH.*AK VEHICLE POWER STEERING PERFORMS LIKE IT HAS NO POWER STERING , JUST LIKE RECALL DESCRIBES. DEALER REFUSED TO TAKE ACTION CAUSE VIN IS NOT IN LOT OF #'S RECALLED. *BF

WITHIN THE LAST 10,000 MILES FUEL PUMP WAS REPLACED FOUR TIMES. EVERY 2500 TO 3000 MILES THE PUMP WILL MALFUNCTION. CONTACTED THE DEALER. HOWEVER, PROBLEM RECURRED. *AK

IN MY 98 SUNFIRE GT I HAVE SOME MAJOR PROBLEMS WITH YET I STILL OWN THE CAR. A LITTLE BIT AGO IT SEEMS LIKE MY EXHAUST PIPE FALLS OFF FROM THE EXHAUST MANIFOLD FROM THE FLANGE. WITH CAUSING YOUR CAR TO SOUND LIKE IT WAS A DRAG RACER. WELL I WENT TO PONTIAC AND FIGURED OUT THAT IT WAS GOING TO COST ME A PRETTY PENNY $500 SOME ODD DOLLARS. AND THE FUNNY THING IS THAT THIS HAS NOT JUST HAPPENED TO ME. IT HAS HAPPENED TO A FEW OF MY FRIENDS AS WELL. I DON'T HOW KNOW MANY TIMES YOU HAVE GOTTEN LETTERS ABOUT THE FAULTY EXHAUST FLANGES. *JB

WHEN I BOUGHT THE CAR USED IN OCTOBER OF 2000 IT HAD TO KEEP GOING BACK TO THE DEALER FOR ABOUT 3 MONTHS BECAUSE THE ENGINE IN THE CAR KEPT CUTTING OUT WHILE DRIVING AROUND 55-60 MPH. DEALER COULD NOT DUPLICATE THE PROBLEM. FINALLY AFTER THE 3RD MONTH THEY FOUND THE MAIN COMPUTER WAS BAD. THAT WAS REPLACED. IT RAN FINE UNTIL THE NEXT WINTER. THE CHECK ENGINE LIGHT CAME ON & CAR KEPT STALLING WHEN AT STOP SIGNS/LIGHTS. TOOK TO DEALER HAD DIAGNOSTIC RAN WHICH READ FAULTY GAS CAP, TPS SENSOR.... I REPLACED THEM MYSELF. CHECK ENGINE LIGHT WENT OUT TILL THE NEXT DAY. TOOK CAR BACK IN FOR DIAGNOSTIC WHICH READ FAULTY GAS CAP, TPS SENSOR,EGR ,COIL PACKS,GAS TANK SENSOR.....HAD DEALER WORK ON IT.... THEY COULD NOT SEE WHY ALL THIS STUFF WAS POPPING UP ....HAD IT ALL REPLACED. REPLACING IT DID NOT WORK. CHECK ENGINE LIGHT CAME ON AGAIN ABOUT 2 DAYS LATER!!! I CHECKED CAR OVER & FOUND IF YOU WIGGLED THE MAIN WIRING HARNESS CONNECTIONS THE CAR RAN FINE & ENGINE LIGHT WENT OUT! TOOK TO DEALER TO HAVE WIRING FIXED. THEY TOOK ALL THE WIRING APART & CLEANED EVERYTHING. THEY FOUND NO PROBLEM IN THE WIRING. CHECK ENGINE LIGHT CAME ON NEXT DAY.TOOK TO DEALER AGAIN FINALLY THEY SAID I NEEDED A NEW BATTERY..... WEATHER WAS NICE AGAIN & HAD NO PROBLEMS WITH CAR.... NOW THAT WINTER IS HERE AGAIN THE CHECK ENGINE LIGHT IS ON AGAIN , DIAGNOSTIC STATED TPS SENSOR WAS BAD... I AGAIN REPLACED IT & CHECK ENGINE LIGHT WENT OUT FOR A COUPLE HOURS & IS BACK ON AGAIN & CAR STALLS WHEN STOPPING & TRYING TO G

MY CAR MAKES A CLUNKING NOISE WHENEVER I TURN TO THE RIGHT OR LEFT. THE FIRST TIME I HAD THE REPAIR WAS IN 2002 AT A PONTIAC DEALERSHIP AND WAS COVERED BY WARRANTY. HOWEVER THE PROBLEM HAS RETURNED AND I CONTACTED THE DEALERSHIP. THEY HAVE TOLD ME THAT THEY ONLY GUARANTEE WORK DONE FOR A YEAR, WHICH LEAVES ME TO PAY FOR THE REPAIR. I HAVE ALSO CONTACTED GMC AND THEY WILL NOT HELP COVER ANY CHARGES, EVEN THOUGH THIS IS THE SECOND TIME I WILL NEED THIS SAME PROBLEM FIXED. IT SEEMS TO ME THAT THIS "SHAFT" PROBLEM SHOULD BE TAKEN CARE OF EITHER BY THE DEALERSHIP OR GMC. BY READING THE OTHER REPORTS HERE, IT'S OBVIOUS TO ME THAT THERE ARE OTHERS WHO ARE COMPLAINING ABOUT THE SAME PROBLEM. SO WHY HASN'T THERE BEEN A RECALL? WHY AM I RESPONSIBLE FOR THE PAYMENT WHEN IT'S A MANUFACTURER ISSUE?

THIS IS AN ONGOING PROBLEM WITH MY STEERING COLUMN. WHEN I TURN MY STEERING WHEEL TO THE RIGHT OR LEFT, IT MAKES A BUMPING NOISE. IT HAPPENS EVERY TIME THE WHEEL IS TURNED TO THE RIGHT OR LEFT. NOW IT HAS GONE OUT AND THE RECALLS R THE SAME BUT THEY SAY IT DOES NOT COVER MY CAR I NEED TO KNOW HOW THIS IS GOING TO BE FIXED. *AK

THERE WAS A PLASTIC PIECE ON THE BUCKLE THAT KEPT THE LAP BELT IN PLACE WHEN THE SEAT BELT WAS FASTENED. BOTH FRONT SEAT BELT PLASTIC PIECES BROKE UPON FASTENING THE SEAT BELT. WHEN THIS OCCURRED THE LAP BELT SLID FREELY BACK AND FORTH AND FAILED TO RESTRAIN THE OCCUPANTS. *AK *SC *JB

I TOOK MY SUNFIRE TO THE DEALERSHIP FOR THE SPECIFIED IGNITION SWITCH RECALL AND AM NOW HAVING PROBLEMS WITH MY STARTER. THE STARTER I HAVE IS NOT EVEN ONE YEAR OLD - I AM SURE THIS HAS SOMETHING TO DO WITH THE RECENT RECALL WORK DONE AT THE DEALERSHIP.

THE IGNITION SWITCH FAILED WITHOUT WARNING. TWO MONTHS LATER A RECALL WAS ISSUED AND PART REPAIRED, HOWEVER, THE PROBLEM STILL EXISTED. THE CONSUMER IWAS CONCERNED THAT THE VEHICLE WILL CATCH FIRE. *AK

RECALL NO. 04V036000, IGNITION SWITCH: THE DEALER WILL NOT REPAIR THE RECALL BECAUSE THE VEHICLE IS SALVAGED.*AK SINCE THE DEALER REFUSED REPAIR, VEHICLE DOESN'T START AND CAN NO LONGER BE DRIVEN. *LA

WHEN APPLYING BRAKES THE VEHICLE CONTINUED TO COAST, AS A RESULT THE VEHICLE EXPERIENCED EXTENDED STOPPING DISTANCE. *JB

ABS BRAKES FAILED 50% OF THE TIME WHEN THE BRAKE PEDAL WAS DEPRESSED. WHEN THIS FAILURE OCCURRED, VEHICLE SLOWED DOWN, BUT THEN THE FRONT BRAKES RELEASED, AND VEHICLE CONTINUED TO ROLL FORWARD. REAR BRAKES WERE THE ONLY BRAKES STOPPING THE VEHICLE. DEALERSHIP SERVICED THE VEHICLE SEVERAL TIMES FOR THIS ISSUE, BUT ONLY PERFORMED A BRAKE ADJUSTMENT. THE PROBLEM STILL EXISTS.*AK

I TOOK MY 98 SUNFIRE IN FOR SERVICE ON A RECALL ON THE IGNITION SWITCH. TWO DAYS LATER I BEGAN TO HAVE PROBLEMS WITH MY STARTER. THE DEALER SUGGESTED A $400 REPLACEMENT OF MY STARTER AND AN $855 REPLACEMENT OF MY FLY WHEEL. IT SEEMS VERY UNLIKELY THAT THIS PROBLEM ISN'T RELATED TO THEIR WORK ON MY CAR DURING THE RECALL WORK.*AK

THE TEMPERATURE GUAGE FLUTTERS FROM TIME TO TIME. THEN IT WILL GO ALL THE WAY DOWN TO 0.WHEN IT STARTS TO FLUTTER AGAIN THE ENGINE SEEMS TO BE RACING. THE TACH. GUAGE WILL BOUNCE ABOUT 200-300 PRM. I ALSO NOTICED THAT WHEN THE CAR IS IN PARK AND YOU IDLE THE ENGINE UP TO ABOUT 3000 RPM, IT ACTS LIKE THERE IS A REV LIMITER. IT HAS NEVER DONE THAT UNTILL A FEW MONTHS AGO. THE CHECK ENGIN LIGHT HAS NEVER COME ON UNTIL TODAY. I CHANGED PLUGS AND PLUG WIRES AND IT DIDNT HELP AT ALL. *AK

MY 1998 PONTIAC SUNFIRE CONVERTIBLE, HINGES HAVE CREATED HOLES IN THE INSIDE TOP, REAR OF THE CAR.

THIS CONCERNS THE FUEL SYSTEM ON '98 (AND SIMILAR YEAR) PONTIAC SUNFIRES. ON DECEMBER 29, 2003 THIS VEHICLE WAS TAKEN IN FOR REPLACEMENT OF THE IN-LINE FUEL FILTER. THE VEHICLE HAD BEEN LOSING ACCELERATION AND HAS 78,000 MILES ON IT. IT WAS TAKEN TO A PONTIAC DEALER FOR THE SERVICE. THE FILTER IS CONNECTED TO THE FUEL LINE WITH A 'SNAP' FITTING. UPON TRYING TO SERVICE THE FILTER, EITHER THE DEALER BROKE THE SNAP FITTING OR THE PREVIOUS OWNER HAD DAMAGED IT (VEHICLE WAS PURCHASED WITH 45,000 MILES ON IT, AND THERE WERE NO LEAKS SO I SUSPECT THAT IT WASN'T DAMAGED). ALSO, THERE WAS A FAIR AMOUNT OF CORROSION ON AND IN THE FITTING. IN THE END, THE FILTER COULD NOT BE REPLACED WITHOUT CORRECTING THE 'SNAP' FITTING. TO MY SURPRISE THE FUEL LINE COULD NOT BE REPLACED AS A SEPARATE PIECE, YOU HAVE TO PURCHASE THE ENTIRE FUEL DELIVERY MODULE. THIS COST (WITH THE TECHNICIAN TIME) WAS $ 425 VS. $50 FOR A FILTER REPLACEMENT. IT WOULD SEEM TO ME THAT SINCE THE FILTER IS A CRITICAL PART OF THE SYSTEM (A CLOGGED FILTER COULD RESULT IN VEHICLE STALLS AND/OR NO STARTS, EMISSION ISSUES ETC.) THAT IT SHOULD HAVE SOME SORT OF REASONABLE WAY TO REPLACE IT WITHOUT PAYING FOR AN ENTIRE MODULE THAT WAS NOT NEEDED. THE FILTER IS A RECOMMENDED SERVICE ITEM. *AK

THIS IS AN ONGOING PROBLEM WITH MY STEERING COLUMN. WHEN I TURN MY STEERING WHEEL TO THE RIGHT OR LEFT, IT MAKES A BUMPING NOISE. IT HAPPENS EVERY TIME THE WHEEL IS TURNED TO THE RIGHT OR LEFT. IT SOUNDS LIKE SOMETHING IS KNOCKING.*AK

SHE WAS INVOLVED IN A ACCIDENT WHERE THE LADY HIT HER ON THE DRIVERS SIDE OF THE CAR. I HAVE SEEN ON TV WHERE THIS CAR HAS A VERY BAD SIDE IMPACT RATING, AND ALSO ON THIS WEBSITE. THE WOMAN WHO HIT HER GOT TWO BROKEN LEGS, THE DRIVER OF THE PONTIAC SUNFIRE DIED. SHE SUFFERED A BROKEN BRAIN STEM, PELVIS, ARMS, AND FEMUR. *LA

I PURCHASED MY VEHICLE ON 06/1999 BRAND NEW WITH ONLY 122 MILES. WITHIN A FEW MONTHS IT DIDN'T START. I CALLED THE DEALER AND ADVISED THEM OF THE SITUATION. THEY COULDN'T FIND OUT WHAT WAS WRONG WITH IT? ABOUT TWO DAYS LATER THEY TOLD ME THAT THE GAS TANK HAD SUGAR IN IT??? SINCE IT WAS STILL UNDER WARRANTY THEY FIXED IT I HAD TO PAY $500.00. WHICH I FEEL WAS A DISCREPANCY ON THEIR DIAGNOSIS?? ON 06/00 THE VEHICLE AGAIN WOULD NOT START AND THIS TIME THEY ADVISED ME THAT IT WAS MY BATTERY? A FEW DAYS LATER THE CAR KEPT TUGGING AND JERKING. I DROVE IT TO THE DEALER AGAIN.THEIR DIAGNOSIS THIS TIME WAS: ENGINE CUTS OUT UNDER LOAD; PLUG WIRES ARE DEFECTIVE;PER TECH BULLETIN#00032.THAT SAME DAY MY STERIO CD PLAYER GAVE OUT! IT KEPT READING ERROR CODE, AND MY CARPET CAME LOOSE FROM THE PASSENGERS SIDE? ON 08/00 THE CAR BEGAN TO STALL AGAIN, IT WAS PULLING BACK AND FORTH,IT LEFT ME STRANDED IN THE MIDDLE OF THE DESERT! THE VEHICLE WAS TAKEN TO THE NEAREST DEALER SHIP.THEY FIGUREF OUT THAT IT WAS A WIRING TO MOTOR BROKEN CODE P0507, IAC MOTOR. ON 09/00 MY RADIO AGAIN WENT OUT;HAD TO BE SENT OUT FOR REPAIR? ON 03/01 THE VEHICLE BEGAN TO SHAKE AND THE CHECK ENGINE LIGHT TURNED ON. I TOOK IT AGAIN TO THE DEALER SHIP AND THEY TOLD ME IT WAS THE INTAKE AIR TEMP SENSOR. I DECLINED THE DEALERS SERVICE SINCE I HAVE LOST CONFIDENCE IN THEIR WORK PERFORMANCE. I TOOK IT TO A LOCAL MECHANIC AND HE FIXED THE PROBLEMS THAT IT HAD; FUEL INJECTION, VALVE COVER, SERP V-BELT, WHL CYLINDES L/R, TEMP SEN

CONSUMER PREFERS TO SEND A MORE DETAILED DESCRIPTION OF THE ENGINE FAILURE. *NLM

WQHILE DRIVING AT 60 PMH DRIVER HEARD NOISE FROM REAR LEFT TIRE. CONSUMER PULLED OVER IN NOTICED A BLOWN TIRE.*AK

CONSUMER WAS HAVING PROBLEMS WITH THE EGR VALVE. DEALER NOTIFIED. *AK WHILE DRIVING THE EGR VALVE BECAME STUCK IN THE OPEN POSITION WHICH CAUSED THE ENGINE TO ROUGH OR STALL WITHOUT WARNING. *PH *NLM

I'VE BEEN HAVING MULTIPLE PROBLEMS WITH MY 1998 PONTIAC SUNFIRE GT. LAST MONTH I HAD A FUEL INJECTOR AND WATER HOSE GO BAD AND NEED REPLACED. THE SUCTION HOSE PUMP FOR THE AC WAS LEAKING AND HAD TO BE REPLACED WITHIN THE PAST 3 WEEKS. IN THE SAME TIME PERIOD, THE COMPRESSOR STARTED LEAKING. I'VE HAD 2 DIFFERENT COMPRESSORS PUT IN, AND BOTH HAVE LEAKED STILL. THE 3RD COMPRESSOR IS BEING INSTALLED TODAY, SO WE'LL SEE WHETHER IT LEAKS TOO. A COMPRESSOR SHOULD REALLY LAST LONGER THAN 5 YEARS, AND I SHOULDN'T HAVE 3 COMPRESSORS IN A WEEK TRYING TO FIND ONE THAT DOESN'T LEAK. THERE'S ALSO A CRACK IN THE WELDING THAT NEEDS TO BE FIXED OR IT WILL START LEAKING. ONE OF THE FAN PARTS WENT BAD, SO NOW LEVEL 1 ON THE FAN ADJUSTMENT DOESN'T WORK. THIS SEEMS LIKE ALOT OF PROBLEMS IN A SHORT TIMEFRAME, ESPECIALLY WITH 3 PROBLEMS BEING FOR THE AIR CONDITIONING. I'VE CONTACTED THE PONTIAC CUSTOMER SERVICE DEPARTMENT, AND THEY CONTACTED A DEALERSHIP WHO SAID THAT PROBLEMS SHOULD BE EXPECTED AFTER 5 YEARS. GUESS I THOUGHT THEY WOULD BUILD A BETTER CAR. SO FAR, I'M OUT $1900 AND HAVEN'T HAD THE FAN OR THE WELDING CRACK FIXED YET. I WOULD APPRECIATE ANY HELP THAT COULD BE OFFERED. *AK

VEHICLE EXPERIENCED THE SAME DEFECT WITH ITS STEERING AS STATED IN RECALL 02 V 286 000. BUT THIS VEHICLE WAS NOT INCLUDED IN RECALL DUE TO VIN. *AK

CONSUMER STATES THAT VEHICLE HAD BEEN SHUT OFF FOR ABOUT 4 HOURS, WHEN SUDDENLY THE VEHICLE WAS FILLED WITH SMOKE. CONSUMER STATES THAT THE VEHICLES STEERING WHEEL MELTED. PLEASE PROVIDE ANY FURTHER INFORMATION.

CONSUMER STATES THAT WHILE DRIVING ABS LIGHT WOULD COME ON. DEALER NOTIFIED.*AK

MY DAUGHTER WAS DRIVING MY 1998 PONTIAC SUNFIRE AND HAD A COLLISION WITH ANOTHER CAR. SHE REPORTED THAT THE BRAKES FAILED AND WOULD NOT STOP THE CAR AT ALL. WE HAVE ALSO REPORTED TO THE DEALER ON MULTIPLE OCCASIONS THAT THE GAS PEDAL GETS STUCK. THIS MAY HAVE ALSO CONTRIBUTED TO THE COLLISION. *NLM

MARCH 24, 2003 DEAR SIRS, I RECENTLY HAD A WATER PUMP FAILURE ON MY 1998 SUNFIRE CONVERTIBLE. THE CAR HAS HAD A NOISE FROM THE FRONT OF THE ENGINE FOR ABOUT A YEAR, I THOUGHT IT WAS AN ALTERNATOR BEARING. THE CAR HAS BEEN IN A GM DEALER TWICE IN THAT TIME FOR OIL CHANGES AND OF ALL THE THINGS THE DEALER HAS TRIED TO SELL ME THEY NEVER SAID ANYTHING WAS WRONG WITH THE WATER PUMP. ON THE NIGHT OF FRIDAY, MARCH 14TH THE CAR BEGAN LEAKING ANTIFREEZE AND THE NOISE INCREASED. I LIVE IN SOUTH LYON, MI AND THE CLOSEST PONTIAC DEALER IS WALDECKER IN BRIGHTON. I ATTEMPTED TO TELEPHONE WALDECKER SEVERAL TIMES ON SATURDAY, MARCH 15TH, BUT DID NOT CONNECT, BECAUSE OF A DEAD PHONE LINE AT WALDECKER. I THOUGHT WALDECKER WENT OUT OF BUSINESS, SINCE IT IS AN OLDSMOBILE DEALER ALSO. I LATER FOUND, FROM THE WALDECKER SERVICE MANAGER ([XXX]) AND THE RECEPTIONIST, THAT THEY WERE IN FACT HAVING PHONE PROBLEMS FOR SEVERAL DAYS. WITH NO OTHER PONTIAC DEALERS IN THE AREA, I REFILLED THE RADIATOR AND TOOK THE CAR TO WALKERS GARAGE, THE CLOSEST AUTO REPAIR. THE BILL CAME TO $700 PARTS AND LABOR, I ASKED WALDECKER AND THEY SAID IT WAS A FAIR PRICE. HAVING TO TAKE THE EXHAUST MANIFOLD OFF, ACCESS THROUGH THE FRONT COVER OF THE ENGINE, GEAR DRIVE OFF THE TIMING CHAIN AND THE LOCATION ABOVE THE CV JOINT IS A POOR DESIGN FOR A SERVICEABLE PART. VEHICLE DESCRIPTION, 1998 SUNFIRE CONVERTIBLE, CURRENTLY: 42,000 MILES VIN# [XXX], 2.4 LITER DOHC ENGINE. I CALLED THE PONTIAC 1-800 NUMBER AND A REPRESENTATIVE TOLD

ON 9/5/02 MY CAR WAS INVOLVED IN AN ACCIDENT WHICH TOTALLY DESTROYED IT. ACCIDENT WAS CAUSED WHEN I WAS SLOWLY MAKING A LEFT TURN, SUDDENLY I EXPERIENCED LOSS OF POWER MAKING IT VERY HARD TO MANEUVER CAR DUE TO HIGH RESISTANCE. I WAS GOING SOUTH, AND WHEN I STARTED TO MAKE LEFT TURN, NORTH BOUND WAS FREE AND CLEAR, BUT BECAUSE THE LENGTH OF TIME I SPENT TRYING TO CONTROL MY VEHICLE, ANOTHER CAR GOING NORTH APPROACHED THE INTERSECTION WHERE I WAS AND COULD NOT AVOID HITTING THE OTHER CAR CAUSING THE CRASH. I SPENT MY ENTIRE SAVINGS TO PURCHASE THIS CAR FROM A PONTIAC DEALER, AND THIS ACCIDENT THAT LEFT ME WITHOUT TRANSPORTATION, CAUSED THE LOST OF MY JOB AND MANY OTHER HARDSHIPS. THEN ON JANUARY 2003, PONTIAC DECIDES TO SEND ME A RECALL LETTER, WHICH WAS TOO LATE FOR ME. MY QUESTION IS WHAT TOOK PONTIAC SUCH A LONG TIME TO ISSUE THE RECALL NOTICE? IF THEY HAD DONE IT EARLIER, I WOULD HAVE NEVER PURCHASE THIS USED VEHICLE IN 2002. FOUR YEARS IS A LONG TIME AND I AM SURE THERE MUST HAVE BEEN NUMEROUS ACCIDENTS, HOPE THEY WERE AS LUCKY AS ME WHO IS ALIVE TO TELL THE STORY. NOW FOR MY RIGHTS..... WHAT ARE THEY IN THIS SITUATION? AS I SAID BEFORE, THIS "MINOR MISTAKE OF GM" LEFT ME WITHOUT CAR, WITHOUT SAVINGS AND WITHOUT A JOB. I STRONGLY BELIEVE THAT GM SHOULD COMPENSATE ME WITH AN EQUAL CAR OR THE EQUIVALENT FOR ME TO PURCHASE ANOTHER CAR, IT IS ONLY FAIR. IF THE PROBLEM WAS MADE PUBLIC IN 1999 OR 2000 I WOULD NOT BE IN THIS PREDICAMENT. PLEASE PRESENT MY COMPLAINT TO THE MANUFA

RECALL #02-V-286-000 THE RECALL REGARDING THE RACK AND PINION FAILED, AFTER THE RECALL WAS PERFORMED.*JB

THE REAR SEAT BELTS WHEN CAR IS COLD WILL NOT COME OUT. THIS HAS BEEN AN ONGOING ISSUE, WITH SMALL CHILDREN THAT NEED TO BE SEATBELTED.

THE DRIVER SIDE WHEEL LOCK UP CAUSING A ACCIDENT. PLEASE FILL IN ADDITIONAL INFORMATION. DEALER IS AWARE OF THE PROBLEM. PH