2017 Pierce Saber

Defect. Pierce Manufacturing (Pierce) is recalling certain 2017-2021 Arrow XT, Enforcer, Impel, Quantum, Saber, and Velocity vehicles. The sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak.

Risk. A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy. Dealers will inspect the rail threads and fuel lines, and replace the rail as necessary, free of charge. Interim notification letters were mailed to owners on June 24, 2021. Owner notification letters were mailed July 30, 2021. Owners may contact Pierce customer service at 1-888-974-3723.

Defect. Pierce Manufacturing (Pierce) is recalling certain 2016-2018 Enforcer, Freightliner and Saber vehicles equipped with ECCO Holdings Code 3 7x9 Stop-Tail-Turn Reverse All-in-One LED stop, tail, turn, and reverse lights. The rear LED lights may be too bright. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Risk. The excessive brightness may negatively affect the vision of other drivers, increasing the risk of a crash.

Remedy. Pierce will notify owners, and dealers will provide a filter kit to be installed in the rear lights, free of charge. The recall is expected to begin April 26, 2021. Owners may contact Pierce customer service at 1-888-974-3723.

Defect. Pierce Manufacturing (Pierce) is recalling certain 2017-2018 Pierce Arrow XT, Dash, Enforcer, Impel, Quantum, Saber, Velocity, and Commercial vehicles equipped with Whelen accessory brake lights. Depending on the specific wiring of the vehicle, these brake lights may illuminate when the brake pedal has not been pressed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

Risk. If the brake lights incorrectly illuminate, it can confuse other drivers, possibly increasing the risk of a crash.

Remedy. Pierce will notify owners, and Whelen will inspect the vehicles and replace the brake lights, as necessary, free of charge. The recall began March 4, 2019. Owners may contact Pierce customer service at 1-888-974-3723.

TL* THE CONTACT OWNS A 2017 (NA) PIERCE SABER 2017 FIRE TRUCK. THE CONTACT STATED THAT THE VEHICLE PRODUCED POOR DEF FLUID QUALITY IN THE DEF FLUID SENSOR, WHICH CAUSED THE VEHICLE TO DERATE. THE MANUFACTURER WAS CONTACTED AND SENT NEW DEF TANK HEADERS THAT WERE INSTALLED AT THE FIRE STATION EXPERIENCING MULTIPLE REPEAT FAILURES IN 6 TRUCKS ALL 2017 MODELS. THE DEF TANK IS BUILT FOR PIERCE BY AN OUTSIDE VENDOR. PIERCE HAS NOT SOLVED THE PROBLEM. ALL 6 TRUCKS EXPERIENCING MULTIPLE DEF HEADER DEF QUALITY FAULTS. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 29,549. *BF*JB

TL* THE CONTACT OWNS A 2017 PIERCE FIRE TRUCK. THE CONTACT STATED THAT THE VEHICLE PRODUCED POOR DEF FAULT CODES IN THE DEF FLUID SENSOR, WHICH CAUSED THE VEHICLE TO DECELERATE. THE MANUFACTURER WAS CONTACTED AND SENT NEW DEF TANK HEADERS THAT WERE INSTALLED AT THE FIRE STATION. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 29,549. *BF *TR