2005 Nissan Titan complaints

CRACKED EXHAUST MANIFOLDS. NISSAN HAS A POOR DESIGN AND I HAVE CHECKED ON LINE AND 100'S OF OTHERS HAVE COMMENTED ABOUT THE CRACKED EXHAUST MANIFOLDS. THESE ARE A SAFETY CONCERN AS I CAN SMELL THE EXHAUST GAS AROUND THE FRONT OF THE TRUCK, INSTEAD OF IT BEING PROPERLY TRANSFERRED OUT THE EXHAUST SYSTEM AS DESIGNED. NISSAN IS NOT SUPPORTING THE REQUIRED REPLACEMENT WHICH SHOULD BE FREE. THE REPAIR COST ARE IN THE THOUSANDS NOT ACCEPTABLE WHEN IT IS NISSAN POOR DESIGN ALL ALL TRUCKS WITH THESE MANIFOLDS ARE AFFECTED.

THE FRONT DRIVERS SIDE AXLE KEEPS FALLING OUT OF THE TRANSFER CASE. I BELIEVE DUE TO A C-CLIP FAILURE. THIS HAPPENS WHEN THE TRUCK IS IN MOTION AND THE STEERING WHEEL IS TURNED.

ON FEBRUARY 25, 2017 MY SON WAS GOING DOWN THE ROAD AND HIS 2005 NISSAN TITAN TRUCK COMPLETELY DIED, LOST ALL POWER STEERING, BRAKES, EVERYTHING. MY SON WAS ABLE TO GET THE TRUCK OFF THE BUSY ROAD WITHOUT GETTING REAR ENDED, WHICH WAS HARD TO DO FOR A 20 YEAR OLD. ONCE WE HAD THE VEHICLE DIAGNOSED, WE WERE TOLD IT WAS A FAULTY FUEL LEVEL SENSOR UNIT. THE VEHICLE SHOWED OVER 1/4 OF A TANK OF GAS, BUT IN FACT, IT WAS EMPTY. UPON DOING SOME RESEARCH, I FOUND OTHER 2005 NISSAN TITAN'S WERE RECALLED WITH THIS SAME ISSUE, HOWEVER, NISSAN TOLD ME, THAT MY VIN WAS NOT INVOLVED IN THE RECALL. THIS CONCERNS ME BECAUSE MY SON COULD HAVE BEEN SERIOUSLY INJURED OR KILLED FROM THE TRUCK DYING AS HE WAS GOING 50 MPH DOWN THE ROAD. I HAVE TRIED TO SPEAK WITH NISSAN, ASKING THEM TO LOOK INTO MY PARTICULAR VEHICLE, SINCE THERE IS A PAST HISTORY OF THIS PART FAILING ON OTHER TITANS. AFTER 3 PHONE CALLS, ALL THEY WILL TELL ME IS, IT ISN'T THEIR FAULT, THE VEHICLE IS OUT OF WARRANTY AND RECALL DOESN'T INVOLVE MY VIN. I AGAIN ASKED THEM TO CONSIDER EXPANDING THE RECALL TO INCLUDE MY VEHICLE AND WAS TOLD NO. THE TRUCK IS CURRENTLY IN THE SHOP TO GET THIS FIXED, BUT IT'S A SHAME THAT NISSAN WON'T EVEN CONSIDER LOOKING INTO THIS WHEN THEY KNOW IT'S AN ISSUE WITH OTHER TITANS. THIS TRUCK HAS BEEN IN THE FAMILY SINCE IT WAS PURCHASED BRAND NEW.

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE FUEL GAUGE FAILED TO FUNCTION AND THE FUEL GAUGE FAILED TO PROVIDE THE ACTUAL READING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL GAUGE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 10V074000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 125,000.

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING 45 MPH, THE ENGINE STALLED WITHOUT WARNING THE FAILURE WAS PERSISTENT. THE CONTACT ALSO STATED THAT THE VEHICLE FAILED TO INCREASE SPEED WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 122,000. UPDATED 04/10/17 LJ *CN

FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM RECALL FOR 2005 NISSAN TITAN - NISSAN CLEARLY HAS A RECALL FOR THE 2005 NISSAN TITAN FUEL GAUGE THAT IS NOT DISPLAYING CORRECTLY. UPON CONTACTING NISSAN, THEY HAVE SAID THE VIN I PROVIDED IS NOT AFFECTED WHICH IS RIDICULOUS AS MY 2005 NISSAN HAS THE SAME PROBLEM AS THE 340,000 TRUCKS THAT ARE AFFECTED. NISSAN HAS CLEARLY NOT INCLUDED ALL VIN'S THAT ARE AFFECTED. THIS IS A DANGEROUS PROBLEM AS THERE IS NOT INDICATION OF HOW MUCH FUEL IS IN THE VEHICLE SINCE THE GAUGE WILL NOT FUNCTION PROPERLY. IF THE VEHICLE QUITS ON A HWY DUE TO RUNNING OUT OF FUEL, NISSAN SHOULD BE COMPLETELY LIABLE FOR ANY AND ALL DAMAGE, INJURIES THAT THIS MAY CAUSE ON AN OPEN HIGHWAY. *TR

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT HEARD AN ABNORMAL NOISE AND OBSERVED THAT THE EXHAUST MANIFOLD WAS FRACTURED. THE VEHICLE WAS DIAGNOSED BY THE CONTACT HIMSELF. THE CONTACT STATED THAT HE WOULD ATTEMPT TO WELD THE MANIFOLD. IF NOT, THE EXHAUST MANIFOLD WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 53,000.

REAR AXLE SEAL LEAKS IN THIS MODEL IT IS A KNOWN PROBLEM YET NISSAN STILL CHOOSES TO DO NOTHING ABOUT IT ,IT IS A HUGE SAFETY ISSUE IT LEAKS FLUID CONTINUOUSLY ON TO THE BACK BREAKING SYSTEM SO NOT ONLY COULD IT COMPRISE YOUR WHOLE BACK END BUT ALSO YOUR ABILITY TO STOP YOUR VEHICLE SAFELY,THIS HAS BEEN REPORTED THOUSANDS OF TIMES TO YOUR AGENCY IN THE MEANTIME THE CONSUMERS CONTINUE TO REPLACE THESE EVERY 30-40,000 MILES JUST TO MAINTAIN THEIR SAFETY AND OTHERS ON THE ROAD WHEN I FEEL IT IS TIME NISSAN ADDRESS THIS AND TAKE THE NECESSARY STEPS TO ENSURE THE BRAKING SYSTEM IN THESE VEHICLES IS NOT CREATING A POTENTIAL HAZARD TOP THE DRIVER OR OTHERS ON THE ROAD . I TOOK MY VEHICLE IN FOR AN OIL CHANGE YESTERDAY ONLY TO FIND OUT MY SEAL IS LEAKING AGAIN AND NOW MY BACK BRAKES NEED TO BE REPLACED AGAIN BECAUSE THEY ARE NO LONGER SAFE DUE TO THE OIL LEAKING ON THEM AGAIN FROM THIS SEAL I DRIVE MY CHILDREN IN THIS VEHICLE DAILY TO SCHOOL TO GAMES AND IM THANKFUL THAT I HAPPENED TO NEED AN OIL CHANGE OR I WOULD HAVE HAD NO IDEA IT WAS LEAKING AGAIN OR JUST HOW UNSAFE MY DRIVING THIS VEHICLE COULD POTENTIALLY BE FOR MY CHILDREN AND MYSELF OR ANYBODY THAT IS DRIVING NEAR ME WHEN IT REQUIRES BRAKING TO STOP .

THE BRAKES FAILED DUE TO A PIN HOLE IN THE LEFT FRONT BRAKE LINE. THERE ARE THREE FITTINGS THAT ARE IN THE SAME LOCATION ON THE TRUCK. ALL THREE SHOWED SIGNS OF CORROSION. THE ONE THAT FAILED LOOKS LIKE IT HAD BEEN DAMAGED ON INSTALLATION. THIS TRUCK IS OVER 11 YEARS OLD AND HAS SPENT MOST OF THE TIME OUTSIDE. IT HAS BEEN LOCATED IN SOUTH FLORIDA THE ENTIRE TIME SO HAS NOT SEEN ANY SALT. ALL THE OTHER FITTINGS AND LINES LOOK FINE. YOU CAN SEE FROM THE PICTURE THE FLAT SPOT ASSOCIATED WITH THE HOLE. THERE HAS BEEN NO WORK DONE ON THIS LINE SINCE THE TRUCK WAS NEW. (I AM THE ORIGINAL OWNER) I HAVE THE FAILED LINE. I REPAIRED IT MYSELF WITH PARTS FROM THE LOCAL NISSAN DEALER. THE FAILURE OCCURRED WITH THE TRUCK ON MY PROPERTY AND THERE WAS NO ACCIDENT INVOLVED. SEE ATTACHED PHOTO OF THE HOLE IN THE LINE. THIS LINE COMES FROM THE ABS UNIT TO A FITTING CLOSE TO THE FRONT WHEEL.

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE AIR BAGS FAILED AND THE AIR BAG WARNING INDICATOR REMAINED ILLUMINATED. THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 06V459000 (ELECTRICAL SYSTEM); HOWEVER; THE REPAIR DID NOT CORRECT THE FAILURE. THE DEALER DIAGNOSED THAT THE AIR BAG WIRE WAS LOOSE, BUT THE WIRE REPAIR DID NOT CORRECT THE FAILURE. THE DEALER DIAGNOSED THE VEHICLE AGAIN AND DETERMINED THAT THE AIR BAG WIRING HARNESS ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 30,000.

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT NOTICED THAT THE EXHAUST MANIFOLD WAS LEAKING FUMES IN THE ENGINE COMPARTMENT WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A LOCAL DEALER WHERE IT WAS DIAGNOSED THAT THE EXHAUST MANIFOLD WAS CRACKED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000.

NISSAN PREVIOUSLY ISSUED A RECALL DEALING WITH THE WIRING HARNESS ISSUE, #06V459000 TO REROUTE AND CHANGE THE WIRING COVER. THIS AFFECTS THE AIRBAGS AND THE OPERATION OF THE SEAT BELTS, AS WELL AS THE AUDIO SYSTEM. THE AIRBAG LIGHT IS FLASHING AND THE REAR PASSENGER DOOR SPEAKER DOESN'T WORK. THE RECALL WAS JUST A TEMPORARY COVER UP OF THE PROBLEM. THE ISSUE CAME UP AGAIN AND THEY REFUSE TO FIX IT, WANTING TO CHARGE UPWARDS OF $1000 TO REPLACE THE WIRING HARNESSS, A PROBLEM THEY ARE ALREADY AWARE OF. THE RECALL DID NOT FIX THE PROBLEM, ONLY A TEMPORARY COVER-UP.

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING AT ANY SPEED, THERE WAS AN ODOR EMITTING FROM THE EXHAUST OF THE VEHICLE. AN INDEPENDENT MECHANIC DIAGNOSED THAT THE MANIFOLD WAS LEAKING AND NEEDED BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 44,000.

FRONT CONTROL ARM LOWER.

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT WHILE DRIVING THE VEHICLE AT ANY SPEED, THE VEHICLE LEAKED FUEL AND EXHAUST FUMES EMITTED. THE VEHICLE WAS DRIVEN TO THE DEALER BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE MILEAGE WAS 63,000.

LOST POWER TO VEHICLE WHILE DRIVING, POWER STEERING, BRAKES, ETC. NARROWLY AVOIDED ACCIDENT. GAS GAUGE INDICATED A QUARTER TANK OF GAS WHEN IT WAS ACTUALLY EMPTY. CONTACTED NISSAN, THEY SAID THERE WAS RECALL FOR THIS FOR THE YEAR MAKE AND MODEL, BUT MY VIN WAS NOT INCLUDED IN THE RECALL.

I HAVE A 2005 NISSAN TITAN WITH 31,000 MILES ON IT AND IT JUST FAILED A VEHICLE INSPECTION, BECAUSE THE FRAME WAS RUSTED THROUGH IN FRONT OF THE REAR WHEELS. I HAVE OWNED THE VEHICLE 10 YEARS AND 6 MONTHS AND THIS SEEMS VERY PREMATURE TO HAVE HAPPEN. OTHERWISE THE BODY LOOKS BRAND NEW.

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING APPROXIMATELY 7 MPH, THE ENGINE STALLED BECAUSE THE FUEL GAUGE READING WAS INACCURATE. THE FUEL TANK WAS EMPTY. THE VEHICLE WAS COASTED TO A SAFE LOCATION AND REFUELED. IN 2014, THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 10V074000 (FUEL SYSTEM, OTHER); HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS NOT REPAIRED A SECOND TIME. IN ADDITION, WHEN THE VEHICLE WAS PARKED WITH A QUARTER TANK OF FUEL, THE READING WOULD DISPLAY LESS AFTER RETURNING TO THE VEHICLE. THE FAILURE OCCURRED INTERMITTENTLY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 55,000.

"TAKATA RECALL" CRACKED MANIFOLDS BANK 1

EXHAUST MANIFOLD CRACKED AT ABOUT 75,000 MILES.

2005 NISSAN TITAN, THE HEATER WORKS INTERMITTENTLY, THE FAN BLOWS FINE ALONG WITH THE A/C, IT DOESN'T MAKE A DIFFERENCE IF THE TRUCK IS MOVING OR STATIONARY.THERE IS A CLICKING IN THE DASH WHEN I SWITCH THE CONTROL FROM, FLOOR TO DASH OR FROM DEFROST TO FLOOR, ETC. I PURCHASED THIS TRUCK IN 2015, BUT ASSUME IT HAS BEEN A PREVIOUS PROBLEM.

CERTAIN 2005 NISSAN TITANS WERE RECALLED IN CAMPAIGN #10V074000 DUE TO THE FUEL GAUGE SHOWING THAT THERE WAS FUEL REMAINING WHEN THE TANK WAS ACTUALLY EMPTY. THIS OCCURRED TO MY VEHICLE IN FEBRUARY 2013. THE VEHICLE SHUT DOWN AND I LOST POWER STEERING. I WAS LUCKILY ABLE TO TURN WITH ENOUGH FORCE TO LEAVE THE ROADWAY. AFTER CONTACTING NISSAN, THEY DECLARED MY VEHICLE WAS NOT PART OF THE RECALL AND WAS NOT AFFECTED ALTHOUGH I WAS HAVING THE EXACT SAME ISSUE.

I WAS RECENTLY DRIVING MY TRUCK DOWN INTERSTATE I-95 IN PHILADELPHIA WHEN I OUT OF NO WHERE I HEARD A LOW PITCHED HOWELING NOISE, I WAS PASSING THREW A CONSTRUCTION ZONE SO I COULDN'T PULL ONTO THE SHOULDER AND LOOK FOR A ISSUE. A FEW SECONDS LATER I HEAR A LOUD SERIES OF THUMPING AND MY TRUCK IN THE BLINK OF AN EYE IS TRAVELING SIDEWAYS AT ROUND 45MPH, I SWERVED AND MISSED SEVERAL CARS AND MANAGED TO JUST MISS THE GUARD RAIL AND COME TO A STOP. IF I WAS TRAVELING ANYTHING OVER 45MPH, IT WOULDN'T HAVE BEEN PRETTY FOR A LOT OF PEOPLE. I THEN INSPECTED THE VEHICLE TO FIND THAT THE REAR AXLE HAD LOCKED UP THE REAR WHEELS AND THE DRIVE SHAFT HAD TORN OUT OF THE REAR AXLE. DO TO THE REAR WHEELS SUDDENLY BECOMING LOCKED, MADE THE TRUCK NEAR IMPOSSIBLE TO STEER AND VERY DANGEROUS WHEN YOU CONSIDER THE SIZE OF THE VEHICLE. I HAD IT TOWED TO FIND THAT THE REAR AXLE HAD FILLED WITH MOISTURE DO TO A DEFECT IN THE SEAL & VENT OF THE SET UP. I HAVE COME TO FIND OUT THAT THIS IS A COMMON ISSUE IN THE NISSAN TITAN WORLD.

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING 20 MPH, THE VEHICLE LOST POWER AND RESTARTED AFTER NUMEROUS ATTEMPTS. THE CONTACT STATED THAT THE FUEL GAUGE WAS NOT REGISTERING. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 10V074000 (FUEL SYSTEM). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. UPDATED 02/05/16*LJ

THE EXHAUST MANIFOLDS ARE FAULTY AND CRACK ALLOWING DEADLY CARBON MONOXIDE EXHAUST GASES TO ENTER THE CAB OF THE TRUCK WHILE THE VEHICLE IS IN OPERATION. THIS COULD CAUSE THE DRIVER TO LOSE CONSCIOUSNESS AND CRASH. IT WAS ONLY AFTER MY 6TH LONG ROAD TRIP (3+ HOURS DRIVING) DID I DISCOVER I WAS BEING POISONED BY CARBON MONOXIDE. I TOOK MY TRUCK TO AN EXHAUST REPAIR COMPANY AND AS SOON AS I MENTIONED MY VEHICLE THE TECHNICIAN TOLD ME HE WAS 99% SURE I HAD A CRACKED MANIFOLD. HE LATER CONFIRMED THIS WITH A DIAGNOSTIC TEST WHICH REVEALED BOTH MANIFOLDS CRACKED AND LEAKING EXHAUST FUMES INTO THE CAB. THIS COULD HAVE KILLED ME JUST SITTING IN A PARKING LOT! I THOUGHT I WAS JUST GETTING BAD HEADACHES FROM THE LONG DRIVE AND MY NAUSEA WAS FROM THE EXTREME HEADACHES. AFTER THIS HAPPENING SO MANY TIMES I KNEW THERE HAD TO BE MORE TO THIS. THINK ABOUT SOMEBODY DRIVING, BEING POISONED TO THE POINT TO WHERE THEY PULL OFF THE ROAD TO REST AND TRY TO SLEEP OFF THEIR HEADACHE IN A RUNNING VEHICLE TO STAY WARM AND END UP DYING. NISSAN NEEDS TO FIX THIS. I DON'T WANT A NEW DEFECTIVE MANIFOLD, I WANT A FIX!

THE TRANSMISSION STOPPED WORKING WHILE DRIVING ON HIGHWAY SUDDENLY; THE RPM'S REVVED UP ACCESSIBLY TO 3000-4000 WITHOUT GOING INTO GEAR. AFTER I IMMEDIATELY PULLED OVER I WITNESSED FLUID SPEWING ALL OVER MY ENGINE, OUT ON THE SIDES OF MY VEHICLE, AND UNDER HOOD.

AFTER DRIVING FOR 250-300 MILES WITH STOPS FOR FUEL AND FOOD THE ENGINE LOSES POWER AND QUITS. AFTER GETTING OFF THE ROAD AND TURNING OFF THE IGNITION FOR SEVERAL MINUTES THE ENGINE WILL RESTART AND RUN FOR 10 T0 20 MINUTES UNTIL IT QUITS AGAIN. THIS HAPPENS ON INTERSTATE HIGHWAYS AT SPEED OF 70+/- MPH. THIS HAS BEEN HAPPENING FOR 6 OR 8 MONTHS. THE TRUCK HAS BEEN TO SEVERAL SHOPS AND SEVERAL PARTS HAVE BEEN REPLACED ACCORDING TO THE ECM SERVICE ENGINE CODES. NOTHING HAS SOLVED THE PROBLEM. TOOK THE TRUCK TO NISSAN DEALER FOR HELP. THEY COULD NOT FIND THE PROBLEM AND SAID THEY HAD NO RECORD OF ANY SUCH PROBLEM AND COULD NOT DO ANYTHING UNLESS THEY DROVE THE TRUCK AND HAD THE PROBLEM HAPPEN WHILE THEY WERE DRIVING. I DO NOT KNOW WHAT IS CAUSING THE ENGINE TO QUIT AT HIGHWAY SPEEDS AND AT THIS POINT NEITHER DOES NISSAN. I BELIEVE THIS LOSE OF POWER IS AS DANGEROUS AS THE GM IGNITION PROBLEM WHICH CAUSED A LOST OF POWER. SINCE I NEED THE TRUCK FOR TRANSPORTATION I CONTINUE TO DRIVE IT BUT TRY TO STAY IN THE RIGHT LANE SO I CAN GET OFF THE ROAD WHEN IT QUITS.

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THERE WERE FUMES COMING FROM THE VEHICLE CAUSING THE CONTACT TO BECOME NAUSEOUS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THERE WERE TWO CRACKS ON THE MANIFOLD AND IT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 155,000.

REAL AXLE SEAL LEAK. NISSAN DOES NOT RECOMMEND REPLACING THE SEAL BUT SAYS THERE IS A PROBLEM WITH THE AXLE AND TO REPLACE AXLE. IF NISSAN KNOWS THE AXLE IS FAULTY AND REQUIRES THE AXLE TO BE REPLACED INSTEAD OF JUST REPLACING THE SEAL THEN THEY SHOULD BE RESPONSIBLE AND PAY FOR THE FIX UNDER A RECALL.

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT WHILE DRIVING, THERE WAS AN ABNORMAL NOISE COMING FROM THE EXHAUST MANIFOLD. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE EXHAUST MANIFOLD AND THE CATALYTIC CONVERTER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000. THE VIN WAS NOT AVAILABLE.

DRIVING TO WORK IN THE MORNING RUSH HOUR TRAFFIC, AT APPROX 65 MPH, I EXPERIENCED MY 2005 NISSAN TITAN SHUT COMPLETELY DOWN LOSING ALL POWER TO THE ENGINE RESULTING IN A LOSS OF POWER TO ALL SUPPORTING ENGINE ACCESSORIES INCLUDING THE POWER STEERING AND ABS. I ATTEMPTED TO RESTART THE VEHICLE WHILE DRIVING, BY DOWN SHIFTING TO NEUTRAL, WHICH FAILED. FORTUNATELY I WAS ABLE TO FIND A FIND A SPOT TO PULL OVER ON THE SIDE OF THE BUSY HIGHWAY AND CALL FOR ROADSIDE ASSISTANCE. IT WAS LATER DETERMINED THAT I HAD RUN OUT OF FUEL, DESPITE THE FUEL GAUGE SHOWING WELL OVER 1/4 OF A TANK OF USABLE FUEL. AT THIS POINT I DISCOVERED A RECALL CAMPAIGN FOR THE 2005 - 2009 NISSAN TITAN INSTRUMENT PANEL FUEL GAUGE (NHTSA CAMPAIGN NUMBER: 10V074000) AND PROCEEDED TO CALL THE PHONE NUMBER LISTED IN THE REMEDY PORTION OF THE RECALL. WHEN SPEAKING WITH NISSAN IT WAS DETERMINED THAT MY VIN WASN'T INCLUDED IN THE RECALL CAMPAIGN, AND AN APPOINTMENT WAS MADE AT THE LOCAL NISSAN DEALERSHIP BY NISSAN CONSUMER AFFAIRS TO CONFIRM MY FINDING AND SEE IF THEY WOULD BE ABLE TO COMPLETE THE REPAIR FOR ME UNDER THE RECALL. WHEN I BROUGHT MY VEHICLE TO MY LOCAL NISSAN DEALERSHIP THEY INFORMED ME THAT THE VEHICLE VIN WASN'T APART OF THE RECALL, BUT DID SEE A SERVICE BULLETIN ASSOCIATED WITH THAT MAKE AND MODEL. IT WAS ULTIMATELY DETERMINED THEY WOULDN'T BE ABLE TO RECOVER WARRANTY MONEY FROM NISSAN, AND INFORMED ME THAT I WOULD NEED TO PAY FOR THE REPAIR OUT OF POCKET. BOTTOM LINE, IT CAME DOWN TO A MONETARY ISSU

THE TRUCK STALLED OUT NO POWER HAD TO CRASH INTO SHOULDER OF ROAD AND EMBANKMENT. GLAD WE SURVIVED THE BUMPY CRASH, I JUST HAD SUSPENSION WORK DONE THAT SAVED US. WE READ THE IPDM BOARD OR ECM RELAY IS BAD AND CAUSES THIS STALLING TO HAPPEN. PART NUMBER FOR ECM RELAY 284B7-CW29.

REAR DIFFERENTIAL FAILED. REAR SEAL AND E LOCKER FAILED

HI, I HAVE A 2005 NISSAN TITAN AND THE EXHAUST MANIFOLD HAS CRACKED IN THE SAME SPOT TWICE NOW AND IT IS BEFORE THE CAT SO THAT MEANS ITS NOW A GROSS POLLUTER. THE PROBLEM IS YOU GET IT FIXED AND THEY PUT THE SAME PART BACK ON THAT CRACKS AGAIN BECAUSE THEY HAVEN'T CHANGED THE DESIGN. THERE ARE 3 OTHER TITANS IN MY TOWN AND ALL OF US HAVE THE SAME STORY. ALSO THE SWAY BAR MOUNT ON ALL OF OURS ARE BROKE WITCH RESULTS IN VERY POOR HANDLING. I HOPE IT CAN BE RECALLED BEFORE SOMETHING SERIOUS HAPPENS. THANK YOU.

I BACK OUT OF MY DRIVEWAY, STOPPED THE TRUCK COMPLETELY, SHIFTED FROM REVERSE TO DRIVE AND AS SOON AS I TOUCHED THE ACCELERATOR PEDAL I HERD A LOUD POP AND THEN VIOLENT GRINDING. I SHIFTED MY TRUCK TO 4X4 TO PULL IT OFF THE ROAD WHERE IT IS STILL JUST SETTING WAITING TO BE REPAIRED. *TR

WE TOOK THE TITAN TO A NISSAN DEALERSHIP FOR RECALL SERVICE AND GENERAL SERVICE ONLY TO FIND OUT THAT THE FUEL LEVEL SENSOR THAT WAS ON RECALL NOTICE IS NOT COVERED ON OUR PARTICULAR VIN. INTERESTING THAT THE $110 DIAGNOSTIC TEST I WAS CHARGED FOR SHOWED THAT SENSOR HAS FAILED, BUT NISSAN REFUSES TO COVER MY VEHICLE UNDER THE RECALL. BY LOOKING AT THE COMPLAINTS ON THIS SITE, I CAN SEE I AM NOT THE ONLY CONSUMER AFFECTED BY THIS ISSUE. MAKES ME WONDER IF NISSAN IS ACTUALLY HONORING ANY OF THE RECALLS FOR THIS PARTICULAR REPAIR. INTERESTING THAT AFTER MY SERVICE DATE, I WAS CONTACTED BY A SALES REPRESENTATIVE WITH THE SAME DEALERSHIP ASKING IF I WOULD CONSIDER BRINGING IN MY 2005 TITAN FOR A TRADE-IN OPPORTUNITY. I DON'T WANT A NEW CAR, I WANT THIS ONE REPAIRED WITH THE RECALL THAT WAS ISSUED TO ADDRESS THIS PROBLEM. I CONTACTED THE NATIONAL OFFICE AND WAS ASSIGNED A CASE NUMBER AND THE INDIVIDUAL HANDLING THE CASE ALSO DECLINED MY REQUEST FOR REPAIR. ON THAT SAME CALL, I WAS ASKED HOW MANY NISSAN VEHICLES I OWN AND IF I WOULD CONSIDER BUYING A NISSAN IN THE FUTURE. BASED ON MY EXPERIENCE WITH THIS RECALL, I WILL NEVER OWN ANOTHER NISSAN. NOR WILL I RECOMMEND NISSAN TO ANYONE WHO ASKED WHAT OUR EXPERIENCE HAS BEEN WITH THIS VEHICLE AND THE NISSAN MOTOR CORPORATION. *TR

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE FUEL TANK WAS EMPTY AND NEEDED FUEL IN ORDER TO START THE VEHICLE. ALSO, THE TECHNICIAN NOTICED THAT THE FUEL GAUGE READ A QUARTER TANK FULL. AS A RESULT, THE TECHNICIAN DIAGNOSED THAT THE FUEL SENDER UNIT INSIDE THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 10V074000 (FUEL SYSTEM, OTHER). THE APPROXIMATE FAILURE MILEAGE WAS 170,000.

WHEN I PUT VEHICLE IN DRIVE, IT WOULD ONLY GO IN REVERSE. I DISCOVERED THE LINKAGE FROM THE GEARSHIFT LEVER TO THE CABLE HAD SEPARATED. THE PLASTIC RETAINING RING ON THE SHIFT CABLE HAD BROKEN TO PIECES AND LEFT NOTHING TO HOLD THE CABLE TO THE SHIFT LEVER. THIS IS POTENTIALLY EXTREMELY DANGEROUS AS A DRIVER COULD MOVE LEVER TO PARK AND THINK HE IS ACTUALLY IN PARK WHEN THE TRANSMISSION IS ENGAGED. SOMEONE GETTING OUT OF THE VEHICLE WHILE IT IS STILL RUNNING WILL THEN HAVE A RUNAWAY VEHICLE. LOCAL NISSAN DEALER HAD NO REPLACEMENT PART. I INSTALLED A RETAINING RING AND CLIP. THE FIX COSTS PENNIES AND JUST A FEW MINUTES TIME. *TR

WHILE DRIVING ON A HIGHWAY AT APPROXIMATELY 55 MPH, MY ENGINE STALLED. I LOST ALL ENGINE POWER TO MY TRUCK, WITH NO ERROR CODES, NO CHECK ENGINE LIGHT. I HAD TO PLACE MY TRUCK IN NEUTRAL WHILE AT SPEED IN TRAFFIC IN THE LEFT LANE AND COAST TO A SAFE LOCATION ON THE RIGHT SHOULDER. DURING THIS TIME, I HAD NO POWER STEERING OR POWER BRAKES. AFTER I SAFELY STOPPED ON THE SHOULDER, I TRIED TO RESTART MY ENGINE. MY ENGINE WOULD NOT START. APPROXIMATELY ONE MONTH PRIOR TO THIS INCIDENT, MY TRUCK HAD INTERMITTENTLY STALLED WHILE STOPPED, WITH AN ERROR CODE THAT POINTED TO AN INEFFECTIVE CATALYTIC CONVERTER. I HAD MY MASS AIR FLOW SENSOR REPLACED, MY ECM RELAY REPLACED, AND MY CATALYTIC CONVERTER REPLACED, AT A COST OF ~ $5000 TOTAL. I AM NOW TOLD THE INTELLIGENT POWER DISTRIBUTION MODULE IS LIKELY THE CULPRIT FOR ALL OF THESE PROBLEMS, WHICH WILL COST ME ANOTHER $700 TO REPLACE. IN RESEARCHING PREVIOUS RECALLS, THERE IS AN EXISTING RECALL FOR THE ECM RELAY, BUT NOT THE IPDM MODULE. IT APPEARS IN OTHER TITAN FORUMS THAT SEVERAL OTHER PEOPLE HAVE SUFFERED FROM THE SAME ISSUE. *TR

AS I WAS REVERSING TO BACK OUT A PARKING SPOT I FELT A HARD THUD LOOKED UNDER AND AROUND TRUCK DIDN'T SEE ANYTHING IT STARTED SNOWING AND I HAD TO USE MY 4WHEEL DRIVE AND IT WOULD NOT ENGAGE THE INDICATOR SAID IT WAS IN 4WHEEL DRIVE BUT THE FRONT WHEELS WOULD NOT TURN TOOK IT A TRANSMISSION SHOP THEY TOLD ME MY LEFT FRONT AXLE POPPED OUT OF THE DIFFERENTIAL WHICH IS A COMMON PROBLEM WITH THE TITAN I FOUND SEVERAL COMPLAINTS ABOUT THIS AND THE SAME WAY MY TRUCK AXLE POPPED OUT AND SAME SIDE CALLED NISSAN AND THEY WONT FIX THIS PROBLEM ITS VERY COSTLY AND DANGEROUS SOME PEOPLE FRONT DIFF BLEW APART I THINK SOMETHING NEEDS TO BE DONE A RECALL OR SOMETHING IT CAN CAUSE A ACCIDENT. *TR

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE TRAVELING 40 MPH, THE VEHICLE STALLED AND THE BRAKES AND STEERING SEIZED. THE CONTACT STATED THAT THE FAILURE RECURRED THREE TIMES IN A FIVE MILE SPAN AND NO WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER AND IT WAS DETERMINED THAT THE ELECTRONIC CONTROL MODULE FAILED. THE DEALER STATED THAT THERE WAS A RECALL FOR THE ECM UNDER NHTSA CAMPAIGN NUMBER: 10V517000 (ENGINE AND ENGINE COOLING); HOWEVER, THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 124,000.

THIS IS THE SECOND DIFFERENTIAL PUT INTO TRUCK SINCE JULY 2014. THE FIRST ONE WAS WITHIN 30 DAYS OF PURCHASE AT 65,000 AND THE SECOND ONE AT 80,000 COSTING $3800.00. THE TRUCK IS BACK IN FOR REPAIR WITHIN 5 DAYS SINCE AND BACK BRAKES ARE NOT WORKING PROPERLY. WAITING TO HEAR FROM MECHANIC. *TR

I HAVE A 2005 NISSAN TITAN WHICH I PURCHASED USED AT 23,000 MILES. TWO YEARS AGO (2013) I HEARD A LOUD NOISE COMING FROM THE FRONT DIFFERENTIAL. I TOOK IT TO A MECHANIC AND I WAS TOLD THAT THE U-JOINTS FAILED WHICH COST $1400 DOLLARS. NOW, MARCH 2015, I AGAIN HEARD A LOUD NOISE COMING FROM THE FRONT DIFFERENTIAL. I FOUND THAT THE RIGHT AXLE HAD POPPED OUT. I TOOK IT TO A MECHANIC AND I WAS TOLD THAT THE FRONT DIFFERENTIAL FAILED WHICH COST $2300 DOLLARS. I WAS TOLD BY MY MECHANIC THAT BOTH OF THESE INCIDENTS COULD HAVE CAUSED ME TO CRASH AND THAT I WAS LUCKY. I HAVE HAD SEVERAL OTHER ISSUES WITH THIS VEHICLE (FUEL PUMP, BRAKES, EXHAUST SYSTEM). I WAS ALSO CONTACTED BY AN ATTORNEY WHO INFORMED ME THAT HE WAS CONDUCTING A LAW SUITE AND WANTED TO KNOW WHAT ISSUES I HAVE HAD. THE ATTORNEY INFORMED ME THAT MY VEHICLE WAS DEEMED A "LEMON" BY THE FIRST OWNER. *TR

WHILE PULLING OUR BOAT OUT FROM BOAT RAMP IN 4LO AND A LOUD NOISE CAME FROM DIFF. WHEN I ARRIVE HOME 25MIN LATER IN THE DRIVE WAY I NOTICED GEAR OIL FROM PASSENGER SIDE. UNDER TRUCK I NOTICED WHERE LEAK WAS COMING FROM AND PUSHED THE AXLE BACK AND IT STOPPED LEAKING. I DRAINED AND REMOVED SHAFT ASSEMBLY SIDE DIFF AND REPLACE SEAL AND REFILLED GEAR OIL. ON THE NEXT TRIP WE NOTICED GEAR OIL LEAK CAME HOME DID RESEARCH AND NOTICED THIS IS KNOWN PROBLEM PURCHASED THE CIRCLIP THINKING THAT WAS THE PROBLEM BUT AFTER LAST NIGHT NOTICED THE SHAFT BROKE WHERE THE CIRCLIP WAS SUPPOSE TO BE. LOOKED DOWN THE DIFF HOUSING AND NOTICED THE OTHER PIECE OF THE SHAFT NUB STUCK INSIDE. ESTIMATE $2500 FOR DIFF REPLACEMENT TO 38500-8S112B OR $825 TO REPLACE SHAFT AND GEAR. 3RD TIME I'VE EVER USED 4 WHEEL DRIVE!!!! *TR

2005 NISSAN TITAN. DOOR LATCH FAILURE DURING COLD WEATHER BELOW FREEZING. LIVE IN PA, SO TIME PERIOD OF THIS WEATHER IS DECEMBER - MARCH. DOOR WILL NOT OPEN, NOR CLOSE PROPERLY FROM INSIDE, OR OUTSIDE OF VEHICLE. HAD THIS PROBLEM LAST WEEK, WAS NOT ABLE TO GET BACK INTO VEHICLE FOR 10MIN . YESTERDAY DRIVING ON A HIGHWAY DOOR OPENED UNEXPECTEDLY AND PASSENGER NEARLY FELL OUT OF VEHICLE. NO ONE INJURED, HOWEVER YOU CAN IMAGINE THE EXPERIENCE AT HIGHWAY SPEEDS. I MUST DRIVE THE VEHICLE WITH A RATCHET STRAP FROM ONE DOOR TO THE OTHER TO KEEP THEM SHUT. THIS IS NOT SAFE BUT THE ONLY WAY TO FIX THE ISSUE AT THIS TIME. THERE IS A NISSAN TSB THAT THEY WILL REPLACE DOOR LOCKING MECHANISM IF VEHICLE IS UNDER WARRANTY. NISSAN USA: TBNS BX56AA / TSB 05118. HOWEVER IF VEHICLE IS NOT UNDER WARRANTY THEY QUOTED ME AT $400+ PER DOOR X'S 4 DOORS. THIS IS UNREASONABLE AND A SEVERE SAFETY HAZARD FOR MOST OF THE COUNTRY THAT EXPERIENCES WEATHER BELOW 32DEGREES F. IT IS A KNOWN FAILURE THAT NISSAN USA KNOWS ABOUT. THIS SHOULD BE A MANDATED RECALL. THERE WILL BE SEVERE LAWSUITS FILED IF ANOTHER PASSENGER, MY CHILD, OR MYSELF CANNOT GET INTO A VEHICLE, OR UNEXPECTEDLY FALLS OUT. BELOW ARE LINKS TO A NISSAN TITAN ONLINE FORUM WITH MULTIPLE OTHER COMPLAINTS ABOUT THIS. FROZEN DOOR LATCH PROBLEM NOT SOLVED...PLEASE ADVISE WINTER PROBLEMS WITH TITAN FROM USA FROZEN DOOR HANDLES FROZEN DOORS WONT CLOSE WHEN COLD!! NISSAN NEW TSB FOR THE FROZEN DOOR HANDLES! *TR

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE VEHICLE FAILED TO START AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT ALSO STATED THAT THERE WAS A STRONG ODOR OF FUEL PRESENT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 77,000.

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT WHILE DRIVING AT UNKNOWN SPEED, THE ENGINE STALLED WITHOUT ANY WARNINGS. THE CONTACT MENTIONED THAT THE VEHICLE WAS EXHIBITING THE SAME FAILURES LISTED IN RECALL NHTSA CAMPAIGN NUMBER: 10V517000 (ENGINE AND ENGINE COOLING). THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHERE IT WAS DIAGNOSED THAT THE ENGINE CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 137,000.

WHILE TRAVELING AT APPROXIMATELY 70 MPH ON A US HIGHWAY, THE VEHICLE BEGAN TO VIGOROUSLY SHAKE AND A LOUD CLANKING NOISE BEGAN FROM THE REAR OF THE VEHICLE. SUDDENLY THERE WAS A LOUD BANGING NOISE COMING FROM UNDERNEATH THE VEHICLE. UPON EXITING THE VEHICLE AS IT CAME TO A STOP, I NOTICED THAT THE REAR DRIVE SHAFT HAD FALLEN OFF. WHEN ATTEMPTING TO LOAD THE VEHICLE ON A WRECKER, THE REAR WHEELS WOULDN'T ROLL. THE ENTIRE REAR DIFFERENTIAL AND AXLE HAD SEIZED. *TR

THE OTHER DAY I WAS SITTING IN TRAFFIC FOR ALMOST 30 MIN STOPPED WITH THE ENGINE RUNNING (LOTS OF CHRISTMAS TRAFFIC ON THE 5 SOUTH FREEWAY), I PUT THE TRUCK IN PARK BECAUSE I NOTICE AN ACCIDENT. I HAD MY WINDOWS UP AND MY CABIN AIR ON. THEN A FEW MIN LATER I STARTED FEELING DIZZY ALMOST FAINTING. THE CAR NEXT TO ME SAW THAT I WAS STRUGGLING, CAME TO MY WINDOW AND ASKED ME IF I WAS OK. I ROLLED DOWN MY WINDOW AND HE NOTICED THE SMELL OF EXHAUST INSIDE MY TRUCK. AFTER MY HEADACHE WENT AWAY. I WENT TO THE DEALERSHIP AND THEY TOLD ME BOTH OF MY EXHAUST MANIFOLDS WERE CRACKED AND THAT'S HOW THE EXHAUST WAS ENTERING NEAR THE FRONT CABIN. *TR

REAR SEAL COMPLETELY FAILED WHILE DRIVING CAUSING DIFFERENTIAL OIL TO SATURATE THE REAR BRAKES. *TR