1992 Mazda Mpv

Defect. Mazda North American Operations (Mazda) is recalling certain model year 1989-1998 MPV, 1990-1995 323, 1990-1998 Protege, 1992-1993 MX-3, 1993-1995 929, 1993-1997 MX-6, and 1993-1998 626 vehicles. In the affected vehicles, grease applied to the contact points inside the ignition switch may become conductive and overheat.

Risk. If the ignition switch overheats there would be an increased risk of a fire.

Remedy. Mazda will notify owners, and dealers will replace the ignition switch, free of charge. The recall began on December 17, 2015. Owners may contact Mazda Customer Experience Center at 1-800-222-5500, option#6. Mazda's number for this recall is 8715J.

WHILE DRIVING, THE ACCELERATOR PEDAL WENT COMPLETELY TO THE FLOOR. THE VEHICLE THEN DOWN SHIFTED TO FIRST GEAR WITH THE THROTTLE WIDE OPEN. THE CRUISE CONTROL ENGAGED. THIS HAD NOT BEEN USED FOR A WHILE WHICH CAUSED AN ACCIDENT AND BROUGHT THE VEHICLE TO A COMPLETE STOP. *AK THE CONSUMERS GRANDDAUGHTER HAD GONE ON A RETURN TRIP, THE ACCELERATOR SUDDENLY WENT TO THE FLOOR, STAYED THERE AND HIT A VEHICLE. *SC *JB

WHILE DRIVING AT 50 MPH VEHICLE WAS INVOLVED IN A HEAD ON COLLISION, AIR BAGS DID NOT DEPLOY. VEHICLE WAS TOTALED. *AK

WHILE VEHICLE WAS IN REVERSE ACCELERATOR PEDAL GOT STUCK, CAUSING VEHICLE TO BECOME UNCONTROLLABLE.*AK

THERE WAS A VERY STRONG GAS ODOR IN THE CAB OF THE VEHICLE. *NLM

APPROACHING INTERSECTION WENT TO SLOW DOWN/STOP VEHICLE. BRAKES FAILED, UPON PRESSING ON BRAKE THERE WAS NOTHING BUT AIR. PEDAL TO THE FLOOR. CAR SKREECHED A FEW TIMES. ENDED UP GOING THROUGH RED LIGHT CAUSING ACCIDENT & INJURY.*JB

WITH THIS VAN THERE HAVE BEEN NUMEROUS INCIDENTS SINCE AUGUST OF 1993. THE FIRST PROBLEM WAS A TICKING NOISE IN THE ENGINE. THE VAN WAS OUT OF SERVICE FOR 3 MONTHS WHILE THEY DALLIED AROUND TO FIX IT. I HAD IT TAKEN TO NORTHTOWNE MAZDA AND IT TOOK THEM A WEEK TO FIX IT. THE SECOND PROBLEM WAS A CONSTANT BREAKAGE OF THE LITTLE PIN THAT SHIFTS THE GEARS. THE THING BREAKS CONSTANTLY AND CAUSES THE GEAR DIAL LETTERS TO BE OFF BY ONE LETTER FOR INSTANCE THE R FOR REVERSE IS D FOR DRIVE. THE NEXT PROBLEM WAS A GAS LEAK THAT I TOOK IN TO HAVE FIXED THREE TIMES BEFORE IT WAS FINALLY FOUND. I WAS TOLD ON TWO DIFFERENT OCCASIONS THAT IT WAS JUST EXHAUST AND THAT THE PROBLEM COULD NOT BE FOUND. I DROVE THE VEHICLE TO MEMPHIS AND LIKED TO GAS MYSELF TO DEATH FROM THE FUMES ON THE WAY THERE AND BACK. UPON RETURN TO KCMO I TOOK IT DIRECTLY BACK TO THE DEALER. THE SERVICE MANAGER SAID JUST LEAVE IT OUTSIDE AND WE WILL BRING IT IN AND CHECK IT. I MADE HIM COME OUTSIDE TO THE CAR. YOU COULD SMELL THE GAS FROM 50 FEET AWAY. WHEN HE TOOK IT IN THERE WAS A RUPTURE INTHE FOURTH QUARTER PANEL HOSE THAT WHEN YOU TOOK A LEFT TURN IT SPILLED GAS INTO THE PASSENGER REAR SEAT. THE NEXT PROBLEM THAT I HAD WITH THIS VEHICLE WAS THAT THE CALIPERS, ROTORS AND BRAKES WORE CLEAN THROUGH AFTER ONLY 20,000 MILES OF WEAR ON THE NEW BRAKES. FIRESTONE FIXED THEM. THEN I HAVE HAD TO REPLACE THE TIMING BELT NOW 5 TIMES. I HAD THE FIRST TIMING BELT WAS REPLACED AT 66,000 MILES, THE SECOND AT 78,000 MILES, THE NEXT A

RECEIVED INFORMATION ON SPECIAL PROGRAM #SSP-33 FROM MAZDA REGARDING FUEL FUMES. TOOK VEHICLE TO DEALERSHIP. MECHANIC REFUSED TO DO ANY REPAIRS ON VEHICLE. *AK CONSUMER ADDS WHILE DRIVING UP HILL, VEHICLE WILL ONLY ACCELERATE UP TO 10 MPH, ONCE REACHED LIGHTS FLICKER ENGINE, BRAKES AND STEERING LOCKED UP, RESULTING IN LOSS OF CONTROL, VEHICLE STARTED SMOKING AND STEAMING CAUSING THE ENGINE AND TRANSMISSION TO FAIL, ON SEVERAL OCCASIONS ENGINE IS OVERHEATING, COOLANT LEAKS AT ENGINE, THE WATER PUMP BELT BROKE, DEALER REPLACED COOLANT HOSES, WATER PUMP, TIMING BELTS, HEAD CYLINDER, THERMOSTAT, RADIATOR HOSE AND FAN CLUTCH. *TT

WHILE DRIVING ON THE HIGHWAY, CONSUMER WENT TO CHANGE LANES WHEN THE RIGHT REAR TIRE BLEW OUT, CAUSING CONSUMER TO LOOSE CONTROL OF VEHICLE AND HIT A GUARDRAIL TWICE, PASSENGERS IN THE VEHICLE SUFFERED INJURIES, IN WHICH ONE PASSENGER WAS EJECTED FROM VEHICLE, TIRE INFORMATION (THOROBRED STEEL P205/75R14 M/6 DOT MYKCEA9.(OHIO TRAFFIC CRASH REPORT #10-89-181).*JB

WHILE DRIVING 5-10 MPH APPLIED BRAKES, PEDAL FELT SOFT, BRAKES FAILED. RIGHT FRONT BRAKE PAD HAD FALLEN OUT. THIS HAPPENED AGAIN ON 28 APR 2001.*AK

WHILE DRIVING CONSUMER NOTICED FUEL LIGHT HAD COME ON, BUT GAS GAUGE SHOWED HALF A TANK, CONSUMER PULLED OVER, OPENED HOOD, AND RADIATOR RESERVOIR EXPLODED, AND HE RECEIVED BURNS. THERE WAS NO SMOKE PRIOR TO THAT. *AK

WHILE MOTOR WAS RUNNING WITH CONSUMER NOT IN VEHICLE, VEHICLE STARTED GOING BACKWARD, HIT 2 PARKED CARS, SPUN AROUND, WENT 100 YARDS, AND HIT A UTILITY POLE. AFTER CONSUMER TURNED OFF ENGINE, HE NOTICED VEHICLE WAS IN REVERSE, NOT IN PARK AS HE PUT IT. *AK *SLC

LOCKS ON THE PASSENGER'S SIDE WILL NOT UNLOCK AT ALL. *AK

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

HEADLIGHTS SPORADICALLY TURN ON. ENGINE MAY BE OFF OR ON, AND THE HEADLIGHTS WOULD AUTOMATICALLY TURN ON. VEHICLE WAS TAKEN TO DEALER, AND DEALER STATED THAT THE PROBLEM HAS BEEN OCCURRING TO NUMEROUS VEHICLES OF SAME MAKE/MODEL AND YEAR.

DOES NOT ALLOW FOR ENOUGH OIL FLOW IN THE ENGINE LIFTERS, CAUSING ENGINE FAILURE . MANUFACTURERIS AWARE OF DEFECT, AND HAS REDESIGNED PART . *AK

NO SUMMARY

FEED HOSE IS TOO SMALL FOR THE OIL TO GO THROUGH, CAUSING THE LIFTER TO COLLASPE AGAINST ROCKER ARM, RESULTING IN A LOUD NOISE. FAULTY DESIGN IN THE ENGINE. *AK

TRANSMISSION HAD BEEN REBUILT, UNDER THE WARRENTY, AFTER I MOVED TO OHIO, FOR A NEW JOB, THE WARRENTY HAD RUN OUT, AND I NEEDED TO GET THE CAR REPAIRED, BUT I NEVER PROCEEDED WITHA COMPLAINT AT THAT TIME

OIL SMOKE, VALVE OR LIFTER NOISE, RATTLE WHEN VEHICLE NOT IN ACCELERATION. *AK

MAZDA HAS A PROBLEM WITH THE WIPER ARM-IT QUIT DURING MY COMMUTE DURING A HARD RAIN. IT POSED A VERY REAL DANGER. REGARDING THE ENGINE: MAZDA KNOWS THERE IS A DESIGN PROBLEM AND IT HAS A VERY EXPENSIVE FIX...I NOW OWN A 2ND MPV ONLY TO HAVE THE SAME HLA PROBLEM WITH THIS SECOND VAN. NOW I KNOW IT'S AN INHERENT PROBLEM AND THE CONSUMER IS HAVING TO PAY FOR THIS VERY EXPENSIVE FIX.