2009 Lincoln Mkz

Defect. Ford Motor Company (Ford) is recalling certain 2007-2011 Ranger, 2006-2012 Fusion, Lincoln Zephyr, Lincoln MKZ, 2006-2011 Mercury Milan, 2007-2010 Ford Edge, and Lincoln MKX vehicles. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Risk. An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy. Ford will notify owners, and dealers will replace the driver-side airbag inflator or module with an alternate one, free of charge. Owner notification letters were mailed on April 9, 2021 for the passenger side, and November 14, 2022 for the driver side. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S12.

Defect. Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Risk. In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy. Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.

Defect. Ford Motor Company (Ford) is recalling certain 2006-2010 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ vehicles. The valves within the ABS Hydraulic Control Units (HCU) may react with brake fluids containing specific corrosion preventative additives. This reaction may cause the valves to not close properly.

Risk. If the valves do not properly close, additional brake pedal travel may be required to stop the vehicle, increasing the risk of a crash.

Remedy. Ford will notify owners, and dealers will flush the brake system with DOT 4 fluid and install a new brake fluid reservoir cap. In addition, the HCU will be tested to detect a possible stuck valve condition, replacing the HCU as necessary. All services will be performed free of charge. The recall began April 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S54.

Defect. Ford Motor Company (Ford) is recalling certain 2013 Ford Mustang vehicles sold, or ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, Ford is recalling certain 2010 Ford Edge, Fusion, Mustang and Ranger, Lincoln MKX and Zephyr/MKZ, and Mercury Milan vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Ford is also recalling certain 2009 Ford Edge, Fusion, Mustang and Ranger, Lincoln MKX and Zephyr/MKZ, and Mercury Milan vehicles ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." These vehicles are equipped with air bag inflators assembled as part of the passenger frontal air bag modules, used as original equipment or replacement equipment (such as after a vehicle crash necessitating replacement of the original air bags), that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Risk. An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy. Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.

Defect. Ford Motor Company (Ford) is recalling certain 2012 Ford Fusion and Mustang and Lincoln Zephyr and MKZ vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain 2009 Ford Ranger, Edge, Fusion and Mustang, Lincoln MKX, MKZ and Zephyr and Mercury Milan vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above, Ford is recalling certain 2007-2008 Ford Ranger, Edge and Lincoln MKX, 2006-2008 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ, 2005-2008 Ford Mustang and 2005-2006 Ford GT vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Risk. An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy. Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Interim letters informing owners of the recall and that parts are not yet available began mailing March 1, 2017. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.

Defect. Ford Motor Company (Ford) is recalling certain model year 2007-2011 Ford Ranger vehicles, 2006-2011 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2007-2010 Ford Edge, Lincoln MKX vehicles, 2005-2006 Ford GT vehicles, and 2005-2011 Ford Mustang vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain model year 2007-2008 Ford Ranger, Edge and Lincoln MKX vehicles, 2006-2008 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2005-2006 Ford GT vehicles and 2005-2008 Ford Mustang vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Any vehicle not included in "Zone A", or "Zone B" is not included in the safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Risk. An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy. Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Ford mailed interim letters informing owners that parts are not yet available on July 15, 2016. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.

Defect. Ford Motor Company (Ford) is recalling certain all weather driver side accessory floor mats sold for use in model year 2006-2011 Ford Fusion and Mercury Milan, 2006 Lincoln Zephyr, and 2007-2011 Lincoln MKZ vehicles manufactured November 9, 2007, through October 31, 2010. The affected floor mats may move and possibly interfere with the accelerator pedal.

Risk. The floor mat could shift such that it could interfere with the accelerator pedal, preventing its return to an idle position, which could result in unintended vehicle speeds, increasing the risk of a crash.

Remedy. Ford will notify owners, and dealers will install new replacement mats, free of charge. The recall began in July 2014. Owners may contact Ford's customer service at 1-800-392-3673. Ford's number for this recall is 14S07. NOTE: Vehicles built after October 31, 2010, while potentially equipped with the same floor mats, are equipped with a Brake Over Accelerator (BOA) feature that prevents simultaneous accelerator and brake application, allowing the vehicle to be safely stopped by pressing firmly and steadily on the brake pedal.

Indicator light came on for passenger side airbag says it has recall and it looks as though the airbag is trying to come out of its compartment

The contact owns a 2009 Lincoln MKZ. The contact stated that while parked in a semi-truck parking lot, another driver was reversing where she was blocking, and the contact then attempted to avoid the collision and drive forward. The accelerator pedal was depressed however, the vehicle accelerated excessively, and the brake pedal was then depressed but failed to respond. Upon a second attempt, the brake pedal went to the floorboard, accompanied by an abnormal vibration. Consequently, the vehicle crashed into a tree. No warning lights were illuminated prior to the incident. The driver mentioned a previous incident where the vehicle reversed into a gate. The contact referenced NHTSA Campaign Number: 19V904000 (Service Brakes, Hydraulic). The brakes had been checked previously and were reportedly functioning properly. During the crash, the air bags deployed, and the driver sustained a head injury but did not seek medical attention. No fire or police report was filed as the incident occurred on private property. The local dealer was contacted and mentioned an extended warranty. The dealer suggested towing the vehicle, but it was not diagnosed or repaired. The manufacturer was contacted multiple times, including their legal department, but no response was received. The failure mileage was approximately 110,000.

2 years ago air bags were replaced on a recall notice. Last week dash board is showing a warning notice with the air bag(s) again. Is there another recall for the air bags? Do I have to pay for replacement?

My MKZ suddenly cut off without warning lamps or messages at highway speed. There was a very quick shudder and all power lost. After pulling onto the road shoulder and waiting a few minutes, it restarted and drove normally. I stopped about 15 minutes later and switched it off. When returning to the vehicle, it would not start. I had it towed to a garage where it has been for 6 weeks. They have been unable to identify the problem and get it restarted. Online reports by others indicate this occurred with other Lincoln products over a span of a few years with no assistance from Lincoln/Ford to identify the problem. This is a HUGE safety issue, as well an immediate personal inconvenience.

Complaint Lincoln 2009 MKZ air vent grid on dash board broke in various places and collapse also, it appears the dash board in front of air vent grid is raised. Causing the defroster to not work properly and the window shield does not clear properly. I was told to fix the problem the whole dash board needs to be replaced. I see this as a design and manufacturer defect and that Lincoln should repair at no cost to Lincoln owners. Lincoln is a Luxury line this should not be happening.

The contact owns a 2009 Lincoln MKZ. The contact received notifications of NHTSA Campaign Numbers: 19V904000 (Service Brakes, Hydraulic) and 21V158000 (Air Bags) however, the parts to do the recall repair were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

BRAKE PEDAL FAILURE 7 MONTHS AFTER BRAKE FLUID RECALL WAS DONE.

The Lincoln Mercury factory chrome plated rims leak air all the time making the tires low on air or flat very often! This is a very dangerous safety hazard that can cause loss of control and having an accident resulting in serious bodily injury or death! There are many numerous other Lincoln car owners that report the same symptoms and problems. The manufacturer never plated the rims properly with nickle prior to chrome plating, thus the chrome coating constantly peels off and corrodes; thus air leaks past the tire bead and the rim surface. This sounds like a giant class action lawsuit!! I am are both very upset and scared to drive under these horrific conditions, but I have no choice as news factory rims are very expensive and I cannot afford them since I am disabled and on a fixed income.

Leaking brakes had to be fixed twice before recalled parts were available. When the last repair was done, dealership said they would reimburse us (since we paid full price) recalled parts labor that we had to pay for since they were on the recall. This has never happened even though we have tried multiple times to remedy. Dealership says they sent in paperwork to Ford twice for the reimbursement as they don't do that. Ford Motor Company says they dont do it that it is up to the dealer. In summary, recalled brakes were finally repaired but we had to pay full price for them though it says parts and labor would be free.

The contact owns a 2009 Lincoln MKZ. The contact received notification of NHTSA Campaign Number: 19V904000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact took the vehicle to the dealer for the recall repair and the Hydraulic Control Unit (HCU) was tested but failed. The dealer informed the contact that the HCU part for the recall repair was not available. The manufacturer was made aware of the issue and informed the contact that they had difficulties obtaining the part for the recall repair. The failure mileage was 22,000. VIN tool confirms parts not available.

TOOK MY CAR IN FOR RECALL #19V904 SAID COULD NOT FIX BECAUSE THE ECU WAS ALSO BAD, IT HAD JUST WENT OUT MY PROBLEM IS THAT FORD WILL NOT FIX THE RECALL IF I DON'T PAY THEM 777.00 TO FIX THE ECU FIRST, AND I THIK THEY SHOULD BECAUSE IT'S ALL TIED TOGETHER I.E. THE VERY SAME SYSTEM

BRAKE PEDAL WENT ALL THE WAY AND TOUCH BODY. IT HAPPENED TWICE IN TWO MONTHS AND 2ND TIME RESULTED IN TO CAR WRECK ON 5 MILES PER HOUR SPEED. IT IS VERY DISAPPOINTING LINCOLN SEEMS TO KNOW ABOUT THE ISSUE BUT TOOK A LONG TIME TO COVER WITH REMEDY. * (RECALL RELATED INCIDENT) TS

TL* THE CONTACT OWNS A 2009 LINCOLN MKZ. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V904000 (SERVICE BRAKES, HYDRAULIC) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT CALLED DAVE SINCLAIR LINCOLN (7500 S. LINDBERGH BLVD, ST. LOUIS, MO 63125, (314) 729-2700) WHERE IT WAS CONFIRMED THAT THE PART WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

DOT 3 BRAKE FLUID AND ANTI-LOCK BRAKE SYSTEM FUNCTION IS DEFECTIVE AND THE ISSUE IS NOT BEING ADDRESSED AFTER A NUMBER OF YEARS

TL* THE CONTACT OWNS A 2009 LINCOLN MKZ. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V904000 (SERVICE BRAKES, HYDRAULIC) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE BRAKE PEDAL WAS INTERMITTENTLY DEPRESSED TO THE FLOORBOARD WITHOUT WARNING. TODD JUDY FORD OF HUNTINGTON (2480 5TH AVE, HUNTINGTON, WV 25703) WAS CONTACTED AND IT WAS CONFIRMED THAT PARTS WERE NOT YET AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND PROVIDED THE SAME INFORMATION AS THE DEALER. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE FAILURE MILEAGE WAS UNKNOWN. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2009 LINCOLN MKZ. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V904000 (SERVICE BRAKES, HYDRAULIC) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT CALLED JACK DEMMER LINCOLN, INC. (21531 MICHIGAN AVE, DEARBORN, MI 48124, (313) 274-8800) WHERE IT WAS CONFIRMED THAT THE PART WAS NOT AVAILABLE. THE CONTACT STATED WHILE DRIVING AT AN UNDISCLOSED SPEED, THE BRAKE PEDAL WAS DEPRESSED AND WENT TO THE FLOOR TO STOP THE VEHICLE. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2009 LINCOLN MKZ. THE CONTACT STATED THAT WHILE APPROACHING A RED LIGHT, THE BRAKE PEDAL WAS DEPRESSED TO FLOORBOARD WHILE ATTEMPTING TO BRING THE VEHICLE TO A STOP HOWEVER, THE VEHICLE FAILED TO STOP AND THE DRIVER HAD TO PROCEED THROUGH THE RED LIGHT WITH SPEED TO AVOID A CRASH. THE BRAKE PEDAL RETURNED TO NORMAL FUNCTION AND THE CONTACT DROVE THE VEHICLE TO THE RESIDENCE. THE CONTACT ALSO STATED THAT ON ANOTHER OCCASION, THE VEHICLE FAILED TO STOP AT A STOP SIGN. THE CONTACT STATED THAT THE FAILURE OCCURRED INTERMITTENTLY. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V904000 (SERVICE BRAKES, HYDRAULIC) AND CONTACTED PACIFICO MARPLE FORD LINCOLN (3015 W CHESTER PIKE, BROOMALL, PA 19008, (888) 320-6221) AND WAS INFORMED THAT PARTS WERE NOT YET AVAILABLE AT THE DEALER FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS NOT AVAILABLE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

WE WERE SENT A RECALL NOTICE ON THE AUTO BRAKE SYSTEM JANUARY 2020. LOCAL LINCOLN DEALER DOESN'T HAVE PARTS TO REPAIR AS OF OCTOBER 2020. THE ABS LIGHT HAS CAME ON RIGHT ABOUT THE TIME OF NOTIFICATION. KEEP GETTING TOLD THAT PARTS ARE NOT AVAILABLE TO REPAIR ON THE RECALL. IF I WANTED TO PAY FOR IT THEN THEY COULD REPAIR THE PROBLEM. THIS IS NOT SATISFACTORY. DO I NEED TO NOTIFY A BETTER BUSINESS BUREAU OR WHAT DO I NEED TO DO TO GET THE REPAIR ON BREAKS WHICH COULD BE A SAFETY HAZZARD?

TL* THE CONTACT OWNS A 2009 LINCOLN MKZ. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V904000 (SERVICE BRAKES, HYDRAULIC) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. FORT MILL FORD (801 GOLD HILL RD, FORT MILL, SC 29708) WAS CONTACTED AND CONFIRMED THAT PARTS WERE NOT YET AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND CONFIRMED THAT PARTS WERE NOT YET AVAILABLE. THE CONTACT STATED THAT THE BRAKE PEDAL WAS DEPRESSED AND WENT TO THE FLOORBOARD. THERE WAS NO WARNING LIGHT ILLUMINATED. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 144,895.

NHTSA RECALL 19V-904