2016 Kia Sorento complaints

When I make a left-hand turn, the right-hand signal light will come on as I'm making the turn. My vehicle is available for inspection. This puts me and the drivers around me in immediate danger of an auto accident. I have not taken the vehicle to a dealer for this problem. The vehicle has not been inspected. There were no warning lamps, messages or other symptoms of the problem prior to it first appearing three or four months after I purchased the vehicle in May of 2020. I don't want to get rear-ended or accidently pitted because of this problem (especially with passengers in my vehicle).

Engine seized with no warning. Kia is stating there was a recall but I never received a notice in the mail. They stated it was sent in July of 2022. Even if I did receive the recall letter, that wouldn't be enough time.

The check oil light keeps turning on then turning off. For the last 2 oil changes which are done every 3000 miles with high mileage oil the oil has been non existent. When you pull out the oil it is dry! No leaking of oil is found anywhere even though the exhaust smells of burning oil. When I took it to the dealership I was told "this was a known problem" and all I need to do is start changing my oil every 3000 miles using synthetic high mileage oil. That's not working. The light keeps coming on and off and I've only driven 1000 miles since my last oil change in July! I took it to the dealership when I threw a code that I was told was just because I ran out of oil and my car stalled. My car should not be running out of oil!

The contact owns a 2016 Kia Sorento. The contact stated while driving approximately 55 MPH, the vehicle lost power and decelerated to 25 MPH. The contact stated no warning light was illuminated. The contact pulled off to the side of the road and turned off the vehicle and was unable to restart the vehicle. The vehicle was towed to an independent mechanic. The independent mechanic diagnosed the vehicle and determined that the oil level had dropped to a very low level and that the engine needed to be replaced. The vehicle had not been repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 81,000.

I am trying to understand how my car was running fine no issues and then it stops on the highway while I am driving in 4P rush hour traffic. The dealership gets to my car 3 1/2 weeks later I get to shortage to tell me my engine is gone when there were no warning!! Continue on my car engine going out to be told because I didn't getting a senor upgrade in 2019 when to inform me of the engine going not to fix the engine but to tell me the engine is gone I must pay close to $9000. This is unacceptable and not the fault of the consumer. There was no letter no email no call nothing to inform me. I am a single mom who lives here in Indy where public transportation is not the best and when I take care of car and service car this not fair especially when this is a known issue with this 2016 Kia Sorento. I am a single mom where transportation is not the best and this issue was not a neglect of me. I do not have an extra $9000 to fix a problem that is known with your cars. To tell a consumer that since they did not get this sensor upgrade that they must eat the cost not right at all.

I noticed a little spot on the hood of my car. It has since continued to peel. It was not hit by anything.

Oil burning reported to freehold kia numerous times car broke down on road needed to be towed

Paint Peeling, Chipping, and Delamination from faulty paint job using Pearl white paint. Car in danger of body rusting and continued severe peeling. My car has low mileage and I live in Northern Virginia. I generally drive kids to and from school.

There is a continuous buildup of carbon in the intake manifold system in the 2.0 engine causing stalling whenever accelerating from a stop, such as turning either way or accelerating across a road when using the power steering which uses up power while accelerating. This carbon buildup is very expensive and difficult to clean out and is very dangerous as it causes you to stall completely for a few seconds when entering traffic lanes, if it does not restart quickly, you will crash...

The vehicle is available for inspection upon request. The engine was burning oil at a very high rate, with no indication of a problem. We went in for an oil change and they said the oil was extremely low and we would need to replace the engine. I've reached out to the local dealership to see if there's anything else that can be done, but the engine is making a loud clicking sound now. The fuel pedal stopped working while my son was taking the car to the shop and he had to push the car off of the road. There were no indicator lights or signs of a problem prior to this issue.

The contact owns a 2016 Kia Sorento. The contact stated that while driving at 65 mph, the vehicle stalled. There were no warning lights illuminated. The vehicle was towed to the local dealer where it was diagnosed that the engine seized and was not covered under the warranty. The vehicle was not repaired. The manufacturer was not contacted. The approximate failure mileage was 138,000.

Car recall repair for Knock Sensor failure has been done three times car now will not accelerate properly, is using excessive oil and, makes horrible engine noises. Dealer refused to inspect the vehicle after the last recall repair was done 10 days ago.

My 2016 Kia Sorrento is burning oil, about 1 quart every 300 miles. It only has 64,000 miles on it. We have the oil changed every 3000 miles and last time it was black and sludge like. This is not acceptable and called the dealership and they suggest paying $700 to do a carbon test. Not paying that when the car has a warranty still!!!! This issue needs to fixed!!! We have dealing with this for months!! Also the lights on dashboard flicker once in a while.

I purchased my 2016 KIA Sorento in October of 2018. Oil changes and everything has always been up to date along with regular maintenance. I never had any issues with it then in April 2022 I was driving to work and had complete engine failure with only 88k miles on it. The first obstacle was reaching KIA corporate. Would call several times a day just to be on hold for 30 plus minutes and sometimes over an hour. After speaking to several different people, they advised there was nothing to they could do, and I would have to pay for it out of pocket due to them saying they sent a piece of paper to the fist owner in June/July 2018 and then another one to me the end of 2019 or 2020. They were unsure of when it was sent to me and there was no proof that I received it. With my hands being tied since still owed money on it I went ahead and paid the $5700 to have my engine replaced. Fast forward I finally got my car back the end of July and two days later realized my heat no longer worked (worked before car went in to have engine replaced). Here it is over two weeks later, and I still do not have my car back. I have to call the dealership for an update and when I do call them, they have no clue who I am or why I am calling. Even though throughout this whole process with engine have only spoken to 1 service rep. KIA’s customer service across the board is very poor. I called the dealership today and they said they finally heard back from corporate again to try and run more tests and they

The contact owns a 2016 Kia Sorento. The contact stated that the vehicle would not immediately start after pressing the start button. After finally starting the engine and while driving 35 mph, the engine suddenly shut off and could not be immediately restarted. After restarting the vehicle, the check engine and traction control warning lights remained illuminated. The cause of the failures was not yet determined. The local dealer was notified of the failures. The manufacturer was not contacted. The failure mileage was 181,000.

I was driving on freeway and all of a sudden my car stopped. The engine blew, I had no oil in car; the oil light didn’t come on. I had recently changed the oil. We kept oil changes up to date every 3000 miles. Called Kia, they said they couldn’t help us. What can we do?

The engine is making a hammer noise when you try to get past 2000rpm. Which has to do with the piston rod system. This will be to be towed if being inspected. This is currently causing engine failure and could blow the engine if it was still on the road. It has been replicated by several people now. And there was not early symptoms just the noise out of no where.

I was driving 65 miles per hour on US 23, when my engine locked up. No warning, wasn't time for oil change, had plenty of oil.

Paint started peeling. I thought it might have been a rock chip but it got worse in about 2 weeks.

There has been an ongoing issue nationwide with the Kia Sorento’s engines. I have been dealing with a burning oil issue and engine issue for months. I spent over 800.00 a few months ago on the oil issue that is still no better today. The engine, Kia is fully aware that there is an issue with the engine however will not state is is a recall as then they will be accountable to replace it. I have been told this by both my local dealership and the warranty company. Two weeks ago my Sorento broke down out of state. It had to be towed back to MA. I was told by the dealership that there are about 12 cars with the same issue in front of mine. It will be several weeks before I can expect any type of resolution. I am without a car and Kia will not pay for a rental until the adjuster comes out. This is very disheartening as I am a single mother on a very fixed income. I cannot afford to rent a car and I absolutely need transportation asap. They say it is an issue with the piston in the engine. I really need my car prioritized or need a rental paid for by KIA. I should also be reimbursed for the issue of which I was charged $800+. I was just told Saturday the 6th of August they would look at my car today the 11th, by the manager, it still has not been looked at, we were also told that if we were to pursue legal action they would not work on it at all. I even purchased the warranty and still nothing. Kia of Burlington MA Pleas help!

The engine consumed the oil prior to the recommended regular oil change without any warning or indication. This has resulted in the need for a total engine replacement uncovered by Kia.

Warning engine light keeps activating saying major fuel leak. Supposed recall sc 172 but according to kia, not associated with my vin and needed to be reported

Ignition switch/steering column lock/anti-theft device. It is widely known key start KIA-Hyundai vehicles are easy to steal due to lack of sufficient steering column/ignition switch/anti theft device which makes these high risk vehicles for theft which also puts owners and bystanders at unreasonable risk of violence. These same vehicles sold in Canada and elsewhere are equipped with different parts making them much more theft resistant. KIA-Hyundai therefore made a decision to NOT install on US market vehicles, deliberately indifferent to safety of owners, occupants, and others of violence and of increased vehicle theft.

I was driving on the highway going 70 mph when my 2016 Kia Sorento 3.3L lost power and could not accelerate. I had to navigate to the side of the highway carefully and got my car towed to the closest Kia Dealership. Upon their investigation, it was a blown head gasket that required the whole engine to be replaced. I am the 2nd owner of the car and bought the car in late 2019 with 45, XXX miles on it and it currently only has 66, XXX miles. I was not covered under warranty as it expires once you pass 60,000k miles. Estimation from Kia would cost close to $10K with a new engine/labor. Contacted Kia Consumer to see if they can help and was denied. Now stuck with a dead car trying to figure out what I can do.

My car began knocking and then it slowed down. It stalled as I pulled off the road and won't start. I had it towed and the mechanic said there was "glitter in the oil". He called our local Kia dealership, gave them the VIN number and was told there was a recall on my engine. I researched your website and it does not show a recall. I found two other individuals who wrote owner reviews in May and June 2022 who had the same problem.

2021 on my passenger side paint literally peeled off. I’ve had a small small chip on my roof and this was few years back. Though was just a chip. Now about last week literally my roof is peeling demalation. I see online many many recalls and issues with this type of pain and I have the Snow White paint

PAINT CHIPPING IN MULTIPLE SPOTS

In October, 2020, the air bag light came on at approximately 90,000 miles. On 10/21/20, I called Kia customer service and they dated it was not covered under any warranty. As of 07/15/22, the airbag light is still on with about 100,000 miles. The airbag light came on and remains on with no incident or accident or repair having occurred. The vehicle is very well maintained and in excellent condition. I called my local Kia dealership on 07/11/2022. They stated the airbag light on my 2011 Kia Sorento is covered under a recall, due to faulty clock spring, but the 2016 Kia Sorento airbag light is not covered. I make this complaint to request NHTSA investigate the same or similar air bag problems occurring on the 2016 Kia Sorento as has occurred with the 2011-2015 Kia Sorento ODS recall. Thank you.

I was on the interstate going 65 mph and my engine stopped shifting it suddenly decreased in speed and I made it off the interstate barely any power to get safely off the interstate.

The car was running hot. The repair shop was suppose replace the thermostat..We received the car back the same day and it was still doing the same thing.. The repair place told us to put water in it when it cools down and continue on our merry way!! The car ran hot, started smoking and now it won’t crank

Vehicle lost power on highway going 70mph. Driver was able to safely exit to roadside. Popped hood and oil covering the engine bay. Lots of smoke. Upon further inspection, it appears as though a wrist pin dislodged from connecting arm and went through the front of the engine block. Oil was everywhere and is a fire risk! Also, vehicle only has 107,xxx miles on it. Kia refuses to tow vehicle at their expense to shop even though in speaking with dealership, engine should be covered under Theta II class action suit.

My 2016 pearl white Kia Sorento started to chip and peel. It started on the front edge of hood (both sides) and now is starting to peel on the roof line at windshield.

7/3/22, 71,500 miles accrued on vehicle. While operating the vehicle, on an uphill grade after 5.7 miles of driving, sudden and abrupt knocking noise occurred. Knocking was intensified during acceleration. At this time, dramatic loss of power occurred. Attempted to "coast" downhill for the remainder of the trip. After another 2.2 miles, a very loud "bang" noise occurred, the driver in fear part felle from the vehicle. Knocking noise intensified, and the vehicle then stopped responding. Displayed oil pressure, check engine and check battery lights. Violent shaking and vibrating occurred. Driver was able to coast the vehicle off the roadway to the right shoulder for safety so as to not become a traffic hazard. Smoke was visible and heat was felt from the engine bay of the vehicle. Driver of the vehicle was in fear of fire occurring imminently. Vehicle was shut off for safety. After smoke dissipated and engine cooled, a restart was attempted but failed. Vehicle would not respond. Nothing was visible from the top of the engine bay. Vehicle was moved to a local repair shop adjacent to the location where it was stopped. On inspection, the engine block cracked adjacent to the connecting rod producing knocking noise and releasing all oil from the engine block. The local automotive shop confirmed the engine/powertrain failure similar to the previous recall: RQ17-003 NHTSA Recall No. 17V-224 on "GDI" engines. Kia corporate was contacted. Kia has not inspected the vehicle but was inform

I reported a complaint on 1/24/2022. I had to replace my engine. I actually had to borrow the money. I went on Kia-Consumer-Assistance-to file a claim for reimbursement. They sent me a denial letter on 6/30/22 stating I did not have the knock sensor detector. Well I would have if I received the notice. I bought my car used. The dealership didn't have any recalls and I did not receive anything until May 2022. Kia emailed me about the knock sensor detector. Although I replaced my engine I had it installed on 6/17/22. How could have known about something that I never received. I didn't even know there was a class action lawsuit until I went on line to find Kia Corporate information. I emailed several people and nit one person emailed back. I was asking for assistance but I guess they delete it but I still have it. I feel like this is an ongoing issue with Kia and they need to reimburse everyone that has had engine failures due to THEIR NEGLIGENCE. Does someone have to be driving and the car turns off and they get hit because of the engine failure. This is a sign of bad business. My reimbursement for the engine needs to be approved. Kia has more than enough money. If they would have tested the GDI engines first before releasing them to the public they probably would not have half the complaints. I think another class action lawsuit should be filed against them. Not only has this impacted me financially but it has impacted me emotionally.

Sometime Mid May 2022 I was driving back from Tri City Washington. As I was passing a semi truck I noticed my car was losing some power. I ten was able to to get in front of the semi when I seen a place to pull off. During this time I noticed my dash lights were coming on. Engine light. I was lucky enough to pull off where on a side road in Warden, Washington. My car then ceased and would not start. I had to have it towed in my home town of Moses Lake, Washington to a auto mechanic by my resident. The name is Customs Auto on Broadway. They said it needed to go to a Kia Specialist/Mechanic for repairs. So I then had it towed to Over Turf Kia Dealership in Tri City, WA. where my car has been sitting since the end of May 2022. Nathan from Over Turf said I needed to replace my engine and quoted me at $6300.00 which is what I owe my bank loan with Wells Fargo. I only had 135,000 miles on it and not sure why all of a sudden my engine ceased. Now I have filed a complaint with NTSB they gave me a complaint #11466956 on Kia and their recalls. I had a recall repair on it September 2017 and had contacted Kia out of Wenatchee, WA where the recall was done. But they are closed down because of the covid. I am lost to what to do at this point. I was given an email address to send an email of pictures or important documents pertaining this problem. I am asking for any direction as to what to do or who to contact. If you need to call me please fill free at [XXX]. Thank You! Sincerely, [XXX] I

Rear door larch fell off. This is a documented problem with this vehicle. Kia dealerships have been unhelpful to resolve this issue. I feel this is a safety item with a recall on the 2015 models. Latch is made with cheap plastic, and many kia’s have this issue. Thanks, Steve Ritchie

Engine failure at 85,500 miles an hour into a road trip. Just had an oil change on it a few days prior. No warning lights came on before the engine started to rattle at 3000 rpms. Engine still rattles while car is idling.

Wife and I where driving on the highway when we she pointed out a tapping noise. About twenty minutes later our vehicle lost all power. Dumbfounded because no safety function signaled there was any possibility of over heating or oil pressure I pull off and inspect under the hood. When I pulled the dipstick there was absolutely no oil in it and the oil on the dipstick was burnt. I only have 74,000 miles on the thing and the engines blown. And Kia won't help with anything even knowing this is a major issue.

I was driving my 2016 Sorento when I noticed a knocking coming from the engine. I took it to get serviced the next day and the check engine light came on as I was driving to get the oil changed. Mechanic at the oil change establishment checked the code and told me that it said the cam shaft was out of alignment. Their shop refused to work on it because of the difficulty in working with Kia's and their computers. I called my local Kia dealer and they had no idea what the warning was but that it would be 20-25 days before they could look at it. My daughter was driving the car than night and the car stopped in an intersection and starting making a horrible clanking sound. I had it towed to Kia and when they got to it they told me that the engine was blown and it would be $8,000 to $11,000 to repair it. There is an extended warranty on the oil pressure switch, but they assured me that it was not the cause of the malfunction. They told me that it was most likely lack of maintenance on my part or the wrong oil being used. I have owned the car for about a year and a half and had it maintained regularly by a reputable mechanic. I have talked to multiple people and been told that Kia has a real problem with engines blowing up on them.

Have a 2016 Kia sorento 93000 miles it is pearl white the paint is coming off peeling off ,chipping off

My family and I own a 2016 Kia Sorrento VIN [XXX] that we purchased from a dealer in August 2017. It was reliable transportation; we were very pleased with it; it was serviced with regular oil changes, maintenance, etc., and had no mechanical issues until early September 2021. The vehicle’s temperature gauge began to register hot, i.e., way over to the “H” during operation. Our regular mechanic at an AAA-registered auto care center replaced the thermostat, but the car was still overheating. After an expensive but thorough diagnosis from early November through early December 2021, the mechanics – including a Kia specialist – confirmed that the head bolts were pulling away from the engine block or the source of our problem. After searching the internet, I understand that this is not a frequent occurrence but not uncommon among the same model and year Kia Sorento's with similar mileage. Replacement engines are not available due to supply issues; there was no guarantee of success from our mechanics or the machine shop who could attempt to mill the head/engine block and drill-tap for new bolts; and the entire process was cost prohibitive. Therefore, we elected not to have it repaired. Our Sorrento that is past its engine-drivetrain warranty with 124K miles on the odometer sits in the driveway with a year’s worth of car payments remaining. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Oil gets low without the warning light coming on and has contributed to a burnt valve or broke ring. This has caused irreversible engine damage.

Paint is chipping off in large chunks on various places on my vehicle. I did see another Kia Sorento (white and same year) that had the same issue happening on their vehicle. There is clearly an issue with the white paint from that year. There has not been any incident that has caused this to occur, it seems to have happened randomly.

The contact owned a 2016 Kia Sorento. The contact stated that while driving approximately 20 mph the vehicle suddenly lost automotive power and the check engine light had illuminated. After stopping the vehicle smoke and flames were present coming from under the hood. The fire and police departments were called to the scene and the flames were extinguished. During the incident, the vehicle was destroyed. A police report was taken at the scene and the vehicle was towed away. The cause of the failure was not determined. The local dealer and manufacturer were not yet notified. The failure mileage was 73,000.

Last weekend we were driving our 2016 Kia Sorento with 111,000 miles on the highway. It started to lose acceleration and I had to pull of on the side of the highway. The vehicle started smoking and antifreeze leaked out all over the right side of the vehicle. This put our family at risk because there were no warning lights and it occurred on an extremely busy highway where are drive anywhere from 70-90 miles per hour. The vehicle was towed and inspected, we were told the head gasket was leaking. No other symptoms were present prior to this occurring and this is the only problem we have really had with the vehicle. All of the mechanics I have talked to about repairs refuse because these motors are known to be very risky to repair. Our local Kia dealer where we purchased the vehicle even stated that it's not worth fixing. New engine replacement are unavailable and buying a used engine is roughly $6,700 before any labor because so many of these engine issues have occurred.

I took my vehicle to AAMCO and was told my engine has went out. The estimate to fix it is $10,000. I am currently paying on it still I called Evergreen Kia whom I got the car from and was told they have over 18+ vehicles with the same problem. I was told to call other Kia dealerships to see if i can get it repaired elsewhere. All other Kia dealerships said they were backed up as well with the same engine problems. I tried to trade it in no one wants to because the cost of repairs and the $13K I owe doesn't equal out.

My 2016 KIA SORRENTO caught fire. I was driving off of the highway, with no issues, when i heard a tapping noise. I stopped at the light, turned right, and as I started turning it suddenly sputtered and stopped. I tried to accelerate to get the car out of the lane of traffic, when smoke started coming out from under the hood. People next to me started yelling that my car was on fire and that I should get out. At this point I got out of the car, and within minutes the entire undercarriage and front part of car was engulfed in flames. The fire dept put the fire out, and the fire marshal and my insurance is investigating.

WHITE PEARL PAINT FINISH IS FLAKING OFF ON HOOD AND ALONG ROOF LINE AT WINDSHIELD. NO IMPACT OR ABRASION CAUSED THIS. FROM READING OTHER COMPLAINTS THIS APPEARS TO BE FROM INCOMPATIBLE PRIMER USED AT FACTORY

My car has the Pearl White paint, it started peeling in 2021 and now is increasing. It mostly on the hood of the car.

Vehicle cranked but didn't start after sitting for a few hours. Vehicle was towed to kia dealership. Dealer advised piston ring failed and engine lost compression. New engine was needed but was not covered by dealership nor the lifetime engine warranty. The repair cost almost 6000 dollars.