2015 Hyundai Santa FE complaints

Hyundai Santa Fe Sport 2015 was making sounds when vehicle was off. The ABS warning lights were lit on the dashboard (3 warnings in total) once car was turned on. Drove home hoping the sound would go away but it did not. Once home the sound continued without the vehicle being on. Opened the hood and listened for the location of the sound. It was the ABS module on the left. This part then caught on fire while parked and off (keys were out).

The contact owned a 2015 Hyundai Santa Fe. The contact stated while driving 25 mph, when he lost control of the vehicle and multiple warning lights were illuminated. The contact stated while attempting to park on the side of the road, he saw smoke entering the AC vents. The contact and his son (front passenger) were able to exit the vehicle before it exploded. The contact stated the fire was located in the front of the vehicle. The contact stated no one was injured nor sought medical attention. The fire department was able to extinguish the fire, but was unaware if a fire report was filed. The police report was filed. The vehicle was not drivable. The insurance company deemed the vehicle total loss. The vehicle was towed to a towing yard. The contact called the local dealer and made them aware of the failure. The manufacturer had been informed of the failure. The contact stated two days after the incident, he received notification of NHTSA Campaign Number: 21V303000 (SERVICE BRAKES, HYDRAULIC) and associated the failure with this recall. The failure mileage was approximately 117,000.

On 5/28/21, while driving vehicle noticed a knocking/banging when in reverse then also began when driving. Took to local Midas dealer and was told rear differential gear was broken and needed repaired. Upon further research, Midas discovered that an upgraded coupler had been replaced on other Hyundai Santa Fe's as the old coupler wasn't protecting the gear. The coupler on my vehicle was therefore not protecting the gear in the rear differential causing it to break in half. I work in a manufacturing company (Honda of America) and could not miss work due to strict attendance policies. Local Hyundai dealership could not assist me in repair asap so had no choice but to have it repaired with Midas so that it would be ready for me to drive to work on Monday. Filed case with Hyundai to ask for reimbursement since vehicle wasn't recalled for defective coupler. They advised me to take to a local Hyundai dealership to ensure work was performed properly and correct parts were used. This cost us an additional $99 on top of the $5066 for the repair. Hyundai then told us after having the local dealership look at the work performed that because we didn't have it repaired at authorized dealership they could not provide assistance. After not accepting this response, I escalated the issue and was told Hyundai Consumer Affairs would contact us. We have yet to hear from them on any type of financial help with this costly repair that was through no fault of our own. This is a truly awful customer

I was driving on the highway with my 3 children (I am 9 months pregnant) when we heard a loud pop from the engine, the car gave a sudden jolt and then a loud ticking sound started. The car had a hard time accelerating as I tried to pull over to a safe location. I felt my life and my family's life was in danger. The car was taken first to a mechanic where I was informed that they had several cases with the same issue from the same vehicles recently and recommended us tow it immediately to a Hyundai dealership as it was a recall issue and it was not safe to drive. We towed it to a Hyundai dealership and they informed us that it was a rod barring failure. They informed us that there was indeed an open recall for this particular issue however it was on the Santa fe 2.4 liter models and not our 3.3 liter model. They did tell us that they tried to contact Hyundai consumer affairs since it is the same issue but that Hyundai refused to extend the recall to us. I called consumer affairs directly after and explained my concerns and situation and was told there was nothing they could do about it since there was no recall on my 3.3 liter vehicle. I was given an estimate of $9-10K as a quote to fix the issue. There were no warning lights, no prior symptoms to the failure, this simply happened unexpectedly and put my family at risk.

The remedy shown for the current recall is the same as the last recall. my vehicle was inspected as per last recall recommendation and no action was performed by the dealer. why is hyundai still using the same the same remedy as per recall 194 CUSTOMERS CAN CONTINUE DRIVING THESE VEHICLES; HOWEVER, DUE TO THE POSSIBILITY OF A FIRE ORIGINATING FROM THE ABS MODULE WHILE PARKED, HYUNDAI RECOMMENDS PARKING THESE VEHICLES OUTSIDE AND AWAY FROM STRUCTURES UNTIL THE RECALL REMEDY IS COMPLETED. HYUNDAI PLANS TO NOTIFY OWNERS TO BRING THEIR VEHICLES TO THE NEAREST HYUNDAI DEALERSHIP FOR INSPECTION OF THE ABS MODULE AND IF NECESSARY, REPLACEMENT WITH A NEW ONE. IN ADDITION TO ABS MODULE INSPECTION, THE ABS MULTI-FUSE WILL BE REPLACED WITH A REVISED ONE TO MITIGATE THE RISK OF A FIRE CAUSED BY AN INTERNAL ELECTRICAL SHORT. THE REMEDY PROCEDURE WILL BE PERFORMED AT NO CHARGE TO THE CUSTOMER. HYUNDAI WILL PROVIDE REIMBURSEMENT TO OWNERS FOR REPAIRS ACCORDING TO THE PLAN SUBMITTED TO NHTSA ON MAY 16, 2018.

My car engine caught fire on 04/18/2021 and totaled my car. I just received a recall notice from Hyundai for this issue via the USPS yesterday 06/29/2021. I had only 60,000 miles and expected to own this car another 3-5 years. I am out a new car payment and this could have burned my condo down as I was 2 blocks away from it driving home and routinely park in my garage.

ABS failed while merging causing a collision that ended up totaling my car.

The contact owns a 2015 Hyundai Santa Fe. The contact stated that while driving at various speeds the vehicle stalled and the two catalytic converters became inoperable. Additionally, the blue link screen failed to load and link the features. There were no warning lights illuminated. The vehicle was taken to the local dealer who diagnosed two catalytic converters that needed to be replaced. The vehicle was not repaired. The manufacturer was notified. The failure mileage was 115,000.

Leak which may cause a fire. This is second recall for same problem. I feel unsafe while driving. They say if ABS light comes on to stop immediately. Unable to park in my garage or close to the house. No incidents as of now. I do not understand why this is taking so long and we are expected to drive an unsafe vehicle. Value of car has also dropped.

I was getting on the expressway and everything just seemed like it was on safety mode. My car gurgled, it wouldn't switch gears, the engine light kept flashing. I thought it was a transmission issue until I got it to a Firestone. They said the cylinder is missing on 2,4,6. And that there was a timing chain issue. The dealership says it sounds more like coils.... I'm experiencing all the same issues I'm reading about here. No warning, smelling something burning although no fire. The rpm kept going up at I'm giving gas but not the speed. It has 80,000. Why are only the sports models covered when there are so many cases of other models?

The sunroof screen will not close therefor is no protection if the sunroof were to shatter. The problem has been confirmed by the dealer. It is not covered by the warranty. There were no warnings prior to the incident. I have tried to close it regularly and it still won’t close.

ENGINE LIGHT CAME ON, ENGINE STARTED TO MAKE A RATTLING SOUND. THE SOUND GOT WORSE WHEN ACCELERATING ESPECIALLY IF I WAS ATTEMPTING TO GO UP A HILL.I TRIED TO MAKE IT TO A MECHANIC, BUT THE ENGINE DIED ON THE WAY WHILE ATTEMPTING TO MAKE IT UP A BIG HILL AND WOULD NOT RESTART. I HAD IT TOWED TO A SHOP, THEY SAID THERE WAS NO OIL IN THE CAR DESPITE THE FACT THAT WE ALWAYS HAD OUR OIL CHANGED REGULARLY. THERE WAS NO SIGN OF A LEAK. THEY HAD TO PUT THREE QUARTS IN IT JUST FOR ANYTHING TO SHOW ON THE DIPSTICK. THE SHOP THAT I TOOK IT TO DID NOT DO ENGINE REPAIR AND RECOMMENDED THAT I HAD IT TAKEN SOME PLACE TO HAVE THE ENGINE REBUILT. THEIR THEORY WAS IS THAT SOMETHING BLEW AND THAT THE OIL WAS BEING BURNED UP. IT HAPPENED SO FAST. ONE DAY I HAD A DEPENDABLE CARE THAT I LOVED. THE NEXT IT NEEDED IT'S ENGINE REPLACED. HOWEVER, I KNEW I COULD NOT AFFORD TO PAY FOR AN ENGINE TO BE REBUILT OR REPLACED. SO, I HAD TO JUST HAVE MY CAR TOWED HOME.

MECHANIC SHOP CUSTOMER PRESENTS WITH COMPLAINT OF OIL LEAK AND NO SERPENTINE BELT. IINITIAL DIAGNOSIS. CAMSHAFT SEAL AND SERPENTINE BELT UPON OPENING UP FOUND EXTENSIVE DAMAGE TO TIMING AND HEADS. DAMAGE TO CAMSHAFT, ROCKER ARMS APPEAR TO BE BURNT FROM NO LUBRICANT. APPEARS TO BE BLUNT FORCE TRAUMA THAT CAUSED BROKEN PARTS. UNLESS WE OPEN UP THE ENGINE THERE IS NO WAY TO DETERMINE THE EXTENT OF DAMAGE TO THE INTERNAL ENGINE PARTS. THE RECALLS DEMONSTRATE OVER 129,000 ENGINES RECALLED FOR HYUNDAI AND THIS APPEARS TO BE CAUSED BY ENGINE DEFECTS. PICS CRANKSHAFT SEAL INSIDE ENGINE PIECE OF SERPENTINE BELT INSIDE ENGINE ROCKER ARM BEARING DAMAGE ROCKER ARM SERPENTINE DAMAGE EMAIL MORE PICS

CAR WAS STATIONARY AND WOULD NOT START, TOWED TO DEALER AND DEALER EXPLAINED ENGINE WAS BLOWN. I SEARCHED GOOGLE FOR RECALLS AND MANY HYUNDAI SANTA FE'S BETWEEN 2013-2019 HAD RECALLS, ALTHOUGH THEY WERE SPORTS MODEL AND OURS IS NOT A SPORTS MODEL, WE BELIEVE THAT THERE WOULD BE OTHER SANTA FE NON-SPORTS MODEL WITH SAME ISSUE. HYUNDAI INFORMED US THAT IT WOULD COST $18000 FOR A NEW ENGINE, THEY WOULD COVER HALF THE COST, WE PURCHASED THE CAR FOR AROUND $21000 - THIS IS RIDICULOUS AND TAKING ADVANTAGE OF CONSUMERS. I AM WAITING FOR PAPER WORK FROM HYUNDAI WITH REPORT BUT THERE IS NO WAY I CAN PAY $9000 TO GET A NEW ENGINE. ANY ASSISTANCE ON THIS GAUGING AND POSSIBLE ISSUE THAT OTHERS HAVE ENCOUNTERED WOULD BE APPRECIATED. I DO NOT THINK THEY ARE BEING HONEST. WE ALSO BROUGHT THE CAR IN PRIOR TO 100000 MILE WARRANTY EXPIRED WITH 'CHECK ENGINE' LIGHT ON, THEY DIAGNOSE SOME SMALL MAINTENANCE HAS TO BE PERFORMED AND WE PAYED FOR THAT, WE DROVE IT HOME AND A FEW DAYS LATER 'CHECK ENGINE' LIGHT RE-APPEARED, BROUGHT IT BACK AND THEY SAID NOTHING WAS WRONG. ATTACHED ARE INVOICES FOR ABOVE REPAIRS

TL* THE CONTACT OWNED A 2015 HYUNDAI SANTA FE. THE CONTACT STATED WHILE MAKING A LEFT TURN AT 5 MPH, WHEN ANOTHER VEHICLE IMPACTED THE FRONT PASSENGER WHEEL. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. NO AIRBAGS DEPLOYED. THE CONTACT SUSTAINED A FRACTURED LEFT WRIST AND RIGHT SHOULDER SPRAIN AND DID NOT SEEK MEDICAL ATTENTION AT THE MOMENT. A POLICE REPORT WAS FILED. THE VEHICLE WAS DRIVABLE, THE INSURANCE COMPANY DEEMED THE VEHICLE TOTALED. THE VEHICLE WAS TOWED TO IMPOUND LOT. A DEALER WAS NOT CONTACTED. THE MANUFACTURER HAD NOT BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 85,400. *DT

THE REAR PASSENGER DOOR WILL NOT OPEN EITHER FROM THE INSIDE OR OUTSIDE. THIS HAPPENED OUT OF THE BLUE. CAR IS A 2015...AND NOT COVERED UNDER WARRANTY. IN RESEARCHING MANY PEOPLE HAVE HAD THE SAME PROBLEM WITH HYUNDAI MODELS AND YEARS. WE HAVE TALKED WITH THE DEALERSHIP, TAKEN IT TO A LOCKSMITH (COULDN'T OPEN WITH A SLIM JIM AND AN INDEPENDENT THAT USED TO WORK FOR HYUNDAI WHO SAID HE WOULD HAVE TO DESTROY THE PANEL TO GET INSIDE TO CHECK THE ASSEMBLY AND REPAIR. DEFINITELY A SAFETY ISSUE IF A FAST EXIT IS NEEDED. HYUNDAI FORUMS HAVE THE ISSUE BEING ASKED ABOUT FREQUENTLY INVOLVING ONE DOOR OR WITH MULTIPLE DOORS

OUR VEHICLE HAS NEVER HAD ANY ISSUES, NO CHECK ENGINE LIGHT, NOTHING. WE WERE DRIVING ON THE HIGHWAY AT APPROXIMATELY 60MPH WHEN THERE BEGAN TO HAVE A KNOCKING, RATTLING NOISE FROM THE ENGINE. WE PULLED OVER TO CHECK IT, NO CHECK ENGINE LIGHT OR ANYTHING STILL. DROVE THE VEHICLE TO OUR REPAIR SHOP, AND ON THE WAY THERE, OUR ENGINE BLEW. STILL NO CHECK ENGINE LIGHT CAME ON. OUR VEHICLE ONLY HAD 133,000 MILES ON IT, SO OF COURSE IT'S OUT OF WARRANTY. SUCH A HUGE BURDEN. WE ARE NOW STUCK HAVING TO REPLACE THE ENGINE, WHILE OWING A CRAP TON OF MONEY ON THIS SUV.

WHEN DRIVING ON THE HIGHWAY 65MPH AFTER 15 MIN THERE IS A BURNING RUBBER SMELL, THE OIL IS LOW EVEN THOUGH I CHANGED IT 3 WEEKS AGO, IT IS CONSUMING TWICE AS MUCH GAS AS BEFORE. I CALLED A CERTIFIED HYUNDAI DEALER AND THEY HAVE NO AVAILABILITY, I HAVE A SAFTEY CONCERN BECAUSE ENGINE FIRES CAN HAPPEN. NOT SURE IF THIS IS RELATED TO ABS RECALL

AFTER GETTING GAS, I NOTICED A STRANGE SOUND COMING FROM MY CAR. I DROPPED IT OFF WITH MY MECHANIC WHO RECOGNIZED THIS AS A HYUNDAI GDI ENGINE HAVING DEFECTS. I HAD THE CAR TOWED TO A HYUNDAI DEALERSHIP THAT CONFIRMED THE BEARINGS WERE WORN AND ENGINE ROD WAS ALMOST THROUGH THE ENGINE. HYUNDAI HAS REFUSED TO COVER EXPENSE TO REPAIR.

THE BLIND SPOT DETECTOR STARTING RANDOMLY GOING OFF VERY SPORADICALLY SINCE WE HAD THE CAR. THEN ONE DAY IT STARTED GOING OFF ALMOST EVERY MINUTE FOR ABOUT 7-8 MINUTES THEN AN ERROR MESSAGE APPEARED AND IT STOPPED WORKING ALL TOGETHER. THE CAR WAS IN MOTION ON THE FREEWAY.

RECALL 194 IS RELATED TO POTENTIAL ELECTRICAL FIRE. THIS RECALL HAS BEEN OUT SINCE 9/2020 AND YET NO DEALERSHIP HAS PARTS TO FIX THE PROBLEM. I HAVE CALL AT LEAST 3 TIMES AND GET TOLD "PARTS ARE NOT AVAILABLE". LAT CALL IS THE DATE BELOW.

PANORAMIC SUNROOF EXPLODED OVER MY HEAD WHILE I WAS DRIVING, JUST STARTING TO MERGE ON THE FREEWAY.

2015 HYUNDAI SANT FE LIMITED 3.3L AWD, PURCHASED NEW FROM DEALERSHIP, 129,280 MILES. ROUTINE OIL SERVICE WITH MOBIL 1 SYNTHETIC AND WIX FILTERS SINCE PURCHASED. TRAVELING 75MPH ON I-10 (FLORIDA) WITH CRUISE CONTROL ON. NOT TOWING, TRAVELING STRAIGHT. AS THE VEHICLE STARTED UP A SMALL GRADE IN THE ROAD, THE CRUISE CONTROL SURGED (AS NORMAL TO MAINTAIN VEHICLE SPEED) I HEARD A BANG, CHECK ENGINE LIGHT CAME ON, OIL LIGHT CAME ON, ENGINE DIED IMMEDIATELY. I IMMEDIATELY SHIFTED INTO NEUTRAL AND LOOKED OUT THE PASSENGER WINDOW TO MERGE ONTO THE SHOULDER AND NOTICED AN ORANGE GLOW OUTSIDE (IT WAS NIGHT). ONCE STOPPED, OPENED HOOD AND NOTICED SMELL OF OIL, OIL POOLED IN THE UNDERBODY FAIRING. CHECKED OIL DRAIN PLUG AND FILTER, AS I HAD AN OIL CHANGE 700 MILES PRIOR. BOTH WERE STILL PROPERLY INSTALLED. TOWED TO LOCAL MECHANIC, DIAGNOSIS WAS SEIZED ENGINE. INSPECTED ENGINE BLOCK AND NOTICED FIST SIZED HOLE IN BLOCK (SEE PHOTOS). TOWED TO DEALERSHIP, WAS INFORMED THEY HADN'T SEEN THIS BEFORE ON THIS ENGINE. I INFORMED THEM I CURRENTLY DRIVE A 2001 HYUNDAI ELANTRA WITH 220K MILES ON IT AND HAVE BEEN DRIVING/MAINTAINING CARS FOR 30 YEARS AND I'VE NEVER SEEN THIS BEFORE EITHER. WAS INFORMED THAT THEY SUSPECT IMPROPER OIL MAINTENANCE. OIL AND FILTER BOTH REPLACED EVERY 5000 MILES. ALWAYS MOBILE 1 SYNTHETIC AND WIX (GOOD QUALITY FILTERS/OIL). I SUSPECT HYUNDAI HAS ENGINE RELIABILITY ISSUES. NO PRIOR ENGINE ISSUES NOTICED. NO CHECK ENGINE LIGHTS PRIOR. NO OIL LIGHTS ON PRIOR. WE JUST COMPLETE

RECEIVED RECALL NOTICE; TOLD TO PARK CAR OUTSIDE AS IT COULD CATCH FINE. TOOK CAR TO DEALERSHIP TO HAVE IT REPAIRED. WAS TOLD DIAGNOSTIC SHOW ABS MODULE WAS NOT LEAKING, THEREFORE NO REPAIR NEEDED ALTHOUGH THEY COULDN'T GUARANTEE IT WOULDN'T LEAK IN THE FUTURE. CALLED HYUNDAI CORPORATE (LISTENED TO CAMPAIGN 953) DETAILING THAT AN ELECTRONIC UPDATE WAS INSTALLED WHICH IF THE LEAK OCCURS, THE CAR WOULD BE PLACED IN A MODE THAT WOULD NOT ALLOW IT TO BE DRIVEN FAST AND TO IMMEDIATELY GO TO HYUNDAI DEALERSHIP. I WANT MY CAR REPAIRED AND PART REPLACED. THIS ELECTRONIC UPDATE DOES NOT DO THAT ... IF THE CORPORATION KNOWS THE PART IS FAULTY THEY SHOULD REPLACE ALL, NOT JUST THOSE THAT TEST BAD AT THE TIME OF THE CHECK. WAS GIVEN NO OTHER RECOURSE.

MY 2015 HYUNDAI SANTA FE HAS BEEN RECALLED DUE TO THE ANTI-LOCK SYSTEM (ABS) MODULES THAT COULD LEAK BRAKE FLUID INTERNALLY AND CAUSE AN ELECTRICA SHORT OVER TIME. THE PISTON SEALS IN THE ABS MODULES'S HYDRAULIC VALVE COULD LEAK BRAKE FLUID INTO THE ELECTRONIC CONTROL UNIT (EUC) . AN ELECTRICAL SHORT IN THE ABS MODULE COULD INCREASE THE RISK OF AN ENGINE COMPARTMENT FIRE. THE SAFETY RECALL LETTER I RECEIVED 12-24-20 STATED TO CALL THE NEAREST HYUNDAI DEALER AS SOON AS POSSIBLE TO SCHEDULE AN APPOINTMENT TO HAVE THIS REPAIRED. I CALLED ON JAN 12, 2021 TO MY DEALERSHIP AND WAS TOLD THE PARTS TO FIX THE RECALL WERE NOT IN YET AND THEY COULD NOT TELL ME WHEN THEY WOULD BE AVAILABLE. I FIND THIS TO BE VERY CONCERNING THAT I MAY HAVE A CAR THAT ANYTIME COULD CATCH ON FIRE AND HYUNDAI CANNOT FIX IT.

VEHICLE WAS IN FOR REPAIR IN DECEMBER 2018 TO HAVE A MOMENTARY LOSS OF POWER WHEN ACCELERATOR WAS PRESSED FOLLOWED BY A LOAD BANG AND THEN THE CAR ACCELERATED. THE DEALER FOUND NO CODES AND LOOKED NO FURTHER. IT HAPPEN A FEW TIMES AFTER BUT NO VISITS TO DEALER. IN JANUARY 2021 WHILE PARKING THERE WAS NOISE COMING FROM UNDER VEHICLE AND IT STOPPED RUNNING. CAR WAS TOWED AND TORQUE CONVERTER FAILED ALONG WITH TRANSMISSION. IT DID NOT HAPPEN AT HIGH SPEED. I FEEL THE BANG AND THE ACCELERATION WERE THE TORQUE CONVERTER AND TRANSMISSION STARTING TO FAIL.

I I HAD THE CAR INTO THE HYUNDAI DEALERSHIP NUMEROUS TIMES FOR MY HEADLIGHTS GOING OUT SINCE MARCH 2020 AND THEY WENT OUT AGAIN ON 1/6/2020 IS IT POSSIBLE THAT IT COULD BE THE WIRING HARNESS THAT IS NO GOOD.

AS PART OF NHTSA RECALL #20V-520, HYUNDAI RECALL #194, I WAS INFORMED THE PART THAT HAS STARTED FIRES, WOULD MAY MERELY BE INSPECTED AND NOT REPLACED. THIS PART SHOULD BE REPLACED SINCE IT IS KNOWN TO START FIRES.

TL* THE CONTACT OWNS A 2015 HYUNDAI SANTA FE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V520000 (SERVICE BRAKES, HYDRAULIC) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT SPOKE TO CIOCCA HYUNDAI OF WILLIAMSPORT (202 LYCOMING MALL DR, MUNCY, PA 17756; (570) 567-2000) WHERE IT WAS CONFIRMED THAT THE PART WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

OIL CONSUMPTION WITHIN 200 MILES BLIND SPOT DETECTION DOESN'T WORK

I HAVE ALREADY REPLACED THE MAP SENSOR AND THE BATTERY LAST YEAR. CAR WAS SHUTTING OFF WHILE DRIVING WITH NO WARNING. CHECK ENGINE LIGHT WOULD STAY ON. RECENTLY IN LAST COUPLE MONTHS NOTICED ISSUES WITH THE BRAKES. WHEN APPLYING PRESSURE TO BRAKES WHILE ON FREEWAY THE STEERING WOULD SHAKE AND FEEL LIKE I HAD NO CONTROL. JUST RECEIVED NOTICE OF A BRAKE RECALL BUT THERE IS STILL NO REMEDY. HOW LONG DO I WAIT FOR THEM TO COME UP WITH A REMEDY?

IN LATE SEPTEMBER WE RECEIVED A RECALL NOTIFICATION ("CAMPAIGNE194") FROM THE MANUFACTURER STATING THAT A BREAK FLUID LEAK IN THE ANTI-LOCK BRAKE SYSTEM COULD CAUSE AN ELECTRICAL SHORT WITH POTENTIAL FIRE IN THE ENGINE COMPARTMENT. MY WIFE IMMEDIATELY WENT TO THE DEALER, FITZGERALD HYUNDAI ROCKVILLE MD, TO GET IT FIXED. THEY SAID THE FIX WAS NOT READY AND THAT WE WOULD BE CONTACTED. WHEN TOLD THEM THAT WE PLANNED TO DRIVE TO SOUTH FLORIDA (FROM JUST NORTH OF WASHINGTON DC), THEY BRUSHED OFF HER CONCERN WITH A CARELESS ATTITUDE. WE ARE NERVOUS ABOUT DRIVING THE VEHICLE AT ALL AND SEE ON YOUR WEBSITE THAT THE MANUFACTURER IS OBLIGED "TO REMEDY THIS SAFETY RECALL FOR YOUR VEHICLE IN A TIMELY MANNER". WE HAVE RECEIVED NO FOLLOW-UP FROM THEM AND FEEL THAT GIVEN THIS BEGAN IN AUGUST, A "TIMELY MANNER" HAS NOT BEEN MET. IS OUR VEHICLE SAFE TO DRIVE?! WE THANK YOU IN ADVANCE FOR YOUR QUICK RESPONSE.

THE VENDOR HAS HAD MONTHS TO HAVE A REMEDY TO FIX THE ABS BRAKE FLUID LEAKING CAUSING POTENTIAL ENGINE FIRES.

TL* THE CONTACT OWNS A 2015 HYUNDAI SANTA FE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V520000 (SERVICE BRAKES, HYDRAULIC) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. GREENWAY HYUNDAI OF ATHENS (4160 ATLANTA HWY, ATHENS, GA 30606, (706) 612-9500) WAS CONTACTED AND IT WAS CONFIRMED THAT PARTS WERE NOT YET AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2015 HYUNDAI SANTA FE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V520000 (SERVICE BRAKES, HYDRAULIC) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2015 HYUNDAI SANTA FE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V520000 (SERVICE BRAKES, HYDRAULIC) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. FAMILY HYUNDAI DEALER, SERVICE & PARTS (8101 W 159TH ST, TINLEY PARK, IL 60477, (708) 444-7100) WAS CONTACTED BY PHONE AND IT WAS CONFIRMED THAT PARTS WERE NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2015 HYUNDAI SANTA FE. THE CONTACT STATED WHILE DRIVING 40 MPH, SHE HAD HEARD AN ABNORMAL KNOCKING SOUND COMING FROM THE ENGINE. AS THE CONTACT ATTEMPTED TO PULL OVER, THE VEHICLE BEGAN TO LOSE POWER WITH SEVERAL WARNING LIGHTS ILLUMINATED. THE CONTACT WAS PULLED OVER TO SHOULDER AND BLACK SMOKE STARTED COMING FROM THE ENGINE. DUE TO THE FAILURE, THE CONTACT HAD THE VEHICLE TOWED TO POHANKA HYUNDAI OF FREDERICKSBURG (5200 JEFFERSON DAVIS HWY A, FREDERICKSBURG, VA 22408). THE NEXT DAY, THE CONTACT WAS INFORMED THAT A CONNECTING ROD BECAME DEFECTIVE AND LED TO COMPLETE ENGINE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 108,818.*DT CONSUMER STATED VEHICLE IS CURRENTLY AT POHANKA HYUNDAI OF FREDERICKSBURG.*JB

TL* THE CONTACT OWNS A 2015 HYUNDAI SANTA FE. THE CONTACT STATED THAT SHE HAD TO DEPRESS THE BRAKE PEDAL TO THE FLOORBOARD FOR THE VEHICLE TO COME TO A COMPLETE STOP. THE CONTACT STATED THAT THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT HAD TAKEN THE VEHICLE FOR EMISSIONS TESTING AND WAS INFORMED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 20V520000 (SERVICE BRAKES, HYDRAULIC) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE INDEPENDENT MECHANIC WHERE THE CONTACT PURCHASED THE VEHICLE WAS CONTACTED AND REFERRED HER TO THE MANUFACTURER. THE MANUFACTURER WAS NOT CONTACTED. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE FAILURE MILEAGE WAS UNKNOWN. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2015 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING, THE BRAKES LOCKED UP AND STARTED TO SHIFT WITH THE CHECK ENGINE WARNING LIGHT FLASHING. THE CONTACT CALLED NALLEY HYUNDAI (7909 MALL PKWY, STONECREST, GA 30038) AND INFORMED THE DEALER OF THE FAILURE AND SCHEDULED AN APPOINTMENT. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 20V520000 (SERVICE BRAKES, HYDRAULIC). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 92,225.

I FOUND ABS ALARM MESSAGE ON DASHBOARD. WHEN I VISITED LOCAL DEALER SHOP, IT IS PROBLEM ON ABS MODULE. BUT I HEARD 2015 HYUNDAI SANTA FE HAS RECALL FOR ABS MODULE. BUT DEALER SHOP TOLD ME MU CAR IS NOT INCLUDED IN RECALL.I JUST WONDER WHY MY CAR IS NOT AVAILABLE RECALL. IT IS SAME KIND OF CAR. I WOULD LIKE THEY INVESTIGATE MY CAR IS AVAILABLR RECALL.

TL* THE CONTACT STATED THAT WHILE DRIVING THE VEHICLE STARTED TO SMOKE FROM THE EXHAUST PIPE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC AND WAS DIAGNOSED THAT THE ENGINE WAS BURNING OIL AND NEEDED TO BE CHANGED. THE OIL WAS CHANGED IN HOPES IT WOULD REPAIR THE FAILURE. THE VEHICLE WAS THEN TOWED TO HERB CONNOLLY HYUNDAI, 520 WORCESTER RD, FRAMINGHAM, MA 01702, AND WAS DIAGNOSED THAT THE ENGINE OIL LEVEL WAS PERFECT ON ARRIVAL AND WAS NOT REPLICATING THE FAILURE OF THE SMOKE. THE FAILURE RECURRED. THE VEHICLE WAS THEN TOWED TO MIRAK HYUNDAI, 1165 MASSACHUSETTS AVE, ARLINGTON, MA 02476, WHERE IT WAS DIAGNOSED THAT TOO MUCH OIL WAS ADDED. THE DEALER INFORMED THE CONTACT WAS TO PICK UP THE VEHICLE. THE DEALER INFORMED THE CONTACT THAT THERE WAS NO REMEDY AVAILABLE FOR THE OPEN RECALL OF NHTSA CAMPAIGN NUMBER: 20V520000 (SERVICE BRAKES, HYDRAULIC). THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND PROVIDED A CASE NUMBER. THE FAILURE MILEAGE WAS APPROXIMATELY 55,000. PART DISTRIBUTION DISCONNECTED. - (RECALL RELATED INCIDENT) TS

GOOD MORNING, I'M REACHING HERE BECAUSE HYUNDAI HAD BEEN NEGLECTING HELPING ME WITH A RECALL THE VEHICLE HAS. THE VEHICLE IS IN THE DOMINICAN REPUBLIC. THE VEHICLE IS AT THE MAGNA HYUNDAI, OFFICIAL DEALER FROM HYUNDAI IN THE DOMINICAN REPUBLIC. I'M ATTACHING THE LAST EMAIL CORPORATE HYUNDAI USA SENT ME. ALL I'M ASKING IS TO FIX THE ENGINE FAILURE BECAUSE OF THE RECALL. THE DEALER IN THE DOMINICAN US WILLING TO COOPERATE IF HYUNDAI USA GIVES THEM THE GREEN LIGHT. THE VEHICLE WAS BUILT HERE IN THE USA. THE VEHICLE WAS JUST USED FOR ABOUT 1K MILES. WE BOUGHT IT IN MARCH 2020.

THERE IS ONE RECALL OUT ON MY 2015 HYUNDAI SANTA FE SPORT HAVING TO DO WITH RISK OF ENGINE COMPARTMENT FIRE. THE ABS SYSTEM CAN LEAK ONTO AN ELECTRICAL MOTOR AND CAUSE AN ENGINE COMPARTMENT FIRE. I HAVE NEVER RECEIVED AN OFFICIAL WORD ON THIS RECALL - ONLY WORD OF MONTH/ RADIO. THERE IS NO REMEDY YET UNTIL END OF OCTOBER 2020.

ENGINE SEIZED ON 2015 HYUNDAI SANTA FE. NO WARNING AT ALL. TOWED TO LOCAL MECHANIC SHOP. DID NOT TAKE TO HYUNDAI DEALERSHIP. MECHANIC FOUND NO OIL IN THE DIP STICK. SYNTHETIC OIL CHANGE DONE A LITTLE OVER A MONTH AGO. VEHICLE JUST WENT OVER 100K IN MILEAGE. I'VE KEPT UP WITH THE MAINTENANCE SCHEDULES. HAS TO BE SOMETHING WITH THESE HYUNDAI ENGINE.

FUEL CONSUMED MORE , LIGHTENING IN BACK NOT CLEAR , ENGINE SOUND ,

TL* THE CONTACT OWNS A 2015 HYUNDAI SANTA FE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V520000 (SERVICE BRAKES, HYDRAULIC) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT CALLED WEST BROAD HYUNDAI LOCATED AT 8903 W BROAD ST, RICHMOND, VA 23294, (804) 755-7777, AND IT WAS CONFIRMED THAT PARTS WERE NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.*DT *AS

ENGINE SEIZED-NEEDED COMPLETE REPLACEMENT; $3,344 PAID TO WAIKEM HYUNDAI CANTON, OH- ENGINE LIGHT CAME WHILE DRIVING AND CAR STALLED. NEVER STARTED AGAIN, TOWED TO WAIKEM HYUNDAI, DENIED WARRANTY COVERAGE STATING NO PROOF OF ADEQUATE OIL CHANGES, EVEN THOUGH MANY PUBLISHED REPORTS OF HYUNDAI SANTA FE ENGINE FAILURES. I BELIEVE ENGINE RECALLS EXIST FOR 2014, ONE YEAR AWAY FROM OUR 2015- BELIEVE ISSUES OBVIOUSLY WEREN'T FIXED AND HYUNDAI NOT BEING ACCOUNTABLE FOR THEIR MISTAKES. OWNED MANY, MANY VEHICLES OVER MANY YEARS...NONE EVER HAD COMPLETE ENGINE FAILURE LIKE THIS HYUNDAI. REPAIR RECEIPT AVAILABLE UPON REQUEST.

CAR WAS BOTH TO DEALERSHIP ON 3/7/2020 -3/12/2020 THE HEADLIGHT WENT OUT THEY REPLACED THE BCM RETURNED TO DEALERSHIP ON 3/19/2020 HEADLIGHT NOT TURNING ON HEATED SEAT WENT OUT AND REAR WINDSHIELDWIPER NOT WORKING GOT BABK 3/20/20 BOUGHT BACK AGING ON 4/22/202 AND RETURNED TO ME ON 5/07/2020 FOR SAME THING IT IS BACK AGAIN AT DEALERSHIP FOR THE SAME THING. I WENT TO START THE CAR UP TO GO TO WORK AND THE LIGHTS DID NOT COME ON IT WAS RAINING THAT DAY AND TURNED ON THE REAR WIPER ON THAT DID NOT TURN ON THEN I TRIED THE HEATED SEAT TURNED IT ON AND IT WENT OUT.

WAS DRIVING TO WORK ON AN INTERSTATE HIGHWAY, GOING APPROXIMATELY 65-75MPH FOR ABOUT 10 MINUTES. AS I PUSHED THE ACCELERATOR TO PREPARE FOR A LANE CHANGE, I REALIZED THAT I COULD PUT THE ACCELERATOR ALL THE WAY TO THE FLOOR WITH NO RESPONSE. I IMMEDIATELY NOTICED THAT MY "CHECK ENGINE" LIGHT APPEARED. I TRIED AGAIN UNSUCCESSFULLY, THEN TRIED THE BREAKS. THE BREAKS WERE VERY STIFF, AS IF THEIR POWER TO THE ENGINE WAS CUT OFF. I TRIED TO TURN OFF OF THE HIGHWAY ONTO THE CURB, AND I NOTICED THAT MY STEERING WHEEL WAS ALSO VERY STIFF. ALTHOUGH I COULD TURN, IT TOOK MUCH MORE STRENGTH THAN USUAL. I LET THE SPEED DECLINE NATURALLY UNTIL IT STOPPED ENTIRELY ON THE SIDE OF THE HIGHWAY. WHILE STOPPED, I TRIED REPEATEDLY TO USE THE BREAKS, GAS, AND TEST THE STEERING, BUT THE SAME ISSUES WERE THERE WITH ZERO SUCCESS. ONE THING I CAN NOTE WAS THAT THE BATTERY APPEARED TO BE WORKING JUST FINE, AS MY RADIO WAS ON THROUGHOUT THIS ENTIRE TIME. THE CHECK ENGINE LIGHT REMAINED ON UNTIL I TURNED THE CAR OFF, AND WAITED A FEW MINUTES. I TURNED THE CAR ON AFTER SOME TIME AND IT IMMEDIATELY WORKED - WITH EVERYTHING ELSE APPEARING TO FUNCTION PROPERLY. THE LIGHT AT THIS TIME WAS OFF, AND HAS NOT HAPPENED SINCE. I IMMEDIATELY TURNED THE CAR INTO THE HYUNDAI DEALERSHIP, BUT BECAUSE THE LIGHT TURNED OFF, THEY CLAIM THAT THEY ARE NOT ABLE TO READ WHAT HAD HAPPENED DURING THIS INCIDENT. THEY GAVE THE CAR BACK TO ME WHILE OFFERING NO SUGGESTIONS, THEY DID NOT EVEN TAKE THE TIME TO LOOK AT THE ENGINE. THE

2015 HYUNDAI SANTA FEE I BOUGHT NEW, TURBO SPORT. AT 26,750 MILES THE DISC PADS ON ALL 4 WHEELS FELL OFF THE STEEL BACKING PLATES. THE PADS IN THE FRONT WERE PAPER THIN AND THE BACK WERE SOMEWHAT BETTER. THE "SQUEALERS" THAT WARN YOU OF PAD THICKNESS NEVER MADE A SOUND. DANGEROUS SITUATION. I'M A 50 YEAR SERVICE MECHANICS, NEVER SAW THIS BEFORE. THE PADS COULD HAVE CAUSED AN ACCIDENT WITH LACK OF STOPPING. I'M NOT ASKING FOR MONEY BACK FROM THEM, WARNING OWNERS NOT TO EXPECT THE 50K MILEAGE STANDARD FOR HYUNDAI VEHICLES. I CALLED THEM AT HEADQUARTERS TO WARN THEM OF THIS SITUATION. COULD HAVE CAUSED GRAND MOTHER AND CHILD SOME SERIOUS OUT COME AS THAT IS THE ONLY USE FOR THIS VEHICLE. BEWARE