2002 Ford Ranger complaints

TL*THE CONTACT OWNS A 2002 FORD RANGER. WHILE DRIVING APPROXIMATELY 35 MPH ON AN ICY ROAD, THE VEHICLE SKIDDED, FOLLOWED BY A LOUD SOUND OF SPINNING TIRES. SUDDENLY, THE VEHICLE BEGAN TO LUNGE FORWARD. THE CONTACT WAS ABLE TO GAIN CONTROL AND CONTINUE DRIVING TO HER DESTINATION. AFTER THE VEHICLE WAS PARKED FOR SIX HOURS AND RESTARTED, THERE WAS NO RESPONSE WHEN PRESSURE WAS APPLIED TO THE ACCELERATOR PEDAL BECAUSE THE WHEELS LOCKED. A MECHANIC INSPECTED THE VEHICLE AND UNLOCKED THE WHEELS. THE BRAKES WOULD NOT FUNCTION EFFECTIVELY AFTER THE WHEELS WERE UNLOCKED. ALSO, THE FOUR WHEEL DRIVE WOULD NOT OPERATE UPON ENGAGEMENT. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE WAS RELATED TO A RECALL DEFECT UNDER NHTSA CAMPAIGN ID NUMBER 02V035000 (POWER TRAIN: DRIVELINE: DIFFERENTIAL UNIT). THE RECALL PERTAINED TO MANUAL TRANSMISSIONS WHICH RESULTED TO THE VEHICLE NOT BEING INCLUDED. THE FAILURE MILEAGE WAS 73,000. THE VIN WAS UNAVAILABLE.

TL*THE CONTACT OWNS A 2002 FORD RANGER. WHILE PERFORMING MAINTENANCE ON THE VEHICLE, THE CONTACT NOTICED THE FRAME WAS RUSTING. OVER THE COURSE OF A FEW YEARS, THE RUSTING HAD PROGRESSED AND WORSENED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER BUT THE FAILURE WAS NOT DIAGNOSED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE WAS 81,000. UPDTATED 2/17/11 *CN UPDATED 04/29/11

FRONT LEFT WHEEL BEARING IS GOING OUT WITH JUST 77,000 MILES ON THE VEHICLE. *TR

PURCHASED P245 75R 16 DEFINITY DAKOTA A/T TIRES FORM PEPBOYS 02/08/2009. I HAVE HAD THEM IN TO BE CHECKED ABOUT 3 TIME FOR BEING OUT OF BALANCE AND KEEP ASK THEM ARE THE TIRE BELT AND ARE TREAD DEFECTED. THE TIRES SEEM TO VIBRATE CONSTANTLY EVEN AFTER A NEW BALANCE. I HAVE ASK THEM ARE THE BELTS SEPARATING AND IS THERE A RECALL ON MY TIRES DOT UT70 PA8 0408 AND DOT UT70 PA8 4808? I BELIEVE THAT THESE TIRE ARE DEFECTED. THAT IS WHY I AM COMPLAINING. I AM GOING BACK TO PEPBOYS TODAY AGAIN AND HOPING THIS CAN BE RESOLVED. I DO NOT WANT TO BE IN AN INJURY OR CRASH. *TR

I OWN A 2002 FORD RANGER WITH A 3.0FEV IT HAS HAD THE PROBLEM RELATED TO NHTSA ID 10018746, FORD TSB 052212. WHILE THE TRUCK WAS UNDER WARRANTY THE DEALERS COULD NOT "FIND THE PROBLEM" AFTER THE WARRANTY RAN OUT THEY FOUND THIS ISSUE AND ARE WILLING TO FIX IT FOR SEVERAL HUNDRED DOLLARS. *TR

WHEN THE DEALERSHIP DISCONNECTED OUR SPEED CONTROL (RECALL) THE ABS LIGHT CAME ON AND STAYED ON WHICH EVENTUALLY LED TO FAILURE OF THE REAR BRAKE SYSTEM. THEY WOULD LOCK UP WHILE GOING DOWN THE ROAD. WE HAD TO HAVE THE REAR BRAKES AND WHEELS REBUILT AND SPENT OVER $1,000 ON REPAIRS. WHEN THE ABS LIGHT CAME ON IMMEDIATELY AFTER DISCONNECTION OF THE CRUISE CONTROL THE DEALERSHIP CHECK IT OUT AND SAID IT WOULD BE FINE. I HAVE A HARD TIME BELIEVING THAT THIS VEHICLE JUST DEVELOPED A SUDDEN BRAKE ISSUE THAT JUST HAPPENED TO CO-INSIDE WITH THE DISCONNECTION OF THE CRUISE CONTROL. WHAT IS EVEN HARDER TO BELIEVE IS THAT ONCE IT WAS FIXED THE BRAKE LIGHT MAGICALLY WENT OFF. *TR

WAS IN AN ACCIDENT AND THE AIRBAG DIDN'T DEPLOY DID SOME RESEARCH ON THE INTERNET AND FOUND OUT THERE IS A WIRE UNDER THE DRIVER'S SEAT THAT IS TOO SHORT. IF SOMEONE TALL LIKE ME PUSHES THE SEAT BACK ALL THE WAY IT STRETCHES THE WIRE AND CAUSES THE SAFETY SYSTEM TO ERROR AND SHUT OFF. AN AIRBAG WARNING LIGHT LIGHTS UP ON THE DASHBOARD. FORD ISSUED A BULLETIN TO THE DEALERS AND ARE WELL AWARE OF THE PROBLEM. I'VE READ CASES OF PEOPLE BEING CHARGED $600 TO FIX IT. *TR

IT SHIFTS THE FIRST GEAR EXTREMELY HARD, ONCE THIS HAPPENS, THE OVERDRIVE LIGHT BLINKS..AFTER DOING SOME RESEARCH I UNDERSTAND THIS A COMMON PROBLEM WITH THIS YEAR FORD RANGER

TL*-THE CONTACT OWNS A 2002 FORD RANGER. THE CONTACT WAS DRIVING APPROXIMATELY BETWEEN 40-45 MPH; PROCEEDING TO MAKE A LEFT TURN. WHILE BRAKING THE VEHICLE INCREASED ACCELERATION. THE VEHICLE WAS ABLE TO SLOW DOWN AFTER SEVERAL ATTEMPTS. THE FAILURE OCCURRED INTERMITTENT AND MORE FREQUENT WHEN THE AIR CONDITION SYSTEM WAS ACTIVATED. THE VEHICLE HAD NOT BEEN REPAIRED FOR THE MALFUNCTION AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS 34,000.

TL*THE CONTACT OWNS A 2002 FORD RANGER. WHILE DRIVING APPROXIMATELY 25 MPH ON NORMAL ROAD CONDITIONS, THERE WAS A LOUD NOISE COMING FROM THE EXTERIOR OF THE VEHICLE. SUDDENLY, THE SPARE TIRE WELL DETACHED FROM ITS FRAME AND ONTO THE ROAD. A REPLACEMENT SPARE TIRE WELL WAS INSTALLED AT A LOCAL REPAIR SHOP. THE VEHICLE WAS LATER TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT THE FRAME EXHIBITED SEVERE RUST AND CORROSION. THUS CAUSING DEFECTS IN THE FUEL TANK STRAP AND TRANSMISSION CROSS BEAM. THE BRAKE LINE AND SHACKLES WERE ALSO DAMAGED. THE VEHICLE WAS NOT REPAIRED WHEN THE COMPLAINT WAS FILED. THE FAILURE MILEAGE WAS 70,000 AND THE CURRENT MILEAGE WAS UNKNOWN.

HEATER CORE STARTED LEAKING WINDOWS FOGGED UP I ALMOST WRECKED. *TR

ON 02-21-2010 MY 2002 FORD RANGER STARTED ON FIRE. I WAS RETURNING HOME WITH IN LESS THEN 5MINS MY CAR WAS BURST INTO FLAMES. AFTER THE FIRE DEPARTMENT CAME TO MY AID THERE WAS NOTHING LEFT OF MY TRUCK. I RECEIVED THE RECALL NOTICE FROM FORD IN 12-2010 AND TOOK MY TRUCK IN FOR THE RECALL REPAIR. THIS WAS 3 WEEKS BEFORE THE FIRE. EVEN WITH THE RECALL MY TRUCK BURST INTO FLAMES LEAVING NOTHING BUT THE FRAME. *TR

I'VE OWNED MY 2002 FORD RANGER SINCE NEW AND HAVE HAD ALL SERVICE PERFORMED BY THE DEALER. THE VEHICLE HAS 60,000 MILES AND WAS SERVICED UNDER A CONTRACT PURCHASED WITH THE VEHICLE WHEN NEW. ISSUES WITH THE BRAKES STARTED WITHIN THE FIRST YEAR OF OWNERSHIP AND HAVE STEADILY WORSENED SINCE. THE COMPLAINT HAS BEEN SUBMITTED TO VARIOUS DEALERS AT LEAST TEN TIMES WITH NO TROUBLE FOUND. ONE FAILURE MODE I HAVE OBSERVED RESULTED IN THREE VERY CLOSE CALLS WHERE THE BRAKE PEDAL IS FIRM, BUT THE VEHICLE DOES NOT SLOW. PRESSING THE BRAKE HARDER DOES NOT INCREASE BRAKING EFFECTIVENESS. IN ONE INSTANCE, I WAS FORCED TO DRIVE OFF THE ROAD TO AVOID (KILLING) A PEDESTRIAN. A SECOND FAILURE MODE IS THE OPPOSITE; A SLIGHT AMOUNT OF PRESSURE APPLIED TO THE BRAKE PEDAL RESULTS IN THE FRONT BRAKES LOCKING. A THIRD FAILURE MODE IS WHERE BRAKING RESULTS IN A VIOLENT SHIMMY, WHICH CAUSED ME TO LOSE CONTROL ON SNOWPACK AND SLIDE OFF THE ROAD. NONE OF THESE FAILURE MODES HAS BEEN CONSISTENT, NOR HAVE THEY REPEATED AT THE DEALERSHIP. I AM VERY CONCERNED FOR MY SAFETY AND THAT OF THOSE AROUND ME. MY RESEARCH HAS REVEALED MANY FOLKS WITH SIMILAR ISSUES. *CN

2002 FORD RANGER O\D LIGHT FLASHES AND TRANSMISSION SHIFTS HARD AND INCONSISTENTLY. *TR

I, AMONG OTHERS OWN A FORD RANGER XLT 4.0 LITER. I RECENTLY REPLACED MY BATTERY AND LOST MY FOUR WHEEL DRIVE. AFTER SOME INVOLVED RESEARCH, I DISCOVERED THAT THIS IS A RECURRING PROBLEM WITH FELLOW 2001, 2002 RANGERS. FORD'S REFUSAL TO CLAIM RESPONSIBILITY FOR THIS ENGINEERING FLAW IS UNSAFE, UNFAIR, AND UNACCEPTABLE. FORD IS MAKING A FORTUNE FROM THIS UNFORTUNATE SITUATION AND IT NEEDS TO BE ADDRESSED. THIS IS CRIMINAL! *TR

2002 FORD RANGER, SEAT BELT COME UNDONE WHILE DRIVING. EVERY TIME I DRIVE THE CAR, IT COMES UNDONE AT LEASED 5 TIMES A DAY WHILE DRIVING EVERY DAY SINCE I BOUGHT THE VEHICLE. WENT TO FORD AND THEY WOULDN'T EVEN LOOK AT IT. JUST TOLD ME TO BUY A NEW ONE....WHICH I COULDN'T AFFORD, ALSO THE PLASTIC HANDLE ON THE TAILGATE BREAKS OFF EVERY COUPLE OF YEARS, AND I HAVE TO REPLACE IT. *TR

BREVARD COUNTY SHERIFF AND FLORIDA HIGHWAY PATROL VERIFIED THE LEFT REARCOOPER TIRE ON MY '02 FORD PICK-UP TRUCK DELAMINATED CAUSING ME TO LOOSE CONTROL OF THE TRUCK ON HWY 95 AND GO AIRBORN AND ROLL OVER THREE (3) TIME, LANDING IN THE MEDIAN STRIP OF HWY 95 IN A CONSTRUCTION ZONE, TOTALLY DESTROYING MY TRUCK. I WAS REMOVED FROM THE TRUCK WITH JAWS OF LIFE, TRANSPORTED TO THE HOSPITAL. MY INJURIES WERE CONSIDERED MINOR, TREATED AND MANAGED IN THE EMERGENCY ROOM AT AN AREA HOSPITAL. FOLLOW UP CARE WITH VERO BEACH, FL PHYSICIANS FOLLOWED. THE DELAMINATION OF THE COOPER TIRE WAS DUE TO A DEFECTIVE TIRE. TIRE SIZE WAS 31" X 10.5 , TIRE LINE: OWL ALL TERRAIN TIRES; VEHICLE INFO: FORD RANGER 2002 PICK-UP TRUCK. *TR

WHILE ACCELERATING OR ATTEMPTING TO PASS ANOTHER VEHICLE THE ENGINE STARTS TO CUT OFF LIKE IT IS STARVING FOR FUEL. STARTED HAPPENING ABOUT 1 YEAR AGO AND CONTINUES TO THIS DATE. *TR

I WAS BACKING MY 2002 FORD RANGER XLT INTO MY DRIVEWAY AND WHEN I STOPPED THE DRIVER SIDE SEAT BACK GAVE WAY WITHOUT WARNING AND I SLAMMED INTO THE BACK OF THE CAB. WHEN I LOOKED AROUND THE SEAT I SAW TWO BOLT HEADS ...THEY APPEARED TO BE SHEARED OFF. MY SEAT BACK WILL NOT STAY OR LATCH ANY MORE. *TR

TL*THE CONTACT OWNS A 2002 FORD RANGER. WHILE DRIVING 35 MPH THE VEHICLE BEGAN TO OVER HEAT AND SMOKE CAME OUT OF THE ENGINE. THE CONTACT WAS ABLE TO STOP THE VEHICLE AND SHUT THE ENGINE OFF; HOWEVER, AS SOON AS HE SHUT THE ENGINE OFF, THE VEHICLE CAUGHT FIRE. THE CONTACT ATTEMPTED TO EXTINGUISH THE FIRE AND WAS UNSUCCESSFUL. THE ENTIRE VEHICLE WAS ENGULFED IN FLAMES AND WAS COMPLETELY DESTROYED. THE CAUSE OF THE FIRE HAS NOT BEEN DETERMINED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 146,000.

THE VEHICLES ENGINE SHUTS OFF AS IT IS BEING ACCELERATED, OR AT CRUISING SPEED. THE ENGINE IS THE ONLY SYSTEM AFFECTED BUT CAUSES VEHICLE TO BE UNDRIVABLE FOR AROUND 5-10 SECONDS UNTIL VEHICLE PUTS ITSELF BACK IN GEAR AFTER SHUTTING OFF. THIS OCCURS RANDOMLY SOMETIMES RIGHT AWAY AFTER VEHICLE IS STARTED AND MOVED OR OTHER TIMES AFTER LONGER PERIODS OF DRIVING. IT HAS OCCURRED REPEATEDLY, WHEN THE VEHICLE ENGINE COMES BACK AND IT DOES PUT ITSELF BACK INTO GEAR AND YOU START TO ACCELERATE AGAIN IT WILL CUT OFF. IT HAS CAUSED OPERATOR NOT TO BE ABLE TO ACCELERATE TO MERGE ONTO HIGHWAYS, PULL OUT ONTO ROADS, OR TO MAINTAIN CRUISING SPEEDS IN ROADS OR HIGHWAYS. IT HAS BEEN TAKEN TO FORD DEALERSHIP FOR REPAIRS 3 TIMES. EACH TIME THE ENGINE CONTROL RELAY DIODE HAS BEEN CHANGED AND BLAMED FOR PROBLEM. THE VEHICLE HAS BEEN CONNECTED TO COMPUTER AND DRIVEN(FIRST TIME AT FORD REPAIR SHOP), THE ENGINE HAS CUT OUT CAUSING VEHICLE TO STOP ACCELERATING AND THE COMPUTER SHOWS THAT NOTHING IS HAPPENING. IT CONTINUES TO READ THAT THE VEHICLE IS RUNNING FINE.I HAVE PERSONALLY REPLACED COIL PACK, AND THROTTLE POSITION SENSOR. THE FIRST TIME DIODE WAS REPLACED THE VEHICLE RAN FOR ALMOST 8 MONTHS THEN PROBLEM RECURRED. IT WAS TAKEN TO FORD AND DIODE REPLACED AGAIN, THIS TIME LASTING ONLY 2-3 MONTHS. IT WAS TAKEN TO FORD THE 3RD TIME FOR DIODE TO BE REPLACED, THIS TIME LASTING ONLY 2 WEEKS. I CALLED THE FORD SHOP AND SPOKE TO MANAGER AND WAS TOLD THAT THE ENTIRE WIRING HARNESS WOULD HAVE TO BE REPL

TL*THE CONTACT OWNS A 2002 FORD RANGER WITH TWO FRONT FIRESTONE DESTINATION LE P245/75R16 TIRES. WHILE DRIVING 60 MPH, THE VEHICLE STARTED VIBRATING. THE CONTACT DECREASED THE SPEED EXPECTING THE VIBRATION TO STOP; HOWEVER, WHILE DRIVING 55 MPH, THE FRONT DRIVER SIDE TIRE BLEW OUT. THE IMPACT CAUSED THE LEFT FRONT FENDER TO EXTEND OUTWARD APPROXIMATELY ONE INCH. A LOCAL REPAIR FACILITY MECHANIC STATED THAT THE BLOW OUT WAS CAUSED BY ROAD HAZARD MATERIALS. THE CONTACT WAS CONCERNED THAT THE VIBRATION CAUSED THE TIRE BLOW OUT. THE MANUFACTURER STATED THAT THEY INSPECTED THE TIRES AND SINCE THEY WERE UNABLE TO DETERMINE HOW LONG THE TIRES WERE ON THE VEHICLE THEY WERE UNABLE TO REPLACE THEM FREE OF CHARGE. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE WAS 45,000. UPDATED 10/06/09 *BF

TL*THE CONTACT OWNS A 2002 FORD RANGER. THE CONTACT WAS INFORMED BY HIS NEIGHBOR THAT HIS VEHICLE WAS SMOKING IN THE DRIVEWAY. THE CONTACT NOTICED BLACK SMOKE COMING FROM THE VEHICLE. THE FIRE DEPARTMENT DISCONNECTED THE BATTERY AND STATED THAT THERE WAS ELECTRICAL FAILURE. THERE WERE NO FLAMES PRESENT, BUT A FIRE REPORT WAS FILED. A CASE WAS FILED WITH THE MANUFACTURER AND THEY STATED THAT THE ANTI-LOCK BRAKING SYSTEM CAUSED THE FAILURE. NO REPAIRS WERE MADE TO THE VEHICLE. THE VIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 99,000.

DRIVING ON FREEWAY AT APPROX 65 MPH FELT SEVERE VIBRATION AND MANAGED TO PULL OVER ACROSS THREE LANES TO GORE POINT AT AN ON RAMP FRONT RIGHT TIRE HAD SIDEWALL COMPLETELY SEPARATE FROM TREAD VEHICLE 2002 FORD RANGER. *TR

THE TIRES STARTED TO WEAR IN AN ODD CUPPING SHAPE AFTER CHECKING TIRE PRESSURE CONSTANTLY TO VERIFY THIS WAS NOT THE CAUSE OF THE WEAR. ADDITIONALLY MULTIPLE ALIGNMENTS HAD BEEN PERFORMED TO ALSO VERIFY THIS WAS NOT THE CAUSE OF THE WEAR. AFTER DRIVING FOR WEEKS LATER, THE TIRE FAILED AT 35 MPH IN A BUSY SUBURBAN STATE ROUTE INTERSECTION. AFTER PULLING ASIDE AND REPLACING THE TIRE, I DISCOVERED A DELAMINATION OF THE TREAD. I HAD INSPECTED THE TIRES AND HAD SEEN ANOTHER STARTING TO SHOW SIGNS OF DELAMINATION. I IMMEDIATELY STARTED TO PRICE TIRES. I CONTACTED FIRESTONE ABOUT THE ISSUE AND WAS TOLD THE TIRE IS NOT ON THE RECALL. THREE DAYS LATER, AND THE OTHER TIRE IS CLEARLY DELAMINATED. I FEEL BECAUSE OF THE LOW MILES ON THE TIRES, THE CONSTANT AND PROPER PREVENTABLE MAINTENANCE PERFORMED, THE TIRES SHOULD BE REPLACED. *TR

HAVING ISSUES WITH MY TRUCK I THOUGHT MIGHT BE TRANSMISSION NOW THE DEALER SAYS IT IS A CAM SENSOR. THE TRUCK SPUTTERS AND STOPS CAUSING SEVERAL NEAR MISSES THIS HAS BEEN AN ISSUE FOR SEVERAL YEARS BUT THE DEALER WAS NOT BALE TO FIND THE PROBLEM. *TR

MY FORD 2002 RANGER EDGE PICK UPS AUTOMATIC TRANSMISSION FAILS TO SHIFT GEARS UNDER ACCELERATION SUCH AS TAKING OFF FROM A LIGHT OR MERGING ON INTO TRAFFIC. THE TRANSMISSION WILL SHIFT FROM ONE GEAR THAN NOT GO INTO GEAR LEAVING VEHICLE ON OF GEAR AND WITHOUT FORWARD MOTION. I HAVE HAD PROBLEMS GETTING ACROSS INTERCEPTIONS AND ONTO THE HIGHWAY. HAVE TO REMOVE FOOT FROM ACCELERATOR FOR SEVERAL SECONDS FOR TRANSMISSION TO FIND A GEAR TO SHIFT INTO. FORD MOTOR COMPANY HAS SOME SERVICE BULLETINS REGARDING SHIFTING ISSUES BUT FALL WAY SHORT OF CORRECTING THIS SAFETY ISSUE. THIS HAS AND IS AN ON GOING ISSUE SINCE THE VEHICLE WAS NEW. *TR

I HAVE A 2002 FORD RANGER, SHORTLY AFTER I PURCHASED IT THE AIR BAG LIGHT STARTED FLASHING AND THEN THE O/D LIGHT STARTED FLASHING AND THE TRANSMISSION STARTED SHIFTING REALLY HARD INTO SECOND GEAR. I TOOK IT TO THE DEALERSHIP AND THEY SAID THE TRANSMISSION NEEDED REPLACED AND THE AIRBAG SWITCH WAS BAD.. FROM WHAT I HAVE READ THIS HAS BEEN AN ONGOING PROBLEM WITH THIS TYPE OF TRANSMISSION SINCE IT CAME OUT. IT IS A SEALED TRANSMISSION, IN THAT,THE FLUID CANT BE CHECKED. IT'S VERY POORLY DESIGNED AND FORD DOESN'T WANT TO DO A RECALL EVEN THEY ARE AWARE OF THE PROBLEM.... *TR

THE RIGHT REAR AXLE FLANGE SEPARATED FROM THE AXLE, NEARLY CAUSING AN ACCIDENT, STARTING A GREASE FIRE IN THE AXLE HOUSING, AND DAMAGED THE REAR BODY PANEL ON THE RIGHT SIDE. *TR

AT APPROX. 26,500 MILES VEHICLE MADE POPPING/CLUNK SOUND ACCOMPANIED BY A JERKING MOVEMENT WHEN TURNING. ESPECIALLY SLOW TURNS AFTER MAKING A STOP. SOUND CAME FROM REAR END. 1 OR BOTH REAR TIRES WOULD BIND IN SLOW CORNERS AND SKID. FORD DEALER CONFIRMED BROKEN GEARS IN DIFFERENTIAL. 2002 RANGER EXT. CAB WITH MANUAL TRANS, 4 CYL, 2WD. $1,650 TO REPAIR. FORD WILL NOT ASSIST IN PAYING FOR ANY PART OF THIS. EVIDENTLY FORD IS SATISFIED WITH THEIR BREAD AND BUTTER TRUCKS FAILING SO QUICKLY. THIS IS HOW THEY LOSE A CUSTOMER FOR LIFE, BY NOT STANDING BEHIND THEIR VEHICLES. TOO MANY REPORTS OF THIS FAILURE FOR IT NOT TO BE TAKEN CARE OF BY FORD. VERY ANGRY, FORD, YOUR HUGE LOSSES ARE WELL DESERVED. *TR

VEHICLES CRUISE/SPEED CONTROL MALFUNCTIONS DISENGAGES AND ENGAGE ON IT'S OWN. STOPS WORKING WITH OUT NOTICE CAUSES VEHICLE TO DECELERATE RAPIDLY WITHOUT NOTICE. WILL NOT ENGAGE AGAIN AFTER SHUTTING IT OFF FOR LONG PERIODS OF TIME. SOMETIMES VEHICLE IN SPEED CONTROL MODE WILL START SURGING AND THEN CONTROL STOPS WORKING ALL TOGETHER. VEHICLE HAS 49,499 MILES. *TR

A RATTLE IN THE ENGINE COMPARTMENT OF A 2002 FORD RANGER (64,000 MILES) ATTRIBUTED TO THE TIMING CHAIN. NO DAMAGE YET, BUT I HAVE ASKED AROUND AND FOUND THIS TO BE A WIDESPREAD PROBLEM AND IN SOME CASES, LEADING TO ENGINE FAILURE. *TR

TL*THE CONTACT OWNS A 2002 FORD RANGER. WHILE DRIVING 65 MPH, THE CONTACT HEARD A RUMBLING SOUND COMING FROM THE FRONT PASSENGER SIDE TIRE. HE EXAMINED THE VEHICLE AND NOTICED THAT THE PASSENGER SIDE FRONT WHEEL BEARING WAS VERY LOOSE. THE CONTACT DID NOT NOTICE ANY DIFFERENCES IN THE VEHICLE BEFOREHAND AND THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE VEHICLE HAS BEEN REPAIRED BY THE CONTACT. THE CURRENT AND FAILURE MILEAGES WERE 94,000. UPDATED 08/04/08 *BF THE SEALED FRONT WHEEL BEARING ABS FAILED. UPDATED 08/07/08.

MY SON WAS TRAVELING ON A 4 LANE STATE HWY AT ABOUT 65 MPH IN THE OUTSIDE LANE WHEN THE DRIVER'S SIDE BACK TIRE FLEW OFF. HE SAID ALL HE REMEMBERS WAS THAT THE TRUCKS REAR DROPPED ON THAT SIDE, SPINNING THE TRUCK TO FACE THE OPPOSITE DIRECTION, AND CAUSING IT TO ROLLOVER NUMEROUS TIMES UNTIL IT LANDED IN THE DITCH ON THE OPPOSITE SIDE OF THE HWY. NOT TO MENTION IT HAD TO GO UP AND EMBANKMENT TO GET THERE. HE COULD HAVE BEEN KILLED OR SERIOUSLY INJURED. DPS , WRECKER DRIVER, MY HUSBAND AND MY SON COULD NOT FIND THE TIRE, WHICH STILL HAS THE BRAKE DRUM ON IT. UPON INSPECTION IT WAS NOTED THAT LEFT REAR AXLE BROKE BEHIND THE FLANGE WHERE THE LUG NUTS GO. I AM TOLD THIS MUST BE A DEFECT BECAUSE YOU RARELY HEAR THIS HAPPENING. DPS AND WRECKER DRIVER STATED THAT VEHICLE HAD GOOD TIRES AND LOOKED AS THOUGH IT HAD BEEN WELL TAKEN CARE OF. IT IS A 2002 FORD RANGER EDGE. *TR

WHILE TRAVELING FROM WORK ON THE INTERSTATE, I HEARD THE TREAD COME OFF OF MY REAR PASSENGER TIRE. THIS SENT ME INTO THE GUARD RAIL AND PRECEDED TO FLIP MY TRUCK OVER SEVERAL TIMES. THE TIRES SHOULD NO SIGNS OF UNUSUAL WEAR, TEAR OR DEFECT AT THIS POINT. *TR

TL*THE CONTACT OWNS A 2002 FORD RANGER. THE CONTACT STATED THAT THE CHECK ENGINE LIGHT ILLUMINATED. THE MECHANIC REPLACED THE THERMOSTAT UNIT HOWEVER, AFTER THE REPAIR THE VEHICLE CONTINUED TO LEAK COOLANT. UPON FURTHER INSPECTION, THE MECHANIC FOUND A SMALL HOLE IN THE ENGINE BLOCK. IN ADDITION, HE FOUND THAT THE ENGINE BLOCK RUSTED. THE CURRENT AND FAILURE MILEAGES WERE 62,000.

I HAVE HAD MULTIPLE ISSUES WITH MY VEHICLE SPEED CONTROL SINCE I BOUGHT THE RANGER EDGE PICKUP SINCE 2002. THE DEALERSHIP HAS CHANGED HANDS SINCE IS NOW LANDERS BUT WAS CALLED CRAIN FORD LINCOLN MERCURY. WHAT IS HAPPENING IS THE SPEED CONTROL IS DISENGAGING WHEN ACTIVATED AND NOT ACTIVATING WHEN TURNED ON AND THEN WORKING SOME TIME AFTER IT HAS BEEN DRIVEN A WHILE. I HAVE 105,000 MILES ESTIMATED BUT WHEN ENGAGED I HAVE HAD IT DISENGAGE NUMEROUS TIMES WHILE DRIVING. THIS WAS CHECKED BY FORD DEALERSHIP OVER 7 TIMES SINCE 2002 AND THEY STATED COULD NOT FIND ANY PROBLEMS AT ALL AND STATED EVERYTHING IS OK BUT THE PROBLEMS STILL PERSIST AND IT SEEMS ONCE THE TRUCK GETS WARM IT STARTS WORKING BUT STOPS WORKING AS WELL. EVEN SOMETIMES WHEN THE TRUCK HASN'T BEEN RUNNING VERY LONG THE SPEED SYSTEM WANT ENGAGE AT ALL WHILE DRIVING THE VEHICLE. IT IS VERY SCARY THOUGH WHEN IT DISENGAGES AND YOU ARE AWARE THAT IT IS NOT WORKING WHILE DRIVING ON THE INTERSTATE AND COULD CAUSE SOMEONE TO RUN INTO ME IF I DON'T NOTICE IT DUE TO THE CHANGE OF LOSS OF SPEED. ALSO THERE HAVE BEEN MANY OCCASIONS WHEN TRYING TO ACTIVATE THE SPEED CONTROL AND IT WILL NOT ENGAGE WHILE ON THE INTERSTATE FOR LONG DRIVE TIMES. WHAT CAN BE DONE???? *TR

TRANSMISSION SHIFT PROBLEMS ON 2002 FORD RANGER. DELAYED SHIFTS; ROUGH SHIFTS; OVERDRIVE LIGHT BLINKS INDICATING TRANSMISSION FAULT; SERVO COVER BLOWN OFF ALLOWING TRANSMISSION FLUID LOSS - INOPERATIVE VEHICLE. *TR

A PLASTIC WATER HEATER CONTROL VALVE IN THE VEHICLE COOLING SYSTEM DENATURED AND CRUMBLED, LEAKING COOLANT OUT OF THE VEHICLE WHICH COULD HAVE CAUSED AN ENGINE SEIZURE HAD I NOT BEEN AWARE OF THE SITUATION. THIS IS THE SECOND PLASTIC PART FAILURE (FIRST WAS THE THERMOSTAT/TEMP SENSOR HOUSING) WHICH FAILED AND LEAKED COOLANT DURING THE WARRANTY INTERVAL. COOLING SYSTEMS ARE NO PLACE FOR PLASTIC PARTS. *TR

VEHICLE WAS HIT IN DRIVER SIDE IN APRIL 2005. AIRBAG DID NOT DEPLOYED THEN. TOOK TRUCK FOR INSPECTION IN JAN 08 AND WAS REJECTED FOR AIR BAG LIGHT ON. COULD BE AIR BAG MODULE DEFECTED. *TR

2002 FORD RANGER SPEED CONTROL RECALL. CONSUMER STATES THAT THE PROBLEM COULD NOT BE REPAIRED DUE TO THE LACK OF PARTS. HE STATES THAT THE PARTS ARE STILL NOT AVAILABLE. HE WOULD LIKE TO KNOW WHEN THE PARTS WILL BE IN. *KB

TL*THE CONTACT OWNS A 2002 FORD RANGER. WHEN LOADING ITEMS INTO THE VEHICLE, THE CONTACT NOTICED THAT BOTH TAILGATE CABLES FAILED AND CAUSED THE TAILGATE TO SLAM DOWN. THE TAILGATE STRUCK THE BUMPER AND WAS DAMAGED. THE CONTACT BELIEVED THAT THE FAILURE COULD CAUSE SERIOUS INJURY. SHE SPOKE WITH THE FORD DEALER AND MANUFACTURER AND THEY BOTH DECLINED TO ASSIST. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 86,000.

TL*THE CONTACT OWNS A 2002 FORD RANGER. THE CONTACT RECEIVED A RECALL NOTICE FOR THE VEHICLE SPEED CONTROL IN THE SUMMER OF 2007. HE HAS BEEN WAITING ON THE PARTS TO ARRIVE FOR SEVERAL MONTHS. THE DEALER CONTINUES TO PROVIDE DATES AS TO WHEN THE PARTS WILL ARRIVE, BUT THEY ARE STILL UNAVAILABLE. THERE HAD BEEN NO FAILURE TO DATE. THE RECALL NUMBER, PURCHASE DATE, AND FUEL SYSTEM WERE UNKNOWN. THE CURRENT MILEAGE WAS 117,763.

TL*THE CONTACT OWNS A 2002 FORD RANGER. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 07V336000 (VEHICLE SPEED CONTROL) IN AUGUST OF 2007. HE CALLED THE MANUFACTURER ON SEVERAL OCCASIONS, BUT THEY HAVE NOT PROVIDED HIM WITH ANY SOLUTIONS. THE CONTACT IS DISPLEASED THAT THE REPAIR WORK HAS NOT YET BEEN PERFORMED. THERE HAD BEEN NO FAILURE TO DATE. THE CURRENT MILEAGE WAS 76,000. UPDATED 04/11/08 *BF UPDATED 04/11/08 *TR

I RECEIVED A LETTER IN AUG, 2007 ABOUT A SPEED CONTROL DEVICE ON MY TRUCK THAT WAS BAD. SAID TO GO HAVE IT DISCONNECTED WHICH I DID. I AM STILL WAITING FOR THE PART AND WAS TOLD ON 2/14/08 THAT THE PART STILL ISN'T AVAILABLE. I WOULD LIKE TO KNOW WHAT IS TAKING SO LONG TO GET THIS FIXED. THANK YOU *TR

I HAVE A 2002 FORD RANGER THAT WHEN I GOT THE TRUCK IT HAD TO HAVE THE SLAVE CYLINDER FOR THE CLUTCH REPLACED WHICH THE DEALER DID, AND THE TRUCK ONLY HAD 18,000 MILES, BUT THEN AGAIN BEFORE MY EXTENDED WARRANTY RAN OUT, IT WENT OUT AGAIN AT ABOUT 52000 MILES, AND NOW IT HAS HAPPENED AGAIN, AT 66,000 MILES, THE SLAVE CYLINDER AGAIN FOR THE CLUTCH, AND I AM NOT NEW TO DRIVING MANUAL TRANSMISSIONS, I AM 47 AND LEARNED TO DRIVE ON A MANUAL TRANSMISSION WHEN 16, IT ALSO UPSETS ME THAT FORD SAID MY EXTENDED WARRANTY FOR THE SECOND REPAIR DID NOT COVER THE CLUTCH SLAVE CYLINDER, AND I DO NOT BELIEVE A VEHICLE SHOULD REQUIRE THIS PART TO BE REPLACED APPROXIMATELY EVERY TWENTY OR THIRTY THOUSAND MILES. I ALSO BELIEVE SINCE I PURCHASED A MANUAL WITH AN EXTENDED WARRANTY IT SHOULD HAVE BEEN COVERED, MY SON ALSO HAS A 2000 FORD RANGER AND HE RECENTLY HAD THE SAME PROBLEM AND WE BOTH HAVE THE V6 WITH 5 SPEED MANUAL TRANSMISSION. *TR

TL*THE CONTACT OWNS A 2002 FORD RANGER. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 07V336000 (VEHICLE SPEED CONTROL) IN AUGUST OF 2007. HE WAS INFORMED THAT THE REPAIR WOULD BE PERFORMED IN OCTOBER. WHEN OCTOBER ARRIVED, THE PARTS WERE STILL UNAVAILABLE. THE DEALER CURRENTLY STATES THAT THE PARTS WILL BE AVAILABLE IN A FEW MONTHS. THERE HAD BEEN NO FAILURE TO DATE. THE CURRENT MILEAGE WAS 85,000. UPDATED 02-25-08 *BF UPDAYED*JB

I RECEIVED A RECALL FROM FORD IN AUGUST 2007. THE RECALL NUMBER IS: 05S28. I TRIED TO SCHEDULE AN APPOINTMENT IN SEP. 07 WITH SUPERSTITION FORD IN MESA, AZ. I WAS TOLD THAT THE PARTS WERE BACK ORDERED AND THAT THEY WOULD PUT MY NAME ON A LIST AND CALL ME WHEN THE PARTS WERE IN. I DID NOT RECEIVE A CALL FROM THAT DAY IN SEP., AND THEREFORE, CALLED THEM AGAIN TODAY, JAN. 28, 08. I WAS ONCE AGAIN TOLD THAT THE PARTS WERE ORDERED IN AUG. 07, BUT HAD STILL NOT ARRIVED AS THE DATE OF MY CALL. I WAS STILL ON THEIR LIST WITH MANY OTHERS TO GET THE RECALL SCHEDULED AND SATISFIED. I STRONGLY FEEL FOR THIS RECALL THAT THE TIME INTERVAL IS UNREASONABLE AND UNSAFE. *CN

TRUCK STILL NOT SHIFTING PROPERLY AFTER COMPLETE OVERHAUL BY FORD ON 5/22/04 ( COMPLAINT ODI NO. 10215891). FORD SERVICE DEPARTMENT ROAD TEST TRUCK AND VERIFIED PROBLEM. CALLED HOTLINE (5LSB2012) R&R TO OVERHAUL, FOUND STICKING VALVE IN MAIN CONTROL(7A100), RESEALED TRANS.,REPLACED MAIN CONTROL AND TORQUE CONVERTER,FLUSHED COOLER LINES. BUT I RETURNED THE TRUCK COMPLAINING THAT THERE WAS A GRINDING WINING NOISE AND STILL NOT SHIFTING RIGHT. SERVICE MANAGER ROAD TESTED AND SAID THERE WAS NOTHING WRONG. WORK WAS PERFORMED AT 60,206 MILES AND NOW AT 90,125 MILES I CAN'T DRIVE THE TRUCK BECAUSE THE TRANSMISSION S BROKEN AGAIN. THE PROBLEM IS HE TRANSMISSION WAS NEVER FIXED PROPERLY AT THE FIRST OVER HAUL OR THE SECOND TIME IT WAS OVERHAULED BY FORD. NOW I HAVE A TRUCK WITH A TRANSMISSION OVERHAULED TWICE BY FORE AND NEEDS OVERHAULED AGAIN. NOW FORD INFORMED ME THAT THE WARRANTY IS OUT AND THEY CAN NOT HELP ME. *TR

TL*THE CONTACT OWNS A 2002 FORD RANGER. THE CONTACT RECEIVED A FORD RECALL NOTICE IN AUGUST OF 2007 FOR NHTSA CAMPAIGN ID NUMBER 07V336000 (VEHICLE SPEED CONTROL). HE CALLED FORD ON FOUR SEPARATE OCCASIONS AND THEY CONTINUED TO STATE THAT THE PARTS WERE UNAVAILABLE. THE CONTACT FEELS THAT THE WAIT IS EXCESSIVE. THE DEACTIVATION SWITCH HAS NOT BEEN DISCONNECTED. THERE HAD BEEN NO FAILURE TO DATE. THE CURRENT MILEAGE WAS 46,000.