2014 Ford Fusion complaints

Fuel tank: Tank leaked when it was filled. Most of the time in my driveway but occasionally in parking lots unstil the tank level was reduced to approximately 3/4 filled. In addition fumes would fill the air surrounding the car. The automobile is being currently repaired at an independent repair facility. No other inspection other than repair facility. Initially no warning light but as it progressed the "check engine light" lit. Inspected the removed gas tank at repair facility and the caused of the problem may be a design flaw. the tank design on my vehicle (all wheel drive) is such that it has two zones and each zone has a fuel pump. The retaining plates on the tank are made of metal and therefore due to New England winters and the position of the tank and the location of the tank the retaining plates rust. This resulted in the retaining plates to rust leaving pin holes in the retaining rings causing gas and fumes to exit the fuel system.

Recall 19V632000 does not show up as a valid recall for my specific vehicle; however, it is at a Ford dealership now. the issue is bolts corroded, the steering gear motor is detached from the gear housing - just as described in the recall. My bolts disinigrated, corroded, and broke away. Can you please issue the recall to my specific vehicle

Car was purchased with less than 100,000k miles and within 2 weeks the the car was put into the shop for loss of power while driving and overheating. Had supposedly needed repair and within a week the car overheated again. Paid over 2,000 in repairs and tows due to issue. Car is towed to Ford was told coolant was in the entire and would need to be replaced over $7000. No way Ford should be able to sell calls with known issues and the consumer be responsible for outrageous repair fees. Ford customer service at corporate nor did the dealership offer any type of assistance with the exception of pay for it or start over for scratch which is impossible with today’s inflation. Ford knowingly sold a faulty product and they should be held accountable.

This is the 2nd time this has happed to me with this car. 2014 Hybrid Ford Fusion has Electronic Power Steering that is controlled by an electronic sensor. When I power steering went out (on my way to Las Vegas), I brought it to the Ford Dealer. They said I needed a new power steering column. After 3 days and doing nothing with my car, I lost my patience. To make me happy, they reset the error code and everything was magically fine - for 3 straight years! Was the power steering column bad? No! The sensor had to be cleared and reset. Now it locked up again. Looking for someone to clear this again. I am not spending $1,800 for this. This should be a recall issue for sure. 1000’s of instances!!! Stop delaying and make this a recall issue. The word “SAFETY” in NHTSA should mean something.

The contact owns a 2014 Ford Fusion. The contact stated that while operating the vehicle, the power steering assist failed, and the steering wheel became difficult to turn in either direction. Additionally, while operating the vehicle, the "Power Steering" and "Traction Control" warning lights remained illuminated. The vehicle was taken to the local dealer who diagnosed that the steering rack was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in NHTSA Campaign Number: 15V250000 (Steering). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 150,000.

Power steering failing, will not correct itself to straight while driving without manual assistance, can stay locked in turned position.

Vehicle started indicating issues turning over to crank. I purchased a new key and key fob for the vehicle and got it programmed successfully I also replaced the starter with a brand new starter, issue still present in which vehicle is not turning on when I turn vehicle on to crank.

On my way home from work I turned into my driveway and my power steering just went out and when I went to start it up again ti see if it worked the steering wheel wouldn't even move. Sometimes it'll move but will be very very hard to turn when parked and other times it won't move at all. This is a known problem that needs to be fixed, luckily I wasn't on the road when it happened but plenty of other people have been and it's a couple thousand dollar fix. Whenever I start the car I get an alert saying power steering assist, uphill assist and advancetrak all require service which fits in line with everyone else's issues. I'm not sure why this hasn't been addressed yet but it should've been dealt with fat sooner. This is an error that could very easily cost lives if it were to happen on the road especially like the express way.

The Car seems to always have a strange issue with power. I have taken it for all services and recall but nothing has every fixed that issue. From talking to other Ford fusion 2013-2014 owners the transmission is bad on these cars from the start. It would be bad to loose or have the transmission go out on any major road people could get hurt. I am now getting p0744,p0741. I believe it is related to other issue suck as car clutch assembly malfunction causing high rev because car pop into wrong gears while driving. This should be a ford issue and google search and you will find everyone who own a ford fusion having this problem.

2014 Ford Fusion 1.5 Eco boost engine now has 37,000 miles coolant leak into cylinders. Coolant container empty's quickly. Car is undrivable over heats causing a problem driving on the highway. Two mechanics confirmed.

My 2014 Ford Fusion lost all power steering and this seems to be a very common problem and when I called Ford customer service they said the VIN did not have a recall for this issue even though it seems to happen to a lot of people. This is a very dangerous situation and I can't afford to fix it so please make them do a full recall for the effected years not just specific VINs because obviously the issue is still continuing in 2024.

The contact owns a 2014 Ford Fusion. The contact stated that while operating the vehicle, there was white smoke coming from the exhaust pipes and the engine was misfiring. Additionally, the check engine warning light had remained illuminated. The vehicle was taken to the local dealer who diagnosed that engine coolant had leaked into the engine cylinders and the engine needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure and the contact was informed that the VIN was not eligible for the Manufacturer’s Extended Coverage for the failure. The failure mileage was 75,000.

My torque converter is going out in my 2014 FORD FUSION SE and it caused me to almost get t-boned twice and hit in the rear once. I pull out of the driveway and it cuts off and won't move. No engine light was on and that's a safety hazard. The dealer is telling me to continue to drive it and if it does it again take a video. The vehicle is getting looked at tomorrow as I will show the video I took too the dealership and they will actually take me seriously. I was told it was low on transmission fluid which is why I began driving it again and it happened two more times while getting it to the dealership. This could cause a hazard to others on the road and myself, it could cause injury or even death. I was so scared getting stuck in the middle of the road of oncoming traffic.

The contact owns a 2014 Ford Fusion. The contact stated while pulling out of a parking space and driving, the vehicle jerked and stalled. There was no warning light illuminated. The contact was able to pull to the side of the road. The contact turned off and restarted the vehicle, and the vehicle responded as needed. The contact stated that the failure recurred while driving on another occasion. The vehicle was taken to the dealer however, the failure could not be duplicated. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 88,000.

Shifter Cable bushing and cover Car would not move when putting into drive or reverse. It was the Shifter Cable bushing that had to be replaced. We were told that this issues was covered on OTHER vin number vehicles but not our car. WHY???

The contact owns a 2014 Ford Fusion. The contact stated while driving approximately 35 MPH, the steering assist and uphill assist warning light illuminated. Additionally, the Service Steering message was displayed. The contact stated the steering wheel was stiff and required extra effort to turn the steering wheel. The contact drove to the destination and parked the vehicle. The contact turned off and restarted the vehicle and the power steering functionality returned. The contact stated that the failure was intermittent but had become a recurring failure. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was diagnosed but was not repaired. The manufacturer was not informed of the failure. The contact had researched online and related the failure to NHTSA Campaign Number: 15V250000 (Steering). The failure mileage was approximately 127,000.

The contact owns a 2014 Ford Fusion. The contact initially discovered that the engine was consuming an excessive amount of coolant. There was no warning light illuminated. Upon inspection, the contact discovered that the coolant level was low; however, the contact later discovered that the coolant level was low again soon after topping off the coolant reservoir. The contact stated that the check engine warning light was illuminated. Upon inspection, the contact discovered that coolant was leaking into an engine cylinder. The dealer was notified of the failure and was given an estimate for a diagnostic test. The manufacturer was notified of the failure and referred the contact to the NTHSA Hotline. The vehicle was not repaired. The failure mileage was approximately 108,000.

Engine coolant leak.

The contact owns a 2014 Ford Fusion. The contact stated while driving 35 MPH during a rainstorm, the contact became aware that the electronic power steering was not functioning properly. The advanced traction control and hill assist warning lights were illuminated. The vehicle was taken to an independent mechanic, who was unable to duplicate the failure. The vehicle was taken to the dealer, who determined that the steering housing was cracked. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 19V632000 (Steering), but the VIN was not included. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 201,000.

The latch holding the driver door closed failed and the door would not close. This issue has happened before and been addressed by previous recalls but continues to be an issue.

Head gasket failed in January of 2023, replaced water pump timing belt and had a full head job completed. Head gasket failed again in September 2023; had a full head job replacement and now again, my engine has overheated with a suspected blown head gasket.

The contact owns a 2014 Ford Fusion. The contact stated while driving approximately 45 MPH, the temperature gauge rose to the HOT zone. The contact stated that she pulled into an auto parts store and was advised to refill the coolant reservoir. The contact topped off the coolant reservoir and then drove the vehicle for less than 20 minutes before the vehicle went into LIMP Mode and lost motive power. The contact stated that the vehicle failed to respond while depressing the accelerator pedal. There were several warning lights illuminated. The vehicle was towed to the local dealer, where it was diagnosed and determined that either the engine or the short block needed to be replaced due to coolant intrusion into the cylinders. The vehicle had not been repaired. The contact researched online and related the failure to Technical Service Bulletin Number: 19-2139 - Coolant Intrusion into the Cylinder (Engine and Engine Cooling). The manufacturer had been informed of the failure. The failure mileage was approximately 140,000.

The contact owns a 2014 Ford Fusion. The contact stated that while driving approximately 55 MPH the message "electric power steering failure" was displayed, and the steering wheel became difficult to turn in either direction. After turning off and restarting the vehicle, the steering operated as normal but later the failure reoccurred. The vehicle was taken to the local dealer who diagnosed that the steering rack needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in NHTSA Campaign Number: 15V25000 (Steering). The contact stated that the vehicle had experienced the same failure listed in the recall. The failure mileage was 99,000.

I Had my car at Southgate Ford from 0ct 17- 20. During this time my car was to be serviced for the recalls. However upon receiving my car back. I was told the recall that is showing incomplete( door latches) was unable to be repaired due to the car only being registered in MI and PA. At this time it is showing my vin is still showing said recalls as incomplete.

See attached document from complainant

See attached document from complainant

The power steering went out, it caused me to swerve into other lanes on the highway with me and my children in the car. I took the car to the Ford dealer and they confirmed the power steering rack and pinion needed replaced, which would cost over $3000 to repair. The power steering was reset during diagnostic so I took it to another shop for pricing, they stated the reach and pinion was bad and they quoted me $4000 to repair. I parked the car and when I drove it again the power steering completed went out. I could not afford the repair, it caused me to lose my job, fall behind on car and rental payments for my house causing is to be in eviction now. I had it towed to a shop and the mechanic asked if there was a recall for this issue because he had had multiple people come in with the same issue, he suggested we all get rid of these cars because this has been a continuous issue and the company won't do anything about it. I'm left with a $20,000 dollar payment for this car and the company is no help. It put me and my kids lives in jeopardy and put us in a horrible position financially.

Coolant intrusion 1.5 liter eco boost.

The cable to the transmission has messed up came off. There’s a recall for the 2014 ford fusion for this problem but it’s not showing one for our vin number and it is the exact problem the recall says

The contact owns a 2014 Ford Fusion. The contact stated that while his daughter was driving approximately 65 MPH, the coolant warning light illuminated. The contact was informed that the vehicle lost motive power and decelerated to approximately 15 MPH. The contact stated that his daughter pulled off the roadway and turned the vehicle off. The contact drove out to his daughter and jumpstarted the vehicle. The contact used an ODB scanner and retrieved fault code: P1299 “Engine overheated”. The contact cleared the code, and the vehicle was driven back to his residence. The contact replaced the coolant temperature gauge. The contact stated that the vehicle drove normally for several days however, the failure reoccurred. The contact checked the coolant reservoir and noticed that the reservoir was nearly empty. The contact then drove the vehicle to a local dealer who diagnosed the vehicle and determined that coolant had intruded into the engine cylinders. The contact was advised that the engine needed to be replaced. The vehicle had not been repaired. The manufacturer had been informed of the failure. The contact researched online and related the failure to the manufacturer Technical Service Bulletin Number: 19-2139 - Coolant Intrusion into the Cylinder (Engine and Engine Cooling). The failure mileage was approximately 62,000.

Back-up Camera: The back-up camera works intermittently, or sometimes not at all; On several occasions, the camera went on briefly, showing children approaching the back of the car while backing out of a driveway. Then it goes blank as they walk behind the vehicle. Additionally, when backing into a parking space, the camera displays, then goes blank as soon as the proximity alert warning beep starts to sound. I’m not sure if the “trigger" is the proximity sensors or the steering sensor since the steering wheel is always turned and the warning beeps are always present.

My transmission has failed multiple times. Luckily my car is under warranty, because I have been able to have it replaced twice, but both times, these malfunctions have put my life and countless others in danger, because the failure is sudden and not preceded by any warnings. This problem has reproduced twice and been confirmed and fixed both times by Sun’s Auto in Spring Texas. The vehicle has been inspected recently by the manufacturer as my shifter bushings also disconnected as part of a separate recall, resulting in a similar situation as the transmission failure. There have been no warnings prior to any of these issues occurring, and at this point recalling individual parts is not sufficient. The transmission and shifter bushing issues alone cost more to repair than the car is worth at this point, and they are extremely dangerous, especially when combined with the other active safety recalls for this same car such as the brakes, door latches, and steering. Almost every aspect of this car is unsafe as manufactured .

Turned vehicle on one day & the parking break light came on, attempted to disengage with the parking break button but nothing released the breaks. Wouldn’t let me move the car when in drive. After trying to disengage with the button many times, decided to undo the battery because its electric & i was hoping to reset it & wait 20 mins. After doing so the release parking break warning, park break malfunction warning & parking break light was still on & it still didn’t move for another 20 minutes then suddenly after putting it in drive again it let me move. Now the release parking break warning, park break malfunction warning & the parking break light stays on even when actively driving & beeps the entire drive. No auto shops I’ve been to knows how to fix this! HELP PLEASE

Coolant leak into the cylinders of the 1.5 L GTDI EcoBoost engine and causes the vehicles to misfire, overheat and even catch fire. As a result of the failure which has been confirmed by an independent mechanic, the car is not operational only has 103K miles.

The contact owns a 2014 Ford Fusion. The contact stated while driving approximately 65 MPH, the vehicle lost motive power. The vehicle failed to function in fifth and sixth gear. There was an abnormal clicking and grinding sound while in fourth gear. There were no warning lights illuminated. The driver was able to pull over to the side of the road. The vehicle was towed to the residence. The vehicle was taken to several independent mechanics, and the contact was informed the vehicle could not be serviced at their location. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 146,000.

Rear view video system is failing either completely or halfway during the back up. Warning message says to contact dealership, who wants to run diagnostics in order to figure out cause. Despite video failure, the audio has continued to work properly. Did not want to pay costly fee to run diagnostics without shopping around for lower price.

The contact owns a 2014 Ford Fusion. The contact stated while driving at an undisclosed speed, he heard an abnormal sound coming from the rear wheels. After a visual inspection, the contact observed that the brake calipers seemed to be stuck in a partially closed position, causing excessive wear and tear to the rotors. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The contact repaired the vehicle himself. After investigating the failure, the contact related it to NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic); the VIN was included, and the front brake hoses were replaced. The manufacturer was not notified of the failure. The failure mileage was 70,000.

The contact owns a 2014 Ford Fusion. The contact stated that while the vehicle was parked and being inspected, the mechanic observed that the sway bar was not properly bolted. The vehicle was diagnosed by a dealer. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 130,129.

The back-up safety camera has become at best intermittently functioning, sometimes will not come on at all when the transmission is placed in reverse. When it does come on with reverse, the camera will often cut out in the middle of a backing maneuver while the vehicle is in motion. From the checking I've done online this appears to be a common issue with ford's back-up cameras, and I am surprised a safety recall is not already in effect, considering these cameras came on the vehicles as required safety equipment.

The rear passenger back door latch is out. Has to be replaced because door will not shut an my toddler almost feel out but I caught him.

The lug nuts on my 2014 Ford Fusion have swollen to the point where they cannot be removed with the tool Ford provided or a standard 4 socket iron wrench. This problem is so severe, AAA was unable to remove the lug nuts after I had a flat requiring a tow for repair of tire. Additionally, the lug nits cam become compromised and cause the rim to become fisplaced while driving.

The contact owns a 2014 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic) however, the part to do the recall repair was unavailable. The contact stated while driving at approximately 15 MPH and slowing down for a traffic signal, the brake pedal was depressed; however, the vehicle failed to slow down as needed and almost causing the contact to run the stop sign. The contact stated that failure was intermittent at first but became a more frequent failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 212,000. Parts distribution disconnect.

I had to have all 20 lugnuts replaced. I had 3 different shops tell me that they are all swollen and needed to be replaced. Lugnuts shouldn't all be defective this quickly. I think Ford used cheap parts

The contact owns a 2014 Ford Fusion. The contact stated that while making a right turn into the driveway, the power steering assist failed, and the steering wheel became very difficult to turn in either direction. The cause of the failure was not yet determined. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in NHTSA Campaign Number: 15V250000 (Steering). The contact stated that while depressing the brake pedal, there was an abnormal vibration coming from the brake pedal. The cause of the failure was not yet determined. The local dealer was not notified of the failure. The failure mileage was 70,000.

The contact owns a 2014 Ford Fusion. The contact stated while driving 15 MPH and making a left turn, the traction control and Uphill Assist warning lights illuminated. Additionally, the "Power Steering Assist" message was displayed, and the steering wheel became firm. The contact shutoff and restarted the vehicle and the vehicle started operating normally. The vehicle was taken to an independent mechanic, but the vehicle was not diagnosed or repaired. The dealer was contacted that stated that there was no recall for the failure on the VIN. The manufacturer was contacted and referred the contact to the local dealer for assistance. The failure mileage was 60,000.

When I went to unload groceries from my 2014 Ford Fusion SE, the Driver side Rear door did not latch closed. Despite not latching, the warning that the door was open did not come on. I read that there was a recall back in 2020 for a similar issue in states that were subjected to warmer temperatures. I have not yet gotten the issue inspected but will be taking the car to a mechanic. NHTSA is welcome to inspect my car if given enough notice.

The contact owned a 2014 Ford Fusion. The contact stated while driving 35-37 MPH, he saw an animal on the road and depressed the brake pedal, but the vehicle responded with delay. There was no warning light illuminated. The contact swerved to avoid crashing into the animal, and the vehicle crashed into a telephone pole, then rolled over two times. The air bags deployed. The contact was able to exit the vehicle. The contact was examined by emergency units and was advised he had not sustained major injuries. The contact sustained whiplash, a laceration and bruise on the right knee, and a swollen neck. The contact was transported to the residence. A police report was filed. The vehicle was towed to a tow yard, where it was totaled. The contact later received a recall notification of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic) that he related to the failure. The dealer was notified of the failure. The manufacturer was not notified of the failure. The failure mileage was approximately 163,000.

“Temporarily lost communication with the Climate System” error. Alert suddenly came on while driving, no prior issues or signs of error. Windows will not go down, air conditioner will not come on, cannot use climate touch screen or control volume from dash.

Large volume coolant leak

The contact owns a 2014 Ford Fusion. The contact stated that after starting the vehicle and shifting into reverse, the steering wheel became firm and difficult to maneuver. The steering assist fault warning light was illuminated, the Lane Keep Assist warning light was illuminated, and the Service Advancetrac warning light was illuminated. An undisclosed dealer was notified of the failure and the contact was advised to have the vehicle towed to the dealer. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 69,596. The contact paid out of pocket to replace the steering gear.