2012 Ford Fusion complaints

Dealership said they reset power steering, it had a recall on it and now my power steering is completely out and they refuse to fix it for free when it is a recalled part. Obviously it wasn’t fixed.

The contact owns a 2012 Ford Fusion. The contact stated that while driving at 30 MPH, the service power steering warning light illuminated as the steering wheel became difficult to maneuver. The vehicle was not taken to the dealer or independent mechanic for diagnostic test or repairs. The contact stated that the dealer was contacted. The contact was informed that the vehicle was not included in a power steering recall. The contact researched the failure online and found NHTSA Campaign Number: 15V340000 (Steering) and related the failure to the recall. The manufacturer was not notified of the failure. The approximate failure mileage was 125,000.

The contact owns a 2012 Ford Fusion. The contact stated that while driving at approximately 10-15 MPH, the power steering assist failed with the "Service Advance Trac" and "Service Power Steering" messages displayed on the instrument panel. The vehicle was taken to the dealer where it was diagnosed with steering gear box failure. The dealer informed the contact that the steering gear box needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 140,000.

The contact owns a 2012 Ford Fusion. The contact stated while driving at an undisclosed speed, the power steering assist failed, causing the steering wheel to be difficult to maneuver. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 140,000.

The contact owns a 2012 Ford Fusion. The contact stated while attempting to exit the vehicle through the front driver’s side door, the door handle fractured. The contact was able to use the remaining part of the door handle to exit the vehicle. The vehicle was not taken to the dealer to be diagnosed or repaired. The manufacturer was not contacted. The failure mileage was 31,000. The VIN was invalid.

It has been 16 months since I received initial communication about the recall for my driver's side air bag. I've received no other communication regarding this recall and the NHTSA website shows that a remedy is still not available. 16 months is not a timely manner to repair an issue that in the event of airbag deployment can cause serious injury or death. Being 16 months into this process with no remedy, no communication, and no repair in sight, I want to know when Ford is going to give up and give me a new car.

The contact owns a 2012 Ford Fusion. The contact stated while reversing out of the driveway, the vehicle lost power steering functionality. There was no warning light illuminated. The contact parked the vehicle. The contact became aware of NHTSA Campaign Number: 15V340000 (Steering). The vehicle was towed to the dealer who informed the contact that she needed to pay a diagnostic fee to determine the cause of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA. The failure mileage was approximately 140,000.

Power steering assist fault

Highway speeds power steering failure, no symptoms prior. Barely got off the road to safety.

Approximately three months ago the ABS system engaged due to applying my brake to avoid pedestrian crossing in front of me. After continuing to drive the brake pedal was very soft and traveled nearly to the floor of the car. The next day the system returned to normal. Several days ago, on 6/25/2022 this occurred once more when a hard brake was needed to avoid a suddenly stopped vehicle and the same problem became present with a soft petal and having to pump the pedal, my wife was the operator this time. The vehicle has not yet been inspected by any entity. I have inquired about this problem from my mechanic and also have researched the problem and see there is a recall > 19S54 also an update to the recall > EA18-002 that states my 2012 Fusion is included in the recall and will now contact the local Ford Dealership to have this concern corrected. In my research I see that is due to the ABS module sticking due to corrosion from the wrong brake fluid. I have had several close calls while operating my car, the recall states Ford advises it is safe to drive. This I strongly disagree with, particularly since my wife uses this vehicle and is not as skillful as I when it comes to mechanical issues such as this. There were no warning lights, or messages, the issue has now cleared up again and brakes are operating normally as before this incident. This vehicle is readily available for inspection on request.

I called Ford at Sam Galloway in Fort Myers and I told them that I have at least 5 recalls but only one is important which is the passenger air bag. I was told that they have availability for September. I asked them, why wasn’t I informed of the recall? They couldn’t answer. I need to know where should I take my car. Thank you

While driving down the road power steering assist came on dash then lost all power to steering, and of course my car says no recalls, I’m stuck with a 17,000 dollar car I can’t fix but still have to finish paying for, I new better then to buy a [XXX] ford too. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The contact owns a 2012 Ford Fusion. The contact stated while driving on the highway at an undisclosed speed and depressing the brake pedal, the pedal went to the floorboard. There were no warning lights illuminated. The contact was able to pull off the highway and the vehicle rolled to a stop. The vehicle was not taken to a dealer or independent mechanic to be diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 120,000.

The contact owns a 2012 Ford Fusion. The contact stated while driving the vehicle out of the parking lot at approximately 3 MPH, the power steering functionality was inoperable. The power steering assists failure warning light illuminated. The vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 19V632000 (Steering). The manufacturer was not notified of the failure. The approximate failure mileage was 60,000

Power steering went out while driving, almost caused me to crash.

The contact owns a 2012 Ford Fusion. The contact stated while driving approximately 30 MPH, the electric power steering assist failure warning light illuminated and the vehicle lost power steering functionality. The vehicle was safely driven to the local dealer to be diagnosed. The contact stated that the power steering assist and the rack and pinion needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 108,000.

I have a 2012 Ford fusion and once again the power steering went out in my car and now I’m stranded trying to figure out a way to get home there was already a recall once on power steering‘s for this car well for this year of a car don’t know if it was mine or not because it says 04 recalled unfixed problems but obviously this car has power steering problems and now I’m paying $17,000 for a car that I can’t even drive because I can’t afford to have my car fixed thanks Ford should’ve known better than to buy one

AC does not work, the climate control module is the problem. when you switch the AC on it only blows heat. The fix would be a new climate control module.

My car rolls away in park 2012 ford fusion

The contact owns a 2012 Ford Fusion. The contact stated while driving 20 MPH and depressing the brake pedal, the vehicle failed to stop within a reasonable time. The contact stated no warning light was illuminated. The contact stated he was able to stop the vehicle after pumping the brake pedal. The contact took the vehicle to the local dealer however, the mechanic was unable to duplicate the failure. The contact continued to experience the failure. The contact took the vehicle back to the local dealer, where it was diagnosed and the brake lines were flushed several times. The vehicle continued to experience the failure. The contact took the vehicle back for the third time and was informed that the rear and front brake calipers, the ABS hydraulic control unit (HCU), and the brake master cylinder needed to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 95,000.

The contact owns a 2012 Ford Fusion. The contact stated that while operating the vehicle, there was a grinding sound coming from the steering column. Additionally, the steering wheel was very unstable and the vehicle did not immediately respond while turning the steering wheel in either direction. The vehicle was taken to an independent mechanic who was unable to determine the cause of the failure. The contact indicated that the vehicle was previously repaired under the NHTSA Campaign Number: 15V340000 (Steering) however, the failure reoccurred. The manufacturer and local dealer were notified of the failure but no assistance was offered. The failure mileage was 80,000.

While I was driving my 2012 Ford Fusion with my two children I lost power steering. Barely made it to side of busy road. The Service Advancetrac AND Power Steering Assist Message displayed AFTER losing power steering. After restarting the car power steering is back and no warning messages. Called local Ford dealer who did not see any recalls for issue or seem to know about this issue. Stated it "shouldn't" be an issue as the car is running like normal and scheduled appointment for a month away.

Takata recall. The contact owns a 2012 Ford Fusion. The contact received notification of NHTSA Campaign Number: 21V158000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2012 Ford Fusion. The contact stated while driving at an undisclosed speed, the vehicle jerked and was slow to accelerate. The air bag warning light was illuminated. The vehicle was taken to the local dealer where it was diagnosed that the throttle body needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to NHTSA. The approximate failure mileage was 175,000.

My steering wheel want turn at all it’s locked

The contact owns a 2012 Ford Fusion. The contact stated while driving approximately 25 MPH, the power steering sensor warning light illuminated. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 70,000.

Power Steering intermittently stops working.

The contact owns a 2012 Ford Fusion. The contact stated while driving approximately 35 MPH, the vehicle lost power steering functionality. The power steering assist fault warning light was illuminated. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure but offered no assistance. The approximate failure mileage was 153,000.

The electrical power steering control system in my car failed, without which steering at low speeds and especially parking is more difficult. The problem was confirmed and assessed by a dealer during other repairs, but no other parties. When the incident occurred, it failed with no warning at car startup. The next car startup the power steering returned for about 2-3 weeks before going out again for good, again with no obvious warning after a startup. Seems to be the same or a similar issue described in campaign 15V340000 that applies to 2012 Ford Fusions, but evidently my VIN number appears to have been excluded from that recall according to Ford.

The contact owns a 2012 Ford Fusion. The contact stated while driving 25 MPH, the power steering assist failed as the “power steering assist fault, service now” warning message appeared on the instrument panel. The contact stated that excessive force was needed to steer the vehicle due to the failure. The contact discovered that there was a Customer Satisfaction Program for the power steering associated with the vehicle. The dealer and the manufacturer were notified of the issue and informed the contact that the vehicle no longer qualified under the Customer Satisfaction Program. The vehicle was not repaired. The failure mileage was approximately 75,000.

The contact owns a 2012 Ford Fusion. The contact stated that while the vehicle was parked, the vehicle lost power steering functionality. The power steering assist fault warning light was illuminated. The vehicle was taken to the local dealer and diagnosed the vehicle with steering rack failure. The vehicle was not repaired. The manufacturer was notified of the failure. The contact related the failure to NHTSA Campaign Number: 15V340000 (Steering). The approximate failure mileage was 65,000.

The contact owns a 2012 Ford Fusion. The contact stated while driving approximately 40 MPH, the power steering became inoperable and the vehicle stalled. The vehicle failed to restart. The vehicle was towed to an independent mechanic and diagnosed with transmission failure. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 60,000. The VIN was not available.

Power Steering Assist Fault and Service Advancetrack error codes appear on the digital dash display. Power steering does not work. The Ford dealership the vehicle was bought at and is serviced at allowed me to drive out of the lot in the car's current state because the vehicle is 7 months out of the extended warranty 10-year recall.

While driving my car I received a warning "service power steering now" and subsequently "service advancetrac". Then my power steering did not function, and the car was extremely hard to steer. In doing research, some Fusions were covered under warranty/recall 15v34000, and/or 15s18. I have been informed that my vehicle is not covered. My car has approximately 72,000 miles and has been well maintained, garaged, with no serious accidents. I suspect that Ford does not want to extend replacement costs on a ten year old car and the problem is more extensive than they have acknowledged.

The contact owns a 2012 Ford Fusion. The contact stated while leaving a parking spot, the steering wheel seized and the electronic steering assist warning light was illuminated. The contact stated he turned off and restarted the vehicle to reset the electrical system and continue driving to his destination. The contact took the vehicle to the local dealer, where it was diagnosed with needing the steering gearbox to be replaced. The vehicle was not repaired. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 15V340000 (Steering) however, the VIN was not included. The manufacturer had been informed of the failure. The failure mileage was approximately 99,800.

The contact owns a 2012 Ford Fusion. The contact stated while driving approximately 45 MPH, the vehicle stalled. There were no warning lights illuminated. The vehicle was towed to the residence and then to the local mechanic and was diagnosed with power steering failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 171,676.

The contact owns a 2012 Ford Fusion. The contact stated that while driving at various speeds, the steering wheel would intermittently lock without warning. Initially, the power steering would resume normal operation after restarting the vehicle; however, on the latest occurrence, the power steering failed to correct itself upon restart. After months of not being driven, the contact had the vehicle towed to a dealer where they informed her that her vehicle was not under warranty or recall and she was given an estimate for the repair. The manufacturer was also notified of the failure and referred the contact to the NHTSA. The vehicle had yet to be repaired. The failure mileage was unknown.

Steering wheel will not turn. The dash says "Power steering assist fault. Was not driving when this happened. When I stopped driving last night it was driving perfect, no problems. Went to drive the the next morning and that's when I noticed this problem.

The contact owns a 2012 Ford Fusion. The contact stated while starting the vehicle, she attempted to open the front driver’s side door but it failed to open. The contact stated no warning light was illuminated. The contact stated that she opened the front driver’s side window and was able to reach the door handle to open the door. The contact took the vehicle to the local dealer, where it was diagnosed with needing the front driver’s side door latch to be replaced. The vehicle was repaired but continued to experience the failure with the driver’s side and both the front and rear passenger’s side door latches. The contact took the vehicle back to local dealer and had all 3 door latches replaced. The vehicle was repaired but experienced the failure for a third time on the front driver side door latch. The contact took the vehicle back to local dealer and had the front driver’s side door latch repaired. The vehicle was repaired but the failure persisted. The manufacturer had been informed of the failure. The failure mileage was approximately 35,000.

Air Bag Recall has been unfixed since car was made in 2012. The recall was First started on March of 2021. I need to know my rights if the remedy is never made. The 1st issue is I don't feel safe driving vehicle and I can't get out into another vehicle which I understand is my issue but if Ford doesn't care about my safety why should I care what is technically owed to me. I didn't make a vehicle that could kill someone because of sup standard parts. 2 issue is I don't to get into an accident but if I do and survive my car Insurance would total set car because they can't as a company put a part on to a vehicle knowing that the Air Bag is still faulty. I do have gap if it came down to it but what if I didn't have that now Im Financially responsible for things I didn't cause or allow to Happen. All I'm asking is what are may rights. Does Ford as a Company have to help me if so how? Rental Car or Help try get me into another vehicle regardless of my Financial Situation.

My 2012 Ford Fusion has a recall for power steering assist failure. I took my car to the ford dealership in Florence KY where I purchased the car 7 months earlier. They told me they would not complete the recall because my car was over 150k miles. My car had 170k miles on it when I purchased it in March of 2021 from that dealer.

The contact owns a 2012 Ford Fusion. The contact stated that she received a recall notification for NHTSA Campaign Number: 15V340000 (Steering) and took the vehicle to the dealer for the recall repair; however, the dealer informed the contact that there were no Diagnostic Trouble Codes (DTC) for the Power Steering Control Module (PSCM). The contact stated while her son was driving at 40-50 MPH after the repair, the steering wheel lost power steering functionality. There was no warning light illuminated. The contact's son continued to drive the vehicle using extra effort to steer the vehicle. The vehicle was taken to the dealer who informed the contact that the mechanic could not replicate the failure. The contact stated that the failure reoccurred several times while driving and the power steering warning light illuminated. The vehicle was taken to a second dealer, Chenoweth Ford Inc (1564 E Pike St, Clarksburg, WV 26301) where it was diagnosed that the electric steering gear assembly needed to be replaced; however she would be responsible for the cost of the repair as the vehicle was out of warranty. The vehicle was repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA. The failure mileage was approximately 100,000.

While driving, the power steering went out completely which made it incredibly difficult to steer the car. The car's warning lights immediately flashed that the AdvanceTrac and Power Steering were both out. There were no advanced warnings and happened in the middle of a drive. I have taken the car to a dealership that said there was a recall for this exact situation in other 2012 Ford Fusions with the electric power assist system going out which causes the power steering to fail, but my VIN did not meet the recall requirements. I believe the recall should be expanded as this is incredibly dangerous to current owners. I am lucky this happened while I was driving the car as my wife would not have been able to safely move the car to the side of the road. She could have been in a much worse situation where the car was a risk to other drivers on the road.

The contact owns a 2012 Ford Fusion. The contact stated that while driving at an undisclosed speed, the steering wheel was difficult to maneuver. The service power steering warning message was displayed. The dealer was made aware of the failure but informed the contact that there was no recall associated with the VIN. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was 233,874.

Dashboard pop-up stating “Service Power Steering Now” and power steering instantly stopped working almost causing a wreck going within a curve.

The contact owns a 2012 Ford Fusion. The contact stated while driving at 59 MPH, the steering wheel locked inadvertently. The message "Service Power Steering Now" was illuminated. The contact was able to veer to the side of the road. The vehicle was towed to the dealer where it was diagnosed that the electric power steering assist had failed. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that they could not assist as the VIN was not included in NHTSA Campaign Number: 15V340000 (Steering). The failure mileage was approximately 159,000.

The contact owns a 2012 Ford Fusion. The contact stated while driving 50 MPH, an unknown warning message for the power steering appeared on the instrument panel along with an audible chime. The contact stated that excessive force was needed to steer the vehicle as she moved to the shoulder of the highway. Due to the failure, the contact had the vehicle towed to her home. The manufacturer was notified of the failure and she was given an estimate for the diagnostic fee and repair. The contact was then referred to the NHTSA for further assistance. Upon investigation, the contact discovered NHTSA Campaign Number: 15V340000 (STEERING) which she linked to the failure. The vehicle was not repaired. The failure mileage was approximately 230,000. Consumer stated steering has a recall and was told to call and report the vehicle not being safe.

Driver’s side door latch/handle suddenly became unoperational from the interior of the vehicle. This is a safety hazard — after struggling with the handle to get out of the vehicle, my wife resorted to climbing over the console and exiting out the passenger door. Called local Ford dealer and they say because the 2012 door latch is not under recall, they won’t replace the handle without us paying parts and labor. They expressed no interest in exploring this safety issue short of us bankrolling the cost, despite the fact that there are recalls for this same safety defect on Fusions in other production years. The 2012 door latch should be recalled. The handle is toast - we cannot exit our Fusion out the driver’s door. We are ordering a part to replace the latch, performing the labor ourselves.

I was driving and the advanc Trac and the power steering check light came on and within 3 to 5 minute of both codes flashing, the power steering service now came on and the steering wheel locked up as I was traveling 55mph with traffic all around nearly causing me to crash with other cars within a sharp curve because of steering wheel locking up as I was in fast lane and had oncoming traffic coming from opposite direction. I barely was able to pull into slower lane and had to use all my body weight and strength to maneuver off the highway to safety. A very terrifying event with only a few moments of prior notice of any problem with the car. This needs to be a safety recall, because of such a short notice, the indicator changed to service power steering now faster than I could change lanes to get off of congested highway. This could have been a deadly ending or caused serious injury for me and other nearby motorists had I not immediately turned on my hazard signal and started tapping brakes to warn others of my perilous situation. I have not had any prior indicator lights alerting me of any problem with the steering. And the warning of any problem was less than 5 minutes before it told me to service power steering now and the lock down of the steering wheel. Too short of a notice especially speeding down a congested highway amongst other drivers who were unaware of the dire situation of trying to control my car and not causing a major collision of multiple cars. I have not rep

Failed Power Steering Assist (Electronic Steering) and AdvanceTrac Assist. Steering wheel hard to turn, and will cause an accident. Current bulletin recall for power assist feature, only applies to Ford Fusions Manufactured after August 2012. I am requesting that the current open recall for Ford Fusions be limited to ALL Ford Fusions from 2010-2012. Mine was manufactured in July, 2012 and is NOT covered under current recall. Many Fusion owners are requesting for this recall to be open for ALL Ford Fusions from years 2010-2012. It has appeared that most 2010-2012 fords fusion owners are experiencing lack of power steering in the electronic steering. Consumer's vehicle is not under the current Ford recalls, as other owners. The rack and electric gears have failed in my Fusion, as well as other fusions as stated. Consumer's Fusion is actually in-between recalls. The recent recalls are for Ford 19S26, and Ford 15S18.