2016 Ford F-250 SD complaints

VEHICLE WAS PURCHASED FROM PRIORTY FORD IN NORFOLK, VA ON SUNDAY MARCH 21ST 2021. INCIDENT #1 MARCH 22ND 2021: FRONT DRIVER'S TIRE COMPLETELY BLEW ON HIGHWAY EN ROUTE TO TENNESSE AN HOUR AND A HALF OUT OF GATLINBURG, TN. SPEEDOMETER WAS ALSO NOT FUNCTIONING PROPERLY PRIOR TO SAYING WE WERE DRIVING A FASTER THAN ACTUAL MPH (CONFIRMED WHILE USING GPS). SPARE TIRE WAS PUT IN PLACE OF BLOWN OUT TIRE, CHANGED SPARK PLUG WIRE (WHICH DIDN'T REPAIR TICKING NOISE PER MECHANIC) MECHANIC ALSO SAID WE WOULD BE GOOD TO GO WITH SPARE TIRE. INCIDENT #2 MARCH 24TH 2021: WHILE EN ROUTE TO NEXT DESTINATION (NEW ORLEANS, LA) TRED CAME OFF REAR DRIVERS SIDE TIRE CAUSING TRUCK TO GO OUT OF CONTROL ON I-59 NEAR BIRMINGHAM, AL. VEHICLE SPUN INTO GRASS MEDIAN ONTO OPPOSITE SIDE OF INTERSTATE AND WAS NO LONGER DRIVABLE. A POLICE REPORT WAS MADE AND TRUCK WAS TOWED. ADDITIONAL INFORMATION AND PROOF VIA PICTURES AND REPORTS AVAILABLE UPON REQUEST.**

AT 34,000 MILES TRUCK STARTED TO SHAKE AND SHUDDER WHILE DRIVING AT 70MPH ON INTERSTATE. VEHICLE BECAME HARD TO CONTROL DUE TO VEHICLE VIOLENTLY SHAKING. AT 58,000 MILES TRUCK STARTED MAKING A CLUNKING NOISE IN FRONT SUSPENSION. VEHICLE STEERED ROUGH. FOR THE SECOND TIME TRUCK WAS TAKEN TO FORD DEALER AND REPAIRED. THE SECOND TIME AT MY EXPENSE. VEHICLE IS UNSAFE TO DRIVE WHEN PARTS IN SUSPENSION WEAR OUT OVER THIS SHORT AMOUNT OF TIME. EACH TIME VEHICLE WAS IN MOTION ON THE HIGHWAY.

AT HIGH SPEEDS 65 PLUS WHEN A BUMP IS HIT THE FRONT OF TRUCK AND STEERING STARTS SHAKING VIOLENTLY AND DOESN'T STOP UNTIL YOU SLOW DOWN TO BELOW 20 TO GET IT TO STOP. THIS VIOLENT SHAKING IN THE STEERING/FRONT END CAN CAUSE LOSE OF CONTROL AND HAVING TO SLOW TO SUCH A SLOW SPEED ON INTERSTATE CAN CAUSE ACCIDENT AND INJURY TO SELF AND OTHERS. THIS HAS HAPPENED SEVERAL TIMES WITH LAST EVENT YESTERDAY AT WHICH TIME A SEMI TRUCK ALMOST REAR ENDED ME.

WHILE OPERATING IN BELOW FREEZING TEMPERATURES ON THE HIGHWAY, THE DIESEL EXHAUST FLUID (DEF) TANK HEATER FAILED, ALLOWING THE DEF TO FREEZE INSIDE THE TANK. WITH THE DEF FROZEN, IT WAS NOT ABLE TO BE INJECTED INTO THE EXHAUST RESULTING IN HIGHER LEVELS OF NITROGEN OXIDES (NOX) TO BE RELEASED INTO THE ATMOSPHERE THROUGH THE VEHICLES EXHAUST.

FAILURE OF REDUCTANT HEATER AND SENDER UNIT FOR DIESEL EMISSION FLUID (DEF) WITH ONLY 37,000 MILES. ERROR CODES WILL EVENTUALLY FORCE VEHICLE TO IDLE AND NOT DRIVE AT HIGHWAY SPEEDS. FORD VEHICLES PRIOR TO 2016 WERE FIXED AT NO CHARGE FOR THIS DEFECT UNDER FORD'S CUSTOMER SATISFACTION RECALL

WHEN I BOUGHT THIS VEHICLE USED OFF OF PINNACLE FORD IN NICHOLASVILLE KY, (NOW HAS 36,700 MILES) I HAD NO IDEA THAT I WAS BUYING A TRUCK WITH THE SO-CALLED "DEATH WOBBLE." LONG STORY SHORT I HAVENT BEEN UNABLE TO DRIVE THIS TRUCK ON ANY LONG TRIPS AND BADLY DREAD IT WHEN I HAVE TO BE ON ANY ROAD WITH A SPEED LIMIT OVER 55 BECAUSE ONCE I BEGIN TO HIT 60 M.P.H. THE FRONT END WILL START TO SHAKE SO BAD THAT THE WORDS SCARY, UNSAFE, AND EMBARRASSING ARE UNDERSTATEMENTS. I HAVE BEEN WAITING PATIENTLY FOR THE FORD "DEATH WOBBLE" RECALL FOR QUITE SOME TIME, BUT I JUST CANT WAIT ANYMORE; I WAS RECENTLY ADVISED TO FILE THIS REPORT. I AM INCLUDING A PICTURE OF ONE OF MY FRONT TIRES THAT WAS NOT SO LONG AGO NEW, AND THEY ARE BOTH CHOPPED SO BAD THAT IF YOU RUN YOUR HAND ACROSS THE TREAD YOUR HAND WILL STOP DUE TO THE EXTREME UNLEVELNESS OF THE TREAD WITH NO EXAGGERATION WHATSOEVER. PLEASE, PLEASE, FORCE FORD TO RECALL THIS TRUCK. I OWN A CONCRETE CONSTRUCTION BUSINESS, AND IF I WERE TO MESS UP SOMEONES NEW DRIVEWAY WITH NO SAFETY ISSUES INVOLVED, I WOULD BE EXPECTED TO FIX IT ASAP, AND FOR THE INTEGRITY OF MYSELF AND MY BUSINESS I SHOULD BE EXPECTED TO FIX IT. IT TRULY AMAZES ME HOW BIG CORPOROTIONS CAN SCREW UP THEIR PRODUCT THAT WE PAY WAY TOO MANY THOUSANDS OF DOLLARS FOR THESE DAYS AND EVEN WITH EXTREME SAFETY ISSUES BEYOND JUST A FAULTY PRODUCT SOLD, THEY CAN LITERALLY CAN GET BY WITH CAUSING WRECKS, DEATHS, AND SELLING FAULTY UNSAFE PRODUCTS; THEY CLEARLY GET BY WITH WHAT THE AVER

DEATH WOBBLE. SECOND COMPLAINT. TRUCK WORKED ON 2 MONTHS A AGO ($600). WOBBLE RETURNED WITH A VENGEANCE. MAYBE 2,000 ADDITIONAL MILES ON TRUCK. 82,000 MILES CURRENTLY. ON FREEWAY, SPEED 55-65 MPH. HIT A CRACK IN THE ROAD ( NOT A POTHOLE OR ANYTHING SIGNIFICANT ). STEERING WHEEL SHOOK BACK AND FORTH 3-4 INCHES. NOISY, HOOD SHAKING STRONGLY. AGGRESSIVE BRAKING TO BELOW AROUND 40 MPH TO STOP THE DEATH WOBBLE. HAPPENED 3 TIMES WITHIN 3 MILES. DROVE HOME AT 35 MPH. I WASN'T TOO POPULAR WITH THE REST OF THE FREEWAY TRAFFIC. I BELIEVE I25 SURFACE IN THAT AREA IS CONCRETE WITH THE OCCASIONAL CRACK IN THE SURFACE. SCARY AS CAN BE.

DEATH WOBBLE OCCURS SO VIOLENTLY WHEN YOU HIT A BUMP IN THE ROAD THAT IT IS HARD TO MAINTAIN CONTROL. YOU HAVE TO COME TO A COMPLETE STOP FOR IT TO QUIT. ITEMS HAVE BEEN REPLACED FROM THE FORD SERVICE BULLETION

TL* THE CONTACT OWNS A 2016 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE CHECK ENGINE WARNING LIGHT ILLUMINATED AND THE VEHICLE DECELERATED INDEPENDENTLY. THE CONTACT DROVE TO HIS DESTINATION. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER RUSH FORD CENTER (1720 HERNDON RD, CERES, CA 95307: (209) 541-3673), WHERE IT WAS DIAGNOSED WITH NEEDING THE DIESEL EXHAUST FLUID (DEF) TANK HEATER TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 49,000.

THE REDUCTANT HEATER AND SENDER ASSEMBLY FAILED CAUSING THE MALFUNCTION INDICATOR TO LIGHT. THIS IS THE SAME PROBLEM ADDRESSED FOR THE 2011-2015 MODEL YEAR PER CUSTOMER SATISFACTION PROGRAM 18M01. THE FAULT WAS CONFIRMED BY RIVERTOWN FORD IN COLUMBUS GA VIA DIAGNOSTIC TOOL. CLEARLY THE ISSUE PER CUSTOMER SATISFACTION PROGRAM 18M01 REMAINS AND IS AFFECTING 2016 MODEL YEAR.

ON MULTIPLE OCCASIONS OVER THE PAST FEW MONTHS THE FRONT END OF MY TRUCK HAS BEGUN TO SHAKE VIOLENTLY. THE STEERING WHEEL SHAKES BADLY AND THE ONLY WAY TO REGAIN CONTROL IS TO BRAKE QUICKLY. IN EACH INSTANCE THE VEHICLE WAS TRAVELING BETWEEN 65 AND 75 MPH AND THE SHAKING SEEMS TO BE INSTIGATED BY HITTING A AN UNEVEN SECTION OF THE ROAD'I SPECIFICALLY RECALL A BRIDGE EXPANSION JOINT AND A POTHOLE THAT SET OFF THE SHAKING. ALL INCIDENTS OCCURRED ON FREEWAY STRAIGHTAWAYS. I TOW A TRAVEL TRAILER AND THIS SHAKING HAS OCCURRED BOTH WHEN TOWING AND NOT TOWING. IN READING A BLOG FREQUENTED BY TRAVEL TRAILER OWNERS, THIS PROBLEM WITH THE F250 HAS BECOME KNOWN AS THE 'DEATH WOBBLE' AND SEEMS TO BE EXPERIENCED BY MANY. I HAVE BEEN FORTUNATE ENOUGH TO HAVE NOT BEEN IN AN ACCIDENT BECAUSE OF THIS PROBLEM, HOWEVER, SINCE THE SOLUTION TO WOBBLE IS RAPID BRAKING GIVEN THE FACT THAT THIS OCCURS ON FREEWAYS AT RELATIVELY HIGH RATES OF SPEED, I IMAGINE IT WILL ONLY BE A MATTER OF TIME UNTIL AN ACCIDENT OCCURS. I HAVE ASKED THE FORD DEALERSHIP ABOUT THIS PROBLEM, HOWEVER THEY CLAIM IGNORANCE. A YOU TUBE VIDEO ENTITLED: FORD F-250: DEATH WOBBLE STRIKES 3 TIMES PROVIDES VIDEO EVIDENCE OF THIS SHAKING.

FRONT END VIOLENT SHAKING AT HIGHWAY SPEED WHEN CROSSING PAVEMENT CHANGE LIKE BRIDGE OR POTHOLE. UNABLE TO CONTROL VEHICLE UNTIL SPEED REDUCED UNDER HARD BRAKING. FORD DEALER AWARE OF ISSUE AND CALLS IT DEATH WOBBLE. CONTACTED FORD CUSTOMER SERVICE AND THEY STATED THEY HAD A PROGRAM FOR THIS ISSUE AND MADE A PARTIAL PAYMENT TO TOTAL COST OFF REPLACING ALL FRONT END SUSPENSION PARTS. THEY KNOW OF PROBLEM AND HAVE DESIGNED ALIGNMENT SPECS TO CAUSE DANGEROUS PRE MATURE PART FAILURE.

DEATH WOBBLE FRONT END AT HIGHWAY SPEEDS.

UPON TURNING ONTO A HIGHWAY AND REACHING APPROXIMATELY 45/50 MILES PER HOUR, THE FRONT END OF THE VEHICLE BEGAN VIOLENTLY SHAKING AND REGAINING CONTROL WAS NOT POSSIBLE UNTIL I SLOWED THE VEHICLE. IT SEEMED AS THOUGH THE VEHICLE FRONT END WAS WOBBLING LEFT AND RIGHT AS WELL AS JUMPING UP AND DOWN. UPON INSPECTING THE STEERING AND SUSPENSION, I FOUND NO APPARENT DAMAGE.

I WAS TRAVELING AT A SPEED OF 65 MPH DOWN INTERSTATE 5 SOUTH IN CASTAIC, CA. THE TRUCK FRONT END SUDDENLY BEGAN TO SHAKE VIOLENTLY. IT WAS ONLY WHEN I SLOWED DOWN AND PULLED OVER WHEN THE SHAKING STOPPED AND THE TRUCK DROVE NORMALLY. I LATER CAME TO REALIZE I HAD EXPERIENCED WHAT MANY CALL THE 'DEATH WOBBLE'. I IMMEDIATELY TOOK THE TRUCK TO MY LOCAL FORD DEALER FOR REPAIRS

I AM GETTING A DEATH WOBBLE. I BOUGHT IT IN TO THE DEALERSHIP AROUND 50 THOUSAND MILES ON THE TRUCK AND ASKED THEM TO CHECK IN TO THIS. THEY TOLD ME I NEED TO CHANGE THE TIRES. WHICH I DID AND I ROTATE THEM EVERY 5,000 TO 10,000 MILES. I WAS DRIVING DOWN THE HIGHWAY TO NIGHT AT 70 MPH WHICH IS THE SPEED LIMIT. I WAS IN A TRANSITION FROM THE FREEWAY TO BRIDE AND THAT LITTLE BUMP PUT ME INTO A DEATH WOBBLE. I HAD NO CONTROL OF THE TRUCK WHICH THE STEERING WHEEL SHAKES VIOLENTLY AND THE WHOLE TRUCK SHAKES. THE ONLY WAY TO GET IT TO STOP IS BRING TO A DEAD STOP. WHICH I HAD TO DO ON THE FREEWAY ALMOST GETTING REAR ENDED BY A SEMI TRUCK. THIS WAS THE FINAL STRAW. IT HAPPEN TO ME 2 TIMES MORE ON THE WAY HOME. LUCKILY THERE WAS NO ONE BEHIND ME. I KNOW I AM NOT THE ONLY ONE EXPERIENCING IT. FORD HAS BEEN GIVING ME THE RUN AROUND. I AM AFRAID EVERY TIME THAT I HIT A BUMP ITS GOING TO HAPPEN. I PAID A LOT OF MONEY FOR THIS VEHICLE AND IT IS UNSAFE FOR ROAD USE. I DON'T KNOW WHAT TO DO IF I SELL IT I WILL LOSE MONEY. THIS NEEDS TO GET ADDRESSED VERY SOON BEFORE SOME ONE IS KILLED OR I AM KILLED BEHIND THE WHEEL.

BACKUP CAMERA CUTS IN AND OUT GOES TO BLUE OR BLACK SCREEN INTERMITTENTLY OR DOES NOT COME ON AT ALL. FROM PARK TO REVERSE. THIS HAS BEEN HAPPENING ON AND OFF OVER THE LAST 5 MONTHS. APPEARS TO BE GETTING MORE FREQUENT AS TIME GOES ON.

I HAVE REAL BAD DEATH WOBBLE WHEN DRIVING I HIT BUMPS IN THE HIGHWAY MY TRUCK HAS 212,000 MILES ON IT AND STARTED IT ABOUT AT 160000MILES I REPLACE THE FRONT STABILIZER AT NO HELP,NEW TIRES NO HELP

WHILE DRIVING AT HIGHWAY SPEED THE STEERING WHEEL GOES INTO A VIOLENT SHAKE AFTER PASSING A HIGHWAY BRIDGE EXPANSION JOINT.

UPON HITTING A BUMP IN THE ROAD AT HIGHWAY SPEEDS THE TRUCK STARTED SHAKING IN THE FRONT END. IN ANOTHER INSTANCE I WAS ACCELERATING TO HIGHWAY SPEEDS AND THE TRUCK STARTED VIOLENTLY SHAKING AT ABOUT 65MPH, STEERING WAS DIFFICULT I HAD TO SLOW DOWN AND STOP ON THE SHOULDER FOR IT TO STOP. I WAS ABLE TO START DRIVING AGAIN AFTER SLOWLY ACCELERATING ALONG THE SHOULDER THEN MERGING BACK INTO TRAFFIC. I NOTICED THAT IT APPEARS WHENEVER I EVEN HIT A MINOR ROAD DEFECT I FEEL A SLIGHT VIBRATION.

TRUCK HAS 80,000 MILES ON IT, 99.9% OF WHICH ARE PAVED ROAD DRIVING AT MODERATE SPEEDS. TRUCK SUDDENLY DEVELOPED THE ' DEATH WOBBLE ' AFTER HITTING A BUMP ON THE ROAD ABOVE 45 MPH OR SO. FIRST NOTICED THE CONDITION 100 MILES AGO. GETTING HESITANT/ A LITTLE SCARED TO DRIVE THE TRUCK AT HIGHWAY SPEEDS. FEELING THE WOBBLE IN THE STEERING WHEEL AFTER A ROAD BUMP HAS TO BE SEEN TO REALLY BELIEVE WHAT IS HAPPENING.

EXPERIENCING THE FORD F250 "DEATH WOBBLE". THE TRUCK VIOLENTLY SHAKES AFTER HITTING A BUMP OR GROOVE IN THE ROAD AT SPEEDS OVER 60 MILES PER HOUR. TO STOP THE SHAKING YOU HAVE TO ALMOST COME TO A COMPLETE STOP IN THE ROAD. IT SEEMS TO HAPPEN MORE OFTEN ON THE HIGHWAY TRAVELING AT HIGH SPEEDS OVER BRIDGES OR WHEN IT IS OFF BALANCE.

ITS SAYS SOMETHING ABOUT RECAPTCHA WHEN I TRY TO RUN A RECALL REPORT

TL* THE CONTACT OWNS A 2016 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING AT 45 MPH, THE CONTACT EXPERIENCED THE DEATH WOBBLE. THE SPEED WAS REDUCED AND THE CONTACT REGAINED CONTROL OF THE VEHICLE. THE CONTACT STATED THAT THE FAILURE RECURRED WHEN THE VEHICLE ROLLED OVER A BUMP IN THE ROADWAY. THE CONTACT STATED THAT THE FAILURE WAS INTERMITTENT. THE VEHICLE WAS TAKEN TO SPRADLEY FORD (2828 US-50, PUEBLO, CO 81008, (717)-387-0875 FOR INSPECTION. THE DEALER REPLACED SEVERAL UNKNOWN PARTS HOWEVER, THE REPAIR FAILED TO REMEDY THE FAILURE. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000.

STEERING DAMPENER AND TIE RODS HAD TO BE REPLACED AT 58800 MILES DUE TO SHAKING OR WOBBLING OF THE FRONT END. THIS WAS AT THE NORMAL RATE OF SPEED ON THE HIGHWAY AT 55 TO 70 MILES PER HOUR. *TR

DRIVING ONE DAY THE FRONT END STARTED SHAKING VIOLENTLY. HAD IT REPAIRED - BUT IT IS DOING IT AGAIN JUST 2 MONTHS LATER. (DEATH RATTLE). *TR

THE DASH CLUSTER CUTS OFF WHILE DRIVING AS WELL AS RADIO AND AIR CONDITIONING. *TR

VIOLENT SHAKING WHEN DRIVING DOWN HIGHWAY. FIRST TIME THIS HAPPENED WAS WHEN I HAD AROUND 38,000 MIKES ON MY TRUCK. IT WAS SPORADIC AND ONLY A FEW INSTANCES. THE VIOLENT SHAKING MAKES IT HARD TO KEEP TRUCK ON ROAD WHILE SLOWING DOWN AND PULLING OFF ON THE SHOULDER. THIS HAS HAPPENED ON/OFF WITHIN NO WARNING. IT HAS BEEN HAPPENING MORE FREQUENTLYO. APPEARS TO HAPPEN WHEN GOING 60 MILES AND HOUR OR OVER AND WITHOUT WARNING BUT MOSTLY ALWAYS WHEN DRIVING ON HIGHWAY OR INTERSTATE.

WHEN DRIVING ON FREEWAYS THE TRUCK GOES INTO A DEATH WOBBLE REPAIRED BY FORD. 10 MONTHS LATER DEATH WOBBLE IS BACK CAN NOT DRIVE TRUCK SAFELY. *TR

DEATH WOBBLE. TRUCK SHAKES UNCONTROLLABLY AFTER A BUMP ON THE FREEWAY AT 70 MPH

RADIATOR IS LEAKING AND NEEDS TO BE REPLACED. THIS IS THE THIRD TIME IN 77,000 MILES THE RADIATOR HAS NEEDED TO BE REPLACED.

WHILE DRIVING MY 2016 FORD F250 CREW CAB ON A HIGHWAY, AT 50 MILES PER HOUR THE VEHICLE STEERING STARTED WOBBLING UNCONTROLLABLY AND THE WHOLE TRUCK STARTED SHAKING, I HAD TO SLOW DOWN TO 25 MILES PER HOUR TO STOP THE WOBBLING. HAPPENED AGAIN AT 65 MILES AND HOUR A FEW MINUTES LATER ON THE SAME ROAD. *TR

TRUCK HAS 48,000 MILES ON IT AND WHEN I WAS DRIVING HOME FROM PENNSYLVANIAN (NOT PULLING A TRAILER JUST DRIVING HOME) WHEN I WAS GOING ALONE THE INTERSTATE AT 65 MILES PER HOUR THE TRUCK STARTED TO SHAKE VIOLENTLY. I BRAKED AND THEN BACK ON THE GAS AND IT WAS FINE. I'VE READ A TON ABOUT THE "FORD DEATH WOBBLE" AND FEARED THIS WHEN BUYING A F250 BUT DIDN'T THINK THAT I TOO WOULD BE A VICTIM OF THIS POOR DESIGN BY FORD. I ROTATE AND BALANCE MY TIRES EVERY 5K TO 15K MILES AND ALIGNMENT CHECKED OKAY. VERY FRUSTRATING I HAVE TO BUY NEW PARTS FOR A TRACK THAT SHOULD LAST 100K+ WITHOUT ISSUES. I ORDERED AN AFTERMARKET (FOX) STABILIZER SHOCK BECAUSE THE FORD OEM ONE ON THE TRUCK WAS SHOT (LOST ALL ITS GAS OR LEAKED). AGAIN ONLY 48K MILES WHAT A JOKE! UNFORTUNATELY THE STABILIZER SHOCK HASN'T COMPLETELY SOLVED THE ISSUE. WHEN I HIT BUMPS IN THE ROAD I CAN FEEL THE PLAY IN THE WHEEL STILL AND BELIEVE I NEED TO GO THROUGH AND CHANGE ALL THE BALL JOINTS AND LINK ENDS. DO ALL THIS AND AGAIN CROSS MY FINGERS THAT IT WONT COME BACK. WANT TO BE PART OF THE CLASS ACTION LAW SUITE. JUST WANT A TRUCK THAT WORKS FOR AS MUCH AS I PAID FOR THIS THING FROM THE FACTORY. SAD FORD. I'M A DIE HARD FORD GUY BUT THIS IS A SAD DAY. *TR

DEATH WOBBLE PURCHASE TRUCK TWO YEARS AGO FRONT AND WAS FIXED THEN WITHIN A YEAR AND A HALF STARTED VIBRATING AGAIN REPLACED EVERYTHING IN FRONT IN DEATH WOBBLE STILL BAD EVEN AFTER ALIGNMENT I AM ALMOST WRECKED THE TRUCK TWICE IN THE LAST WEEK IT IS NOW PARKED IN THE DRIVEWAY NOT SAFE TO DRIVE

WHILE DRIVING ON THE HIGHWAY AT 70 MPH HAD A CATASTROPHIC BLOW OUT. THE LOW TIRE PRESSURE WARNING LIGHT CAME ON AND WITHIN SECONDS THE TIRE BLEW. ALSO AFTER INSPECTING THE OTHER TIRES NOTICED A CHUNK OF TREAD MISSING ON ANOTHER TIRE.

WITH 24,000 MILES ON MY TRUCK MY VEHICLE FRONT TIRES AND STEERING WHEEL EXPERIENCED A VIOLENT SHAKING TO WHERE MY TRUCK FELT LIKE THE AXLE WAS GOING TO FALL OFF. IT HAS BEEN IN THE FORD DEALERSHIP 4 TIMES FOR THIS DEATH WOBBLE. THE FIRST TIME I WAS GOING 70 MPH ON THE FREEWAY AND WENT OVER A BRIDGE JOINT WHICH TRIGGERED THE SHAKING. AS SOON AS I SLOWED DOWN BELOW 45 (ON THE FREEWAY MIND YOU), THE WOBBLE GOES AWAY AND MY TRUCK RIDES LIKE NORMAL. I PULLED OVER TO INSPECT, BUT I COULDN'T FIND ANYTHING WRONG. I TOOK IT TO THE DEALERSHIP, AND THEY FOUND THAT MY BALL JOINTS WERE DESTROYED, AND REPLACED THEM. THREE MONTHS LATER THE DEATH WOBBLE CAME BACK AND I TOOK IT BACK TO THE DEALER WHO ORIGINALLY REPLACED THE BALL JOINTS, AND ONCE AGAIN THE NEW BALL JOINTS WERE DESTROYED. THIS TIME THEY ALSO INSTALLED A STEERING STABLEIZER WHICH MADE THE FRONT END FEEL BETTER, BUT AFTER A FEW MONTHS OF DRIVING IT, THE DEATH WOBBLE CAME BACK. I NOW TOOK MY TRUCK TO ANOTHER DEALER WHO INSTANTLY FOUND A TECHNICIAN SERVICE BULLETIN (TSB) #16-0087 WHICH IS POSTED FROM FORD IN APRIL OF 2016 WHICH STATES THAT SOME SUSPENSION PARTS NEED TO BE ADDED TO THE REAR OF MY TRUCK, SO THEY INSTALLED THOSE PARTS..THE VERY NEXT DAY THE DEATH WOBBLE CAM BACK, AND THE DEALERSHIP INSTALLED A NEW TRACK BAR,THIS TIME EVEN THOUGH IT DIDN'T LOOK DEFECTIVE, BUT BECAUSE AFTER HAVING MY TRUCK FOR A MONTH, AND EVEN WITH THE HELP OF FORD'S MECHANICAL SPECIALISTS AT THE MAIN HEADQUARTERS COULDN'T FIND ANYTHING ANYTHING ELSE W

DRIVING ON INTERSTATE AND THE TRUCK STARTED A UNCONTROLLABLE WOBBLE. DURING THE WOBBLE I FELT I HAD NO CONTROL OF VEHICLE AND WAS MOVING OUT OF MY LANE. FORD NEEDS TO DO SOMETHING IMMEDIATELY BEFORE SOMEONE GETS KILLED I ALSO TELL A FIFTH WHEEL CAMPER AND I CAN ONLY IMAGINE HAVING THAT KIND OF WEIGHT BEHIND ME THAT THE TRUCK WOULD FLIP AND POSSIBLY KILL ME OR SOMEONE ELSE ON THE INTERSTATE.

SERVICE ENGINE LIGHT CAME ON TWICE WHILE VEHICLE WAS UNDER WARRANTY. DEALER SERVICED BOTH TIMES AND WAS UNABLE TO RECTIFY OR UNDERSTAND THE PROBLEM. THEY ONLY CLEARED THE FAULT CODES. THE CODE IDENTIFIED WAS FOR THE REDUCTANT HEATER PUMP - LOW VOLTAGE. THE SAME CODE JUST CAME BACK ON FOR THE 3RD TIME - THIS TIME IDENTIFIED BY A DIESEL PERFORMANCE SHOP - WITH ADVICE TO REPLACE THE REDUCTANT PUMP. PREVIOUS MAKE AND MODEL SUPERDUTY TRUCKS HAVE HAD RECALLS FOR THE SAME THING. THIS IS AN OBVIOUS ISSUE, NOT SURE WHY FORD SERVICE SHOPS COULD NOT RECTIFY. TRUCK IS NOW OUT OF WARRANTY AND I AM FORCED TO PAY OUT OF POCKET. UNACCEPTABLE SERVICE AND CARE! -COLD WEATHER EACH TIME -ENGINE LIGHT COMES ON - SAME CODE EACH TIME -REDUCED SPEED AND SLUGGISH PERFORMANCE -CODE CLEARED - TRUCK PERFORMS NORMAL -OBVIOUS THAT THE REDUCTANT HEAT PUMP IS NOT DOING WHAT IT IS DESIGNED TO DO.

"DEATH WOBBLE" AT APPROX 34K MILES I EXPERIENCED WHAT I LATER FOUND OUT WAS KNOWN AS THE DEATH WOBBLE. I DROVE OVER A SECTION OF HIGHWAY THAT I HAD BEEN OVER A THOUSAND TIMES BUT THIS TIME I HIT A POT HOLE JUST RIGHT AND MY STEERING WHEEL BEGAN TO VIOLENTLY SHAKE IN MY HANDS. AT THE SAME TIME I WAS APPROACHING A CURVE AND LITERALLY HAD TO STOP TO MAKE THE SHAKING GO AWAY. FORTUNATELY NOBODY WAS FOLLOWING ME ON THE HIGHWAY AND I WAS GOING THE SPEED LIMIT OF 55MPH WHEN THIS OCCURRED. THE PROBLEM HAS ALSO HAPPENED ON CERTAIN CITY STREETS WHEEL YOU HIT A POT HOLE OR ROAD SEEM IN JUST THE RIGHT WAY. I CONTACTED A FORD DEALERSHIP AND THEY REPLACED SEVERAL FRONT END COMPONENTS AND TOLD ME THAT THOSE REPAIRS WOULD FIX MY ISSUE. MY TRUCK NOW HAS 47K MILES ON IT AND THE PROBLEM IS SLOWLY RETURNING. THE WHEEL DOESN'T SHAKE AS BADLY AS IT DID THE FIRST TIME BUT IN THE RIGHT CONDITION IT WILL SHAKE IN YOUR HANDS.

FORD F250 DEATH WOBBLE, WHEN MY VEHICLE HITS A BUMP OR GROOVE IN THE ROAD WHILE DRIVING AT NORMAL HIGHWAY SPEEDS OR 45 MPH+. THE VEHICLE BEGINS TO VIOLENTLY WOBBLE AND SHAKE WHILE DRIVING, CAUSING ME TO LOSE CONTROL.

STEERING WHEEL OSCILLATION, MY FORD TRUCK EXPERIENCES THE DEATH WOBBLE WHEN TRAVELING MORE THAN 45 MPH AND THE TIRES HITS A GROOVE OR BUMP IN THE ROAD. THE ONLY WAY TO CONTROL THE VIOLENT SHAKING IS BY QUICKLY REDUCING SPEED, A DANGEROUS MOVE WHEN DRIVING IN TRAFFIC.

WHEN DRIVING AROUND 70 MPH I HIT A BUMP AND THE VEHICLE STARTED SHAKING HORRIBLY. WHEN I REDUCED THE SPEED TO AROUND 50MPH THE SHAKING STOPPED. THE TECHNICIAN CALLED IT A "DEATH WOBBLE" AND AFTER A FEW DAYS, THE VEHICLE WAS REPAIRED FOR $3755.80.

TL* THE CONTACT OWNED A 2016 FORD F-250. THE CONTACT STATED THAT WHILE HER SON WAS DRIVING 35 MPH AND TOWING A TRAILER WITH HIS ATV ON, A VEHICLE IN FRONT WAS MAKING A LEFT TURN AND THE DRIVER DEPRESSED THE BRAKE PEDAL. AN UNKNOWN WARNING LIGHT ILLUMINATED AND THE VEHICLE STALLED. THE CONTACT LOST CONTROL OF THE VEHICLE AND CRASHED INTO THE VEHICLE IN FRONT THAT WAS MAKING A LEFT TURN. THE VEHICLE CONTINUED 125 FEET DOWN THE ROAD, CROSSED OVER TO THE OPPOSITE LANES, CRASHED INTO SOME TREES WHERE IT EVENTUALLY CAME TO A STOP. NO AIR BAGS DEPLOYED. THE DRIVER SUSTAINED A CONCUSSION FROM HIS FACE HITTING THE STEERING WHEEL DURING THE IMPACT, MUSCLE NECK AND SHOULDER INJURIES WHICH RECEIVED MEDICAL ATTENTION FROM THE HOSPITAL. THE OTHER DRIVER SUSTAINED UNKNOWN INJURIES AND WAS TAKEN TO THE HOSPITAL VIA AMBULANCE. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED BY GEICO TO THE CONTACT RESIDENTS WHERE AN ADJUSTER INSPECTED THE VEHICLE AND TOWED THE VEHICLE TO A REPAIR FACILITY WHERE IT WAS DEEMED THE VEHICLE A TOTAL LOSS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT NO RECALL WAS UNDER THE VIN. NO FURTHER INFORMATION WAS PROVIDED BY THE MANUFACTURER. NO DEALER WAS CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000.

TL* THE CONTACT OWNS A 2016 FORD F-250. THE CONTACT STATED WHILE DRIVING 60 MPH, WHEN SHE EXPERIENCED THE "DEATH WOBBLE" SEVERAL TIMES. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE CONTACT WAS ABLE TO CONTROL. THE VEHICLE WAS TAKEN TO LOCAL DEALER FAIR OAKS FORD LINCOLN LOCATED AT 2055 W OGDEN AVE, NAPERVILLE, IL 60540, (630) 250-5750, AND THEY WERE MADE AWARE OF THE FAILURE. THE VEHICLE HAD NOT BEEN DIAGNOSED ORE REPAIRED AS OF YET. THE MANUFACTURER HAD BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS 20,000. *BF*JB

MY 2016 FORD F250 PRODUCED A CHECK ENGINE LIGHT. PER AN OBD TESTER THE CODE P20BA IS PRODUCED. THIS CORRESPONDS TO THE DIESEL REDUCTANT FLUID PUMP ASSEMBLY. UPON ONLINE RESEARCH THIS NORMALLY CORRESPONDS TO THE HEATER WHICH HEATS THE DIESEL EXHAUST FLUID FAILING. UPON FURTHER RESEARCH FORD EXTENDED THE WARRANTY ON OLDER MODELS OF THIS TRUCK, EVIDENTLY FROM 2011 THROUGH 2015. FROM OTHER'S EXPERIENCES IT APPEARS THE PROBLEM CONTINUES INTO THE 2016 MODEL YEAR HOWEVER THERE IS NO EXTENDED WARRANTY COVERAGE. AS THE VEHICLE MODEL OF 2016 IS SIMILAR TO THE 2011-2015 MODELS I BELIEVE COVERAGE SHOULD BE EXTENDED TO THE 2016 MODELS AS WELL. THE CHECK ENGINE LIGHT CAME ON TODAY UPON STARTING MY VEHICLE ON 1/17/2020.

WHILE DRIVING, IF I HIT A POTHOLE OR DIPS IN THE ROADWAY, HIT THE TRANSITION FROM THE ROADWAY PAVEMENT TO A BRIDGE OR OVERPASS ON THE HIGHWAY OR HIT A GROOVE IN THE ROADWAY THE FRONT END AND THE STEERING WHEEL CAN BEGIN TO SHAKE AND WOBBLE ERRATICALLY AND SOMETIMES VIOLENTLY. THIS IS SCARY AND HAS ALMOST CAUSED ACCIDENTS. THIS USUALLY OCCURS WHILE DRIVING AT SPEEDS BETWEEN 55 AND 70 MPH. ALSO, WHEN DRIVING AT SPEEDS BETWEEN 68 AND 75 THE STEERING WHEEL SHAKES. THIS OCCURS ALL THE TIME. I HAVE SPENT A LOT OF MONEY ON HAVING ALL FRONT END PARTS REPLACED, SHOCKS REPLACED AND TWO SETS OF BRAND NEW TIRES REPLACED WITHIN THREE AND A HALF MONTHS.YET, STILL I GET THE VIBRATIONS IN THE STEERING WHEEL AND FRONT END.

HIGH WAY SPEEDS VERY BAD SHAKE. DEATH WOBBLE. NEED CASTER SET MORE ON A 2.5 - 3 DEGREE. EVERYTHING IS STOCK ON THIS TRUCK AND AS MUCH AS I PAID FOR IT I AS SURE WASN'T EXPECTING THAT TO HAPPEN. I HAD TO PULL OF THE HIGHWAY AND STOP COMPLETELY AND THEN GRADUALLY GAIN SPEED AND AVOIDING HITTING EGG YOKES DIVIDING LANES. THAT WOULD SET IT OFF RUNNING 55 TO 60. MY MECHANIC IS THE ONE WHO TOLD ME ABOUT THE CASTER ADJUSTER. I DON'T WANT TO VOID MY WARRANTY MUCH LESS HAVE TO BUY SOMETHING THAT SHOULD'VE BEEN ALREADY INSTALLED ON THIS BEAST OF A TRUCK.

WHILE DRIVING HIT SMALL CRACKS AND BUMPS THAT CAUSED A VIOLENT SHAKING OF TRUCK, GOT ON BRAKES STOPPED AND THEN IT HAPPENED THREE MORE TIMES REGULAR EXPRESSWAY JOINTS CAUSED IT, HWY 385 AND I 240 BOTH 4 LANE EXPRESSWAYS, NO POT HOLES JUST JOINT CONNECTIONS AT SPEEDS OF 45 MILES A HOUR GETTING ON EXPRESSWAY AND AT SPEED ON I240 65 MPH WHEN IT HAPPENED. TRUCK WAS GOING STRAIT AT ALL TIMES WHEN THIS HAPPENED. TRUCK IS STOCK NO MODIFICATIONS.

TURNED ON REAR WINDOW DEFROSTER THIS MORNING WHILE PARKED IN MY DRIVEWAY. SOMETHING CAUGHT FIRE AND SHATTERED MY REAR WINDOW.

THE FRONT WHEELS WILL START SHAKING VIOLENTLY CAUSING THE ENTIRE TRUCK TO SHAKE. THIS IS KNOWN AS THE DEATH WOBBLE. THE TRUCK ONLY HAS 56,000 MILES AND THIS HAS HAPPENED SEVERAL TIMES. IT USUALLY HAPPENS WHEN YOU ARE IN A SLIGHT TURN AT HIGHWAY SPEEDS AND HIT ANY TYPE OF BUMP OR ROUGH PATCH IN THE ROAD.