2016 Ford F-250 SD complaints

The contact owns a 2016 Ford-250. The contact stated that while driving at various speeds, the vehicle experienced severe shaking and vibration after driving over bumps on the roadway. The vehicle was taken to the local dealer who diagnosed that the front ball joints were faulty and needed to be replaced. The ball joints were replaced, and the vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 30,000.

The contact owns a 2016 Ford F-250. The contact stated that while driving at an undisclosed speed, an unknown message was displayed on the instrument panel. The vehicle was taken to the dealer, where it was diagnosed and determined that the exhaust filter assembly was clogged and needed to be replaced. The dealer replaced the exhaust filter assembly. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was 93,538.

Upon hitting small road bump while accelerating to highway speed, steering wheel started violently shaking (death wobble), had to decelerate quickly to regain control. Upon later inspection found steering damper bad and some resulting ball joint play in several areas due to bad steering damper.

The contact owns a 2016 Ford F-250. The contact received notification of NHTSA Campaign Number: 22V337000 (Air Bags) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving at various speeds, the air bag warning light illuminated and remained illuminated. Additionally, the contact stated that the horn became inoperable. The contact called a dealer and was informed that the part to complete the recall repair was on a national backorder. The manufacturer was not made aware of the issue. The failure mileage was approximately 50,000. VIN tool confirms parts not available.

The contact owns a 2016 Ford F-250. The contact received notification of NHTSA Campaign Number: 22V337000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the steering wheel was stiff and made rattling sounds while making a turn. The air bag warning light was illuminated. Additionally, the horn, cruise control, phone, and radio buttons on the steering wheel were inoperable. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure and confirmed that parts were expected to become available in the third quarter of 2023. The failure mileage was approximately 90,000. VIN tool confirms parts not available.

The contact owns a 2016 Ford F-250. The contact stated that the check engine warning light was illuminated. The vehicle was taken to the dealer for a diagnostic test; the diagnostic test showed that the rear knock sensor was defective and needed to be replaced. The contact was informed by the dealer and the manufacturer that the vehicle was not covered under warranty. The contact was referred to NHTSA Hotline for assistance. The vehicle was not repaired and remained in the possession of the dealer. The failure mileage was approximately 71,000.

OTHER ELECTRICAL MALFUNCTIONS OCCURING, WINDSHIELD WIPERS WON'T TURN OFF

The contact owns a 2016 Ford F-250. The contact received notification of NHTSA Campaign Number: 22V337000 (Air Bags) however, the part to do the recall repair was not yet available. The local dealer was contacted and notified of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2016 Ford F-250. The contact stated that the check engine warning light illuminated intermittently. The vehicle was taken to several independent mechanics, where the warning light was reset; however, the failure persisted. The vehicle was taken to the dealer, where it was diagnosed that the reductant heater had failed and needed to be replaced. The contact became aware that the VIN was included in Ford Service Campaign Number: 20M01; however, the dealer informed the contact that the vehicle could not be repaired under the Service Campaign due to the mileage. The dealer referred the contact to the NHTSA Hotline for assistance. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 117,000.

The contact owns a 2016 Ford F-250. The contact received notification of NHTSA Campaign Number: 22V3370000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that an unknown dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2016 Ford F-250. The contact received notification of NHTSA Campaign Number: 22V337000 (Air Bags); however, the parts to do the recall repair were not yet available. The contact stated that the air bag warning light was illuminated. Additionally, the horn, the fuel gauge, the oil pressure gauge and other instrument cluster functions were inoperable. The vehicle was taken to the dealer, where it was diagnosed that the failure was related to the recall. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 70,000. VIN tool confirms parts not available.

The contact owns a 2016 Ford F-250. The contact received recall notification of NHTSA Campaign Number: 22V337000 (Air Bags) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2016 Ford F-250. The contact received notification of NHTSA Campaign Number: 22V337000 (Air Bags) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2016 Ford F-250. The contact received notification of NHTSA Campaign Number: 22V337000 (Air Bags) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2016 Ford F-250. The contact received notification of NHTSA Campaign Number: 22V337000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The local dealer was contacted. The manufacturer was made aware of the issue and advised the contact to take the vehicle to the dealer for an inspection. The contact had not experienced a failure. Parts distribution disconnect.

A notice of recall was received July 2022 by my family with the following numbers: Safety Recall Notice 22S35 / NHTSA Recall 22V337. I called NHTSA today to follow up on this notice, which in July 2022 I was told by Parsons Ford the fix was not available as of yet. [XXX] with NHTSA gave me a number to Ford's customer care hotline. Ford contacted Malloy Ford in Winchester VA which is suppose to call us when an actionable fix is available. They have no clue when that will be so I contacted NHTSA again today which now says there is no recall on my vehicle. So are we driving a vehicle that could potentially kill us or not. Why would the recall disappear within hours of talking to NHTSA & Ford? INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The contact owns a 2016 Ford F-250. The contact stated that while driving at an undisclosed speed, the air bag warning light, the ESC warning light, and the oil change warning light were illuminated. The contact related the failure to NHTSA Campaign Number: 22V337000 (Air Bags). The vehicle was taken to the dealer; however, no cause for the failure was found. The manufacturer was not made aware of the failure. The failure mileage was approximately 48,000.

Yesterday (3/20/23), as I was driving on the interstate at about 70 miles per hour, I hit a bump in the road and that caused the truck to go into severe shaking which I later learned has been termed as the "death wobble". I had to pull over to the emergency lane and stop the vehicle in order to get the vehicle under control. Luckily, there were not many vehicles on the road at the time so moving from the middle lane to the emergency lane on the right side was easy to do without causing any disruption to other drivers. I called my mechanic about the situation and he was the one to tell me it was the "death wobble" and it is common in Ford trucks and Jeeps. This was my first time experiencing this "death wobble" and it scared the crap out of me. In the past, I've hit bumps before and the truck felt like it might bounce off the road, but it never continuously shook (and shake violently) like it did yesterday. There was no warning or warning lights or anything like that that came on. As I was going to the emergency lane I did turn on the emergency flashers. I have an appointment with my mechanic to get this looked at in a week. That was the soonest I could get in.

Maintained Truck and did all required maintenance. Truck blew up while driving. All oil leaked out. Ford found hole in upper oil pan. Truck had poor fuel Truck has exhaust issues and ford can’t correct Lost truck and a lot of money , engine needs to be replaced.

I had the F-250 Death Wobble. I hit a bump at 70mph and the entire truck started shaking violently. It didn’t stop shaking until I slowed down to 30mph on the highway. This had the potential to be a life threatening accident if I would have lost control, especially since this happens at high speeds. Thousands of people have had the death wobble, why won’t the NHTSA mandate Ford to fix this?

The contact owns a 2016 Ford F-250. The contact received notification of NHTSA Campaign Number: 22V337000 (Air Bags) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was contacted but was unable to confirm when parts would become available. The contact had not experienced a failure. Parts distribution disconnect.

In December 2022, I received a safety recall notice from Ford stating, dust contamination may lead to loss of electrical circuit connection, which may result in failure of airbag to deploy in an accident. Ford stated that when parts become available, they would notify me via email to schedule a service appointment for repairs to be completed free of charge (parts & labor). Parts are anticipated to be available early first quarter 2023. My dealer has no information about availability of parts yet. I am following up, in hope to learn the status of this important safety recall. Thank you, [XXX] sent Feb. 8, 2023 INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

DEF heater/sender assembly was replaced under Ford 21M01 recall. However, the damaged caused by these defective items caused the need to repair additional component's that was not paid for by Ford. Ford will not reimburse additional cost, and can not furnish a statement from a Ford engineer that states the defective replaced parts did not cause the additional repairs. (expense).

When I drove over 50mph and hit any bump the front of the truck shakes wildly. Online says DEATH WOBBLE. This has been going on for 4 months. When taking my children to school 20+ miles away on the highway this has happened several times to and from school on the same day. Other vehicles move out of my line to avoid me while I slow the truck to under 45 mph. They are scared and nervous about getting to school safely. My mother and wife refuse to drive the truck after experiencing this while driving. The fuel injector now also has a problem. The truck is going in to be serviced for the failing fuel injector and death wobble hopefully today if Waldorf MD Ford has openings I am awaiting a call back. It has not been inspected yet only diagnostic at AutoZone showing the fuel injector error code. No warning was given prior to this happening, the truck was riding smoothly, hit a bump in the highway and went crazy. Then it did it again and again and again.

I was experiencing what is known as the "death wobble" in my 2016 Ford F250 FX4 truck. The truck only has 56,000 miles but is out of warranty. I recently spent $1326.00 to have the problem repaired. Apparently this is a major problem with these trucks. I have the repair bill but didn't include it with this statement.

The contact owns a 2016 Ford F-250. The contact received notification of NHTSA Campaign Number: 22V337000 (Air Bags) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

On a highway, 65-70 mph, drove over a rough patch of road and truck front end began to shake violently(death wobble). Happened three times on same day, same trip. On all occasions we were very lucky to be able to stop or slow down without being involved in an accident. I spent $5000 this past summer that was suppose to have fixed the problem.

Entered a highway on-ramp, accelerating to 65-70 mph, drove over a rough patch of road and truck front end began to shake violently(death wobble) we were very lucky to be able to slow down without being involved in an accident. I spent $5000 this past summer that was suppose to have fixed this problem.

I was traveling on the interstate at the posted speed limit of 70 mph. I was crossing an overpass and upon exiting the overpass my vehicle began what is often referred to as ‘death wobble’. My front suspension began shaking so violently that I temporarily lost control of the vehicle and had to reduce my speed dramatically in the travel lane to regain control before I was able to steer into the emergency lane. Had I been hauling or towing a load I am sure this would have resulted in a wreck. Since this happened, I have read that Ford has refused to conduct a recall on this issue. I urge the NHTSA enter this situation and require Ford to address the issue.

Truck was driving 70 mph going to TN when it started shaking and grinding or awful noise. Lost control of steering d/t shaking. Slowed down and pulled over to side of road to check vehicle equipment. Made call to my son who said it's the death wobble, advised to slow below 60 mph. No death wobble again unless I hit a bump then it started again.

My 2016 F-250 continues to experience the Ford Truck "death wobble." It sometimes happens after I have travelled on an interstate entrance and am increasing speed up to normal highway speed (or similar situation). The front end begins to terribly "shake" and I can only stop it by drastically braking to a much slower speed or even coming to a stop. Usually, there is no obvious reason for this wobble to occur although a rough interstate entrance rough surface may increase the probability of it occurring. I have been able to handle it thus far, but I do worry about being in a traffic lane and having limited options to resolve the issue quickly.

The contact owns a 2016 Ford F-250. The contact received notification of NHTSA Campaign Number: 22V337000 (Air Bags) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

At highway speed on Interstate-95, I hit a rough patch of asphalt paving and front end of vehicle began to shake uncontrollably. Vehicle continued to shake violently until speed was significantly reduced below the flow of traffic thus creating an extremely dangerous situation. All 4 shocks and steering stabilizer were replace with upgraded Bilstein brand products bya Ford master mechanic within the last 6 months.

Death wobble. Uncontrollable shaking in steering to the point of loss of control. Occurs after a bumpy road or at speeds in excess of 45mph. This occurred on a packed interstate and by the grace of God we didn't wreck or be rear-ended by a semi.

Violently shaking can not control truck, I’ve looked this up and it is known as the death wobble. It looks like they have recalled /027 but not 2016 models what can be done about this. It has happened about 6 times in 3 days

There was a violent shaking from the front end od my Ford F250 Super Duty trucks happening on the freeway while driving over 50 miles and hour. This has happended 3 times in the last 6 months. It is very dangerous and causes other vehicles around to try and get out of the way. It only stops after reducing to a dangerously low speed on the freeway. It is very scary and life threatening in my opinion. Please recall and correct!

At speed on interstate after hitting bumps in the roadway front end started to wobble bad. Had to slow down below 45mph to get wobble to stop.

Ford sent me a recall #22S35 regarding a clock spring contamination of the steering wheel date (5/2022) notice beginning in 6/2022 to have it repaired by making an appt with a local dealer however, the dealer service advisors at Tustin Ford in Ca told me in multiple calls to them that Ford does not have the parts built yet. Please advise John J. Rochefort (949) 285-7171 [email protected]

The Driveshaft fractured and fell out of truck while driving and lost control and veered off onto the grass of highway.

The airbag light is on as the spring in the steering column has become contaminated which caused audible cracking sounds in steering column, degrading steering and the horn not to function.

I have had multiple repairs done and several components replaced and im still fighting a death wobble issue. It occurs at normal opersting speeds above 40mph when you travel across bumpy surfaces.

FRONT WHEELS WOBBLE UNCONTROLABLY AFTER HITTING A BUMP AT SPEEDS ABOVE 30 MPH. PROBLEM CONFIRMED BY MECHANIC AND TEMPERARY FIX ACOMPLISHED BY ADDING 2 MORE DAMPENING SHOCK ABSORBERS IN ADDITION TO THE ONE PROVIDED BY THE FACTORY AND REPLACING FRONT STRUTS AND FRONTEND BALL JOINTS.

While driving on Route 64 in Virginia in May 2022, the vehicle sustained severe steering wheel oscillations after hitting rough pavement, driving around 65 miles per hour. It was difficult to hold on to the steering wheel. The oscillations lasted roughly 60 seconds. There were no warning lamps, messages, or other symptoms of the problem prior to the occurrence. This occurrence happened again while driving on Route 50 eastbound to Annapolis on Saturday October 1, 2022 around 65 miles per hour. After hitting rough pavement, the vehicle sustained severe steering wheel oscillations. The oscillations last roughly 60 seconds. In both occurrence, it was difficult to hold onto the steering wheel. We were concerned that the ability for the truck to break would be impacted.

I was driving on the highway going 65mph when my truck started violently shaking and I almost lost control, I had to pull to the shoulder and stop. This is the second time It has happened. It is very dangerous, thank god I drive with two hands. It is very scary and I could of hit another car.

Death wobble occurred this morning for the first time ever. It was terrifying for me and my children. I had to slam on the brakes so hard that I nearly slid off the road! The fact that Ford doesn’t acknowledge this is ridiculous. I hope and pray that this does not occur with my children in the vehicle, or while I’m hauling my horses.

Air bag clock spring in steering wheel has broken, air bag light is on and no functions on the steering work ...heated, volume control buttons, horn etc will not work.

Violent shaking from front end at moderate highway speed experienced when bumps road or when driving on groved surfaces. problem confirmed by ford mechanic and repaired at my expense. Approximately one year later same violent shake. same ford dealer replaced parts originally repaired by them. from time to time a less severe shake has been noted. Have repair invoices. concerned this problem will result one day in loss of vehicle control.

While driving on a highway I went over a bump in the road and the vehicle started shaking violently and I could not control it. I applied the brakes and slowed to about 30 mph and the shaking stopped. No other motorists were involved.

Traveling on uneven road leads to uncontrollable driving when u hit a bump the front end shakes to the point you have to stop even when passing a vehicle on interstates ( my incident) my mechanic has changed numerous parts , rotated tires ( installed 06 21) i cannot let my wife drive this truck for fear of her not being able to control the shaking if she hits a bump especially while on the interstate I just think she would freak out I did the first time now I am very cautious when driving but in Louisiana it is impossible to miss a bump

The contact owns a 2016 Ford F-250. The contact stated while driving out of a parking lot at approximately 3 MPH, the air bag warning light illuminated and the steering wheel was difficult to operate. The contact then parked the vehicle. The contact drove the vehicle to the dealer and it was diagnosed with an air bag sensor failure. The vehicle was not repaired due to parts not being available. The manufacturer was notified of the failure. The approximate failure mileage was 90,000.