2019 Ford F-150 complaints

See attached document for complaint

The contact owns a 2019 Ford F-150. The contact stated while driving 75 MPH, the vehicle unexpectedly downshifted, started jerking, and decelerated. The vehicle returned to normal functionality, but the failure became a regular occurrence. The service engine warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the transmission. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 62,000.

The car lost ALL POWER and the ability to accelerate for more than 10 seconds. Luckily cars coming form across moved to the side to not hit me. I was stuck in the middle of the intersection. I attempted to shift manually in a panic and the car slammed really hard in likely 1st gear, red-lineed for several seconds then inched forward enough to pull to the side. I was able to proceed forward stuck in 7th gear, where the car remained stuck in that gear. This was terrifying as I had ZERO ability to move forward, the engine was revving but no gears were available

Fuel tank purge valve issue causing multiple idling and performance issues, eventually resulted in break down. Tank was found to be imploded upon mechanical inspection.

Transmission failure requiring replacement

Has high fuel pressure constantly and I have changed several parts for the fuel system and has it running to rich

I am aware of the cam phase issue with 2017-2020 F150s 3.5 Eco Boost (also effected my 2016). I have 89K miles and I took it to the dealership as my cam phasers are failing and making the engine loud and ready to fail. The repair bill is 4K and I called Ford Customer Care - who does not Care. I had purchased extended warranty, but they are stating it is not covered. This is the 2nd F150 I have owned with the problem. Ford service is stating they see "a lot" of these - Ford needs to make this right for their consumers.

Issue was with the boat trailer tire for VIN 405119BA2LC000663. Goodyear Marathon, ST205/75R14, DOT [XXX], 8/32 tread remaining. Steel belt failure. Tires pressure was set to 40 psi before trip. Failure occurred after 45 minutes on the highway traveling at 65 mph. Felt a bad vibration, then loud bang when air came out of tire. This tire is only 8 years old. I replace them at 10 years. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2019 Ford F-150. The contact stated while driving 80 MPH, the vehicle was experiencing hard shifts, and the transmission was shifting in and out of gear and failed to shift as intended. The power train warning light was illuminated, and a message advising that the power train had failed was displayed. The contact pulled into a gas station and inspected the vehicle but found no failure. The contact stated that after turning off and restarting the vehicle, the warning light was no longer illuminated, and the message was no longer displayed. The contact was able to continue driving. The vehicle was taken to the dealer, where it was diagnosed that the transmission CDF drum had failed and needed to be replaced. The vehicle was not repaired. The contact related the failure to TSB Number: 22-2428. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 70,100.

The contact owns a 2019 Ford F-150. The contact stated that while the vehicle was started, there was an abnormal sound coming from the engine compartment. The vehicle was taken to a dealer where it was diagnosed and determined that the cam phasers needed to be replaced. The vehicle was not repaired. The contact believed that the failure was associated with Manufacturer Recall Campaign Number: 21N03. The manufacturer was notified of the failure. The failure mileage was approximately 83,000.

The contact owns a 2019 Ford F-150. The contact stated that the driver's side air bag cover had fractured. The contact stated that the air bag cover was fractured through the middle. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The dealer was contacted and made aware of the failure. The contact was informed that the repair was not covered under recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 97,000.

My 2019 F150 transmission will downshift very harsh into first gear like the truck nose dives and will slam back into fourth after, like the transmission loses power. I have had it at the dealer when it was still in warranty and they had it for like two weeks and then said it was the throttle body but that definitely never fixed it. Since I am out of warranty I just learned to live with the issue for last couple of years and now I see there is a recall for this issue but my truck doesn’t fall under the recall or something. Trying to get help with fixing this issue.

The contact owns a 2019 Ford F-150. The contact stated when the vehicle was cold started, the vehicle rattled for several minutes until the engine warmed up. The contact stated no warning light was illuminated. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer was informed of the failure. The contact researched online and related the failure to Customer Satisfaction Program: 21N03 Cam Phaser Replacement (Engine). The failure mileage was approximately 72,000.

This afternoon while getting ready to leave church, I pulled my truck forward about 10 feet with no issues in order to load some things in the truck bed before taking off. The truck started up just fine, and the starter sounded just as strong as it always does, indicating the battery was of good health. Upon starting the vehicle less than 5 minutes later the engine would not start due to a dead battery - or so that's what the symptoms led me to believe anyway. I heard some clicks, but no starter motor activity, then saw a warning on my radio screen stating "turn ignition off or start engine." This could have been at a stoplight, leaving me as a stalled vehicle in the middle of the road had it happened in conjunction with the auto start/stop that shuts off the engine when stopped for a short period of time. I have not yet taken the truck into a dealership to have this issue looked at. This appears to be a resurfacing problem from about 2 years ago when I had electrical issues where my radio would not turn off as I got to work one morning - even though the ignition had been turned off and the driver door was open. The radio was still running when I got back to the truck in the afternoon. I was able to drive home that day, but with limited functionality of the truck. It was during a heavy rain, and the rear brake lights would not work, and the windshield wipers would not turn on. When I went down the next morning to take it into the dealership, I had to get it jump started, as t

The contact owns a 2019 Ford F-150. The contact stated that the vehicle was shifting hard. The contact stated that while at a red light, the vehicle hesitated and shut off. The engine warning light was illuminated. The contact placed the vehicle in park and restarted the vehicle, but the failure recurred. The vehicle was taken to the local dealer, who was unable to determine the cause of the failure. The vehicle was not diagnosed or repaired. The vehicle was taken back to the local dealer, who performed a transmission flush, but the failure persisted. The vehicle was taken to a transmission shop, where the failure was experienced; however, the vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 64,000.

When transmission is cold, 4th gear shift is intermittently extremely delayed.

The contact owns a 2019 Ford F-150. The contact stated that upon starting the vehicle, there was an abnormal rattling sound coming from the engine compartment. After the vehicle engine had warmed up the vehicle returned to normal functionality, but the failure became a regular occurrence. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the cam phasers. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N03. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 75,000.

My truck's gas pedal does not always accelerate the truck. By playing lightly with the accelerator I can usually keep the truck accelerating. If I press the accelerator to the floorboard, the truck just stops, so I never do that. Maybe 3 times in 4 years. Several times I have been on a freeway and my truck comes to a complete stop. Very Scary! My truck has had this behavior since I first bought it. Planet Ford told me repeatedly that it was due to the way I drove. Called Ford and they were no help. I finally gave up.

I have a 2019 ford f150 lariat with the 3.5 ecoboost engine. Ford issued a customer satisfaction with the F150’s regarding faulty camphasers. Ford sent this out to every owner that had a F150 made from april 15, 2019 to November 30, 2019. My specific truck was made in December 21, 2018. My truck’s vin number was not attached to that customer satisfaction program 21N03, but my truck has that exact problem. I took it to the local Ford dealership July 30, 2024 where they found I had faulty camphasers and are replacing them right now. I am currently trying to contact Ford to figure out why my truck was not notified. And not have to pay out of pocket for a problem Ford caused and created.

The contact owns a 2019 Ford F-150. The contact stated while driving at approximately 40 MPH, the accelerator pedal was depressed, and the transmission shifted erroneously from 2nd gear to 4th gear. The contact stated that the failure also occurred while in 5th gear and attempting to accelerate, with the transmission downshifting to 2nd gear before jolting into the higher gear. The contact stated that the gear shift transitions were not smooth and caused the vehicle to jolt. The contact stated that the check engine warning light illuminated, and the "WRENCH" symbol was displayed. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the CDF drum and a transmission overhaul was needed. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 118,000.

The contact owns a 2019 Ford F-150. The contact stated while driving 72 MPH, the vehicle independently decelerated to 40 MPH. Additionally, the vehicle lost motive power with the check engine warning light illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. Additionally, the contact stated that the vehicle had been serviced by the dealer six times due to the failure. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 120,000. The VIN was unavailable.

The contact owns a 2019 Ford F-150. The contact stated while driving at an undisclosed speed, the vehicle lost motive power. The contact stated that there was an abnormal sound coming from underneath the vehicle after the vehicle was started. There was no warning light illuminated. The vehicle was taken to a local Midas, and the contact was informed that that the cam phaser needed to be replaced. The vehicle was taken to a local dealer where it was diagnosed that the cam phaser had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 75,000.

The contact owns a 2019 Ford F-150. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The vehicle was taken to an independent mechanic where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 62,000.

The contact owns a 2019 Ford F-150. The contact stated while the vehicle was parked, the vehicle was started, and the contact heard an abnormal sound coming from the engine. There was no warning light illuminated. The vehicle was drivable; however, the vehicle was not taken to a dealer to be diagnosed. The dealer was contacted, and the contact declined to pay for a diagnostic test to be performed. The contact related the failure to an unknown Manufacturer recall related to cam phaser failures. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 40,000.

The contact owns a 2019 Ford F-150. The contact stated while cold starting the vehicle, the vehicle was idling roughly, and abnormal sounds were coming from the engine. The contact stated that no warning light was illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the cam phasers needed to be replaced. The vehicle was not repaired. The contact researched online and related the failure to Customer Satisfaction Program: 21N03 Cam Phaser Replacement (Engine). The manufacturer was informed of the failure. The failure mileage was approximately 42,000.

The transmission on this vehicle regularly hesitates, lurches and shifts gears unexpectedly. I have had multiple incidents of not being able to accelerate without a delay while in traffic and once the transmission downshifted incorrectly on the freeway which nearly caused me to lose control of the vehicle. The unexpected lack of acceleration while in live traffic and the erratic gear shifting on the highway is a safety hazard for me and for other drivers on the road.

When we come to a complete stop and going at highway speed the transmission slips from 10th gear to 1st gear while driving then through other gears until it catches back up to the correct gear. The whole truck will stall until the correct gear is found causing us to possibly be hit

Tail gate will not latch/lock properly. Tail gate will not latch into the closed position when pushed closed, and sometimes only partially latches. This may allow the cargo to fall on the road, putting other motorists in danger. Tail gate external latch handle remains in the open position and does not properly retract under spring pressure to the unopen position after manually opening. Tail gate latch handle must be forcibly manually closed with significant pressure to allow the tail gate to latch closed on the two side plate bosses. With out this manually effort, tail gate lock will not engage the locking bosses. If one is not careful to ensure full retraction the tail gate lock may not fully latch and could open while driving. I have Lubricated the latch handle mechanism latch locking mechanism and all joints, with no significant improvement. Defect or tolerance problem in latch mechanism is very likely. Prior recall on model year F-150’s have reported very similar problem

Safety Concerns Regarding F150 10-Speed Transmissions: oI am deeply concerned about the safety of my F150 due to reports of accidents related to faulty 10-speed transmissions. oThe risk of sudden downshifting to 1st gear, potentially causing loss of control, poses a serious threat to me, my passengers, and other road users. oFord must address this issue promptly to ensure the safety of its customers. Transmission overheats while towing rated camper. Engine sounds like a loud sewing machine when first starting. Fear engine may explode.

The contact owns a 2019 Ford F-150. The contact stated that on several occasions while driving at various speeds, the transmission unexpectedly downshifted and the rear wheels seized. The vehicle was pulled to the side of the road and inspected. The contact stated that the ESP warning light was illuminated. The vehicle was taken to a dealer where the transmission, engine, and rear differential needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 116,000.

The contact owns a 2019 Ford F-150. The contact stated that upon starting the vehicle, there was a rattling sound coming from the top of the engine. The vehicle was taken to the local dealer who diagnosed that the cam phasers were faulty, and a software update was performed. The failure was temporarily resolved; however, the failure recently reoccurred. The manufacturer and local dealer were notified of the recent failure, but no assistance was offered. The failure mileage was 15,000.

Defective 10R80 transmission shifts erratically; fall out of gear and won’t accelerate; won’t shift into drive or reverse consistently. The issue puts others at risk as the vehicle doesn’t function in a consistent manner. Yes. The transmission was replaced entirely, but the problems persist. It has not been inspected by police of insurance. No lights or messages are displayed when the issues present.

The contact owns a 2019 Ford F-150. The contact stated that while driving on several occasions at various speeds, the vehicle shuddered and vibrated abnormally. The vehicle was taken to a dealer where it was diagnosed and determined that the tires were out of balance. The vehicle was repaired but the failure persisted. The vehicle was then taken to the same dealer again where it was diagnosed that the driveshaft needed to be replaced. The vehicle was repaired but the failure persisted. The vehicle was taken to another dealer where it was diagnosed that the torque convertor and valve body needed to be replaced. The vehicle was repaired but the failure persisted. The vehicle was taken back to the first dealer to be diagnosed but the failure was unable to be replicated. The manufacturer was notified of the failure. The failure mileage was approximately 77,000.

The contact owns a 2019 Ford F-150. The contact stated that upon attempting to start the vehicle, there was a knocking and rattling sound coming from the engine compartment. There were no warning lights illuminated. The vehicle was taken to a local dealer where it was diagnosed with a cam phaser leaking oil pressure; however, the vehicle was not repaired because the warranty had expired four months prior to the failure. The contact related the failure with Customer Satisfaction Program: 21N03 (Certain 2017-2020 Model Year F-150, 2018-2020 Expedition, and 2018-2020 Navigator Vehicles Equipped with a 3.5L GTDI Engine Cam Phaser Replacement); however, the vehicle was not included. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 150,000.

While driving, rpms went high, speed dramatically decreased suddenly as transmission suddenly and without warning began changing gear. as soon as possible, I pulled into a local convenience store where I had no transmission gears at all ( 1st thru reverse ). Looking under my vehicle, I noted a stream of transmission fluid running down the parking lot. The incident caused an extremely dangerous situation as I was traveling on a major, busy 4 lane highway. Vehicle was towed to a prominent ford dealer, where a “ blown out transmission cooler fitting “ was found. “Wrench” light came on dash as vehicle began to decelerate. Transmission had similar issues regarding loss of power and gear changing issues no fewer than 3 times after this.

Certain 2019 f-150 ford models are recalled for the SAME issue I am having but my model truck is not in the recal. For the same exact isssue

The transmission surges forwarded upon placing in drive during a cold startup. during driving loses power and will not engage. when this happens the gas paddle has to released so that the transmission can regain power. check engine light came on. Truck was inspected by ford dealership and was informed that the truck needs a new transmission after diagnostic was preformed.

The cam phasers on my 2019 F-150 recently starting making a rattling noise on cold starts. The dealership is quoting a replacement for $4500. I received Customer Satisfaction Program 21B10, 21N03, and 21N08 updates in the mail in 2021 from Ford to have the cam phasers replaced. The recall/replacement program was extended from 2022 to January 1, 2023. Unfortunately I've had my truck in for service multiple times and was told to not replace the cam phasers if there isn't an issue. Now there is an issue after the expiration and I'm being asked to pay out of pocket.

Transmission failure

The contact owns a 2019 Ford F-150. The contact stated that while operating the vehicle, the transmission malfunctioned, causing the vehicle to lose motive power. The contact stated that the vehicle failed to accelerate as needed. Additionally, while driving at an undisclosed speed, the transmission unexpectedly downshifted, causing the vehicle to abruptly decelerate. The vehicle was taken to the local dealer to be diagnosed. The contact was informed that the transmission was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 100,000.

Cam Phasers went bad, was told that while some vehicles from other factories feel under an extended warranty this one did not although its the same make and model for what appears to be a widespread issue.

Transmission has been horrible for a couple of years, would down shift on its on while on highway at high speeds. Also would not not allow you to accelerate randomly nearly causing numerous accidents.

Vehical shifts hard and surges forward during shifts. After sitting for a least 8 hours, the shifting will stick at 7th gear and then cycle between 1st and 7th until finally issuing a power train warning symbol (wrench). Other times it stays in 7th gear at a complete stop. This causes a slow pull out at intersections ( pulling out in 7th gear) until it slams into 3rd gear and surges forward.

The contact owns a 2019 Ford F-150. The contact stated while driving 75 MPH over a bump, the vehicle made an abnormally loud banging sound. The contact stated that the vehicle then made an abnormal humming and grinding sound that persisted while driving at various speeds and coming to a complete stop. The contact stated that the failure had been recurring increasingly while coming to a complete stop. The vehicle was taken to the dealer, where it was test-driven, and the dealer informed the contact that the abnormal sound originated from the rear differential. Additionally, the dealer informed the contact that the rear differential needed to be taken apart to determine the cause of the failure. The vehicle was not diagnosed or repaired. The contact related the failure to an unknown recall. The manufacturer was notified of the failure and offered to repurchase the vehicle and to partially cover the repair of the vehicle. A case was opened, and the contact was referred to the NHTSA Hotline for further assistance. The failure mileage was approximately 80,000.

The contact owns a 2019 Ford F-150. The contact stated while in reverse, the rearview display screen occasionally displayed a blank black screen and failed to display the images as intended. There was no warning had illuminated. Additionally, the contact stated that while driving, the back over prevention screen displayed an image. The contact stated the manufacturer had performed a master reset for the display screen OTA, but the failure reoccurred. The local dealer was not contacted. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 90,000.

My wife was driving about 40 mph and the emergency collision alarm came on causing the vehicle to abruptly try to stop. San alarm went off in the dash indicating an imminent crash causing my wife to almost lose control of the vehicle. There was no vehicle in front of us and none in the opposing lane or behind us to trigger this response. My wife speculated maybe a bird flew across in front of us but I dodn,t see that. it was very alarming and almost caused her to lose control of the vehicle. I had this happen to me driving alone at about 40 mph. The only difference , there was a vehicle in front of m E but I was not close enough to trigger this safety alarm. The vehicle in front of me was not stopped and I was not close enough to trigger this response. I was at least4 or 5 car lengths away doing 40 mph. and they were traveling about the same speed. No rapid approach issue...

10 speed Transmission bucks and jams when accelerating and bangs down shifting unexpectedly, creates an unsafe feeling with this action

The contact owns a 2019 Ford F-150 equipped with Michelin Tires, Tire Line: Defender LTX, Tire Size: 275/65/R18, DOT Number: [XXX] . The contact stated that after a visual inspection, he observed that the front passenger’s side tire rib was cracked and separating from the tire body, exposing the steel belts. The vehicle was taken to the dealer, who was unable to diagnose the failure but determined the failure to be an abnormal safety hazard. The tire was replaced, but the contact had since observed the failure occurring in the remaining tires. The manufacturer was not notified of the failure. The failure mileage was 35,000. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2019 Ford F-150. The contact stated that while driving at various speeds, the transmission erroneously upshifted and downshifted unexpectedly. The contact stated that the transmission had randomly shifted from 6th to 8th gear and from 3rd to 2nd gear unexpectedly. Additionally, while restarting the vehicle, the failure had self-corrected but the failure later reoccurred. The vehicle was examined by an independent mechanic who was unable to determine the cause of the failure. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was 130,000.

Hard and or lagging shift seems to have delayed shift then slam into gear