2017 Ford F-150 complaints

Harsh shifting up and down, never shifts into 2nd gear jumps from 1st to 3rd and 3rd to 1st possibly unsafe on ice and snow packed roads. Shift lag intermittently.

The contact owns a 2017 Ford F-150. The contact stated that while driving uphill at an undisclosed speed, the brake pedal would go to the floorboard while depressed. The vehicle was taken to the dealer and diagnosed that the brake master cylinder was leaking. The brake master cylinder needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to file a complaint with NHTSA. The failure mileage was approximately 15,000.

Vehile is parked outside every night. On some cold mornings, with temperatures below freezing, one or more of the door latches freeze shut. Sometimes the door will not open. The most dangerous thing that happens is that if a door is opened and the latch is frozen, the door will fail to latch closed. You try to close the door and it just bounces off the frame of the car. It will not stay closed. I had to drive my kids to school today with one child holding a door shut the entire time since it would not latch closed. Additionally, at these times, the power locking actuators fail to raise or lower the locking mechanism. This does not happen every time there is freezing weather, but it has happened 10+ times over the past ~2 years. Multiple doors are affected.

It was 15 degrees F out last night. Both driver and passenger front doors would not latch when closed. The passenger door swung open as I turned the corner. Thankfully I did not have a passenger.

The contact owns a 2017 Ford F-150. The contact stated while attempting to unlock the door, the door latch would not release. The vehicle was taken to a local dealer but was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 45,818.

There is a known problem with the 2015-2020 model year F150s door latches freezing shut, when in sub freezing temperatures, the door will wildly bounce off the truck frame and open/close on a whim. Usually I have either spent extra time in the mornings idling with the heat on long enough for the latches to melt themselves free, stood outside with a heat gun to evaporate the moisture or in a pinch, had to drive physically holding the door shut with a tow strap. This is on a modern, five year old vehicle mind you. The problem has been, at least on my truck, predominantly always the drivers side and passenger side doors until today when it impacted the rear doors of my crew cab. I drive my children (ages 4 & 5) to daycare and kindergarten every weekday. This morning my daughters door, which was seemingly latched shut and fine, swung wide open while turning. Luckily she was in a car seat and tightly in due to the harness but that is 100% unacceptable, dangerous and ridiculous. These latches are going to get a child killed. My truck was purchased in Clearwater FL and never had an issue the 3 years I lived in a tropical climate. I moved to Ohio, and during the summer, late spring and early fall was fine. As soon as the temperature drops for winter the freezing starts and the doors become dangerous. To my knowledge there are no safety recalls for this issue but a number of worthless “fixes” offered by Ford, all of which do nothing to rectify the problem. https://www.f150forum.com/f1

Multiple doors have latches frozen open after opening such that when the door shuts it does not stay closed but appears closed. Will open when driving. Latches will reseat themselves after truck interior warms up.

Rear door latch failures in both left and right sides when there are freezing temperatures. Three separate incidents: 12/23/2019 - rear left door latch failure... the door opened, but would not latch when closed. Took to Ford dealership where they applied the 18N03 door latch safety recall service, adding seals, grease, and a clip. 12/28/2019 - just one week after the 18N03 safety recall service, both left and right door latches failed again, where the doors would open but would not latch shut (have recording on iPhone). Temperatures were 33F. Returned to Ford dealership and they replaced both latches under a third-party warranty. 12/21/2021 - both rear left door again would not latch shut in freezing temperatures. Able to latch shut after removing rubber seal from door and blowing hot air in from a hair dryer. Video of issue is on iPhone. 12/29/2021 - called Ford corporate office and spoke with Katelyn. Expressed concerns that the incident is recurring and wanted a permanent solution, given safety concerns. She indicated that she would record the incident in my file but that there is nothing further that Ford is recommending at this point. Will attempt to visit Ford service again to see what they can do, but I remain very concerned given the above history.

The electric power steering system can take up to 10 seconds to turn back on after the auto start/ stop function restarts the engine. The truck has done it intermittently since new, but now has started to do it more often. It has caused me a few close calls making right-hand turns. I start to take off only to find I have no steering assist and either have to manually steer the truck or stop and wait in the middle of an intersection for it to turn on. last week this caused me to run wide into the turn lane for the lane I was turning into, thankfully it was not occupied at the time or it could have caused an accident. Since it is not repeatable, and there are no warning/trouble lights the dealer is of no use. I asked when the truck was under warranty was told they didn't want to look at it unless it was able to be reproduced on demand. This issue is occurring at a rate of about 1-3 incidents a month.

APIM failure

I got a flat tire on Interstate 75 North in central Georgia. I had an issue with the lug nuts coming off. This issue put me and my family in grave danger. Instead of a simple tire change I had to wait on the side of the interstate for roadside assistance due to the issued lug nut wrench not working properly because of the swollen lug nuts! This is a very unsafe! Please contact Ford to make them accountable!

Swollen lug nuts

Used remote starter; about 2 minutes later my family entered the vehicle with my 2 small kids secured in their child seats in back seat. We left our home, made about 1-mile down the road when back window suddenly popped and shattered. Nothing struck or hit the window to break it. Tiny glass fragments blew onto my children and scared them. The plastic cover on the defroster connection mechanism on the rear center electronic sliding glass window also popped off and the one of the electronic metal connections is clearly broken loose on the mechanism also. No warning messages on dash/display. I did not turn on defroster and rear defroster light was not on at the time, but maybe came on automatically with remote start used. I submitted claim promptly with insurance. Have appointment with Service King for estimate and repair to be made. According to online forums, this unfortunate safety incident with Ford truck and van rear windows has occurred hundreds or thousands of times to Ford owners over the past 10 years.

My transmission started slipping and went completely out on a 2 lane busy highway. I had and still have NO transmission. I've driven mostly highway miles. No towing. Done all the proper maintenance. I now find out via my regular mechanic and subsequently checking the the internet that Ford F150 models 2017 - 2019, 10 speed transmission have had this problem including hard shifting (which I experienced) slippage of transmission. And to add to my frustration....the shops tell me....Ford needs to fix the issue and it will never be fully fixed. Regardless, most Ford shops want nothing to do with fixing the problem. I've only been able to get one shop, Larry Miller Ford in Lakewood....yes one to call me back and I have to wait over a month. So, I am having to rent a car to get to work....which costs me $1,200. And Larry MIller already told me....yes, this is a common problem....the fix will likely be between $ 900 to $2,000 fix. And NO....even though it's a common problem on Ford 150, Ford is NOT doing a recall. Come on....do your job.....put pressure on Ford to do a recall.

The transmission failing slips out of gear randomly when accelerating from a stop. Extremely long hard shifts that make the slam the vehicle forward. On occasion it will fail to downshift at all while braking, this has created several near miss accidents because of zero acceleration. Example being a on 55mph road, having to slow drastically or stop (truck was in 5th gear needed to be in second or 1st due to speed) .car in front of me turns causing a braking situation (not stopping) but leaves me and my family vulnerable to drivers approaching from the rear . If the road is wet, and the vehicle randomly drops the gear, in turn causing the vehicle break traction At random times. When attempting to pull out from a stop sign or a side road if the transmission slips or stutters and there’s oncoming traffic, there is a strong chance of being involved in an accident.

Wheel lug nuts swollen and impossible to difficult to get all off vehicle with supplied wrench.

Vehicles rear passenger brake light does not work when hitting brakes but lights up when vehicle is on. The blinker does not work but the reverse light does. Vehicle has a short somewhere and has put me at risk of being rear ended by others and I have drivers on the road notifying me on the daily. My vehicle is covered under CPO (Certified Pre-Owned) and only has 46k miles and well taken care of. Ford has not inspected it due to an upfront cost that I am expected to pay. The vehicle did not warn me of any electrical failures. I was notified by a friend that it was not working.

The contact owns a 2017 Ford F-150. The contact stated while driving at various speeds, the steering became difficult to turn. The contact stated the track assist and the hill descent warning lights were illuminated. The contact took the vehicle to the local dealer, where it was diagnosed with needing the gear assembly to be replaced. The vehicle was not repaired but was pending the repairs. The manufacturer had not been informed of the failure. The failure mileage was 93,926.

If vehicle is locked overnight it is impossible to open back doors until vehicle has warmed up. Vehicle left unlocked overnight had doors fly open at traffic light.

About a month after purchasing the truck in April 2021 with About 35,000 on the truck when stopped at a traffic light the trucks auto stop/start kicked in and the vehicle would not restart and had to be pushed out of the road during rush hour. Since then the truck has been in the dealership atleast 5 times for this issue and has not been resolved. They keep giving the truck back saying they don't know

Problem started in May 2021 at about 70,000 miles. Initially truck would idle rough at stop lights, stop signs, and when parking RPM dropping to 500 not all the time. Then in August 2021 progressively got worse and even started idling rough and stalling at intersections, stop signs, and parking. When there is a lot of moisture in the air it is worse. One rainy night it stalled at three intersections in a row. You have to put vehicle in park and put some pressure on gas pedal to keep RPM's up. Someone is going to get hurt very bad in a accident or on the freeway from these trucks stalling out. My truck is currently in the dealership and they are initially saying they see no issues as there are no codes. Online there are many many of the same issue reported. All with the exact same characteristics of rough idle then stalling and no codes or check engine light.

Check engine light on error code P2007 Runner control was replaced via Ford OEM PART #FR3Z 9J559 C Ran well for 2 days then stopped working.

Lug nuts are swollen. Dealer told me they needed to be replaced at a cost of $160.00. Not covered under warranty. Correctly made lug nuts do not need to be replaced. ALL tire changed and rotations have been done by FORD.

The contact owns a 2017 Ford F-150. The contact stated that the vehicle would hesitate upon startup without warning. The contact had initially taken the vehicle to an independent mechanic where the engine shut off while performing a test on the battery. The mechanic discovered that the negative lead cable had become defective. The mechanic performed a temporary repair and instructed him to take the vehicle to the nearest dealer for repair. The contact took the vehicle to a dealer where it remained in their possession and was not yet repaired. The manufacturer was notified of the failure and informed him that there were no recalls on the vehicle. The failure mileage was approximately 55,000.

I started my truck with my remote starter. After letting it run and warm up for a couple minutes, we opened the doors to find cab filled with smoke. I immediately shut off the truck. I than let it air out for a few seconds to see where the smoke was coming from. I seen from standing by driver door it was smoking from behind the rear passenger seat as I run around front of truck to passenger door I hear the rear back window shatter

Rear defroster started smoking during morning warm up using remote start. Rear windshield was shattered violently. Very dangerous situation to be in. The shattering happened during a drive.

The contact owned a 2017 Ford F-150. The contact stated that while operating the vehicle, smoke and heat were suddenly present inside the cabin of the vehicle. After exiting the vehicle the fire department was called to the scene and extinguished the flames. During the incident, the vehicle was destroyed and towed away. The contact indicated that the flames had started behind the front seats inside the cabin of the vehicle but the cause of the fire was not determined. The manufacturer was notified of the failure. The local dealer was not contacted. The failure mileage was 47,000. THE CONSUMER STATED THERE WAS NO POLICE OR FIRE REPORT, BUT BOTH ARRIVED AT THE SCENE. THE CONSUMER SUFFERED FROM 3RD DEGREE BURNS ON THE ARM.

Unable to remove lug nuts with provided tire tool. Took to Gary Yeomans Ford in Daytona Beach, FL. Was informed that my Lugnuts where Swollen and needed to be replaced. Paid $96 + tax for this repair.

Steering keeps on vibrating… feels like the whole truck is bouncing. Have done multiple alignments, rotates, balances, tire replacement and nothing has worked the steering gets very stiff around 70-80 mph and rides smooth then bumpy over and over , riding bumpy most of the time it’s on and off and it has nothing to do with what speed I go above 65-70 mph making me swerve and jerk the truck repeatedly. Also truck tends to vibrate obnoxiously at an idle almost like it’s going to die on me, I noticed this happening in drive when I come to a stop it stutters and almost dies… it has died 3 times on me now and have got 1 check engine light that has disappeared.thinking this may have something to do with the steering vibrations.

While driving my vehicle the rear driver's side window completely shattered for no apparent reason. Weather conditions were clear and temperatures were mild (80 degrees). If a passenger would have been in the back seat at that time there could have been serious cuts from glass shards. I have an appointment on Sep. 28, 2021 to have the window replaced by a independent service center.

I purchased this vehicle new in 2017 and since then I have had an intermittent issue with the rear camera when put into reverse. Either frozen image, static lines and yellow screen. When the image it frozen, it looks like its working but nothing in the screen is moving. If something is behind me I would not see it and think its clear. Ford has replaced the camera 1 time but I dont think thats the issue because I disconnected all the wires in the tail gate (where the camera is) and it still messes up. I have seen online a lot of other people with the same truck and same issue. here is a video of my issue. https://www.youtube.com/watch?v=xAx6haPQ8Ho

Went to change tires on 09/18/2021 @ Discount Tire and found that the rug nuts on wheels are swelled. In order to replace tires, I had to buy new sets of rug nuts. Ford sold its BEST SELLING trucks with defective/deficient rug nuts.

Had tire failure on interstate 59 in Alabama. Went to change tire on truck and found lug nut wrench would not fit any of the lug nuts. All lug nuts distorted. Alabama State Trooper came to assist. He had a an electric impact wrench with multiple sockets and found an oversized socket and proceeded to remove lug nuts. Called local Ford dealership ( Cleveland Tn.) that has performed 100% of service on my truck since purchase And was told that lug nuts were swollen…. Asked service manager if they check lug nuts during tire rotation, and was told they inform customers if they need to be replaced.. Asked why I wasn’t informed… Also, is it reasonable to expect a lug nut wrench to fit in a roadside emergency? Replied that other auto manufacturers have the same problem.. Apparent design issue. Two piece hollow cap design hex collapses / distorts when torqued. Service techs just move to a larger socket which further distorts during impact wrench torquing.

The contact owns a 2017 FORD F-150. The contact stated that the rear glass sliding window had become defective due to the sliding track. The contact also stated that the top track had detached from the window which allowed moisture to enter the cabin of the vehicle. The contact had taken the vehicle to a dealer and was given an estimate for the repair of the window. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 28,000.

Oil pan is leaking TSB 20-2051 superceeds a previous TSB. After searching online this is a known issue acknowledged by the mafacturer affecting numerous vehicles that should be covered through a manufacture recall. The latest TSB states to replace the plastic oil pan with with a metal oil pan. This is an obvious manufacturing defect that consumers should not have to pay to repair.

Eastbound I-94 around Burns Harbor, IN. High speed, high density traffic. High temperature warning illuminated on dash while the temperature gauge went to full cold. Within seconds the engine lost power, forcing me to navigate to the shoulder of the highway. I was successful, but the loss of power and the resulting speed differential put myself and other traffic at a significant risk of collision. The vehicle was shut down and checked for any signs of overheating. With no signs of overheating the vehicle was restarted and we continued to our destination. The following day the problem was diagnosed by Castle Ford, Michigan City, Indiana as a faulty cylinder head temperature sensor; there was not a problem with high temperature. The sensor has been replaced and there has been no further issue.

Slopping shifting. Lunges forward at slow speed shifting. Hard down shifting at times.

2017 Ford F 150 5.0 6 speed 4x4 transmission failed at 93000 miles in February 2021. Torque Convertor was replaced. August 13 2021, vehicle went into limp mode at highway speed and slammed into low gear causing a sudden slow down on the interstate. Wrench light was on and no gear selector indicator working. Was able to drive to dealership for diagnoses but no time availability until October 2021 or mid November 2021. Vehicle towed to AAMCO and diagnosed with Range Sensor Issue. Cannot order part due to being on back order. Suggested repair is full remanufactered transmission with 3 year 100k warranty. Vin number is not identified as being part of latest TSB or EXTENDED WARRANTY COVERAGE FOR THIS ISSUE.

Why is nothing being done with the ford 10R80 transmission and the shifting issues. I would hate to have my transmission lock up on the highway, because ford says it's normal for the loud clunking and banging when is shifts I see there are many class action suits involved in this issue but still Ford is doing nothing

My safety was put at risk when the the truck would not start after stopping at a light. This happened three times. The last two times on July 18th and August 11th, after shutting off the truck would not restart and the speed limit on each road is 45-55 mph. Police had to come block the road because it was unsafe. The dealer took the vehicle in on Aug 2-6th and advised that it was fixed, only for it to happen again on the 11th. No warning messages were present.

I was driving my vehicle stopped at a red light the light turned green I started to go through the intersection and when I got halfway through the intersection a loud clunk stopped my vehicle in the middle of the intersection I almost got rear ended and then I shut my vehicle off I started it back up and it kept lunging forward the transmission was having issues

My son, Marine LCpl Ryan McCoy, was driving on I95 in Virginia back to Camp Lejeun when he heard a “pop” sound. Assuming something was wrong, he pulled over to the breakdown lane. The vehicle began to smoke and the temperature gauge shot up to the hottest it could register. At that time, he turned off the vehicle and exited. He noticed the front of the vehicles so in flames and began to run away from the vehicle and saw the vehicle violently explode. He called 911. Stare Trooper Joseph Worley arrived and he called a tow truck. When the fire went out, the trooper left without checking to see if Ryan was okay or had a ride anywhere. The tow truck dropped Ryan at the nearest rest stop and the tow truck took the vehicle to Interstate Garage.

Intermittent wipers do not shut off.

The 10-speed transmission has had issues smoothly transition gears since I acquired it in early 2017. For years I have dealt with constant rough shifting, random clunking while driving at low speeds but now the issue seems to have progressed to the transmission sticking at higher speeds. I was driving recently at about 45mph and rpms just started roaring and it would not transition gears. The truck was in drive when this happened. When it finally did grab there was a hard thrust and threw the vehicle forward. These issues are present all of the time. Every time I put it in gear there is a clunk and a thrust. I have had the truck into the dealer numerous times over the 4+ years only to be told it was the adaptive transmission trying to learn how I am driving. Now, the dealer is so backed up with transmission-related issues they require you to leave your vehicle for 7+ days before they can even look at it leaving the consumer stranded without a vehicle. They should have all of the service records.

Steering Assist was once again disabled within a week after the last incident with Steering Assist Caution advisory. This time it almost caused an accident. Steering malfunction happened right at the moment while making a left turn at the inside lane of an intersection. While the steering wheel was turned left to negotiate the turn, the steering became stiff and made the vehicle encroached on the outside lane. Applied brake immediately and forced steered vehicle back to inside lane.

Power steering becomes non-functional and " Steering Assist Fault Service Required" warning is displayed. Happened three times, twice within (Odometer reading) 44410 miles and again at 44951 miles. The vehicle is difficult to steer and can cause accidents especially during high speed on highways. The problem eventually goes away after letting the car rest with engine turned off for a while. The malfunction does not produce fault code and dealer is not able to troubleshoot/replicate.

The contact owns a 2017 Ford F-150 equipped with Cooper Tires, Tire Line: Evolution H/T, Tire size: 275/65/R18, DOT Number: 3018. The contact stated that the driver’s side tire had started to form air bubbles on the sidewall. The contact took the vehicle to the local tire repair shop and was informed that the tire could blowout, and needed to be replaced. The tire was replaced. The manufacturer was not made aware of the failure. The failure mileage on the vehicle was 117,000. The tire failure mileage was 50,000.

Transmission was shifting erratically, making it difficult to keep the proper speed on the thruway. Once I was able to pull over, the reverser gear stopped working, creating a hazard while I was trying to park in a busy parking lot. I am taking the car in this week to see what the issue is.

The contact owned a 2010 Newmar Essex RV hauling a 2017 Ford F-150 Raptor. The stated that while driving at 60 mph, he was alerted by another driver that the 2017 Ford F-150 Raptor, had caught fire. The contact stated that the fire started from the hood and grille assembly of the vehicle. The contact attempted to extinguish the fire with a fire extinguisher, but was unsuccessful. The fire engulfed both vehicles. The fire department was able to extinguish the fire. A police report and fire department reports were filed. No medical attention was received however, the contact stated that his cat was injured. Both vehicles were towed to a wrecking yard and was deemed totaled by the insurance company. The vehicles will later be towed to salvage yard for the insurance company to perform an investigation. The dealer was made aware of the failure. The manufacturer was made aware of the failure and a complaint was filed with the manufacturer. The failure mileage was 45,846.

FORD F-150 MOON ROOF RAMP/GUIDE JAW (PART # FL3Z1651070B/FL3Z1651071B) STOPPED WORKING. THE MOON ROOF MALFUNCTIONS GETTING SUCK IN THE OPEN MODE, OR FAILING TO CLOSE PROPERLY IF AT ALL. MANY FORD OWNERS HAVE EXPERIENCED THE SAME ISSUE, TO THE POINT THAT THERE ARE VIDEOS ON THE INTERNET PERTAINING TO THIS MALFUNCTION. WHILE ATTEMPTING TO GET THIS REPAIR FIXED AT THE FORD DEALERSHIP THE EMPLOYEES ADVISED ME THAT THEY SEE THIS ISSUE OFTEN, AND THAT THE GLASS SHATTERS AND BREAKS FROM THIS MALFUNCTION. I WAS QUOTED $400.00 TO REMEDY THE ISSUE, AND WOULD HAVE TO LEAVE MY VEHICLE AT THE DEALERSHIP FOR THE DAY. THE ESTIMATED TIME TO COMPLETE THE REPAIR WAS FOUR HOURS.