2017 Ford F-150 complaints

The contact owns a 2017 Ford F-150. The contact stated that while reversing out of his driveway, the brake pedal went to the floorboard while depressed with brake fluid leaking onto the ground. The vehicle was towed to the dealer where it was diagnosed that one of the brake lines was leaking and the other brake line showed a bulge. The dealer informed the contact that the brake lines needed to be replaced. The vehicle was not repaired and remained at the dealer. The manufacturer was made aware of the failure and informed the contact that there was no recall associated with the VIN. The failure mileage was approximately 88,000.

The truth caught on fire driving down the road with passengers. It started on the passenger side and engulfed the truck. Insurance is investigating it.

The truck uses start stop technology. When you start to move after it has stopped the power steering does not start working initially making turns nearly impossible. Once the power steering builds pressure it returns to normal steering. This has occurred multiple times and seems to get worse as the truck ages.

The issue starts with a check engine light that gives an error for the bank 2 being stuck closed. This issue is with the intake manifold that is equipped and what happened is that the pin that is in the bank 2 is weak from the stamp that the manufacturer puts on it which eventually causes it break. Once it breaks it causes major safety issues while driving down the road, it sends codes that the motor is overheating although it wasn’t. So when that happens it causes the whole truck to shut off unexpectedly. When looking to get this repaired, you have to replace entire manifold on the truck; and there are not parts available to purchase for this issue. This is a common occurance for that model and engine and at this time my truck has been in drivable and unrepairable for 4 months.

1. Torque converter failed per Ford Service Technician. 2. My safety is more mental of not knowing if this will lead to a complete mobility failure while traveling and be stranded. 3. The problem has been reproduced by a certified Ford Service Technician at Crossroads Ford of Sanford NC on 07/06/2022 4. The truck was inspected and diagnosed by by a certified Ford Service Technician at Crossroads Ford of Sanford NC on 07/06/2022 5. There was no warning lights of the issue. The issue began approximately in February 2022. There's a jerking motion sometimes at takeoff from a dead stop as well as a slow roll and excelleration. There's a rumbling /shudder when excellerating even at 55 mph .

Incident x2: When coming to a stop after towing, once on the off ramp and the other at the gas station, the truck died/stopped running and would not stay started when trying to restart. Both times, the gas tank was at 50 miles to empty, and while in tow mode, towing a camper trailer. First time we had it towed to dealer, they found nothing wrong, no faulty codes. Second time, after fueling, started the truck and pressed the gas pedal for about 10-15 seconds to RPM at 4000 then let off gas and truck stayed running. Seems something in the gas line, tank or computer system. Does not happen when not towing.

Vehicle: 2017 Ford F150 10 speed transmission 3.5L engine I was driving on Route 22 Westbound toward Pittsburgh, within Weirton city limits. The speed limit is 60MPH and I was traveling at 60MPH when truck (unprompted) switched gears to 1st gear. This caused the truck to lunge to nearly a complete stop on the highway with NO warning or brake lights. Only by God's grace did my family survive. I have contacted local Ford garage for service. I am afraid of the cost, as I believe the transmission shredded itself with this unprompted and dangerous shifting of gears. I am contacting you to report dangerous product. Please recall this death machine.

The first time I had a problem was after refueling the gear display went blank and as I started to drive it felt like the truck was not in 1st gear. I stopped turned off the truck and restarted and it was OK. I took it to my mechanic and he did a diagnostic which showed error codes p0706 p0707 p1702 and p1721. He couldn’t replicate the problem and thought is may have been a moisture problem since we had been getting heavy rains. The next time it happened it happened I was on I195 in Richmond driving at 55 mph and the gear indicator lights flickered and then went off and the truck downshifted and slowed suddenly. The indicator lights came back on quickly and everything was fine. I went back to the mechanic and he got the same error messages. It was not raining this day

On two occasions, my 2017 F150 failed to restart after the auto stop/start shut the engine off. April 29, 2022, I stopped at a crosswalk to allow pedestrians to cross. My truck auto stop engaged and the engine stopped. I took my foot off the brake peddle to continue driving and my truck would not restart. Error messages flashed telling me to restart my truck. After attempting to restart my truck, nothing happened. All electronics continued to work (radio, air conditioning, power windows, etc.); however despite numerous attempts to restart the truck, it would not restart. Three pedestrians had to assist by pushing the truck off of the street to a parking lot as it was blocking the flow of traffic at a very busy intersection. As I sat waiting over two hours for a tow truck and periodically attempted to restart the truck, around 2 1/2 hours later the truck restarted and I drove it to the dealer. The dealer noted that the truck may have restarted since it "had time to reset". The dealer checked the truck but could not get it to replicate the problem but did note an error code of p164c. They made no attempt to offer any solutions or probable cause for the issue. We continued to drive the truck and had the auto stop/start issue repeat itself on May 8, 2022. The same scenario happened where the truck went into auto stop during a complete stop and failed to restart. Again, the truck was on an open roadway and impeding the flow of traffic. After numerous attempts to restart the truck,

Check engine light came on, took car to certified Ford dealer and found out the intake manifold gasket was cracked. A cracked intake manifold gasket results in poor engine functioning as well as negatively impacts accelerating, endangering both the occupants of the vehicle and those around. This part is on backorder with Ford for over 1400 customers, we are the 1400th so who knows how many in total are actually affected. Ford needs to be held responsible for this faulty part.

I believe the APIM has failed and I'm only at 54000 miles. My Sync 3 is stuck on version 1.0 and CANNOT be updated to the current 3.4 system.

Hard shift “clunk” transmission, most often when decelerating low speed, gears 3-5. Happening since I purchased the truck. Risk is the truck lurches or slows, leaving the driver unsure of next operational behavior. I have had the transmission oil and filter replaced, which did not resolve the issue. Took to Ford garage and unable to replicate but have heard of this issue from other 10-speed owners. My truck has not been inspected by a regulation body. Anyone like myself that would drive my truck in normal conditions would find this issue, while random it’s still present. I am concerned about my safety, my wife who drives and resale. I receive no warnings lights or any indication the issue is about to happen or just did. Very concerned.

The contact owns a 2017 Ford-F 150. The contact stated that the vehicle was taken to a dealer for an unknown recall, where it was confirmed that there was a loss of motive power without warning. The local dealer attempted to repair the failure; however, was unsuccessful. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 85,000.

Lug nuts swollen and needs to be replaced

The engine formed a premature oil leak around the oil pan.

The contact owns a 2017 Ford F-150. The contact stated while driving 70 MPH, the air bag warning light illuminated. The vehicle was driven to the dealer. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 91,300.

Second time this has happened to my truck. First time was in 2020, now it just happened AGAIN in May 2022. Rear window in Ford F150 suddenly popped and shattered for no reason because the defrost mechanism malfunctioned and over heated causing the rear window to expand and shatter. The shattered window was hot to the touch after shattering and there was an electrical fire smell in the cab of the truck. The first time Ford gave me a case number but blew me off and I had to pay out of pocket. This time I have a case number but it is still a hastle and I am getting the run around and am hoping Ford pays for the window in full this time as they did not follow up or give me a reimbursment last time this happened. Ford has a big problem on their hands and needs to remedy this before someone gets glass in their eyes driving down the freeway after the window pops and someone gets killed in an accident.

The engine rattles on cold start. It has been diagnosed with a cam phasers failure issue. The truck has 74000 miles on it and has had regular maintenance. This is an ongoing known issue with Ford and this engine. How has Ford managed to get away with not having a recall for this?

SWOLLEN LUG NUTS HAD TO BE REPLACED BEFORE THEY CAUSED A SAFETY ISSUE

I brought my ford in to have tires rotated and they were unable to do because ford installed factory lug nuts are distorted. I brought my truck to a reputable tire shop and they told me it is a common problem on Ford F-150 from 2016 to present. I ordered replacement lug nuts to remedy the problem. I am saving the old lug nuts in case I have to take them to small claims.

The ABS and Traction Control lights came on. Then out of no where the Power Steering just stopped working.

At 56,000 miles Anti freeze started to disappear from reservoir. After refilling it, noticed 2 weeks later an empty coolant reservoir again. Truck gave a "misfire" and "turbo charger " code. 8 weeks later truck had cylinder heads replaced.

Safety Concern: Potential engine failure at speed. Cam Phasers cause loud rattle on cold start. Sound is alarming, as if the engine will fail. Engine light came on, dealer tested and recommended cam phaser repair & replacement. FORD would not pay for repair b/c mileage over 90K. I paid for 1st repair 11OCT2019, failed 2nd time 09Nov2020, Dealer repair under warranty. Received letter from Ford "Customer Satisfaction Notice: to have Powertrain Control Module reprogram, completed 17NOV2021. Engine rattle on cold start occured 3rd time, Dealer told me I'm on a waitlist in Jan2022. Notice to bring vehicle in, 9May2022 for diagnosis, same problem. Ford Customer service contacted twice, Ford refuses to repair again under warranty. Told me to file this complaint. Dealer would not repair under warranty, because Ford will not cover 2nd repair. Dealer told me there is nothing they can do and referred me to file this complaint.

Merging on interstate in heavy traffic when transmission would not shift out of 1st gear, traffic was heavy and I had several really close calls of getting run over. The dealership service manager (Supreme Ford Slidell,La.)said the transmission control module is bad. Repair cost will be $1,858.00 and no recalls on my vehicle. I’ve had Ford trucks all my adult life and I’m severely disappointed with this issue

The contact owns a 2017 Ford F-150. The contact stated while starting the vehicle, the vehicle experienced engine failure. There were no warning lights illuminated. The vehicle was diagnosed with cam phaser failure. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 71,300.

I was making a turn on a curve in the roadway and truck lost power steering, causing me to fight the steering to keep it in my lane so I didn’t hit the car in the other lane around the curve. Call dealership and I was informed that that it would be over a week or so before they can even schedule me in for an appointment. Took to another shop and they said racks piñon. Be said it could be power steering control module’s

On 4/1/22 while driving the rear glass exploded. There are many reports of this issue online. the vehicle was in a perfectly flat road with no holes and for no apparent reason it just exploded with a very loud bang. Thankfully this happened in a 40-mph zone, i can only imagine what would happen if this occurred at a high rate of speed. this vehicle is not used as a commercial vehicle, and we don't off road...

Bought vehicle used 9 months ago and had no problems, warning lights or malfunctions prior to incident 3/9/2022. Driving 50 mph in 5pm rush hour when automatic transmission of 2017 F-150 suddenly decelerated. It downshifted hard on its own and slowed to 25 mph on a busy one-lane interstate entrance ramp. It then lurched forward violently and accelerated back to 45mph. Fortunately, the driver behind me was alert and did not slam into me. The gear selector indicator became non-illuminated, transmission gear display disappeared, plus orange wrench check engine sign appeared on dash display. Those displays then intermittently come on/off every few miles. Vehicle managed to maintain modest highway speed however engine was very loud, revving high rpms at slower speed on side streets. Limped home and shut vehicle off. Tried to restart hoping computer would reset but nothing engaged. There was charge/lights but no crank or start; truck didn't even attempt turnover. Vehicle towed to Bob Allen Ford in Overland Park, KS. Was told 'range sensor' in transmission failed which informs vehicle when and which gear to be in. That part sits inside of a 'lead frame' however, unless repair was for covered warranty period Ford was not making it available to dealers. Was told this is known issue with F-150s and earlier models (2011-2013) had been recalled. Service Advisor had to secure another more expensive component called 'body valve’ that contained both aforementioned parts and cost about 3x th

What compontent: The lug nuts on my Truck swelled and are distorted so at risk of cracking. I couldn't get them off when i had a flat tire. It is available for inpsection. Safety: Safety put at risk 1. i couldn't change my flat, and couldn't tightne them correctly when i DID force it and 2. they are at risk of cracking, they ahve deterioated so wheels at risk of failing. Inependent verification: Costco changed my tires and noticed the issue, having to use other size sockets bc they were swelled so much. Warnings: No warnings or anything as purely mechanical/steel parts. You only know when you try to take ethe tires off, you think the jack is the wrong size. Its messed up how big they got. its ALL OF THEM. These SUCK. dealers so no recal so to be safe i guess I have to buy new ones and replace (Parts AND labor). Thank you

Rear window spontaneously burst no apparent reason everything for that started bulging and then big loud boom

On my 2017 Ford F150 I have had repeated issues of delays when changing gears. In the past the dealership has replicated it and has uploaded several updates and even reset it which helped for a while but it always comes back. Going from 3rd to 4th gear is the current problem and when pulling out on a highway going 0 to 55 you cannot have your vehicle stall like this. The risk of being rear ended or worse is great. The dealership acts like they have no idea why this happens and cannot replicate the issue. It does not happen everytime and seems random so I have no idea how to get it to replicate. Very frustrating and unsafe. The vehicle does not show any warnings and the dealership says the diagnostics do not show an issue.

Shift indicator light will flash and go off. Check engine light and wrench light comes on for coded P0706, P0707, P1702, P1921. U0401. Needed range sensor. Shifted when it wanted to and quit altogether then start back up. Had range sensor replaced.

I previously had my door modified per Manufacturer Communication Number: 21M04. This past winter (Feb 2022) my family and I were vacationing in Vermont when it rained and then flash froze. Understandably the water had frozen on the door seals, making the doors difficult to open. However, the drivers side door would not latch shut for hours until the truck warmed sufficiently from the sun exposure and heater run on high. Unacceptable safety hazard rendering my truck un-drivable. (The other 3 doors worked fine.)

I HAD TO REPLACE DEFECTIVE (SWOLLEN) LUG NUTS ON MY 2017 FORD F-150 PICKUP. THIS ISSUE WAS IDENTIFIED BY THE LOCAL FORD DEALER. COULD HAVE CAUSED A SERIOUS ISSUE HAD THEY NOT BEEN REPLACED.

The wheel lugs have seized and are unable to be removed with a tire wrench or impact wrench. This is a huge safety issue as the driver is unable to change a flat tire. The dealer informed me the lugs are made of aluminum and are subject to overheating and corrosion. I was informed the lugs are a two-piece set and have to be replaced and need to be cut off with a cutting torch. Ford is aware of the problem, however, dismisses a recall because they say the dealer service centers are using the wrong tools. The problem is the lugs are inferior metal and easily swell up and seize. Ford has used aluminum lugs since 2000. Since a driver can't change the tire this vehicle needs to be towed. Not being able to change the tire is a huge safety issue.

The contact owns a 2017 Ford F-150. The contact stated while driving 80 MPH and depressing the brake pedal, the brake pedal was soft. There was no warning light illuminated. The vehicle was taken to the dealer to be diagnosed: however, the results were not yet available. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 74,862.

There has been a recall on the Transmission's Lead Frame for certain years of the F150 with the 6r80 transmission. I have that same exact transmission in my 2017, and I am now having the same exact problem everyone else is having with that Lead Frame. But according to Ford due to the year of my truck I am not a part of that recall. So now I have a truck I am paying for that is not working and the part that I need to get it fixed is on back order due to the recall. So how is it that I am having the same symptoms and the same recalled part needs to be replaced but my truck is not covered by the recall. That does not make logical sense at all!

Cam Phasers are failing and causing engine oil pressure to fail as well as timing to jump. This is a major concern and can cause a serious accident if a engine seizes. Ford did not issue a recall but if you bring it in then they tell you. was never notified of issue and now that i am over 90,000 miles it is no longer warrantied. they do a reprogram but it makes the issue worse.

The contact owns a 2017 Ford F-150. The contact stated while driving at 45 MPH, the vehicle stalled. The contact stated that the check engine warning light was illuminated. The vehicle was not drivable. The vehicle was towed to the contact's residence. The vehicle was then towed to an independent mechanic where it was diagnosed that the fuel tank needed to be replaced. The vehicle was not repaired. The local dealer was made aware of the failure. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 60,000. Consumer would like to cancel the complaint in having a second opinion, fuel tank collapsing was inaccurate.

The Cam Phasers have failed. I have done all the Computer resets, both did not work, the truck is supposed to have them replaced. I have contacted Ford Customer service to no avail. The simply do not return my calls. I have left numerous messages regarding the delivery date for the parts necessary to replace my Cam Phasers. The vehicle has not caused a safety issue yet however the problem seems to be getting worse leading me to believe it will become unsafe to drive. Byers Ford Dealership has confirmed the problem however they have no idea when the parts for the cam phasers will be shipped. The Check Engine light came in August or September of 2021. I had this checked by an independent mechanic as well as the Ford Dealership. The problem as I see it is Ford has had a problem with their Cam Phases since 2005 and has done little or nothing to correct the problem. A little research and you can find out the the failure rate for Cam Phasers is around 40%. Seem to me NHTSA should have forced the manufactures to correct this problem a long time ago. It appears you are allowing the manufacturers to sell vehicles that have little value after the cam phasers fail as the replacement is not a permanent fix.

Drivers side door does not latch after rain and a freeze. This has happened 3 times. Today was the first time the passenger side door flew open while driving. It seems to be fixed when the car heats up. There was a recall on other versions of the F-150 for this exact issue but apparently not on this one. It seems to have the same issue.

DRIVERS DOOR FREEZES UP. WHEN YOU DO GET IT OPEN, IT WON'T LATCH SHUT

Rear window shattered with defrost on.

Plastic oil pan has leaking drain plug even after installing new drain plug. This is a danger to the environment and roadways due to leaving oil drips throughout the roadways traveled.

2017 FORD F-150. CONSUMER STATED THAT TIRE ROTATION WAS NOT PERFORMED PROPERLY. THE CONSUMER STATED THE DEALERSHIP REFUSED TO ROTATE THE TIRES DUE TO THE AGE OF THE TIRES AND DAMAGE IT MAY CAUSE. THE CONSUMER STATED THE VEHICLE WAS UNDER WARRANTY AND THE TIRES SHOULD HAVE BEEN ROTATED. THE CONSUMER REQUESTED THE PORTION OF THE POLICY BE CHANGED THAT PREVENTS THE TIRES FROM BEING ROTATED IF THEY ARE OUTDATED. THE MANUFACTURER WAS NOTIFIED.

The truck will stall while sitting at a stop sign, red light, waiting to turn. You can feel the truck idle and watch the tac bounch up and down before it stalls. Wants to stall when the gas is applied while pulling across an interseciton or from the stopped position. Intake manifold has been replaced twice in a 2 month period. The intake manifold caued the check engine light to come on, but did not correct the stalling issue.

The contact owns a 2017 Ford F-150. The contacts stated that his wife was driving approximately 55mph when the vehicle in front came to an abrupt stop and the contact crashed into the other vehicle, which resulted in the air bags not deploying. The contacts sought medical treatment and sustained abdominal, wrists chest injuries, while the wife sustained chest, side, back, and stomach injuries. The contact's son was sitting in the rear passenger side seat and also received chest and stomach injuries. A police report was taken, and the vehicle was towed by the city and remained in their lot. The manufacturer was not informed of the failure. The failure mileage was approximately 103,000. The VIN was not available.

While driving my vehicle I began to notice a clicking noise in relation to my tires/speed. No sensors came on, all gauge readings were normal. I pulled over and viewed the tires to check for a flat, all seemed fine and pressure was reading normal. When I resumed driving, I came back into my lane turning slightly left and noticed that the steering wheel began to vibrate. I slowed the vehicle again and put on my hazard lights while attempting to reach a freeway exit. The vehicle began shaking as though I had a flat but again I did not. I decided to turn off an exit and when I attempted to make a left turn into a parking lot, my front passenger wheel flew completely off. My two four year olds and I were then left without control of the truck, finally grinding to a stop blocking two directions of traffic on a Highway unable to get out of harms way. It was night, cars were coming in either direction. I had to emergently remove my children from their car seats and get away from the vehicle to safety. The lug nuts/bolts were completely sheered off. The wheel flew into a field several yards away from the vehicle. If I would not have exited the freeway, I shutter to imagine what would have happened to us as other large trucks would not have been able to stop at the rate that we were forced too. Please. This vehicle/part needs an official recall!

Transmission slipped out of gear on numerous occasions during a clattering sound. Good thing it has not happened yet when pulling out into traffic. It happens most often between 2nd and 3rd gear when starting out.

While attempting to accelerate from stop, vehicle would not accelerate. Vehicle was stuck in 7th gear and did not have enough power to accelerate through intersection. Cyclic vibration while maintaining constant speed. No vibration when coasting. Erratic shifting that causes jerking motions during gear change.