2017 Ford F-150 complaints

Tapping noise coming from 5.0 engine from cold start. Ford dealership concluded it was a Cam Phasers that needed to be replaced

The contact owns a 2017 Ford F-150. The contact stated that while driving in cold weather, the vehicle had experienced extremely hard shifting and jerking. The contact indicated that the transmission had erroneously shifted from first gear to third gear causing the RPM's to increase and the vehicle to jerk and the transmission had erroneously shifted from seventh gear to first gear and back to seventh gear. The cause of the failures was not yet determined. The manufacturer and local dealer were notified of the failures, but no assistance was offered. The contact was informed that the VIN was not included in the extended coverage for the failure. The failure mileage was 50,000.

The contact owns a 2017 Ford F-150. The contact stated that after the vehicle was started, the vehicle was idling roughly. In addition, the contact stated that there was a rattling sound coming from the vehicle. The vehicle was taken to an independent mechanic where it was diagnosed with timing chain failure and a fractured timing belt adjustor. The contact was informed that the timing chain needed to be replaced, and the adjustor needed to be tightened. The vehicle was not repaired. The dealer was made aware of the failure. The vehicle was scheduled for an upcoming diagnostic test. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was unknown.

The contact owns a 2017 Ford F-150. The contact stated that while driving on three occasions at various speeds, the vehicle failed to shift gear properly and the vehicle lost motive power. The contact stated that the power train warning light was illuminated. The vehicle was taken to a dealer where it was diagnosed that the molded lead frame needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 43,000.

2017 F150 transmission 10R80 started failing at 80K miles and completely failed at 113K. Dealer was asked to inspect the transmission but they misdiagnosed it. It is available for inspection until it is returned to Ford as part of complete swap\core charge. In the beginning the hard shifting did not put occupants at risk. As the transmission continued to fail it did put occupants and others at risk. Is would loose power/not respond to accelerator. Hunt for gears, shift from high gears to low gears while moving. Shifting to 1st gear while traveling at 45 miles per hour. Several times it would start to move from a stop but then not continue to move forward (in heavy traffic) The dealer miss diagnosed the problem and severity at 90K miles. They told me the transmission would continue to have firmer shifts while it was relearning programing. The dealer diagnosed a complete transmission failure based on codes DTSC P0734 and P07F7 stored in the transmission control module (at 113K miles). Their recommendation is a new upgraded replacement transmission from Ford due to internal failure. Ford Motor has been contacted through the customer service number 800-392-3673. There were no visible warning/check engine lights in the beginning (80K miles). Symptoms included harsh/delayed shift and harsh/delayed engagement. 20K miles later (113K miles) check engine light said to check the owner manual but didn't display codes. Transmission started to severely/erratically hunt for gears. Shift to

The contact owns a 2017 Ford F-150. The contact stated while driving at an undisclosed speed, there was a clanking sound coming from the engine. There was no warning light illuminated. The vehicle was taken to the dealer where it was diagnosed that the cam phasers had failed and needed to be replaced. The vehicle was repaired but the failure persisted. The contact stated that while the vehicle was parked and turned off, the contact was unable to restart the vehicle. There was no warning light illuminated. The vehicle was towed to the dealer where it was diagnosed that the cam phasers had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The approximate failure mileage was 89,000.

Intermittently, transmission violently down shifts around 60 MPH causing deceleration to 40 MPH. Other "rough" shifts are present. Capital Ford of Wilmington NC has assessed the transmission issues. A new transmission was their recommendation. There were no warning lights on the dash board.

Drivers side door will not shut in cold weather. Unlock/lock switch will not work.

My 2017 Ford F-150 demonstrates every single aspect of an existing recall for 2017 F150 vehicles. However my VIN number is not included in the recall. My truck shifts suddenly in and out of gear causing me to have momentary instances of no power. This has happened, for example, turning left on busy roads with acceleration disappearing in critical moments. The vehicle downshifts suddenly on occasion. The gear indicator moves rapidly between gear 10 and gear 1. The vehicle routinely does not downshift to 1st gear at stoplights. The vehicle often shifts hard from gear to gear. The vehicle sometimes cannot go to the next gear, say from 7 to 8, and will be in some version of neutral during this time before finally connecting. Electronic issue plague this particular vehicle. All of these items have been noted in the existing recall. I am requesting an expansion of the recall to include all 2017 Ford F150's with 10 speed transmission. Ford dealer has indicated I need to replace the transmission for close to $10K. And they noted they see this problem constants - showing me a stack of folios in their repair facility for the same reason. The problem has been diagnosed by Ford dealer and an independent qualified transmission specialist shop This is an ongoing issue - per the questions below there is no specific date associated with the issue.

The contact owns a 2017 Ford F-150. The contact stated that while driving at an undisclosed speed, the contact heard a loud knocking sound coming from the engine with the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed and determined that the fuel pump module and the cam phasers had failed and needed to be replaced. The vehicle was repaired; however, the failure recurred. The vehicle was taken back to the dealer where it was diagnosed that the engine had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The approximate failure mileage was 134,030.

I live in a cold climate, WA State, and own a 2017 Ford F150 XLT. On several occasions, both the drivers front door and passenger front doors have opened while driving without activating the door handle. This only occurs when it is wet with rain or snow and below freezing outside. On several occasions, when wet and cold, the doors on this truck will not latch shut as the latching mechanism is freezing on the interior of the vehicle doors. This truck has already been into the Ford dealer and the door recall notice has been addressed and fixed per Corwin Ford. The problem has not been resolved and continues to this day in an extremely dangerous state. I was advised there was nothing else they could do to help the door suddenly and unexpectedly opening issue and that I should contact both Ford and NHTSA. This is a very dangerous situation as my son was driving home from the ski resort, the doors would not latch shut and a passenger nearly fell out of the vehicle. This is unacceptable and extremely disappointing. I feel this safety issue has not been handled by Ford Motor Company and I am very afraid to have my son drive this truck in this dangerous condition. Please contact me regarding this complaint as I can give further details on the issue and send videos of this issue occurring. When this occurs, there are no warning lamps present. Please see the attached repair invoice for the recall notice.

The contact owns a 2017 Ford F-150. The contact lives in a cold weather State, and each winter the driver’s side door latch would freeze and be difficult to operate as needed. The contact stated that a dealer was contacted; however, the vehicle was not taken the dealer to be diagnosed or repaired. The manufacturer was notified of the failure but offered no assistance. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The approximate failure mileage was 97,450.

My 2017 Ford F150 STX with 3.5L Ecoboost engine was recently noted to have a leaking oil pan. I was told by my mechanic that the OEM plastic/composite Ford oil pans have a chronic problem with leaking seals. Replacing with another OEM pan is highly likely to result in another leak down the road. Replacement at my local dealer is in the range of $3,000.00. Even the service representative admitted that this was a recurring problem with these pans. I note that other TSBs have been issued for this problem. According to several Technical Service Bulletins (TSBs), Ford F150 vehicles, particularly those with 2.7L EcoBoost engines, may experience oil pan leaks due to issues with the RTV sealant on the oil pan gasket, often requiring a replacement of the oil pan itself; this problem is most prevalent in models from 2015-2018, with TSB numbers like 19-2205 and 20-2051 referencing this issue.

The contact owns a 2017 Ford F-150. The contact stated while driving at an undisclosed speed, the rear driver's side door glass fractured without impact. The vehicle was taken to the dealer; however, the vehicle was inspected, and the contact was informed that the glass fracture was not due to a manufacturing defect. The vehicle was repaired. In addition, the contact stated that later, the rear driver's side door latch failed to latch as intended. The contact's son inspected the vehicle and noticed water in the door frame. The dealer was made aware of the failure. The contact referenced an unknown recall; however, the contact was informed that the VIN was not associated with the recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 90,000.

The contact owns a 2017 Ford F-150. The contact stated that while driving on the highway at 40 MPH, there was a knocking sound coming from the engine. No warning light was illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed, and the contact was informed that the cam phasers were faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 42,000.

The contact owns a 2017 Ford F-150. The contact stated that upon starting the vehicle, the engine made an abnormally loud rattling sound. The vehicle was taken to the dealer, where it was diagnosed that the cam phasers had failed and needed to be replaced. The dealer informed the contact that the vehicle was not covered under Ford Campaign Number: 21N03 because the campaign had expired. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 68,000.

The windshield was not sealed properly. The primer and glue were applied incorrectly and now has disintegrated over time causing a leak in the area where the pin holds the windshield at the drivers side of the vehicle. From what I understand this could cause the windshield to dislodge in an accident.

The wiring for the rear defrost caught fire. A week later it caused the rear glass to completely shatter. We didn't know it was the rear defrost wiring until we had the glass replaced and were able to see the wires fried. I have farm animals and routinely leave my 3 children in their carseats in the truck with it running when it's cold outside and I feed our animals. If it had caught fire with my kids in the truck I wouldn't have known and they wouldn't have been able to get out. I talked to 2 Ford dealerships, 2 different lawyers and a service rep through Ford's website. Even though this exact issue is everywhere on Ford Forums no one will do anything about it because there's no current recall. The only thing we could do to make sure this doesn't happen again is to pull the fuse for the rear defrost. This is a devastating accident waiting to happen and no one will do anything about it.

The door locks on all four doors keep freezing and will not stay locked. I have to thaw them out with a hair dryer to get them to lock closed. With my kids in the vehicle and driving down the road at normal operating speeds the doors will just pop open enough to hear the road noise outside and the interior lights come on along with the doors open warning on the main dash. My children have to hold onto the door handles to keep the doors somewhat closed until we get to our destination. While this happens I am forced to go lower than normal speed limits and drastically slow down in turns just to keep the doors from swinging open while completing the turns all while my kids hold onto the doors. This is extremely dangerous. But I'm forced to do this as my kids need to get to school and I need to get to work. I have read that Ford has chosen this is not a concern for recall. I feel this should be a recall as peoples lives are at danger of flying out and and the danger to the general public.

This is a MAJOR issue with Ford F150s. I am not sure how this was never a recall. Ford issues a TSB for this but NOTHING is the TSB fixes the issue. There is a major fault in the IWE system that causes the 4x4 to engage randomly causing the truck to have major steering issues. It causes grinding, like metal on metal grinding, the steering wheel locks in place at times and I personally almost dies several times from this.The locking steering wheel caused me to crash into a ditch because I could not bring the steering wheel back to center. This has randomly happened to me several times while driving, The TSB claims the issue to be intermittent, which it is due to the fault in this IWE system. FOrd needs to literally cover and replace the entire IWE system before someone gets hurt. Please look this up, this is a very known issue that deserves to be a recall and not a TSB. Please help save lives.

I was drinking home from work one day traveling at a rate of 60 mph and all of a sudden the transmission shifts into 2nd gear which made me come to a fast stop with no warning and would not allow me to accelerate to the posted speed limit. This is very dangerous and it’s a common issues that ford will not take accountability for.

This first began when we went to Oregon from dry Central Valley in California and hit rain. Multiple error messages appeared: Service Advance Trac, Check 4x4, Hill Assist Not Available, ABS, Steering Assist Fault, etc. Power steering assist was lost and is now intermittent which creates a dangerous situation. The ABS brakes made load groaning noises. I went to O’Reilley’s and used their OBD2 scanner. It showed codes: U1012-00, U0212-00, U0121-00, P062C-00, all being communication errors. I got a new battery and had a shop scan it. The clockspring was bad so it was replaced with an OEM from Sunrise Ford. He can’t get any communication with any of the other modules. I researched the issues and disconnected the battery while I cleaned the ABS controller connection with electrical contact cleaner. I checked some of the grounding points that weren’t checked by the shop. All of the error messages are now gone except the STEERING ASSIST FAULT. My research showed that this may be related to a wheel speed sensor or the front hub that contains the sensor. It also might be the ABS controller. I entered Engineering Test Mode and have the following continuous DTCs: C40182, C12100, C41582, C42082, C15100, C21200, C42982, C10200. Since they all end in 00 or 82 I think they are likely related. I was told in an online forum that they are communication errors. I think that might apply to the 00 errors, but don’t know about the 82 errors. The truck has under 28,000 miles and the extended warran

Lug nuts swollen and unable to remove with provided equipment

The transmission-10 speed. Yes it is available. The vehicle has been exhibiting on and off hard shifting since early December. Yesterday while crossing an intersection the vehicle went out of gear and would not move. A car behind me traveling at normal speed had to brake and swerve into the next lane to avoid hitting my vehicle. After contacting a few transmission shops they all confirmed that this has been an ongoing issue with these transmissions and they could not work on it and the only option was to replace it. Additionally Ford seems to be aware of the problem as they have issued a number of TSB's. The vehicle has not been inspected. The only thing I noticed was that the 1-10 gear indicator turned off.

Leaking sunroom. I cleaned tube's couple times and it is still happening. Ever time it's been raining my floor mat is soaking wet

The contact owns a 2017 Ford F-150. The contact stated that shortly after refueling the vehicle; while his wife was driving at a slow speed and merging onto the highway, the transmission failed to shift above 4th gear. In addition, the contact stated that the RMP had increased but the vehicle failed to accelerate as intended. No warning light was illuminated. The vehicle was towed to a local dealer where it was determined that there was failure with 2 wiring harnesses that required replacement. The vehicle was not repaired. Upon further investigation, the contact noticed that the rearview camera image occasionally failed to properly display an image. The manufacturer was made aware of the failure. The failure mileage was approximately 72,000.

Door latch on both front doors continues to intermittently freeze and will not either open or allow the doors to remain closed.

My 2017 F150 is 7 years old with 80K mileage. Engine problem: Cold start ticking/tapping/rattle noise. Ford claimed it sent a letter in 2021 but I never received. Googled and found there are large amount of the same complaints on 2017-2020 F150 with 3.5L EcoBoost engine. The Cam Phaser / VCT Units will fail. Vehicles may not restart after auto-start-stop. Ford issued Customer Satisfaction Program 21N03 and Technical Service Bulletin TSB23-2143. Those measures are not enough. Ford should recall all 2017-2020 F150 with 3.5L Ecoboost built before Nov 30, 2019. Lug nuts at wheels: Ford used cheap two-piece nuts. All the nuts were swollen in Dec 2024 and could not be removed by myself. I had to drive my F150 to Quick Lane and paid $140 to get all the nuts replaced with one-piece nuts. An employee of Quick Lane told me Ford used cheap two-piece nuts for long time, and it's a common issue on some Ford vehicles. Image if a tire is flat on highway while the nuts are swollen and the flat tire can not be changed! Ford should recall all vehicles using the cheap two-piece nuts. I still keep the old nuts as an evidence.

There has been a continuous oil leak from the oil pan since the vehicle was first purchased from the dealer. The manufacturer is aware of this issue and has issued a TSB for all vehicles from the Kansas and Detroit plants that are affected by a defective oil pan. The manufacturer is refusing to issue a recall despite the issue being wide spread and the dealership reporting that if left unfixed, the issue could result in loss of steering and could cause a serious accident. The vehicle has been inspected by the dealership and instructions were given to contact the customer support center for the manufacturer. The manufacturer admitted to knowing about the defect and still refuses to issue a recall.

Cam phasers make engine rattle at startup and idle. A recall has been put out but the dealer did not get the issue fix and sold it anyway. Also rear sensors don't work right.

DRIVERS DOOR AND PASSENGER DOOR FREEZES IN COLD WEATHER AND DOES NOT CLOSE COMPLETLY

Oil pan leaking, front oil pan leaking on RH. Valve covers failed for updated oil pan. RTD seal leak. Seen that this is a current recall. But my VIN isn't showing this recall. But I'm having this issue.

Similar to the 10-14 f150 recall for the 6r80 transmission lead frame failure. Driving down the freeway at speeds of 50-70 in 6th gear truck has down shifted into first causing loss of control. Transmission then disengages entirely and loses power mid driving. After turning truck off and waiting, starting the truck it returns to normal. failing speed sensor and lead frame are the cause in this transmission from Ford called the 6R80 in year models 10-19 however recalls were only ever issues for the 10-14 generation for repairs of less than 10 years of age or 150,000 miles. My truck is the generation after, a 2017 model with 146,000 miles. Truck is currently at Ford for repairs and diagnostics. In the most recent event with the truck shifting from 6th gear to 1st yesterday I was in heavy traffic and when I lost control of truck I had to "sweep" to the side of road / ditch to avoid collision with vehicles behind and beside me at speeds of 65-75. I believe the year models 15-19 should be included on the existing recall if equiped with the 6 speed automatic transmission being the fact they were built and manufactured with the same failing parts before the current recall was put in place a few months ago according to online sources. Fortunately I was safe in all 3 incidents but yesterdays close call has forced my hand in "parking" the truck until Ford can repair any malfunctioning parts. If a recall is placed after my trucks repair it would be nice to have compensation for this bil

The door locks freeze in the unlock state and doors will not close and lock. This is a recurring problem for several years. Door will not close and stay closed until the truck heats up.

The contact owns a 2017 Ford F-150. The contact stated while driving at an undisclosed speed, the vehicle stalled with the check engine warning light illuminated. The vehicle was able to restart; however, the failure recurred. The vehicle was taken to an independent mechanic and diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure. Additionally, the contact stated that while the vehicle was parked, the moon roof became inoperable. The contact attempted to engage the moon roof and became aware that the frame was fractured and failed to close properly. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The approximate failure mileage was 82,000.

Driving down the road, truck started erratically shifting into 1st gear while going 55 mph on the highway. This was causing truck to jolt and drop speed quickly and was cause for a major safety issue on the highway. Cause was found to be the lead frame and dealer is replacing it this week. Transmission is the same as found in the 11-13 f150s with an active recall for the lead frame. Have found many others reporting this as an issue that happened to them between 60-120k miles. Mine happened at 60,200 miles. Wanted to report it for others safety on the road to extend the recall to the 15-17 series trucks with the same issues as the 11-13 f150s.

I have the Ford F1 50 2017 model, 10 speed transmission. I about it new. In early December 2024 well on a road trip went down shifting the transmission started jerking, feeling like it was having trouble finding the correct gear. This continues to occur with subsequent driving of my vehicle. This was dangerous because it was occurring when trying to accelerate and pass other vehicles with a safe margin. This safety factor was definitely impaired. The speed was not properly controlled and the whole vehicle was jerking strongly. Luckily there were no oncoming vehicles but if there were this could have led to a head-on collision. Hesitancy to properly accelerate is extremely dangerous. Doing some research, I see that this problem was recognized by Ford in 2018 and memos to service departments were put out. I also saw that there is a 6 State class action lawsuit regarding exactly the same issue that has been issued against Ford Motor Company since approximately 2018. The lawsuit shows there have been numerous memos regarding this problem known about the Ford 10 speed transmission and not just in Ford F1 50s. I tried contacting Ford Motor Company and they said "your VIN number was not included in any recalls so you can only complain to the NHTSA". This is a known and dangerous problem that Ford motor company should issue a recall for and be responsible for repairing since it has been known since 2018 while all warrantees were still in force. My warranty is no longer in force, but

The contact owns a 2017 Ford F-150. The contact stated while starting the vehicle, there was an abnormally loud clanking noise coming from the vehicle with the check engine warning light illuminated. The vehicle was restarted; however, the failure recurred. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 130,000.

The contact owns a 2017 Ford F-150. The contact stated that while starting the vehicle the contact heard a loud clanking noise with the check engine warning light illuminated. The vehicle was able to restart however, the failure recurred. The vehicle was taken to an independent mechanic where it was diagnosed that the cam phasers had failed and needed to be replaced. The vehicle was not repaired. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 130,000.

I was driving home and noticed that the back mirror light was on. I tried to turn it off using the button, but it wouldn't go off. Confused, I pulled over to the side to check what was wrong and found that the rear sliding glass was leaning forward on my back seat. The track that was apparently holding it in place had come unglued! I could not believe it. It was raining and I was still a one hour drive away from home.

The doors on my truck have been freezing and wont let me latch the door shut. this was apparently resolved early this year using 18N03. however in Wisconsin it hasnt happened now till winter. first day below freezing, i could not close them. i have 2 young kids and this is a huge safety concern. as an adult its not a big deal. i am terrified to drive my truck due to putting my kids at risk with a door whipping open and or not being able to get them out in an emergency because they are LOCKED shut. the dealer apparently put the fix to it but the first day below freezing, my kid has to sit his seat wondering if his door will fly open. no one else has inspected it except for my local dealer which the "repair" happened. there was no other signs of failure till after i hit my first cold day in fall of 2021 were i thought it was a fluke till i noticed its a truck wide issue from 2015-2017.

Cam phaser and timing chain is starting to go bad

The contact owns a 2017 Ford F-150. The contact stated that the engine was making an abnormal rattling sound on cold starts, with an abnormal ticking sound while driving at various speeds. The dealer was notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and advised the contact to report the issue to the NHTSA Hotline. The contact referenced Ford Campaign Number: 21N03. The failure mileage was approximately 99,000.

Cam Phaser Rattle and engine ticking noise. No check engine lights illuminated.

The contact owns a 2017 Ford F-150. The contact stated that after starting the vehicle, there was a loud rattling and knocking sound coming from the engine compartment. The vehicle was taken to the local dealer who diagnosed that cam phasers were faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 170,000.

I have a 2017 F-150 3.5 Ecoboost and contacted my local Ford dealership and was told my vehicle does not have a recall on the cam phasers but there is a recall on this faulty parts and I'm experiencing these parts failing with only 73,000 miles. Would there be a program I could qualify for to help with the replacement of these faulty parts ? Thank you.

I had a problem that would cause my transmission to randomly downshift or slip into neutral while in drive. When this happened it would also disengage cruise controll and would disengage the blind spot monitoring system.Took it to the dealership and they confirmed it was a faulty molded lead frame. I had them replace the part. But was doing research and saw where they have had similar recalls on previous years.

The contact owns a 2017 Ford F-150. The contact stated while the vehicle was parked, there was an abnormal sound coming from the engine compartment. No warning light was illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that an unknown software update needed to be performed. The vehicle was repaired; however, the failure recurred. The vehicle was taken back to the dealer to be diagnosed. The contact was informed that the cam phasers needed to be replaced. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 73,900.

I'm experiencing issues with Ford's 10-speed transmission, widely considered dangerous due to issues like: harsh shifting, sudden jerking, hesitation when applying power, and unpredictable gear changes. Erratic shifting: The transmission can shift gears unexpectedly, causing sudden jolts and potentially causing loss of control, especially during critical driving situations like lane changes or heavy traffic. Power loss: sudden loss of power due to transmission issues, which can be dangerous on the road The issue occurs in regular intervals but with no particular trigger. No, there were no prior warnings before this failure The ford dealer has run diagnostics on my vehicle and reports an issue with the transmission which causes the above mentioned dangerous conditions.

Trans is hard shifting and shaking.