2005 Ford F-150 complaints

TURNING LEFT INTO SOUTH BOUND LANE OF A HIGHWAY WHEN THE RIGHT FRONT UPPER CONTROL ARM ASSEMBLY CAUSED THE TIRE TO DETACH FROM THE THAT AREA. THE TIRE LANDED ON THE HIGHWAY HOWEVER REMAINED ATTACHED FROM THE LOWER ASSEMBLY. DUE TO THE MOMENTUM OF THE VEHICLE WAS ABLE TO GET ACROSS THE HIGHWAY TO PREVENT A COLLISION. VEHICLE WAS TOWED TO AN AUTOMOTIVE REPAIR CENTER. THE RIGHT FRONT UPPER CONTROL ARM ASSEMBLY WAS COMPLETELY RUSTED THROUGH

AIRBAG LIGHT STAYS ON.

SPARK PLUG BLEW OUT OF THE ENGINE CAUSING DAMAGE AND REQUIRING ENGINE REPLACEMENT.

ON THE MORNING OF MARCH 5TH 2015 I STARTED MY TRUCK TO WARM THE INSIDE AND ALSO MELT THE SNOW OFF MY WINDSHIELD. I GOT IN THE TRUCK AND BACKED OUT AWAY FROM HOUSE. DUE TO HAVING SNOW ON THE DRIVEWAY I TURNED ON THE 4 WHEEL DRIVE IN HIGH. MY FOUR WHEEL DRIVE WOULD NOT WORK SO I TRIED TO SWICTH TO 2 WHEEL DRIVE BACK TO FOUR WHEEL DRIVE BUT THE 4 WHEEL DRIVE WOULD NOT TURN ON. I GRABBED THE GEAR SHIFT TO PUT THE TRUCK BACK IN PARK WHEN I NOTICED MY GEAR SHIFT COULD FLOAT TO PARK TO 1ST GEAR FREELY AND WOULD NOT SHIFT. AT THIS TIME I NOTICED SMOKE STARTING TO COME INSIDE CAB FROM UNDER DASH AND THRU THE VENTS. I JUMPED OUT AND OPENED THE HOOD. A 1 FOOT SECTION OF A WIRING HARNES MOUNTED TO THE FIREWALL HAD CAUGHT FIRE. I MADE ATTEMPTS TO PUT OUT THE FIRE BUT WITHIN A FEW SECONDS THE ENGINE COMPARTMENT WAS ENGULFED. IN 2 TO 3 MINUTES THE ENTIRE INSIDE OF THE CAB WAS ALSO COMPLETELY ON FIRE. MY WIFE WHO WAS WATCHING ME IMMEDIATLY CALLED 911 TO GET THE FIRE DEPARTMENT. AFTER 3 MINUTES THE TRUCK WAS ALREADY A TOTAL LOSE. DUE TO THE TRUCK BEING ONLY 60' FROM MY HOUSE AND BURNING SO HOT I WAS CONCERNED ABOUT MY HOUSE CATCHING FIRE. TWO GENTLEMAN FROM THE RESCUE SQUAD ARRIVED BUT IT WAS TOO LATE FOR ANYTHING TO BE DONE. I WAS ABLE TO GET A BACKHOE AND PUT THE FIRE OUT WITH SNOW. UNFORTUNATELY I HAD LIABILITY INSURANCE ONLY WHICH MEANT A TOTAL LOSE. I NEVER DREAMED THAT THE TRUCK WOULD BURN UP SITTING IN MY DRIVEWAY!!!! I KNOW THERE HAVE BEEN SOME RECALLS FOR F150 DUE TO FIRE HAZARDS WIT

DRIVING ON INTERSTATE DOING 70 MPH (IN FAST LANE) WHEN TRUCK STOPPED/STALLED AND I GUESS FROM RESEARCH WENT INTO "LIMP MODE". I WAS UNABLE TO PRESS THE GAS PEDAL, IT JUST SHOOK THREE TIMES EACH OF WHICH SLOWED IT DOWN INCREDIBLY, THE CHECK ENGINE LIGHT WAS ON AND A WRENCH SHOWED UP, BUT THE RADIO STILL WORKED. WHILE TRYING TO PULL OVER ALMOST WRECKED (MEMORIAL DAY WEEKEND AND I WAS IN FAST LANE). FINALLY ABLE TO PULL OVER TO SIDE OF ROAD HYSTERICAL, SHUT OFF AND WAITED A MINUTE AND IT STARTED. DROVE REST OF WAY HOME *100 MILES* WITH CHECK ENGINE LIGHT ON AND ABS LIGHT ON. I AM SCARED TO DEATH TO DRIVE AGAIN. NOT FUN HAVING A VEHICLE STALL/QUIT WHATEVER ON INTERSTATE IN RUSH HOUR TRAFFIC.

MY 2005 F150 XLT FRAME IS RUSTED THROUGH ON THE DRIVER,S SIDE OF THE TRUCK. I PURCHASED IT IN DECEMBER OF 2005 SO IT HAS NOT SEEN TEN YEARS OF SERVICE YET. IT WILL NOT PASS VERMONT STATE INSPECTION WHICH MEANS I WILL NO LONGER BE ABLE TO DRIVE IT ON PUBLIC ROADS DUE TO SAFETY REASONS. THE BODY IS IN VERY GOOD CONDITION AND THE TRUCK HAS LESS THAN 41,000 MILES ON IT. I HAVE UNTIL THE END OF AUGUST, 2005 TO GET THE TRUCK FIXED SO IT WILL PASS INSPECTION. I DO NOT WANT TO DRIVE IT BECAUSE OF THIS SAFETY ISSUE. THE FRAME WHICH SUPPORTS ALL OTHER COMPONENTS OF THE TRUCK NEEDS TO AND SHOULD DEFINITELY LAST MUCH LONGER THAN TEN YEARS. WILL THERE BE A RECALL ON THESE TRUCKS TO REPAIR/REPLACE THE FRAMES SOON? IT WILL BE VERY EXPENSIVE TO HAVE IT REPAIRED LOCALLY.

I STARTED THE TRUCK AND THEN TURNED ON THE REAR DEFROST, WHICH I RARELY USE. IT WAS ABOUT 55 DEGREES OUTSIDE. AFTER ABOUT 2 MINUTES I HEARD A HISSING NOISE THAT LASTED FOR ABOUT 5 SECONDS AND THEN A HEARD LOUD POP AND THEN THE WINDSHIELD SHATTERED. MANY OTHER ARTICLES ON THE WEB INDICATE THAT THIS IS A KNOWN DEFECT WITH THE REAR DEFROST. I CALLED FORD AND THEY WILL NOT OFFER AND COMPENSATION TO HAVE IT FIXED EVEN THOUGH IT IS A KNOWN ISSUE. MY DAUGHTER WAS IN THE BACK SEAT AND GOT GLASS IN HER HAIR. *TR

I ATTEMPTED TO START MY TRUCK, IT TURNED OVER BUT WOULD NOT START. I HAD THE TRUCK TOWED TO THE LOCAL FORD DEALERSHIP WHERE I PURCHASED IT NEW, AND FOUND THE CAUSE OF THE NO START CONDITION TO BE THE FUEL PUMP DRIVER MODULE. (PART NUMBER 5L3A-9D370-AA) I ASKED TO HAVE THE PART SAVED FOR MY INSPECTION. WHAT I FOUND WAS VERY DISTURBING. THE ALUMINUM CASE OF THE MODULE WAS CRACKED IN HALF AND HAS A DIME SIZE HOLE ERODED THRU. BY CHANCE, ONE OF MY WORK ASSOCIATED WHO HAS A 2004 F150 HAD A FLAT TIRE THIS MORNING (JUST THREE DAYS AFTER MY EXPERIENCE WITH THIS PROBLEM) AND HAD THE SPARE TIRE DOWN. I LOOKED UNDERNEATH HIS TRUCK AND FOUND HIS TRUCK TO HAVE A MODULE IN AS POOR CONDITION AS THE ONE I HAD REPLACED. I TOOK A PICTURE THAT I WOULD BE HAPPY TO FORWARD. TWO ADDITIONAL WORK ASSOCIATES WITH 2004 - 2005 F150'S HAVE EXPERIENCED THIS SAME PROBLEM WITH THEIR TRUCKS, I HAVE ALSO READ SEVERAL ONLINE POSTS TODAY OF THIS VERY SAME PROBLEM. THIS IS NOT AN ISSUE OF NORMAL WEAR OF A PART, THIS IS A DEFINITE DESIGN FLAW AND SAFETY ISSUE. THE MODULE IN QUESTION IS MOUNTED ABOVE THE SPARE TIRE ON THE DRIVERS SIDE REAR AXLE. THE TIRE IS MOUNTED FOR STORAGE TO THE UNDERSIDE OF THE TRUCK. THE ALUMINUM COVER OF THE MODULE IS MOUNTED AGAINST THE STEEL AXLE AND SEEMS TO ACT LIKE A SACRIFICIAL ANODE AS THE MODULE COVER ERODES AND CRACKS TO THE POINT OF NEAR TOTAL DESTRUCTION EXPOSING A CIRCUIT BOARD TO THE ELEMENTS. IT WOULD SEEM THIS MODULE WOULD BE PLACED IN AN AREA THAT WOULD BE LESS LIKELY TO D

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE INDEPENDENTLY DECELERATED BEFORE RAPIDLY ACCELERATING WITHOUT WARNING. THE FAILURE PERSISTED AND WOULD CAUSE THE ENGINE TO MISFIRE. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE SPARK PLUG, IGNITION COIL, AND THE NUMBER FIVE COIL NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 125,000.

UPON STARTING MY CAR THAT MORNING IT BACKFIRED AND WHITE SMOKE EXITED FROM THE EXHAUST WHICH IT HAS NEVER DONE BEFORE. ONCE IDLING I PUT THE TRUCK IN REVERSE WITH MY FOOT ON THE BRAKE AND MY TRUCK ROLLED DOWN THE DRIVEWAY. I HAD TO DEPRESS MY BRAKES WITH SIGNIFICANT FORCE TO GET IT TO STOP. UPON CHECKING THE ENGINE LATER THERE IS NO VACUUM DETECTED AT THE POWER BRAKE ASSIST. THERE IS A RECALL ON OTHER FORD TRUCKS OF THIS YEAR AND MODEL WITH THE SAME ISSUES THAT MINE WAS EXHIBITING. UPON CALLING FORD THEY SAID THAT MY VIN # WAS NOT ASSOCIATED WITH THIS RECALL. GO FIGURE! *TR

SPARK PLUGS BLOWING OUT. *TR

THIS ENGINE IS PRONE TO ENGINE FAILURE DUE TO CAM PHASERS ON 5.4 MOTOR ON A FORD F150 CAM PHASERS RESULTING IN ENGINE FAILURE WITH THE 5.4 MOTOR ## *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD SHAKE AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 85,000.

2005 FORD F-150. CONSUMER WRITES IN REGARDS TO VEHICLE TUNE-UP ISSUES. *SMD THE CONSUMER STATED NO ONE CAN TELL HIM THE ESTIMATED COST OF A TUNE-UP BECAUSE THE SPARK PLUGS CAN BREAK OFF WHEN BEING REMOVED AND CAN COST SEVERAL HUNDRED OR EVEN THOUSANDS IF THE CYLINDER HEAD HAS TO BE REMOVED TO DEAL WITH THE BROKEN PLUG(S). *JB

THE VEHICLE HAS A REMOVABLE RUBBER COVER ON THE BRAKE PEDAL WHICH CAN COME OFF DURING BRAKING CAUSING ONE'S FOOT TO COME OFF THE PEDAL. THIS IS WHAT HAPPENED CAUSING ME TO HIT THE CAR IN FRONT OF ME AS I WAS COMING TO A STOP. *TR

TL*THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT 55 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED BUT THE VEHICLE DID NOT MOVE FORWARD. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE SPARK PLUGS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 96.000. THE VIN WAS UNAVAILABLE.

THE LOWER UJOINT ON THE STEERING COLUMN IS FREEZING UP FROM CORROSION. IN THE PAST I HAD NOTICED IT WAS GETTING HARDER TO STEER SO I WOULD SPRAY THE JOINTS WITH PENETRATING OIL AND THEY WOULD IMPROVE. TODAY THE JOINTS WERE SO BAD IT WAS AS IF THE POWER STEERING HAD GIVEN OUT, TO THE POINT I PULLED OVER TO CHECK THAT I DIDN'T BLOW A POWER STEERING HOSE. I WILL NOT LET MY WIFE DRIVE THIS TRUCK UNTIL THE PART IS REPLACED BUT AT A COST OF $200 FOR THE PART IT WILL HAVE TO BE PARKED FOR A WHILE. I UNDERSTAND NORMAL WEAR BUT THIS IS COMMON ENOUGH TO DRAW SOME ATTENTION I HOPE. *TR

EXHAUST MANIFOLD ON THE FORDS' 5.4L ENGINE APPARENTLY WERE NOT ENGINEERED CORRECTLY. I HAVE HEARD OF MANY THAT HAVE LEAKED AND HAD TO BE REPLACED. I WORRY ABOUT THE POSSIBILITY OF FIRE. I HAVE CONTACTED FORD MOTOR CO. MULTIPLE TIMES HOWEVER THEY DECLINED ANY HELP WITH THERE REPLACEMENT ON MY TRUCK. IT SEEMS TO BE A VERY COMMON PROBLEM FROM WHAT I'VE HEARD AND SEE ONLINE. SHOULD FORD HAVE A RECALL ON THESE MANIFOLDS? *TR

I TOOK MY TRUCK IN FOR A REPAIR AND WHEN THEY LIFTED IT THEY FOUND HOLES IN THE FRAME OF THE TRUCK. I HAVE BEEN INFORMED THAT IT MAY FAIL WITHIN TWO YEARS. THIS TRUCK IS AROUND 10 YEARS OLD AND HAS BEEN PARKED IN A DRIVEWAY FOR THE FIRST HALF OF ITS LIFE AND UP TILL LAST YEAR HAS BEEN GARAGE KEPT. THERE IS 57,805 MILES ON IT TALKED TO MULTIPLE MECHANICS AND NONE OF THEM CAN BELIEVE THAT THERE IS ANY LOGICAL REASON FOR SUCH A FAST ROT OUT. *TR

I JUST WANTED TO ADD MY VEHICLE TO THE LIST OF COMPLAINTS ABOUT THE DIFFERENTIAL. MINE MAKES NOISE AND HAS MADE NOISE FOR QUITE SOME TIME. I THOUGHT IT MIGHT BE THE TIRES OR ROTORS. I FOUND OUT THAT IT WAS COMING DIRECTLY FROM THE REAR DIFFERENTIAL. BASED ON THE COMPLAINTS I HAVE HEARD, I AM PRETTY SURE THIS IS THE SAME THING. THE NOISE SOUNDS LIKE METAL RUNNING ON METAL. I BELIEVE THIS SHOULD BE SOMETHING FORD SHOULD PAY TO FIX. IF I HAVE TO PAY FOR IT, I'M DEFINITELY NOT USING FORD. I READ THAT'S MANY PEOPLE HAVE THE SAME COMPLAINTS. THIS FAILURE IS SECURITY PUBLIC PROBLEMS, BECAUSE ACCIDENTAL OR CRASH MAY OCCUR. *TR

WE HAVE HAD OUR 2005 F-150 KING RANCH FOR ABOUT 10 YEARS NOW. TODAY (FEB 10,2015), MY WIFE AND OUR ONE YEAR BABE WERE HEADING TO THE POST OFFICE THE TRUCK DISPLAYED A MESSAGE READING "ENGINE FAILSAFE MODE". THE TRUCK LOST ALL POWER, NO STEERING, AND IT STALL ON THE HIGHWAY GOING ABOUT 65 MPH. LUCKILY, SHE SAID THERE WERE VEHICLES BEHIND HER AND SHE PULLED IT OVER WITH NO STEERING AND THE ENGINE DEAD. MY WIFE THEN SAT ON THE HIGHWAY FOR ABOUT 10 MINUTES AND TRIED TO START THE VEHICLE, WHICH STARTED AND THERE WERE NO "ENGINE FAILSAFE MODE" ON DISPLAY ANYMORE. KNOW WITH-IN THE LAST YEAR OUR TRUCK HAS HAD THE CHECK ENGINE LIGHT AND THE ABS LIGHT HAS COME ON AND OFF EVERY OTHER MONTH. I HAVE CHECKED THE FUSES AND HAD REPLACE A FEW BUT AT TIME IT IS NOT THE FUSE. I'VE HAD THE INTERIOR DIM IN AND OUT AND AT TIMES IT DOES NOT WORK AT ALL. BY READING THE F150.NET FORUM FOUND OUT THE A WIRE THAT SPLITS INTO TWO WIRES WAS CORRODED ON THE PASSENGER SIDE FLOOR BOARD, IT SEEMS THAT CONDENSATION OR WATER COME IN AND STAYS IN THAT POCKET WERE THAT WIRING HARNESS GOES THRU. I AM NOW TERRIFIED THAT TRUCK WILL SHUT OFF ON THE HIGHWAY AGAIN WITH MY FAMILY AND I IN IT. THIS SEEMS TO BE A LIFE THREATENING PROBLEM. I HAVE READ THRU SOME FORUMS AND IT SEEMS THAT PEOPLE HAVE CALLED THE FORD DEALERSHIP AND THE SERVICE DEPARTMENT CLAIMED THEY HAVE NEVER HEARD OF THIS PROBLEM, BUT CAN WORK ON IT IF THEY BRING IT IN. BUT THAT FORD CLAIM THAT THEY FIX THE PROBLEM AND THE PEOPLE SAYS THAT THE PROBLEM STILL

BOUGHT A 2005 F150 TRITON V8 5.4L NEW IN 2005. I HAVE NOW EXPERIENCED A CAM PHASE PROBLEM WHICH WILL COST APPX 2500 TO REPAIR. TALKING TO MY MECHANIC HE SAID THAT IT WAS NO PROMISE TO FIX THE ISSUE , BECAUSE THESE MOTORS ARE KNOWN FOR THIS ISSUE. WAS TOLD IT WOULD BE EASIER TO PUT ANOTHER MOTOR IN SO I WOULDN'T HAVE TO WORRY ABOUT ,IF IT WOULD FIX THE PROBLEM. MY BROTHER HAS A 2008 FORD WITH THE SAME MOTOR AND HAD THE SAME PROBLEM ,BUT HIS MOTOR AFTER HAVING THE CAM PHASER'S REPLACED BLEW UP AND HAD TO REPLACE THE MOTOR. AFTER RESEARCHING AND TALKING TO SEVERAL ASE QUALIFIED MECHANICS THEY ALL SAID THAT THERE'S AN ISSUE WITH THE 5.4 LITER TRITON MOTOR. UPON CALLING FORD MOTOR COMPANY AS I WELL FIGURED WOULD HAPPEN THEY SAID THAT THEY WOULDN'T HELP WITH THE COST AND THAT THERE WAS NOR RECALL. CONSUMERS SHOULD BE ABLE TO GET MORE THAN 100,000 MILES OUT OF A VEHICLE THEY BUY. IF FORD WANTS TO KEEP CUSTOMERS HAPPY THEY SHOULD ADDRESS THEPROBLEM AND THE GOVERNMENT SHOULD BE MORE VIGILANT IN ASSURING THE CONSUMER IS PROTECTED FROM COMPANIES WHOSE PRODUCT DOSEN'T MEET STANDARDS. I WOULD LIKE TO SEE THE GOVERNMENT TO LOOK AT ALL COMPLAINTS THROUGH A SURVEY ON THIS MOTOR TO FIND A SOLUTION FOR THE CONSUMER. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT AFTER STARTING THE VEHICLE, THE ENGINE MISFIRE AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE PROBLEM RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE SPARK PLUG WAS FRACTURED AND THAT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 90,000.

SPARK PLUG BLEW OUT OF HEAD. *TR

2005 F150 GOES INTO "FAIL SAFE MODE" AND SHUTS DOWN WHILE DRIVING. IT ONLY OCCURRED ONCE PER YEAR STARTING AT 65,000 MILES, BUT NOW HAPPENS EVERY 3-4 WEEKS AT 114,000 MILES. ONCE THE ENGINE SHUTS DOWN, I PUT THE TRANSMISSION INTO NEUTRAL WHILE COASTING AND IT RESTARTS EASILY. THE ENGINE LIGHT ILLUMINATES FOR 3-4 DAYS AND THEN TURNS OFF. IN RESEARCHING THE ISSUE, IT SEEMS TO BE A RATHER COMMON PROBLEM WITH THIS VEHICLE AND IS USUALLY CAUSED BY A FAULTY THROTTLE BODY. FORD STATES THAT THEY ARE AWARE OF THE PROBLEM. *TR

I OWN THE ABOVE MENTION VEHICLE, THERE WAS NO DISCLOSURE TO ME AT THE TIME OF PURCHASE OF A VERY SERIOUS DESIGN FLAW WITH THE SPARK PLUGS THAT COULD AND LIKELY WILL BREAK OFF IN THE ENGINE DURING REPLACEMENT AND THE EXTREME COST IN CHANGING THESE PLUGS AROUND 900 TO 1000 DOLLARS IF NO PLUGS BREAK OFF AND EVEN MORE IN THE PLUGS DO BREAK OFF OR HEADS HAVE TO REMOVED TO EXTRACT THE PLUGS EVEN WORSE PIECES OF PRSHELL COULD FALL INTO THE ENGINE CYLINDER AND CAUSE ENGINE DAMAGE TO AROUND 8000 DOLLARS NOW THAT I AWARE OF THE EXTREME COST 3 OR 4 TIMES THE AMOUNT FOR ROUTINE MAINTENANCE OF CHANGING SPARK PLUGS IN THESE FORD VEHICLES FORD IS NO HELP AT ALL SAYING ITS NOT A SAFETY ISSUE I CANT HELP IT THE DESIGN FLAW WITH THESE LONG 2 PIECE PLUGS IS SO SERIOUS AND THE PRICE GOUGING OF THE CONSUMER FOR THE COST TO CHANGE SPARK PLUGS IS SO EXPENSIVE AND SO BAD I STRONGLY FEEL THAT THE FEDERAL GOV SHOULD STEP INTO THE MATTER AND HELP THE CONSUMERS OUT AND NOT ALLOW FORD TO GET BY WITH THIS EXTREME BAD DESIGN FLAW AND THE OUTRAGEOUS COST THEY ARE CHARGING AND THE FED GOV SHOULD FORCE FORD TO RECALL ALL AFFECTED VEHICLES AND MANDATE THAT FORD EAT THE COST OF CHANGING THESE SPARK PLUGS AND PUT IN THE NEWLY DEVELOPED PLUGS THAT ARE NOT PRONE TO BECOME SEIZED TO THE ENGINE AND FORD SHALL DO SO AT NO COST TO THE CONSUMER SAFETY OR NOT IT IS JUST UNBELIEVABLE THEY CAN GET BY WITH SUCH A SERIOUS DESIGN FLAW WITH SUCH A HIGH EXPENSE TO THE CONSUMER FOR SOMETHING THAT IS SUPPOSED TO BE ROUTINE. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 25 MPH, THE FOUR WHEEL DRIVE ACTIVATED INDEPENDENTLY AS A LOUD ABNORMAL NOISE EMITTED FROM THE FRONT OF THE VEHICLE. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS REPAIRED ON NUMEROUS OCCASIONS BUT THE FAILURE PERSISTED. THE REPAIR SPECIFICS WERE NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 58,000.

CORROSION OF THE U-JOINTS ON THE LOWER STEERING SHAFT OF MY 2005 FORD F150 (4.6 L) IS CAUSING THE STEERING TO MALFUNCTION. STEERING WILL NOT RETURN TO CENTER AFTER TURNING, EVEN AT MODERATE SPEEDS. THE VEHICLE DRIVES AS IF IT HAS NO POWER STEERING. LUBRICATION OF THESE JOINTS WILL REMEDY THE PROBLEM FOR A PERIOD OF A WEEK OR SO, BUT THE PROBLEM PERSISTS. THIS IS A KNOWN DESIGN FLAW THAT HAS BEEN RECALLED IN OTHER FORD MODELS WITHIN SIMILAR MANUFACTURE DATES. I LIVE IN A COLD WEATHER STATE WHERE THE PROBLEM IN THE RECALLED VEHICLES HAS BEEN NOTED TO BE MORE OF AN ISSUE. THERE ARE MANY ONLINE COMPLAINTS REGARDING THIS DESIGN FLAW IN THE F150. THE COST FOR ME TO REPLACE THIS PART WILL RANGE FROM $300 TO $600. HOWEVER, THE REPLACEMENT PARTS ARE MADE WITHIN THE SAME ORIGINAL OEM DESIGN. THE PARTS NEED TO BE CORRECTED SO THAT REPLACEMENTS WILL NOT FALTER AS WELL. IT IS VERY SCARY TO THINK THAT I MAY NOT BE ABLE TO RELY ON MY STEERING DURING DIFFICULT WEATHER SITUATIONS. *JS

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING APPROXIMATELY 60 MPH, THE ENGINE STALLED AND THE ENGINE FAILURE SYSTEM WARNING LIGHT ILLUMINATED. THE VEHICLE WAS RESTARTED AFTER MULTIPLE ATTEMPTS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 103,000.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT REMAINED ILLUMINATED. THE INDEPENDENT MECHANIC DIAGNOSED THAT THE SEAT BELT PRETENSIONERS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 33,000.

AFTER THE RECALL TO PREVENT A SHORT BETWEEN HORN AND AIR BAG WAS COMPLETED IN 2011 A SHORT TIME THEREAFTER IN THE MIDDLE OF THE NIGHT THE HORN CAME ON BY ITSELF IN THE LOCKED VEHICLE WITH NO ONE IN IT. AFTER TRYING EVERYTHING I COULD THINK OF LIKE STARTING THE ENGINE AND PUSHING THE HORN BUTTON NUMEROUS TIMES. I WAS ABOUT READY TO DISCONNECT THE BATTERY WHEN IN ANGER I HIT THE CENTER OF THE STEERING WHEEL VERY HARD WITH MY HAND AND THE HORN STOPPED BLOWING. FROM THAT DAY ON THE AIRBAG WARNING LIGHT STAYS ON WHEN THE ENGINE RUNS. AND THE HORN BLOWS HALF AS LOUD AS IT ORIGINALLY DID WHEN ACTIVATED. FORD SAYS ITS MY PROBLEM BECAUSE THE RECALL WAS ALREADY COMPLETED. ONLY PROBLEM HERE IS THAT THEIR WAS NO PROBLEM AT ALL UNTIL AFTER THE RECALL WORK. *TR

OVER THE PAST 5 YEARS I HAVE HAD MY TRUCK GO INTO FAIL SAFE MODE. MY TRUCK WILL FLASH FAIL SAFE AND I WILL LOSE ALL POWER TO THE VEHICLE. I'M ABLE TO COAST TO A STOP. I HAVE BEEN ABLE TO RE START MY VEHICLE AND CONTINUE DRIVING. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED TWICE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN DIAGNOSED THAT THE FRONT SEAT BELT PRETENSIONER WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE HAS BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 33,000.

FRONT END COLLISION INTO THE REAR OF ANOTHER TRUCK. WHOLE FRONT END DAMAGED THROUGH RADIATOR, HOOD, HEADLIGHTS, BUMPERS ETC. AIRBAG NEVER DEPLOYED AND UPON RETURN OF VEHICLE AFTER REPAIRS, I AM NOW GETTING A CODE 42 THAT THE SENSOR IS BAD AND AFTER RESEARCH FIND OUT THERE IS A RECALL ON THIS BUT FOR THE OPPOSITE REASON BUT ALSO NOW UNDERSTAND THERE ARE CORROSION ISSUES WITH THE CONNECTION OF THE SENSOR ALSO. HOPE THIS HELPS. PLEASE ADVISE WHAT TO DO, WILL FORD FIX THIS WHOLE PROBLEM AND REPLACE WITH A NEW SENSOR AND THE WIRE CHAFFING PROBLEM? THANK YOU IN ADVANCE! *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE APPROACHING A TRAFFIC LIGHT, THE BRAKES WERE ENGAGED AND THE VEHICLE SURGED FORWARD. THE CONTACT MENTIONED THAT EXTREME FORCE WAS REQUIRED IN ORDER TO STOP THE VEHICLE. ALSO, THE CONTACT STATED THAT THE SAFE MODE AND CHECK ENGINE LIGHT ILLUMINATE AS THE VEHICLE STALLED. THE CONTACT HAD TO WAIT SEVERAL MINUTES BEFORE THE VEHICLE RESTARTED. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE THROTTLE BODY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000.

THE "AIRBAG" INDICATOR LIGHT CAME ON. STAYED ON FOR ABOUT 6 WEEKS WHEN VEHICLE WAS IN USE, THEN TURNED OFF. NOW, A MINUTE OR SO AFTER STARTING VEHICLE AN ALARM SOUNDS, 5 LOW SOUNDING BEEPS IN 5 ROUNDS, WILL DO IT ABOUT EVERY 30 MINUTES, SAME ALARM CYCLE. ACCORDING TO THE OWNERS MANUAL THIS IS AN INDICATION OF A PROBLEM WITH THE AIRBAG SYSTEM. I THOUGHT I WAS RESPONSIBLE FOR HAVING THIS FIXED. CURRENTLY WITH MY SCHEDULE AND FINANCIAL SITUATION I HAVE BEEN PUTTING OFF SERVICING THIS ISSUE HOWEVER, I HEARD ON THE NEWS EARLIER THIS WEEK ABOUT SEVERAL RECALLS AND MY VEHICLE FITS INTO THIS. I HAVE NOT RECEIVED ANY RECALL NOTICE FROM FORD. I'M NOT SURE IF MY VEHICLE IS ACTUALLY PART OF THIS, THIS IS WHY MY INQUIRY TO YOU. PLEASE ADVISE *TR

I HAVE OWNED MY FORD TRUCK FOR ALMOST 8 YEARS AND I HAVE EXPERIENCED NOTHING BUT BAD LUCK WITH THIS ENGINE AND ME AND OTHER FORD OWNERS AGREE THAT THIS ENGINE IS 1 OF THE WORST ENGINES THAT FORD HAS PRODUCED AND THEY KNOW IT. AND ARE RELUCTANT TO DO ANYTHING ABOUT IT. AND ITS COSTING ME THOUSANDS TO REPLACE SPARK PLUGS AND CAMPHASERS. MY TRUCK NOW WILL STALL WHEN PUT IN REVERSE. IT ALSO HAS A LOUD TICKING NOISE TO IT. I KNOW ITS THE CAMPHASERS AGAIN WHICH I ALREADY REPLACE ABOUT 4 YEARS AGO.THIS TRUCK IS COSTING ME MORE THAN ITS WORTH. I ONLY HAVE 85000 MILES ON IT. FORD NEEDS TO DO SOMETHING ABOUT THIS PROBLEM. ME AND OTHER FORD OWNERS OF THIS MODEL CANT KEEP SLAMMING MONEY INTO SOMETHING THAT IS A COMPLETE FAILURE FROM THE START. THIS TRUCK IS DANGEROUS AND THE PROBLEM NEEDS SOLVED. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE AIR BAG LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN DIAGNOSED THAT THE SEAT BELT PRETENSIONER AND STABILIZER BAR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. HOWEVER, THE DEALER ADVISED THE CONTACT THAT THE SEAT BELTS WERE NOT COVERED UNDER WARRANTY. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 33,000.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE VEHICLE FAILED TO RESTART AFTER BEING SHUT OFF. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE CONTACT REPAIRED THE FUEL PUMP DRIVE MODULE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 123,000.

2005 FORD F-150. CONSUMER WRITES IN REGARDS TO SPARK PLUGS AND COILS PROBLEM. *SMD THE CONSUMER STATED THE VEHICLE STALLED, UPON ACCELERATION. THE CONSUMER ALSO STATED THE CHECK ENGINE LIGHT ILLUMINATED AND FLASHED WHEN A SPARK PLUS MISFIRED. *JB

WHILE STOPPING FOR A PEDESTRIAN, AT A SPEED OF APPROXIMATELY 10 MPH,THE REAR PASSENGER SIDE RUBBER BRAKE LINE SEPARATED FROM THE STEEL BRAKE LINE,RESULTING IN THE IMMEDIATE LOSS OF ALL BRAKE FLUID AND THE BRAKE PEDAL GOING TO THE FLOOR.THE CAUSE OF THIS SEPARATION ,WAS CORROSION OF THE FACTORY STEEL CLAMP ,CLAMPING THE RUBBER HOSE TO THE STEEL BRAKE LINE. UPON EXAMINATION,IT WAS FOUND THAT TWO OTHER CLAMPS WERE IN THE SAME CONDITION.I WAS ABLE TO COMPLETELY REMOVE ONE CLAMP ,BY RUBBING IT BETWEEN MY FINGER AND THUMB.THESE STEEL COMPONENTS ARE UNSAFE FOR USE IN STATES THAT USE SALT OR BRINE ON THEIR ROADS.THIS WAS MADE WORSE BY THE FACT THAT THE RESERVOIR USED,IS NOT SPLIT INTO TWO SECTIONS, ALLOWING LOSS OF ALL BRAKE FLUID FOR BOTH FRONT AND REAR BRAKES AT THE SAME TIME. *TR

FORD DESIGNED THE FACTORY SPARK PLUGS AS A TWO PIECE DESIGN. ONCE THE TRUCK REQUIRES A TUNE UP THE CURRENT SPARK PLUGS BREAK IN HALF AS THEY ARE REMOVED CAUSING AN ADDITION COST FOR EXTRA LABOR AND SPECIAL TOOLS DESIGNED TO REMOVE THESE PLUGS. I TOOK MY TRUCK TO THE FORD DEALER WHO THEN BROKE 6 OUT OF 8 PLUGS UPON REMOVAL AT AN EXTRA COST OF 80 DOLLARS A PIECE. THE TUNE UP WHICH ONLY INCLUDES THE REMOVAL OFF THE OLD AND THE INSTALLATION OF THE NEWLY DESIGNED ONE PIECE SPARK PLUGS ENDED UP COSTING ME 1000 DOLLARS. THESE SPARK PLUGS ALSO BREAK INSIDE THE ENGINE CAUSING A LOSS OF POWER AND POSSIBLE DAMAGE TO THE CATALYTIC CONVERTER. *TR

TRUCK SHAKES VIGOROUSLY AT SPEEDS OVER 55MPH, CANNOT EXCEL IN FAST ONCOMING TRAFFIC WITH CHILDREN IN VEHICLE! ENGINE CUTS OUT AND JERKS THE WHOLE VEHICLE. MISFIRING. CONTINUOUSLY HAVING TO GET TOWING BECAUSE THE VEHICLE FAILS TO START ALL TOGETHER! THIS COULD LEAD TO INJURY, DEATH, ACCIDENTS NOT ONLY FOR THE DRIVER/PASSENGERS BUT OTHERS ON THE ROADS AS WELL. THIS ISSUE HAS BEEN BROUGHT TO ATTENTION IN THE FORD F-150 5.4L ENGINE MORE THAN SEVERAL HUNDRED TIMES AND NO ACTION HAS BEEN TAKEN. YOU CAN FIND INFORMATION ALL OVER OF PEOPLE HAVING THE SAME ISSUES, THE FORD DEALERSHIP I TOOK IT TO TOLD ME I WOULD NEED A NEW ENGINE OR TO SPEND THOUSANDS TO FIX IT AND THEY SEE PEOPLE BACK IN THERE WITHIN THE MONTH OF SPENDING GRANDS TO FIX IT. SOMETHING NEEDS DONE ABOUT THIS BEFORE PEOPLE END UP DYING IN THESE VEHICLES. *TR

THE 5.4 LITER ENGINES HAVE A DESIGN PROBLEM THAT'S COSTING OWNERS A LOT OF MONEY JUST TO REPLACE THE SPARK PLUGS. THE PLUGS ARE TWISTING OFF OR BREAKING BECAUSE THE BLOCK DESIGN ALLOWS THE PLUG TO EXTEND INTO A HOLE THAT ALLOWS CARBON BUILDUP AROUND THE TIP OF THE PLUG. WHEN YOU TRY TO REMOVE THE SPARK PLUG THE BOTTOM OF THE PLUG IS SEALED TIGHT TO THE HEAD THEREFORE ALLOWING THE TOP OF THE PLUG TO TWIST AND NOT THE BOTTOM. THIS IS HAPPENING TO A LOT OF TRUCK OWNERS AND SOME DEALERS WON'T EVEN ATTEMPT TO REPLACE THE PLUGS. IF ONE BREAKS, IT COULD COST UP TO $2000 FOR THE REPAIRS. I HAVE 4 OF THEM BROKE OFF. I HAVE ORDERED THE EXTRACTOR KIT BUT THE BACK TWO CYLINDERS ARE GOING TO BE HARD TO REPAIR. I LIKE MY FORD TRUCK BUT SINCE THE EARLIER MODEL FORDS WERE BLOWING PLUGS OUT OF THE BLOCKS AND NOW WE CAN'T GET THEM OUT WITHOUT AN EXTRACTOR, TO ME THIS IS NOT GOOD ENGINEERING. I WOULD LIKE TO KNOW WHAT FORD IS DOING ABOUT THIS EXTREME COST TO ITS CUSTOMERS. THANK YOU, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE AIRBAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V107000 (AIR BAGS). THE FAILURE MILEAGE WAS 79,000.

WE BOUGHT THIS VEHICLE NEW IN 2005. CHANGE OIL AS REQUIRED AND DID REGULAR SERVICES. ENGINE STARTED KNOCKING AND RUNNING ROUGH. TOOK TO DEALER WHO STATED CAM PHASERS WENT OUT WHICH IN TURN BLEW THE ENGINE. DEALER STATES NEW ENGINE IS REQUIRED ON A 9-YEAR OLD VEHICLE WITH LESS THEN 140,000. DEALER STATES CAM PHASERS ARE VERY COMMON PROBLEM IN THIS ENGINE (5.4L TRINITRON) . CALLS TO NUMEROUS OTHER LOCAL FORD DEALERS REVEAL NUMEROUS ENGINE REPAIRS DUE TO CAM PHASERS IN THE ENGINE INTERNET RESEARCH FIND NUMEROUS ISSUES WITH THE CAM PHASERS IN THIS ENGINE CAUSING COMPLETE ENGINE FAILURE. FORD REFUSES TO ACKNOWLEDGE THE PROBLEM. DEALER QUOTE TO REPLACE THE ENGINE ON A 9-YEAR OLD VEHICLE WAS $7150.00. *TR

THE VEHICLE BEGAN TO SMELL LIKE RAW FUEL, PARTICULARLY AT STOP SIGNS OR INTERSECTIONS. THE SMELL APPEARED TO BE COMING FROM THE ENGINE BAY. UPON DISASSEMBLY OF THE INTAKE COMPONENTS OF THE ENGINE TO EXPOSE THE FUEL INJECTION SYSTEM, IT WAS EVIDENT THAT THE FUEL RAIL HAD BEGUN LEAKING RAW FUEL INSIDE THE ENGINE BAY. THE FUEL RAIL DEVELOPED A SPECK OF CORROSION ABOUT 2-3MM IN DIAMETER ON THE TOP SURFACE OF THE RAIL. THE CORROSION EVIDENTLY PENETRATED THE ENTIRE RAIL AND BECAME A PINHOLE LEAK. RAW FUEL WAS SEEN LEAKING UP AND OUT OF THE PINHOLE. THIS HAPPENED ON THE PASSENGER SIDE FUEL RAIL, WHICH IS POSITIONED INCHES AWAY FROM THE HIGH VOLTAGE COIL PACK, AND ABOVE THE EXHAUST MANIFOLD AS WELL. CALLED FORD CUSTOMER SERVICE HOTLINE AND WAS TOLD THERE IS NO RECALL FOR IT, NO EXTENDED WARRANTY PROGRAM, NO ASSISTANCE WHATSOEVER. ORDERED A NEW FUEL RAIL THROUGH LOCAL FORD DEALER FOR $500 DOLLARS (4 TIMES WHAT A TYPICAL FUEL RAIL COSTS); PART HAS NOT BEEN SHIPPED, DEALER UNSURE IF FORD HAS ANY IN STOCK OR IS EVEN MAKING THE PART. TRUCK HAS BEEN INOPERABLE FOR OVER A WEEK WITH NO WAY TO FIX IT. *TR

THE NUMBER 3 SPARK PLUG BLEW LOOSE. THE FIRST TIME IT HAPPENED IT WAS JUST STARTED AND IDLING. IT GOT FIXED WITH A REPAIR KIT AND THEN IT HAPPENED AGAIN THE NEXT WEEK. IT WOULDN'T BE A HUGE CONCERN BUT THERE ARE MULTIPLE THINGS THAT COULD HAPPEN AND CAUSE SERIOUS INJURY AND OR A FATALITY. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE REVERSING, THE VEHICLE ACCELERATED INDEPENDENTLY AND CRASHED INTO THREE OTHER VEHICLES. A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 87,000.

TRUCK WENT INTO "LIMP" MODE ON START UP. VERY DIFFICULT TO GET HOME IN TRAFFIC. "FIX" WAS NEW THROTTLE BODY FROM FLECTHER FORD. $582.38. SEEMS TO BE AN ONGOING PROBLEM WITH FORD. *TR