1997 Ford F-150 complaints

CHECK ENGINE LIGHT CAME ON AND WHEN MECHANIC SERVICE VEHICLE HE INFORMED ME THAT COOLANT HAS LEAKED INTO THE NUMBER FOUR CYLINDER AND THAT THIS ENGINE HAS A HISTORY OF HEAD GASKET FAILURES. HE CAN REPLACE GASKET BUT BELIEVES THAT THIS WOULD ONLY BE A TEMPORARY FIX. HE WOULD BE WILLING TO REPLACE GASKET FOR $1600 BUT HE CAN NOT GUARANTEE RESULTS, A REPLACEMENT ENGINE WOULD COST APPROX. $4800. AFTER RESEARCHING THIS ISSUE ON THE WEB IT HAS BECOME APPARENT TO ME THAT FORD HAS LONG KNOWN OF THIS PROBLEM BUT HAS FAILED TO TAKE ANY ACTION TO REMEDY THIS SITUATION. *JB

TL*THE CONTACT OWNS A 1997 FORD F-150. THE CONTACT STATED THAT THE WIRING HARNESS CAUGHT FIRE UNDER THE HOOD. FORD STATED THAT HE WOULD BE RESPONSIBLE FOR THE REPAIRS. HE BEGAN RECEIVING RECALL LETTERS REGARDING THE WIRING HARNESS IN 2004. THE CONTACT HAS BEEN IN TOUCH WITH FORD CONCERNING REPAIRS AND/OR REIMBURSEMENT. THE RECALL NUMBER WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 52,660. UPDATED 12/12/2007 *BF

MY F150 XLT 4.2L ENGINE HAD BEEN OPERATING NORMALLY PRIOR TO 9/21/07. THE TRUCK WAS SITTING AT HOME AND HAD NOT BEEN DRIVEN FOR APPROXIMATELY ONE WEEK WHEN I WENT TO DRIVE IT. AS I CRANKED IT, THE ENGINE SUDDENLY BEGAN MAKING A VERY LOUD CLATTERING NOISE. I IMMEDIATELY SHUT OFF THE ENGINE AND OPENED THE HOOD TO SEE IF SOMETHING WAS HITTING THE FAN BLADE OR SOME SIMILAR EVENT. AFTER INSPECTING THE ENGINE COMPARTMENT AND DISCOVERING NOTHING UNUSUAL VISUALLY, I AGAIN STARTED THE ENGINE AND AGAIN THE SAME HORRIBLY LOUD NOISE CONTINUED. I WAS TOLD BY AN AUTO MECHANIC WHO LIVES NEARBY THAT THE NOISE SOUNDED LIKE A ROD "KNOCK" CAUSED BY CATASTROPHIC ENGINE FAILURE. AFTER LEARNING OF THE 99B29 RECALL ON THIS 4.2 ENGINE FOR FRONT GASKET DEFECTS THAT CAUSE COMPLETE ENGINE FAILURE IF NOT STOOPED IN TIME, I CONTACTED THE ORIGINAL OWNER AND LEARNED THAT HE HAD NEVER BEEN NOTIFIED OF ANY SUCH RECALL, AND HE SPECIFICALLY STATED THAT ANYTIME HE WAS NOTIFIED OF A PROBLEM HE ALWAYS TOOK THE VEHICLE TO THE DEALER AS INSTRUCTED. IN FACT, HIS FATHER WORKED AT A FORD DEALERSHIP AND HIS FATHER SOLD HIM THE TRUCK AND HE STILL HAD NO KNOWLEDGE OF ANY SUCH RECALL. I HAD RECENTLY ADDED ENGINE COOLANT TO THE RESERVOIR BEFORE THE ENGINE FAILURE BECAUSE IT WAS VERY LOW, BUT I DISCOVERED NO LEAKS ANYWHERE NOR ANYTHING ELSE UNUSUAL SO THERE WAS NOTHING APPEARING OUT OF THE ORDINARY. THE ENGINE IS NOW RUINED DUE TO THE FAULTY GASKET BECAUSE THE VEHICLE OWNER WAS NEVER NOTIFIED OF THE DEFECTIVE CONDITION. IN

1997 F150 4.2L ENGINE FAILURE. *JB. UPDATED 01/11/08. *LJ THE ENGINE MAIN BEARINGS, LOWER ENGINE GASKET AND TIMING BELT GASKET COVER WERE REPLACED. UPDATED *JB

1997 FORD F150 4.2L ENGINE - THROWN ROD/ CRUISE CONTROL FIRE POSSIBILITES. *TR

'97 F150 4.2 V8 COOLANT LEAK, ENGINE BLOWN @ 140,000 AFTER SEVERAL HEAD GASKET REPAIRS. *JB

I HAD MY SPARK PLUGS REPLACED TWICE AT $541 DOLLARS AT A FORD DEALERSHIP BECAUSE THEY WERE "CORRODED". UPON TAKING IT SOME PLACE ELSE GOODYEAR TO BE SPECIFIC THEY PULLED UP A FACTORY RECALL ON FORD F150 FROM 97 BECAUSE A GASKET LEAKS COOLANT ONTO THE SPARK PLUGS CAUSING CORROSION. EMPIRE FORD NEVER EVEN GAVE ME A REASON FOR THIS, JUST KEPT CASHING THE CHECKS, NOW THEY ARE SAYING MY VIN NUMBER WAS NEVER INCLUDED, BUT I HAVE THE SAME PROBLEM AS THOSE RECALLED, COINCIDENCE, IMPOSSIBLE. *JB

AT 1:50A.M. ON 8/1/2007 OUR 1997 FORD F150, WHICH WAS UNDER RECALL, BURNED IN OUR DRIVEWAY. DAMAGE WAS ALSO DONE TO 2 OTHER VEHICLES, OUR HOME, DRIVEWAY, AND BASKETBALL GOAL. *TR

TL*THE CONTACT OWNS A 1997 FORD F-150. THE CONTACT STATED THAT A ROD PUNCTURED THE OIL PAN AND RUINED THE ENGINE. THE VEHICLE IS UNABLE TO BE DRIVEN AND HAS NOT BEEN TO THE DEALER. HE HAS DISCOVERED SEVERAL OTHER PEOPLE WHO HAVE EXPERIENCED THE SAME FAILURE. THE VIN, SPEED, AND MILEAGE INFORMATION WERE UNAVAILABLE.

VEHICLE WAS PARKED IN DRIVEWAY WITH DOORS LOCKED AND IGNITION IN THE OFF POSITION. NO ONE WAS NEAR OR IN THE VEHICLE. LOOKED OUT WINDOW AND NOTICED WHAT LOOKED LIKE MIST FROM A WATER SPRINKLER FROM THE FRONT SIDE OF TRUCK. LOOKING CLOSER, I REALIZED IT WAS SMOKE AND THEN SAW FLAMES FROM THE TIRE WELL AND UNDER THE HOOD BY THE WINDSHIELD WIPERS. CALLED 911. THE FIRE DEPARTMENT ARRIVED VERY QUICKLY, PUTTING THE FIRE OUT. THEIR ASSESSMENT WAS IT WAS AN ELECTRICAL SHORT WHICH HAD CAUSED THE FIRE. THE FIRE CAUSED THE HOOD HYDRAULIC LIFT TO EXPLODE LIKE A ROCKET, HITTING THE WINDSHIELD, CRACKING IT AND THEN SHOOTING OFF INTO THE YARD. THE FRAMES INSIDE THE ENGINE HOUSING BY THE DRIVERS TIRE BURNT THE HOUSING COMPLETELY AWAY. THE WIRING HAS BEEN COMPLETELY BURNED AND MELTED AWAY INSIDE THE ENGINE COMPARTMENT. ALL THE PLASTIC FLUID CONTAINERS MELTED, THE ENTIRE ENGINE HOUSING, ENGINE AND ALL ELECTRICAL COMPONENTS UNDER THE HOOD WERE BURNED UP OR DAMAGED IN SOME WAY BY THIS FIRE. THE TRUCK WILL NOT START OR RUN. NONE OF THE LIGHTS WORK, RADIO, HEAT, AIR OR POWER FUNCTIONS WORK. THE TRUCK IS TOTALLY INOPERABLE. I CONTACTED THE INSURANCE COMPANY AND THEY DIRECTED ME TO THIS SITE TO LOOK FOR FIRE RELATED DEFECTS AND TO FILE A COMPLAINT. THE TRUCK HAS NOT BEEN REPAIRED AS IT IS BEYOND REPAIR SINCE ALL THE WIRING AND MOST OF THE INSIDES UNDER THE HOOD HAVE BURNED UP OR MELTED. *JB

PURCHASED A 1997 FORD F-150 IN EARLY SPRING OF 2006. VEHICLE HAD LESS THAN OR CLOSE TO 100,000 MILES. DROVE THE VEHICLE BETWEEN 1,000 AND 2,000 MILES OVER THE NEXT YEAR. IN LATE MARCH OR EARLY APRIL OF THIS YEAR THE VEHICLE'S ENGINE, A 4.2 L 6 CYLINDER MOTOR SELF DESTRUCTS. ON THE MORNING IN QUESTION, I WENT OUT AND ATTEMPTED TO START THE VEHICLE. THE MOTOR TURNED OVER VERY SLUGGISHLY AS IF THE BATTERY WAS LOW. WHEN THE MOTOR STARTED, IT MADE A TERRIBLE RACKET AND BLEW A CHUNK OF THE ENGINE BLOCK OUT APPROXIMATELY THE SIZE OF MY THUMB. AFTER THIS HAPPENED, I RESEARCHED THE PROBLEM ON THE INTERNET ONLY TO FIND THAT 1997 4.2 L FORD MOTORS HAVE A DEFECTIVE GASKET WHICH ALLOWS WATER TO FLOW INTO THE CYLINDERS. THE GASKET HAD FAILED AND ALLOWED WATER TO LEAK INTO THE CYLINDER(S) OVERNIGHT CAUSING THE VEHICLE TO HYDROLOCK AND "BLOW UP". FORD HAS BEEN AWARE OF THIS PROBLEM FOR MANY YEARS, AND EVEN SENT OUT NUMEROUS TECHNICAL SERVICE BULLETINS REGARDING THE PROBLEM. I HAVE EVEN FOUND EVIDENCE THAT THEY MAY SENT OUT A FEW RECALL NOTICES, BUT NOT TO EVERY OWNER. HUNDREDS OF '97 F-150 OWNERS HAVE HAD THIS SAME PROBLEM, AND THEY, LIKE ME, CANNOT AFFORD TO PAY THE APPROXIMATELY $5,000 TO REPAIR THEIR MISTAKE. I CURRENTLY OWE ABOUT $5,000 ON THIS VEHICLE, WHICH AT THIS TIME IS ONLY AN EXPENSIVE LAWN ORNAMENT. FORTUNATELY, THERE WAS NOT FIRE OR INJURIES WHEN THIS OCCURRED, BUT THEY COULD HAVE. I'M CERTAIN THAT FORD NEVER REPLACED THE GASKET ON THIS VEHICLE, AS THE ONLY RECALL "STICKER" IS O

TL*THE CONTACT OWNS A 1997 FORD F150. WHILE DRIVING 55 MPH, THE CONTACT HEARD A LOUD POP AND THE VEHICLE PULLED TO THE RIGHT. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT THE AXLE TUBE WAS FRACTURED. THE REPAIR SHOP REPLACED THE CV AXLE AND THE AXLE TUBE. THE CURRENT MILEAGE WAS 136,000 AND FAILURE MILEAGE WAS 135,000.

AFTER STOPPING IN DRIVEWAY MY 1997 F150, 4.6 L WOULD NOT SHIFT INTO PARK AND THE GEAR SHIFT SEEMED TO BE LOOSER THAN NORMAL. AS I TRIED SEVERAL TIMES TO SHIFT INTO PARK A 1 INCH, BRASS, STAR HEAD MACHINED SCREW FELL OUT FROM UNDER THE STEERING COLUMN. ALSO, THE GEAR SHIFT INDICATOR CAME TO REST BETWEEN PARK AND REVERSE. THE ENGINE WOULD NOT START IN THIS POSITION, BUT DID START IN NEUTRAL. I HAD A DIFFICULT TIME FINDING REVERSE AND DRIVE, BUT ONCE IN GEAR THE TRANSMISSION SOUNDS AND RUNS NORMALLY. THE SAFETY IMPLICATION OF THIS PROBLEM IS THE UNINTENDED MOVEMENT OF THE TRUCK IF THE EMERGENCY BRAKE IS NOT SET OR DEFECTIVE. MY RESEARCH OF THE PROBLEM DISCLOSED TWO RELATED RECALLS OF 1997 FORD VEHICLES; CAMPAIGN NUMBER 97V147000, SEPTEMBER 9, 1997 AND CAMPAIGN NUMBER 97V171000, OCTOBER 7, 1997. BOTH THESE RECALLS INVOLVED SOME FACET OF THE TRANSMISSION LINKAGE BETWEEN THE STEERING COLUMN AND THE TRASMISSION HOUSING, JUST AS MINE DID. ON MY TRUCK THERE ARE TWO BOLTS SECURING THE TRANSMISSION SELECTOR LEVER ARM AND SUPPORT TO THE STEERING COLUMN TUBE. THE SHIFT CABLE IS ATTACHED TO THIS ARM. THE TOP BOLT CAME LOOSE AND FELL OUT, WHILE THE SECOND BOLT WAS VERY LOOSE, IN FACT, THE WHOLE ARM WAS READY TO FALL OUT. THIS WAS THE CAUSE OF MY PROBLEM. THE SOLUTION WAS TO REALIGN THE SELECTOR LEVER ARM AND SUPPORT TO THE SHIFT TUBE AND REINSERT THE TWO SCREWS, AFTER USING A "LOCTITE" COMPOUND. *TR

VEHICLE CAUGHT FIRE SITTING IN FRONT OF HOME. ALL WIRING IS DESTROYED AND DASHBOARD MELTED. VEHICLE HAD NOT BEEN RUNNING FOR AT LEAST 48 HOURS PRIOR TO THE FIRE. HAD NO FIRE INSURANCE ON VEHICLE SO TOOK A COMPLETE LOSS. LATER LEARNED THAT FORD HAD RECALLED THIS MODEL FOR CRUISE CONTROL DEACTIVATION SWITCH. CONTACTED FORD AND THEY CLAIM NO LIABILITY FOR THE FIRE. *JB

TL*THE CONTACT OWNS A 1997 FORD F-150. THE CONTACT NOTICED FLAMES COMING FROM UNDER THE HOOD WHILE THE VEHICLE WAS PARKED. THE DEALER HAS NOT INSPECTED THE VEHICLE TO DETERMINE THE CAUSE THE VEHICLE WAS DEEMED TOTALED. UPDATED 09/05/07. *JB

I OWN A 1997 F-150 FORD PICKUP WITH THE TRITON V8 4.6L ENGINE. AFTER HAVING 10,5000 MILE SCHEDULE SERVICE TO REPLACE SPARK PLUGS AND TUNE UP THE NUMBER 4 CYLINDER PLUG BEGAN TO POP-OUT" OF THE BLOCK. SO FAR NO DAMAGE TO THE VEHICLE, BUT IT WAS NOT FIXED YET. I KNEW THIS WAS A"COMMON PROBLEM THAT WAS INVESTIGATED BEFORE, BUT I WANTED TO DOCUMENT THAT THE PROBLEM CONTINUED, AND FORD NEEDED TO ACKNOWLEDGE THE DEFECT. I WAS TOLD BY MY FORD DEALERSHIP THAT IF I DROVE WITH NUMBER 4 CYLINDER MISFIRING FOR AN EXTENDED PERIOD IT MAY CAUSE HYDRO LOCK OR FIRE DAMAGE TO THE ENGINE. THAT WAS PRETTY SERIOUS AND SOUNDED LIKE AN ADMISSION FROM FORDS DEALERS THAT THERE WAS A SERIOUS PROBLEM. THE DEALER HAS BEEN VERY HELPFUL, AND WAS WORKING TO FIX THE PROBLEM SO I HAVE NO COMPLAINT AGAINST THE DEALER. HOWEVER, JUST BECAUSE THERE HASN'T BEEN A FATALITY WITH THIS DEFECT DID NOT MEAN THERE SHOULDN'T BE AN ADMISSION BY FORD OF THE DESIGN DEFECT, AND A RECALL TO FIX THE PROBLEM WITHOUT CHARGE TO THE CUSTOMER. *AK

TL*THE CONTACT OWNS A 1997 FORD F150. WHILE DRIVING 25 MPH, THE CONTACT APPLIED THE EMERGENCY RIGHT HAND BRAKE AND THE ROTOR SHEARED OFF THE HUB. THE FAILURE OCCURRED A SECOND TIME WHILE DRIVING 25 MPH. DURING THIS FAILURE, THE LEFT HAND BRAKE WAS APPLIED AND THE ROTOR FAILED. A MECHANIC HAS REPAIRED THE FAILURE AND FORD STATED THAT THEY NEVER HEARD OF THIS BEFORE. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 92,000.

1997-F-150 SUPER CAB WITH FACTORY INSTALLED REAR SLIDING WINDOW. THE WINDOW HAS FLOWED WATER/RAIN EVERY TIME. IT SEEMS TO BE COMING IN AROUND THE SEAL WHERE IT MEETS THE CAB OF THE TRUCK. I HAVE TALKED WITH OTHER 97 F-150 OWNERS AND THE SAME THING WAS HAPPENING TO THEIR TRUCKS. ISN'T THERE SOMETHING THAT CAN BE DONE? *AK

I WENT OUTSIDE ONE EARLY MORNING TO START UP MY VEHICLE WHEN I HEARD A LOUD POP THAT ORIGINATED FROM THE ENGINE OF MY 1997 FORD F-150 XLT. I TOOK A LOOK AT THE ENGINE; HOWEVER I AM NO MECHANIC. I ATTEMPTED TO START THE ENGINE AGAIN, BUT THE ENGINE WOULD NOT TURN. I LATER FOUND OUT THAT THE ENGINE WAS LOCKED BECAUSE OF THE COOLANT LEAKING FROM A GASKET INTO THE CYLINDER CAUSING ONE OF THE RODS TO BEND. MY MECHANIC INFORMED ME THAT THE LIQUID WAS NOT ALLOWING THE ROD TO FULLY COMPRESS BECAUSE OF THE PRESSURE CAUSED BY THE LIQUID. NEEDLESS TO SAY, HE TOLD ME THAT THE FORD PICK UPS' ENGINES HAVE THAT PROBLEM AND I WOULD JUST BE WASTING MY MONEY REPAIRING THE ORIGINAL ENGINE. HE ADVISED ME TO SEARCH FOR A REBUILT ENGINE THAT HAD A WARRANTY ON IT. DUE TO THE EXPENSE, MY PICK UP IS SITTING THERE WITH A DEFECTIVE ENGINE. THIS IS THE SECOND FORD I HAD PURCHASED BECAUSE I WAS SO PLEASED WITH THE FIRST FORD VEHICLE. HOWEVER AFTER THIS DISAPPOINTMENT, I PURCHASED A NISSAN INSTEAD. I MAKE SURE THAT I TELL ALL MY FRIENDS AND RELATIVES OF THIS EXPERIENCE WITH FORD AND THE UNSATISFACTORY PRODUCT THEY HAVE PUT OUT. NO WONDER THE TOYOTA TUNDRA AND NISSAN TITAN ARE LEAVING FORD BEHIND! "BUILT FORD TOUGH, RIGHT.... *TR

A 1997 FORD F150 PICK UP TRUCK OWNED BY STEVEN QUAGLIATO CAUGHT FIRE WHILE PARKED AND DAMAGED MY VEHICLE CAUSING APPROX $650 WORTH OF DAMAGED TO THE TAILLIGHT ASSEMBLY AND BUMPER.

TL*THE CONTACT OWNS A 1997 FORD F-150. WHILE DRIVING 60 MPH, THE CONTACT HEARD A LOUD POPPING NOISE COMING FROM THE VEHICLE'S HOOD. HE WAS ABLE TO DRIVE THE VEHICLE HOME, BUT WAS UNABLE TO RESTART THE VEHICLE ONCE HE SHUT IT OFF. THE VEHICLE WAS TOWED TO A MECHANIC WHO STATED THAT COOLANT WAS FOUND IN THE CYLINDERS DUE TO A CRACKED HEAD GASKET OR A CRACK IN THE CYLINDER. THE MECHANIC INSTALLED A REMANUFACTURED ENGINE AND THERE HAVE NOT BEEN ANY MORE FAILURES. THE CURRENT MILEAGE IS 99,600 AND FAILURE MILEAGE WAS 98,780.

ENGINE THREW ROD, JUST LIKE THE FEW THOUSAND OTHER COMPLAINTS I HAVE SEEN ON THE INTERNET. TREATED THIS TRUCK LIKE A BABY, HEARD FROM A FORD MASTER MECHANIC THAT THEY KNEW ABOUT THIS PROBLEM ALREADY ,AND HE ACTUALLY LAUGHED AS HE TOLD ME I WAS SCREWED. HAPPENED ONE MORNING WHEN TO START IT AND BAM BLEW ROD. WAS FULL OF OIL, FULL COOLANT, WET SPARK PLUG AMAZING I COME FROM A 4 GENERATION FORD FAMILY AND BECAUSE OF THIS I WILL NEVER BUY A FORD AGAIN. *AK

RECALL OF THE CRUISE CONTROL DEACTIVATION SWITCH IN THE 1997 FORD F-150 SONS TRUCK CAUGHT FIRE IN THEIR GARAGE FORD DECLINED TO ACCEPT RESPONSIBILITY**CC THE CONSUMER PROVIDED A COPY OF THE RECALL. *TR THE CONSUMER STATED THE DEALER NEVER SENT A RECALL NOTICE TO THE CURRENT ADDRESS AND FURTHER STATES THEY MOVED TO THE LOCATION IN 2006 SO FORD COULD NOT HAVE MAILED THE NOTICE IN 2005 AND THE CONSUMER DID NOT OWN THE VEHICLE IN SEPT. 2005. THE CONSUMER STATED EVEN THOUGH THE RECALL NOTICE DATE WAS LISTED AS DEC 2006, THEY HAD NOT RECEIVED NOTICE UNTIL SPRING 2007. THE CONSUMER STATED FORD SHOULD BE ASHAMED OF PUTTING A CHILD'S LIFE IN DANGER AND FABRICATING THE TRUTH AFTERWARD. *TR

FORD F150 FIRE CAUSED BY CRUISE CONTROL DEACTIVATION SWITCH. VEHICLE IN GARAGE, VEHICLE TOTALED AND GARAGE DAMAGED.

1997 FORD F150 PICKUP TRUCK, THE FIRE APPEARED TO HAVE STARTED UNDER THE HOOD IN THE ENGINE. THE INSURED STATED TO THE FIREMEN THAT IT LOOKED ELECTRICAL . THIS MODEL OF TRUCK HAS BEEN KNOWN TO BURN DUE TO A FAULTY CRUISE CONTROL SWITCH. THEY INCLUDED A COPY OF THE RECALL NOTICE FROM FORD. THE INSURED WAS NOT SURE IF THE RECALL WAS EVER COMPLETED. THEY STATED THE CRUISE CONTROL HAD NOT WORKED IN SOME TIME. *AK

MY FORD F150 1997 WAS PARKED IN MY DRIVEWAY WHEN THE ALARMS SOUNDED. I CHECKED AND THOUGHT AT FIRST SOMEONE MIGHT BE TRYING TO STEAL THE TRUCK THEN. I THEN SAW IT WAS ON FIRE. I GOT THE WATER HOSE AND TOLD MY WIFE TO CALL THE FIRE DEPT. SHE ALSO CALLED A COUPLE OF OUR NEIGHBORS TO HELP. THE VFD CAME ALONG WITH THE SHERIFF AND DEPUTY SHERIFF. NO ONE WAS INJURED, BUT THE TRUCK WAS TOTALED.

CRUISE CONTROL HAD NOT WORKED FOR A FEW MONTHS. JUST BACKED TRUCK INTO DRIVEWAY FROM PARKED ON STREET. WENT INTO THE HOUSE. WITHIN 5 MINUTES, MY NEIGHBORS ALERTED ME TO THE FIRE. I PUT IT OUT WITH AN EXTINGUISHER. THE ORIGIN OF THE FIRE WAS AT THE CRUISE CONTROL SWITCH AT THE MASTER CYLINDER. VEHICLE IS IN THE PROCESS OF BEING FIXED AT THIS TIME. *TR

A COOPER DOMINATOR SPORT A/T TIRE OF THE TYPE THAT IS CURRENTLY THE SUBJECT OF EA 06 -021 EXPERIENCED A TREAD SEPARATION WHILE MOUNTED ON THE REAR AXLE OF A FORD F150. THE TREAD SEPARATION LED TO A LOSS OF CONTROL AND VEHICLE ROLLOVER THAT RESULTED IN THE DEATH OF ONE MAN AND INCAPACITATING BRAIN INJURIES TO ANOTHER. THE TIRE HAD 7/32 OF TREAD AND WAS IN GOOD CONDITION BEFORE THE FAILURE. THE TIRE WAS WELL MAINTAINED AND SHOWED NO SIGNS OF ABUSE OR MISUSE. THE TIRE THAT FAILED WAS MANUFACTURED IN 2004 AT COOPER'S FINDLAY, OHIO PLANT. *TR

TL*THE CONTACT OWNS A 1997 FORD F-150. WHILE DRIVING 45 MPH, THE CONTACT HEARD A KNOCKING NOISE COMING FROM THE ENGINE. THE VEHICLE WAS BROUGHT TO THE DEALER AND THE ENGINE WAS REPLACED. AS A RESULT, THE ENGINE BEGAN TO OVERHEAT AND A SIGNIFICANT LOST OF COOLANT RESULTED DUE TO A RESERVOIR FAILURE. AT 80,000 MILES, THE CONTACT BEGAN TO EXPERIENCE OIL PRESSURE FAILURE, WHICH THE DEALER STATED WAS CAUSED BY A BENT PISTON ROD ON THE CRANK CASE. THE MANUFACTURER WOULD NOT ASSIST THE CONTACT BECAUSE THE VIN EXCLUDED THE VEHICLE FROM THE RECALL. FORD CLAIMED TO HAVE ONLY ISSUED A PARTIAL LEVEL B RECALL. THE FAILURE ORIGINATED 6 WEEKS AGO, BUT HAS BEEN ONGOING SINCE JUNE OF 2006. THE TECHNICIAN SUGGESTING WAITING UNTIL THE ENGINE FAILS TO HAVE IT REPLACED AGAIN. THE CURRENT MILEAGE IS 850 AND FAILURE MILEAGE WAS 108,000.

TL*THE CONTACT OWNS A 1997 FORD F-150. THE SPARE TIRE CARRIER DETACHED FROM THE END OF THE SPARE TIRE RETAINER. THE CONTACT WAS TRAVELING 35 MPH ,AND STATED THAT THE VEHICLE DID NOT HIT ANY BUMPS. THE CURRENT AND FAILURE MILEAGES WERE 81,000.*AK THE CONSUMER STATES THAT THE RETAINER WAS AT THE END OF THE CABLE ASSEMBLY USED TO LOWER AND RAISE THE SPARE TIRE. THE CONSUMER ALSO STATES THAT THE TIRE BOUNCED 6FT IN THE AIR AND ALMOST HIT THE CARD BEHIND HIM. UPDATE 05/04/07*TR

WHILE TRAVELING ON INTERSTATE AT 70 MPH WITH CRUISE CONTROL SET VEHICLE BEGAN ACCELERATING WHILE CLIMBING A GRADE. SPEED CONTINUED TO INCREASE WELL PAST 70 MPH SET POINT. I TAPPED BRAKE TO DISENGAGE SPEED CONTROL WITH NO SUCCESS. I HAD TO BRAKE AGAINST ACCELERATING ENGINE WITH SPEED CONTROL STILL ENGAGED. THE ONLY WAY I COULD BRING VEHICLE UNDER CONTROL WAS TO SHIFT INTO NEUTRAL, TURN OFF ENGINE, AND COAST TO SIDE OF ROAD. I DISCONNECTED RECENTLY INSTALLED , FORD RECALLED, VEHICLE SPEED CONTROL WIRING HARNESS, AND ACTIVATED THE SPEED CONTROL ON/OFF STEERING WHEEL SWITCH. COMBINATION OF ACTIONS DISENGAGED SPEED CONTROL WITH NO FURTHER INCIDENT. ON 4/11/07 HAD VEHICLE LOOKED AT BY FORD SERVICE CENTER; NOTHING OUT OF ORDINARY WAS FOUND. *AK

MY NON-COMMERCIAL TWO WHEEL DRIVE, 1997 F-150 WITH 59747 MILES WITH 4.2 V-6 ENGINE BLEW ITS 4R70W AUTOMATIC TRANSMISSION . I WAS NOT ABLE TO GO FORWARD BUT COULD GO IN REVERSE. THERE WAS NO SIGN OF FAILURE AND THE TRANNY FILTER AND FLUID HAD BEEN SERVICED TWO TIMES. IT COST $ 2121.52 TO REBUILD THE TRANNY AT A TRANSMISSION REPAIR SHOP. FORD'S CUSTOMER SERVICE CENTER SAID THERE IS NOTHING THEY CAN DO AND DID NOT WANT TO DISCUSS ANYTHING WITH ME OR THE TRANNY SHOP TO FIND OUT MORE. ALSO THE TIMING CASE COVER GASKET,BRAKE CALIPERS AND SPEEDOMETER HAVE BEEN REPLACED ALSO. *JB

I JUST GOT MY 1997 FORD F150 XLT WITH THE 4.2L ENGINE BACK YESTERDAY, AFTER PAYING $1430 FOR ENGINE REPAIRS. THIS TRUCK ONLY HAS 47,700 MILES ON IT. I WENT OUT TO THE TRUCK ONE DAY AND TURNED THE KEY, AND - NOTHING. TURNS OUT TO BE HYDRO LOCK BUT I DIDN'T KNOW IT AT THE TIME. I FINALLY GOT IT STARTED, & GOT IT INTO THE DEALER, AND THE TECHNICIAN THOUGHT IT NEEDED TO BE TUNED UP, PLUS I WAS HAVING THE HEAT FADE AT STOPS SO HE FLUSHED & REFILLED THE COOLANT. I MENTIONED THAT I WAS HAVING TO TOP OFF THE COOLANT ABOUT ONCE A MONTH, BUT I DIDN'T KNOW WHERE THE COOLANT WAS GOING, AND IT WASN'T SHOWING UP IN THE OIL. I GOT IT BACK, AND IT WAS STILL RUNNING REALLY BAD, SO I DROPPED IT OFF AGAIN 2 DAYS LATER. THIS TIME HE THOUGHT IT WAS THE COIL PACK. THEY HAD IT AGAIN FOR ANOTHER DAY, REPLACED THE COIL PACK AND A SENSOR. I GO OUT TO THE LOT AND START IT, AND IT WAS STILL RUNNING REALLY BAD. SO, I GO BACK IN & GET THE TECHNICIAN, AND HE CAME OUT TO CHECK IT HIMSELF, AND HE WAS AMAZED AT HOW BAD IT WAS RUNNING. WE TOOK IT FOR A RIDE, AND IT SMOOTHED OUT A LITTLE, BUT IT WAS STILL NOT RIGHT. I TOLD HIM I WOULD LET HIM CONSULT HIS BOSS, AND CALL THEM BACK ON MONDAY. MONDAY COMES, AND I GO TO START IT TO GO TO WORK, AND - HYDRO LOCK AGAIN. SO, I TAKE MY WIFE'S CAR TO WORK, AND CALLED THEM FROM THERE, AND TOLD THEM WHAT IT WAS DOING. THEY WERE THERE WITHIN A HALF HOUR TO GET IT. THIS TIME I GET A CALL FROM THE SERVICE MANAGER, AND HE TOLD ME THAT HE PUT HIS BEST TECHNICIAN ON IT, AND WOULD

1997 FORD F150 4.2 V6 OIL PRESSURE FALLS TO ZERO AFTER WARM UP... WITH WARNING. I WAS DECEPTIVELY SOLD THIS PROBLEM WITHOUT WARRANTEE JUST LAST MONTH. MY TRUCK HAS ONLY 66K MILES AND NOW I DISCOVER A BIG ONGOING PROBLEM... JUST BY PLACING THIS TOP LINE IN ANY SEACH ENGINE YOU'LL REACH... HTTP://FORUMS.TREEMEDIA.COM/FB/SHOWTHREAD.PHP?T=224 THAT IS 400 HITS OF THE SAME PROBLEM WHICH LEADS TO ENGINE FAILURE. EVEN IF ITS REPAIRED PRIOR TO FAILURE.

MY 1997 FORD F-150 HAS HAD 3 UNCOMMANDED THROTTLE SURGES THAT I COULD NOT STOP UNTIL I TURNED THE IGNITION OFF. THE FIRST TIME IT HAPPENED, I RODE THE BRAKES AND WAS ABLE TO SLOW DOWN TO AROUND 55 MPH BUT IT WOULDN'T STOP UNTIL I TURNED THE IGNITION ON AND OFF 3 TIMES. I TOOK THE VEHICLE TO A FORD DEALER AND THEY ADVISED THAT EVERYTHING CHECKED OUT JUST FINE. THEY SEEM TO THINK I DON'T KNOW HOW TO USE THE CRUISE CONTROL...THE CRUISE CONTROL WAS NOT ON DURING ANY OF THESE EPISODES. THERE WAS AN ARTICLE ON THE INTER NET WHERE A POLICE CROWN VICTORIA DID THE SAME THING AND THE END RESULT WAS AN ACCIDENT.

TL*- THE CONTACT STATED THAT HER 1997 FORD F-150 XLT HAD A PROBLEM WITH THE THROTTLE. THE CONTACT STATED THAT ON COLD DAYS WHILE DRIVING AT 50 MPH THE ACCELERATOR PEDAL STAYED DOWN AND BECAME STUCK WHEN TRYING TO COME TO A STOP. ALSO, WHILE DRIVING AT THIS SPEED AND TRYING TO COME TO A STOP OR SLOWING DOWN THE ACCELERATOR PEDAL CONTINUED TO GO AT A HIGH SPEED. THERE WAS RECALL 96V251000 FOR THE VEHICLE SPEED CONTROL. SHE CONTACTED THE MANUFACTURER, AND THEY INFORMED HER THAT THE VEHICLE WAS NOT ON THE RECALL DUE TO THE VIN. TOOK THE VEHICLE TO THE DEALERSHIP, AND FOUND THAT THERE WAS A SERVICE BULLETIN ON THE VEHICLE ,AND SHE THOUGHT THAT SHE SHOULD BE REIMBURSED FOR THE REPAIRS DUE TO THE FAULTY THROTTLE. THE CURRENT AND FAILURE MILEAGE WERE BOTH 11500.*AK UPDATED 04/05/07. *JB

HYDRO LOCK 1997 FORD 4.2 V6 44,000 MILES. *NM

1. FAILURE OF FORD MOTOR COMPANY AND DEALER WHERE VEHICLE WAS PURCHASED NEW, FAMILY FORD SALES INC., FLORENCE, AL TO NOTIFY CUSTOMER OF DEFECT WITH 1997 4.2 L V6 ENGINE AS PUBLISHED IN FORD SERVICE PROGRAM, NUMBER 99B29 WHICH COULD LEAD TO ENGINE FAILURE THROUGH ENGINE FRONT COVER GASKET FAILING AND POLLUTING THE OIL WITH COOLANT, RESULTING IN DESTROYED ENGINE. FURTHER FAMILY FORD SALES INC. DIAGNOSED THIS PROBLEM ON THIS VEHICLE 11/20/02 AND REPAIRED IT FOR $432.08 COST TO OWNER. NO MENTION OF THE FORD NO-CHARGE SERVICE PROGRAM OR POSSIBLE ENGINE DAMAGE WAS GIVEN AT THIS TIME. 2. FAILURE OF 1997 FORD F150 ENGINE WITH 87,522 MILES DUE TO A KNOWN FAILURE TO FORD MOTOR OF FAULTY GASKETS (LOWER INTAKE MANIFOLD (FORD TSB 99-20-7) AND ENGINE FRONT COVER GASKET FAILING AND POLLUTING THE OIL WITH COOLANT (FORD SERVICE PROGRAM, NUMBER 99B29) NEITHER OF WHICH WERE COMMUNICATED TO THE ORIGINAL OWNER OF THE VEHICLE. THIS ACTION CAUSED $3,061.20 OF DAMAGE DUE TO REPLACEMENT OF ENGINE LONG BLOCK 1/26/2007 THE BABBITT WAS REMOVED FROM ENGINE BEARINGS, RESULTING IN LOW OIL PRESSURE AND ENGINE OIL LIGHT COMING ON WHICH WAS DIAGNOSED BY FAMILY FORD ON 1/5/2007 (COST $73.50). AGAIN FORD SERVICING DEALER/OEM SELLING DEALER DID NOT INFORM CUSTOMER OF ANY ISSUES WITH THIS ENGINE OR EARLIER NO-CHARGE SERVICE PROGRAM. FAILURE TO NOTIFY OR FRAUDULENT ACTIONS BY THE DEALER AND FORD MOTOR COMPANY HAVE COST ME OVER $3,500 AND THE LOST TIME ASSOCIATED WITH THIS FAULTY PRODUCT. VEHICLE VIN IS [XXX]. DOCU

1997 FORD 150, 144,000 MILES. ENGINE KNOCKS AND IS LOOSING COOLANT. AFTER DOING RESEARCH JUST FOUND OUT THIS WAS A COMMON PROBLEM WITH THE 4.2L V6 ENGINE. I NEVER RECEIVED A RECALL FROM FORD STATING A PROBLEM WITH THE MANIFOLD GASKET. I AM THE ORIGINAL OWNER. *NM

TL*- THE CONTACT STATED THAT WHILE THE 1997 FORD F-150 WAS PARKED IN THE DRIVEWAY THE VEHICLE CAUGHT ON FIRE UNDER THE HOOD. THE FIRE DEPARTMENT ARRIVED TO EXTINGUISH THE FIRE. THE FIRE DAMAGED THE ENGINE, ELECTRICAL WIRING, PIPING ,AND ANYTHING THAT WAS MADE OF PLASTIC MELTED IN THE VEHICLE. THE CONTACT COULD PROVIDE PICTURES OF DAMAGED VEHICLE, AND A FIRE DEPARTMENT REPORT.*AK UPDATED 02/28/07. *JB

TL* - THE CONTACT HAS A 1997 FORD PICKUP F150. THE CONTACT STATED THAT ON 01/22/2007 HE WAS MAKING A TURN WHEN THE STEERING WHEEL LOCKED AND HE RAN OFF THE ROAD. THIS HAS HAPPENED AT LEAST THREE OTHER TIMES WHILE HE WAS DRIVING. THE CONTACT STATED THAT THERE WAS A PLATE IN THE COLUMN THAT IS LOOSE AND COULD PUSH UP AND DOWN AN INCH. THE WEATHER WAS NOT A FACTOR, AND HE WAS DRIVING APPROXIMATELY 15 MPH AT THE TIME OF THE LAST FAILURE. *AK UPDATED 02/22/07*JB

AT AROUND 5:45 PM EST 1/13/2007 MY HUSBAND WAS WORKING ON OUR COMPUTER WHILE MY SON AND I WATCHED A MOVIE. THE DOORBELL RANG AND I WENT OUTSIDE TO FIND MY HUSBAND'S 1997 FORD F150 WITH FLAMES SHOOTING HIGH OUT OF THE HOOD. I GRABBED MY SON AND CAME BACK INSIDE AND SCREAMED FOR MY HUSBAND. HE GRABBED A FIRE EXTINGUISHER AND TRIED TO PUT OUT THE FIRE BUT IT WAS FAR TOO INVOLVED. A NEIGHBORHOOD KID HAD BEEN WALKING BY AND SAW THE FIRE AND RANG THE DOORBELL - HE WAITED WITH US DOWN THE STREET FOR THE FIRE TRUCKS. I CALLED 911 AND EVACUATED THE HOUSE AND RAN DOWN THE STREET. THE FIRE DEPARTMENT ARRIVED WITHIN 5 MINUTES OR SO - WHILE WE WAITED THERE WERE SEVERAL MINOR EXPLOSIONS BUT THE FIRE DEPARTMENT WAS ABLE TO EXTINGUISH THE FIRE BEFORE IT GOT TO THE HOUSE (ONLY A FEW FEET FROM THE TRUCK) OR THE OTHER CAR PARKED RIGHT NEXT TO THE TRUCK IN THE DRIVEWAY. THE TRUCK IS COMPLETELY DESTROYED - THE HOOD AND WINDSHIELD ARE GONE - THE INTERIOR IS BLACK AND DEVASTATED AND THE TIRES ARE MELTED - THE PAINT IS GONE - IT LOOKS NOTHING IT DID A FEW HOURS AGO. *JB

COMPLAINT: FORD MOTOR COMPANY, POOR DESIGN OF LOWER INTAKE PLENUM/MANIFOLD GASKET IN THE ESSEX 4.2L V-6. 1: EVENTS LEADING UP TO THIS FAILURE ORIGINALLY THERE WERE NO OBVIOUS SIGNS OF IMPENDING FAILURE. THE INDICATIONS OF FAILURE ARE LOSS OF ENGINE COOLANT WITH NO VISIBLE EXTERNAL LEAK, AND COOLANT IN THE COMBUSTION CHAMBER. 2: FAILURE AND IT'S CONSEQUENCES THIS DEFECT ALLOWS COOLANT LEAKAGE INTO THE COMBUSTION CHAMBER, CAUSING A HYDRAULIC LOCKING CONDITION WHICH WILL BREAK/BEND ONE OR MORE CONNECTING RODS. THIS RENDERS THE ENGINE UNUSABLE, AND IT MUST BE PULLED, REPAIRED IF POSSIBLE (SOME ARE NOT), AND RE-INSTALLED. 3: FAILURE CORRECTION. IN MOST CASES THE ENGINE CAN BE REPAIRED BY REPLACING A CONNECTING ROD, PISTON, AND CRANKSHAFT, AND ALL THE OTHER ASSOCIATED PARTS THAT ARE INVOLVED WITH THIS LEVEL OF DISASSEMBLY. IN SOME CASES THE CONNECTING ROD WILL BREAK AND DAMAGE THE BLOCK BEYOND REPAIR. THIS HAPPENED IN MY CASE. THE REPLACEMENT ENGINE WAS OVER $2000, NOT TO MENTION THE LABOR INVOLVED IN IT'S REPLACEMENT. FORD MOTOR COMPANY IS AWARE OF THIS DESIGN FLAW, AND HAS ISSUED A TECHNICAL SERVICE BULLETIN REGARDING IT. HOWEVER, TO THIS DAY THEY WILL STILL NOT OFFER ANY AID, IN ANY FORM, FOR DAMAGES INCURRED DUE TO THIS DESIGN FLAW. *NM

THIS WEEK THE ENGINE IN MY 1997 F-150 BLEW. THE PLUGS WERE WET. COOLANT LEAKED. I WENT ON THE INTERNET TO SEE ABOUT PURCHASING AN ENGINE AND I FOUND A WEBSITE CALLED FIGHT BACK WITH DAVID HORIWITZ. THERE ARE 27 PAGES OF COMPLAINTS THAT ARE EXACTLY THE SAME AS MINE. HTTP:WWW.FORUMS.TREEMEDIA.COM/FB/SHOWTHREAD.PHPT=224 YOU NEED TO SEE FOR YOURSELF. IT IS UNBELIEVABLE. *JB

MY TRUCK FORD F150 1997 WAS PARKED ON FRONT DRIVEWAY AND GET ON FIRE BY ITSELF. ENGINE WAS COLD AND TRUCK WAS IDLE FOR MORE THAN 4 HOURS. DAMAGE WAS TOTAL. FIRE MARSHAL WAS AT THE SCENE AND GET TO THE CONCLUSION THAT FIRE WAS CAUSED BY CRUISE CONTROL SWITCH. *NM

TL* - WHILE DRIVING THE TIRE STARTED WOBBLING. THE WEATHER CONDITIONS AT THE TIME OF THE FAILURE WAS CLEAR AND SUNNY. THE TIRE DISENGAGED, AND THE CONTACT CAME TO A STOP. THE TIRE WAS NEW, AND ONLY BEEN DRIVEN 15 MILES. THE TIRE ALWAYS TEARS BETWEEN THE BEAD AND SIDEWALL. *AK UPDATED 04/05/07

LOW ON COOLANT- OIL PRESSURE STARTED TO DROP, COOLANT IN OIL. AFTER READING CONSIDERABLY ABOUT THIS ON INTERNET FOUND OUT ABOUT TSP #99B29 AND THE RESULTING ONP DO NOT BELIEVE THIS WAS EVER FIXED I AM SECOND OWNER AND THE ONP EXPIRED IN 2001. FORD SHOULD HAVE TO CORRECT THIS PROBLEM LEAKING GASKET. MANY MANY COMPLAINTS ON WEBSITES REGARDING THIS. I HAVE SMALL CHILDREN AND CANNOT AFFORD A $4000 MOTOR BECAUSE FORD DID NOT GET IT RIGHT AND WILL NOT FIX THE PROBLEM WITH A RECALL. SOMEONE NEEDS TO MAKE FORD RESPONSIBLE FOR THEIR ERRORS. *NM

MY 1997 FORD F-150 4.2 L 6 CYLINDER MYSTERIOUSLY THROUGH A ROD AT 80K MILES RESULTING IN THE REPLACEMENT OF THE ENTIRE ENGINE. FROM WHAT I HAVE READ THIS HAS BEEN A COMMON PROBLEM PLAGUING MANY FORD CUSTOMERS, YET FORD HAS PROVIDED NO RELIEF. AN EXPENSIVE $4000 REPAIR! *JB

I OWN A 1997 FORD F150 4.2L. MY TRUCK HAS BEEN LOSING COOLANT FOR A WHILE! I HAVE REPLACED THE WATER PUMP, REPLACED HOSES, REPLACED THERMOSTATS,ETC. MY TRUCK IS NOW HAVING A TICKING SOUND WHEN I START IT IN COLD WEATHER. I HAVE COME TO FIND THAT FORD MOTOR COMPANY HAD PREVIOUSLY ISSUED A RECALL ON THIS TRUCKS ENGINE FOR A FAULTY INTAKE MANIFOLD GASKET. I WAS NEVER INFORMED OF THIS RECALL!!! I WAS INFORMED OF OTHER RECALLS LIKE LUG NUT FAILURE, CRUISE CONTROL CABLES,ETC, BUT NEVER ABOUT THE MOST EXPENSIVE, MOST VITAL PART OF THE TRUCK THE ENGINE. THE INFORMATION OF THE RECALL WAS DISCOVER AS I WAS ON THE WEB TRYING TO FIND OUT HOW TO FIX THE KNOCKING SOUND. THE WEB SITE HAD OVER 350 MESSAGES OF PEOPLE WITH THE SAME PROBLEM!!! PLEASE HELP!! *JB

COOLANT RUNNING LOW,STARTED MY TRUCK AND IT STARTED KNOCKING VERY LOUD,AND THE ENGINE LOCKED UP ALMOST INSTANTLY,HAD TO HAVE ENGINE REBUILT AND NOW IT IS KNOCKING AGAIN. *NM