1997 Ford F-150 complaints

ON OCCASION, TRUCK WOULD HESITATE, TAKING A BIT OF TLC ON THE GAS PEDAL TO CLEAR IT UP. ONE OCCASION, IN TRAFFIC, ATTEMPTING TO AVOID A NEAR MISS, I ACCELERATED THROUGH THIS. WHITE SMOKE BEGAN POURING OUT THE TAIL PIPE. HEAD GASKET FAILURE. LIMPED HOME. ENGINE HYDRO-LOCKED. DIAGNOSIS = REPLACE HEAD GASKETS ($2,100) IN THIS SAME 'WEAK' 4.2 V-6 OR REPLACE MOTOR ($2,500) WITH NEWER 4.2 V-6. REPLACEMENT WILL BE DONE TOMORROW. FORD FAULTY ENGINE / GASKETS - NOT MY FAULT. MY PROBLEM THOUGH. *JB

F150 FORD RIGHT SIDE UPPER HEAD GASKET FAILURE. *NM

MY 1997 FORD F150, 4.2L V6, HAS BEEN LOSING COOLANT SINCE ABOUT 2004. MY SON HAD A DIFFICULT TIME STARTING THE VEHICLE ONE AFTERNOON. FINALLY I GOT IT STARTED AND DROVE 5 MILES HOME. THE NEXT AFTERNOON THE CAR STARTED QUICKLY BUT IMMEDIATELY STARTED BANGING AWAY. MY MECHANIC SAYS THE ENGINE IS DEAD - BAD ROD. NOW I FIND OUT FROM THE INTERNET THAT THIS IS A KNOWN ISSUE WITH THIS ENGINE BUT FORD REFUSES TO ACKNOWLEDGE IT. TRADE IN VALUE ON THE CAR IS ZERO BECAUSE ALL THE 2ND TIER DEALERS KNOW ABOUT THE ENGINE PROBLEM. I'M OUT THE COST OF A NEW ENGINE (SEEMS ONLY FAIR AFTER MY 96 WINDSTAR NEEDS NEW HEAD GASKETS BECAUSE THEY WEAR OUT AT 30K MILES) APPARENTLY IF YOU KNOW A FORD MECHANIC, HE WILL TELL YOU THE MOTOR HAS BEEN BAD SINCE THE DAY IT WAS FIRST MANUFACTURED. THIS MOTOR SHOULD NOT HAVE FAILED AND HAD IT NOT BEEN FOR THE FAULTY GASKET LEAKING COOLANT INTO THE MOTOR IT WOULDN'T HAVE. FROM READING WEB SITES I HAVE FOUND THAT FORD ISSUED A RECALL ON THE GASKET AND THEN PULLED IT. I NEVER RECEIVED A BULLETIN ON THE FAULTY GASKET. DON'T EXPECT TO OWN ANOTHER FORD, BUT SOME FINANCIAL HELP WOULD SURE SOOTHE MY FRUSTRATION IF SOMEONE WANTS THE PARTS TO USE TO ACQUIRE COMPENSATION FROM FORD I CAN KEEP THE DEAD ENGINE FOR A COUPLE OF WEEKS. *JB

WHILE TRAVELING ON THE FREEWAY, HEARD A LOUD NOISE COMING FROM REAR OF TRUCK AND WHAT APPEARED TO BE A BLOWOUT. AS I CHANGED LANE TO GET TO THE SHOULDER I SAW WHAT APPEARED TO BE PIECES OF TIRE COMING FROM THE REAR OF THE VEHICLE. ONCE PULLED OVER, I GOT OUT TO INVESTIGATE, AT FIRST EVERYTHING SEEMED TO BE OK UNTIL I LOOKED AT THE RIGHT REAR TIRE, SAW THAT THE TIRE WAS STILL INFLATED, BUT THE TREAD HAD SEPARATED FROM THE TIRE, THE SIDEWALLS WERE IN PERFECT CONDITION, BUT THE TREAD HAD JUST PEALED AWAY FROM THE CENTER. *MM

DT*: THE CONTACT STATED THE REPAIR FOR NHTSA RECALL # 05V388000, PERTAINING TO THE VEHICLE SPEED CONTROL, WAS PERFORMED ON THE VEHICLE. HOWEVER, AFTER 2 WEEKS, THERE WAS A SMELL INSIDE THE CAB OF THE VEHICLE OF SOMETHING BURNING. THIS WAS FOLLOWED BY THE CRUISE CONTROL FAILING. THE VEHICLE WAS TAKEN BACK TO THE SERVICE DEALER THAT ORIGINALLY PERFORMED THE WORK, WHO THEN INFORMED THE CONTACT THAT THE REPAIR PART OF THE RECALL HAD BEEN FULFILLED. THE MANUFACTURER WAS CONTACTED, WHO WAS UNABLE TO FIND THE VIN IN THE RECALL, EVEN THOUGH THE CONTACT HAD RECEIVED THE NOTICE.

HYDRO-LOCK ON 1997 FORD F-150 WITH 4.2L V6 CAUSED BENT ROD. ENGINE HAD TO BE REPLACED. THE FORD ON-99B29 WAS EXERCISED IN 2000 WHICH WAS SUPPOSE TO PREVENT THIS TYPE OF FAILURE. *NM

DT*: THE CONTACT STATED WHILE PULLING OUT OF THE DRIVEWAY AT 3 MPH, WHEN THE BRAKES WERE APPLIED, THE PEDAL WENT TO THE FLOOR. AN INDEPENDENT REPAIR SHOP DETERMINED THE BRAKE LINE HAD RUSTED AND EXPLODED. UPDATED 10/4/2006 - *NM

1997 FORD F-150 4.2L V6. ENGINE FAILURE. BROKEN ROD FOLLOWING HYDRO LOCK. PROBLEM PRECEDED WITH COOLANT LEAK AND REPLACEMENT OF TIMING CHAIN COVER GASKET. *JB

I HAVE A 1997 FORD F150 PICKUP. IT HAS THE 4.2L V6. I HAD 84,000 MILES ON THE VEHICLE AND HAD TO REPLACE THE MOTOR DUE TO A BENT ROD. THE ROD DAMAGE WAS CAUSED BY A LEAKING GASKET THAT ALLOWED COOLANT INTO THE CYCLINDER. WHEN THE TRUCK WAS ATTEMPTED TO BE STARTED THE FLUID (DOES NOT COMPRESS) PREVENTED THE PISTON FROM FULL TRAVEL AND BENT THE ROD. THIS IS A SERIOUS DEFECT. FORD IS AWARE OF THIS AND DENIES EVERYTHING. AFTER THIS HAPPENED, I BECAME AWARE OF MANY MANY OTHERS WITH THE SAME PROBLEM. *NM

I DRIVE AN IMPORTED F150 FROM 1997 (4X4, 5.4 ENGINE). LAST WEEK MY CRUISE STOPPED WORKING. AFTER INSPECTION AND SURFING THE NET, I CAME TO THE CONCLUSION THAT THE PROBLEM IS THE SAME A LOT OF F150 HAD (HAVE), OIL LEAK TO THE CRUISE-CONNECTOR. A FRIEND OF MINE WHO OWNS A GARAGE, INSPECTED CAREFULLY AND CAME TO THE SAME CONCLUSION. I WROTE TO FORD.COM TO ASK FOR HELP TO GET THE PROBLEM FIXED. NO REACTION. I ONLY ASK FOR THE REPLACEMENT PARTS I NEED AND THE NECESSARY INSTRUCTIONS TO DO THE REPAIRS, NOT MORE. PERHAPS YOU CAN HELP ME TO GET THE PROBLEM FIXED. I LOVE THAT TRUCK AND I JUST WANT TO KEEP DRIVING AS SAFE AS POSSIBLE. FOR THE MOMENT I DISCONNECTED THE CRUISE (AS RECOMMENDED ON A LOT OF FORD-FORUMS).*JB

MANIFOLD STUDS RUSTED AWAY CAUSING EXHAUST PIPE TO SEPARATE FROM MANIFOLDS. AS A RESULT OF THIS FAILURE, EMISSIONS PORTION OF NYS INSPECTION WAS FAILED. REPAIR IS REQUIRED TO PASS INSPECTION, AND IS ESTIMATED BY NEW COUNTRY FORD TO BE APPROXIMATELY $2200.00. I BELIEVE THIS TO BE AN EXCESSIVE EXPENSE AS A RESULT OF THE MANUFACTURERS POOR DESIGN AND QUALITY OF PARTS. *JB

FORD F-150 V-6 4.2L MOTOR COOLANT CAUSED THE MOTOR TO THROW A ROD. *NM

THIS IS SHORT. MY 5.4 BLEW A SPARK PLUG OUT OF THE HEAD. FORD HEADS ONLY HAVE .250 IN. OF THREADED DEPTH IN HEAD NOT ENOUGH. *JB

DT*: THE CONTACT STATED THE FUEL TANK FELL OUT DUE TO RUSTED STRAPS. THE VEHICLE IS NOT GARAGED. THE CONTACT EXPRESSED THE THAT THE TANK SHOULD NOT HAVE RUSTED OUT. UPDATED 08/01/06. *JB

I BOUGHT A 1997 FORD XL V-6 4X4 FROM NOLLER FORD IN TOPEKA, KS BRAND NEW . I WAS TOLD THIS V-6 ENGINE WAS THE GREATEST THING EVER INVENTED BY FORD. I NOTICED THAT ABOUT EVERY OIL CHANGE I HAD TO TOP OFF THE COOLANT. I CALLED TOPEKA FORD ABOUT THIS APPROXIMATELY 6 MONTHS AFTER I DROVE THE TRUCK--I WAS TOLD IT WAS NORMAL FOR THIS MOTOR. I TOOK THEIR WORD. MY SON IS IN THE MILITARY AT NELLIS AFB IN LAS VEGAS NEVADA. HE DROVE MY TRUCK THERE AND CALLED ME LAST NIGHT SAYING THE MOTOR LOCKED UP.(IT HAS ABOUT 112,000 MILES ON IT) I CALLED THE LAS VEGAS FORD DEALERSHIP AND TALKED WITH FERNANDO AND HE INFORMED ME THAT THERE WAS NOTHING WRONG WITH THE FORD V-6---PLEASE LOOK INTO THIS!!!! I THEN CALLED A FORMER FORD MECHANIC AND ASKED HIM WHAT MY SON COULD DO---HE STATED THAT FORD HAD MANY PROBLEMS WITH THE V-6 AND MOST WAS DUE TO SOME HEAD GASKET PROBLEMS (OR SOMETHING LIKE THAT) AND MANY PEOPLE HAVE HAD THEIR ENGINES SEIZE UP DUE TO THIS. I HAVE READ SEVERAL WEBSITES WITH A LOT OF PEOPLE HAVING THE SAME COMPLAINT AS I DO---WHY DOESN'T FORD STEP-UP? I HAVE BOUGHT QUITE A FEW FORDS BUT IF THEY CHOOSE NOT TO FIX THIS PROBLEM, THIS WILL BE THE LAST ONE. SOME FORD OWNERS HAVE HAD FORD SEND THEM A RECALL NOTICE FOR THE GASKET ISSUE---WHY HAVEN'T I???? MY SON IS DUE TO BE DEPLOYED TO IRAQ SOON AND HE SHOULDN'T HAVE TO WORRY ABOUT WHAT WILL HAPPEN TO THIS TRUCK. HE DOES NOT HAVE THE MONEY TO FIX IT, NOR DO I---FERNANDO WAS QUICK TO POINT OUT THAT FOR $4000 IT COULD BE FIXED, I ASKED HOW HE CAM

I HAD THE 05S28 FORD RECALL PERFORMED ON MY F150 ON 9/12/05 - THEY DID NOT DISCONNECT MY CRUISE CONTROL TO WAIT FOR THE NEW HARNESS - THEY INSTALLED A BRAKE KIT - AT CHRISTMAS TIME - I WENT HOME TO MINNESOTA AND HAD PROBLEMS WITH THE CRUISE CONTROL ON THE WAY BACK - WHEN I GOT HOME I CALLED THE DEALERSHIP AND THEY SAID THAT THERE WAS A PROBLEM WITH SOMETHING WITH THE CRUISE IN NORTHERN CLIMATES ICING UP AND IF IT DIDN'T STOP WHEN I WAS HOME IN OKLAHOMA TO CALL THEM BACK - IT DIDN'T DO IT ANYMORE SO I DIDN'T CALL BACK. ON JULY 8TH I WENT TO BROKEN ARROW AND AFTER I SHUT MY TRUCK OFF AND PARKED IT - IT CAUGHT FIRE AND BURNED TO THE GROUND. ONLY TOOK ABOUT 8 MINUTES TO BURN. EVERYTHING FROM THE CAB BACK WINDOW FORWARD IS BURNED TO A CRISP. THE FIREMAN SAID THEY WERE WRITING IT UP AS ENGINE ELECTRICAL MALFUNCTION. EVERYTHING ON THE DRIVERS SIDE IS GONE - THE BATTERY IS COMPLETELY MELTED AWAY - THE INTAKE MANIFOLD IS MELTED - THERE IS MORE MISSING AND MELTED ON THE DRIVERS SIDE - SO THE FIREMAN SUSPECT IT STARTED THERE ON THE DRIVERS SIDE IN THE ENGINE COMPARTMENT. THERE WERE NO INJURIES. THE FIRE WAS SO HOT THAT IT MELTED SOME PALLETS OF PVC PIPE THAT WERE STACKED ABOUT 8 FEET FROM WHERE I PARKED THE TRUCK AND THEY FELL OVER ON TOP OF THE TRUCK AND ONE OF THE FIREMEN. THEY GOT HIM OUT AND HE WAS UNINJURED. I LOST MY TRUCK, THE FIREMAN GOT MY TRAILER UNHOOKED WITH MINIMAL DAMAGE, I LOST MOST OF MY TOOLS AND A LOT OF PERSONAL BELONGINGS. POLICE CAME BUT LEFT IT UP TO FIRE DEPARTMEN

BROKEN BOLTS TO THE STEERING BOX. NO INCIDENT INVOLVED. STEERING CONTROL BECAME LOOSE. DIAGNOSIS OF PROBLEM WAS A LOOSE STEERING BOX FROM BOLT FAILURE. ADDITIONAL FAILURES OF REMAINING BOLTS WOULD CAUSE LOSS OF STEERING CONTROL. *NM

1997 FORD F150 4.2 MOTOR FAILURE. I HAVE HAD TO ADD COOLANT A FEW TIMES OVER THE PAST FEW YEARS AND COULD NOT FIND ANY LEAK, KEPT THE OIL CHANGED EVERY 3 THOUSAND MILES. THE MOTOR THREW A ROD AND ALL THE OIL LEAKED OUT OF THE BACK OF THE ENGINE. I FOUND OUT ON THE INTERNET THAT THIS IS AN ONGOING PROBLEM WITH FORD, AND THEY WILL NOT FIX THE PROBLEM. *JB

I WAS DRIVING ABOUT 55 MPH ON 15-501 HIGHWAY ON ROUTE TO UNC HOSPITAL. WHEN ALL OF A SUDDEN, MY TRUCK WENT TOTALLY OUT OF CONTROL FOR NO REASON AND MY THEN 4 YR OLD AND I HAD A TERRIBLE ACCIDENT. THE TRUCK WAS TOTALED. WE WERE BOTH IN SEAT BELTS. SHE WAS BELTED IN HER CAR SEAT IN THE BACK AND I IN THE FRONT DRIVERS SIDE UPSIDE DOWN THE AIRBAGS NEVER DEPLOYED! WE WERE THOUGHT TO BE DEAD AT FIRST UNTIL MY DAUGHTER STARTED CRYING. WE WERE RUSHED TO UNC HOSPITAL IN CHAPEL HILL FOR CUTS AND CONTUSIONS. AT THAT TIME, I HAD NO MAJOR PAIN, BUT NOW, I CAN HARDLY WALK SOMETIMES BECAUSE OF THE WAY THE TRUCK LANDED IN THE EMBANKMENT UPSIDE DOWN HANGING TWISTED IN MY SEAT BELT .WE WERE LUCKY NOT TO HAVE DIED BUT NOW AFTER 3 YEARS I AM IN CONSTANT LEG, HIP AND BACK PAIN THAT I KNOW WAS DUE TO THIS ACCIDENT. NOW WHAT? MY LEGS GO NUMB ALL THE TIME AND I CANNOT EVEN BEND MY BACK HALF THE TIME DUE TO THIS. *JB

I OWN A 1997 F-150 . I PURCHASED THIS TRUCK FROM A PRIVATE PARTY WHEN IT HAD 52,000 MILES. THE TRUCK NOW HAS ABOUT 90K MILES. ON MAY 16 I STARTED THE VEHICLE AND HEARD A RAUCOUS NOISE FROM THE ENGINE COMPARTMENT. ON MAY 17TH I HAD THE TRUCK TOWED TO AUTO SPECIALTIES, AN INDEPENDENT REPAIR SHOP. THEY IDENTIFIED THE NOISE AS A BENT CONNECTING ROD. THEY DISCOVERED STEAM COMING FROM THE TAILPIPE AND BELIEVE COOLANT SEEPED INTO THE CYLINDER THROUGH A BLOWN HEAD GASKET. I ASKED HOW THIS COULD HAVE HAPPENED. THEY SAID PROBABLY OVERHEATING. YET, IN THE ENTIRE TIME I OWNED IT, THE TEMPERATURE GAUGE HAS NEVER REGISTERED HIGH, NO STEAM AROSE FROM THE ENGINE AREA. I HAVE ALWAYS CHANGED THE OIL EVERY 3K MILES. I HAVE ALWAYS MAINTAINED CORRECT FLUID LEVELS. I HAVE NEVER TOWED ANYTHING WITH THIS TRUCK AND NEVER CARRIED ANYTHING MORE THAN A HALF-TON LOAD. I ALWAYS LET IT WARM UP AND DRIVE IT GENTLY WHILE IT IS WARMING UP. IN ADDITION, THE TRUCK SPEED CONTROL DEVICE WAS REPLACED BY THE LOCAL FORD DEALER ON SEPT. 14, 2005. IN THEIR INSPECTION OF THE VEHICLE THEY UNCOVERED NO PROBLEMS WITH COOLING OR OVERHEATING. THIS IS THE FIRST FORD I HAVE OWNED, THE FIRST AMERICAN CAR. I HAVE OWNED 1 MITSUBISHI AND 2 TOYOTA PICKUPS WHICH I BOUGHT SECOND HAND. I OWNED THEM UNTIL THEY HAD OVER 125K MILES AND THEY NEEDED NO REPAIRS OTHER THAN NORMAL MAINTENANCE. I HAVE DRIVEN A PRE-OWNED INTEGRA TO OVER 140K MILES WITHOUT PROBLEMS AND A HONDA CIVIC WHICH I DROVE FROM 60K-120K WITHOUT THE SLIGHTEST PROBLEM. A T

HEAD GASKET FAILED ON MY 1997 FORD F-150 WITH 4.2 LITER (V6) ENGINE. IT LEAKED INTO CRANKCASE AND THE ENGINE LOCKED UP. IT IS A TOTAL LOSS OF THE ENGINE AND I CAN'T AFFORD TO BUY ANOTHER ENGINE. I HAVE FOUND OUT THAT THIS HAS HAPPENED TO MANY OTHER PEOPLE. *JB

NORMAL USE OF 4.2 V6 FORD ENGINE OIL PRESSURE DROPS TO 0 PSIG AT ENGINE IDLE AFTER TRYING TO FIX THE PROBLEM MY SELF (25 YEARS AUTO MECHANIC 17 YEARS AVIATION TECH) AND SEARCHING THE WEB FOR OTHERS WITH THE SAME PROBLEM AND THERE ARE THOUSANDS I HAVE FOUND THE FIX IS REBUILD OR REPLACE THE ENGINE $2000.00 - $6000.00 FOMOCO SHOULD SHARE IN THIS EXPENSE BUT I HAVE NOT HEARD OF ANYONE WITH HELP FROM FORD I WILL STATE THAT MANY HAVE BEEN AND WILL BE INJURED MOMENTARILY. *NM

DT*: THE CONTACT STATED WHILE TRAVELING 30 MPH, THE VEHICLE STALLED AND WOULD NOT RESTART. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE CONTACT DETERMINED THE SPARK PLUG EJECTED FROM THE CYLINDER HEAD. THE VEHICLE HAS NOT BEEN SEEN BY THE DEALERSHIP, BUT THE MANUFACTURER WAS ALERTED.

I HAVE A FORD F150 V6 4.2 WITH A BLOWN ENGINE. I STARTED IT ONE MORNING TO A LOUD KNOCKING AND SMOKE FROM THE EXHAUST. I UNDERSTAND THIS HAS BEEN A FREQUENT PROBLEM THAT FORD REFUSES TO TAKE RESPONSIBILITY FOR. MY TRUCK HAS 81,000 MILES ON IT. *JB

STARTED VEHICLE IN DRIVEWAY, LOUD BANG, WHITE SMOKE OUT OF TAILPIPE, AND KNOCKING IN ENGINE. MECHANIC SAYS THE ENGINE IS RUINED - BEND RODS. ONE OWNER VEHICLE WITH 55,000 MILES.

DT*: THE CONTACT STATED WHILE ATTEMPTING TO START THE VEHICLE, THERE WAS A LOUD KNOCKING NOISE COMING FROM THE ENGINE FOLLOWED BY THE ILLUMINATION OF THE CHECK ENGINE LIGHT AS WELL AS SMOKE FROM THE EXHAUST. ALTHOUGH THE PROBLEM PERSISTED, THE VEHICLE WAS NOT INSPECTED BY A DEALER.

I HAVE A 1997 F150 V-6 4.2L PICK UP TRUCK. I HAVE BEEN LOOSING ENGINE COOLANT AND MY ENGINE OIL LEAKS OUT. I HAVE FOUND THAT THE LOWER INTAKE GASKET PROBLEM IS VERY COMMON WITH THIS ENGINE TYPE AND TRUCK. I FOUND OUT THAT FORD HAD A RECALL ON THIS GASKET BUT THEY DID NOT SEND ME ANY INFORMATION ABOUT IT. THE RECALL ON THE GASKET EXPIRED IN 2005 ( I WAS TOLD BY FORD). I ONLY HAVE 66,000 MILES ON THIS TRUCK. CAN YOU GUYS HELP ME? *NM

I NOTICED MY FORD 4.2L V-6 WAS LOSING COOLANT. BUT, THERE WAS NO LEAKS EXTERNALLY. I WENT OUT TO START IT THE OTHER MORNING, AND IT WOULD NOT TURN OVER. I SEARCHED THE INTERNET, AND FOUND INFO ON HYDROLOCKING AND BAD GASKETS. I REMOVED ALL THE SPARK PLUGS, AND CRANKED THE ENGINE. LOTS OF COOLANT CAME OUT OF CYLINDER 1. NOW, I'M LOOKING AT BEST ALL NEW GASKETS, OR POSSIBLY A NEW ENGINE IF THE TIMING COVER GASKETS WEREN'T REPLACED UNDER THE RECALL. *NM

I OWN A 1997 FORD F-150 TRUCK, 4.2L V-6. MY WIFE WAS DRIVING THE TRUCK AND WITH NO WARNING THE ENGINE STARTED KNOCKING VERY BADLY, SHE WAS FRIGHTENED AND DROVE THE TRUCK HOME VERY SLOWLY, WHICH ALMOST GOT HER INTO AN ACCIDENT. AFTER DOING RESEARCH WITH FORD MECHANICS AND PRIVATE MECHANICS, I FOUND OUT THE ENGINE IS A DEFECTIVE ENGINE THE YEARS WERE 1997 AND 1998. I CONTACTED FORD AND THEY WILL NOT STAND BEHIND THEIR PRODUCT. THERE CUSTOMER SERVICE IN DETROIT WAS NO HELP AT ALL. I BOUGHT THE TRUCK WITH 36,000 MILES ON IT, TOOK VERY GOOD CARE OF IT, AND IT NOW HAS 64,000 MILES ON IT AND CANNOT BE DRIVEN. I RECENTLY RECEIVED A RECALL FOR THE CRUISE CONTROL SAYING IT COULD CATCH ON FIRE. UNFORTUNATELY THE TRUCK CAN'T BE MOVED UNTIL I REPLACE THE ENGINE, AND IT IS IN MY GARAGE. IF THIS TRUCK CATCHES ON FIRE AND BURNS MY HOUSE DOWN FORD WILL BE SUED. THERE WAS NO WARNING WHEN THE ENGINE WENT, FAILURE WAS TOTAL LOSS OF ENGINE, AGAIN FORD HAS DONE NOTHING. *NM

MY 1997 4.2L V6 F150 WOULD NOT START, REPLACED STARTER MOTOR, PULLED PLUGS FOUND COOLANT IN #1 CYLINDER. I'M CURRENTLY DIGGING INTO THE ENGINE TO REPLACE THE HEAD GASKET. *NM

1997 FORD 150 V6 4.2 L ENGINE FAILURE, NEVER RECEIVED NOTIFICATION FROM FORD ABOUT LOWER INTAKE GASKET RECALL, OR THE RECALL ON THE FRONT COVER GASKET. BOTH DEFECTS CAUSE ENGINE FAILURE BY HYDROSTATIC LOCK, BENDING OR BREAKING THE CONNECTING ROD(S) IN 1 OR MORE CYLINDERS. *NM

(1) NO SPECIFIC EVENTS PRECEEDED FAILURE. (2) DURING ROUTINE INSPECTION BY OWNER, A LEAK WAS DISCOVERED IN A STEEL BRAKE LINE NEAR THE FRONT DRIVERS SIDE WHEEL. CAUSE OF LEAK APPEARS TO BE RUST THROUGH. THERE IS EXTENSIVE RUSTING OF BRAKE LINES ON THIS VEHICLE. (3) REPAIRS HAVE NOT BEEN PERFORMED YET. RUSTED BRAKE LINES WILL BE SAVED AFTER REPAIRS ARE PERFORMED. *NM

11/16/2005 ~ GO IN FOR A ROUTINE OIL AND LUBE. ATTENDANT GIVES ME DETAILS, I HAVE AIR FILTER REPLACED AND COOLANT ADDED BECAUSE IT WAS LOW. 2/23/2006 ~ GO IN FOR MY ROUTINE OIL AND LUBE. I ASK THE ATTENDANT TO LOOK AT THE COOLANT, I TELL HIM THAT IT KEEPS GETTING LOW. SURE ENOUGH HE COMES BACK AND LETS ME KNOW ITS VERY LOW, DID I WANT TO PUT COOLANT IN IT. 4/28/2006 ~ I GO TO MY 97 F-150 TO HEAD OUT TO AN INTERVIEW, SHIRT AND TIE, CUP OF COFFEE AND PAPERWORK IN HAND. PUT THE KEY IN THE IGNITION AND IT WONT TURN OVER. IT ISN'T THE "BATTERY IS DEAD" WON'T TURN OVER, ITS A "I WANT TURN OVER BUT I CAN'T" OVER AND I CALL MY MECHANIC. HE ARRIVES AND GETS OUT HIS JUMPERS TO SEE IF IT IS A DEAD BATTERY. WE LOOK AT THE STARTER, ELECTRICAL EVERYTHING AND CAN'T SEEM TO FIGURE IT OUT. HE SAYS TO ME, "YOU DON'T HAVE VERY LOW OR LITTLE COOLANT, PUT SOME IN THE RESEVOIR" HE ASKS ME IF I NOTICED ANYTHING ODD, ANY HESITATION THE PREVIOUS DAY, I TELL HIM NO, I LITERALLY DROVE 3 MILES TO GO TO THE MARKET AND THAT WAS IT FOR DRIVING THAT DAY. HE ASKS ME TO PUT IT IN REVERSE AND WE TRY AND PUSH IT BACKWARDS TO TURN THE MOTOR OVER. IT WON'T BUDGE, AT THIS POINT HE SAYS THERE HAS TO BE SOMETHING IN THE CYLINDER(S), GAS, WATER, OIL, SOMETHING AND WE'LL PULL THE PLUGS AND SEE WHAT COMES OUT. WE PULLED THE PLUGS AND COOLANT CAME POURING OUT OF CYLINDER #2. I HAVE PICTURES ETC OF THE COOLANT AND PLUGS. I FOUND THERE ARE MANY PEOPLE HAVING ISSUES IDENTICAL TO THIS WITHIN THE SAME TIMBERING OF MILEAGE AN

DT*: THE CONTACT STATED THE VEHICLE LOST POWER INTERMITTENTLY WHILE DRIVING AT ANY HIGHWAY SPEED. THIS HAPPENED MORE OFTEN WHILE TOWING SOMETHING BEHIND THE VEHICLE. THE ENGINE SPEWED COOLANT ONTO THE ENGINE BLOCK. THE VEHICLE HAS BEEN TO THE DEALERSHIP FIVE TIMES. THE HEADS HAVE BEEN CHANGED ONCE; THE RESERVOIR SYSTEM HAS BEEN CHANGED TWICE. THE EGR VALVE HAS BEEN CHANGED TWICE. HOWEVER, THE PROBLEM STILL PERSISTS.

RE: 97 FORD F- 150 PICKUP W/ 4.2L V 6 IT HAS COME TO MY ATTENTION THAT THIS ENGINE GIVES TROUBLE W/ FAILING HEAD GASKETS . MINE FAILED AT 86,560 MI. ENGINE COOLANT/ANTIFREEZE LEAKING INTO #S 3 & 6 CYLINDERS SO BOTH SIDES OF ENGINE WERE AFFECTED FORD OWES ME $1765 DOLLARS IF THEY KNEW OF THIS PROBLEM PLEASE HELP! *NM

1997 FORD F150 4.2L V 6 ENGINE. WENT TO START THE TRUCK AND IT RAN VERY ROUGH. CUT IT OFF AND HAD IT TOWED TO THE LOCAL FORD DEALER, THEY SAID IT HAD A BENT ROD AND WOULD NEED A REBUILT ENGINE AT A COST OF $5,000. I DID SOME RESEARCH ON THE INTERNET AND FOUND 100'S OF COMPLAINTS ABOUT THIS ENGINE ALL WITH THE SAME SYMPTOMS. NOW I'M STUCK SHOPPING AROUND FOR A BETTER DEAL ON REBUILT ENGINES THAN THE FORD DEALER PROVIDED. *NM

MY 1997 FORD F-150 HAS A LOUD TAPPING SOUND IN THE ENGINE. IT EITHER BROKE A ROD OR A PISTON. *NM

I HAVE A 1997 FORD F-150 WITH A 4.2L V6 ENGINE THAT HAS FAILED WITH 82,000 MILES. IT IS MY UNDERSTANDING THIS FAILURE IS DUE TO COOLANT LEAKING INTO THE ENGINE DUE TO AN ENGINEERING FLAW. IT IS ALSO MY UNDERSTANDING THE FORD MOTOR COMPANY IS WELL AWARE OF THIS PROBLEM BUT CHOOSES TO EXCEPT NO RESPONSIBILITY AND LEAVE THE CONSUMER WITH THE BURDEN OF ENGINE REPLACEMENT FOR $4000 TO $5000. I ALSO UNDERSTAND THE FAILURES ARE NOT AN ISOLATED PROBLEM BUT ARE BEING EXPERIENCED BY THOUSANDS OF FORD F-150 TRUCK OWNERS WITH THE 4.2L V6 ENGINE. IT SEEMS TO ME THAT IF A PROBLEM IS THIS WIDE SPREAD AND THE MANUFACTURER REFUSES TO BE ACCOUNTABLE A GOVERNMENT AGENCY SHOULD STEP UP AND REPRESENT AS WELL AS PROTECT THE PEOPLE TO SOMETHING THAT AMOUNTS TO OUT AND OUT CONSUMER FRAUD. *NM

DT*: THE CONTACT STATED WHILE STOPPED AT AN IDLE, THE ENGINE OIL PRESSURE DECREASES TO ZERO FOLLOWED BY A GRINDING NOISE WITHIN THE ENGINE COMPARTMENT. THE VEHICLE WAS SEEN BY AN INDEPENDENT REPAIR SHOP FOR INSPECTION. THE MECHANIC DETERMINED THE ENGINE NEEDED TO BE REPLACED.

DT*: THE CONTACT STATED WHILE DRIVING THE VEHICLE, AFTER FILLING THE GAS TANK THE BRACKET THAT HOLDS THE TANK IN PLACE BROKE. THE GAS TANK DROPPED 4 INCHES; HOWEVER THE VEHICLE WAS DRIVEN TO THE CONTACT'S RESIDENCE. UPON INSPECTION ONE OF THE TWO BRACKETS WERE CORRODED AND HAD COMPLETELY BROKEN OFF. THE BRACKET WAS REPLACED AND THE MANUFACTURER WAS ALERTED. UPDATED 5/3/2006 - *NM

1997 F150 4.2L V6 60K MILES WATER IN CYLINDER WARPED ROD. ENGINE NO GOOD. CANT AFFORD TO SPEND 5K DOLLARS TO TRY TO REPAIR ENGINE. *NM

BOUGHT A 1997 F-150 USED IN 2001 WITH 62,000 MILES ON IT. I HAVE PUT LESS THAN 15,000 MILES ON THE VEHICLE IN THE 4.5 YEARS I HAVE OWNED IT AND CHANGED THE OIL TWICE. I HAD NOTICED IN THE PAST THAT I WOULD HAVE TO FILL UP THE COOLANT, BUT COULD NOT FIND A LEAK. I ALSO HAD PROBLEMS WITH THE HEAT GOING IN AND OUT. WENT TO START THE TRUCK AND IT SHOOK AND CAME TO A STOP. STARTED IT AGAIN AND THERE IS NOW AN AWFUL BANGING/KNOCK. I BELIEVE TO BE A ROD OR OTHER INTERNAL PART. HAVE NOT HAD THE PROBLEM DIAGNOSED BY A PROFESSIONAL, BUT AFTER READING THE FORUMS ON THE FORD 4.2 LITER ENGINES I FEEL CONFIDENT THAT I CAN SELF DIAGNOSE THE PROBLEM AS HAVING TO DO WITH THE COOLANT LEAK PROBLEMS. I HAVE NOT RAN THE ENGINE AND HAVE NOT HAD THE MONEY TO FIX IT OR REPLACE IT. I CAN'T BELIEVE THE NUMBER OF PEOPLE THAT HAVE HAD THE SOME PROBLEM, SYMPTOMS, AND OUTCOME AS ME. THEY HAVE TO NUMBER IN THE HUNDREDS-THOUSANDS. FORD SHOULD NOT BE ABLE TO GET AWAY WITH THIS AND HAVE TO BE FULL AWARE OF THE PROBLEMS WITH THEIR 4.2 MOTOR. THERE NEEDS TO BE A CLASS ACTION SUIT AND A RECALL. ON BEHALF OF ALL THE F-150 OWNERS WHO HAVE HAD THIS PROBLEM WE NEED HELP TO RESOLVE THIS. THANKS FOR YOUR CONSIDERATION AND PLEASE INFORM ME IF ANYTHING HAPPENS OR CAN BE DONE AS I HAVE NOT FOUND ANYTHING AS FAR AS A CLASS ACTION SUIT AGAINST FORD. JB

COMPLETE ENGINE FAILURE ON 1997 FORD F150 4.2L 145K DUE TO LEAKING GASKET IN ENGINE, ALLOWING ENGINE COOLANT INTO ENGINE, CAUSING ENGINE TO FREEZE CYLINDER AND THROW A ROD THEN ENGINE COMPLETELY STOPPED. I NOTICES THAT ENGINE COOLANT WAS DISAPPEARING AND WHITE SMOKE OUT OF TAIL PIPE, THEN CHECK ENGINE LIGHT WENT ON, THEN SOON AFTER THROUGH A ROD AND ENGINE SEIZED UP. MY CAR NOW REQUIRES A NEW ENGINE DUE TO DEFECTIVE GASKET ALLOWING ENGINE COOLANT INTO ENGINE. THIS SEEMS TO BE A RECURRING THEME WITH FORD ENGINES IN THIS YEAR. *JB

1997 FORD F-150 INTAKE MANIFOLD GASKET FAILED ALONG WITH A TON OF OTHER PEOPLE. HAD TO PAY A HEFTY REPAIR FEE. THERE WERE NO EVENTS LEADING UP TO IT, JUST SAW WHITE SMOKE COMING FROM MY TAIL PIPE. LUCKILY I CAUGHT IT REAL QUICK AND IT ONLY COST THE ME REPAIR OF THE ENTIRE GASKET. A LOT OF TIMES IT IS A WHOLE NEW ENGINE. MY REPAIR COST $500. *JB

MY TRUCK WAS TAKEN IN FOR A BRAKE REPAIR THE WEEK OF MARCH 6- 10, 2006. WE GOT THE TRUCK BACK DROVE IT A 100 MILES ON THE WEEKEND WITH NO PROBLEMS. ON MONDAY, 3/13/06, I NOTICED IT MISSING AFTER 40 MILES AN HOUR. MY HUSBAND DROVE IT TO WORK THE NEXT DAY TO SEE WHAT I WAS TALKING ABOUT. HE HAD THE SAME PROBLEM. I TOOK MY SON TO WORK ON THURSDAY AND IT WAS STILL MISSING. WHEN ON THE FREEWAY, I GOT IT UP TO 65/70 MPH WHEN IT JUST STARTED SLOWLY DOWN. I COULD NO LONGER GIVE IT ANY GAS. I WAS ABLE TO PULL ONTO A LARGE SHOULDER WHERE I HAD IT TOWED INTO A TRANSMISSION SHOP I TRUSTED. ON INSPECTION, THE TRANSMISSION WAS FLOODED WITH WATER AND COOLANT AS WELL AS THE ENGINE DUE TO A FAULTY RADIATOR. I HAD REPLACED THE RADIATOR APRIL 11, 2005. THIS WAS NOT THE FIRST RADIATOR REPLACED. THIS WAS THE 4TH RADIATOR. I HAD THE TRUCK TOWED TO THE DEALERSHIP THAT INSTALLED THE RADIATOR AND WAS TOLD THAT MY ENGINE AND TRANSMISSION HAD FAILED. I'M WAITING FOR A CALL BACK WITH AN EXPLANATION AS TO WHY. I WAS TOLD THAT I WOULD HAVE TO HAVE AN ENGINE BREAKDOWN WHICH WOULD COST ME, TO FIND OUT WHY IT FAILED. WE HAVE HAD NUMEROUS PROBLEMS WITH THE WHOLE COOLING SYSTEM IN GENERAL SINCE 1999. RANGING FROM CHANGED HEAD GASKETS, HEATER CORES, RADIATORS, ETC. IT HAS BECOME APPARENT FROM READING ON THE FIGHT BACK SITE: [HTTP://FORUMS.TREEMEDIA.COM/FB/SHOWTHREAD.PHP?P=836&PAGE=2&PP=15] THAT THIS A COMMON UNRESOLVED ISSUE WITH THE FORD COMPANY. APPARENTLY THIS IS A COMMON COMPLAINT THAT HAS YET TO BE TAKEN S

OWN A 1997 F150 WITH 4.2 FOR ABOUT A YEAR NOW. NEVER SEEN THE SMOKE COMING. HYRDOLOCKED ON ME WITH 150,000 KMS WHICH I HAVE HEARD IS KINDA LOW KMS FOR THAT TO HAPPEN. LOOKING AT GETTING A REBUILT BUT WILL SEE WHAT HAPPENS WITH THIS. *NM

COOLANT LEAK. *NM

ENGINE FAILURE, FORD 4.2L V6 1997 WITH 102,000 MILES. STARTED ENGINE AND LOUD CLANGING NOISE FROM FRONT OF ENGINE ALSO LARGE PLUMES OF WHITE SMOKE FROM EXHAUST. BROUGHT MY TRUCK TO FORD DEALER FOR SERVICE AND WAS TOLD BEST SOLUTION WAS TO REPLACE ENGINE. TRUCK IS CURRENTLY AT DEALER. I WENT TO ON-LINE TO RESEARCH ENGINE PROBLEMS ASSOCIATED WITH THIS AND FOUND 21 PAGES OF SIMILAR COMPLAINTS. THE SYMPTOMS WERE EXACTLY THE SAME FOR EACH ONE. ONLY THE MILEAGE VARIED. SOME CLAIMED A FORD RE-CALL WAS ISSUED FOR A GASKET PROBLEM TO CORRECT COOLANT LEAKING INTO ENGINE CAUSING INTERNAL FAILURES. I DID NOT RECEIVE THIS RECALL. PLEASE INVESTIGATE WHAT CAN BE DONE TO HAVE FORD TAKE RESPONSIBILITY FOR MY (AND THE OTHERS) ENGINE FAILURE. IT IS VERY COSTLY. THANK YOU.*JB

SPARK PLUG BLEW OUT WHILE RUNNING. I HAVE ONLY HAD THE PLUGS CHANGED ONCE BY THE FORD DEALER. I HAVE READ ON THE FORD F150 FORUMS THAT THIS IS VERY COMMON ON THE 5.4 ENGINE AS THEY HAVE VERY FEW THREADS HOLDING THE PLUG IN. I AM TOLD FORD FIXED THE PROBLEM IN 2002 BUT HAS NOT RECALLED THE EARLIER TRUCKS. *JB

MY FORD F-150 4.2 L ENGINE THREW A ROD ON MARCH 8 2006, WITH LESS THAN 61K MILES ON THE MOTOR. THE FAILURE WAS DUE TOO WATER SEEPING INTO THE CYLINDERS FROM A DEFECTIVE GASKET . I HAVE MAINTAINED THIS VEHICLE PER FORD'S PRINTED MANUAL AND HAVE THE RECORDS TO PROVE IT. THE RESULT OF THE PROBLEM HAS COST ME OVER 3,000 DOLLARS FOR AN ENGINE REPLACEMENT. I EXPECT FORD MOTOR CO. TO REIMBURSE ME FOR MY DAMAGES FINANCIALLY. I SPOKE WITH A SERVICE MANAGER AT A LOCAL FORD DEALERSHIP AND HE SAID HE HAS NEVER KNOWN OF FORD TO REIMBURSE A CUSTOMER IN THIS TYPE OF SITUATION. THEREFORE I DECIDED TO FILE THIS COMPLAINT. MY TRUCK IS NOW BEING REPAIRED BY AN INDEPENDENT SERVICE GARAGE. *NM