2021 Ford Explorer complaints

This vehicle has a major defect and is unsafe to operate. The rear differential has only 1 rear bolt and is completely inadequate for the performance and duty of the car. It can break and cause gerat injury or death if it fails. It puts anyone operating and in the car at great risk of injury or death if the only remaining rear bolt breaks, dislogding the drive shaft and half shafts in catastrophic failure. I have had the vehicle inspected and compared to the 2020 Ex ST which has 2 rear bolts and my 2021 only has 1 rear differential bolt. This is a major defect and major safety concern. Lets not wait for someone to get injured or die. Thank you. [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The contact owns a 2021 Ford Explorer. That contact stated that the silver plastic strip on the driver's side power window switch had started peeling away, creating the potential for her to lacerate her finger. The vehicle was not taken to the dealer or an independent mechanic. After investigating the failure, the contact related it to Customer Satisfaction Program: 22B37, but the VIN was not included. The manufacturer was notified of the failure. The failure mileage was unknown.

The camera system keeps going blue and will not work about 80 percent of the time since the repair has been completed. This has gotten progressively worse it seems. At times the whole radio screen will remain blue and can not use it until you turn the whole car off and wait for some time. The radio system also has lost all Bluetooth additions have added to it multiple times. There is a second recall for the blue screen but it appears they have put it on hold.

I have taken my Explorer in twice to have the infotainment system repaired. It will randomly shut down and go blank. Nothing will work to include the camera/backup assists. Sometimes an ignition cycle will clear it, but there have been times it will not. Both local dealers claim they could not duplicate despite bringing in and showing the service advisor during an event. Ford has also performed a "recall" for this 4 times, with the 3rd being canceled because it was not actually fixing the issue.

The recall that was previously issued for this issue was removed by the dealer because of 'many complaints from owners about the software fix'. The dealer told me that Ford was working on it and they would update later. However, you, on this website, will list this vehicle as 'recall completed'. Not sure why the disconnect. Also, for this vehicle, the rear subframe bushing failed last fall and was replaced under warranty. This bushing has failed again and I have an upcoming appt to have it fixed. This issue MUST be addressed by NHTSA as this is a severe safety issue that you are NOT pushing Ford hard enough to address. For 2023, Ford is producing 'some' Explorer ST models with the two bolt system (that is not under this recall), however, some are still being produced with the one bolt. The 2021-2022 models were, mostly, all made with the one bolt setup. The Fix is to simply use the correct rear subframe (Ford is doing this for owners that complain/push this issue, which I'll be doing now that this has happened twice). Please call me if you need details.

Numerous times over the recent 2 months, I have experienced different issues with my 2021 Ford Explorer. The vehicle was purchased used in 2022 with less than 10,000 miles on it. It currently has 36k miles. When the vehicle is stopped but in drive and then accelerated to merge into traffic, the vehicle stalls and will not engage. The accelerator has to be pressed repeatedly to get the vehicle to begin moving again. This can take anywhere from 2-3 presses and 10-20 seconds. This creates a hazard for moving traffic and a safety issue. This occurs repeatedly with no warning beforehand. The vehicle has no lights to reflect an issue. Additionally, while the vehicle has been parked and shut-off, the electronics will turn on. On two separate occasions, the lights have turned on on their own and the radio has done the same; there was nobody in the car either. Over the past weekend, while driving down the road, no rain or water on windshield, and the wipes started. The vehicle persistently has a blue screen during backup. There is a concern for the electronics as a whole with all of the issues occurring. When accelerating on the highway/interstate, often times, an odd smell can be sensed, as if the EcoBoost is not functioning appropriately. The recall for rear axle bolt was repaired by Ford in Yukon, OK, and was informed that is the only recall currently with a repair available. The vehicle is available for inspection, as necessary.

I have filled claims with Ford Motor Company as well as the BBB regarding my vehicle and not shifting and lunging into gear. Ford has replaced my transmission 3 times and denied my claim for a buy back under the Lemon Law and Magnuson Moss Warranty claim. Now I am reading Ford is recalling many 2021 Ford Explorers for the same issue that I had reported struggled and continue to struggle with for over a year now. Is there anything NHTSA can do to require Ford to purchase my vehicle back for at least what I paid for? I can provide claim numbers, if needed.

I had a reputable after market brake system installed on my 2021 Ford Explorer ST at Holman Ford in Turnersville,NJ a couple years back. Since this time I have taken back the vehicle for my brakes being too spongy. I explained to the dealership that the brakes needed to be bleed again. The technician did not and adjusted the actuator on the brakes. Last year around the same time I had almost complete brake failure. This was do to the brakes having air in the lines and leaking from a fitting. The same concern I had from the beginning. The dealership fixed the problem and also added the parking brake software due to my vehicle only having one rear bolt in the subframe. Since this time, I have received numerous parking brake fault codes on my instrument cluster. The parking brake also disengages violently to the point where my vehicle lunges forward. It wasn’t until several days ago that my 2021 Explorer went back to the dealership for the parking brake issue and then saying my parking brake actuator broke apart. I have had nothing but issues with my brakes installed by the dealer and now I’m experiencing an issue caused from the software update.

I had my suv service recall done on 6/04/22 for rear axle bolt fractures. When I got to driving my suv the transmission was acting funny, it was shifting up and down different than it was. So I took it back , and they said it had to get use to my driving. So it seemed ok in a couple of days. Then all of a sudden I was at a stop light one day and it wouldn’t shift out of first gear.so we pulled over to a parking lot, we went in and had lunch, after lunch we tried driving it and it seemed fine. And it was ok until about 3/08/23 when we were almost got home from a shopping trip when all of a sudden it just started making noise and acted different shifting. So I took it to my ford dealer,I asked them to look at it and tell me what they wanted to drive it or not.they said not drive it, so they gave me a loaner car. So I checked with them a couple of times and they had not looked at it. So after not looking at my suv for 30 days I got mad and traded in . So I don’t know for sure what happened to my suv I think it was in transmission or driveline.there was no warning lights or codes they told me when I dropped it off

I had my 2021 in the shop for NHSTA Recall 22V255 in June of 2022. They reprogrammed my parking break to auto-engage when the car is put in Park. The DID NOT replace the rear axle mounting bolt. The Ford letter to dealers describes the dangers of driving with a defective rear axle bolt. Why weren't these bolts replaced? I was told (by [XXX]) that no bolts were available. He agreed with me that the proper repair could not be completed without changing the bolt(s) in question. So does Ford only repair broken rear axle bolts? INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 21V735000 (Back Over Prevention) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was not made aware of the issue. The contact had not experienced a failure. The VIN was not available.

I am reporting countless incidences of my backup camera screen going to black or blue when the Gear Shift is selected to REVERSE. This has happened multiple times a day, week, month, etc. and is extremely frustrating. I am reporting in hopes to do anything I can to get the software fix expedited because it has been occurring for too long without a fix. t=The only "FIX" (if you can even call it that) for this problem is to stop what you are doing, put your car in PARK, turn the car OFF, open the driver's door to "reset", and then turn your car back on AGAIN in HOPES that the backup camera / 360 view is back to functioning within normal limits. That is unacceptable!!! It is not safe and anyone experiencing this issue should not have to stop their car, open a door, and restart it just to get the backup camera to work. I have contacted my dealership, Ford Corporate Offices, and now you guys in hopes to get this process going and the software to be fixed. Thank you - please contact for any questions or more information.

The back up camera fails basically 1 out of 5 times it's engaged between skipping or just straight blue/black screen. The screen is out and causes blind spots while backing up.

This vehicle has had multiple recalls for the same issue. Current recall is 23V022. This is a recurring issue with the sync screens. Now the entire screen is failing at all times rendering it impossible to drive hands free. Meaning navigation does not work, operating a phone through the car does not work, at times the reverse emergency brake does not work. All of these features are there to improve not only the safety of the vehicle occupants, but the safety of other motorists. It is unfortunate that the government has allowed a vehicle manufacturer to make its own rules when it comes to the safety of this nations motorists. All of the photos attached were taken on different days over the last couple of months and I would be happy to verify this upon request.

Recall on REAR CAMERA BLUE OR BLANK SCREEN

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V022000 (Back Over Prevention) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that his vehicle rental company owns a fleet of 105 2021 Ford Explorers, and the VINs were all included in the recall. The contact stated that 35% of the 105 vehicles had experienced a loss of rearview camera image. The dealer was made aware of the failure and confirmed that parts were not yet available. The vehicles were not repaired. The manufacturer was made aware of the failure. The failure mileage was unknown. VIN tool confirms parts not available.

The contact owns a 2021 Ford Explorer. The contact stated while driving 30 MPH and attempting to slow down, the vehicle failed to properly respond. The contact desperately depressed the brake pedal, but the vehicle failed to respond. The contact activated the parking brake, and the vehicle was able to stop. The contact was able to drive back to the residence. The vehicle was towed to the dealer and the dealer stated that the ABS module needed to be replaced. The vehicle was repaired but the failure persisted. The vehicle was taken to the dealer and the dealer stated that the wiring harness needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, and a case was filed. The failure mileage was 20,000.

After receiving a Ford issued recall for a potential rear axle bolt fracture, the dealer reprogrammed the PCM per Ford's reported repair solution. After this PCM update, the vehicle would randomly slam to a complete stop while driving. It happened several times with 3 different drivers (myself, my wife, and my son), each happening at 30-35 mph or less. It was usually preceeded by an audible clicking sound, but not always. We took the vehicle to the dealership several times, but they said they were not able to reproduce the issue, and continually returned the vehicle to us despite our grave concern for high risk of crash and injury. We even contacted Ford's customer service and legal departments several times, who ultimately refused to allow us to continue using a loaner vehicle and demanded that we return the loaner and retake possession of our Explorer because they said they had not received any other similar complaints, and their field engineer could not reproduce the issue and cleared the vehicle as safe, although Ford was never able to supply us with service records proving the repairs they purported despite our repeated inquiries. Ultimately, the issue happened again, and slammed while driving down a hill at about 40-50 mph, but this time the slamming was immediately followed by seemingly disengaging the drivetrain and causing the vehicle to roll downhill with no ability to accelerate, ultimately causing me to roll into a utility pole. Ford has since repurchased the vehi

Car rolled down driveway while in park three separate times. Could have killed someone.

Last month out of the blue, my 2021 Ford Explorer ST with 15,500 miles would not start. Attempts to jump it were futile. I then had it towed in to the local Ford dealer. At first, they were thinking the starter. A few days later, I got a call saying they could not hand crank the motor as it seized up. In addition to that, they found pieces of metal from the piston in the oil pan. The dealer took apart the intake manifold and found that the valve keeper failed thus dropping the intake valve into the #5 cylinder. This necessitated replacement of the engine, both turbos and even the flywheel and torque converter. This is a known issue with the 2021 Broncos and is even being investigated by the NHTSA. I just wanted to bring awareness that this can happen to the 2021 Explorer with the 3.0 Ecoboost as it was built in the same factory as the Bronco 2.7 and is a similar engine. I can provide the repair invoice upon request. I couldn't get it to upload.

2021 ford explorer exterior windshield trim is loose and has been shown to come off while driving. it is also causing a wind noise inside of the vehicle while in operration. No warnings shown. Link below shows issue and repair guidelines. https://www.tsbsearch.com/Ford/22-2021

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 22V255000 (Power Train) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2021 Ford Explorer. The contact stated that while driving at various speeds, the rear end of the vehicle became very unstable, and the vehicle fishtailed. The vehicle was taken to the local dealer who performed a rear wheel alignment, but the failure persisted. The manufacturer was notified of the failure and informed the contact that the VIN was not included in the NHTSA Campaign Number: 21V870000 (Suspension). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 12,000.

Front passenger seat overheated and caused 2nd degree burns

At 13,000 miles this New vehicle started smoking blue gray smoke on startup I have videos. Yes the Dealer reproduced the problem. The dealer stated that both turbos were defective and leaking oil into the hot exhaust on both sides of the engine which could have lead to a fire and endangered our lives. The dealer removed the engine and transmission from the vehicle in the process broke numerous bolts and repaired with inferior quality parts.after four attempts to pick up the car hoses were left loose and short on antifreeze and Turbo boost hose fell off,now there is a antifreeze burning smell and a rough idle. There were no warning lights or messages. This car was meticulously maintained since brand new I have all records to back up . Ford Corporate has just denied a buy back request and said I don’t qualify for state Lemon law after 2 months at dealer.

Defective Starter - car will not start, battery, alternator check off ok.

The rear camera has not worked since the vehicle was purchased in spring of 2021. It has now been "repaired" 3 times based on open recalls. however the issue is a known issue and can not be fixed. We have now been told they will.nees to replace the camera which is on indefinite backorder. This is a huge vehicle safety issue Ford is aware of and yet not one of their alleged recalls actually resolves this serious issue.

The transmission hesitates for several seconds and shifts hard when being shifted into reverse. The dealership has made one repair attempt already.

Loud popping metal sound from rear brakes as vehicle starts to move Ford has been contacted and replaced rear brake pads which made no difference. This problem started last August After Safety Recall 22S27 below is a link to videos with sound which clearly describe my safety concern https://www.dropbox.com/sh/a3iawirsizbc6iq/AAA3dgaCvZ9JcouFufKLLmGUa?dl=0

Issue with navigation system. Many times is shows no GPS. Navigation does not always recognize current vehicle position and many times navigation does not even work. On many occasions, upon starting the vehicle, the clock does not even work when the navigation system isn't being used. This is a safety issue when we are traveling out of town. We are not fans of using our phones for navigation as an alternative to the faulty vehicle onboard navigation. This first started happening December 2022.

While using Intelligent Adaptive Cruise, the vehicle suddenly thought the speed limit was 85mph and quickly started accelerating. Confused, I hit the brakes to stop the acceleration. I have uploaded a photo of the dash that I took showing that the system read the speed limit sign as 85. I saw no speed limit sign in the area, so, I have no idea what prompted the system to change speed. I was talking on the phone via Android Auto and using Waze, via Android Auto, USB direct connect. The only other problem I've ever had with this system is on interstates that have specific Truck speed limits in West Virginia. There, sometimes trucks have slower speeds and this system picks up those truck speeds and decelerates/brakes to comply. While it can be overridden in the moment, the next time it sees such sign, it slows again. This sudden deceleration poses a hazard to other drivers who do not expect a 'non-truck' vehicle to suddenly slow.

Vehicle developed a clicking noise when accelerating/decelerating. Noise also present when switching between drive/reverse. Ford dealer found that driveline was flexing. Closer inspection revealed that the bushing for the single bolt rear subframe mounting to rear differential was broken. Had this not been caught, the bolt would have broken releasing the rear driveline from the structure of the vehicle. The 2020 Ford Explorer ST had two bolts that connected the rear diff to the rear subframe. In 2021-2022 Ford changed this to a one bolt design. This triggered the current recall for the 2021-2022 in which the 'fix' was to apply the emergency brake if the bolt broke. On the 2023 Ford Explorer ST model, Ford has returned to the two bolt design used in 2020. Photos uploaded.

The contact owns a 2021 Ford Explorer. The contact stated while driving 10 MPH, there was a strong gasoline odor inside the cabin of the vehicle. Additionally, the contact stated while the vehicle was parked in the garage, there was a strong gasoline odor coming from the vehicle. The contact stated that the gasoline odor was present throughout the entire three-story residence. There was no warning light illuminated. The vehicle was taken to the dealer where it was diagnosed that the fuel line was leaking from a hole. The fuel line was replaced, and the diagnostic fault codes were cleared. The contact stated that upon reviewing photographs of the fuel line, he noticed that an unknown component had been rubbing against the fuel line, which caused the failure; however, the dealer did not inform him of the cause of the failure. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 41,000.

Back-up camera starts turning blue. Verified that there was an issue during manufacturing that they left a hole open and can cause malfunctioning of the back up camera causing the blue screen. Unable to spot blind spots when backing up and can put others safety in danger if behind vehicle especially children and I am not able to see them when reversing.

On or about 9 am on Tuesday, January 10, 2023, I entered a parking garage facility and drove up the ramp and continued on a level parking area and begin to turn into a parking space beside a large cement column. Just as I entered the parking space at a low rate of speed without my foot on the accelerator, I experienced sudden unintended acceleration which caused the vehicle to narrowly miss the cement column and the front cement wall of the parking space. Fortunately, I quickly braked to avoid a collision and then put the vehicle in park and shut off the vehicle. There were no warning lights on the vehicle dash, and I have not yet taken the vehicle to an authorized Ford Dealer to have it checked. Vehicle is still under factory order and has approx. 26,700 miles.

The contact owns a 2021 Ford Explorer. The contact stated that he recently had a manufacturer recall performed on the vehicle for Ford Customer Satisfaction Program Number 22N06 (Rear Axle Bolt Replacement). The contact stated that the dealer re-programed the E-brake to engage automatically when the vehicle was placed in park(P). The contact stated while reversing out of his driveway the vehicle would not move. The contact had been instructed to tap on the accelerator to release the E-brake. The contact stated that the RPM was raised to approximately 2,000 RPM, and only then would the high RPM release the E-brake; however, the vehicle would lurch into motion at approximately 10 MPH. The contact stated that the E-brake warning light was illuminated and then switched off once the E-brake was disengaged. The contact stated that the failure was more pronounced while reversing on a slope. The contact stated that the failure recurred while placing the vehicle in drive(D) however, the vehicle lurched and jumped forward. The contact stated that the motion was not as aggressive as while the vehicle was in reverse(R). The contact had taken the vehicle back to the local dealer where it had been reprogrammed. The contact was advised that all that could be done was to reprogram the E-brake. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 23,000.

Backup camera “blue screens” during critical times it is required. Software updates were updated but no resolution until Ford replaced the backup camera.

Rear subframe bolt bushing broke. (See existing recall for the rear subframe bolt breaking). This vehicle had recall performed which actually didn't address the engineering shortfall from Ford using the wrong, lighter duty, subframe on the ST model. This subframe only has one bolt holding the rear diff to the subframe. The 2020 model had two bolts, as do all MY of the Lincoln Aviator. While Ford is fixing this under warranty, using the same subframe will not fix this issue. Result will be that the bolt may break or the bushing may fail. A broken bolt will result in the drive shaft disconnecting while driving, loss of acceleration, potential wreck from drive shaft hitting ground at speed.

Numerous times no response when pushing gas pedal no acceleration when vehicle is in electric and switching to gas.This a Hybrid vehicle. I can't let my wife drive it. No warning lights come on. The recall for rear end states if the bolt fails the drive shaft and rear axles could move out of alignment and cause an accident .....yet they refuse to replace it.

When driving at lower speeds, typically under 30 MPH, the vehicle jerks & lurches. Also sometimes lurches, hesitates or doesn’t react on rapid acceleration such as highway merging or passing. Have had many near-misses. Parking, Reverse & Drive do not always engage immediately upon shifting. I nearly ran over my husband when the car was supposed to be in park and it was still in drive. Car will become extremely hot after extended driving causing the A/C to automatically turn to hot air in order to cool the engine. It smells bad and is not at all comfortable on long summer road trips.

The contact owns a 2021 Ford Explorer. The contact stated while it was raining, the windshield wipers were activated but failed to clear the windshield as needed. The vehicle was taken to the dealer and the wipers were replaced, but the failure continued. The vehicle was taken to the dealer and the windshield arm were replaced, but the failure reoccurred. The vehicle was taken back to the dealer and the contact was informed that the vehicle operated as designed. The manufacturer was notified of the failure but offered no assistance. The failure mileage was 5,000. The VIN was not available.

Vehicle began smoking after a cold start at around 9000 miles. Dealer confirmed the issue was happening and the engine was replaced, but the smoking problem remains. No warning lamps, indicators, or DTCs have been thrown to help in diagnostic. Thus far, there has been no safety impact due to the issue.

My Explorer ST has the issue of having the incorrect rear subframe for the high-performance engine with only one bolt holding the differential to the rear subframe. I have talked to all of the Ford dealerships in my area. They said that this is a problem, but Ford has not provided a solution or any timeframe to fix this major issue. Another example of Ford not caring about their customers and putting profits ahead of safety. Why did they think that they could get away with installing incorrect parts for the four-cylinder engine on a vehicle that develops substantially higher HP and torque. This is my first and last Ford product I will ever buy. Why doesn't the NHTSA force Ford to fix this potentially dangerous issue.

Ford has started a recall for vehicles with a single bolt in the rear differential mount. This is in reference to the roll away issue as their calling it. Some people have recieved notice for this and others have not. My production date is listed as 8/21. Which I believe is in part of the recall. Even if not this vehicle has only one bolt in the unit and not 2. Which is part of the recall issue.

Two issues. 1. After the software update that was supposed to fix the rear camera blue screen issue, it randomly shows a blue screen instead of the camera image when reversing. The issue doesn't correct until the vehicle is turned completely off and restarted. 2. The rear hatch randomly closes when getting items out or putting items in the cargo area. It cracks you on the head and DOES NOT STOP. If you can't get out from under it in time you fall to the ground. More than once it has made me see stars it struck my head so hard. Also sometimes when walking away from the vehicle the hatch will open on its own with no one near it. The dealer tried once to reproduce the issue but didn't happen while they had it.

The contact owns a 2021 Ford Explorer. The contact stated that he had received a recall notification for NHTSA Campaign Number: 22V255000 (Power Train). During a routine maintenance check, the recall was serviced; however, upon return of the vehicle, the brake pedal was depressed to the floorboard with the parking brake fault, uphill assist, and ABS warning lights illuminated. The contact also stated that while driving at various speeds, the brake pedal hardened and the vehicle failed to stop as needed. The contact's wife called the dealer and was informed that there were 5 other vehicles that had experienced the same failure. The contact attempted to reach the manufacturer but was unsuccessful. The vehicle was not repaired. The failure mileage was approximately 37,000.

My 2021 Ford Explorer should be included in safety recall NHTSA 22V255, Ford recall 22S27, Ford Program 22N06 My vehicle[XXX] was built in September 2021. Ford identified to NHTSA that Explorer vehicles built between June 4 2020 to November 10, 2021 were affected. My vehicle was built during that period. My vehicle has the V6 engine with AWD powertrain. My vehicle has the 52T trailer towing package. Trailer towing will put additional load on the powertrain and the rear axle mounting bolt. The bolt may fracture while towing the trailer leading to a serious injury and personal property damages. I have not received the recall letter from Ford. All letters were supposed to be sent by June 2022. Ford will not include my vehicle in the recall at my request. Ford will not apply the PCM update to automatically engage the electronic parking brake every time the vehicle is shifted into Park (P). Ford will not provide the one-time repair of the for 10 years or 150,000 miles. I'm concerned the vehicle may experience the rear axle mounting bolt fracture. Please help. Thank you. -------------------------------------- Safety Recall 22S27 / NHTSA Recall 22V255 / Customer Satisfaction Program 22N06 Certain 2020-2022 Model Year Explorer Vehicles Rear Axle Bolt Fractures REASON FOR THIS SAFETY RECALL In some of the affected vehicles, the rear axle mounting bolt may fracture during vehicle acceleration. A fractured rear axle bolt will allow the rear axle housing to move out of position, resultin

I recently had the recall addressed at my local Ford dealer, Performance Ford in Randolph, NJ. Ford is only allowing dealerships to reprogram the parking break to engage whenever the vehicle is placed in park. If the axle bolt were to shear, it would disengage, allowing the vehicle to roll in park. This remedy does not adequately address the underlying issue- which was the fact that Ford’s Chicago mfg facility used a part designed for the 4-cyl engine power train, not the 4 bolt design required in the Police Interceptor and Explorer ST versions. The police version will be getting the parts upgraded while consumers are left with a band-aid solution. NHTSA should force Ford to address the issue- which is an inadequate bolt configuration for the HP/Torque output of performance version Explorers. This is a safety hazard as the bolt can snap while in use, disconnecting the drive axle from the rear differential.

Our 2021 Ford Explorer Limited was purchased in December of 2020. It currently has been driven only 6,900 miles. Our apparent transmission problem has occurred three times so far. 1. On 27 June 2022, I experienced the first problem. While turning left on to a four-lane city street, which is largely flat in that area, a loud grinding/ringing sound occurred. Right in the middle of the four-lane street, the transmission dropped into neutral. It scared the crap out of us. We could have been hit by oncoming traffic. I brought it to a stop, then shifted to park and then into drive. We drove away normally as if nothing happened. 2. On 28 July 2022, after having the "bolt failure" recall completed (22S27/22V255/22N06), the transmission again made the loud grinding/ringing sound immediately after accelerating from stopping at a city street intersection. The road grade has a slight incline in the direction we were traveling. The vehicle dropped into neutral, then the newly programmed "auto braking" brought us to an abrupt stop in the middle of this intersection! Again, a scary situation. 3. Today, 25 August 2022, while backing out of our garage today, which has a slight downward driveway, the vehicle did an abrupt stop while halfway out of the garage. The message was "Hill Start Assist Warning." The message on my phone was "The Hill Start Assist System has detected a failure." This is the first and only time that this problem has happened. I think it is related to the problems mentione

Backup and front cameras are not working consistently. Blue screen shows on display screen. Cannot reproduce at the Ford dealer. Blue screen camera issue started on June 13, 2022. Since then I have had 27 instances to date. There currently is a recall for this same problem on other Ford Explorer's.