2019 Ford Explorer complaints

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000(Structure); however, the part to do the recall repair was not yet available. The contact stated that both the driver's side and the passenger's side windshield exterior A-Pillar trims had separated from the vehicle. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 99,000. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact stated while driving at an undisclosed speed, the driver's side windshield trim detached and flew off. In addition, the contact stated that the passenger's side windshield trim had detached and was held in place with tape. The dealer was made aware of the failure; however, the contact was informed that the parts were not yet available. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was 89,000. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000(Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed that the parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact stated while driving at approximately 55 MPH, there was an abnormal sound coming from the roof. The contact stated that it sounded like an object bouncing on the roof of the vehicle. The contact stated that the sound ceased after several minutes. The contact arrived at the destination, checked the roof, and became aware that the passenger’s side roof rail had detached from the vehicle. The vehicle was not taken to a dealer or independent mechanic to be diagnosed or repaired. The contact researched online and related the failure to NHTSA Campaign Number: 21V316000 (Structure); however, the VIN was not included. The manufacturer was informed of the failure. The failure mileage was approximately 54,000.

The contact owns a 2019 Ford Explorer. The contact stated that while driving approximately 65 MPH, there was an abnormal anti-freeze odor inside the cabin of the vehicle. The contact stated that the "overheat" and "temperature" gauge illuminated. The contact drove the vehicle back to the residence, parked the vehicle, and observed that anti-freeze was leaking onto the driveway. The contact had the vehicle towed to an independent mechanic and was informed that the water pump had failed and needed to be replaced. The contact was referred to a dealer for assistance. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 70,000.

The contact owns a 2019 Ford Explorer. The contact stated while driving 25 MPH, the exterior A-pillar trim detached from the vehicle. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure; however, was unable to confirm when the part would become available. The failure mileage was 85,000. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000(Structure); however, the part to do the recall repair was not yet available. The contact stated that the upper part of the driver's side windshield exterior A-Pillar trim was fractured, causing the trim to detach. An unknown local dealer was notified of the failure. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 120,000. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact stated that while driving at 40 MPH, the trim piece detached from the vehicle. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE) however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure however was unable to confirm when the part was to become available. The failure mileage was unknown. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact stated while the vehicle was at the dealer for a routine oil change, it was discovered that the roof rack was loose and advised the contact to bring the vehicle to the dealer the following day to have it inspected. The vehicle was taken back to the same dealer the following day as instructed and it was advised that the roof rack needed to be replaced. The vehicle was previously serviced under NHTSA Campaign Number: 21V316000 (STRUCTURE) however it failed to prevent the risk. The vehicle was not repaired due to it being out of warranty. The manufacturer was notified of the failure. The approximate failure mileage was 32,000.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

For months, almost a year, my transmission could not properly accelorate. The car would not allow for the pick up in speed to happen. Each time I took it to the shop that cares for my car, Mike's More Miles, the problem would not duplicate. My special needs son, his service dog and I were all of the expressway traveling, the car slowed down on its own, I had not applied the brakes, the speed dropped from 65 to less than 35 in seconds. I pulled over and tried to regain speed after putting the car into park. No luck. the car would not go faster then 20-30 miles an hour, with me putting into neutral when coasting downhill, then back into drive manually to get it to the repair shop. This almost caused a terrible accident. This scared my son, who has brain disease. Our 85 lb. service dog was jolted from the back of the car slamming into the seat. I was also very scared and shaken. My son began to yell and scream what is happening, it was a scary and tense, literally jaw dropping experience. I drove to Enterprise Rental, called Austin the owner of the shop that has tried to duplicate the problem on a dozen tried and told him what occurred. I left my car at Enterprise, where Austin picked it up. The problem did duplicate. FINALLY a code came up to diagnose the problem. The transmission fluid was also black, with metal shavings in it as well. Please refer to all technical service bulletins that note this is a known problem by Ford. I have paid $7582.70 for a new transmission. The sho

The contact owns a 2019 Ford Explorer. The contact stated while driving at an undisclosed speed, the Forward Collision Avoidance camera failed to function as intended. The contact stated that the Forward Collision Avoidance camera displayed a very blurry image. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The dealer was made aware of the failure. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 68,500.

Vehicle lost acceleration while driving down highway and shuttered severally when depressing gas pedal. I had to cut across lanes of highway traffic with no power and nearly caused an accident. Engine revs up be vehicle wont accelerate, just shakes badly. I am waiting on a mechanic to verify the problem but appears to be a transmission failure. The vehicle has had hard shifting in recent months leading up to this failure. A 2019 model year with 105000 miles.

Rear left toe link failed while entering a curved freeway on ramp. Failure caused the vehicle to lose traction in the rear causing the vehicle to fish tail. Advanced drivers training prevented a collision but the vehicle swayed back forth due to the forward momentum. By a miracle there was no collision because it was a narrow two lane road, with no shoulder and was between concrete wall and guardrail.

See attached document for complaint.

I am writing to formally file a complaint regarding my 2019 Ford Explorer, which is currently subject to the 2011–2019 Ford Explorer® — A-Pillar Trim Detachment Recall (Recall Reference Number: 24S02). The exterior A-pillar trim on my 2019 Ford Explorer, covered under the aforementioned recall, has caused severe issues including vibrations and a loud whistling noise around the windshield area, particularly at highway speeds. These problems are not only a nuisance but also pose a potential safety hazard, as the vibrations could lead to more severe structural damage or detachment of the trim while driving. I have contacted several Ford dealerships in my area, as well as Ford headquarters, seeking a resolution under recall 24S02. Unfortunately, I was consistently informed that the necessary parts to correct the issue are not available. I was told that Ford had provided the parts, but they were only available for a two-week period and are no longer in stock. The person I spoke with at the dealership advised me to call back at a later time to check if the parts are available. Additionally, when I reached out to Ford’s headquarters customer relations department for further assistance, I was simply transferred to my local dealership without any other form of help or guidance. This lack of support from the manufacturer is deeply frustrating and concerning. Furthermore, one of the dealerships informed me that another customer with similar issues under the same recall has been waiting

The contact owns a 2019 Ford Explorer. The contact stated that while driving at an undisclosed speed, after a visual inspection of the exterior of the vehicle, the contact became aware that the shark fin antenna cover had detached, potentially becoming a dangerous road hazard. The vehicle was taken to the dealer, who was unable to determine the cause of the failure. The dealer determined that the shark fin antenna cover had detached independently. The vehicle was not repaired. The manufacturer was notified of the failure but did not assist. The failure mileage was 32,000.

The contact owns a 2019 Ford Explorer. The contact stated upon inspection, it was noticed that the B-pillar applique trim was peeling off. The vehicle was taken to a local dealer where it was diagnosed that the B-pillar applique trim needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 75,000. The VIN was not available.

The contact owns a 2019 Ford Explorer. The contact stated while driving approximately 70 MPH, the vehicle lost motive power, decelerated, and stalled. The vehicle was later towed to the local mechanic who diagnosed that the water pump was faulty and needed to be replaced. The water pump was replaced, and the vehicle was repaired. The manufacturer and local dealer were notified of the failure, but no assistance was provided. The failure mileage was unavailable.

The contact owns a 2019 Ford Explorer. The contact stated that while depressing the accelerator pedal, the vehicle shuddered and failed to properly accelerate. The contact stated that the failure also occurred on several occasions while driving up an incline. The vehicle was taken to the local dealer to be diagnosed and it was determined that the transmission was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 84,000.

The contact owns a 2019 Ford Explorer. The contact stated while driving at 75 MPH, the driver's side windshield exterior A-pillar trim separated and flew off. The contact stated that the failure caused the passenger's side of the windshield to become fractured. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. No further information was provided. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was 78,532. VIN tool confirms parts not available.

Vehicle suddenly began vibrating while in drive or reverse, and developed decreased acceleration, and overall sluggish performance. Mechanic checked and said it was the torque converter. This exact problem is addressed by a Customer Satisfaction Program 20N07, which seems like it should include my vehicle because it was manufactured in the covered location and dates. However, my VIN number does not appear to be covered.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Rough idle in drive and reverse, hard shifting or not shifting In to gear

The vehicle vibrates excessively when shifting into Drive or Reverse (rough idle). Additionally, the vehicle lacks acceleration/power when driving in slightly uphill roads, creating a hazard for nearby drivers. There were no check engine lights and the issue first appeared at approx. 84,000 miles. The vehicle was diagnosed at a Ford dealership and the issue was determined to be the torque converter. The Ford Service Dept cited TSB 22-2287 and recommended replacing the full transmission to fix the issue.

EXTERIOR A-PILLAR TRIM PART DETACHED, NOW CAUSED CRACKED WINDSHIELD WHERE TRIM WOULD HAVE BEEN. THE PART HAS BEEN DETACHED FOR MONTHS AND MY LOCAL FORD DEALERSHIP HAS NO TEMPORARY OR PERMANENT SOLUTION. MY WINDSHIELD NOW HAS A SPIDERING CRACK WHERE IT WOULD HAVE BEEN PROTECTED .

The contact owns a 2019 Ford Explorer. The contact stated that there was an orange wrench warning light was illuminated when the vehicle was shifted into reverse. The vehicle was towed to the dealer where it was diagnosed, and it was determined that the failure was with the torque converter. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The vehicle was towed to an independent mechanic where the same information was provided. The vehicle was not yet repaired. The manufacturer was notified of the failure and advised to contact NHSTA Hotline for assistance. The approximate failure mileage was 65,000.

I was putting my car in reverse and all of a sudden, it shifts really hard and makes this loud noise. I thought it was very strange, and put it in drive and went not even 2 minutes and my car had no power. I was pressing the gas pedals but it didn't want to go. I stopped it and called a Tow truck to come get my car and take it to the nearest Ford dealer. They called me in a few days advising that the transmission was gone. After researching online, I noticed a lot of Ford Explorers being recalled for this exact issue, including My sisters Ford Explorer. Hers was under the recall, and Ford paid for hers. Ironic, the same thing happened to mine and mine has no recall. My car had been running fine, up until this day. I have maintained this car and no warning lights ever came on, until I put it in drive and the Orange Wrench cam e on. I knew something was wrong then. I am a single mother of a [XXX] and this could have put us in alot of danger INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2019 Ford Explorer. The contact stated while driving 65 MPH, the A-pillar trim on the passenger’s side windshield started to detach. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The local dealer was contacted, and the dealer stated that parts were not yet available. The contact was charged for the vehicle to be diagnosed. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and referred the contact to the NHSTA Hotline for assistance. The approximate failure mileage was 56,000. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving approximately 62 MPH, the front driver’s side door keypad detached and caused a short circuit in the battery causing the battery to fail. The battery was replaced, and the keypad was repaired but shortly afterward the keypad detached and flew off the vehicle on the highway and the battery failed again. The contact referenced the failure to TSB: 19-2150 (Factory Keyless Entry Keypad). The dealer was made aware of the failure. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 19,000. VIN tool confirms parts not available.

I took my vehicle last year to the dealership to report the safety concern I had with a loose piece under my hood causing a flapping sound while driving. They determined the exterior a pillar was warped, loose and missing pieces. I received the recall in the mail a few weeks later, although they will not set up an appointment for me to resolve this issue. Not only does it state this is a potential safety concern, it has already been established this piece is defective on my vehicle. I also drive fellow associates around to meetings in my vehicle and it is putting them in danger along with myself and is bringing concerns it has not yet been addressed. The recall was sent to me a few weeks later on 01/26/2024.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was not made aware of the issue. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Airbag light has come on, states second row passanger side airbag inflatable circuit (inflatable seatbelt). Just purchased vehicle two days ago.

The contact owns a 2019 Ford Explorer. The contact stated that the roof rail had detached. The local dealer where the vehicle was diagnosed determined that the roof rail needed to be replaced. The contact stated that the roof rail was temporarily fixed with tape. The vehicle was not repaired. The contact was made aware NHTSA Campaign Number: 21V316000 (Structure). The manufacturer was made aware of the failure. The failure mileage was approximately 21,000.

The contact owns a 2019 Ford Explorer. The contact stated while driving approximately 65 MPH, the passenger's side A-pillar trim detached and made a loud popping sound. The contact stated that the driver's side A-pillar trim was extremely loose. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The vehicle was taken to the dealer. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made of the failure. The failure mileage was approximately 63,250. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact stated that the exterior pillars on both sides of the window had detached. Additionally, the contact stated that while driving on several occasions over 30 MPH, she observed a loud buzzing noise and wind coming through the sides of the windshield. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 76,000.

The windshield cawl ( bottom piece that goes across windshield) has deteriorated. Making a whistling sound going down the road. I have already in December 2023 had to replace the A pillar trim and clips on driver side. Have talked to other explorer owners having the same issue. Thank you for your time

The contact owns a 2019 Ford Explorer. The contact stated while driving approximately 60 MPH, the vehicle began making abnormal noises from under the floorboards. The contact stated that the vehicle was losing forward momentum. The contact depressed the accelerator pedal and the vehicle only revved and was not gaining forward momentum. The contact stated numerous warning lights were illuminated. The contact stated that he was able to reach his destination, but was not able to exceed 30 MPH. The contact was able to drive the vehicle to a dealer; however, the vehicle was not diagnosed or repaired. The contact stated that the transmission had been replaced a year prior and felt that the failure was related to the transmission. The manufacturer was not informed of the failure. The failure mileage was approximately 52,000.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

I was traveling on the interstate (~75 mph) when the rear of my vehicle suddenly jerked to one side with enough force to cause a loss of control. There were no lights or warning sounds to indicate that there was anything wrong with the vehicle in that moment or leading up to it. I was fortunate enough that no contact was made with any other vehicles as my car crossed all three lanes; from the center lane to the far right and then back across all three lanes to the far left. The car skidded off the highway and slid onto a sloped embankment before it stopped. Obviously, I or someone else could have been seriously injured or even killed. I was able to drive the car back up on the shoulder of the highway. Everything was functioning properly EXCEPT the steering. I was able to drive at ~15 mph to the nearest exit. I was then towed to my mechanic's shop. The tow truck driver said it looked like my right rear tire was about to "fall off" and that I was very lucky. My mechanic took pictures of the damaged part (Right Rear Toe Arm) both on the vehicle and again once removed. He checked with Ford for a recall and found out that this part had been part of a recall on Explorers from 2012-2017, but not on the 2019. Assuming the part had been redesigned after 2017, he ordered a replacement for the right. (The Left Toe Arm was not damaged.) However, once the replacement part arrived, it was a completely new design from the 2019 Toe Arm. He recommended I replace the Left Toe Arm as well since

The B-pillar trim piece has become detached from the vehicle due to broken clips and when driving it appears as if it will fall off. Ford will not address the issue, other then using two sided adhesive tape which needs to be replaced continuously. The clips that hold the trim in place are broken and this is common on many explorers. There are other body trim pieces which have been recalled for and this needs to be added as well. The A-pillar trim was recently a recall item and this is just as much a hazard.

The contact owns a 2019 Ford Explorer. The contact stated that there was rust on the aluminum hood, which had bubbles and rust. The vehicle was taken to the local dealer, who stated that the hood needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, but no additional assistance was provided. The failure mileage was approximately 18,600.

The contact owns a 2019 Ford Explorer. The contact stated that there was an abnormal sound coming from the vehicle. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The approximate failure mileage was 38,000. VIN tool confirms parts not available.

My wrench light came on in my 2019 Ford Explorer with 2.3L engine last week. It caused my vehicle to have lack of acceleration during launch and shudder while driving. When my son and I took off from a stop, it was very slow when crossing traffic. Made appointment with Ford dealership to have it looked at the next morning. After car was parked and restarted, wrench light went off. Kept appointment and told them a mechanic friend said it sounded like the torque converter (which my mother who has a 2019 Ford Edge just had replaced the week before!). Explained this to the dealership, they said it didn't sound like that was it. 4 wheel drive module was corrupt so they updated it and told me I may need a new transmission in the near future. Today, my light came on again while taking my son to school and caused lack of acceleration while pulling onto the highway and I took it to the dealership while it was lit up. Codes P0767 and P2704 showed and they told me it was I needed a new transmission due to my torque converter failing. I checked into it and Customer Satisfaction Program 20N07 does not include my car even though it is doing the exact same thing and was assembled in Chicago in January 2019 (timeframe of the program and location). I just don't understand how my car doesn't fall under that program when it is DOING THE EXACT SAME THING with only 67,200 miles on it. This is a serious safety concern. So thankful that there was not heavy traffic when I pulled onto the highway.

The contact owns a 2019 Ford Explorer. The contact stated that the horn was inoperable. There was no warning light illuminated. The dealer was notified of the failure and an appointment was scheduled to perform a diagnostic test. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 74,000.

The contact owns a 2019 Ford Explorer. The contact stated that while driving at an undisclosed speed, the exterior B-Pillar trim detached. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 24V031000 (Structure). The manufacturer was notified of the failure but provided no assistance because the recall did not include the B-Pillar. The failure mileage was 96,000.

Drivers door will not lock. It will only lock if you push it down but doesn’t lock when taking off like it’s supposed to for safety.

Needs a full transmission replacement and only have 80,000 miles on it. Bought new from dealership in 2019.

The A-pillar passenger side flank flew off while driving.

Operator law enforcement was idling for an extended time in this vehicle. He was found unconscious in the vehicle and diagnosed with acute carbon monoxide poisoning. He was hospitalised for 4 days, and suffers continuing neurological deficits. Post-incident testing by engineer instructed by operator indicated two improper or incomplete welds on exhaust system, allowing exhaust to pool under vehicle and enter passenger compartment through HVAC fresh air intake. Post-incident testing recreated rising CO levels in passenger compartment. Vehicle has also been inspected by manufacturer. There were no warning lamps or messages.