2019 Ford Explorer complaints

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000(Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the windshield exterior A-pillar trims were loose, and there was a noticeable windy sound coming from the windshield while driving. The vehicle was taken to the dealer, where the contact was informed that the parts to do the recall repair were ordered. The vehicle was not yet repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 50,000.

The contact owns a 2019 Ford Explorer. The contact stated that while driving at an undisclosed speed, the contact noticed an abnormal buzzing sound coming from the windshield. The dealer was made aware of the failure. The contact stated that a technician arrived at the residence and inspected the vehicle, and placed duct tape around the front windshield. In addition, the contact was informed that the vehicle would fail an inspection with duct tape around the front windshield. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, parts were not yet available. The vehicle was taken to the dealer several times; however, the contact was informed that parts were not yet available. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was unknown.

Blown engine due to ecoboost fuel issues. Vehicle quit and shut off on highway. Multiple issues with 2019 ford explorer that does not get resolved.

The contact owns a 2019 Ford Explorer. The vehicle was serviced under NHTSA Campaign Number: 24V031000 (STRUCTURE), but the failure persisted. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the windshield. The local dealer was contacted; however, the vehicle was not inspected or diagnosed. The manufacturer was not made aware of the issue. The failure mileage was unknown.

The catalytic converters for the Ford Explorer Utility Police Interceptor fail prematurely, degrading the emissions from the vehicle and causing the vehicle to fail emissions testing. Although Ford has implemented a Customer Satisfaction Campaign 22M06, they do not inform owners of the campaign or potential problem. My car was inspected by two Ford dealerships who simply cleared the error code (P0430) and made no mention of Campaign 22M06. The error code persisted as I replaced numerous other components (spark plugs, purge valve, oxygen sensors, Mass air flow sensor) trying to alleviate the problem over the last year. Only if you mention the campaign specifically will they inspect the vehicle for the purpose of replacing the the catalytic converters under warranty. Replacing these failing catalytic converters should be a recall because failure creates substandard emissions for thousands of vehicles.

The contact owns a 2019 Ford Explorer. The contact stated that after a visual inspection of the exterior of the vehicle, the driver’s side roof rack rail had detached. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 21V316000 (Structure). The VIN was included, but the vehicle was repaired in October 2025. The manufacturer was not notified of the failure. The failure mileage was 90,000.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

Suspension issue causing premature inside tire wear which can be fatal, if not deadly. Multiple cases have been recorded and found among other owners for this same make and model yr. Even after parts replacement and 4 wheel alignment was completed.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that upon further inspection, the front driver’s and passenger’s side A-pillar trim seals had started to deteriorate. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 93,000.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure). The contact stated that while driving approximately 65 MPH, the driver’s side exterior A-pillar trim detached and flew off the vehicle. The vehicle was taken to a dealer, where it was determined that the part was under recall and that parts were not yet available for the recall repair. The manufacturer was not notified of the failure. The failure mileage was unknown.

The A pillars are coming off. Other years make and model were recalled . The A pillars on the sides should be recalled just as the front b pillars.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had experienced the failure listed in the recall. The failure mileage was 75,000.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The dealer was contacted. The dealer confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

Rear camera stopper working.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was not yet available. The contact stated there was an abnormal sound coming from the windshield while driving. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was not available.

It has been a year and a half since Ford recalled a part and they have yet to replace that part. It’s a year overdue from the timeline they claimed to be ready by.

The contact owns a 2019 Ford Explorer. The contact stated while driving approximately 75 MPH with the cruise control activated, the vehicle suddenly started sputtering and decelerated unintendedly. The vehicle was driven to the shoulder of the roadway, and the vehicle stalled. The vehicle failed to restart and was towed to the local dealer. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 52,000.

I have attempted multiple times to report Sync 3 screen issues with this vehicle. Began as intermittent issues. Screen would go off, get hung in reverse, unable to use touch screen, etc. Now, it is completely useless. Not able to use touch screen, not able to connect phone thru Bluetooth (making phone unusable), basically not unusable. I have no access to maps, any controls on screen. There's recalls on Explorers for this exact issue in 2020, etc models, so I am positive this same issue relates to mine. This is a very costly part to repair (we were quoted over $1200.00 by local Ford Dealership My car was barely out of warranty when this issue occured.

The contact owns a 2019 Ford Explorer. The contact stated that upon noticing that the roof rail cover was missing, the vehicle was taken to the local dealer, where it was repaired under NHTSA Campaign Number: 21V316000(Structure); however, the failure recurred. The contact stated that while driving at 30 MPH, the roof rail cover detached from the vehicle. The driver was able to retrieve the roof rail cover. The contact called the local dealer, but there was no response. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 63,000.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Subject: Urgent Complaint – Recall Repair Delayed Due to Unavailable Parts (2019 Explorer) To Whom It May Concern, I am writing to formally file a complaint regarding a safety-related recall/service campaign for my 2019 Ford Explorer (VIN: [XXX] ), specifically concerning the roof rack trim detachment issue (Customer Satisfaction Program / Recall #20N11 or 21S22). I visited an authorized Ford dealership to schedule the required repair, but was told that the necessary parts are currently unavailable, and no estimated delivery date could be provided. It has been an extended delay, and I am concerned about the continued safety risk this issue may present. As this is a known issue affecting many vehicles, I respectfully request: •A clear explanation of when the required parts will become available •An expedited resolution or alternative dealership that can complete the repair •A formal record of this delay for safety and warranty documentation purposes Please treat this matter as urgent. I would appreciate a prompt response with a timeline and any appropriate next steps. Sincerely, [XXX] Phone: [XXX] Email: [XXX] Location: Manhattan, New York VIN: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The bottom part that holds the windshield down is coming off. My windshield sounds like it is going to fly off when I drive. It makes a constant loud noise when driving. This has been an ongoing issue for almost 2 years. Ford told me they couldn’t do anything about it.

The contact owns a 2019 Ford Explorer. The contact stated that upon acceleration from a stop, the vehicle experienced a loss of automotive power. There were no warning lights illuminated. The vehicle was towed to a local dealer where it was diagnosed, and the contact was informed that the fuel pump and the fuel injectors were faulty and needed to be replaced. The vehicle was repaired; however, the failure persisted. The contact stated that on another occasion while driving 63 MPH, the vehicle lost automotive power. There were no warning lights illuminated. The vehicle was towed to a local dealer where it was diagnosed, and the contact was informed that the fuel pump and fuel injectors were faulty and needed to be replaced. The vehicle was repaired; however, the failure reoccurred while driving 72 MPH, and the vehicle lost automotive power. There was no warning light illuminated. The vehicle came to a complete stop and the contact called the Police for traffic control and the vehicle was towed to a local dealer to be diagnosed. The contact was informed that the fuel pump and the fuel injectors were faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 60,000.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was not yet available. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that the front driver’s side A-pillar trim had been ejected from the vehicle, and the passenger’s side A-pillar trim was cracked and not fully secured to the vehicle. The failure mileage was 104,000. VIN tool confirms parts not available.

Car would not start at certain times without warning. Sometimes putting us in an unsafe location. Finally vehicle was in a public parking and would not start and had to be towed to Ford dealer. The fuel pump and some other issues failed. Repair shop said it would happen with low gas, but we had over a half a tank. Total cost of bill without tow was $2132.02. Vehicle had 45,015 miles.

On 3 separate occasions my car has stalled when driving. All three were after driving for several hours in hot weather. 2 of the times I had a quarter of a tank of gas and pressed on the gas to pass someone and my car stalled out immediately after. Both very dangerous scenarios. 3 time just this week. Driving for over 5 hours in hot weather conditions, but 3 quarters of a tank of gas and stuck in traffic and the car just completely stalled. Again a dangerous scenario on the highway. All three times after waiting for about 45 minutes the car will start again. Sluggish at first and then drives normal. It’s giving indications that it could be a defect in the low pressure fuel pump that has been a recall in other 2019 ford explorers, but my vin #is not listed as one of them.

The contact owns a 2019 Ford Explorer. The contact stated while washing the vehicle in the driveway, the contact became aware that the A-pillar trim on the front passenger’s side had started to detach. The vehicle was not diagnosed by the dealer; however, a technician from the dealer went to the residence to inspect the vehicle. The vehicle was not repaired. The manufacturer was not notified of the failure. The contact related the failure to NHTSA Campaign Number: 24V031000 (STRUCTURE); and the VIN was included. The failure mileage was 73,441. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact stated while driving approximately 65 MPH, the keypad cover on the driver’s side door detached. The vehicle was taken to the dealer, who confirmed that the trim that had detached was not under recall. The vehicle was not repaired. The manufacturer was informed of the failure. The manufacturer opened a case regarding the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 68,000. The VIN was unavailable.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The A-PILLAR TRIM has flew off on the freeway on 4 separate occasions. 3 different times I paid out of pocket to have it repaired, not knowing this was a manufacture defect. Ford keeps saying that they do not have the parts to repair it.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

[XXX] � [XXX] [XXX] ⸻ To Whom It May Concern, My name [XXX], and I am writing to file a formal complaint against Ford Motor Company and multiple associated dealerships for gross negligence, financial harm, and discriminatory practices related to a recall repair that began in 2023 and has yet to be properly resolved. I own a 2019 Ford Explorer, VIN [XXX]. In 2023, I brought my vehicle to Wayne Akers Ford in West Palm Beach due to a torque converter recall. Before the issue was fixed, their transmission technician was fired, and I was redirected to Mullinax Ford. That began a two-year ordeal of being passed around between dealerships, misdiagnosed, and ignored while the original issue persisted. Alpaca Ford on 10th Avenue witnessed the malfunction twice but refused to repair it. I was told by Lenny, the Service Manager, and the Advisor Manager to “monitor the mileage” and report back — a delay tactic that eventually allowed them to deny my repair once the issue persisted at under 30 miles. When I returned with proof, they claimed the warranty had expired. This was caused entirely by their inaction and misguidance. To make matters worse: •I was forced to pay $1,300 for motor mounts that didn’t resolve the issue, despite telling them repeatedly it was unrelated. Ford covered a portion, but I was left to pay $897 out of pocket. •Tim Olsen at Wayne Akers Ford has refused to provide my refund and is now ignoring all calls and communication. •Ford’s corporate customer service has bee

In February I was driving to an appt. when the side panel on driver's door broke & started flying around & hitting car. (It has the numbers to enter the car without a key.) So I had to roll down window 1/2 way, grab the broken part & drive 18 miles to town, holding the part so it wouldn't fly off (in 30 degree weather!) So I drove by the Ford Dealership where I got my car. They thought there was a recall on that item so I've been waiting. I just saw on the NHTSA site there was a recall for that item on 2016-17? Explorers, but mine is 2019!!! Would you please add the 2019 model to that recall? Also, I'm STILL WAITING (1 1/2 years later) for the recalled trim pieces around the front windshield.

The contact owns a 2019 Ford Explorer. The contact stated that upon start-up there was an abnormally loud rattling sound coming from the engine compartment, with the check engine warning light illuminated. The cause of the failure has not yet been determined. The manufacturer and local dealer were notified of the failure, but no assistance was provided. The failure mileage was 97,000.

The contact owns a 2019 Ford Explorer. The contact stated while driving at an undisclosed speed, the brake pedal became inoperable. There was no warning light illuminated. The contact stated that the brake pedal failed to function properly, and the contact had to depress the brake pedal with added force to stop the vehicle. The contact also stated there was an abnormal sound while depressing the brake pedal. The vehicle was towed to the dealer, where it was diagnosed and determined that the rear brake pads and rotors had failed, and the braking system needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was opened. The contact was also referred to the NHTSA Hotline for additional assistance. The approximate failure mileage was 36,000.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was not contacted. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the driver's side windshield exterior A-pillar trim had detached. The vehicle was taken to the dealer, who inspected the vehicle and advised the contact to apply tape on the windshield trim. The contact stated that the trim was taped; however, while driving 65 MPH, the driver's side windshield exterior A-pillar trim separated from the vehicle. Additionally, the contact stated that the weather stripping around the windshield was detaching. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure and informed the contact that the part was available at the dealer. The failure mileage was approximately 40,000. VIN tool confirms parts not available.

Difficulty getting the vehicle repaired in a reasonable time or without charge. Initial recall indicated parts would be available in the latter half of 2024. It is now mid 2025. Ford dealership indicates parts are not available for recall, BUT parts ARE available if I'd like to pay out of pocket for repairs. That seems fraudulent and the A-pillar trim on my vehicle is obviously defective and coming off the vehicle. This is hazardous and Ford should not be able to charge for repairs and not comply with the recall repairs.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the front driver's side windshield exterior A-pillar trim had detached. The vehicle was taken to the dealer, where it was inspected. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 95,000. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The windshield lower molding is deteriorating. The molding has cracked and fallen off in several places. This has been happening over the last 6 months but has gotten much worse. It also makes a buzzing vibration over 50mph. I'm afraid that if it gets any worse the windshield may pop out in an accident. Unknown Unknown No warning

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The A-pillar trim on the driver's side around windshield is coming off, and poses a risk to other drivers if it flys off while driving down the road. A recall on Ford Explorers of the same year is already issued, does not include the Police utility of same year.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated that while driving approximately 25 MPH, the driver's side A-pillar blew off the vehicle. The contact was unable to stop to recover the trim. The failure mileage was 25,000. VIN tool confirms parts not available.