2018 Ford Explorer complaints

Strong exhaust smell in the front cabin while driving 40+ mph. Resulting dizziness and nausea symptoms. Vehicle taken to dealer for diagnosis. Odometer reading 10560

Roof Rail cap flew off on Highway. Complained of issue was told its under investigation but no fix is available

Roofrack became detached while driving on freeway. Almost flew off in traffic and had to hold onto it while driving until I was able to pull over and tape it down. Almost flew off road while holding it down.

Air conditioning failed. dealer says its compressor, but they have had it for a month and cannot fix it. last excuse was a bolt fracture. bolt fracture? my previous 2013 explorer had a fire in the ac unit at 9 thousand miles.

On June 18, 2021 while driving we noticed a particular smell inside the vehicle while driving and stationary. When we exited the vehicle the smell was exact same smell as the exhaust coming from the car. All doors were closed to include rear hatch as it was 110 plus outside. We had the A/C on recirculating mode and wife complained of a headache and mentioned she had been getting headaches several times while in the vehicle and I too had a headache. I searched the web and came across the same in issue with this generation Explorer and people had stated the 2018 models had the same complaint but were not recalled. For the remainder of the trip we rolled windows down and used fresh air to clear to vehicle of the exhaust smell. The vehicle has not been inspected by the dealer as we have been driving another vehicle due to the safety risk of CO2 poisoning.

The contact owns a 2018 Ford Explorer equipped with four Hankook tires, Tire line: Ventus S1 Noble S2, Tire Size 255/50/R20. DOT Number: 5mnb1ah1218. The contact stated while having a routine inspection was informed that the rear driver and passenger tires needed to be replaced due to unusual wear. The vehicle was taken to the dealer where they were unable to determine the failure cause. The manufacturer was not notified. The tire mileage was 50,000. The failure mileage was 14,000.

The contact owns a 2018 Ford Explorer equipped with Hankook Ventus S1 Noble 2 tires. Size: 255/50R20 105H, dot number: 5mnc 1ah 1218. Upon inspection, it was discovered that the 2 rear tires were prematurely worn out or will get a rejected sticker if not replaced. Owner went to Baystate Ford dealer in Easton MA where the failure was confirmed, but the cause of the failure was not determined. The contact was told by this dealer service that neither they or the manufacturer would offer any assistance for this failure.

2018 Ford Explorer. Consumer writes in regards to roof rail covers safety recall. THE CONSUMER STATED THE PARTS NECESSARY TO COMPLETE THE RECALL REPAIR WERE UNAVAILABLE. THE CONSMER STATED THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME COMPLETING THE RECALL REPAR.

WINDSHIELD TRIM PIECE CAME OFF WHILE TRAVELING ON THE FREEWAY.

TODAY I NOTICED THAT THE TRIM ON MY WINDSHIELD WAS CRACKED, BROKEN AND FALLING OFF. MY CAR HAS ABOUT 40K MILES ON IT AND WOULD NOT HAVE EXPECTED THIS TO FALL APART ALREADY. THIS PAST YEAR I MAY HAVE DRIVEN MY CAR 5000 MILES. IT HAS NOT BEEN IN ANY STORMS OR EIGHT WIND SITUATIONS. I HAVE BEEN HEARING A STRANGE NOISE IN THE FRONT BUT DID NOT CONNECT THIS TO A TRIM MOLDING ISSUE. IT IS DANGEROUS BECAUSE IT COULD FLY OFF AND HIT A PEDESTRIAN,MOTORCYCLE RIDER OR BICYCLE RIDER OR EVEN ANOTHER VEHICLE.

UNDER ACCELERATION WITH THE AIR CONDITIONING SET TO RECIRCULATE THE CABIN FILLS WITH EXHAUST FUMES.

POWER STEERING WENT OUT TWICE. DEALERSHIP SAID NO PROBLEMS. NOW MAKE NOISE. DEALERSHIP STILL SAYS NO PROBLEM. BLAMED IT ON AGE. IT IS A 2018 SUV. SHOULD NOT BE HAPPENING.

ON JANUARY 24, 2021 I BOUGHT MY CERTIFIED PRE-OWNED 2018 FORD EXPLORER SPORT. THE FOLLOWING WEEK I HEARD AN INTERMITTENT BANGING SOUND WHEN DRIVING DOWN THE ROAD AT APPROX. 60 MPH. WHEN I GOT HOME I SAW THAT THE PLASTIC COVERINGS OF THE ROOF RACK RAILS WERE COMING OFF AND WERE WHAT WAS MAKING THE BANGING SOUND. FROM RESEARCHING THE ISSUE ONLINE IT APPEARS IF LEFT UNADDRESSED THE COVERS CAN FLY OFF THE VEHICLE WHILE ON THE ROAD. UNFORTUNATELY FORD HAS YET TO PROVIDE A FIX. THERE ARE HUNDREDS OF COMPLAINTS FROM PEOPLE ONLINE SHOW THIS IS A VERY COMMON PROBLEM AND FORD HAS YET TO PROVIDE A ADEQUATE SOLUTION FOR. SOME PEOPLE HAVE STATED THAT FORD'S FIX IS TO APPLY SILICONE TO THE CLIPS THAT COME LOOSE. UPON INSPECTION I SEE THAT SILICONE HAD BEEN APPLIED TO MINE PREVIOUSLY (NOT BY ME) AND THAT, LIKE MANY OTHER REPORT, THIS DOES NOT HOLD/ RESOLVE THE PROBLEM. MANY MORE USER COMPLAINTS OF THIS ISSUE CAN BE FOUND HERE HTTPS://WWW.CARGURUS.COM/CARS/DISCUSSION-T73385_DS991660

THIS CAR HAS A LEAK ISSUE. MULTIPLE POINTS OF ENTRY FOR WATER LEAVE THE CAR SOAKING WET AFTER RAIN. THIS ISSUE WAS UNKNOWN AS ALL-WEATHER LINERS WERE PLACED INTO THE CAR BLOCKING OCCUPANTS FROM BEING ABLE TO FEEL LARGE AMOUNT OF WATER ACCUMULATED ON THE FLOOR. MOLD GREW IN CAR AS OCCUPANTS DID NOT KNOW THAT THEIR WAS AN ISSUE POSING AN EXTREME HEALTH HAZARD TO ADULTS AND CHILDREN. THIS IS NOT SAFE. FORD KNOWS THIS IS A KNOWN ISSUE AND HAS NOT TAKEN ANY ACTION TO REMEDY THE PROBLEM. THE CAR LEAKS WHILE IN MOTION AND STATIONARY. CARS ARE LEAKING FROM SUNROOFS, BOLTS, AND FROM UNDER THE HOOD. THIS IS MAKING PEOPLE SICK AND THEY DO NOT CARE. A CLASS ACTION SUIT NEEDS TO BE FILED AGAINST FORD. MY CAR HAD TO BE REPAIRED TWICE AT HAWKS PRAIRIE AUTOMOTIVE IN LACEY, WA IN DECEMBER 2020 AND JANUARY 2021. RECEIPTS CAN BE PROVIDED. I AM UNSURE IF THIS ACTUALLY REPAIRED THE ISSUE COMPLETELY.

ROOF RACK CONTINUALLY POPS LOOSE WHILE DRIVING.

WATER LEAK, PASSENGER SIDE 3RD ROW FIXED POSITION WINDOW EVERY TIME IT RAINS, WATER ACCUMULATES IN REAR OF VEHICLE

VEHICLE WHEN ACCELERATING PULLS SHARPLY TO RIGHT . PROBLEM NOT RESOLVED AFTER 30 DAYS AT DEALERSHIP. ALIGNMENT WAS NOT PROBLEM. WAS DOCUMENTED WHILE UNDER WARRANTEE ANT WAS FIRST NOTICED AT 21000 MILES AND DOCUMENTED

WE TOOK OUR 2018 FORD EXPLORER INTO THE SHOP LAST WINTER COMPLAINING OF A BAD SMELL. THE SHOP KEPT OUR CAR FOR ABOUT 5 DAYS AND SAID THERE WAS NOTHING WRONG. 2 WEEKS AGO MY WIFE WENT TO THE ER AND WAS DIAGNOSED WITH CARBON MONOXIDE POISONING. WE BEGAN WORKING WITH FOR TO HELP GET THIS FIXED, 5 DAYS LATER SHE PASSED OUT AT THE WHEEL AND WRECKED INTO A TELEPHONE POLL. WHILE AT THE ER THERE WAS CARBON MONOXIDE IN HER BLOOD AGAIN. THANK GOODNESS SHE DIDN'T HIT A FAMILY OR SOMETHING WORSE. SINCE THEN FORD HAS REFUSED TO WORK WITH US SINCE THE CAR IS WRECKED. THIS IS A PROBLEM AND NEEDS TO BE LOOKED INTO!*DT*JB*DT *TR

WHILE TRAVELING WITH ADAPTIVE CRUISE ENGAGED WE WERE IN LEFT LANE FOLLOWING A SEMI APPROXIMATELY 1000' AHEAD OF US AND WHEN HE MOVED OVER TO MAKE AN EXIT OUR VEHICLE PASSED BY AND AUTO BRAKED HARD CAUSING VEHICLES BEHIND US TO TAKE EVASIVE ACTION FROM HITTING US ALONG WITH VEHICLES IN THE RIGHT LANE OF TRAFFIC. THIS ALSO HAPPENED AGAIN THE FOLLOWING WEEK EXCEPT PASSING BY A DUMP TRUCK. I WAS AWARE THAT TIME AN MASHED ACCELERATOR IN TIME AS INSTRUCTED AS PER OPERATING MANUAL. I DON'T FEEL SAFE USING MY CRUISE WITH OR WITHOUT ADAPTIVE ON AND NOW SEVERAL WEEKS LATER I'M GETTING AN 'ADAPTIVE CRUISE NOT AVAILABLE' MESSAGE DISPLAYED ON INSTRUMENT PANEL.

DRIVING IN THE DARK AND PASSENGER SIDE HEADLIGHT WENT OUT. GOT DIAGNOSED THAT IT WAS A BAD LIGHT HOUSING.GOT VARIOUS PRICES FROM 700 TO 1200 DOLLARS. NOW THE LIGHT WORKS .WAS OUT FOR 3 WEEKS DECIDED TO COME BACK ON.WELL I WOULD ASSUME ITS NOT THE HEADLIGHT OR JUST FAULTY ELECTRONICS. NOT SURE ANY HEKP?

TL* THE CONTACT OWNS A 2018 FORD EXPLORER EQUIPPED WITH HANKOOK TIRES, TIRE LINE: VENTUS S1 NOBLE, TIRE SIZE: 255/50/R20, DOT NUMBER: 5MNC1AH3917. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THERE WAS AN ABNORMAL VIBRATION IN THE VEHICLE DUE TO CUPPING OF THE TIRES. THE CONTACT STATED THAT THE DRIVER'S SIDE FRONT TIRE HAD EXPERIENCED TREAD SEPARATION. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE LOCAL DEALER HUNTLEY FORD LOCATED AT 13900 AUTO MALL DR, HUNTLY, IL 60142 AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 24,000. THE VIN WAS NOT AVAILABLE.

WHILE DRIVING THE OTHER NIGHT IN RAIN, NIGHT AND HEAVY TRAFFIC, I HEARD SOME FLAPPING FROM THE ROOF OF THE CAR, BUT COULD NOT STOP BECAUSE WE WERE IN A MOUNTAIN PASS AND WINDING ROADS. I DID SEE SOMETHING LIKE FLY OFF OF MY CAR AND CARS BEHIND ME WERE SWERVING, I THOUGHT MAYBE A SMALL BRANCH. BUT NO IT WAS THE TOP CAP OF MY ROOF RAIL ON THE DRIVER SIDE. THE PART IS $450, AND WHEN I GOOGLED IT, IT IS DEFINITELY A KNOWN PROBLEM AT FORD. HUNDREDS OF HITS WITH THE SAME ISSUE

WHEN ACCELERATING ABOVE 2500 RPM, SUCH AS WHEN MERGING ONTO THE HIGHWAY / WITH THE FLOW OF TRAFFIC, OR ACCELERATING UP HILL, THE CABIN FILLS WITH A FOUL ODOR WHICH SMELLS LIKE BURNT OIL OR BAD EXHAUST. THIS HAPPENS WITH RE-CIRCULATION TURNED ON OR OFF, AND ALSO WITH THE A/C / FAN UNITS POWERED OFF ENTIRELY AND USUALLY WINDOWS MUST BE ROLLED DOWN TO GET THE ODOR/FUMES TO LEAVE THE CABIN. MY CONCERN IS IF THE SMELL IS COMING IN, ALL THE TOXIC GASSES AND FUMES THAT COME WITH IT ARE ALSO ENTERING THE CABIN.

THE RAIL COVER ON TOP OF THE CAR JUST CAME OFF WITH NO ONE MESSING WITH OR BEING DAMAGED. I RESEARCHED TO SEE IF OTHER HAS A PROBLEM LIKE THIS AND I FOUND NUMEROUS OF PEOPLE SAYING THE RAIL COVER JUST DETACHED FORM THE ACTUAL RAIL. WHILE DRIVING DOWN THE HIGHWAY.

THE TWO FRONT HANKOOK TIRES HAVE WEAR IN THE FORM OF FLAKING RUBBER AROUND THE WHOLE TIRE. AT ABOUT 10,000 MILES, WE WENT TO FORD TO HAVE IT LOOKED AT AND THEY REFERRED US TO THE TIRE STORE. THEY SAID IT WAS FINE, BUT AS I LOOK AT THE OTHER COMPLAINTS, IT IS OBVIOUS THAT THESE TIRES HAVE A FLAW AND THERE SHOULD BE SOME COMPENSATION GIVEN. AT 32,000 MILES OF CITY ROAD DRIVING, THE TIRES HAD TO BE REPLACED.

TL* THE CONTACT OWNS A 2018 FORD EXPLORER. THE CONTACT STATED THAT THE INFLATABLE SEAT BELT FAILED TO RETRACT WITH BRITAX FRONTIER CLICK TIGHT CHILD SAFETY SEAT WHILE USING THE HIGH BACK WITH THE REAR PASSENGER SHOULDER STRAP FAILED TO SECURE THE CHILD IN THE VEHICLE. AS THE CHILD WAS SEEN HANGING OUT THE WINDOW WHILE THE MOTHER WAS DRIVING. THE CONTACT STATED THAT THE CAR SEAT WAS SECURED WITH THE LATCH SYSTEM HOWEVER, THE CHILD WAS NOT SECURED WITH THE VEHICLE'S SEAT BELT. THE CONTACT STATED THAT THE FAILURE ALSO OCCURRED WITH THE GRACO TURBO BOOSTER WHICH DOES NOT HAVE A LATCH SYSTEM. THE MANUFACTURERS FORD AND BRITAX WERE MADE AWARE OF THE FAILURE. THE FORD MANUFACTURER OPENED A CASE. THE BRITAX MANUFACTURER OFFERED NO ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 18,000.*DT THE CONSUMER PROVIDED PHOTOS. *TR

I HAVE BEEN EXPERIENCING ACCELERATION/TRANSMISSION CONCERNS, WHERE THE VEHICLE ESSENTIAL STALLS AND WILL NOT ACCELERATE. AFTER APPROXIMATELY 5 SECONDS, THE COMPUTER AND TRANSMISSION APPEAR TO 'SYNC' AND THE VEHICLE WILL ACCELERATE, BUT THE ISSUE WILL CONTINUE TO HAPPEN UNTIL THE VEHICLE IS TURNED OFF AND BACK ON AGAIN. THE FIRST TIME THIS HAPPEN, I WAS IN A COSTCO PARKING LOT, SO I DID NOT THINK MUCH OF IT. THE SECOND TIME THIS HAPPEN, JULY 12TH, 2020, I WAS CROSSING A BUSY ROAD OF TRAFFIC NEAR MY HOME AND WAS ALMOST INVOLVED IN A SERIOUS ACCIDENT AS A RESULT OF THIS FAILURE. AS I WAS CROSSING THE 2 LANES OF TRAFFIC TO MAKE A LEFT HAND TURN, MY VEHICLE STALLED AND I WAS ALMOST SIDE SWIPED BY AN ONCOMING VEHICLE. AFTER THIS INCIDENT, I HAD MY VEHICLE TOWED TO A FORD DEALERSHIP FOR INSPECTION. UPON EXTENSIVE ANALYSIS OF THE VEHICLE, THE TECHNICIANS COULD NOT FIND ANYTHING WRONG WITH THE VEHICLE INCLUDING NO FAILED SENSORS IN THE COMPUTER AND THE TECHNICIANS WERE NOT ABLE TO REPLICATE THE CONCERN. ON AUGUST 19TH, 2020, MY CHECK ENGINE LIGHT CAME ON AND I IMMEDIATELY RETURNED THE VEHICLE TO FORD DEALERSHIP HOPING THIS WAS A RESULT OF THE ISSUES I HAD BEEN HAVING. UPON ANOTHER DIAGNOSIS, THE ERROR WAS CLEARED FOR AN ENGINE KNOCK SENSOR, BUT THIS WAS NOT RELATED TO MY CONCERNS WITH THE ACCELERATION OR TRANSMISSION.

I PURCHASED THE FORD EXPLORER SPORT LAST NOVEMBER 2018, AND THERE'S NO SQUEAKING NOISE UNDER THE STEERING WHEEL. I NOTICED IT LAST MONTH AND I GO STRAIGHT AT THE FORD DEALERSHIP AND THEY TOLD ME IT'S THE CHARACTERISTIC OF THE CAR. IM SO DISAPPOINTED WITH THE DIAGNOSIS, THE DISTURBING NOISE IS UNDER THE STEERING WHEEL, AND THE CONFUSING PART IS THE SQUEAKING NOISE YOU CAN ONLY HEAR THAT WHEN YOU TURN THE STEERING WHEEL TO THE RIGHT. HOPEFULLY YOU CAN PIN POINT THE PROBLEM. IF IT'S THE STEERING WHEEL OR THE AIR BAG INSIDE IS THE PROBLEM.

THE ELECTRONIC STEERING SYSTEM DETECTED A FAULT, TWICE. LOSS POWER STEERING WHILE DRIVING ON CITY STREET. I COULD BARELY TURN THE VEHICLE.

VEHICLE EQUIPPED WITH A 3.5L ECOBOOST V6 ENGINE HAD AN ILLUMINATED MALFUNCTION INDICATOR LAMP (MIL), POWERTRAIN MALFUNCTION (WRENCH) LAMP, SERVICE ADVANCETRAC MESSAGE, HILL START ASSIST NOT AVAILABLE MESSAGE, AND LACK OF POWER WITH DIAGNOSTIC TROUBLE CODE P0107 (MAP FAULTY). OCCURRED WHILE PULLING AWAY FROM A RED LIGHT WITHOUT WARNING. THIS DISABLED THE VEHICLE IN MIDDLE OF INTERSECTION AND POWER STEERING WAS LOST. VEHICLE LURCHED ERRATICALLY AND HAD TO BE PUSHED TO SAFETY THEN TOWED TO DEALER. VERY UNSAFE AS IT LITERALLY DIED AND STEERING WENT OUT WITHOUT WARNING!!! INITIALLY TOWED TO COLLEY FORD IN GLENDORA, CA. THAT DEALER WAS SO HORRIFIC TO DEAL WITH, WE HAD THE SUV IMMEDIATELY TOWED (AGAIN) TO PUENTE HILLS, CA DEALER. UNACCEPTABLE HANDLING BY COLLEY FORD.

MY 2018 FORD EXPLORER ROOF RACKS FLEW OFF (BROKE OFF) WHILE DRIVING ON THE FREEWAY CAUSING CARS BEHIND ME TO SWERVE TO AVOID IMPACT THIS OCCURRED IN JANUARY 2019.

IN MARCH 2018 I BOUGHT A BRAND NEW 2018 EXPLORER. IN NOVEMBER 2019 MY SECURITY SYSTEM STARTED GOING OFF ON IT'S OWN WITHOUT ANY DISTURBANCE TO THE VEHICLE OR ME TOUCHING MY KEYS. THE NEXT DAY THE BATTERY WAS DEAD AND THE FORD SERVICE CENTER TOLD ME MY BATTERY WAS DEAD DUE TO A COLD SNAP (WE ARE IN SC...IT DOES NOT GET THAT COLD). I HAD TO GET A BRAND NEW BATTERY. NOW LESS THAN A YEAR LATER, IT'S AUGUST 2020 AND THE KEY PAD ON THE DRIVER'S SIDE EXTERIOR DOOR IS MALFUNCTIONING AND BLINKING UNCONTROLLABLY UNTIL IT FINALLY DIED AND DOES NOT WORK. THE CAR IS STILL FUNCTIONING FINE UP UNTIL THIS POINT. NOW 3 WEEKS LATER, MY CAR DID NOT START THIS MORNING AND I HAD TO BE JUMPED OFF. I TOOK IT TO THE FORD DEALERSHIP AND THEY SAID SOMETHING IS DRAINING MY BATTERY AND IT IS NOT HOLDING A CHARGE. THERE'S NO REASON WHY A 2018 EXPLORER SHOULD NEED TWO NEW BATTERIES IN 2 YEARS. SOMETHING IS DRAINING MY BATTERY AND NO ONE CAN TELL ME WHAT THAT ISSUE IS.

HAD CAR SERVICED ON 06/13/20 BATTERY 100% DOCUMENTED. ON 07/09/20 WHILE DRIVING THE VEHICLE A QUARTER OF MILE FROM MY HOUSE WHEN THE BATTERY EXPLODED. THERE WAS A STRONG SULFUR(ROTTEN EGG) SMELL THAT FILLED THE WHOLE CAR AND WAS HARD TO BREATHE. STOPPED THE CAR AND OPENED THE HOOD AND CONFIRMED THAT THE BATTERY HAD EXPLODED SPRAYING ACID ALL OVER THE ENTIRE ENGINE COMPARTMENT, DOWN UNDER THE WHOLE CAR AND COVERING THE TAILGATE AND TIRES AS WELL SINCE THE CAR WAS IN MOTION WHEN IT HAPPENED. FORD WANTS TO TAKE NO RESPONSIBILITY FOR THE BATTERY DEFECT THEY ARE CALLING IT. I'VE HAD TO OPEN A COMPREHENSIVE CLAIM THROUGH CAR INSURANCE TO COVER ALL THE BODY DAMAGES AND MECHANICAL DAMAGES FROM THE ACID. THE CAR ONLY HAD 43,000 MILES WHEN IT HAPPENED WITH A 2 YEAR OLD FORD MANUFACTURED BATTERY THAT WAS JUST SERVICED AS NOTED IN THE BEGINNING BEING AT 100%. THERE WAS NEVER A INDICATOR LIGHT FROM THE BATTERY OR ENGINE CLAIMING THAT SOMETHING WAS HAPPENING OR DID HAPPEN. MY HEALTH REPORT ON MY CAR STILL SAID NOTHING WAS WRONG EVEN THOUGH MY BATTERY HAD EXPLODED.

WHEN ACCELERATING WE CAN SMELL EXHAUST IN THE CABIN OF OUR VEHICLE. THIS HAS BEEN AN ONGOING ISSUE FOR MORE THAN A YEAR. WE HAVE TO ROLL THE WINDOWS DOWN TO GET AIR. ON TRIPS FROM PHOENIX TO SAN DIEGO THRU THE MOUNTAIN PASSES WE HAVE GOTTON DIZZY FROM EXHAUST SMELL. I HAVE TAKEN IT TO THE DEALER 4+ TIMES TO COMPLAIN ABOUT THIS ISSUE, DEALER HAS SAID ITS A KNOWN ISSUE WITH NO FIX. YOU CAN SMELL THE HUMIDITY OF THE EXHAUST AS WELL AS THE BURNT OIL. EVERY TIME I GET IN MY VEHICLE WITH FRIENDS, I'M EMBARRASSED OF SMELLING EXHAUST AND HOPE IT DOESN'T AFFECT HEALTH OF ANYONE. WE CAN SEE THE EXHAUST SOOT BUILDING UP ALONG THE ENGINE BLOCK AND EXHAUST MANIFOLD BUT THE DEALER TOLD US THATS NORMAL ROAD GRIME.

TL* THE CONTACT OWNS A 2018 FORD EXPLORER. THE CONTACT STATED THAT WHILE MERGING INTO TRAFFIC ON THE FREEWAY AT VARIOUS SPEEDS, THE VEHICLE INDEPENDENTLY SHIFTED INTO LIMP MODE WITHOUT WARNING. THE CONTACT TOOK THE VEHICLE TO AUTONATION FORD EAST (28825 EUCLID AVE, WICKLIFFE, OH 44092) WHERE THE MECHANIC WAS UNABLE TO DUPLICATE THE FAILURE. THE MECHANIC ATTRIBUTED THE FAILURE TO A POTENTIAL TURBO LAG. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. CONSUMER STATED INDICATOR FAULT LIGHTS ON THE DASH FAILED THREE TIMES.*JB

HANKOOK VENTUS S1 NOBLE 2 (255/50R20 105H) TIRES HAVE EXCESSIVE TREADWEAR (LESS THAN 2/32 MINIMUM) AND CUTS IN TREAD. HANKOOK TIRES HAVE 28K MILES, ARE ORIGINAL TO 2018 EXPLORER PURCHASED NEW. VEHICLE AND TIRES ARE SERVICED AND MAINTAINED VIA PREMIUM MAINTENANCE PLAN. VEHICLE IS ALIGNED. LOW TREAD AND CUTS ARE PREVENTING DEALERS/OTHERS FROM FIXING FLAT CAUSED BY NAIL PUNCTURE. AT LEAST 2 TIRES HAVE EXCESSIVE WEAR AND CUTS.

HANKOOK VENTUS S1 NOBLE 2 (255/50R20 105H) TIRES HAVE EXCESSIVE TREADWEAR (LESS THAN 2/32' MINIMUM) AND CUTS. HANKOOK TIRES HAVE 28K MILES, ARE ORIGINAL TO 2018 EXPLORER PURCHASED NEW. VEHICLE AND TIRES ARE SERVICED AND MAINTAINED VIA PREMIUM MAINTENANCE PLAN. VEHICLE IS ALIGNED. LOW TREAD AND CUTS ARE PREVENTING DEALERS/OTHERS FROM FIXING FLAT CAUSED BY NAIL PUNCTURE.

THE GAS DOOR DOES NOT SEAL AND PROPS OPEN ALL TIME, THE VEHICLE COMES WITH NO FUEL CAP AND DOOR DOES NOT LOCK ALLOWING ANYONE TO PUT CONTAINMENTS IN THE FUEL

TL* THE CONTACT OWNS A 2018 FORD EXPLORER EQUIPPED HANKOOK TIRES, TIRE LINE: VENTUS S1 NOBLE2, TIRE SIZE: 255/50/R20, DOT NUMBER: 5117. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN FOR ROUTINE SERVICE AT KOEPPEL FORD (57-15 NORTHERN BLVD, QUEENS, NY 11377), AND THE CONTACT WAS INFORMED THAT ALL FOUR TIRES NEEDED TO BE REPLACED DUE TO ACCELERATED TREAD SEPARATION. THE CONTACT MENTION THAT WHILE DRIVING AT AN UNDISCLOSED SPEED, THE VEHICLE HYDROPLANED DUE TO THE TIRES. THE TIRES WERE NOT REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE TIRES WOULD BE PRORATED TO DEFRAY SOME OF THE COST FOR THE TIRE REPLACEMENT. THE CONTACT WAS REFERRED TO THE DEALER FOR ASSISTANCE. THE FAILURE MILEAGE OF THE VEHICLE AND TIRES WERE APPROXIMATELY 24,459. *LN *TR

I HAVE A FORD EXPLORER LIMITED 2018 WITH ROTTEN EGG AND SULFUR SMELL WHEN REMOTE START AT IDLE AND HARD ACCELERATION. I TOOK THE VEHICLE FOR THE 3RD TIME AND GOT IT BACK AFTER 14 DAYS. I WAS HOPING THEY WOULD REPLACE THE CATALYTIC CONVERTER BUT THEY DECLINED IT. THE REPORT STATED THERE WERE NO CAT CONVERTER CODE AND THAT BY DESIGN THE FORD EXPLORER'S CATALYTIC CONVERTER HAS NORMAL SULFUR AND ROTTEN EGG SMELL. THIS WAS TAKEN FROM THE VEHICLE REPORT " SOME SULFUR OR ROTTEN EGG TYPE SMELLS FROM THE EXHAUST ARE NORMAL BECAUSE OF THE CATALYTIC CONVERTER DESIGN. PLEASE CONFIRM THE SOURCE OF THIS STENCH BECAUSE AFTER HARD ACCELERATION AND OR REMOTE STARTS THE EXHAUST FUMES COULD SMELL LIKE SULFUR AND IT'S NORMAL" . HOW CAN I CLAIM THE 8YRS/80,000 MILES CATALYTIC CONVERTER WHEN THEY CALL SULFUR AND ROTTEN EGG NORMAL? WILL I JUST EXPOSE MY FAMILY TO CANCER CAUSING FUMES? IF I TRADE THIS VEHICLE I WILL BE $5000 NEGATIVE AND THE PERSON WHO WILL BUY THIS VEHICLE WILL HAVE THE SAME ISSUES. I CAN PROVIDE A COPY OF THE SERVICE REPORT IF NEEDED. *TR

EXHAUST FUME INSIDE THE CABIN. BROUGHT IT TO 2 FORD DEALERSHIP AND THEY BOTH SAID THEY COULD NOT DUPLICATE THE ISSUE. FORD GAVE ME EXTENDED SERVICE WARRANTY MAYBE TO KEEP ME CALM. BUT I GOT THE SUV IN JAN 2, 2019 AND UP UNTIL NOW I STILL SMELL THE FUME INSIDE THE CABIN. I HAVE 2 KIDS AND THEY HAVE BEEN INHALING TOXIC FUMES EVERY TIME I TAKE THEM INSIDE THE EXPLORER. ESPECIALLY WHEN YOU ACCELERATE HARD. *TR

VEHICLE CAME WITH HANKOOK VENTUS S1 NOBLE 2, 255/50R20 TIRES. WE ONLY HAVE 15K MILES ON THE VEHICLE AND THE TIRES ALREADY NEED TO BE REPLACED. WE HAD THEM ROTATED AT THE DEALERSHIP AT THE SCHEDULED OIL CHANGE INTERVAL. ONE OF THE TIRES DEVELOPED A SLOW LEAK AND REQUIRED RE INFLATION EACH WEEK. ONE REAR TIRES LOST ALL AIR PRESSURE WHILE WE WERE DRIVING ON THE STREET. THERE WAS NO NAIL OR HOLE FOUND IT IT. THE TIRES ARE SHREDDING TREAD AS WELL. ALL 4 NEED TO BE REPLACED BUT NEITHER FORD OR HANKOOK HAVE ANSWERED OUR COMPLAINT. THESE TIRES NEED TO BE RECALLED BECAUSE THEY ARE DANGEROUS.

2018 FORD EXPLORER HAS A ROOF RAIL ISSUE WHERE THE TOP PART THE THE ROOF RAIL THAT COMES FACTORY ON THE VEHICLE WILL POP OUT OF PLACE AND NOT CLAMP DOWN PROPERLY THE FOR PART NUMBER IS FB5Z 78551A47 AA AND ALSO FB5Z 78551A46 AA ONE BELONGS TO THE LEFT AND THE OTHER THE RIGHT. I WAS DRIVING DOWN THE HIGH WAY WITH THEM NOT FULLY SEATED IN THE BACK END OF THE RAILING AND NOTICED WHEN I GOT HOME THAT THEY MUST HAVE FLOWN OFF WHILE DRIVING DOWN THE HIGHWAY. THIS IS THE SECOND SIME I HAVE HAD THEM FIXED AND THEY ARE NOW NOT STAYING DOWN PROPERLY SEATED. LUCKLY MY VEHICLE HAS WARRANTY ON IT STILL TO GET IT FIXED BUT IF THIS IS GOING TO HAPPEN OUTSIDE OF WARRANTY ITS NOT A CHEAP FIX UNFORTUNATLY.

WENT FOR A INSPECTION STICKER ON MY 2018 EXPLORER AND WAS TOLD I NEEDED TIRES. I SAID THAT WAS IMPOSSIBLE SINCE I ONLY HAD 25000 MILES ON THEM. THEY SHOWED ME THE WEAR AND I COULD NOT BELIEVE IT. THE TIRES ARE HANKOOK VENTUS S NOBLE 2. THESE TIRES ARE A MAJOR SAFETY ISSUE AND UPON RESEARCH HERE THIS IS A COMMON PROBLEM WITH THEM. DO NOTBUY THESE TIRES

THE TOP CAP ON THE DRIVERS SIDE (WHERE THE LUGGAGE RACK IS) CAME COMPLETELY OFF WHILE DRIVING ON THE HIGHWAY. THE PASSENGER SIDE ONE KEEP COMING LOOSE. THIS IS A SAFETY HAZARD, AS THE PIECE THAT FLEW OFF COULD HAVE INJURED SOMEONE OR WORSE. THIS IS NOT A SAFE PIECE ON THE SUV AND NEEDS TO BE ADDRESSED, AS MANY, MANY PEOPLE HAVE COMPLAINED ABOUT THIS ISSUE.

ELECTRIC SHORTAGES, SMELL BURNING WIRES, STALLS VEHICLE WAS REPURCHASED BY FORD AND I WANT TO MAKE SURE ITS REPORTED AS A LEMON AND NOT RESOLD FOR SAFETY OF OTHERS

FOR WEEKS NOW THE CAR HAS BEEN DECIDING WHAT TO DO. THE AIR CONDITIONER RANDOMLY TURNS OFF OR WON'T TURN ON. THE WINDOW WON'T ROLL UP OR DOWN. LIGHTS IN THE DASHBOARD RANDOMLY GO ON AND OFF ALL THE TIME. SOMETIMES THERE IS JUST A LOUD NOISE BUT NO LIGHTS. THEN RECENTLY WHEN I WAS DRIVING ON THE HIGHWAY GOING 55 MPH WITH MY 3 CHILDREN THE CAR SHUT ITS SELF OFF. THE LIGHTS WENT CRAZY THEN SHUT OFF. THERE WAS NO GAS OR BRAKES AS I WAS GOING 55 MPH. ONCE THE CAR CAME TO A ROLLING STOP. IT DID NOT TURN BACK ON. ONCE TOWED TO THE DEALERSHIP, THEY CANNOT FIND ANYTHING WRONG.

TL* THE CONTACT OWNS A 2018 FORD EXPLORER. THE CONTACT STATED WHILE DRIVING AT APPROXIMATELY 40 MPH, THE TRANSMISSION SHIFTED INTO GEAR IMPROPERLY. ON ONE OCCASION THE VEHICLE INDEPENDENTLY SHIFTED FROM PARK TO REVERSE INDEPENDENTLY. THE VEHICLE WAS TAKEN TO AIRPORT MARINA FORD LOCATED AT 5880 W CENTINELA AVE, LOS ANGELES, CA 90045 (310-574-2641) WHERE THE VEHICLE WAS REPAIRED. THE CONTACT ALSO HEARD AN ABNORMAL NOISE WITH THE BRAKE PEDAL DEPRESSED AND HAD THE VEHICLE INSPECTED. AIRPORT MARINA FORD ALSO INSPECTED THE BRAKES AND INFORMED THE CONTACT THAT NO DEFECTS WERE FOUND WITH THE BRAKES OR BRAKING SYSTEM. THE APPROXIMATE FAILURE MILEAGE WAS 28.

WHEN CLIMBING HILLS AND ENGINE AT HIGH RPM I CAN SMELL EXHAUST IN THE CABIN PORTION OF MY VEHICLE. I INITIALLY THOUGHT IT WAS THE VEHICLE IN FRONT OF ME, BUT IT HAPPENED AGAIN A FEW DAYS LATER WHEN I WAS TRAVELING THROUGH THE HILLS AGAIN. SAME CIRCUMSTANCES, CLIMBING HILLS AT A HIGH RPM. SPEED WAS APPROXIMATELY 65 MPH. THE SMELL WAS EXACTLY THE SAME AS IF I WAS WALKING BEHIND THE CAR IN THE MORNING AFTER STARING THE ENGINE.

REACHING UNDER DRIVER SEAT AND CONTACTED SEAT FRAME SHARP AND CUT FINGER.