2016 Ford Explorer complaints

WHILE DRIVING MY 2016 FORD EXPLORER, THE POWER STEERING BECAME LOOSE AND MAKING A GRINDING NOISE IN THE FRONT END. THE VEHICLE WAS TAKEN TO A LOCAL FORD DEALERSHIP AND WAS DIAGNOSED WITH A STEERING RACK ISSUE. NEEDS TO BE REPLACED. FORD MOTOR CO WILL NOT PAY FOR THE REPAIR. THIS IS CLEARLY A SAFETY ISSUE. MORE IMPORTANTLY, WHILE MY VEHICLE WAS BEING DIAGNOSED, TWO ADDITIONAL FORD EXPLORERS WERE BROUGHT TO THE SAME DEALERSHIP FOR THE SAME PROBLEM. FORD NEEDS TO RECALL THESE VEHICLES AND MAKE THESE SAFETY REPAIRS. PRIOR TO BRINGING THE VEHICLE TO FORD FOR DIAGNOSTICS I TOOK A VIDEO OF THE DAMAGE AND THE GRINDING SOUNDS IN THE FRONT END.

ABOUT TWO MONTHS AGO MY CAR STARTED SHUTTERING AND WAS VERY JUMPY. I TOOK IT INTO THE DEALERSHIP AND THEY HAD TO REBUILD THE ENTIRE TRANSMISSION. TWO WEEKS AFTER THAT, WHILE DRIVING ON THE HIGHWAY, MY A/C STOPING BLOWING OUT COLD AIR AND WAS ONLY BLOWING OUT HOT AIR. TOOK IT BACK TO THE DEALERSHIP AND THE SAID THE AIR COMPRESSOR SEIZED, AND THEY HADD TO REPLACE THAT ALONG WITH ALL THE LINES THAT GOES TO IT. TWO WEEKS AFTER THAT,, I STARTED TO NOTICE MY CAR WOULD SHUDDER WHEN IN REVERSE. TOOK IT INTO THE DEALERSHIP, AND THEY TOLD ME 'INTERNAL ENGINE FAILURE'. WHEN I READ THE DIAGNOSTIC REPORT (BECAUSE THE SERVICE REP WOULDN'T EXPLAIN IT TO ME)...IT STATED THAT THERE WAS COOLANT FOUND IN ONE OF THE CYLINDERS IN THE ENGINE....MEANING MY COOLANT WAS LEAKING INTO THE ENGINE. IF I CONTINUE TO DRIVE IT, MY VEHICLE WILL OVERHEAT.

THE FACTORY BATTERY RUPTURED AND SPEWED BATTERY ACID IN ENGINE COMPARTMENT.

MY HUSBAND WAS DRIVING DOWN THE ROAD WHEN A BUNCH OF ERRORS STARTED POPPING UP INCLUDING STEERING ASSIST FAULT, SERVICE ADVANCE TRACK, SERVICE HILL DESCENT, ETC. THE STEERING ON MY CAR IMMEDIATELY LOCKED UP AND HE COULD BARELY GET THE CAR TURNED OFF THE ROAD BEFORE IT SHUT DOWN. IT ALMOST CAUSED AN ACCIDENT AS WE WERE NEARLY REAR-ENDED. I TRAVEL THE INTERSTATE DAILY AND HAD THIS HAPPENED ON THE INTERSTATE INSTEAD OF A CITY STREET IT COULD HAVE RESULTED IN A DEADLY ACCIDENT. I USE THIS CAR TO TRANSPORT MY INFANT AROUND AND IT IS NOT SAFE AT ALL. AN ERROR LIKE THIS COULD KILL MY WHOLE FAMILY.

MY STEERING STARTING MAKING NOISE AND HESITATING WHEN TURNING DURING CITY TYPE DRIVING. THE NEXT DAY DRIVING BECAME MORE DIFFICULT STEERING ESPECIALLY AT HIGHER SPEEDS ON THE HIGHWAY. I WAS UNABLE TO KEEP THE VEHICLE STRAIGHT CONTINUALLY GOING BACK AND FORTH IN MY LANE. THE FOLLOWING DAY THE WHEEL WOULD NOT TURN AT ALL AND ALL SORTS OF ERROR DISPLAY MESSAGES STARTED. SAYING STEERING FAILURE, STOP AS SOON POSSIBLE, TRACTION CONTROL FAILURE AND MORE. MY EXPLORER IS ONLY 3YEARS OLD WITH LESS THAN 80,000 MILES. IF THIS FAILURE HAPPENED WHILE I WAS DRIVING IT COULD HAVE CAUSED SERIOUS INJURY OR DEATH. FORD IS UNWILLING TO DO ANYTHING TO ADDRESS THIS ISSUE. ONLY THING I COULD GET THEM TO TELL ME IS THAT IT WAS BEING LOOKED IN TO. ONLINE MESSAGE BOARDS SHOW THIS IS A VERY COMMON IN THE 2016 EXPLORERS AND EVEN REOCCURS SOMETIMES AFTER BEING 'FIXED'. SEEMS FORD DOESN'T HAVE A HANDLE ON THE ISSUE AND THIS NEEDS TO BE ADDRESSED ASAP. SEARCHING ONLINE ALSO SHOWS SEVERAL LAWSUITS IN REGARDS TO THIS ISSUE. I'M UNSURE WHY THIS IS NOT BEING ADDRESSED WHEN IT'S CLEARLY A MAJOR, MAJOR SAFETY CONCERN.

MY VEHICLE HAS 48,950 MILES AND WAS TOLD THAT THE LOUD CLUNKING SOUND MY VEHICLE MAKES WHILE TURNING THE STEERING WHEEL IN EITHER DIRECTION, IS DUE TO THE STEERING GEAR AND HARDWARE THAT NEEDS TO BE REPLACED. I HAVE SEEN MANY ONLINE COMPLAINTS ABOUT STEERING ISSUE WITH THIS MAKE, MODEL AND YEAR. IT IS CONCERNING TO ME THAT THIS MAY AFFECT THE SAFETY OF MY FAMILY. SUCH AN EXPENSIVE VEHICLE AND TO BE TOLD THAT THIS REPAIR WILL COST OVER $2000 IS UNACCEPTABLE. THIS IS POOR MANUFACTURING AND NOT A NORMAL WEAR AND TEAR ITEM, AND CERTAINLY NOT AT 49,000 MILES.

I WAS PARKED, WHEN A LOUD SOUND CAME FROM THE MOTOR AREA OF MY 2016 FORD EXPLORER. THE SERVICE ADVANCE TRACK AND THE STEERING FAILURE LIGHT CAME ON ABOUT. I BROUGHT THE CAR TO DEALER AND THEY SAID THAT THE RACK AND PINION IS LEAKING, EVAN THAT ONLY HAD 32, 000 MILES IS NOT COVERED BY WARRANTY BECAUSE EXPIRES A FEW MONTHS AGO, AND IS GOING TO COST $2,230.00 FOR THE PARTS AND LABOR. THE DAY BEFORE I WAS WITH ALL MY FAMILY HAVING FUN AND DRIVING AROUND, I'M THINKING IF THIS PART BREAKS WHILE WE WAS AT INTERSTATE 70, THAT THE SPEED LIMITS IS 70MPH, AND YOU LOSE CONTROL OF THE VEHICLE, IT WILL BE A REALLY BAD OR FATAL ACCIDENT. THERE BEING A LOT OF REPORTS WITH THIS ISSUE. WHAT FORD AND THE NHTSA ARE WAITING TO TAKE ACCION, THAT MORE INCIDENT OCURRED OR PEOPLE DIED TO DO A RECALL. LIKE THEY ARE DOING WITH THE AIR BAGS AFTER A MANY PEOPLE DIED. PLEASE TAKE ACTION TODAY, DON'T WAIT UNTIL IS TO LATE.

MY 2016 FORD EXPLORER JUST TURNED 36,000 MILES AND ALL FOUR OF THE HANKOOK VENTUS S1 NOBLE 2 TIRES THAT CAME ON CAR HAVE PREMATURE WEAR, WITH 3/32ND OF AN INCH REMAINING ON THE TREAD. THERE HAVE BEEN NUMEROUS COMPLAINTS ABOUT PREMATURE TREAD WEAR WITH THIS TIRE AND FORD WILL NOT DO ANYTHING ABOUT IT. I WAS TOLD BY FORD MOTOR CUSTOMER SERVICE THAT BECAUSE MY CAR HAS TURNED 36,00 MILES THERE IS NO WARRANTY COVERAGE OR OTHER RECOURSE THAT I CAN TAKE. THIS IS A SAFETY ISSUE. THE SERVICE MANAGER AT MY LOCAL FORD DEALER, CHATHAM FORD, WHERE I PURCHASED THE VEHICLE ALSO TOLD ME THAT THIS PARTICULAR TIRE SHOULD NOT BE USED ON AN EXPLORER. YET MY DEALER ALSO SAID THAT THEY CANNOT DO ANYTHING TO HELP ME. THERE APPEARS TO BE A DEFECT WITH THIS TIRE AND THERE SHOULD BE A RECALL.

WE EXPERIENCED POPPING NOISES ON THE FRONT END WHILE TURNING AT INTERSECTIONS, PULLING IN AND OUT OF DRIVEWAY AND PARKING SPOTS. DUE TO HAVING TO REPLACE WORN TIRES AT 32K, WE TOOK TO LOCAL QUICK LANE AT OUR ST JOSEPH FORD DEALERSHIP. WE REPORTED THE POPPING NOISES AT THIS TIME AND REQUESTED IT BE LOOKED AT WHILE THEY REPLACED TIRES. THERE WERE NO FINDS AT THIS TIME REGARDING WHAT WAS MAKING THE NOISES. WE CONTINUED TO EXPERIENCE OCCASIONAL POPPING NOISES WHILE TURNING AT INTERSECTIONS, PULLING IN/OUT OF DRIVEWAY AND PARKING SPOTS. ON 8/8/19, WE TOOK TO SAME DEALERSHIP SERVICE DEPARTMENT TO PERFORM FSA19S17, A RECALL WHERE THE REAR SUSPENSION TOE LINK WAS REPLACED AT 38205MI. A 4-WHEEL ALIGNMENT WAS ALSO DONE AT THIS TIME. ON 8/23/19, WE NOTICED THE POPPING HAD GOTTEN WORSE. ON 8/26/19, THE STEERING BRIEFLY SEIZED ROUNDING A CORNER AT APPROXIMATELY 30-35MPH. IT SCARED MY WIFE, AS SHE FELT A BRIEF LOSS OF CONTROL OF THE VEHICLE. ON 8/28/19 WE DROPPED IT OFF AT THE SAME DEALERSHIP AND REPORTED THAT POPPING WAS WORSE AND THE STEERING HAD SEIZED. AFTER THE TEST DRIVES AND ASSESSMENT THEY CALLED TO REPORT THAT THE STEERING RACK WAS FAILING AND WOULD NEED REPLACED. THEY QUOTED $2900.00 FOR REPAIRS. WE HAVE NOT AGREED TO PAY FOR THIS REPAIR. WE HAVE SINCE DISCOVERED THIS IS A WELL KNOWN ISSUE BY FORD AND OTHER VEHICLE OWNERS OF THE SAME MAKE AND MODEL. WE ARE REPORTING IN HOPES THAT FORD WILL RECALL TO RECTIFY THIS SERIOUS SAFETY ISSUE.

MY STEERING PROBLEM STARTED WHILE DRIVING, WHICH BEGAN WITH A POPPING NOISE WHEN BACKING UP AND THEN A GRINDING NOISE WHILE TURNING LEFT OR RIGHT WHEN DRIVING FORWARD. THE PROBLEM QUICKLY PROGRESSED AND THE VEHICLE BECAME DIFFICULT TO TURN LEFT OR RIGHT WHEN I WAS DRIVING IN TRAFFIC AT AROUND 30 MPH. I HAD TO MUSCLE THE STEERING WHEEL TO TURN THE VEHICLE AND MANAGED TO DRIVE TO THE NEAREST GARAGE. THIS SAME GARAGE WAS VERY AWARE OF THIS PROBLEM WITH THE FORD EXPLORER AND REPAIRED MY VEHICLE AT A COST OF $2417.74. FROM THE TIME THE STEERING PROBLEM BEGAN TO THE TIME THE VEHICLE COULD NOT BE DRIVEN WAS LESS THAN FOUR HOURS. THIS PROBLEM IS VERY DANGEROUS AND THERE SHOULD BE A RECALL FOR IT ASAP!!.

AT APPROX 65K MILES I NOTICED THE STEERING WHEEL BECOMING STIFF AND A NOISE OF PLASTIC RUBBING IN THE STEERING COLUMN. TODAY AT 67K MILES I TOOK VEHICLE INTO FORD DEALER FOR ANOTHER RECALL TO BE TOLD THE RACK IS BAD. SEEING AS THIS IS SUCH AN ABUNDANT ISSUE WITH THESE VEHICLES, I'M TRYING TO UNDERSTAND HOW THIS ISN'T A SAFETY RECALL. IF THIS PART FAILS WHILE DRIVING IT COULD LEAD TO A CATASTROPHIC CRASH. HONESTLY I'M AFRAID TO HAVE THE DEALER REPLACE IT WITH AN IDENTICAL PART SINCE THERE IS OBVIOUSLY AN ISSUE WITH THE PART IS IT IS CURRENTLY BEING PRODUCED.

I HAVE A 2016 EXPLORER WHICH HAS 2ND ROW AIRBAG SEATBELTS. WHEN PURCHASING MY CAR IT WAS EXPLAINED TO ME THAT REAR AIRBAG SEATBELTS WERE THE BEST SAFETY FEATURE FOR CHILDREN. I DID NOT HAVE CHILDREN AT THE TIME. I NOW HAVE A 2 YEAR OLD WHOM WILL BE EXCEEDING THE LATCH WEIGHT LIMIT SHORTLY. UPON ATTEMPTING TO INSTALL HIS CAR SEAT REAR FACING, IT BECAME APPARENT I AM UNABLE TO RUN AN AIRBAG SEAT BELT THROUGH MY CHILDS CAR SEAT. IT IS A EXTREME SAFETY HAZARD. I REQUESTED MY SEAT BELTS BE CHANGED OUT FOR REGULAR SEAT BELTS AND I WAS TOLD THIS COULD NOT BE DONE AS IT WOULD DEACTIVATE MY CARS AIRBAGS SYSTEM. PLEASE HELP ME FIND A SOLUTION AS I CANNOT PUT HIM IN THE CENTER SEAT. HIS CAR SEAT DOES NOT FIT BEING THE CENTER SEAT OF THE EXPLORER IS NOT A FULL-SIZED SEAT. I HAVE SPOKEN WITH FORD CORPORATE OFFICE, THE DEALERSHIP (OC WELCH FORD IN HARDEEVILLE, SC) AND HAVE GOTTEN LITTLE TO NO ASSISTANCE OTHER THAN THERE IS NOTHING THEY CAN DO BUT ASSIST ME IN FINDING A NEW CAR TO PURCHASE. THAT IS THE LAST THING I WANT TO DO. I AM AT A LOSS AND ONLY WANT WHAT IS BEST FOR MY CHILD. I CANNOT RISK HIM BEING INJURED. WHO CAN I CONTACT TO GET THIS RESOLVED? PLEASE ADVISE URGENTLY.

DRIVING AND LOST FULL POWER STEERING CONTROL OF VEHICLE. FORD HAD TO REPLACE POWER STEERING WITH ONLY 47,900 MILES ON VEHICLE.

EXPLORER SPORT 57800 MILES VEHICLE IS EXPERIENCING POPPING NOISES WHEN TURNING THE STEERING WHEEL LEFT OR RIGHT ALSO HAPPENS WHILE BRAKING THE POPPING IS SIGNIFICANT ENOUGH TO FEEL IN THE STEERING WHEEL AS WELL AS IN THE FLOOR BOARDS ON BOTH FRONT PASSENGER AND DRIVER. THE STEERING WHEEL HAS EXHIBITED EXTREME VIBRATION ENOUGH TO MAKE THE OUTSIDE DRIVER REVIEW MIRROR SHAKE. THE STEERING WHEEL HAS ALSO BEEN STUCK IN THE LEFT TURNING POSITION TWICE WHILE TRYING TO STRAIGHTEN WHEELS BACK OUT. DEALER WANTS $2,500 TO REPAIR IT. THEY ALSO CHARGE ME $140 TO TELL ME IT NEEDED TO BE FIXED.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE DRIVING 65 MPH, THE TRACTION CONTROL INDICATOR ILLUMINATED AND THE STEERING SEIZED. THE CONTACT PULLED THE VEHICLE OVER AND ATTEMPTED TO TURN OFF AND RESTART THE VEHICLE, BUT THE STEERING WAS LOCKED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DISCOVERED THAT THE ENTIRE FRONT RACK AND PINION SYSTEM NEEDED TO BE REPLACED. THE TOTAL COST, INCLUDING TOWING, WAS $2,300. FORD OF HIBBING (2627 E BELTLINE, HIBBING, MN 55746, (218) 262-3881) STATED THERE WERE NO RECALLS AND THE WARRANTY RECENTLY EXPIRED; THEREFORE, THEY WOULD NOT ASSIST WITH THE REPAIR COST. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 31,060.

STANDARD DRIVING DRUG WITH NO CRASHES. AIRBAG LIGHT BEGAN COMING ON INTERMITTENTLY WHILE DRIVING IN EARLY TO MID OCTOBER OF 2018 (AROUND 45,000 MILES). AFTER A FULL WEEK OF THE LIGHT STAYING ON VEHICLE WAS TAKEN TO DEALERSHIP. THE HARNESS CONNECTOR WAS LOOSE. FIVE TO SEVEN DAYS AFTER REPAIR THE LIGHT BEGAN COMING ON INTERMITTENTLY AGAIN. A SECOND DEALERSHIP SAID THE GARDENS CONNECTOR WAS LOOSE. TWO TO THE WEEKS LATER THE LIGHT CAME ON AND PERSISTED. I WAS TOLD IN LATE MAY THAT IT WAS THE WIRING HARNESS BEFORE THE FRONT PASSENGER SEAT. AFTER SOME ISSUES WITH THE DEALERSHIP, IT WAS TAKEN TO THE DEALERSHIP THAT ORIGINALLY FIXED IT IN OCTOBER 2018. THIS TIME BOTH THE PASSENGER WIRING HARNESS AND AIRBAG WERE REPLACED. OVER $800 AND 3.5 HOUR APPOINTMENT FOR THE ACTUAL FIX. PICTURES FROM INITIAL SERVICE ARE ATTACHED.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT THE AIR BAG INDICATOR ILLUMINATED WITHOUT WARNING. THE CONTACT STATED THAT THE AIR BAG HARNESS NEEDED TO BE REPLACED. THE CONTACT CALLED MIDWAY FORD (2777 N SNELLING AVE, ROSEVILLE, MN 55113-1796, 651-638-4800) AND WAS INFORMED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT CALLED THREE OTHER UNKNOWN FORD DEALERS AND WAS INFORMED THE SAME THING. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 78,000.

AT 40,906 MILES THE STEERING TOTALLY FAILED. I WAS DRIVING HOME FROM WORK AND LOST ALL STEERING CAPABILITY, THE WHEEL EFFECTIVELY LOCKED UP. TOWED TO DEALER. A STEERING MODULE INSIDE THE GEARBOX FAILED. FROM WHAT I HAVE READ, THIS IS A COMMON ISSUE WITH THE EPDS SYSTEM. THE ENTIRE GEAR ASSEMBLY WAS REPLACED FOR A TOTAL OF $2,234.22 WITH LABOR. AFTER OVER A DOZEN DIFFERENT CALLS TO FOMOCO CUSTOMER SERVICE, THEY AGREED TO COMPENSATE ME A TOTAL OF $525.00 THIS IS AN EXTREMELY DANGEROUS ISSUE AND I AM CONCERNED IT WILL HAPPEN AGAIN.

WHILE TAKING A 250 MILE TRIP UP THE COAST OF CALIFORNIA, WE STOPPED FOR GAS. WHEN THE 2016 FORD EXPLORER WAS TURNED BACK ON, A "STEERING ASSIST FAULT" ERROR MESSAGE APPEARED ON THE DASHBOARD AND I REALIZED I NO LONGER HAD POWER STEERING. THE POWER STEERING NEVER RETURNED AFTER THAT. I HAD TO DRIVE THE VEHICLE 250 MILES BACK HOME WITH NO POWER STEERING. I TOOK IT TO THE LOCAL FORD DEALER, AND I WAS TOLD THE REPAIRS WOULD NOT BE COVERED UNDER ANY WARRANTY SINCE MY VEHICLE NOW HAS JUST OVER 50,000 MILES ON IT. I AM WAITING FOR THE ESTIMATE ON THE REPAIRS.

I WAS DRIVING 55MPH ON THE HIGHWAY WHEN MY POWER STEERING STOPPED WORKING. IT WAS VERY HARD TO DRIVE AND CONTROL THE CAR. I COULD OF EASILY CRASHED AND KILL MYSELF OR SOMEONE ELSE. I HAD JUST PURCHASED THIS CAR LESS THEN A WEEK BEFORE AND I TOOK IT TO THE FORD DEALERSHIP I BOUGHT IT FROM. THEY SAID THEY COULD NOT COVER IT AND I HAVE TO PAY OVER $2000 TO GET IT FIXED.

I WAS DRIVING DOWN THE HIGHWAY AND ALL OF A SUDDEN ALL THE WARNING LIGHTS FOR THE POWER STEERING STARTING FLASHING ON MY DASH AND MY STEERING LOCKED UP. I ALMOST HAD AN ACCIDENT GOING DOWN THE ROAD. THE GARAGE I HAVE TAKEN IT TO HAVE TOLD ME THAT THE POWER STEERING CONTROL MODULE AND THE RACK AND PINION ARE WHAT NEEDS REPLACING AND IT'S $1950.00. I'VE READ HUNDREDS OF OTHER PEOPLE'S STORIES ABOUT THIS EXACT SAME THING HAPPENING TO THEM AND COSTING THEM ANYWHERE FROM $2-$4000 TO FIX. AND IT'S ALWAYS HAPPENING WHEN THE VEHICLES ARE AROUND 20-40,000 MILES AND IT'S ALWAYS BEEN FORD EXPLORERS 2016-2018 MODELS. MY EXPLORER IS AT 102,000 MILES. THERE NEEDS TO BE A RECALL ON THESE PARTS ASAP BEFORE SOMEONE DIES FROM THIS HAPPENING!

STEERING STARTED MAKING A POPPING NOISE WHEN TURNING THE WHEEL TO THE RIGHT. COULD NOT FEEL ANYTHING IN THE STEERING WHEEL WHEN IT HAPPENED. POPPING CHANGED FROM A SINGLE POP WHEN TURNING RIGHT TO MULTIPLE POPS. TOOK TO FORD DEALER. FORD SAID NOT TO DRIVE AS THE STEERING COULD LOCK UP CAUSING AN ACCIDENT. FORD REPLACED THE STEERING GEAR AND SAID THIS WAS A KNOWN AND FREQUENTLY OCCURRING PROBLEM.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT RECEIVED A CUSTOMER SATISFACTION PROGRAM NOTICE (19N05) FOR THE AIR CONDITIONING REPROGRAMMING, DRAIN PLUGS, AND REAR BUMPER. IN ADDITION, THE CONTACT TOOK THE VEHICLE TO JOHN KENNEDY FORD OF CONSHOHOCKEN (LOCATED AT 1023, 1403 RIDGE PIKE, CONSHOHOCKEN, PA 19428, (610) 279-1700) DUE TO AN EXHAUST ODOR IN THE VEHICLE. THE ODOR CAUSED DIZZINESS, LIGHTHEADEDNESS, AND NAUSEA. MEDICAL ATTENTION WAS NOT RECEIVED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER TEST DROVE THE VEHICLE, BUT WAS UNABLE TO DETECT AN EXHAUST ODOR. HOWEVER, THE DEALER MADE UNKNOWN REPAIRS AND THE VEHICLE PASSED THE EMISSIONS TEST. WHEN THE CONTACT RETRIEVED THE VEHICLE ON AUGUST 8, 2019, THERE WAS A STRONG EXHAUST ODOR COMING THROUGH THE VENTS. THE CONTACT TESTED THE VEHICLE WITH HIS OWN CARBON MONOXIDE DETECTOR, WHICH ALERTED HIM WITHIN TWO TO THREE MINUTES. THE CONTACT CALLED L.B. SMITH FORD-LINCOLN (1100 MARKET ST, LEMOYNE, PA 17043, (717) 761-6700) AND SCHEDULED AN APPOINTMENT. THE DEALER STATED THAT THEY WOULD HAVE TO REPAIR THE VEHICLE PER TECHNICAL SERVICE BULLETIN: 17-0044. THE DEALER FINALLY AGREED TO REPLACE THE PTU UNDER WARRANTY AND COVER THE REPAIR COST. THE CONTACT CALLED THE MANUFACTURER AND WAS PROVIDED CASE NUMBER: ZAS-22339312-Z6X9V3. THE APPROXIMATE FAILURE MILEAGE WAS 28,139. *DT I DO HAVE VIDEO OF OUR KIDDIE BRAND CO DETECTOR ALERTING IN THE VEHICLE BUT THE FILE IS TOO LARGE TO SEND.*JB *DT*JB

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 45 MPH, THE STEERING SEIZED. THE CONTACT REGAINED CONTROL OF THE STEERING AND DROVE TO PURVIS FORD LINCOLN (3660 JEFFERSON DAVIS HWY, FREDERICKSBURG, VA 22408, (540) 898-3000). THE DEALER DIAGNOSED THAT THE RACK AND PINION FAILED. THE MANUFACTURER WAS CONTACTED AND PROVIDED CASE NUMBER: 23972804. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 33,000.

REQUIRED A NEW TRANSMISSION. REPORTED INITIAL PROBLEM AT 58,000 MILES THE DEALER COULD NOT FIND A PROBLEM WHILE CAR WAS STILL UNDER WARRANTY. CAR WAS EXPERIENCING A HESITATION DURING ACCELERATION. AT 80,000 MILES THE TRANSMISSION HAD TO BE REPLACE (OUT OF WARRANTY). REQUIRE NEW BATTERY AND CABLES AFTER BATTER "EXPLODED" CORRODING THE BATTERY CABLES. (68,000 MILES). REQUIRED A NEW WATER PUMP AT 86,000 MILES.

STEERING RACK/STEERING GEAR FAILURE CAUSING CAR TO LOSE CONTROL AND RUN OFF ROAD INTO SHOULDER/DITCH. ALLOY WHEEL BENT WITH RUNNING OFF ROAD. NO INJURY OR BODILY HARM AS THIS OCCURRED IN A LOW TRAFFIC AREA AT ABOUT 30MPH. STEERING WHEEL WOULD LOCK INTO TURNS. CAR STEERING WHEEL VERY HARD TO TURN CAR UNCONTROLLABLE AT ANY HIGHER RATE OF SPEED. NOT COVERED UNDER MANUFACTURE WARRANTY OR RECALL. MILEAGE AT FAILURE: 53257 PART # FB5Z*3504*V GEAR ASY- STEERING COST $1310.40 AFTER LABOR AND TAX REPAIR TOTAL CAME TO $1826.60

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR ILLUMINATED. THE CONTACT WAS CONCERNED THAT THE AIR BAGS COULD DEPLOY AT ANY TIME AND THE SEAT BELTS MAY NOT WORK. IN ADDITION, THE TOE LINK SUSPENSION ALSO FAILED AND THE SEAT BELT WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO MCCLARDY FORD (4400 LANDERS RD, NORTH LITTLE ROCK, AR 72117, (501) 945-1200) WHERE THE MECHANIC STATED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE CONTACT MAY HAVE TO PAY FOR THE REPAIRS. THE FAILURE MILEAGE WAS 39,000.

HAD JUST RETURNED TO BATON ROUGE,LA FROM BILOXI MS, STOP TO DROP OFF OUR TRAVELING GUEST AT THEIR HOME RESTARTED THE VEHICLE AND A STEERING ASSIST ERROR CODE APPEARED ALONE WITH TWO OTHER CODES UPHILL START AND ONE FOR TRACTION. THERE WAS NO WARNING OR INDICATION SOMETHING WAS WRONG

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 19V435000 (SUSPENSION) REGARDING THE TOE LINK FRACTURING. THE CONTACT CALLED OXMOOR FORD LINCOLN (100 OXMOOR LN, LOUISVILLE, KY 40222, (502) 426-2500) AND AN APPOINTMENT WAS SCHEDULED TO HAVE THE RECALL SERVICED. PRIOR TO THE APPOINTMENT, WHILE DRIVING 55 MPH OVER AN OVERPASS, THE CONTACT LOST CONTROL OF THE VEHICLE DUE TO THE DEFECTIVE TOE LINK FRACTURE. THE CONTACT EXITED THE HIGHWAY AND DROVE HOME AT A LOW SPEED. THE CONTACT SPOKE WITH THE DEALER AND WAS INFORMED THAT THEY COULD NOT INSPECT THE VEHICLE UNTIL HIS APPOINTMENT DATE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE CONTACT REQUESTED A LOANER VEHICLE. THE MANUFACTURER REFUSED THE REQUEST FOR A LOANER VEHICLE AND EXPLAINED THE RECALL POLICY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 60,494.

2016 FORD EXPLORER XLT - WHILE DRIVING 70 MPH ON STRAIGHT HIGHWAY, THE PLASTIC OUTER PILLAR WINDSHIELD TRIM ON THE PASSENGER'S SIDE OF THE WINDOW SHIELD DETACHED WITHOUT WARNING. THE VEHICLE HAS NOT YET BEEN TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE FAILURE MILEAGE WAS ~38,000.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE MADE A GRINDING NOISE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS 78,597.

STEERING WENT OUT ON THE VEHICLE. DIAGNOSED AS THE STEERING GEAR/RACK. STARTED WITH MAKING A GRINDING NOISE WHEN TURNING AND EVENTUALLY FAILED. ONLY 40,000 MILES ON VEHICLE.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT TOOK THE VEHICLE TO STAR DODGE CHRYSLER JEEP RAM (5101 S 1ST ST, ABILENE, TX 79605, (325) 698-2222) TO HAVE THE VLA EMISSION COMPUTER UPDATE COMPLETED. AFTER A FEW DAYS, THE VEHICLE BEGAN TO EXHIBIT A DELAYED RESPONSE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. IN ADDITION, THE VEHICLE DOWNSHIFTED ON ITS OWN SUDDENLY, ESPECIALLY WHILE DRIVING UPHILL. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE VEHICLE WAS AFFECTED BY THE VLA EMISSION UPDATE. AFTER THE UPDATE, THE VEHICLE TENDED TO OVERHEAT AND THE FUEL GAUGE DID NOT ACCURATELY DISPLAY THE CORRECT READING. THE VEHICLE WAS TAKEN TO STAR DODGE A THIRD TIME WHERE IT WAS DIAGNOSED THAT THE EGR WAS THROWING COOLANT INTO THE TURBO. THE CONTACT REACHED OUT TO THE MANUFACTURER AND WAS PROIVDECASE NUMBER: 407224. THE DEALER STATED THAT THE CASE WOULD BE CLOSED BECAUSE THEY COULD NOT REMEDY THE FAILURE. PRIOR TO UPDATING THE VLA, THE CONTACT WAS INFORMED BY THE ECO SYSTEM HOTLINE THAT THE VEHICLE WOULD NOT BE AFFECTED. THE FAILURE MILEAGE WAS 51,000.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE DRIVING VARIOUS SPEEDS, THE POWER STEERING MALFUNCTIONED AND THE STEERING WHEEL BECAME VERY DIFFICULT TO TURN IN EITHER DIRECTION. IN ADDITION, THE MESSAGE "STEERING FAULT" WAS DISPLAYED. THE VEHICLE WAS TAKEN TO KEITH HAWTHORN FORD (617 NORTH MAIN ST, BELMONT, NC) WHERE IT WAS DIAGNOSED THAT THE STEERING COLUMN NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 88,000.

I WAS PARKED AT THE AIRPORT. WHEN I STARTED MY CAR I RECEIVED A WARNING "STEERING ASSIST FAULT SERVICE REQUIRED" THE POWER STEERING WAS COMPLETELY DISABLED AND I WAS NOT ABLE TO DRIVE THE VEHICLE WITHOUT GREAT DIFFICULTY. I HAD TO DRIVE IT HOME AND IT WAS EXTREMELY DANGEROUS. THE VEHICLE WAS PARKED WHEN I GOT THE WARNING.

AT APPROX 48,000 MILES, AIRBAG LIGHT CAME ON. CAR WAS NOT MOVING, WAS PARKED FOR 9 HOURS AFTER A DAY OF WORK. NOTHING HIT, NO IMPACT. FORD DEALER DIAGNOSIS: AIRBAG HARNESS/CONNECTOR ISSUE TRACED BACK TO REAR PASSENGER SEAT BEHIND DRIVER. 1.5 DAYS WORK AND $478.93 CHARGE, NOT A WARRANTY OR RECALL REPAIR. AIRBAG CIRCUIT INOPERATIVE. FIX IS PER TSB16-0001. I AM KEEPING THE PARTS THE DEALER IS REPLACING. REQUIRES REMOVAL OF REAR SEATS/REPLACE/SPLICE CONNECTOR. DEALER NOT FORGIVING.

AS I WAS DRIVING MY 2016 FORD EXPLORER ON THE HIGHWAY ON 08/01/2019 I EXPERIENCED THE VEHICLE START TO STUTTER JUST BEFORE I WAS GOING ON TO THE ON RAMP MERGING ON THE HIGHWAY AND AFTER I WAS ON THE HIGH WAY THE VEHICLE STARTED SMOKING FROM UNDER THE HOOD AND WOULD NO LONGER ACCELERATE AND I COULD SMELL OIL BURNING AND PULLED OVER AND SHUT THE CAR OFF LOOKED UNDER THE CAR AND SAW THE PILE OF OIL UNDERNEATH BUT THE VEHICLE DID NOT HAVE THE ANY CHECK ENGINE LIGHT OR WARNINGS ONCE WE TOWED THE VEHICLE HOME I LOOKED UNDER THE CAR AND SAW THAT THE TRANSMISSION CASING WAS CRACKED PRETTY MUCH IN HALF I COULD ACTUALLY SEE THE GEARS INSIDE THE CASING OF THE TRANSMISSION I ALSO REMEMBERD IN THE PAST YEAR OR SO THE VEHICLE WOULD SHIFT VERY HARD AFTER BRAKING AND THEN GETTING BACK ON THE GAS IT HAPPENED EVERY ONCE IN A WHILE .

WITH NO WARNING - EXPERIENCED SUDDEN LOSS OF POWER WHILE DRIVING. ENGINE LIGHT CAME ON. ALSO THE WRENCH LIGHT CAME ON WITH A MESSAGE THAT SAID "SEE MANUAL." I WAS ABLE TO GET OUT OF TRAFFICE AND PULL OVER. AFTER TEN MINUTES, I RESTARTED THE CAR. THE CAR STARTED BACK UP WITH NO PROBLEM AND THE ENGINE LIGHT WAS BACK OFF. FROM THERE IT DROVE BEAUTIFULLY LIKE IT NEVER HAPPENED - EXCEPT THAT IT DID ! FOUR DAYS LATER, I TAKE IT TO THE DEALORSHIP. THEY DETERMINED THAT THIS HAPPENED DUE TO A DEFECTIVE THROTTLE BODY. I HAVE TO HAVE IT REPLACED AND IT'S GOING TO COST ME $380. I FIND IT HARD TO BELIEVE THAT WITH THE SIGNIFICANT NUMBER OF COMPLAINTS ON THIS ISSUE ALL OVER THE INTERNET THAT THEY DIDN'T KNOW ABOUT THIS AT THE DEALORSHIP WHEN THEY SOLD ME THE CAR. AND ALSO THAT FORD HAS NOT RECALLED THIS YET CONSIDERING THE NUMBER OF COMPLAINTS. I HAVE TO HAVE THIS FIXED, I HAVE NO CHOICE. I WOULD DEFINITLY LIKE TO REUMBERSED FOR THIS REPAIR. BUT IN ADDITION TO THE OUT OF POCKET COST, THE POWER GOING OUT ON THE CAR WHILE DRIVING IS A MAJOR SAFETY ISSUE. WITH THE SIGNIFICANT NUMBER OF COMPLAINTS ON THIS ISSUE WITH THIS SPECIFIC VEHICLE MODEL / YEAR , I HOPE THAT SOMEBODY DOESN'T HAVE TO DIE BEFORE THEY PLACE A RECALL ON THIS ISSUE.

ON THE HIGHWAY WITH MY FAMILY IN THE CAR "STEERING FAULT" LIGHT CAME ON AND THE STEERING WHEEL GOT HARD TO TURN. LUCKILY I WAS CLOSE TO HOME AND STARTED GOING HOME. JUAT AS I PULLED INTO MY DRIVE WAY "STEERING LOSS" LIGHT CAME ON AMD I COULD NO LONGER TURN MY STEERING WHEEL. LUCKILY NO ONE WAS INJURED. HAVING THE VEHICLE TOWED TO DEALERSHIP.

WHILE IN MOTION THE VEHICLES STEERING SUDDENLY BECAME "STICKY" AND MAKING A GRINDING SOUND. SHORTLY AFTER THE CAR BECAME HARD TO CONTROL WHILE IN MOTION BECAUSE IT HAD LOST POWER STEERING. THE CAR IS ONLY 3 YEARS OLD AND THE REPAIR IS VERY EXPENSIVE AS WELL AS NOT GUARANTEED BECAUSE THE PART IS FATLY AND IT CAN HAPPEN AGAIN.

WHILE STATIONARY, OR SITTING IN VEHICLE WHILE IDLING, CARBON MONOXIDE IS DETECTED IN THE CABIN AND I HAVE BEEN FALLING ASLEEP AND STAYING TIRED FOR REST OF THE DAY. THIS HAS BEEN GOING ON IN THE 2 MONTHS THAT I HAVE HAD THE NEW SUV. I SUSPECTED AFTER I WAS TOLD BY A FRIEND THAT THIS HAS BEEN REPORTED BY SHERIFFS. I PLUGGED IN MY HOME DETECTOR TO CHECK IF THAT WERE THE CASE. I AM NO LONGER IDLING WITHOUT WINDOWS OPEN IF POSSIBLE DUE TO WEATHER.

I STARTED HAVING PROBLEMS WITH THE STEERING WHEEL AT 16,000 MILES. I TOOK THE VEHICLE TO MY LOCAL FORD DEALERSHIP EACH TIME, ONLY TO BE TOLD IT MUST BE GIVING A CODE SO THEY CAN FIGURE OUT THE PROBLEM. MY EXPLORERS STEERING PROBLEM WOULD CORRECT ITSELF IF I TURNED OFF THE IGNITION & STARTED BACK. IN JULY 2019 AT 46,636 MILES I LOST ALL STEERING. I HAD THE EXPLORER TOWED INTO MY LOCAL FORD SERVICE CENTER AND WAS TOLD IT IS A STEERING GEAR THAT NEEDS TO BE REPLACED. THIS IS A VERY DANGEROUS PROBLEM WITH THESE VEHICLES THAY I FEEL NEEDS TO BE ADDRESSED ASAP!

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE DRIVING 50 MPH, THE 'POWER STEERING FAULT ASSIST' MESSAGE APPEARED ON THE INSTRUMENT PANEL AND THE POWER STEERING SEIZED. THE CONTACT HAD TO USE EXCESSIVE STRENGTH TO STEER THE VEHICLE. THE CONTACT DROVE TO MAGIC CITY FORD (51 NORTHRIDGE LN, LEXINGTON, VA 24450, (540) 463-3196) AND WAS INFORMED THAT THE RACK AND PINION NEEDED TO BE REPLACED. THE DEALER ORDERED THE PART, WHICH WAS EXPECTED TO ARRIVE ON JULY 30, 2019. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 44,000.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE DRIVING VARIOUS SPEEDS, THE POWER STEERING MADE A GRINDING NOISE WHILE THE VEHICLE WAS MAKING A TURN. ALSO, THE STEERING WHEEL BECAME STIFF AND RESISTANT WITHOUT WARNING. TED BRITT FORD OF CHANTILLY (FORD BUILDING, 4175 AUTO PARK CIR, CHANTILLY, VA 20151, (703) 454-0008) WAS CONTACTED AND STATED THAT DIAGNOSTIC TESTING WAS NEEDED. THE VEHICLE WAS DIAGNOSED AND REPAIRED. THE MANUFACTURER WAS NOTIFIED 5 TIMES. THE FAILURE MILEAGE WAS 37,000.

WHILE DRIVING ON THE HIGHWAY AT 65 MPH I NOTICED MY STEERING WHEEL BECOME SHAKY AND UNCONTROLLABLE . I WAS FEELING UNSAFE AND MOVED TO THE RIGHT LANE AND WITHIN SECONDS THE STEERING WHEEL FROZE UP AND WARNING LIGHTS WENT ON. I GLIDED TO THE SHOULDER. TURNED THE CAR OFF. TRIED SEVERAL TIMES TURNING IT BACK ON BUT WARNING LIGHTS AND STEERING WHEEL WAS STILL LOCKED. HAD THE CAR TOWED.

2016 FORD EXPLORER - THE BACKUP CAMERA WILL COME ON WHILE TRAVELING DOWN THE HIGHWAY AT 55-60 MPH. WILL CAUSE IT TO LOOSE POWER, THE RPM'S DROP RIGHT BELOW 1000, THE WRENCH SYMBOL COMES ON, AND IT WILL BARELY MOVE DOWN THE ROAD. A SCREEN WILL POP UP ON OCCASION SAYING HILL ASSIST IS UNAVAILABLE. YOU HAVE TO PULLOVER, TURN THE CAR OFF, OPEN THE DRIVER DOOR TO MAKE SURE THE RADIO AND ALL GOES OFF, WAIT EXACTLY ONE MINUTE, AND THEN YOU ARE ABLE TO CRANK THE VEHICLE UP TO BE ABLE TO MOVE. I HAVE TAKEN TO DEALERSHIP, AND ALL THEY SAY IS IT'S A SENSOR INSIDE THE TRANSMISSION, AND ALL THEY CAN DO IS CLEAR THE CODE OUT. THEY SAY THAT IT IS SAYING MY VEHICLE IS TRYING TO ENGAGE IN REVERSE WHILE GOING DOWN THE ROAD. THIS SOUNDS LIKE A HUGE SAFETY ISSUE ESPECIALLY WHEN I HAVE HAD OTHERS SAY THE SAME THING HAS HAPPENED TO THEM AS WELL. I HAVE REACHED OUT TO THE DEALERSHIP IN REGARDS TO MY WARRANTY, BUT I HAVE YET TO HEAR BACK FROM THEM, AND IT HAS BEEN OVER 2 WEEKS. I HAVE ALSO REACHED OUT TO THE SALES REPRESENTATIVE SEVERAL TIMES, AND I HAVE YET TO HEAR FROM HIM. I CONTACTED THEM BECAUSE WHILE LOOKING AT THE PAPERWORK IT SAID IT HAD A LIMITED POWER TRAIN WARRANTY, BUT IT WAS PURCHASED AS A PRE-CERTIFIED USED VEHICLE WITH AN UNLIMITED POWER TRAIN WARRANTY THEY WERE OFFERING FOR VEHICLES WITH LEST THAN 80,000 MILES. I HAVE NOT HAD IT A YEAR YET. I HAVE AN EMAIL FROM THE SALES REP HIMSELF STATING THAT IT IS UNLIMITED. IT WAS PURCHASE IN SEPTEMBER OF 2018.

SMELL OF SULFUR OR NATURAL GAS IN THE CABIN, CAUSING HEADACHES AND DIZZINESS. THE ISSUE SEEMS TO BE WORSENED IF CLIMATE CONTROL FANS ARE BLOWING. THE ISSUE OCCURS WHILE DRIVING OR IDLING.

I HAVE HAD AN ISSUE IN THE TRANSMISSION OR SHIFTING AND WON'T GO INTO GEAR OR DRIVE UNTIL YOU TAKE IT AND PUT BACK TO PARK. THEN SOMETIMES IT WILL AND SOMETIMES IT WON'T. I TOOK IT TO THE DEALER AND THEY HAD A FORD ENGINEER THAT THOUGHT THEY FIGURED IT OUT AFTER SHELLING SOMETHING AND REPAIRING IT. IT WORKED FOR A MONTH AND NOW IS BACK AT DEALER FOR A SECOND TIME. SEEMS TO BE WITH 4 WHEEL DRIVE OR TRANSMISSION

TURNING STEERING WHEEL MAKES A GRINDING NOISE. STEERING GETS STUCK WHEN TURNING LEFT OR RIGHT AND HAS TO BE FORCED BACK TO CENTER. DOES NOT RETURN ON ITS OWN. HAPPENS WHILE SITTING OR DRIVING. IF YOU MAKE A TURN ON THE STREET IT WILL SEND YOU OFF THE ROAD OR INTO ANOTHER LANE IF YOU DO NOT FORCE THE STEERING WHEEL BACK. THE STEERING RACK IS BAD. 3 YEAR OLD EXPLORER. AFTER RESEARCHING MORE ALMOST EVERY OTHER YEAR OF EXPLORER IN THE TEENS HAS HAD A RECALL FOR THE STEERING GEAR EXCEPT 15/16. THERE ARE A LOT OF COMPLAINTS FOR 2016 STEERING GEARS. ARE WE WAITING FOR SOMEONE TO GET KILLED FIRST?

RECEIVED RECALL 19V-435 BROUGHT IT INTO DANA FORD STATEN ISLAND AN WAS TOLD THIS RECALL ONLY COVERS REAR ALLIGNMENT AND THIS COULD EFFECT THE FRONT ALIGNMENT AND I WOULD HAVE TO PAY $89 PLUS TAX. WHY SHOULD I PAY FOR 5HEIR MISTAKE?