2016 Ford Explorer complaints

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE DRIVING THE CONTACT TURNED ON THE HEAT IN THE VEHICLE AND SMELT AN DISTINCT ODOR COMING FROM THE VEHICLE. THE ODOR WAS STRONG THE CONTACT HAD TO ROLL DOWN THE WINDOW IN THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THE FAILURE AS A CARBON MONOXIDE LEAKAGE. THE VEHICLE WAS REPAIRED BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 66,000.

AIRBAG LIGHT HAS BEEN COMING ON INTERMITTENTLY FOR OVER 1 YEAR. DIAGNOSTIC TEST DETERMINED THERE IS A FAULTY CONNECTION TO THE 2ND ROW INFLATABLE SEATBELT SENSOR. FORD ISSUED A SERVICE BULLETIN TO REPLACE THE WIRE HARNESS PIG TAIL CONNECTION. WHEN THE AIR BAG LIGHT IS ILLUMINATED DUE TO THIS FAULTY CONNECTION, ALL OF THE AIR BAGS IN THE VEHICLE ARE DEACTIVATED. THIS IS EXTREMELY DANGEROUS, AND MY FAMILY HAS BEEN DRIVING THE CAR IN THIS CONDITION FOR OVER A YEAR. UPON FURTHER RESEARCH, NUMEROUS CASES EXIST REPORTING THE SAME ISSUE. PLEASE ADDRESS THIS SAFETY ISSUE.

DRIVING DOWN THE ROAD AND THE AIR BAG LIGHT COMES ON AND NOW IT WONT GO OFF. IT STAYS ON 24/7. THIS IS AN ISSUE IN MANY 2016 FORD EXPLORERS AND IT HAS YET TO BE RECALLED. THIS IS A SAFETY ISSUE.

I TOOK MY 2016 FORD EXPLORER XLT ON DEC 29TH 2020 TO GET A OIL CHANGE ETC. THEY HAD THE VEHICLE ALL DAY EVEN THOUGH I TOOK IT IN AT 7AM. I PICK IT UP A 4:45 PM THEN DRIVE IT HOME BECAUSE I WORK FROM HOME I DID NOT DRIVE IT AGAIN UNTIL SATURDAY JAN 9TH 2021, WHILE DRIVING IT THAT MORNING I REALIZED THAT THE STEERING WHEEL WAS HARD TO STEER AND THE TRUCK WOULD MAKE NOISES WHEN I TURN THE STEERING IN EITHER DIRECTION. I TOOK IT IN TO THE DEALERSHIP THAT MORNING AND ASKED THE SERVICE CONSULTANT TO TAKE A LOOK AT IT. HE TOLD ME WHILE MY FATHER WAS ON THE PHONE THAT HE BELIEVES IT THE RACK AND PINION AND HE CAN'T TAKE IT BECAUSE THEY ARE BUSY AND IT'S OKAY FOR ME TO DRIVE IT. I ALSO TOLD HIM AT THAT TIME I AM SUPPOSED TO DRIVE OUT OF TOWN AND I WON'T BE BACK FOR AWHILE SO IF THERE IS A PROBLEM I RATHER LEAVE IT SO IT CAN BE FIXED. I HAVE DAMAGED ON MY C5 VERTEBRAE SO I CAN FEEL THE HARDNESS IN THE STEERING. HE ASSURED OR DISMISSED ME BUT HE SAID IT'S FINE. A FEW HOURS LATER THE STEERING WHEEL SEIZED UP AND THE DASHBOARD STARTED MAKING NOISE AND THE WARNING LIGHTS AND MESSAGES STARTED TO DISPLAYING. IT ALMOST KILLED BOTH MY MOTHER AND I ON THE HIGHWAY. IF YOU KNOW NYC HIGHWAY YOU KNOW THERE IS NO SHOULDERS. WHEN I PULLED OF THE ROAD THE STEERING WHEEL LOCKED UP AND I COULD NOT MOVE IT. I HAD TO PAY FOR THE TRUCK TO BE TOWED AND A UBER FOR MYSELF BACK TO THE DEALERSHIP AND THEN PAID FOR ME TO GET HOME. NOW THEY ARE TELLING ME THAT I HAVE TO PAY $2719.81 FOR THE RACK AND PINION REPAIR

CAR WENT IN FOR RECALL NHTSA #20V675 AND DEALER INSPECTED VEHICLE AND INFORMED US, IT HAS FAILED INSPECTION AND WILL REQUIRE REPLACEMENT. THEY HAVE PARTS QUOTED AT 4-6 WEEKS OUT AND WE ASKED ABOUT A RENTAL VEHICLE AND WERE INFORMED THAT IT WOULD NOT BE COVERED. WE ASKED IF THE VEHICLE WAS SAFE TO DRIVE AND THEY WILL NOT STATE IT IS SAFE TO DRIVE, SO THEREFORE WE CANNOT DRIVE IT. CONTACTED FORD CUSTOMER SERVICE AND WERE INFORMED OUR RENTAL REQUEST WAS DENIED AND THEY WILL NOT SAY THE CAR IS SAFE TO DRIVE. WE CANNOT BE WITHOUT A CAR FOR 6 WEEKS AND CANNOT AFFORD A RENTAL FOR THAT AMOUNT OF TIME. FORD SHOULD COVER RENTAL WHEN PARTS ARE NOT AVAILABLE.

2016 FORD EXPLORER. CONSUMER WRITES IN REGARD TO BRAKE FAILURE WHILE DRIVING. *AS THE CONSUMER STATED AS A RESULT OF THE CONTINUOUS FAILURE, THE VEHICLE WAS TRADED IN. *JS

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V675000 (SUSPENSION) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT CONTACTED BEAU TOWNSEND FORD (1020 W. NATIONAL RD, VANDALIA, OH 45377, (937) 898-5841) TO SCHEDULE AN APPOINTMENT AND THE DEALER CONTACTED THE CONTACT BACK TO INFORMED HIM THAT THERE WERE NO PARTS AVAILABLE FOR THE RECALL REPAIR. THE CONTACT CONTACTED THE MANUFACTURER BUT THERE WAS NO RESPONSE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

TL* THE CONTACT OWNED A 2016 FORD EXPLORER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V435000 (SUSPENSION). THE VEHICLE TAKEN LOCAL DEALER KEVIN'S ROYAL FORD OF COOPERSTOWN (5069 NY-28, COOPERSTOWN, NY 13326:(607) 547-9924) AND HAD THE RECALL COMPLETED. THE CONTACT STATED WHILE DRIVING 45 MPH, WHEN THE VEHICLE'S TOE LINK DETACHED AND CRASHED INTO A GUARD RAIL AND DROVE INTO A DITCH. ALL 5 AIR BAGS DEPLOYED. THE CONTACT DID NOT SUSTAINED ANY INJURIES OR SEEK ANY MEDICATION ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT DRIVABLE. THE INSURANCE COMPANY DEEMED THE VEHICLE A LOSS. THE VEHICLE WAS TOWED TO A JUNKYARD. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V675000(SUSPENSION) ON NOVEMBER OF 2020 AFTER THE ACCIDENT. THE MANUFACTURER HAD BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 42,300. *JS

WENT TO VISIT FAMILY ON CHRISTMAS MORNING AND WHILE DRIVING POWER ASSIST WENT OUT AND POPPED UP THE DISPLAY WARNINGS. DROVE IT ANOTHER 8 MILES TO DESTINATION. VEHICLE SAT FOR ABOUT 3 HOURS IN THE DRIVEWAY. 30 DEGREE WEATHER. WENT TO LEAVE AND AS I PULLED ONTO THE MAIN ROAD THE STEERING LOCKED AND WARNING MESSAGE LOSS OF STEERING BRAKE SAFELY. I COULD JERK THE WHEEL HARD TO GET IT TO SLIGHTLY MOVE ENOUGH TO GET BACK IN THE DRIVEWAY. JUST HIT 100K MILES. HAD TO HAVE IT TOWED BACK HOME.

MY 2016 FORD EXPLORER XLT TURBO 4WD IS HAVING POWER STEERING PROBLEMS, THE TRUCK ONLY HAS 65,000 MILES AND IT'S HARD TO TURN THE WHEEL AND IT MAKES A GRINDING RUBBING SOUND WHEN TURN THE WHEEL LEFT OR RIGHT. IT MAKES THAT NOISE WHILE DRIVING OR PARKED.

USING A PEDAL COMMANDER PC18 BLUETOOTH "THROTTLE ENHANCER" IN AN EMERGENCY VEHICLE EQUIPPED WITH A VHF MOBILE TWO-WAY RADIO. THE RADIO TRANSMITS AT 50W AND IS INSTALLED BY A PROFESSIONAL EMERGENCY VEHICLE UPFITTER PER MANUFACTURERS INSTRUCTIONS. WHEN TRANSMITTING IN THE 156MHZ RANGE THE PEDAL COMMAND CONSISTENTLY AND UNEXPECTEDLY CAUSES THE VEHICLE TO BEGIN ACCELERATING WHEN IN DRIVE, AND INCREASING THE RPM OF THE ENGINE IN PARK. THE ACCELERATION CONTINUES AS LONG AS THE USER IS TRANSMITTING ON THE TWO-WAY RADIO. AS SOON AS THE TRANSMISSING ENDS THE VEHICLE GOES BACK TO IDLE OR RPMS CONSISTENT WITH THE PEDAL POSITION. THESE SYMPTOMS GO AWAY AS SOON AS THE PC18 IS REMOVED. THIS ISSUE WAS ALSO EXPERIENCED BY OTHER USERS WITH PC18 AND RADIOS THAT TRANSMIT IN THE MID 150MHZ RANGE.

THE STEERING WHEEL AT TIMES WHEN EVEN MAKING A SLIGHT TURN POPS BACK AND SHAKES. RESTRICTING THE TURN THE WIPERS HAVE NOW MULTIPLE TIMES IN RAIN STOPPED IN THE UPRIGHT POSITIONS CAUSING A GRAVE DRIVING HAZARD

I FIRST NOTICED THE PROBLEM LAST WINTER, WHEN WE WOULD DRIVE OUR EXPLORER IN THE SNOW THE CAR WOULD PULL IN RANDOM DIRECTIONS, IT GOT TO THE POINT WHERE I WAS SCARED TO DRIVE THE CAR IN FEET I WOULD BE PULLED INTO ON COMING TRAFFIC. I TOOK IT TO A MECHANIC AND THEY COULDN'T FIND ANYTHING WRONG OTHER THAN MY REAR SHOCKS WERE BAD, SO I REPLACED THEM. THEN OVER THE SUMMER I NOTICED WHEN I TURN GOING AT SLOW SPEEDS THE CAR WOULD MAKE A LOUD POP AND SOMETIMES THE STEERING WOULD GET STUCK WHEN IT POPED, SO I DID SOME RESEARCH A THOUGH MAYBE IT WAS MY TOE LINKS. SO I JUST REPLACED THEM AND THIS CAR IS STILL TERRIFYING TO DRIVE IN THE SNOW. I HAVE SEEN THAT A CONCERNING NUMBER OF PEOPLE HAVE HAD THIS SAME ISSUE AND THEY END UP REPLACING THEIR RACK AND PINION AND IT COSTS THOUSANDS OF DOLLARS.

ELECTRONIC POWER STEERING HAS FAILED WHILE VEHICLE WAS IN MOTION TURNING ON A HIGHWAY. IT WAS IMPOSSIBLE TO TURN THE VEHICLE OFF THE ROADWAY DUE TO LOSS OF POWER STEERING.

POWER STEERING BEGAN TO GO WHEN I WAS DRIVING ON A HIGHWAY, MAKING ME FEEL LIKE I WAS LOSING CONTROL. WAS ABLE TO GET CAR HOME AND ENDED UP COMPLETELY LOCKING UP NEEDING TO BE TOWED FROM MY DRIVEWAY. I NEED TO HAVE STEERING RACK REPLACED FOR OVER $1800 JUST FOR THE PART ON A VEHICLE WITH ONLY 80,000 MILES ON IT.

WHILE OPERATING VEHICLE AT HIGH SPEEDS THE ADVANCETRAC LIGHT, TRACTION CONTROL LIGHT, AND NO STEERING ASSIST LIGHT CAME ON. BEFORE I COULD GET OFF THE INTERSTATE I LOST MOST OF MY STEERING. LUCKILY IT WAS AT NIGHT AND NOT TO MANY ON THE INTERSTATE. IT WAS AN EXTREMELY DANGEROUS SITUATION FOR MYSELF AND MY FAMILY. VERY LUCKY WE DIDN'T GET IN A SERIOUS ACCIDENT. IT WAS WORSE THAN LOOSING POWER STEERING WITH A HYDRAULIC POWER SYSTEM. THERE WAS NO CONTROL AVAILABLE WHILE TRYING TO GET OVER.

I WAS DRIVING TO WORK AND MY CAR MADE A SCREECHY SOUND ONCE I GOT ON THE HIGHWAY AND WENT 45 OR OVER THE STEERING WHEEL STARTED TO SHAKE. IN A WAY IT FELT THE STEERING WHEEL OR THE PART THAT HOLDS THE FRONT TIRES WAS LOOSE. IT FELT LIKE IF I WENT ANY FASTER I'D LOSE CONTROL OF THE CAR.

THERE IS AN SRS AIRBAG WARNING LIGHT ON THE DASHBOARD THAT USED TO INTERMITTENTLY DISPLAY. NOW IT IS ON CONSISTENTLY WHEN THE VEHICLE IS DRIVEN. IT IS DUE TO A CIRCUIT FAILURE OR A BROKEN CORD LEADING TO THE DRIVER SIDE MIDDLE ROW SEATBELT AIRBAG. DIRECTLY FROM SITE: HTTPS://FORD.OEMDTC.COM/1203/AIR-BAG-WARNING-LIGHT-ILLUMINATED-WITH-DTC-B141B-B141C-2014-2016-FORD-EXPLORER TSB 16-0001 AIR BAG WARNING LIGHT ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) B141B AND/OR B141C THIS IS NOT NORMAL WEAR AND TEAR BUT A SAFETY ITEM DESIGN BY FORD THAT HAS FAILED IN THE VEHICLE. FORD DEALERSHIP CLAIMS THAT THIS IS NOT WARRANTY FAILURE. BUT SOUNDS LIKE AN ELECTRICAL AND SAFETY ISSUE TO ME...WHICH SHOULD BE COVERED UNDER WARRANTY. THE TRUTH TO THE MATTER IS...FORD DOES NOT CARE THAT A POTENTIALLY HIGH RISK PROBLEM HAS BEEN IDENTIFIED AS A FAILURE ON THE COMPANY'S END BUT THEY DON'T CARE ENOUGH TO DO ANYTHING ABOUT IT. WELL..OTHER THAN CHARGE THE CUSTOMER CLOSE TO $1000 OUT OF POCKET TO FIX FOR A POOR DESIGN ON FORD'S END. THE FORD DEALERSHIP SERVICE DEPARTMENT DOES NOT KNOW HOW THIS SAFETY FEATURE BROKE. IF WE WERE TO GET IN AN ACCIDENT WHILE THE AIRBAG IS IN THIS STATE, IT WOULD NOT DEPLOY AND THE LIVES OF ALL PASSENGERS IN JEOPARDY!

WHENEVER PUTTING THE VEHICLE INTO REVERSE THERE WILL BE A LOUD POP AND WILL SLAM INTO GEAR. SIMILARLY WILL HAPPEN WHEN SHIFTED INTO DRIVE. THEN WHEN CHANGING GEARS FROM SECOND TO THIRD THE VEHICLE WILL HESITATE SWITCHING GEARS AND THE RPM WILL GO INTO THE 5000 RPM. WILL HAPPEN USUALLY WHEN SHIFTING AGAIN INTO A HIGHER GEAR. USUALLY CAN DRIVE AROUND FIVE TO TEN MILES AND WILL SORT ITSELF OUT. HOWEVER IF YOU ARE ENTERING TRAFFIC ESPECIALLY A BUSY ROAD SYSTEM THIS MAY NOT ALLOW YOU TO ACCELERATE TO A SAFE SPEED SINCE THE GEARS NOT SHIFTING WILL CAUSE THE VEHICLE TO STALL AND NOT ACCELERATE.

I STARTED HEARING A GRINDING NOISE WHEN TURNING THE VEHICLE IN EITHER DIRECTION IN REVERSE LAST WEEK. I TOOK A LITTLE TRIP ON DEC. 5 2020, GOING UP TO THE MOUNTAINS. IT GOT WORSE WHILE STEERING MY VEHICLE ON A MOUNTAIN ROAD. I MADE AN APPOINTMENT ON DECEMBER 7 TO THE LOCAL DEALER. MY WIFE WAS DRIVING AT 50 MPH WHEN THE STEERING STARTED TO LOCK UP AND ALMOST CAUSED A COLLISION.THAT'S WHEN WE DECIDED IT IS A SAFETY ISSUE TO DRIVE THIS VEHICLE SO WE TOOK IT TO THE DEALER ASAP AND WAS HANDED A REPAIR COST OF 2620.00 TO REPAIR STEERING GEAR ASSEMBLY . THE VEHICLE HAD ONLY 47,700 MILES ON MY 2016 FORD EXPLORE XLT. IT IS NOW AT THE LOCAL FORD DEALER ON DECEMBER 9, 2020 AWAITING COMPLETION OF REPAIR AS VEHICLE IS NOT DRIVE-ABLE UNTIL REPAIRED. MY WIFE WAS ON THE HIGHWAY DRIVING WHEN SHE ENCOUNTERED ERRATIC BEHAVIOR FROM THE STEERING WHEEL GOING 50MPH. MY PARTS TOTAL FOR REPAIR IS 1,840.44 WITH LABOR TOTAL IS 2,620.00 WITH PARTS.

I RECEIVED A RECALL NOTICE FROM FORD ON THURSDAY. EVERYTIME I CALL TO MAKE A SERVICE APPOINT, I TOLD RECALL COMPUTERS ARE DOWN.

I TOOK MY VEHICLE IN FOR AN AIRBAG LIGHT AND WAS TOLD THAT THE WIRE ASSEMBLY LOCATED UNDER THE REAR SEAT WAS DAMAGED/FAULTY. THIS SEEMS TO BE A VERY COMMON ISSUE (SEE LINKS BELOW) THAT REQUIRED ME TO REPLACE THE WIRING AND WAS NOT COVERED UNDER WARRANTY BUT IS A SAFETY ITEM THAT IS WELL DOCUMENTED BY OTHERS IN ONLINE FORUMS. HTTPS://FORD.OEMDTC.COM/1203/AIR-BAG-WARNING-LIGHT-ILLUMINATED-WITH-DTC-B141B-B141C-2014-2016-FORD-EXPLORER?FBCLID=IWAR1IAMT7GHXQIAJF_Q3ETH7XLFE011S14V7P3JBMQQF1BY4XP1GP55U5F-E HTTPS://WWW.CARPROBLEMZOO.COM/FORD/EXPLORER/AIR-BAG-LIGHT-ON-PROBLEMS.PHP?FBCLID=IWAR32W-NNT2R2ESUV-5JM3H5ULS1FW4OQUHGPXWVRW5DLBBVOTZ4ED5OR69M

THE VEHICLE WITHOUT WARNING , JUST SHUTS OFF. EVEN WHILE GOING 65 MPH ON A HIGHWAY. IF YOUR LUCKY, YOU CAN COAST OFF THE HIGHWAY BEFORE YOU ARE HIT . FORD REFUSED TO FIX EVEN THOUGH UNDER WARRANTY. SO I HAD TO SELL IT SO I WOULDN'T BE KILLED. HUNDREDS IF NOT THOUSANDS HAVE COMPLAINED ABOUT THE SAME THING.

48K MILES PLATINUM EDITION , STEERING WHEEL BEGAN STICKING. RECENTLY STARTED PULLING HARD TO THE RIGHT AT TIMES. HAD IT LOOKED AT AND IT LOOKS LIKE AS WITH MANY MANY OTHERS LIKE IT, THE THE RACK AND PINION NEEDS TO REPLACED. FORD SHOULD BE FORCED TO RECALL THE CARS AND FIX THE PROBLEM. THERE ARE LITERALLY HUNDREDS OF PEOPLE WITH THE SAME PROBLEM. WHEN IS THE NHTSA GOING TO STEP UP AND DO SOMETHING? AFTER PEOPLE START DYING?

UPON STARTING MY CAR FOR THE THIRD TIME THAT DAY MY AIR BAG LIGHT CAME ON AND DOES NOT GO OFF. I ALSO HAVE A PROBLEM WITH IT OCCASIONALLY NOT REGISTERING MY DRIVERS SEATBELT AS BUCKLED OR UNBUCKLED.

S AIR BAG LIGHT IS ON, CHECK AND ADVISE SRS AIRBAG LIGHT IS ON. MANUFACTURER AND DEALERSHIP ARE AWARE OF THE ISSUE AND HAVE A TSB FOR THE ISSUE BUT ARE NOT COVERING UNDER VEHICLE WARRANTY OR RECALL. INSTEAD THEY ARE CHARGING FOR TROUBLE SHOOTING TO LOOK UP THE CODE AND THEN OFFERING TO LOOK INTO REPLACING PARTS TO GET THE SYSTEM WORKING AGAIN UNDER THE ALREADY ISSUED TSB FOR THE FAULTY SAFETY SYSTEM. THIS IS THE DESCRIPTION PROVIDED: VERIFIED CONCERN. RAN EEC TEST, FOUND B141C STORED IN RCM, SECOND ROW INFLATOR CONTROL SEAT BELTS. RAN OASIS, TSB 16-0001 APPLIES HOWEVER NOT COVERED UNDER ACTIVE CONTRACTS CPO POWERTRAIN.

ON SEVERAL OCCASIONS WHEN I GO TO START THE VEHICLE I GET A MESSAGE ON THE LEFT SIDE OF THE DASH CLUSTER THAT SAYS " STEERING ASSIST FAULT FAILURE, SEEK SERVICE." THE VEHICLE WON'T START. AFTER I KEEP PRESSING THE START BUTTON IF WILL START. I CARRIED IT TO THE DEALER ( PARADISE FORD IN COCOA, FL) AND THEY SAID THERE WERE NO CODES IN THE SYSTEM BUT DID SAY THERE WERE A LOT OF PROBLEMS WITH THE STEERING FAILURE ON THAT MODEL AND WOULD COST AROUND $2,500.00 TO REPAIR OUT OF MY POCKET. THE VEHICLE ONLY HAS A LITTLE OVER 5,000 MILES ON IT AS OF 11/29/20.

MY AIRBAGS LIGHT IS ON AND NONE WILL DEPLOY IN THE EVENT OF AN ACCIDENT AND IS NOT COVERED BY ANY WARRANTY. UNACCEPTABLE AND VERY DANGEROUS MANY OWNERS ARE REPORTING THIS ISSUE. HTTPS://WWW-ODI.NHTSA.DOT.GOV/VEHICLECOMPLAINT/

WHEN ACCELERATING AN ODOR LIKE BURNT HAIR OR ELECTRICAL ENTERS THE CABIN. FORD DID PERFORM RECALL WORK BUT THE ODOR STILL ENTERS THE CABIN.

WHEN BACKING OUT OF MY DRIVEWAY AND TURNING SLOWLY THERE IS A POPING NOISE AND MY STEERING WHEEL LOCKED UP MULTIPLE TIMES. BEFORE THIS I SPENT 1000 BUCKS TO GET THE WIRING HARNESS FOR AIR BAGS REPLACED. NONE OF THEM WORK FORD WOULD NOT COVER IT BECAUSE THERE IS NOT A RECALL.

WHEN I GO TO TURN, IT CONTINUES TO POP. THE TIE RODS HAVE BEEN REPLACED ALONG WITH RACK AND PINION BUT YOU COULD BE STOPPED AND APPLYING BRAKE AND TURN WHEEL AND IT POPS.

MY WATER PUMP HAS GONE OUT AND APPARENTLY THIS HAS NOT BEEN THE ONLY ONE.

ON AUGUST 20, 2020, MY VEHICLE HAD LAST BEEN DRIVEN AROUND 12 NOON. IT SAT IN THE DRIVEWAY WITH ALL OF US HOME. MY SON WENT TO GET IN THE VEHICLE AROUND 6:30 PM. SMOKE POURED OUT, THE SEAT WAS SMOLDERING AND FLAMES CAME UP. WE COULDN'T PUT THE FIRE OUT WITH EXTINGUISHER. FIRE DEPARTMENT PUT HOSE ON SEAT. FIREMEN STATED THEY SEE THIS OFTEN WITH HEATED/AIRCONDITIONED SEATS THAT MALFUNCTION AND BURN UP OR CAUSE FIRE. FIREMEN STATED THEY COULD TELL THE WAY IT LOOKED "LIKE ALL THE OTHER HEATED /AIR CONDITIONED SEATS THAT IGNITE THAT THEY SEE OFTEN". INSURANCE COMPANY SAYS CAR IS TOTALED SINCE HOSE WAS PUT ON IT. FORD WILL NOT WORK WITH ME. NO ONE LEFT ANYTHING BURNING IN THE SEAT OR SMOKED IN THE CAR. I BELIEVE THE CAR HEATED/AIR CONDITIONED SEAT MALFUNCTIONED AND FORD SHOULD HELP. I HAD PURCHASED BUMPER TO BUMPER WARRANTY FROM DEALERSHIP. WARRANTY COMPANY SAYS IF A CAR CATCHES FIRE, WARRANTY IS VOIDED, EVEN IF CAR MALFUNCTIONED CAUSING THE FIRE. INSURANCE COMPANY IS TRYING TO PAY AS LEAST AMOUNT AS POSSIBLE. THIS WAS A WELL CARED FOR, VERY NICE CAR. I BELIEVE IT MALFUNCTIONED. FORD MOTOR COMPANY SENT ME A LETTER SAYING THEY HAD THE DEALERSHIP TAKE PICTURES, AND THEY FEEL IT HAD SOMETHING LEFT BURNING ON THE SEAT. NO ONE LEFT ANYTHING BURNING ON THE SEAT. IN THE LETTER FORD MOTOR COMPANY SENT ME BY EMAIL, THEY STATE THEY INSPECTED THE CAR. THEY NEVER CAME TO SEE THE CAR IN PERSON. THEY ONLY HAD THE SERVICE STAFF TAKE PICTURES. THE CAR WAS SITTING IN THE DRIVEWAY ALL AFTERNOON. I A

TL* THE CONTACT OWNS A 2016 FORD EXPLORER EQUIPPED WITH HANKOOK TIRES, TIRE LINE: VENTUS S1 NOBLE 2, TIRE SIZE: 255/50/R20, DOT NUMBER: 5MNC 1A H 0716. THE CONTACT BECAME AWARE OF TREAD SEPARATION ON ALL FOUR TIRES. THE CONTACT STATED THAT THE FAILURE WAS MORE SEVERE ON THE TWO FRONT TIRES. THE VEHICLE WAS NOT TAKEN TO HAVE THE TIRES REPLACED. THE CONTACT ALSO STATED THAT THE TIRES FAILED TO MAINTAIN THE PROPER TIRE PRESSURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 16,132.

RANDOMLY ONE OF THE CAPTAIN CHAIRS SEAT BELTS NO LONGER BUCKLES. IT'S A AIRBAG SEATBELT WITH A DIFFERENT TYPE OF LATCH. WE HAVE NUMEROUS PROBLEMS WITH THESE TYPE OF BUCKLES SINCE WE BOUGH THE VEHICLE. THEY HAD TO REPLACE THE WHOLE HOUSING UNIT ON THE OTHER SIDE WITHIN THE FIRST 6 MONTHS BECAUSE IT JUST FELL APART.

WITHIN 10 DAYS OF BUYING IT BRAND NEW I'VE HAD ELECTRICAL PROBLEMS. REPLACED BACK UP SCREEN WITHIN THOSE 10 DAYS EVEN THOUGH THEY DIDN'T FIND ANYTHING WRONG. STILL CONTINUES. MULTIPLE ISSUES WITH THE POWER TRAIN. NOW I'VE BEEN OUT OF A CAR FOR 2 WEEKS BECAUSE I MIGHT NEED A NEW TRANSMISSION AT 65,000 NO LONGER UNDER WARRANTY. HOW CAN I PAY $38,000 AND IT GOES BAD INSTANTLY? NO HELP FROM FORD OR DEALER. MY GEARS ARE STALLING AND NOT SHIFTING CORRECTLY OR PICKING UP SPEED. I DRIVE LIKE AN OLD LADY AND TAKE CARE OF THIS CAR LIKE IT'S BRAND NEW. I WILL NEVER BUY A FORD AGAIN AND WILL TELL ANYONE WHO WILL LISTEN NOT TO DO THE SAME.

POWER STEERING LOCKED UP , WELL ITS ELECTRIC STEERING .AND THE WARRING LIGHTS CAME ON TERRAIN ASSIST AND HILL ASSIST DISABLED, SERVICE ADVANCE TRAC ,STEERING LOSS , I WAS TRAVELING ON THE FREEWAY DOING ABOUT 70 MILES AN HOUR WHEN THIS HAPPED I ALMOST LOSS CONTROL OF THE VEHICLE . THERE ARE SO MANY COMPLAINTS ABOUT THIS PROBLEM WITH THE FORD EXPLORE STEERING ISSUSE .

WHILE MOVING THE STEERING WHEEL THERE IS A WEIRD CLUNK/POP NOISE AND FEELS A BIT LOOSE. SO THIS IS CONCERNING 66,000 MILES ON MY VEHICLE. ALSO THE FRONT SUSPENSION IS VERY ROUGH AND I HAVE TAKEN VERY GOOD CARE. DEALERSHIP WAS NOT SURE WHAT IT WAS BUT STATED IT WAS SAFE

WHILE DRIVING 52MPH, CRUISE CONTROL SET, CLEAR WEATHER, RURAL ROAD, TRAVELING STRAIGHT - NO INCLINE OR DOWNHILL...THE VEHICLE SUDDENLY DOWNSHIFTED TO 2ND OR 1ST GEAR - THUS DECELERATING RAPIDLY. AFTER A MOMENT, IT WENT BACK TO BEING ABLE TO ACCELERATE AND MAINTAIN NORMALLY. 2016 EXPLORER SPORT WITH 44K MILES...I'VE HAD IT FOR ABOUT A MONTH.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE WAS PARKED INSIDE HIS GARAGE WHEN HE STARTED TO SMELL A HEAVY EXHAUST ODOR INSIDE AND OUTSIDE OF THE VEHICLE. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO DORSCH FORD LINCOLN KIA (2641 EATON RD, GREEN BAY, WI 54311, (920) 469-3000) TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE CATALYTIC CONVERTER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED COST ME $3,000 TO FIX BY CONSUMER'S MECHANIC. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 107,000.*DT*JB

WHILE I WAS DRIVING I STARTED TO GET A STRONG SMELL OF ROTTEN EGGS/SULFUR THAT FILLED THE CABIN. IT GOT SO STRONG THAT I HAD TO ROLL DOWN THE WINDOWS TO AIR IT OUT AND IT STARTED TO GIVE ME A HEADACHE. IT HAPPENED AGAIN WHILE DRIVING BACK TO MY HOME THAT SAME DAY. THE SMELL GOT SO STRONG IT STARTED TO MAKE ME DIZZY, NAUSEOUS AND GAVE ME A HEADACHE.

AIRBAG WARNING LIGHT ILLUMINATED ON VEHICLE. CHECKED ALL WIRES UNDER THE SEAT AND NONE ARE LOOSE OR DAMAGED. SEARCHED TOPIC ONLINE AND APPEARS TO BE A KNOWN ISSUE. FORD ISSUED A SERVICE BULLETIN FOR THE REPAIRS BUT WILL NOT COVER UNDER WARRANTY OR ISSUE RECALL. THIS IS A SAFETY ISSUE AS THE AIRBAGS WILL NOT DEPLOY WHEN THIS LIGHT IS ILLUMINATED.

THE STEERING WHEEL LOCKED WHILE WE WERE DRIVING IN THE CAR. WE TURNED LEFT INTO THE GROCERY STORE AND THEN BACK RIGHT TO ENTER A PARKING SPOT AND THE STEERING LOCKED AND WE ALMOST RAN INTO A PARKED CAR. LUCKILY WE SLAMMED ON THE BRAKES IN TIME TO AVOID AN ACCIDENT. WE HAD TO CRANK THE STEERING WHEEL ALL THE WAY TO THE RIGHT TO ALLOW IT TO "RELEASE" AND GIVE US SOME STEERING BACK...BUT AFTER THAT THE STEERING NOW CLICKS WHILE YOU TURN LEFT OR RIGHT BADLY. WE TOOK IT INTO OUR DEALER...THEY SAID IT IS THE STEERING GEAR MOTOR. THE CAR WAS IN THE SAME DEALERSHIP 1 WEEK PRIOR TO THIS GETTING AN OIL CHANGE AND NO SIGNS OF MALFUNCTION OR WEAR/TEAR...WITHOUT WARNING THE STEERING LOCKED UP ON US...VERY FRIGHTENING...OUR CAR IS 4 YEARS OLD AND ONLY HAS 16,000 MILES ON IT. AND THEY CANNOT EXPLAIN EXACTLY WHY IT HAPPENED. SO I AM UNSURE OF IF/WHEN IT HAPPENS AGAIN.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT THE SECOND-ROW MIDDLE SEAT FAILED TO UNLATCH AS DESIGNED. THE CONTACT STATED THAT HIS CHILD WAS CONFINED IN THE SEAT WHILE STRAPPED INTO THE SEAT BELT. THE CONTACT TOOK THE VEHICLE TO VAN DRUNEN FORD (3233 183RD ST, HOMEWOOD, IL 60430) AND WAS INFORMED THAT THERE WERE NO RECALLS ON THE VEHICLE AND WAS PROVIDED AN ESTIMATE FOR THE REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 60,600.

SOUNDED LIKE A POPPING OR CLUNK TYPE NOISE WHEN I TURNED THE WHEEL TO THE RIGHT FOR A WHILE THEN IT STARTED TO MAKE NOISE WHEN TURN THE WHEEL EITHER WAY. LOSING CONTROL DRIVING. READ ON THE NEWS, 1.2 MILLION EXPLORER RECALLED FOR THE STEERING ASSEMBLY RECALLED FOR SAME ISSUE BUT WHEN I CALL FORD THEY SAID THIS VIN WAS NOT PART OF RECALL. VERY DISAPPOINTED.

THE FIRST TIME MY STEERING GOT STIFF ON 09/13/2019 WHILE TRYING TO MAKE A LEFT TURN ON A CITY STREET. IN THE PROCESS OF MAKING THE LEFT TURN MY STEERING WHEEL GOT STIFF, AND THE STEERING FAULT HILL START AND TRAC LIGHT WENT ON. I WAS UNABLE TO CONTROL THE STEERING WHEEL WHICH CAUSE ME TO GET UP ONTO THE SIDE WALK AND ALMOST HITTING A TREE. I HAD TO SLAM ON MY BREAKS IN ORDER TO AVOID THE ACCIDENT. MY KIDS BODY JERK BACK AND FORTH REALLY HARD. I TURN MY CAR OFF AND BACK ON, AND THE STEERING WHEEL WAS WAS NO LONGER STIFF AND WORKING. I WAS ABLE TO DRIVE HOME. THE SECOND TIME STEERING WHEEL GOT STIFF WAS ON 10/05/2019. WHILE ON THE CURVE OF A RAMP TO GET OFF THE FREEWAY THE STEERING WHEEL GOT STIFF AGAIN AND THE STEERING FAULT, HILL START AND TRAC LIGHTS WENT ON AS WELL. ONCE AGAIN I HAD TO SLAM ON THE BREAKS IN OR. I DER TO AVOID HITTING THE RAILS, AS I WAS NOT ABLE TO CONTROL THE STEERING WHEEL. I TRY TURNING MY CAR OFF AND BACK ON AGAIN TO SEE IF MY STEERING WHEEL WOULD WORK AGAIN, BUT IT STILL DID NOT WORK. I HAD TO CALL MY HUSBAND TO COME PICK ME UP. I TOOK THE CAR TO THE DEALER AND I WAS TOLD THAT THEY H.AD TO REPLACE THE WHOLE POWER STEERING EQUIPMENT WHICH COST ME A TOTAL OF $2350.39

TWO SEPARATE FAILURE WITHIN A FOUR DAY TIME SPAN. COMPANY SOLD ME THE VEHIXAL SAID IT WAS A TIE ROD AND FIXED THE RIGHT PASSENGER REAR WHEEL. THE VEHICAL WAS REAL EASED TO ME TODAY WITH THE UNDERSTANDING THAT THE REAR SUSPENSION WAS FULLY REPAIRED. I HAD A HIGH SPEED ACCIDENT AFTER THE LEFT REAR TIR ROD BROKE AT A SPEED OF 80 MPH. DUE TO THE SUSPENSION BREAKAGE, THE CAR WENT OFF THE INTERSTATE AT HIGH SPEED. THE REAR END SUSPENSION HAD COMPLETE FAILURE AND THE AUTO DEALERSHIP RELEASED THE VEHICLE TO ME WITH THE FULL WITH ASSURANCE THE ISSUE WAS FIXED. THIS WAS A VERY SERIOUS INCIDENT WITH A POTENTIAL DEADLY OUTCOME.

POWER STEERING FAILED COMPLETELY ON MY 2016 FORD EXPLORER WHILE DRIVING. DASHBOARD LIT UP WITH A STEERING ASSIST FAULT, AND THEN HILL ASSIST FAULT. STEERING THE VEHICLE TO SAFETY WAS VERY CHALLEGING. I WAS TURNING AT A LEFT TURN LIGHT AND ALMOST CRASHED INTO ANOTHER VEHICLE BECAUSE I COULD NOT STEER THE CAR. LOOKED IT UP ONLINE AND HAVE FOUND NUMEROUS OTHER ACCOUNTS OF THE SAME ISSUE WITH NO REPSONSE OR RECALL FROM FORD.

WHILE DRIVING THE TRACTION CONTROL AND ABS LIGHTS COME ON. SYSTEM HAS STABILITY CONTROL WARNING. WHILE DRIVING THIS CAUSES BRAKES TO LOCK UP. MY WIFE ALMOST CRASHED DUE TO THE BRAKES LOCKING. ONCE YOU TURN OFF THE CAR IT WILL RESET AND EVERYTHING APPEARS NORMAL UNTIL IT HAPPENS AGAIN. UNFORTUNATELY THIS INCIDENT DOES NOT STORE ANY CODES IN THE SYSTEM. WE HAVE HAD THE 2016 EXPOLORER IN THE SHOP MULTIPLE TIMES AND THE DEALERSHIPS HAVE DONE NOTHING TO FIX THE ISSUE. BECAUSE THERE ARE NO CODES THEY ARE DOING NOTHING. THEY DO NOT RESEARCH THE ISSUE NOR HAVE THEY TRIED TO FIX ANYTHING. THERE ARE MULTIPLE COMPLAINTS ABOUT THIS AND A PROCEDURE NEEDS TO BE ESTABLISHED TO DIAGNOSE AND FIX THE PROBLEM. THIS IS A SERIOUS SAFETY ISSUE AND NEEDS TO BE ADDRESSED BY FORD BEFORE SOMEONE DIES. MY WIFE WILL NO LONGER DRIVE THIS VEHICLE BECAUSE SHE FEEL UNSAFE.

MY TIRE VALVE CORRODED AFTER 3 YEARS WITH THE CAR. WHICH CAUSED DAMAGE TO THE TIRE AND THE TIRE PRESSURE SENSOR. THE POWER STEERING WENT AT 67000 MILES. IT STOPPED WORKING COMPLETELY WHILE DRIVING, EXTREMELY SCARY. THE SERVICE DEPARTMENT AT THE DEALERSHIP SAID IT IS JUST SOMETHING THAT HAPPENS. $2400 FIX ON A 4 YEAR OLD CAR WITH 67000 MILES AND COULD HAVE CAUSED AN ACCIDENT.