2016 Ford Explorer complaints

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING, THE VEHICLE SURGED BETWEEN GEARS AND DECELERATED BEFORE OPERATING AS DESIGNED. THE CONTACT ALSO STATED THAT AFTER THE VEHICLE REVERSED OUT OF THE DRIVEWAY AND SHIFTED INTO DRIVE, AN ABNORMAL CLUNKING NOISE WAS HEARD UNDERNEATH THE VEHICLE. THE CONTACT STATED THAT THE FAILURES WERE NOTICED DURING A TEST DRIVE PRIOR TO PURCHASING THE VEHICLE HOWEVER, THE TECHNICIAN AT THE GRIECO FORD OF RAYNHAM LOCATED AT 1651 NEW STATE HWY, RAYNHAM, MA, 02767, INFORMED THE CONTACT THAT THERE WAS NO PROBLEM WITH THE VEHICLE. THE CONTACT STATED THAT THE FAILURE RECURRED AFTER THE VEHICLE WAS PURCHASED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE WAS NOT DIAGNOSED NOR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 45,000.

I HAD THE REAR TOE LINKS REPLACED DUE TO A SAFETY RECALL DECEMBER 2, 2019. ON 09/27/20, I WAS RETURNING HOME AFTER DROPPING MY KIDS OFF TRAVELING 70 MPH ON A HIGHWAY, WHEN THE RECAL PART I HAD REPLACED LESS THAN A YEAR AGO BREAK. THIS CAUSED ME TO LOSE CONTROL AND HAVE AN ACCIDENT. I NOTIFIED FORD OF THIS 09/28/20 AND I WAS INFORMED THAT THE RECAL WAS COMPLETED, NOTHING THEY COULD DO. I INFORMED THEM THE PART BROKE AT THE WELD WHICH IS A DEFECTIVE PART. AGAIN, I WAS TOLD OT THEIR PROBLEM. THIS HAS CAUSED MY VEHICLE TO TO BE TOWED , DAMAGE TO THE REAR BUMPER AND MYSELF BUYING A NEW PART OUT OF POCKET TO GET VEHICLE ON ROAD AGAIN TO GO TO WORK. THIS IS ALSO ANY OTHER PROBLEMS THAT IT MAY HAVE CAUSED DUE TO STRESS ON VEHICLE, LIKE OTHER TOE LINK, TIRES, BRAKES, OTHER SUSPENSION PARTS. ENCLOSED IS PART AND PART NUMBER THAT WAS THE RECAL PART REPLACED BY A FORD DEALERSHIP AND DAMAGE TO VEHICLE. I WAS LUCKY I DID NOT HIT THE OTHER VEHICLES AROUND ME, HIT HEAD ON WITH CENTER DIVIDER OR GUARDRAIL, ROLL THE VEHICLE OR HAVE SERIOUS INJURY.

STEERING WOULD LOCK UP AND YOU WOULD HAVE TO FORCE THE STEERING BACK TO DRIVE ABILITY. THE RACK AND PINION WAS WORN OUT, IN MY OPINION PREMATURELY. THIS HAPPENED WHILE THE VEHICLE WAS IN MOTION. THE FIRST TIME IT WAS NOTICE WAS ON HIGHWAY DRIVING IN A CONSTRUCTION ZONE. THE STEERING WOULD CATCH WHEN TURNING LEFT OR RIGHT AND YOU WOULD HAVE TO FORCE THE WHEEL TO STRAIGHTEN OUT THE VEHICLE.

STEERING WHEEL IS STIFF AND MAKES NOISE WHEN TURNING.

EVEN UNDER WARRANTY THERE WERE SPORADIC TIMES THE FRONT SUSPENSION/STEERING WOULD MAKE A LOAD THUMP NOISE. THIS USUALLY HAPPENED WHEN BACKING OUT OF THE DRIVEWAY AND SOMETIMES WHEN PULLING OUT OF A PARKING SPACE. THE DEALER COULD NEVER DUPLICATE THE NOISE SO THEY FOUND NOTHING WRONG WITH IT. NOW AT 48K MILES AND OUT OF WARRANTY THE SOUND HAPPENS MUCH MORE OFTEN. MY WIFE SAID ONCE THE STEERING APPEARED TO MOMENTARILY LOCK UP AND HAD TO PULL THE STEERING WHEEL PRETTY HARD TO FREE IT UP. I FOUND SEVERAL OTHER INTERNET SITES STATING THAT THE STEERING SYSTEM IS NEEDING REPLACED ON MANY EXPLORERS WITH RELATIVELY LOW MILES AT A COST TO THE OWNERS OF OVER $2000.

POWER LOCKS GET STUCK ON EITHER LOCK OR UNLOCKED NOT ALLOWING ME TO EITHER LOCK OR UNLOCK THE CAR DOOR ON DRIVER AND BACK PASSENGER DOOR. PLASTIC STRIPPING PANELS ON FRONT DRIVER AND PASSENGER DOORS ARE COMING OFF AND THE PANELS CONNECTED TO THE WINDSHIELD ON BOTH SIDES. POWER SEATS DO NOT HOLD THE MEMORY OF WHERE IT WAS LEFT. THE SEAT GOES ALL THE WAY UP TO THE STEERING WHEEL WHEN MEMORY BUTTONS ARE PRESSED OR IF THE KEYLESS CODE ON THE DOOR IS USED TO UNLOCKED THE CAR. KEYLESS ENTRY WILL UNLOCK WITHOUT TO CODE BEING TYPED IN CORRECTLY. USING THE FIRST THREE NUMBERS CAN UNLOCK THE DOOR. ALL OF THESE THINGS HAPPEN WILL THE CAR IS STATIONARY.

WHEN TURNING RIGHT AT A SLOW SPEED, HEAVY KNOCKING/THUMPING NOISE AND STEERING WAS JERKY. VEHICLE HAS 33,400 MILES. HAD IT REPAIRED AT THE FORD DEALERSHIP YESTERDAY AND THEY REPLACED THE RACK AND PINION AT A COST OF $1800. SINCE I READ THIS SEEMS TO BE A COMMON PROBLEM I ASKED IF THIS ISSUE HAS BEEN RECALLED AND WAS INFORMED IT WAS NOT.

PER FORD WEBSITE, I WAS TOLD THAT MY SYNC SOFTWARE NEED AN UPGRADE WHEN I TYPED IN THE VIN, THEN I FOLLOW THE INSTRUCTION ON WEBSITE BUT THE PROGRAM I DOWNLOADED MESSED UP MY APIM MODULE ON MY CAR AND RADIO, GPS, AND OTHER FUNCTION AE NOT WORKING. SO I TOOK MY SUV TO THE DEALER AND THEY SAID IT WILL COST ME $1050 TO FIX THE ISSUE.

STARTED HAVING ISSUES WITH THE STEERING AT 39,500 MILES. SOUNDED LIKE A POPPING OR CLUNK TYPE NOISE WHEN I TURNED THE WHEEL TO THE RIGHT. I TOOK IT TO FORD DEALERSHIP WHO INDICATED THE WHOLE STEERING ASSEMBLY NEEDED TO BE REPLACED. THIS CAR WAS BUILT AT THE CHICAGO PLANT LIKE ALL THE OTHER EXPLORERS THAT NEEDED THE STEERING ASSEMBLY REPLACED. FORD INDICATED THIS VIN WAS NOT PART OF RECALL.

I HAVE A 2016 FORD EXPLORER WITH 94,000 MILES. WE NOTICED THAT THE AC WAS BLOWING HOT AIR SO WE TOOK THE CAR IN FOR A REPAIR ON 9/8/2020. THE DEALERSHIP CALLED US BACK TO INFORM US THAT THE WATER PUMP HAD FAILED WHICH CAUSED ANTIFREEZE TO LEAK INTO AND ON THE AC COMPRESSOR CAUSING IT TO FAIL. WE WERE QUOTED A PRICE OF $2600.00 FOR THE REPAIR THE WATER PUMP. I WAS ALSO TOLD THAT MANY POLICE CRUISERS WITH THE SAME MOTOR ARE HAVING THE SAME ISSUE. FORD RECOMMENDS THAT THE WATER PUMP BE REPLACED AT 150000 MILES' THE MILES ON THE SUV ARE HIGHWAY MILES.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE STEERING WHEEL FAILED. THE DRIVER KEPT THE STEERING WHEEL UNDER CONTROL AND MOVE INTO THE SLOW LANE WHILE CONTINUING TO DRIVE. THE CONTACT STATED THAT THE STEERING SYSTEM FAILURE WARNING LIGHT ILLUMINATED ON THE INSTRUMENTAL PANEL WHEN THE FAILURE OCCURRED. THE VEHICLE WAS TOWED TO LEWIS J C FORD (9505 ABERCORN STREET SAVANNAH, GEORGIA, 31406, (912)-210-5677) TO BE DIAGNOSED. THE MECHANIC LOCATED THE FAILURE AT THE STEERING WHEEL RACK AND PINION. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 65,000.*DT*JB

INITIAL ISSUES WAS AN ISSUES ACCELERATING. WHEN ACCELERATING TO 3000 RPM, THE RPMS WOULD SUDDENLY DROP BACK TO 2 AND THE CAR WOULD LURCH. STARTED EXPERIENCING ISSUES WHEN SLOWLY DECELERATING LIKE GEARS WOULD NOT ENGAGE CORRECTLY. WHEN STARTING THE CAR AND SHIFTING INTO DRIVE, THE CAR LURCHED FORWARD WITH A GRIND AND THE WRENCH DASH LIGHT CAME ON.

STEERING STARTED MAKING A GRINDING NOISE TURNING LEFT OR RIGHT. INTERMITTENT SEVERE PULLING TO THE LEFT OR TURNING FROM LEFT TO RIGHT. HAPPENS AT LOW OR HIGH SPEED. STARTED ABOUT 58K MILES. CAR IS UNSAFE AND UN-DRIVABLE IN THIS CONDITION. ADVISED THE RACK AND PINION IS BAD AND NEEDS TO BE REPLACED AT APPROX $2000.

STARTED DRIVING AND RECEIVED A WARNING ON THE SCREEN SAYING "STEERING FAULT SERVICE NOW". LOTS POWER STEERING CONTROL. THANKFULLY WAS AT A LOW SPEED AND COULD STOP SAFELY BEFORE LEAVING OUR NEIGHBORHOOD. PUT VEHICLE IN PARK, POWERED OFF, POWERED BACK ON, AND WAS ABLE TO DRIVE AGAIN. VEHICLE HAS 56K MILES ON IT.

WHILE MAKING TURNS EITHER AT SLOW SPEEDS OR AT A COMPLETE STOP, THE STEERING MAKES POPPING SOUNDS. STEERING WHEEL ALSO LOCKS FOR HALF A SECOND. TOOK VEHICLE TO A SHOP AND WAS ADVISED IT WAS THE RACK AND PINION ON THE FRONT RIGHT TIRE AREA. THE VEHICLE IS A 2016 AND HAS 41K MILES. THIS ISSUE BEGAN MANIFESTING APPROXIMATELY TWO WEEKS PRIOR. ESTIMATED COST TO REPAIR IS $2500. ACCORDING TO VEHICLE FORUMS THIS IS A COMMON ISSUE WITH THIS VEHICLE MAKE AND MODEL.

MY WIFE WAS DRIVING DOWN THE ROAD WHEN THE STEERING QUIT. IT WAS PULLING FROM SIDE TO SIDE AND SHE ALMOST LOST CONTROL. STEERING FAILURE ALARMS WERE CONTINUING TO GO OFF. SHE WAS ABLE TO GET THE VEHICLE OFF THE ROADWAY AND AVOID A CRASH.

NOT LONG AFTER PURCHASING THE VEHICLE FROM A DEALERSHIP I WAS DRIVING DOWN THE HIGHWAY WITH MY FAMILY WHEN THE DRIVER WINDSHIELD PILLAR MOLD FLYS OFF MY VEHICLE AND INTO TRAFFIC BEHIND ME. A FEW WEEKS OR SO LATER THE SAME THING HAPPENED TO THE PASSENGER SIDE. I WAS LOOKING ONLINE FOR PARTS AND NOTICED MANY PEOPLE COMPLAINING ABOUT THIS ISSUE.

THE ENTIRE AIR CONDITIONING SYSTEM HAS CORROSION AND RUSTED COMPLETELY OUT. THIS VEHICLE IS ONLY 4 YEARS OLD. IT SHOULD NOT BE RUSTED BEYOND REPAIR. THIS ENTIRE SYSTEM IS VERY COSTLY. THERE IS A LEAK AT THE REAR EVAPORATOR HOUSING CONNECTION.

POWER STEERING WENT ON A 2016 FORD EXPLORER XLT WITH 57001 MILES ON IT. CHARGED FOR STEERING RACK/BOX REPLACEMENT PLUS OTHER ASTRONOMICAL FEES ASSOCIATED WITH IT OUT OF POCKET. THE VEHICLE IS SUPPOSED TO BE A FAMILY CAR. IT IS UNSAFE AND HASN'T BEEN THE SAME SINCE. CAR JUST GAVE OUT ON HIGHWAY WITH CHILDREN IN CAR. THE CAR STARTED TO ACTIVELY SWAY ALL OVER THE ROAD WITHOUT WARNING. NO CONTROL. HAD TO PULL OVER. CALLED FOR ASSISTANCE AND THAN RESTARTED THE CAR TO HAVE NO POWER STEERING WHAT SO EVER. IT WAS WORSE THAN TRYING TO DRIVE A HEAVY DUTY TRUCK. AS A FEMALE, I COULD NOT EVEN TURN THE STEERING WHEEL. NO CODES CAME UP PRIOR; UNTIL THE RESTART OF THE CAR. ???? DEALER TOOK WEEK TO GET IT IN PLUS A DAY FOR PART AND THOUSANDS OUT OF MY POCKET DURING A WORLD WIDE PANDEMIC. WITH MASSIVE AMOUNTS OF PEOPLE COMPLAINING ABOUT THIS ISSUE WHY HASN'T IT BEEN RECALLED? THIS IS INCREDIBLY DANGEROUS.

THE VEHICLE WAS IN MOTION ON A STATE HIGHWAY WHEN THE FOLLOWING WARNING MESSAGES WERE DISPLAYED STEERING ASSIST FAULT SERVICE REQUIRED, HILL START ASSIST NOT AVAILABLE, SERVICE ADVANCE TRAC, TERRAIN MANAGEMENT SYSTEM FAULT. AT THIS POINT I HAD COMPLETE LOSS OF POWER STEERING. I WAS ABLE TO PULL TO THE SIDE OF THE ROAD SAFELY AND HAD TO HAVE TOWED TO THE FORD DEALER IN MY TOWN WHICH IS WAS 2 HOURS AWAY. FORD DEALERSHIP DIAGNOSED THE PROBLEM AS POWER STEERING CONTROL MODULE.WHICH IS INTEGRAL WITH THE RACK AND PINION ASSEMBLY. COST OF REPAIR IS 2400.00 OF COURSE I HAVE A LIFETIME WARRANTY ON MOST PARTS INCLUDING FUEL PUMP, ENGINE ,TRANSMISSION BUT RACK AND PINION NOT CONSIDERED UNDER THIS WARRANTY. *TR

TL* THE CONTACT OWNS A 2016 FORD EXPLORER EQUIP WITH HANKOOK VENTUS S1 NOBLE 2; TIRE SIZE: 255/50R20-108H AND THE DOT NUMBER: 5MNC 1A H0118. THE CONTACT STATED THAT WHILE INSPECTING THE TIRES, IT WAS DISCOVERED THAT THE TIRES HAD EXPERIENCED CRACKING AND GUDGES ON THE INSIDE AND OUTSIDE OF THE TIRES. THE FAILURE WAS PRESENT ON ALL FOUR TIRES. THE CONTACT ALSO INDICATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD SHAKE AND VIBRATE. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER AUTONATION FORD LOCATED AT 7700 BLANDING BLVD, JACKSONVILLE, FL 32244 WHO REPLACED ALL FOUR TIRES WITH THE SAME BRAND SIZE AND MODEL TIRES BUT APPROXIMATELY 13,000 MILES LATER THE SAME FAILURE HAD OCCURRED. THE CONTACT WAS UNABLE TO REACH OUT TO THE MANUFACTURER IN REFERENCE TO THE FAILURES. THE VEHICLE FAILURE MILEAGE WAS 18,000 AND THE FAILURE TIRE MILEAGE WAS NOT AVAILABLE. THE VIN WAS NOT AVAILABLE.

I WAS DRIVING HOME FROM DROPPING MY DAUGHTER OFF AT DAYCARE AND I LOST THE POWER STEERING ON MY VEHICLE WHILE THE VEHICLE WAS IN MOTION AND I WAS DRIVING A STEADY SPEED DOWN A STRAIGHT ROAD. MY DAUGHTER WAS NO LONGER IN THE CAR WITH ME AS THIS COULD HAVE RESULTED IN AN ACCIDENT BUT THANKFULLY SHE WAS NOT AND I WAS ABLE TO PULL OFF THE ROAD WITH A LOT OF EFFORT INVOLVED. MY CAR HAD TO BE TOWED TO THE FORD SHOP AND I HAD TO HAVE MY POWER STEERING CORE CHANGED. $2500. THIS CAR ONLY HAS 37,000 MILES AND IS A 2016 FORD EXPLORER. QUITE FRUSTRATING, DISAPPOINTING AND EXPENSIVE. THERE NEEDS TO BE A RECALL WITH THIS PROBLEM BECAUSE I AM NOT THE ONLY ONE THIS HAS HAPPENED TOO.

NOTICED PROBLEM WITH STEERING. WHEN I CHANGED LANES THE VEHICLE CONTINUED IN THAT DIRECTION UNTIL I CORRECTED IT. THIS HAPPENED SEVERAL TIMES WHILE DRIVING HOME FROM WORK SO I WENT STRAIGHT TO MATT BOWERS FORD IN METAIRIE. I WAS TOLD THE STEERING GEAR NEEDED TO BE REPLACED, THE MODULE REPROGRAMMED AND AN ALIGNMENT. I'VE SEEN QUITE A FEW RECALLS CONCERNING THIS BUT WAS NOT TOLD THAT MY VHEICLE VIN WAS NOT AFFECTED. I NOW SEE MANY PEOPLE ARE COMPLAINING OF THE SAME PROBLEMS. THIS SHOULD BE LOOKED AT CAREFULLY BEFORE SOMEONE GETS HURT.

THE VEHICLE WAS IN MOTION ON A STATE HIGHWAY WHEN THE FOLLOWING WARNING MESSAGES WERE DISPLAYED STEERING ASSIST FAULT SERVICE REQUIRED, HILL START ASSIST NOT AVAILABLE, SERVICE ADVANCE TRAC, TERRAIN MANAGEMENT SYSTEM FAULT. AT THIS POINT I HAD COMPLETE LOSS OF POWER STEERING. I WAS ABLE TO PULL TO THE SIDE OF THE ROAD SAFELY AND HAD TO HAVE TOWED. LOCAL FORD DEALERSHIP DIAGNOSED THE PROBLEM AS POWER STEERING CONTROL MODULE.WHICH IS INTEGRAL WITH THE RACK AND PINION ASSEMBLY.

I WAS TURNING INTO A GAS STATION AND THE POWER STEERING WENT OUT WITH NO PREVIOUS WARNINGS OR ISSUES.

BROKEN TOE LINK. FORD REFUSING TO RECOGNIZE IT AS A FAILURE UNDER FORD RECALL 19S17. THEY SAY IT WAS REPAIRED UNDER FORD RECALL 17S11. REAR DRIVER SIDE TOE LINK BROKE 7/25/20 WHEN GOING OVER A RAILROAD GRADE CROSSING. OEM REPLACEMENT PART PURCHASED FROM FORD DEALER BROKE 8/24/20 TURNING GENTLY TO THE LEFT. ATTACHED PICTURE IS THE ORIGINAL LINK THAT BROKE 7/25/20. REPLACEMENT PART BOUGHT THROUGH FORD DEALER BROKE IN APPROXIMATELY THE SAME AREA.

LOSS OF STEERING WHILE DRIVING. NEARLY CAUSED A 4 CAR COLLISION. STEERING WHEEL LOCKED WHILE DRIVING 57 MPH. WAS BARELY ABLE TO SLOW DOWN AND PULL OFF TO THE SIDE. THIS HAS HAPPENED MULTIPLE TIMES, HOWEVER AFTER THIS LAST TIME, THE STEERING WHEEL IS PERMANENTLY LOCKED. STEERING LOSS LIGHT CAME ON AFTERWARDS.

WHILE DRIVING ON TRIPS OVER 30 MINUTES I EXPERIENCE HEADACHES, NAUSEOUS AND FATIGUE. I HAVE AN APPOINTMENT WITH FORD DEALER ON AUGUST 27, 2020

I OWN A 2016 FORD EXPLORER WHICH HAS 78,146 MILES AND WHILE DRIVING THE ENGINE LIGHT CAME ON AND THE VEHICLE STALLED WITHOUT WARNING. I HAD TO PUT MY CAR IN NEUTRAL AND COAST TO THE SIDE OF THE ROAD WITH MY CHILDREN IN THE CAR. I JUST PURCHASED THIS VEHICLE FROM EVERETT FORD IN BENTON, ARKANSAS LESS THAN A YEAR AGO AND HAVE HAD NORMAL ROUTINE MAINTENANCE COMPLETED ACCORDING THE THE OWNERS MANUAL. AFTER HAVING A MECHANIC TAKE A LOOK IT IS A RESULT OF A FAULTY WATER PUMP IN WHICH I WAS QUOTED $2500-$3500 FOR A REPLACEMENT IN ADDITION THE ENGINE WOULD BE SEVERAL THOUSAND. THE PROBLEM IS THAT THE WATER PUMP IS INSIDE THE ENGINE AND SO WHEN THE WATER PUMP FAILS IT DESTROYS THE ENGINE WITHOUT WARNING BY MIXING THE COOLANT WITH THE ENGINE OIL. AFTER LOOKING INTO THIS FURTHER THE DEALERSHIP AND THE MANUFACTURER WERE AWARE OF THIS MECHANICAL DEFECT AND THE THOUSANDS OF CUSTOMERS THAT WERE AFFECTED BUT CONTINUE TO ADVERTISE 'BUILT FORD TOUGH'TO DRIVE SALES AND DID NOT WARN CUSTOMERS OR MAKE THEM AWARE. THIS IS A SAFETY CONCERN FOR ALL OWNERS OF THE FORD DURATEC V6 ENGINE AND THERE SHOULD BE A FORCED RECALL BY THE NATIONAL HIGHWAY SAFETY ADMINISTRATION. DO NOT WAIT FOR THERE TO BE DEATHS FROM THIS MECHANICAL DEFECT BEFORE TAKING ACTION. FORD SHOULD TAKE RESPONSIBILITY. I AM A LOYAL CUSTOMER OF FORD BUT WILL BE GETTING RID OF MY VEHICLE AND MAKING SURE ALL FORD OWNERS ARE AWARE AND YOU CANNOT TRUST FORD WHEN THEY ARE AWARE OF A SAFETY RELATED MECHANICAL FAILURE AND THEY ARE NOT TAKING RE

THERE IS AN AIRBAG WARNING LIGHT ON THE DASHBOARD. IT IS DUE TO A CIRCUIT FAILURE OR A BROKEN CORD LEADING TO THE DRIVER SIDE MIDDLE ROW SEATBELT AIRBAG. THIS IS NOT NORMAL WEAR AND TEAR BUT A SAFETY ITEM DESIGN BY FORD THAT HAS FAILED IN THE VEHICLE. THE FORD DEALERSHIP SERVICE DEPARTMENT DOES NOT KNOW HOW THIS SAFETY FEATURE BROKE. IF WE WERE TO GET IN AN ACCIDENT WHILE THE AIRBAG IS IN THIS STATE, IT WOULD NOT DEPLOY AND PUT MY PASSENGERS LIFE IN MORE JEOPARDY.

STEERING WAS GETTING DIFFICULT WHILE MAKING TURNS. TOOK IT TO A FORD DEALER AND WAS TOLD THE RACK & PINION NEED TO BE REPLACED FOR $2,560 AND IT IS UNSAFE TO DRIVE. FORD IS NOT COVERING THIS ISSUE EVEN THOUGH IT IS A FAULTY PART ON THEIR END AND SHOULD BE THEIR RESPONSIBILITY.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE THE ENGINE COOLANT OVER TEMPERATURE MESSAGE WAS DISPLAYED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT A FLUID LEAK WAS PRESENT BEHIND THE WATER PUMP. THE VEHICLE WAS NOT REPAIRED. THE LOCAL DEALER MCGOVERN FORD LOCATED AT 1212 WESTFORD ST, LOWELL, MA 01851 AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 16V183000 (ENGINE, ENGINE COOLING). THE CONTACT STATED THAT THE VEHICLE HAD EXPERIENCED THE SAME FAILURE LISTED IN THE RECALL. THE FAILURE MILEAGE WAS 99,000.

I WAS DRIVING ON THE HIGHWAY 65 IN HAM LAKE, MN SEVERAL WEEKS AGO WHEN I SUDDENLY LOST CONTROL OF THE STEERING. THE VEHICLE LUNGED TO THE LEFT TOWARDS THE DITCH. I WAS ABLE TO FISHTAIL IT BACK ONTO THE ROAD, ALMOST ROLLED THE VEHICLE AND BARELY KEPT IT UNDER CONTROL. I GOT OVER TO THE RIGHT SHOULDER AND CALL THE ANOKA COUNTY SHERIFF FOR ASSISTANCE. A DEPUTY ASSISTED BUT I DON'T BELIEVE A FORMAL POLICE REPORT WAS FILED. THIS WAS SUNDAY JULY 19TH. WE WERE ABLE TO GET TO LOCAL MECHANIC WHO LOOKED AT IT THE FOLLOW DAY AND DETERMINED THAT THE TOE CONTROL LINK HAD BROKEN. THEY REPAIRED IT WITH A NEW PART FROM THE LOCAL FORD DEALERSHIP AND THE VEHICLE SEEMED FINE. LAST NIGHT THE NEW PART THAT THEY INSTALLED BROKE AS WELL. I LOOKED ONLINE AND SEE THAT THERE IS A RECALL FOR THIS EXACT PART, THE TOE CONTROL LINK ON 2011-2017 FORD EXPLORERS. I CHECKED THE VIN ON THE NTSB WEBSITE BUT IT INDICATES THAT OUR CAR IS NOT INCLUDED IN THE RECALL. WE HAD BROUGHT THE CAR INTO METROPOLITAN FORD IN EDEN PRAIRIE EARLIER IN THE YEAR FOR OTHER RECALL ISSUES. HAD THE RECALL BEEN COMPREHENSIVE, THIS WOULD HAVE BEEN CAUGHT AND FIXED. AT 65 MPH, MY DAUGHTER AND I SHOULD HAVE BOTH BEEN KILLED IN THE ORIGINAL INCIDENT. IT HAD BEEN SEVERAL WEEKS SINCE THE (NEAR) ACCIDENT AND WE ARE STILL SHAKEN UP BY IT. FORTUNATELY, LAST NIGHT'S INCIDENT WAS AT MUCH SLOWER SPEED. I AM FEARFUL THAT THERE ARE OTHER FAMILIES WHOSE LIVES IN DANGER AS WELL. I HAVE A PHOTO THAT I TOOK OF THE CURRENT (SECOND) BREAK THAT OCCURRED T

I INITIALLY HAD 'STEERING FAULT' ALERT A FEW MONTHS AGO. JUST TODAY A 'TERRAIN MAINTENANCE FAULT' ALERT CAME UP WITH A FEW ALERTS ICONS ON THE DASHBOARD. THE STEERING FROZE TO THE POINT I COULD ONLY MOVE THE STEERING WHEEL AN INCH WHILE MUSCLING IT TO A STOP. APPARENTLY, ACCORDING TO THE DEALERSHIP, THIS IS A KNOW ISSUE. THEY HAD ME RESTART THE SUV AND THAT TEMPORARILY SOLVED THE ISSUE, BUT IT COULD HAPPEN AGAIN AT ANYTIME. THE DEALERSHIP SAID, IF THE ISSUE ISN'T OCCURRING WHEN I BRING THE SUV IN THEY CAN'T SPECIFICALLY DIAGNOSE THE PROBLEM, BUT MORE THAN LIKELY THE STEERING GEAR NEEDS TO BE REPLACE FOR ~$2K. AS I AM READING OTHERS, THIS IS AN ONGOING ISSUE THAT COULD PUT DRIVERS IN DANGER AND HAVE FOR OTHERS. I WAS IN MARSHFIELD, MA WHEN THIS HAPPENED, DRIVING 30 MPH APPROXIMATELY 2PM ON PLAIN STREET.

PASSENGER SIDE WINDSHIELD TRIM MOLDING FLEW OFF WHILE DRIVING. DRIVER SIDE DOOR TRIM PANEL LOOSE.

THE FLUIDITY OF THE STEERING IS DETERIORATING. WHEN TURNING THE WHEEL RIGHT OR LEFT THERE IS A GRINDING SOUND OF METAL ON METAL. INTERMITTENTLY I HAVE TO WRESTLE WITH THE STEERING WHEEL WHEN ACCELERATING THROUGH A TURN WHICH IS A MAJOR SAFETY CONCERN I HAVE AS I TYPICALLY AM TRAVELING WITH TWO YOUNG CHILDREN. THE PROBLEM HAS ARISEN IN THE PAST THREE MONTHS AND THE MECHANIC I UTILIZE, WHO DOES NOT REPAIR STEERING RACKS, REPORTED THAT THE COST OF ADDRESSING THE ISSUE COULD EXCEED $1000. THIS PROBLEM SHOULD NOT BE ASSOCIATED WITH A 2016 MODEL THAT JUST WENT OVER 50,000 MILES AND IS NOT SUBJECTED TO ROUGH, EXTENDED DRIVING BUT RATHER MOST DAYS ARE A 28 MILE ROUND TRIP FOR WORK.

THIS CAR HAS EXTREMELY BAD SWAY IN THE REAR END, IT CANNOT BE DRIVEN OVER 40 MPH OR YOU WILL LOSE TOTAL CONTROL OF THE VEHICLE

49000 MILES, ELECTRONIC STEERING IS STARTING TO GO OUT. WHEN DRIVING MODERATE SPEEDS CAR MAKES LOUD AUDIBLE NOISES ESPECIALLY WHEN TURNING THE WHEEL. RACK AND PINION WILL NEED TO BE REPLACED. FORD TOLD ME IT WAS 100% SAFE TO DRIVE. TOOK TO INDEPENDENT MECHANIC WHO SAID THE EXACT OPPOSITE AND SHOULD BE REPLACED BEFORE IT GOES OUT HEAVEN FORBID AT HIGH SPEEDS.FAMILY OF 4 YOUNG KIDS, THIS IS SUPPOSED TO BE A SAFE, FAMILY CAR. FORD IS PUTTING A LOT OF FAMILIES AT RISK NOT RECALLING THIS. THIS CAR ONLY HAS 49K MILES. THEY ARE LOSING LOTS OF RETURN CUSTOMERS BY NOT HANDLING A SAFETY ISSUE PROPERLY. I HOPE NO DEATHS HAVE TO HAPPEN TO BRING MORE SEVERITY TO THIS PRESSING ISSUE. IF YOU HEAR A CLICK WHEN STEERING, GET THE CAR INSPECTED ASAP! CLICKING OCCURS WHEN STATIONARY AND IS MORE INTENSE WHEN DRIVING. IT COULD GO OUT AT ANY MOMENT.

OUR 2016 FORD EXPLORER WITH ONLY 50K MILES STARTED TO HAVE VERY STICKY STEERING AND IT WOULD MAKE SOME CLUNKING NOISES WHEN TURNING. THIS PROGRESSIVELY GOT WORSE WHILE MY PREGNANT WIFE USED THE SUV AS A DAILY DRIVE UNTIL ONE DAY SHE SAID SHE NEARLY LOST CONTROL OF THE FORD AND HAD TO SWERVE OFF THE ROAD TO AVOID HITTING ONCOMING TRAFFIC. WE TOOK THE VEHICLE INTO HAROLD ZEIGLER FORD IN LOWELL, MI AND THEY SAID THAT THE ELECTRONIC STEERING GEAR HAD GONE BAD AND NEEDED TO BE REPLACED. THAT MEANS REPLACING THE ENTIRE STEERING ASSEMBLY WHICH IS A $2,200+ REPAIR. THAT IS WAY TO SERIOUS OF A REPAIR TO HAPPEN SO OFTEN AND THIS EARLY. BASED ON THE MANY SIMILAR ISSUES I HAVE READ ABOUT REGARDING THIS ISSUE AND THE FACT THAT FORD ALREADY HAD A SIMILAR RECALL FOR EARLIER YEARS OF THE EXPLORER, THIS NEEDS TO BE RECALLED. SOMEONE WILL GET HURT AND FORD IS JUST TRYING TO SAVE MONEY BY NOT ADDRESSING IT. THE WORST PART IS THAT THERE SEEMS TO BE NO GUARANTEE THAT IT WON'T HAPPEN AGAIN IN 50K MORE MILES.

EXHAUST IS GETTING INTO THE CAB OF VEHICLE WHEN UNDER MODERATE ACCELERATION TO PASS VEHICLES AND WHEN THE WINDOW OR WINDOWS ARE OPEN IT IS EVEN WORSE.

WHILE DRIVING AT 75 MPH THE VEHICLE EXPERIENCED A LOSS OF POWER STEERING, THE WHEEL JERKED AND I ALMOST RAN OFF THE ROAD. THEN THE STEERING MADE GRINDING NOISES. THE DEALERSHIP WANTS $1500 FOR THE PART AND JUST AS MUCH OR MORE FOR THE LABOR, NOT COVERED UNDER WARRANTY AND THE VEHICLE ONLY HAS APPROXIMATELY 77000 MILES ON IT.

THE RACK & PINION MOTOR FAILED ON THIS VEHICLE AFTER ONLY APPROXIMATELY 40,000 MILES. IN THIS INSTANCE IT DID NOT CAUSE AN ACCIDENT. HOWEVER, I UNDERSTAND THAT THESE MOTORS ARE FAILING AT A RELATIVELY HIGH RATE AND STEERING COULD LOCK UP IN THESE VEHICLES WHILE DRIVING.

THIS TRUCK HAS HAD ISSUES SINCE I BOUGHT IT LIKE 5 MONTHS AGO FROM CARMAX WITHIN THAT TIME I REALLY ONLY HAD IT A MONTH REST OF TIME IT HAS BEEN IN THE SHOP I BOUGHT WITH 26K MILES FROM CARMAX ALREADY HAD REBUILT ENGINE BREAKS ROADERS STILL HAVE ENGINE ISSUES NOW TODAY BELT BROKE AND NEEDS TO BE TOWED I SHOULD NOT HAVE TO HAVE DO MANY ISSUES WITH A NEW TRUCK NOT MENTION IF YOU DO NOT SHUT THE TRUNK HARD IT WILL DRAIN THE BATTERY SINCE IT KEEPS THE LIGHTS ON IN THE TRUCK ALREADY HAD TO REPLACE THE BATTERY. THIS TRUCK HAS BEEN A LEMON SINCE DAY ONE AND SHOULD HAVE NEVER BEEN SOLD I FEEL THIS TRUCK IS NOT RELIABLE AND UNSAFE AT TIMES. NOT WORTH THE 26000 I PAID FOR IT. PLUS THE SENSORS GO OFF FOR NO REASON AND NOTHING IS AROUND.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT AT START-UP OR WHILE DRIVING AND ATTEMPTING TO TURN IN EITHER DIRECTION, THERE WAS AN ABNORMAL KNOCKING SOUND COMING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO BOZARD FORD LINCOLN (540 OUTLET MALL BLVD, ST. AUGUSTINE, FL 32084, (904) 824-1641) TO BE DIAGNOSED. THE STRUT TOWER AND STEERING GEAR NEEDED TO REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS CONTACTED HOWEVER, NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE 78,105.

I HAVE A 2016 FORD EXPLORER PLATINUM AND I TOOK THE CAR INTO THE FORD DEALERSHIP WITH AROUND 40-45,000 MILES BC THE AIRBAG LIGHT HAD CAME ON. TURNS OUT I WOULD HAVE TO PAY OUT OF POCKET FOR THE FIX BC ITS NOT A RECALL EVEN WITH IT BEING STILL UNDER WARRANTY. AS I HAVE LOOKED MORE AND MORE INTO THIS IT REALLY NEEDS TO BE ONE. BECAUSE ITS OUT NOW, ALL MY AIRBAGS WILL NOT DEPLOY IF SOMETHING WAS TO HAPPEN I HAVE 3 KIDS (NIGHTMARE TO THINK IF SOMETHING DID). I HAVE SEEN 100'S WITH THE SAME PROBLEM. ITS A MATTER OF TIME BEFORE SOMEONE SUES FORD WITH THIS MANY COMPLAINTS ON JUST THIS ALONE. WHEN PEOPLE ASK ME ABOUT GETTING A FORD I TURN THEM AWAY AND SHOW THEM HOW MUCH I HAVE SPENT ON REPAIRS AND ETC. AND THEY ALL END UP WITH SOMETHING ELSE. THIS NEEDS TO BE FIXED.!!

PLASTIC ROOF RACK TOP CAPS ARE POORLY AFFIXED AND CAME LOOSE ON HIGHWAY AND BLEW OFF THE VEHICLE. THIS PRESENTS HAZARDOUS ROAD CONDITIONS FOR DRIVERS AND PEDESTRIANS. AFTER THE INCIDENT, I RESEARCHED AND FOUND THAT THIS IS A WELL DOCUMENTED ISSUE WITH THIS GENERATION OF FORD EXPLORER.

OUR 2016 FORD EXPLORER WITH 44K MILES IS MAKING KNOCKING SOUNDS WHILE TURNING. THE SOUND WAS INTERMITTENT AT TIMES SO NOT ALL TURNS MADE THE KNOCKING SOUND.WE HAD IT LOOKED AT BY A MECHANIC AND HE SAID THE RACK AND PINION STEERING IS GOING OUT. HE EXPLAINED IN MORE DETAIL, BUT THE GIST OF IT IS A REPAIR COST OF $2K ON A VEHICLE THAT'S NOT PAID OFF AND EXTREME HAZARD TO DRIVE. THIS IS A CRITICAL CONCERN FOR MANY FORD EXPLORER OWNERS THAT HAVE REPORTED THE SAME ISSUE. PLEASE INVESTIGATE.

STEERING FAULT LIGHT CAME ON TWICE IN TWO DAYS, BOTH INSTANCES HAPPENED AFTER TAKING OFF FROM A STOPLIGHT. TOOK THE VEHICLE IN THE DEALERSHIP WHERE THEY READ THE CODES AND IT CAME BACK THE STEERING ASSEMBLY WAS FAILING. THEY PROCEEDED TO TELL ME THAT THE STEERING COULD GO OUT ANY MINUTE. THE VEHICLE ONLY HAS 57K MILES ON IT BUT OF COURSE ISN'T COVERED UNDER POWER TRAIN WARRANTY. AFTER GOOGLING THE ISSUE, IT SEEMS AS THOUGH THIS IS A VERY COMMON PROBLEM AND THE DEALERSHIP CONVENIENTLY HAD THE A STEERING ASSEMBLY IN STOCK. NOT SURE WHAT THE HOLD UP IS FOR FORD TO ISSUE A RECALL! THIS COULD KILL SOMEONE.

WE OWN A 2016 FORD EXPLORER, AND HAVING MAJOR ISSUE WITH STEERING ASSIST FAULT SERVICE REQUIRED. WHICH MEANS NEW RACK SYSTEM AT $2,100 +. I'VE READ SO MANY OTHER PEOPLE WITH SAME PROBLEM, AND EVEN WITH PAST EXPLORERS WITH RECALLS. WHY HAS FORD NOT RECALLED THIS PROBLEM AS THEY DID WITH PAST EXPLORERS?? IT'S A DEATH TRAP, AND YOU WILL LIKELY WRECK WHEN THIS HAPPENS. I'M THE LUCKY ONE THIS TIME..

AIRBAG WARNING LIGHT INDICATOR CAME ON. FORD DEALERSHIP (SOUND FORD RENTON,WA) PERFORMED $150 DIAGNOSTIC WHICH PRODUCE CODE STORED IN RCM "B141B" FOR 2ND ROW DRIVER SIDE INFLATABLE SEAT BELT DEPLOYMENT CONTROL USING OASIS THE DEALER FOUND TSB 16--0001. THIS SERVICE BULLETIN REPLACES THE CONNECTORS FOR THE LEFT AND RIGHT SECOND ROW SEATING AIRBAG CONTROL AND RE-ROUTES HARNESS. VEHICLE HAS 45,319 MILES (BELOW THE 5YR/60,000 SRS WARRANTY) HOWEVER DEALER CLAIMS REPAIR IS OUT OF POCKET. DEALER ALSO STATED WHEN THE AIRBAG LIGHT IS ON NO AIRBAGS WILL DEPLOY IN EVENT OF ACCIDENT.