2016 Ford Explorer complaints

The transmission is constantly slipping. While driving up or down any steeper grades, the RPMs are so high we have to adjust speed to get the transmission to shift properly as to not blow the engine. The suv surges and shifts hard while going only 15 to 20 mph on regular pavement. This has all been happening since we purchased the vehicle (in 2018 @ 27,000 miles). We took in right away and they did replace the transfer case. Since then we’ve taken it to two different Ford dealerships in the area and they state there is nothing wrong. We were told ‘sorry it’s not like we can drive it up a hill to see what the issue is and it’s just not bad enough to warrant replacing the transmission at this time’ We’ve had to swerve to the side of the highway to avoid rear end collisions due to poor shifting and reduced speeds. It’s not trustworthy to travel and at our first chance we’re dumping it for a Chevy. Ford knows there’s an issue with their transmissions, but they push you off until you’re outside of your warranty to tell you to replace the transmission. We helped our elderly mom purchase a Ford and her transmission went out with the same issues and she had to purchase another vehicle as well due to being put off outside of her warranty (by three days - WOW Ford!). ‘It’s not bad enough’ - we’ll it’s not going to get better!!

THE VEHICLE WAS PURCHASED IN 2020 AND SO FAR I HAVE HAD TO REPLACE THE A PILLAR TRIM 3 TIMES.ONCE ON THE PASSENGER SIDE AND TWICE ON THE DRIVERS SIDE. COSTING OVER $100 EACH TIME JUST FOR THE PARTS.THE TRIM HAS COME OFF TWICE WHILE AT HIGHWAY SPEED, 60 MPH, CAUSING A LOUD NOISE AND FLYING DEBRIS. THE THIRD TIME THE TRIM CAME OFF AT A SLOW SPEED OFF 35 MPH AND ACTUALLY BROKE IN HALF. I ATTACHED A PHOTO OF THE TRIM PIECE. I BELIEVE THE CAUSE MAY BE THE PLASTIC CLIPS THAT HOLD THE TRIM IN PLACE.

MY HUSBAND WAS DRIVING TO WORK AND LOST DRIVE POWER AND THE UNDERNEATH OF THE SUV WAS ON FIRE, MY HUSBAND PULLED OVER AD CALLED 911. THE DEALER STATED THE PTU CRACKED FROM PRESSURE LEAKING ALL THE OIL ONTO THE EXHAUST. ALSO STATED ALL OF MY TIRES WERE GOOD .. SO WE ARE UNSURE WHERE THE PRESSURE CAME FROM>

VEHICLE DISPLAYS AIR BAG WARNING LIGHT. DEALERSHIP STATED IT IS DUE TO ELECTRICAL CONNECTION UNDER REAR SEAT. COST TO REPAIR $700-1000. WHILE AIR BAG LIGHT IS ON AIR BAGS WILL NOT DEPLOY. A INTERNET SEARCH YIELDED OVER 250 REPORTED CASES OF THIS EXACT ISSUE. DUE TO THE AIR BAGS NOT FUNCTIONING, THE COST OF THE REPAIR, AND THE FREQUENCY OF THIS VERY SPECIFIC BREAK, AND THE QUANTITY OF REPORTS,I QUESTION WHY FORD HAS NOT RECALLED THIS SAFETY ISSUE.

HEARD NOISES WHEN I TURN MY STEERING WHEEL. I WAS TOLD I NEED TO HAVE MY RACK AND PINION STEERING REPLACE-EST COST MID 2K. STARTING TO RESEARCH ONLINE AND I SEE THAT THIS IS A COMMON PROBLEM WITH POTENTIAL SEVERE CONSEQUENCES IF NOT FIXED. WHY HASN'T THIS BEEN RECALLED??? ALSO WE HAD TO REPLACE THE STRUTS. THE CAR DOES NOT HAVE 50K MILES YET. I DO HAVE THE REPAIR FOR THE STRUTS. HAVE NOT REPAIRED THE RACK AND PINION YET.

WHILE DRIVING DOWN THE HIGHWAY AT APPROXIMATELY 75 MPH, THE DRIVER'S WINDSHIELD SIDE TRIM MOLDING DETACHED FROM THE VEHICLE. THIS MOLDING IMPACTED THE SIDE OF THE VEHICLE, AND BECAME FOD ON THE HIGHWAY. IN REVIEW, ONLY HALF OF THE MOLDING DETACHED FROM THE VEHICLE, WITH HALF REMAINING IN PLACE.

RADIO SPARKING AND SMOKING PLUS PEELING AND BUBBLES INSIDE THE HOOD PAINT

AIR BAG LIGHT ON DASH. CAUSED BY DTC B141B. FOUND TSB RELATED TO CONNECTORS UNDER REAR SEAT MP 130. CAR WAS STATIONARY.

THE 2ND ROW AIRBAG LIGHT CAME ON, AND FORD TOLD ME IT WAS A SHORTAGE IN THE WIRES AND IT WASN'T COVERED UNDER THE MANUFACTURERS WARRANTY. THEY STATED THAT SINCE THE AIRBAG LIGHT WAS ON, THE SHORT IN THE WIRING WOULD STOP THE AIRBAG FROM DEPLOYING, WHICH IN TURN IS A SAFETY ISSUE.

ON MULTIPLE OCCASIONS TRANSMISSION WAS SLIPPING WHICH LED TO AN EVENTUAL COMPLETE FAILURE. EXPLORER WAS ON CA HIGHWAY 76 GOING WESTBOUND WHEN TRANSMISSION FAILED. DRIVER WA FORCED TO DODGE TRAFFIC AND COAST TO AN EMERGENCY STOP AT THE RIGHT SIDE OF THE HIGHWAY. EXPLORER HAD TO BE TOWED.

MY AIRBAG LIGHT CAME ON AND THE FORD DEALER WARNED ME THAT THE AIRBAGS WOULD NOT DEPLOY UNTIL I GOT THE ISSUE FIXED. THIS IS A KNOWN ISSUE BY FORD, AS THEY HAVE ISSUED TSB IT. MY EXPLORER SPORT IS 4 MONTHS OVER THE 5 YEAR/60,000 MILE POWER TRAIN WARRANTY, SO I CONTACTED ASSURANT SOLUTIONS BECAUSE I BOUGHT A 72 MONTH/75,000 MILE EXTENDED WARRANTY THROUGH USAA ON 1/6/2016. THIS WAS MY FIRST CLAIM AND THEY DENIED THE CLAIM BECAUSE THEY SAID THAT 'SAFETY RESTRAINT SYSTEMS' WAS AN 'EXCLUDED ITEM'! WHAT'S INFURIATING IS THAT THEY COVER ELECTRICAL ASSEMBLY, INTERIOR ELECTRONICS AND POWER TRAIN ELECTRONICS, BUT NOT 'SAFETY' ELECTRICAL COMPONENTS!! I RAISED CANE WITH THE GENERAL MANAGER OF THE FORD DEALERSHIP AND THEY WENT BACK TO FORD FOR A 'GOODWILL' WARRANTY COVERAGE AND THEY AGREED TO PAY FOR ALL BUT $261 OF THE REPAIR. WHILE I SINCERELY APPRECIATE THE GOODWILL OFFER, FORD LOST ANY FUTURE BUSINESS FROM ME FOR NOT PROACTIVELY OFFERING THE GOODWILL COVERAGE FROM THE START BEFORE I HAD TO PURSUE OTHER OPTIONS. SHAME ON FORD!! IT DOESN'T RISE TO THE LEVEL OF A FULL RECALL, BUT IT IS A KNOWN DEFECT WITH A CRITICAL SAFETY FEATURE, SO THEY SHOULD HAVE COVERED IT FROM THE START WHEN PRESENTED WITH THE AIR BAG LIGHT COMING ON! *TR

DRIVING ON HIGHWAY, WINDSHIELD TRIM ON DRIVERS SIDE BROKE OFF. ONCE STATIONARY, INSPECTED WHERE THE TRIM WAS AND IT'S COMPLETELY GONE & APPEARS THAT THE CLIPS HOLDING IT THERE ARE BROKEN AND SOME GONE. PASSENGERS SIDE TRIM IS WARPED AND APPEARS LOOSE. ALSO, DRIVERS DOORS TRIM IS NOW PARTLY DETACHED FROM DOOR

I TOUCHED THE STEERING WHEEL BOTTOMS FOR AND WHEN I TRUN THE STEERING WHEEL I HERE A POPING SOUND. I'M SACAR IT MAY LOCK AND THEN CRASH. WHILE IN MENTION. CITY AND HIGHWAYS.

MY EXPLORER STARTED HAVING POPPING NOISES WHEN TURNING LEFT OR RIGHT. IT IS BAD ENOUGH TO GIVE SIGNIFICANT FEEDBACK IN THE STEERING WHEEL AND VIBRATIONS THROUGHOUT THE FRONT PASSENGER AREA. WHEN I JACK UP THE FRONT END UNLOADING THE WHEELS, THERE IS NO NOISE OR POPPING. WITH FULL WEIGHT ON THE WHEELS, WHEN THE WHEEL IS TURNED SLIGHTLY LEFT AND RIGHT AND GET SIGNIFICANT POPPING AND CRACKING FEEDBACK VIA THE TIE RODS, THE NOISE HAS PROGRESSED INTO THE STEERING WHEEL FREEZING IN PLACE WHILE DRIVING THE VEHICLE. NOT BEING ABLE TO CONTROL THE CAR IS A MAJOR LIFE SAFETY ISSUE IF NOT ADDRESSED THIS HAS THE POTENTIAL TO CAUSE MAJOR INJURIES OR DEATH. IF IT HAS NOT ALREADY. THE DEALER IS AWARE OF THE ISSUES AND I FIND COUNTLESS ONLINE INSTANCES OF THIS MECHANICAL DEFECT.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT AT START-UP, THE DRIVER'S SIDE FRONT SEAT INDEPENDENTLY ADJUSTED, TRAPPING THE CONTACT UP AGAINST THE STEERING WHEEL. THERE WAS NO WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER WALKER FORD (17556 US HWY 19 N, CLEARWATER, FL 33764, (727) 265-3992) BUT WAS NOT YET DIAGNOSED. THE VEHICLE WAS NOT YET REPAIRED. THE MANUFACTURER WAS INFORMED OF FAILURE. THE CONTACT WAS STILL AWAITING A RESPONSE. THE FAILURE MILEAGE WAS APPROXIMATELY 23,000. THE CONSUMER STATED THE DEALER WAS NOTIFIED AND SUGGESTED THE CONSUMER INADVERTENTLY CHANGED THE SEAT SETTINGS. THE CONSUMER WAS UNABLE TO REPLICATE THE FAILURE AND DENIED CHANGING THE SETTINGS.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT WHILE HAVING A ROUTINE OIL CHANGE AT WALDORF FORD (2440 CRAIN HWY, WALDORF, MD 20601, (888) 709-3528) THE TECHNICIAN INFORMED THE CONTACT THAT THE ENGINE BLOCK WAS LEAKING AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. A FEW DAYS LATER A BYSTANDER INFORMED THE CONTACT THAT THERE WAS WATER IN THE PASSENGER'S SIDE REAR BRAKE LAMP AND THAT THE BRAKE LAMP FAILED TO ILLUMINATE WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT MENTIONED NHTSA CAMPAIGN NUMBER: 15V605000 (FUEL SYSTEM, GASOLINE) AS A POSSIBLE SOLUTION TO THE FAILURE HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA TO FILE A COMPLAINT. THE FAILURE MILEAGE WAS APPROXIMATELY 85,000.

THE CAR LOOSE THE POWER AND DON'T GO OVER 20 MILES AN HOUR . RPM GOES OVER 5000 CAR SPEED DON'T CHANGE MAKE NOISE YOU CAN'T GO UP THE HAVE THE POWER TO GO ONLY 20 MILES TO 23 MILES AN HOUR

I WAS STATIONARY IN A PARKING LOT AND STARTED THE VEHICLE TO FIND MESSAGES STEERING ASSIST FAULT SERVICE REQUIRED, HILL START ASSIST NOT AVAILABLE, SERVICE ADVANCE TRAC, AND TERRAIN MANAGEMENT SYSTEM FAULT ALL DISPLAYED ON THE INSTRUMENT CLUSTER. THERE WAS NO POWER STEERING ASSISTANCE AND THE STEERING WHEEL WAS INCREDIBLY HARD TO TURN. IN THE DAYS LEADING UP TO THE FAILURE I NOTICED ON A FEW OCCASIONS THE STEERING WHEEL WOULD NOT CENTER AFTER EXITING A 90 DEGREE TURN AND I WOULD HAVE TO PROVIDE INPUT TO STRAIGHTEN THE WHEELS. THE ELECTRIC POWER STEERING RACK HAS FAILED AND THERE ARE NOT EVEN ANY PARTS AVAILABLE FOR THIS, NOR DOES IT APPEAR FORD HAS ACKNOWLEDGE THEY HAVE A WIDESPREAD PROBLEM..

WENT TO THE BEACH THIS PAST SATURDAY AND AS I WAS PULLING INTO THE TURNING LANE FOR THE STATE PARK AND ALARM WENT OFF SAYING DRIVE ASSIST CONTROL FAILURE, AND NUMEROUS THINGS THAT NO LONGER WORK, SINCE THEN THERE HAS BEEN NO POWER STEERING AND IT WAS A MIRACLE WE GOT IT HOME WHICH WAS AN HOUR AND A HALF AWAY, HAD THIS HAPPENED WHILE GOING FASTER THEN I COULD OF LOST CONTROL OF THE VEHICLE, AND I WAS GOING ABOUT 10 MPH WHEN IT ALARMED. THE PICTURES SHOW WAS ALERTS EVERY TIME THE VEHICLE IS STARTED NOW. THIS MORNING THE STEERING WHEEL WAS NEAR IMPOSSIBLE TO MOVE SO MY GIRLFRIEND WHO DRIVES THE EXPLORER HAS TO USE THE BACK UP CAR THAT CAN'T HOLD ALL OF OUR KIDS.

I RECEIVED THE RECALL NOTICE IN OCTOBER 2020 MANUFACTURER RECALL NUMBER20S62 NHTSA RECALL NUMBER20V675. WHEN ATTEMPTING THE SCHEDULE WITH KOONS FORD ANNAPOLIS, I HAVE BEEN TOLD THE PARTS ARE STILL ON BACK ORDER. THIS IS NOW MONTH 5 AND THE RECALL HAS NOT BEEN CORRECTED.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING THERE WAS A STRONG ODOR COMING INTO THE CABIN OF THE VEHICLE CAUSING THE CONTACT AND HER HUSBAND TO BECOME LIGHTHEADED. WHEN THE CONTACT RETURNED TO HER RESIDENCE SHE CHECKED UNDER THE HOOD AND SMELLED AN ABNORMALLY STRONG ODOR COMING FROM UNDERNEATH THE ENGINE. THE CONTACT STATED THE ODOR SMELLED LIKE SULFUR AND ROTTEN EGGS. THE CONTACT TOOK THE VEHICLE TO THE LOCAL DEALER BALISE FORD (1979 BOSTON RD, WILBRAHAM, MA 01095) TO HAVE THE VEHICLE DIAGNOSED HOWEVER, THE DEALER WAS UNABLE TO FIND THE CAUSE OF THE ODOR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 63,000.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT THE PASSENGER MIDDLE ROW SEAT BELT FAILED TO LATCH CORRECTLY. THE CONTACT SPOKE WITH BREDEMANN FORD (2038 WAUKEGAN RD, GLENVIEW, IL 60025, (847) 510-5585) WHO STATED THAT THE SEAT BUCKLE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE AND FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT UNDER RECALL AND THERE WAS NO WARRANTY ON THE VEHICLE. THE APPROXIMATE FAILURE MILEAGE WAS 33,778.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED WHILE DRIVING 5 MPH, THE VEHICLE MADE AN ABNORMAL NOISE PRIOR TO THE STEERING WHEEL LOCKING UP. THE VEHICLE WAS TURNED OFF AND RESTARTED AND THE STEERING WHEEL UNLOCKED. THE CONTACT STATED A TIRE SENSOR WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO BANNER FORD OF MONROE (6300 FRONTAGE RD, MONROE, LA 71202) WHERE IT WAS DIAGNOSED WITH THE RACK AND PINION NEEDING TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE REPLACEMENT PART WAS DEFECTIVE. THE MANUFACTURER HAD NOT BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 101,509.

AS MY WIFE WAS DRIVING SHE HEARD A POP NOISE, THEN SHE WENT TURN AND THE STEERING LOCKED UP WHICH FORCED HER TO STAY IN HEAD ON TRAFFIC. AFTER FORCING THE WHEEL BACK AND FORTH SHE WAS ABLE TO GET STEERING BACK AND TOOK THE SUV TO A LOCAL SHOP. IT WAS THEN DETERMINED THAT THE STEERING GEAR WAS BAD. THIS HAPPENED WHEN OUR VEHICLE ONLY HAD ROUGHLY 60,000 MILES. THANKFULLY NO ONE HIT HER HEAD ON. THE STEERING GEAR WAS REPLACED.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT THE WATER PUMP LEAKED FLUID WITHOUT WARNING. THE CONTACT TOOK THE VEHICLE TO STEVENS FORD OF MILFORD (717 BRIDGEPORT AVE, MILFORD, CT 06460) WHERE SHE WAS INFORMED THAT THE VEHICLE NEEDED A NEW WATER PUMP. THE CONTACT DECLINED THE REPAIR. THE CONTACT THEN TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHERE SHE HAD THE VEHICLE REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 78,000.

THIS VEHICLE ALMOST TOOK MY LIFE THE OTHER DAY. ALMOST JUST AS SCARY IS THE FACT THAT THIS ISSUE IS WIDELY REPORTED ON THESE VEHICLES FROM 2011 ON AND FORD HAS ZERO RECALL FOR IT. I WAS ON THE FREEWAY THE OTHER DAY GOING ABOUT 70MPH WHEN INSIDE OF 10 SECONDS (WHILE ON A BEND IN THE ROAD) MY DASH LIT UP AND MY STEERING LOCKED!!! AT 70 MPH!!! I ALMOST HIT 3 CARS WHILE TRYING TO SLOW DOWN AS I COULD ONLY GO STRAIGHT. WHEN I SAY LOCKED, I MEAN AS IF IT WAS CEMENTED IN PLACE. THE DASH READS 'STEERING LOSS STOP SAFELY', 'SERVICE ADVANCETRAC', 'HILL START ASSIST NOT AVAILABLE'. THIS COULD HAVE LIKED NOT ONLY ME BUT OTHER MOTORISTS THIS DAY. ON TOP OF THE INCREDIBLE CONCERN OF SAFETY, THE 'HEAD IN THE SAND' MENTALITY THAT FORD HAS ON THIS ISSUE IS DISGUSTING, AS THEY'RE ALSO LEAVING OWNERS WITH $5000-$10000 REPAIR BILLS DUE TO THIS ISSUE. THIS WAS THE LAST STRAW WITH FORD, AFTER 20 YEARS, I'M DONE.

VEHICLE STARTED TO MISFIRE AS I WAS DRIVING. IT WOULD GET WORSE EVERY TIME I WAS IDLE AT STOP LIGHTS. HAD TO PULL OVER TO ASSESS THE SITUATION AND I SHORTLY SCHEDULED A SERVICE APPOINTMENT WITH A FORD DEALERSHIP. FORD TECHS SAID IT WAS THE SPARK PLUGS AND COILS. HAD ALL 6 SPARK PLUGS & COILS REPLACED BUT THE ISSUE CONTINUED. STILL NO RESOLUTION AS OF TODAY. VEHICLE ONLY HAS 47K MILES.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT UPON MAKING A SHARP TURN FROM LEFT TO RIGHT AT A LOW RATE OF SPEED, AN ABNORMAL CLANKING SOUND WOULD EMIT FROM THE UNDERCARRIAGE OF THE VEHICLE. THE CONTACT HAD TAKEN THE VEHICLE TO BALISE FORD OF CAPE COD (90 HIGH SCHOOL RD EXT, HYANNIS, MA 02601) WHERE THEY INFORMED HIM THAT THE VEHICLE HAD A BLOWN SHOCK. THE SECOND TIME, THE CONTACT WAS INFORMED THAT HE NEEDED A FULL STEERING RACK REPLACEMENT. THE MANUFACTURER HAD YET TO BE NOTIFIED OF THE FAILURE. THE VEHICLE HAD YET TO BE REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 61,000. THE VIN WAS UNAVAILABLE.

THE HOOD OF THE VEHICLE IS RUSTING ALONG THE FRONT EDGE. IT STARTED WITH A SMALL AREA AT FIRST A YEAR AGO BY BUBBLING UP FROM UNDERNEATH. NOW THERE ARE SEVERAL VISIBLE AREAS ALONG THE FRONT EDGE OF THE HOOD DOING THE SAME. IT'S A MATTER OF TIME TIL THE RUST BREAKS THRU THE PAINT. 5 YEARS OLD AND I LIVE IN MD. MILD WINTERS. SHOULDN'T HAPPEN.

WHILE TRAVELING AT APPROXIMATELY 70 MPH THE PASSENGER SIDE WINDSHIELD PILLAR MOLDING DEPARTED THE VEHICLE. WHILE RESEARCHING PART NUMBERS AND REPAIRS ONLINE I HAVE NOTICED THIS APPEARS TO BE A COMMON PROBLEM FOR EXPLORERS FROM 2011- 2018. ALSO SEEMS SOMEWHAT RELATED TO THE CURRENT RECALL FOR EXPLORER ROOF RACKS THAT USE SOME OF THE SAME MOUNTING HARDWARE. PARTS SEPARATING FROM VEHICLES AT HIGHWAY SPEEDS CREATES HIGH RISK OF INCIDENTS.

I'M EXPERIENCING LIMP MODE. WHILE DRIVING AT ANY SPEED THE TRUCK LOSES POWER AND CUTS BACK ALMOST LIKE I PUT IT IN PARK WHILE DRIVING. THE WRENCH AND ENGINE LIGHTS ARE ON.

94000 MILES THE TRANSFER CASE BURST AND WHEN 70000 MILES CHARGING CYCLE DOES NOT WORK , THE VEHICLE SUDDENLY STOPS.

EXHAUST FUMES IN THE CABIN. STATED SLOWLY AND PROGRESSIVE GOT WORSE. HEAVY FUMES AND NOT SAFELY DRIVABLE, FORD REPAIR SAID IT WAS THE PTU UNIT LEAKING ALLOWING EXHAUST FUMES IN THE CABIN THROUGH THE AIR FLOW SYSTEM. FORD SAID THE PTU WOULD HAVE TO BE REPLACED- $2,400. THE VEHICLE ONLY HAS 58,740 MILES. DEFINITELY A SAFETY AND HEALTH HAZARD. THIS HAPPENS WHEN VEHICLE IS RUNNING AND AFTER RUNNING AND PARKED IN GARAGE FILLS GARAGE WITH NOXIOUS ODOR OF EXHAUST SMELL.

WIFE WAS SHOPPING IN ANOTHER CITY AND STEERING LOCKED UP WHEN SHE STARTED IT AFTER BEING PARKED IN A LOT ,WARNING SIGNALS CAME ON . TURNED EXPLORER OFF AND RESTARTED CAR AND DROVE FINE AND DROVE HOME 50 MILES . WENT TO HOCKEY GAME AT AN ARENA , CAME OUT AND STARTED CAR AND STEERING WAS HARD TO STEER ( NO POWER STEERING ) BUT MANAGED TO DRIVE HOME 2 MILES AND PUT IN GARAGE . LOOKED FOR POWER STEERING RESEVOUR AND THERE WAS NONE UNDER HOOD THINKING LOW ON FLUID . LOOKED IN OWNERS MANUAL AND SAW -- ALL ELECTRONIC ! DROVE IT TO DEALERSHIP NEXT DAY ( WEEKEND ) AND PARKED IT EVEN THOUGH IT WAS HARD TO STEER . GOOGLED THIS PROBLEM AND SAW ALL THE SAME PROBLEMS THAT OTHERS HAD WITH THIS STEERING GEAR ! WENT TO DEALER MONDAY MORNING AND THEY CHECKED IT OUT AND CALLED ME TO TELL ME IT WAS THE STEERING RACK THAT NEEDED TO BE REPLACED AT A COST OF APPROXIMATELY $ 2500 AND PART HAD TO COME OUT OF DETROIT AND WOULD TAKE A FEW DAYS TO GET HERE AND THEN REPAIR IT . CALLED ME YESTERDAY AND CAR WAS DONE ( $ 2395.91 ) WHY NO RECALLS ???

TL* THE CONTACT OWNS 2016 FORD EXPLORER. THE CONTACT STATED UPON ENTERING THE VEHICLE, THE FRONT DRIVER'S SIDE SEAT BELT FAILED TO LATCH SECURELY. THE CONTACT CALLED TOWN AND COUNTRY FORD (7800 E LLOYD EXPY, EVANSVILLE, IN 47715) HOWEVER, THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED NOR REPAIRED. THE CONTACT WAS INFORMED THAT THE VIN WAS NOT UNDER RECALL. THE MANUFACTURE WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILLAGE WAS 45,000.

FORD DESIGNED THE HEADLIGHTS IN THE 2016 FORD EXPLORER SO THAT THE LED LOW BEAM IS BUILT INTO THE HOUSING. SO YOU EITHER HAVE TO REPLACE THE VERY EXPENSIVE HOUSING (1,000) WHEN YOUR LOW BEAM GOES OUT OR DRIVE WITH LESS VISIBILITY. MOST PEOPLE DO NOT HAVE $1,000 JUST LAYING AROUND.

YOU CAN SMELL EXHAUST IN THE CABIN. IT SEEMS TO BE WORSE THE HIGHER THE HEATER IS TURNED UP. IT IS IRRITATING TO THE EYES. FORD DENIES THIS BEING A PROBLEM BASED ON OUR VIN.

I LOST MY STEERING COMPLETELY AND HAD TO TAKE MY VEHICLE INTO A SHOP. THE RACK AND PINION FOR THE STEERING OF MY VEHICLE HAS GONE OUT COMPLETELY AT ONLY 80,000 MILES. THIS IS AN EXTREMELY DANGEROUS ISSUE, AS IT COULD HAVE CAUSED A SERIOUS CRASH. WHILE STATIONARY OR MOVING SLOWLY, THE WHEEL IS HARDER TO TURN AND MAKES A LOUD SLIDING/GRINDING SOUND. AT HIGHER SPEEDS, THE STEERING WHEEL GETS "STUCK" AND IS VERY HARD TO GET OUT OF A CERTAIN POSITION. THIS ISSUE CAUSED ME TO ALMOST HIT ONCOMING TRAFFIC. AS COMMON AS THIS ISSUE IS AT AN AVERAGE OF 52,000 MILES ON THESE EXPLORERS, IT SHOULD BE A RECALL! THE REPAIR IS AT AN ESTIMATED $3,000 TO FIX. NOW I AM OUT OF A VEHICLE UNTIL I CAN COME UP WITH THAT KIND OF FUNDING, WHILE STILL OWING TONS OF MONEY ON IT. NOT ONLY IS THIS A HUGE FINANCIAL NIGHTMARE, BUT IT IS EXTREMELY UNSAFE!

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT THE AIR BAGS WARNING LIGHT REMAINED ILLUMINATED ON THE INSTRUMENTAL PANEL. THE CONTACT TOOK THE VEHICLE TO KOONS FORD OF ANNAPOLIS (2540 RIVA ROAD, ANNAPOLIS, MD 21401, (410-224-2100) TO HAVE A DIAGNOSTIC TEST PERFORMED. THE CONTACT WAS INFORMED THAT THE AIR BAGS ELECTRICAL CONNECTOR LOCATED UNDERNEATH THE DRIVER'S FRONT SEAT WAS CORRODED AND NEEDED TO BE REPLACED. THE DEALER INFORMED THE CONTACT OF MANUFACTURER COMMUNICATIONS NUMBER: 16-0001 AND PROVIDED AN ESTIMATE FOR THE COST OF THE REPAIR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 93,000.

I WAS DRIVING ON THE HIGHWAY AND WHEN I BEGAN TO TURN OFF THE EXIT I BEGAN HEARING A LOUD GRINDING SOUND COMING FROM MY STEERING COLUMN. IT WAS ALSO EXTREMELY DIFFICULT TO TURN THE WHEEL. IAM GRATEFUL THAT MY YOUNG CHILDREN WERE NOT WITH ME AT THE TIME BECAUSE THE GRINDING WAS SUPER LOUND AND I WAS ABOSULTELY TERRIFIED THAT I WAS GOING TO CRASH. I IMMEDIATELY TOOK THE TRUCK TO MY LOCAL MECHANIC WHERE HE SAID THAT I SHOULD NOT BE DRIVING THR TRUCK AT ALL BECAUSE I COULD DEFINITELY CRASH AN KILL MYSELF OR ANY OTHERS AROUND ME. ALSO THAT IT IS GOING TO COST $2500.00 TO FIX THE PROBLEM. I JUST PURCHASE THIS TRUCK FROM AUTOFAIR FORD IN JULY 2020 FOR 20K AND 6 MONTHS LATER AM FORCED TO DUMP 2.5K INTO IT WHEN MONEY IS TIGHT AND MY FAMILY IS STRUGGLING AS IT IS...I AM EXTREMELY UPSET THAT THIS HAPPENED AND TO LEARN THAT THIS HAS HAPPENED TO THOUSANDS OF PEOPLE, YET THERE IS NO RECALL FOR THIS ISSUE. AOMETHING SHOULD BE DONT TO HELP ME AND MY FAMILY BY FORD MOTOR COMPANY THIS IS NOT ACCEPTABLE TO BE GOING BROKE BECAUSE OF THIS ISSUE AND THE CAR IS JUST 5 YEARS OLD.

PAINT BUBBLING AND PEELING AROUND FRONT EDGE OF HOOD SHOWING RUST UNDERNEATH. VEHICLE IS GARAGE KEPT AND CLEANED REGULARLY.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING, THE REAR GLASS EXPLODED WITHOUT AN IMPACT. NEITHER THE DEALER NOR THE MANUFACTURER WERE MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000.

2016 FORD EXPLORER SMELLS LIKE CARBON MONOXIDE INSIDE OF THE VEHICLE WHEN DRIVING ,UNABLE TO DRIVE DUE TO BEING OVERCOME WITH CARBON MONOXIDE.

MY DRIVER SIDE AIRBAG LIGHT IS ON MY DASH I HAVE PLUGGED IN AND UNPLUGGED ALL OF THE SEATBELTS RESET THE AIRBAG LIGHT AND IT STAYS OFF FOR A WHILE. THIS IS DEFINITELY A SAFETY ISSUE I UNDERSTAND IT IS EITHER A SENSOR OR THEY ARE HAVING PROBLEMS WITH THE WIRING HARNESS THIS SHOULD BE ADDRESSED IN A RECALL. THE FRONT PASSENGER SIDE SEAT WARMER/COOLER DOES NOT WORK, NOT SURE IF THAT ISSUE IS PART OF THE AIRBAG LIGHT PROBLEM.

WE ARE DRIVING BACK FROM ZION NATIONAL PARK THEN IN THE FREEWAY SUDDENLY I LOST POWER LUCKILY IT WAS ON A DOWN HILL. I WENT ON THE SIDE OF THE ROAD THEN THEN COUPLE I STARTED RIGHT BACK. NOW AM AFRAID DRIVING IT FAR AWAY. FROM TIME TO TIME WHEN UPHILL IT JERK A BIT AND IT FEELS LIKE LOOSING POWER.

TOOK A QUICK LOOK UP TOP AND MY SUNROOF WAS CLOSED CORRECTLY. I OPENED THE SUNROOF AND POURED SOME WATER INTO THE CHANNEL AND WATER SEEMS TO DRAIN DOWN THE HOLES CORRECTLY. I ALSO CLOSED THE ROOF ALL THE WAY AND SPRAYED IT WITH A GARDEN HOSE, AND DIDNT SEE ANY LEAKING. I CANT SEE WHERE AND WHY WATER WOULD BE LEAKING OUT OF THE OVERHEAD CONSOLE. DID A QUICK SEARCH ON YOUTUBE AND FOUND SOMEONE ELSE HAD THIS PROBLEM, BUT COULDNT FIND A SOLUTION

DURING ACCELERATION CAR SMELLS LIKE ROTTEN EGGS ALL WINDOWS NEED TO BE OPEN TO VENT CAR AND ALL PASSENGERS GET NAUSEOUS. DEALER TRIED TWICE TO FIX PROBLEM BUT WITH NO SUCCESS.ITS GETTING IMPOSSIBLE TO DRIVE THE CAR ON HIGHWAY.FORD NEEDS TO DO SOMETHING ASAP.

I PURCHASED A 2016 EXPLORER LIMITED FROM A FORD DEALER AND NOTICED IT WAS LOW ON COOLANT, WAS TOLD IT WOULD BE FILLED AND OF COURSE IT WASN'T, I FILLED IT MYSELF. A WEEK LATER IT WAS LOW AGAIN, TOOK IT TO A CHEVY DEALER AND WAS TOLD THE WATER PUMP IS LEAKING. I CONTACTED THE SELLING DEALER AND LEFT A VOICEMAIL AND NO ONE RETURNED MY CALL. I CALLED BACK A COUPLE WEEKS LATER AND WAS TOLD IT ISN'T COVERED UNDER THEIR 30 DAY/1000 MILE WARRANTY. I CONTACTED FORD AND WAS TOLD NO ASSISTANCE BECAUSE I'M NOT THE ORIGINAL OWNER, SHOULD THAT MATTER WITH 69500 MILES??? I WAS TOLD TO CALL A LOCAL DEALER MAYBE THEY CAN HELP ME. THE WATER PUMP ON THIS VEHICLE IS MOUNTED INTERNALLY AND DRIVEN BY THE TIMING CHAIN AND COST ABOUT 1500.00 TO REPLACE. SO FAR AFTER A USED PURCHASE I'LL HAVE $25,000 INTO A VEHICLE THEY MAY TURN INTO A BRICK. I HAVE BOUGHT AND LEASED SEVERAL NEW FORD VEHICLES AND THIS IS HOW THEY TREAT CUSTOMERS, INCLUDING HAVING RETIRED FAMILY MEMBERS.

BROKEN CLOCK SPRING CAUSING DISABLING OF AIRBAG PROTECTION. COST TO REPAIR $541.10

DRIVING 45MPH SUDDENLY LOST STEERING CONTROL, WAS ABLE TO DECELERATE AND GET OFF THE ROAD, THEN SLOWLY GET HOME. AFTER THIS IT SEEMED TO WORK FINE. HOWEVER, EVERY DAY, A LOUD POPPING CREAKING SOUND THAT YOU CAN EVEN FEEL IS COMING FROM THE ELECTRIC POWER-ASSIST STEERING. ESPECIALLY NOTICEABLE WHEN PULLING IN OR OUT OF A PARKING LOT/DRIVEWAY/GARAGE. LOCAL SHOP SAYS IT WILL COST ABOUT $2500 TO REPLACE THE ELECTRIC POWER-ASSIST STEERING RACK AND PINION, AND IT MUST THEN BE PROGRAMMED TO THE VEHICLE. THIS EXPLORER HAS 78,000 MILES ON IT. THANKS.