2015 Ford Explorer complaints

TL* THE CONTACT OWNS A 2015 FORD EXPLORER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V435000 (SUSPENSION). THE CONTACT CALLED TOMMIE VAUGHN FORD AT 888-841-4361 (LOCATED AT 1201 N SHEPHERD DR, HOUSTON, TX 77008) AND WAS INFORMED THAT THE PARTS WERE NOT AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT WAS ALSO INFORMED THAT THERE WAS NO PROVISION FOR A LOANER VEHICLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

NOISY POPPING NOISE WHEN STEERING LEFT AND RIGHT AT A STAND STILL OR LOW SPEEDS. THIS TURNS INTO A LOCKED STEERING WHEEL IN ONE POSITION.

TL* THE CONTACT OWNS A 2015 FORD EXPLORER. WHILE DRIVING AND ATTEMPTING TO TURN, THE STEERING WHEEL SEIZED AND THEN RETURNED TO ITS NORMAL POSITION. THE VEHICLE WAS TAKEN TO CROUSE FORD (11 ANTRIM BLVD, TANEYTOWN, MD 21787, (877) 782-7280) WHERE IT WAS DIAGNOSED THAT THE RACK AND PINION NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 90,000.

I THOUGHT THE VEHICLE WAS HAVING STRUTS ISSUES IN THE FRONT AS WELL AS A SWAY BAR. HOWEVER I FINALLY GOT AN APPOINTMENT AT THE FORD DEALERSHIP AND THEY STATED THAT THE ISSUE WAS CAUSED BY A FAILING ELECTRONIC STEERING RACK. THIS VEHICLE ONLY HAVE 42,524 MILES ON IT AND THIS SHOULD NOT BE HAPPENING ALREADY. THIS COULD POTENTIALLY FAIL CAUSING YOU TO LOSE POWER STEERING AND CAUSE AN ACCIDENT. THE VEHICLE MAKES THE NOISE WHEN TURNING SLOWLY TO THE RIGHT OR WHEN BACKING UP. IT WILL ALSO MAKE THE NOISE WHEN YOU ARE STATIONARY AND TURN THE WHEEL BACK AND FORTH. THE QUOTE I RECEIVED FOR THE REPAIR WAS $1,770. THIS IS NOT SOMETHING THAT SHOULD HAVE TO BE REPAIRED ON A 2015 VEHICLE WITH LOW MILEAGE.

VEHICLE HAS STRONG EXHAUST LIKE BURNT HAIR UNDER HARDER ACCELERATION. FOR INSTANCES, CLIMBING A HILL AND NEEDED TO SPEED UP. THE SMELL STAYS WITH THE VEHICLE AS WELL. FOR AT LEAST A MILE AFTER THE FACT. I HAVE HAD SEVERAL VEHICLES AND NEVER HAVE I HAD ONE SMELL LIKE THAT UNDER ACCELERATION.

TWO MONTHS AGO I HAD THIS WEIRD SMELL IN THE CABIN OF MY EXPLORER WHEN ACCELERATING , , TAKE IT TO THE SHOP, TWO DAYS AFTER THE DEALER TOLD ME IT WAS CARBON MONOXIDE IT STARTED MAKING A WEIRD NOISE , TAKE IT IN AGAIN AND THE PTU IS COMPLETELY SHREDDED. WAS TOLD ALL THE FLUID LEAKED OUT AND CAUSED THIS DAMAGE. COMPLETE REPLACEMENT OF THE PTU OVER $2500 ON A VEHICLE 2015 FORD EXPLORER WITH ONLY 64,000 MILES ON IT.

CONSTANT STEERING POPPING NOISES INCLUDING OCCASIONAL STEERING BINDING AND LOCKING UP. I HAVE HAD A FEW INCIDENTS WHERE I NARROWLY AVOIDED AN ACCIDENT AFTER STEERING LIMITED TO APPROXIMATELY 30 DEGREES. I HAD TO MUSCLE THE WHEEL, AND AFTER A LOUD BANG, FULL STEERING ROTATION WAS REGAINED. LIKELY THE SAME ISSUE AS IN PREVIOUS YEAR MODELS WHERE STEERING RACK HAD TO BE REPLACED UNDER A MASS RECALL. DEALERSHIP ASSUMING IT IS THE SAME ISSUE, YET THE RECALL DID NOT CARRY OVER TO 2015'S WHICH SUFFER THE SAME PROBLEM.

CARBON MONOXIDE COMPLAINT, I HAVE BECOME; SLEEPY, SICK, NAUSEOUS, VOMITING, 08/20/2015 THE RICH FORD AUTO DEALERSHIP SALESMAN INFORMED ME THAT THIS WAS THAT NEW CAR SMELL, I FILED COMPLAINTS 08/28/2015 UNTIL TODAY WITH, THE RICH FORD AUTO DEALERSHIP SALESMAN INFORMED ME AGAIN THAT THIS WAS THAT NEW CAR SMELL, MECHANIC PERFORMING NOSE SAFETY SNIFF TEST USING HIS NOSE, AND DECLARING THE VEHICLE SAFE, USING ONLY THE NOSE SAFETY SNIFF TEST, AND I FILED MY COMPLAINT WITH THE BBB ALBUQUERQUE, NEW MEXICO, THEY REFEREED ME TO BBB DENVER COLORADO THEY REFEREED ME TO BBB AUTO LINE ARLINGTON VA, THEY HAVE SAID IT IS TOO LATE TO FILE MY BBB COMPLAINT [XXX] WITH FORD MOTOR CO COMPLAINT, ABOUT CARBON MONOXIDE FROM THE DAY I BOUGHT THIS VEHICLE UNTIL NOW, TODAY, THEIR MECHANIC HAS REPEATEDLY PERFORMING NOSE SAFETY SNIFF TEST USING HIS NOSE, AND DECLARING THE VEHICLE SAFE, USING ONLY THE NOSE SAFETY SNIFF TEST, [XXX] WAS THE SERVICE WRITER, SHE HAS BEEN PROMOTED TO SERVICE MANAGER, [XXX] HAS INFORMED ME THAT RICH FORD AUTO DEALERSHIP, IS GOING TO START CHARGING ME FOR SERVICE CALLS TO CHECK THIS CARBON MONOXIDE PROBLEM. FORD VEHICLES INVOLVED IN THIS EVENT COULD BE (BOUGHT BACK BY THE DEALERSHIP) (IF ASKED) I ASKED THEY SAID THEY WOULD ALLOW ME TO TRADE IN THE 2015 FORD EXPLORER SPORT, VIN [XXX] FOR $2,000.00 OF 1% OF WHAT I PAID FOR IT, IT WILL BE PAID OFF IN 09/2021. TSB 16-0166 DID NOT BECOME OR TURN INTO PROGRAM 17N03. THEY ARE DIFFERENT REPAIRS FOR THE SAME ISSUE. THE DEALERSHIP MUST PE

AIRBAG SENSOR CAME ON AT ABOUT 66,000 MILES. DISREGARDED FOR A WHILE, AS I WAS ON A LONG TRIP. WENT TO DEALER AND THEY PUT ON COMPUTER; DIAGNOSIS CODES ARE DTC B141B AND B141C. DEALER SUGGESTED TO REPLACE THE AIRBAG HARNESS, WITH CONNECTORS REPLACED FOR $963.17, B/C WARRANTY CONVENIENTLY EXPIRED AT 60,000 MILES. THIS IS A SAFETY ISSUE AS NONE OF THE AIRBAGS IN THE CAR WILL DEPLOY UNLESS I PAY FORD RANSOM FOR A PART THAT HAS NO MOVING PARTS. I SEE MULTIPLE PEOPLE WITH SAME ISSUE SO THERE SHOULD BE A RECALL.

THE AIRBAG WIRING HARNESS IS FAULTY, CAUSING NO AIR BAGS. THE PART TO REPAIR HAS BEEN ON BACK ORDER DUE TO HIGH DEMAND. MY VEHICLE HAS BEEN WITHOUT AIRBAG SYSTEM THREE WEEKS WITH ANOTHER TWO WEEKS TO WAIT FOR PART TO ARRIVE.THE PROBLEM BEGUN BEING ADDRESSED IN OCTOBER 2018 AND HAS CONTINUED. PART OF WIRING HARNESS WAS REPLACED. TOLD IT WAS GOOD TO GO AND TWO WEEKS LATER NO AIRBAGS. SCARY TO HAVE NO AIRBAGS WITH CHILDREN IN CAR. DEALER SAID, BUT YOU STILL HAVE SEATBELTS......

LANE KEEPING STEERING ASSIST IS ELECTRIC MOTOR ASSIST. THE RACK & PINION STEERING GEAR MOTOR MALFUNCTIONED, LEAVING THE STEERING WITHOUT ANY ASSIST, RESULTING IN MANUAL (EXTREMELY DIFFICULT TO STEER) STEERING. IN THIS CASE, NO CRASH RESULTED, BUT REQUIRED RACK & PINION REQUIRED REPLACEMENT. REPLACEMENT COST ~$2200.00 AT A FORD DEALERSHIP.

TL* THE CONTACT OWNS A 2015 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 60 MPH, THE 'LANE DETECTION FAILURE' MESSAGE SUDDENLY APPEARED AND THE POWER STEERING FAILED. THE STEERING WHEEL BECAME VERY DIFFICULT TO TURN IN EITHER DIRECTION. AFTER STOPPING THE VEHICLE AND RESTARTING THE ENGINE, THE VEHICLE OPERATED NORMALLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO FOUND DIAGNOSTIC CODE: C200D AND ADVISED THE CONTACT TO TAKE THE VEHICLE TO THE LOCAL DEALER. THE VEHICLE WAS TAKEN TO JONES FORD OF NORTH CHARLESTON (5757 RIVERS AVE, NORTH CHARLESTON, SOUTH CAROLINA), BUT THE CODE WAS NO LONGER PRESENT AFTER RESTARTING THE VEHICLE SEVERAL TIMES. THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 45,000.

STEPPED ON THE GAS PEDAL TO ACCELERATE AND VEHICLE KEPT ACCELERATING AFTER REMOVING FOOT FROM PEDAL. IT DID THIS 3 TIMES WITHIN 10 MINUTES. THE FLOOR MATS WERE NOT IN THE WAY AND CRUISE CONTROL WAS NOT ACTIVATED.

TL* THE CONTACT OWNS A 2015 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING AT 60 MPH, THE FRONT SUSPENSION ON THE DRIVER SIDE COLLAPSED. THE VEHICLE VEERED TO THE LEFT AND HIT THE CONCRETE BARRIER, BOUNCED AND HIT THE RIGHT CONCRETE BARRIER. NONE OF THE FRONTAL AIR BAGS DEPLOYED. THE POLICE WAS PRESENT AND A REPORT WAS ISSUED. THE CONTACT WAS TRANSPORTED TO THE HOSPITAL BY AMBULANCE, TREATED AND RELEASED. THE VEHICLE WAS TOWED TO AN IMPOUND LOT. THE INSURANCE COMPANY LABELED THE VEHICLE AS DESTROYED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR A DIAGNOSTIC. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 50,000.

ON 6/6/19 VEHICLE LOST ENGINE THROTTLE POWER WHEN "WRENCH" LIGHT INDICATOR APPEARED ON DASHBOARD WHILE DRIVING ON INTERSTATE (AT LEAST 65MPH). WRENCH NOTED TERRAIN MANAGEMENT SYSTEM ERROR. ENGINE DID NOT SHUT OFF. VIBRATED VERY BADLY WHEN COMING TO STOP. HAPPENED AGAIN ON 6/12 ON CITY STREET DRIVING APPROX 35MPH. BOTH TIMES STOPPED VEHICLE, TURNED OFF, AND RESTARTED AND OPERATED NORMALLY. FORD DEALERSHIPS CANNOT DETERMINE PROBLEM BECAUSE THERE COMPUTER SYSTEMS CANNOT SEE ERROR CODE(S) IN DIAGNOSTICS.. ADDITIONALLY, FORD MOTOR COMPANY WILL NOT RESPOND UNTIL "ERROR CODE" IDENTIFIED BY FORD SERVICE DEALERSHIP. READ ONLINE AND YOUTUBE EXACT ISSUES BUT NOT DISCUSSION ON RESOLUTION(S). SEE URL ADDRESS FOR EXAMPLE OF ISSUE THAT OCCURRED WITH OUR VEHICLE: HTTPS://WWW.YOUTUBE.COM/WATCH?V=ASRDPLP4_QE&T=1S. VERY DANGEROUS TO LOSE POWER ON HIGHWAY AND LITTLE CONTROL OF VEHICLE. BELIEVE THIS IS A SYSTEMIC ISSUE WITH FORD EXPLORERS

DRIVING TO WORK AND RECEIVED A "STEERING ASSIST FAULT/SERVICE REQUIRED" WARNING MESSAGE. TOOK CAR TO DEALER, WHERE THEY REPAIRED A FAULTY STEERING GEAR ASSEMBLY.

MAKING SLOW RIGHT HANDED TURNS, CLUNKING SOUND WAS DETECTED IN THE FRONT OF THE VEHICLE. THE FORD DEALER INVESTIGATION REVEALED THAT THE POWER STEERING RACK NEEDS REPLACEMENT. THE VEHICLE HAS ONLY 61000 MILES ON IT AND THE COST WILL BE $1950.

CARBON MONOXIDE IN THE FORD EXPLORER 2015 NOT FIXED BY FORD DEALERSHIP PURCHASED FROM NEW 2015, CUSTOMER COMPLAINED ABOUT SINCE DAY ONE DELIVERY, UNSTABLE MOVEMENTS, LEFT RIGHT, SIDE TO SIDE, NOT FIXED BY FORD DEALERSHIP PURCHASED. DEALERSHIP STATES (NOT OUR PROBLEM, PROVE IT.)

THE SEAT BELT LOCKS AND WILL NOT RELEASE UNLESS THE BELT IS COMPLETELY BROUGHT BACK IN.

THE INTERIOR DRIVER DOOR PANEL IS SPLITTING AT SEAM AND THE YELLOW FILLER IS NOW SHOWING.

WHEN I DRIVE AT SLOW SPEEDS TO PULL INTO A PARKING SPOT, GARAGE, TURN INTO A DRIVE WAY AND REVERSING OUT OF THESE SPOTS, THERE IS A LOUD CLUNK NOISE. WHEN TURNING THE STEERING WHEEL TO THE RIGHT.

80,000 MILEAGE STARTING WITH STEERING NOISY AND CLICK NOISY SOMETIME . POWERTRAIN LOOSES WHEN PARKING AND HARD TO SHUT OFF THE ENGINE.

VEHICLE MAKES GRINDING NOISE WHEN TURNING RIGHT. THIS VEHICLE JUST HAS 40K MILES AND THE STRUTS SHOULD NOT BE MAKING SOUNDS LIKE THIS. THIS HAPPENS WHEN THE VEHICLE IS IN SLOW MOTION AND IN REVERSE. THIS WAS RECALLED IN 2011-2014 BUT NOT IN 2015 AND I BELIEVE WAS IN AN ON GOING ISSUE. THESE VEHICLE WAS MANUFACTURED IN JULY 2014.

WHILE DRIVING RECENTLY MY CAR WOULD 'SPUTTER' WHILE AT A LIGHT ETC. WELL TODAY IT COMPLETELY DIES WHILE DRIVING (ABOUT 20MPG). IT EVENTUALLY RESTARTED AND I WAS ABLE TO DRIVE TO MY MECHANIC. THE VEHICLE COMPLETELY DIED WHILE PULLING INTO THE DRIVE OF THE MECHANIC WHO WILL TAKE A LOOK ON MONDAY. ALSO, HAD PROBLEMS WITH STEERING UNIT THAT FORD SAID NEEDED TO BE REPLACED. SAID THAT WOULD COST US ABOUT $1100 FOR A NEW MODULE. AT THAT TIME THE CAR HAD 40,000 MILES ON IT. CURRENTLY HAS 72,000. MY HUSBAND WAS GOING TO BY A F150 NOW SERIOUSLY CONSIDERING GOING WITH TOYOTA. HE'S HEARTBROKEN AS WE BOTH THOUGHT THE EXPLORER WOULD BE A RELIABLE CAR.

THE SIDE PANEL POPPED OUT IN THE FRONT PASSENGER SIDE OF THE VEHICLE FOR NO APPARENT REASON. THE FORD DEALERSHIP I TOOK IT TO WAS AWARE OF IT. THE SECOND ISSUE WE HAD AT 66,000 MILES WAS AN ERROR CALLED 'TERRAIN MANAGEMENT FAULT'. BOTH TIMES THIS ERROR OCCURRED, WE WERE MOVING. THE FIRST TIME IT HAPPENED IT FIXED ITSELF. THE SECOND TIME, WE HAD TO HAVE IT TOWED. THIS IS SO DANGEROUS AND SOMEONE IS GOING TO GET HURT OR KILLED. THEY HAD TO REPLACE THE THROTTLE BODY. PLEASE GET FORD TO A DRESS THESE SAFETY ISSUES.

I WAS DRIVING DOWN THE HIGHWAY AT 75 MPH AND HEARD A HUGE POP ON THE PASSENGER WINDOW AND SOMETHING BLACK FLY BY. WE PULLED OVER AND SAW THAT THE PLASTIC BLACK TRIM ON THE SIDES OF THE WINDSHIELD BROKE IN HALF AND THE RUBBER WAS HANGING OFF. I HAD TO CUT IT OFF. AFTER TAKING A CLOSER LOOK, IT APPEARS THERE ARE SEVERAL PIECES OF THE PLASTIC TRIM THAT ARE WARPING AND EVEN THE DRIVER'S SIDE PANEL WAS LOSE SO I'M SURE IT'S ONLY A MATTER OF TIME BEFORE THIS SIDE BREAKS OFF ALSO. I SEE OTHER PEOPLE HAVE HAD THIS HAPPEN TO THEM ALSO AND IT WOULD BE NICE IF FORD WOULD DO A RECALL ON THE PANELS, AS THEY ARE NOT CHEAP. EVEN THE BOARD THAT THE TRIM ATTACHES ITSELF TO IS COMING LOSE.

ON 4/14/19 WE LEFT FOR VACATION AND DROVE1,100 MILES FROM ARLINGTON, VA TO KEY LARGO, FL AND WHEN WE GOT TO FL, THE STEERING STARTED MAKING A CLUNKING NOISE AND GOT STUCK WHEN WE WERE MAKING A U-TURN. AFTER SOME RESEARCH, I COULD TELL IT WAS THE STEERING, COULD GIVE OUT WHEN DRIVING AND WAS A SERIOUS REPAIR THAT COULD NOT WAIT UNTIL RETURNING HOME IN A WEEK TO GET IT REPAIRED. WE DROVE TO LORENZO FORD IN HOMESTEAD, FL. ON 4/16/19. LORENZO FORD KNEW RIGHT AWAY THAT THE PROBLEM WAS THE STEERING. OUR EXPLORER HAD 41,339 MILES ON IT AND THE MECHANIC SAID IT WAS NOT UNUSUAL FOR THE STEERING TO GIVE OUT. HE ACTUALLY SAID IT WAS A PROBLEM BUT NOT A RECALL. THE REPAIR TOTALED $2,335.91. I THOUGHT WE WERE DRIVING A DEPENDABLE AND SAFE CAR ON OUR VACATION, BUT WE GOT TO SPEND A LOT OF TIME GETTING OUR CAR REPAIRED ON OUR VACATION. I'VE HAD NUMEROUS FORDS, AND HAVE ALWAYS CALLED MYSELF A FORD PERSON. SADLY, I DON'T LIKE THE DIRECTION FORD IS GOING AND THIS MAY BE MY LAST ONE. THANKS FORD FOR NOT MAKING QUALITY JOB #1 AND WRECKING MY VACATION. YOU NEED TO RECALL THIS BEFORE SOMEONE GETS HURT.

MY WIFE WAS DRIVING DOWN THE ROAD WHEN THE POWER STEERING SUDDENLY WENT OUT ALMOST CAUSING HER TO WRECK. SHORTLY AFTER A "STEERING ASSIST FAULT SERVICE REQUIRED" MESSAGE POPPED UP. AFTER SEARCHING THROUGH FORUMS AND GOGGLE IT SEEMS THIS IS A COMMON ISSUE THAT FORD REFUSES TO RECOGNIZE.

THE POWER STEERING FROZE WHILE DRIVING ON THREE SEPARATE OCCASIONS OVER THE LAST TWO DAYS. THE FIRST WAS WHILE PULLING INTO A PARKING SPACE, THE SECOND TIME WAS WHILE TURNING TO MERGE ONTO A BUSY TWO LANE HIGHWAY AND THE THIRD TIME WAS WHILE DRIVING 55 MPH MERGING ONTO THE FREEWAY. THE CAR WAS IN MOTION IN ALL THREE CASES AND HAD TO BE PUT IN PARK AND TURNED OFF BEFORE STEERING CAME BACK. MY WIFE WAS UNABLE TO TURN THE CAR WHEN IT HAPPENED TO HER BECAUSE SHE WASN'T STRONG ENOUGH TO OVERCOME THE FORCE.

POWER STEERING STOPS WORKING SUDDENLY; DUE TO FACTORY MISTAKE OR FAULTY PARTS OR MANUFACTURING. POSSIBLY CAUSING LOSS CONTROL AND CRASH OCCURRENCES. UNLESS YOU HAVE UPPER BODY EXTREME STRENGTH YOU CAN'T CONTROL THE STEERING WHEEL DUE TO THIS DEFECT. THERE HAVE BEEN PREVIOUS RECALLS BUT NOT FOR THIS YEAR OR MY VIN NUMBER DESPITE THE ISSUE BEING THE SAME. FORD REFUSES TO PAY TO REPAIR IT. ALSO, THIS ONCE REPAIRED CAN HAPPEN AGAIN.

CARBON MONOXIDE IN CABIN FROM LEKING EXAUST

THE VEHICLE HAS APPROX 42,000 MILES AND HAS STARTED EXHIBITING THE CLUNKING NOISE AND DIFFICULT TURNING AT LOW SPEED, SPECIFICALLY IN TURNING RIGHT, AS REPORTED IN MANY OTHER COMPLAINTS. LOOKING AT A $2K FIX AT SUCH A LOW MILEAGE WITH WITH SO MANY OTHER SIMILAR COMPLAINTS IS DISTURBING AND AMAZING WHY FORD IS NOT FIXING THIS.

1ST CONCERN: MY 2015 FORD EXPLORER IS AT 84,000 MILES. I HAVE CAPTAIN (BUCKET) SEATS FOR THE 2ND ROW. ABOUT 6 MONTHS AGO, MY SON COULDN'T GET OUT HIS SEAT BELT. THE RED BUTTON WOULDN'T RELEASE AND IT WAS TIGHT AROUND HIS WAIST, EVENTUALLY I WAS ABLE TO MAKE ENOUGH ROOM FROM HIM TO SLIDE UNDER THE LAP BELT. THE ESTIMATE I RECEIVED 3 WEEKS AGO WAS $230 NOT COVERED UNDER WARRANTY. I HAVE NEVER HAD TO REPLACE A SEAT BELT. 2ND CONCERN: THIS PAST WEEKEND TRAVELING 70 MPH ON A HIGHWAY I HEARD FLAPPING OUTSIDE THE FRONT DRIVERS WINDOW THE PANEL WAS SHAKING FOR ABOUT 30 SECONDS THEN FLEW OFF. BEFORE I COULD SAFELY STOP THE RUBBER THAT WOULD HAVE BEEN UNDERNEATH THE PANEL CAME LOOSE AND STARTED HITTING THE DRIVER'S SIDE WINDOW. I INSPECTED THE PASSENGERS SIDE AND IT HAS ALSO LIFTED AND WILL COME OFF SOON. I HAVEN'T HAD AN OPPORTUNITY TO GET AN ESTIMATE BUT I FEEL AS THESE ARE ISSUES THAT SHOULD BE HAPPENING. BOTH IN MY OPINION ARE SAFETY CONCERNS, NOTHING SHOULD BE FLYING OFF THE CAR AND SEAT BELTS SHOULD WORK.

HAVING A FEELING OF NAUSEA WHEN DRIVING EXOLORER. YESTERDAY AND TODAY WE HAVE BEEN RUNNING THE AC DUE TO HOTTER TEMPS. AFTER LETTING CAR IDLE FOR 5-10 MINUTES WHILE USING REMOTE START I START TO FEEL LIGHT HEADED AFTER ABOUT 20 MINUTES OF DRIVING. AFTER FEELING FINE ALL DAY. SEEMS TO BE ONLY WHEN THE CAR USES AC. TODAY I WAS IN THE DRIVE THRU FOR MY SON WHILE IDLING WHEN I STARTED TO FEEL LIGHT HEADED. NOTICED THE RECIRCULATION MODE TURNS ITSELF ON AFTER I TURNED IT OFF. THIS ISSUE IS QUITE CONCERNING. WAS SLATED TO HAVE RECALL FIX DONE AT CAPITOL FORD BUT ADVISOR SAID IT WASNT ATTACHED TO THE VIN SO THEY DIDNT DO IT.

AT THE EDGE OF THE HOOD THE PAINT IS BUBBLING, MY CLAIM AT FORD HAS BEEN DENIED AT UNDER 4 YEARS OLD.

CHECK ENGINE LIGHT CAME ON. TOOK THE CAR TO CONRAD'S. SCANNED CODE AND THE RESULT IS ENGINE TIMING CHAIN NEEDS TO BE REPLACED AND POSSIBLY THE ENGINE. HAVE QUOTES FROM MULTIPLE SERVICE STATIONS AND EACH ONE SAID THIS ENGINE HAS LOTS OF PROBLEMS.

HOOD HAVE DETAIL RETAINING DENTS. WHEN I BACK UP SWELLING SOUNDS

FORD MOTOR COMPANY (FORD) IS RECALLING CERTAIN WHEEL HUB BEARING ASSEMBLIES, PART NUMBER HB5Z-1104-C, INCORRECTLY LISTED AS BEING FOR INSTALLATION ON THE REAR AXLES OF 2011-2017 FORD EXPLORER 4X2 VEHICLES. THESE BEARINGS ASSEMBLIES WERE MANUFACTURED WITHOUT A SELF RETENTION FEATURE, POSSIBLY RESULTING IN THE SEPARATION OF THE WHEEL OR WHEEL END. IS NOOTGOOD

SLOW SPEED GRINDING NOISE WHEN TURNING. IN MOTION AND STATIONARY ON ALL SERVICES

WHEN ACCELERATING IN MY VEHICLE FROM A STOPPED POSITION AND WHEN DRIVING ON THE EXPRESSWAY, THERE IS A CARBON MONOXIDE ODOR AND I GET LIGHT HEADED AND HAVE HEADACHES AFTERWARD. THIS HAS CONTINUED AFTER MY VEHICLE WAS REPAIRED BY A FORD DEALERSHIP DUE TO THE RECALL. THIS HAS HAPPENED SEVERAL TIMES BEFORE AND AFTER THE REPAIR.

HAD THE RECALL DONE FOR (FSA 17N03) AFTER THE SERVICE WAS DONE, WE HAVE NOTICED WHEN PASSING ON THE FREEWAY OR GOING UP HILL, HOT AIR BLOWS OUT THE VENTS THEN A HEAVY ODOR OF EXHAUST. MY VEHICLE ALSO USES E85, SO WE HAVE RULED OUT MAYBE A CAR IN FRONT OF US. WHEN USING E85 WE GET A STRONG SMELL OF ALCOHOL TYPE. WE HAVE BEEN TO THE DEALERSHIP FOR THE SMELL, EACH TIME THEY WANT THE WINDOWS DONE OR HAVE THE A/C ON. I TELL THEM WE DON'T DRIVE WITH IT ON ALL THE TIME OR HAVE THE WINDOWS DOWN ON THE FREEWAY. EVERY 4-6 MONTHS MORE STORIES IN THE NEWS HAVE BEEN COMING UP WITH CONCERNS ABOUT EXHAUST SMELLS IN THE EXPLORER AND NOW FORD IS REDESIGNED THE VEHICLE. THIS SHOULD BE LOOKED AT MORE AND MAYBE WITH THIRD PARTY ENGINEER.

POWER STEERING FAILED AS I WAS PULLING AWAY FROM A GAS PUMP AFTER REFUELING. POWER ASSIST WARNING LIGHT CAME ON AND I WAS NOT ABLE TO TURN THE STEERING WHEEL UNLESS I USED A GREAT AMOUNT OF FORCE. LUCKILY I WAS STILL IN THE GAS STATION PARKING LOT WHEN THE FAILURE OCCURRED. THE CAR HAD TO BE TOWED TO A DEALER.

TL* THE CONTACT OWNS A 2015 FORD EXPLORER. THE CONTACT STATED THAT THE SERVICE STEERING WARNING INDICATOR FLASHED INTERMITTENTLY AND THEN THE STEERING WHEEL SEIZED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED BY AN AUTHORIZED DEALER OR AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,100.

PAINT IS PEELING ON THE EDGE OF THE HOOD. TWO EXPLORERS 2015 FAMILY OWNS AND PEELING IN THE SAME LOCATION. CONTACTED FORD AND WAS TOLD WE HAD TO BUY A NEW HOOD. THERE ARE MANY COMPLAINTS ON THE INTERNET SAYING THE SAME THING. THIS PAINT LESS HOOD NEEDS TO BE RECALLED DUE TO FACTORY FAULT OR REPAINTED HOW EVER FORD DOES IT. AROUND 2000.00 FOR A NEW ONE THEY TOLD US. PAINT SHOULD LAST MORE THEN 3 TO 4 YEARS.

AT AROUND 100,000 MILES DRIVERS SEAT BELT WOULD NOT LOCK OR UNLOCK...STARTED STICKING AROUND 95,000 MILES. NEVER HAD TO REPLACE A SEATBELT BEFORE ESPECIALLY IN A CAR THAT WAS ONLY THREE YEARS OLD. ALSO, AT AROUND THE SAME TIME THE DRIVERS SIDE WINDSHIELD PILLAR BROKE OFF AND FLEW OFF WHILE DRIVING ON THE HIGHWAY AT AROUND 65 MPH. THE PASSENGER SIDE FLEW OFF AT 115,000 MILES WHILE DRIVING ON THE HIGHWAY AS WELL. NEITHER IS COVERED BY WARRANTY AND OWNER WILL HAVE TO COME OUT OF POCKET TO COVER THE DAMAGES ($500+). HOW CAN FORD PUT ON SUCH CHEAP FINISHES TO THE CAR? NOISE LEVEL IN THE CAB IS AFFECTED DUE TO WIND NOISE. PASSENGER PILLARPOPPED LOOSE AND WOULD NOT POP BACK IN. APPEARED THAT A CLIP HAD BROKEN.

OUR 2015 EXPLORER SPORT WITH 60550 MILES HAD THE CHECK ENGINE LIGHT COME ON FOR ONE DAY, THEN TURNED OFF. WE HAD IT DIAGNOSED IMMEDIATELY AND WERE TOLD THE CAR NEEDED A TIMING CHAIN ($3200). THE LIGHT CAME ON DURING NORMAL DRIVING CONDITIONS AND THE NEXT DAY WAS NOT LIT. THE LIGHT CAME ON RIGHT AFTER THE WARRANTY PERIOD EXPIRED, AND FORD WOULD NOT HELP WITH REPAIRS. FOR SUCH AN ISSUE TO OCCUR SO EARLY AND RIGHT AFTER THE WARRANTY IS EXTREMELY DISAPPOINTING.

CAR WAS IN MOTION IN NEW YORK CITY, VAN WYCK EXPRESSWAY SERVICE ROAD. THE CAR JUST SHUT OFF ON 3/17/2019, 4:30 PM THE DASH BOARD SIGNALED POWERTRAIN, DEALER STATES TIMING CHAIN ISSUE. VEHICLE PURCHASE USED WITH 59,000 MILES ON FEBRUARY 2018. CHECK ENGINE LIGHT WAS ON SINCE MARCH 2018. CURRENTLY 82,600 MILES. BEEN TO THE DEALER SEVERAL TIMES FOR ADDITIONAL PROBLEMS. I HAD TO REPLACE THE BATTERY HEADLIGHTS , HEARTNG MOTOR, THERE ARE LEAKS INTO THE CAR THAT HAVE NOT BEEN REPAIRS. THE CAR IS LOW FALLING APART :( .AND HAD TO PAY OUT OF POCKET SINCE EXTENDED WARRANTY DID NOT COVER EVERYTHING.. NOT GETTING STRAIGHT ANSWERS FROM FORD OR THE DEALER. THANK GOD I WAS ON THE SERVICE ROAD AND GOING 25 MPH STOPPED AT A LIGHT. THE CAR NEVER STARTED AND HAD TO BE TOWED TO THE DEALER.

THERE ARE OFTEN ISSUES WITH THE RADIO AND HEATING SYSTEM. RADIO TURNS ON AND OFF BY ITSELF AND SO DOES THE HEAT AND AIR CONDITIONING. IN ADDITION, I HAVE COMPLAINED ABOUT SOMETHING MAKING ME DIZZY AND NAUSEOUS IN THE VEHICLE. IN INFORMED THE FINANCE COMPANY REGARDING MY INABILITY TO BREATH, FOR WHICH I WAS HOSPITALIZED. I HAVE BEEN HOSPITALIZED ON NUMEROUS OCCASIONS SINCE THE PURCHASE OF THE VEHICLE AND HAVE INFORMED THE FINANCE. FURTHERMORE, THEY HAVE BEEN ADDITIONAL HOSPITALIZATIONS IN 2018, FOR WHICH I WILL HAVE TO UPLOAD THE DOCUMENTS AT A LATER TIME.

I PREVIOUSLY REPORTED A POSITIVE CASE FINDING OF CARBON MONOXIDE POISONING ON 03/22/19 SECONDARY TO A LARGE AMOUNT OF EXHAUST TYPE FUMES ENTERING MY VEHICLE THROUGH THE VENTILATION SYSTEM UPON ACCELERATING FROM STOPPED POSITION TO ACCELERATION TO 70 ON INTERSTATE WITH CLIMATE CONTROL ON. ON 03/26 /19 I AGAIN EXPERIENCED THE SAME OCCURRENCE PRIOR TO DRIVING TO FORD DEALERSHIP WITH VEHICLE IN PARKED POSITION IN DRIVEWAY WITH CLIMATE ON AUTO HEAT. AN ODOR OF EXHAUST FUMES WAS NOT EXPERIENCED HOWEVER CAR AUTOMATICALLY TURNED ITSELF TO AC AND COLD AIR CAME IN ON ITS OWN PRIOR TO DEPARTURE. I SHUT ALL CLIMATE FUNCTIONS OFF AND ROLLED DOWN ALL WINDOWS, I WAS VERY COLD SO ROLLED I UP 3 WINDOWS AND HEATED SEATS AND HEATER 10 MIN FROM DEALERSHIP. THEN AGAIN ACCESSORY AIR KICKED ON ACCESS I BEGAN HAVING I BEGAN EXPERIENCING BLURRED VISION AND LIGHTHEADEDNESS I ROLLED DOWN ALL WINDOWS . I ARRIVED AT FORD SERVICE AND VIN LOOKUP WAS PERFORMED AND I WAS TOLD THERE WAS A RECALL FOR CARBON MONOXIDE CONCERNS. I WAS DRIVEN TO HOSPITAL AND AGAIN TREATED FOR ACUTE CARBON MONOXIDE POISONING AND ADMITTED FOR ADMINISTRATION OF 10 LITERS ON A BREATHING MASKS FOR 6 HOURS THIS TIME. MY CARBOXYHEMOGLOBIN WAS EVEN HIGHER AT 6.6% AND PA O2 WAS IN THE 80?S AND NORMALIZED TO 1.5 BEFORE DISMISSAL. I EXPERIENCED SEVERE MENTAL CONFUSION AND SLOWED SPEECH FOR 2 HOURS AFTER EXPOSURE. MY CAR READINGS SHOWED A CONSTANT LEVEL BETWEEN 10 AND 15 FROM FROM OSHA DETECTOR BORROWED FROM JOB SITE WITH A HIGH LEVEL OF 30.4

WATER PUMP STARTED LEAKING AT 54000 MILES RIGHT OUT OF WARRANTY. WAS TOLD NEEDED REPLACEMENT OR ELSE ENGINE WOULD SEIZE. PAID OVER $2,100 TO GET IT REPLACED. STUPID DESIGN AND HARD LABOR TO GET TO IT. CAR HAS VIBRATION NOW EVER SINCE WE HAD IT REPAIRED BUT THOUGHT IT WAS NORMAL LEAVING DEALER. I DON'T KNOW WHY THIS HASN'T BEEN RECALLED. NOW, THE PARKING AID WENT OUT. THESE CARS ARE HORRENDOUS