2019 Ford Expedition complaints

I had a complete transmission replacement 3 weeks ago and as I was driving down a grade, the car started smoking. I immediately took it back to dealership that had just replaced the transmission. They stated that the new transmission was "factory overfilled" that caused the smoking. They called Ford and now I am on my 3rd transmission. It was covered under the warranty of the transmission I paid 3 weeks ago. This was very scary as we were traveling as a family when the car started smoking. Our car could have started on fire.

The contact owns a 2019 Ford Expedition. The contact stated while driving at various speeds, the vehicle intermittently came to an abrupt stop without any other objects or vehicles nearby. The emergency braking image followed by a warning chime would appear on the instrument panel during the failure. The contact had taken the vehicle to a dealer where he was informed that the failure could not be duplicated. An investigator was sent to inspect the vehicle and the brake module was replaced. Despite the repair, the failure persisted. The computer and battery were both replaced after the initial repair but failed to fix the vehicle. The manufacturer was notified of the failure and the contact was provided a case number. The vehicle was not repaired. The failure mileage was approximately 22,000.

The transmission in my 2019 Ford Expedition is slipping and having drastic gear changes. Other people with the 10R80 transmission are having similar issues. This car is unsafe to drive.

Hard shifting, getting stuck in high gears while stopped. Vehicle is only at 75,000 miles. Ford service says transmission needs to be replaced and it's extremely expensive.

The chrome interior trim on the center console (around the drink holder and shifter, as well as the smaller compartments) in the limited edition is defective and edges are lifting to the point that razor sharp edges are exposed and have cut open my hands, as well as the hands of my children. I asked them to replace it under my warranty and they declined. This part is defective and there are reports of others experiencing this online. The material used seems to be lifting and is not adhering properly. The part started lifting around 36,000 miles and continues to lift. The edge, again, is extremely sharp. WE have continually cut ourselves just reaching to grab a drink.

Transmission shifts really hard , will not go into gear, and downshifts unexpectedly. Dealership said if they cannot make it happen on test drive nothing they can do. Ongoing problem with thousands of vehicles. 10 speed Transmission is the problem.

Our 2019 Ford Expedition MAX (75k miles), has a transmission that disengages while driving (wrench light on; powertrain system failure limp mode; incorrect 4th gear ratio error code). A mechanic diagnosed it as an inner sleeve of the C-D-F drum moving out of position needing a full rebuild or new transmission. The vehicle has lost total drive train power while driving in traffic at speed. Whenever there is a need for up shift or down shift, the vehicle will intermittently stutter, slip/grind gears, rev up, or lose power completely. This has put my family in danger on the road. The car is dangerous when attempting to pull onto roads with moving traffic. It is concerning that Ford has not issued a recall.

My 2019 Ford Expedition Max- Limited: Shifting was starting to get rough and car was jerking between gears. It was unsafe as it would not speed up in the highway and it would jerk all of a sudden. Transmission failed at 88K miles. I had to pay over 8K at the Ford Dealership to get a whole new transmission placed after various attempts to deal with issue failed. Ford Company could care less about their faulty transmissions. No warning lights ever came on other than the harsh shifting that suddenly started within a week's time.

The contact owns a 2019 Ford Expedition. The contact stated that his wife was unable to unlatch the front driver’s side door. The contact called the local dealer and made them aware of the failure. The vehicle was not diagnosed or repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 32,077.

The transmission randomly switches gears, both down and up. At times, the car will just downshift and appears to lose power. Especially when attempting to pass other vehicles. This can be a dangerous situation, and has been. It also has caused a near accident on a snow covered road by 'taking off' in a high gear which caused the card to slide into the oncoming lane twice. I have taken this car to the dealership service department 4 times, they say there are no codes or recalls and just reset the computer to have it relearn my driving habits.

Vehicle has harsh shifting mainly gear 3-5 almost like being brake checked. The vehicle revs to 4000 rpm and won’t accelerate then slaws into gear causing the car to lurch forward and illuminate wrench symbol. Latest issue is car accelerates on it’s on and almost drove it on a drainage ditch pulling in my driveway.

Our 2019 Ford Expedition MAX (50k miles on it), has a transmission that disengages while driving. The vehicle has lost total drive train power while driving in traffic at speed. Whenever there is a need for up shift or down shift, the vehicle will intermittently stutter, slip gears, or lose power completely. This has put my family (pregnant wife and two children under 4) in extreme danger on the road. In one incident her only available course of action was to attempt to coast off the road while in the midst of moving traffic with speeds in excess of 50+ miles per hour around her. The car is dangerous, attempting to pull onto roads with moving traffic, is now extremely worrying. It is unconscionable that this vehicle issue has not resulted in a recall.

The vehicle has problem when shifting gears, and complete loss of power occurs. When trying to enter a road or cross a street, the vehicle can start to move then lose power in the middle of an intersection or lane. A loud clicking can also be heard after power is lost.

Both Rear shocks leaked oil at 37k causing vehicle to become very bouncy and unsafe to drive/control

FYI re: Request #[XXX] Let me know if you have any info I sent this letter on November 20, 2022 and as of January 10, 2023 I have had no response from Ford Motors: [XXX] Office of the CEO Ford Motor Company 1 American Road Dearborn, Michigan 48126 Re: 2019 Ford Expedition ACC-Cruise Control Potential Safety Problem Mr. [XXX], I wanted to let you know of a bizarre recent ACC cruise control issue with my 2019 Expedition. It has ~30,000 miles on it and has performed very well without problem before and after this incident. Several weeks ago I was driving on an interstate highway in a construction zone with stop and go traffic, and had the ACC on. I slowed down behind a dull colored black Chevrolet pickup that had dark lens covers over the tail lights and a dark cover over the license plate to about 5 MPH. Suddenly the ACC had full acceleration then the auto safety braking slowed me abruptly, then the ACC hit full acceleration again and the auto brake engaged. I turned the ACC off, and then back on, and it did the exact acceleration and safety braking so I turned the ACC off. There was no accident or problem other than this acceleration/braking sequence. When I no longer was behind the pickup I tried and ACC and it has worked perfectly since then, as it had prior to this bizarre issue The ACC seemed to not see this pickup truck but the auto safety braking system did. The pickup was an unusual non factory appearing paint job, dark gray or black not just a primer, and the tail ligh

The contact owns a 2019 Ford Expedition. The contact stated that while driving at an undisclosed speed, there was a vibration in the front differential. The contact stated that the vehicle felt like it was being driven in 4-WD however, the vehicle was in 2-WD. There were no warning lights illuminated. On another occasion, while driving approximately 30-35 MPH, there was a vibration and shimmy in the steering wheel. The vehicle was taken to the local dealer in July 2021 where it was diagnosed and determined that the failure was due to the front differential. The vehicle was repaired but the failure recurred. The manufacturer was contacted, and the contact was referred to the NHTSA Hotline. The failure mileage was approximately 47,000.

The contact owns a 2019 Ford Expedition. The contact stated upon starting the vehicle, he heard an abnormal sound coming from the engine on several occasions. There was no warning light illuminated. The vehicle was taken to the local dealer who informed the contact that the VIN was not included in Customer Satisfaction Program Number: 21N03 (Cam Phaser Replacement). The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 61,900.

All four struts are leaking and causing erratic handling when rough roads are encountered. FORD has known of this problem for several years and refuses to replace after their base warranty, even though I have a full coverage extended warranty. If a consumer doesn't realize they have a defective suspension it could lead to their death. FORD has a service bulletin out on this problem. - strut, yes -yes -yes -yes -no, leakage of oil on garage floor

While driving down the road, my vehicle suddenly drops from a higher gear down to 2nd. When this happens, the RPMs jump very high and the engine revs very high. While this is happening, I have no control and I can't use the gas pedal and am losing speed. The vehicle seems to be stalling. There are two messages that flash on the screen. "Shift system fault" and "see Manual". Neither are in the manual. I have taken it to Ford and after a day, they said nothing is wrong and collect almost $200. I took it in before my 75,000-mile transmission warranty was out. They said they have never heard of such a problem. I have now research it have found many people with the same on expeditionforum.com. It happens on a daily basis now and it's my only car and my learner car for my 15 year old. It WILL cause an accident. I did finally get it on videa and will make another attempt with FORD next week.

The contact owns a 2019 Ford Expedition. The contact stated that while her husband was driving approximately 40 -45 mph, he collided with a Volkswagen Jetta that cut him off. All the airbags in the vehicle deployed. The contact son was occupying the front passenger seat but the seat belt failed to retract. There were no warning lights illuminated. The steering wheel air bag struck the driver in the mouth. The passenger had scratches, but medical attention was not provided. A police report was filed. There was no reported fire. The vehicle was towed to an independent lot. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was notified about the failure but provided no additional assistance. The failure mileage was approximately 89,000.

All lenses on the front headlights have stress cracks forming in the corner of the housing. This has allowed moisture and condensation to build inside the housing and is altering the light output.

The Ford series of Trucks/SUVs from 2018-2022 are equipped with an Automatic Start/Stop feature which turns off the engine when the brake is depressed, and the engine is idling. On 4 occasions in the last month, when releasing the brake to start accelerating from a stop, the vehicle's engine has completely stalled/turned off disabling the vehicle and requiring the vehicle to be shifted in to park, restarted, and then attempted to drive. This causes an obvious safety risk if turning in front of traffic, vehicles behind you moving, etc.. When researching this online there are multiple complaints on this issue, specifically for the F-150 which uses the same components. Ford will not admit there is an issue and refuses to respond to owner complaints on this obvious safety risk. I would ask that the NHTSA looks further into this issue and the risk to consumers.

The contact owns a 2019 Ford Expedition. The contact stated that he had noticed oil leaks on his garage floor. The contact took the vehicle to a dealer where he was informed that all four of the struts on the vehicle had leaked oil and needed to be replaced. The service advisor also informed him that the warranty provider was contacted and informed the dealer that the cost of the repair would not be covered. The manufacturer was notified of the failure but was not offered any assistance. The vehicle was not repaired. The failure mileage was 59,584.

Transmission failure 4 occurrences after dealer repair under warranty. The transmission issues are very well documented and dealer has returned vehicle to parent with kids in vehicle..within 20 miles vehicle stooped on I-40 traffic endangering lives 3rd failure. Returned vehicle to dealer and when told vehicle was ready it made 15 miles prior to overheating and ceasing to accelerate out of traffic endangering lives. These are the last 2 times vehicle was returned. 2 prior when we were told the vehicle was ok and loss of acceleration, grinding, jerking were normal. Vehicle currently at dealer. Communication with Ford with little assistance. Prior to these failures were cam phasers with 4 similar failures and almost burned my garage down. This vehicle and many others are not safe and should be addressed.

The main interface screen for GPS, Radio, Bluetooth (hands free phone operation), backup camera, and other vehicle settings, is malfunctioning and frequently non-responsive. This is tied to a faulty ACCESSORY PROTOCOL INTERFACE MODULE (APIM), also known as the SYNC 3 Module. Research on the issue shows this is a common issue with Ford Vehicles. The fixes reported in TSB 20-2255 05 August 2020 have been completed, the issues are persisting. The failure of this item creates safety issues with operating the vehicle. Similar issues have been reported in 11321932, 11300724, 11052887.

The contact owns a 2019 Ford Expedition. The contact took the vehicle for an oil changed was informed that the high-pressure fuel pump had caused the fuel and oil to mix. The failure was related to NHTSA Campaign Number: 18V392000 (Fuel System, Gasoline) however, the VIN was not included. The vehicle had not been repaired. The manufacturer was made aware of the failure and opened a case regarding the failure. The approximate failure mileage was 83,000.

The vehicle started to rough shift. Then it started to not shift into gear, and the engine will rev as if in neutral instead of in gear. This has resulted in abrupt loss of power and the vehicle actually shutting down completely requiring restart. I called my Ford dealer (Columbia, TN) when it started shifting rough. They told me it was 2mos out for transmission issues. I called another Ford dealer in Franklin, TN whom also said months before they could see it. They referred me to a local transmission shop. That shop Coleman transmission, said these transmission in 2018&2019 are notorious for failing and were redesigned by 2020, that he had many just like mine awaiting rebuild. So I started researching, and I’m not alone, and many have had this exact same extremely dangerous situation of losing power, and car shutting down repeatedly.

The contact owns a 2019 Ford Expedition. The contact stated that upon starting the vehicle, the engine started rattling. No warning lights were illuminated. The vehicle was taken to the dealer where it was diagnosed that the cam phaser adjuster needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was advised to call the NHTSA Hotline for assistance. The failure mileage was approximately 103,000.

The contact owns a 2019 Ford Expedition. The contact stated that the vehicle was taken to the local dealer for maintenance service and he was informed that the rear passenger’s side strut was leaking and needed to be replaced. The vehicle was repaired. The contact stated that while driving at various speeds, he heard an abnormal sound coming from the front of the vehicle. The contact stated no warning light was illuminated. The contact took the vehicle back to the local dealer and the vehicle was diagnosed and the contact was informed that the front passenger’s side strut needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was 24,195.

A message on the instrument panel, and a red braking warning light the breaking start to get havey risking car crashing. Similer to issue NHTSA campaign number: 22V150000.

The contact owns a 2019 Ford Expedition. The contact stated while starting the vehicle, the vehicle made abnormal rattling sounds. The vehicle was taken to the dealer where it was diagnosed that the failure was related to Customer Satisfaction Program: 21N03 (Cam Phaser Replacement) however, the VIN was not included. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 62,000.

In April 2021 while driving, the car abruptly when into low power mode. I drove it straight to ford. They pulled the codes and said there was nothing wrong. Ever since then, the car will randomly make a grinding sound, lose power, a wrench flashes and then it goes back to normal. It has done with several times on the freeway upon acceleration. The dealerships cannot replicate.

On multiple occasions while driving at freeway speeds, there have been sudden episodes of power loss and rapid loss of speed associated with harsh transmission downshifts. These events sometimes occurred on slight uphill grades and also on flat highway. At other times, the transmission will fail to shift into higher gear and seem to slip, resulting in loss of speed. A warning indicator appeared on the last occasion (8/27/22) with a wrench icon, and the FordPass app told me to have vehicle serviced. Vehicle is at dealer now.

Driving 70 miles per hour part of the roof rack blew off the vehicle; the molding and front cap on the driver side of the vehicle. The roof rack had never been used. A Ford dealer inspected the area where the parts were and could not determine what caused the failure.

With approximately 42,600 miles on 2019 Expedition, two Ford Service Centers diagnosed the vehicle control issue as suspension related. Specifically, loss of vehicle control due to shocks. Upon inspection by Ford, shocks were found to be leaking and not providing adequate suspension. Two separate Ford Service Centers advised replacement of all four shocks. Wife had been complaining about this for a month or more (June/July 2022). I didn’t believe her until weeks later I drove her car and two Ford Service Centers conforming all shocks needed replacement. I just could not believe at 42,000 miles all shocks needed replacement nor could Ford Service Center. Nor could I believe the severity of control. I experienced loss of control similar to a bucking horse with my head hitting the interior roof of the Expedition. My hands, both, were suddenly off the steering wheel due to up and forward bucking. I was able to slow the Expedition down by braking and regaining the steering wheel. I was luckily. Speed was below 45 mph. No warning lights or voice occurred. This occurred in August 2022.

Our SUV has had problems in trying pick up speed. It started a few years back when I was taking a right turn and as I pushed on the gas pedal the SUV would not take off. We took it into the dealership but they could not recreate this problem. Yet, the problem persisted for us so we took it again to a different dealership and again they could not recreate the problem. Now our check engine light is on and the problem is getting worse. I called the dealership last week to bring it in and they could not get me in until mid-Septmember. One major incident occured when we were merging on the highway with lots of traffic and the SUV would not pick up speed. Some warning lights came on our dashboard and we had to immediately pull over to the side because the SUV would not pick up speed and it starting puttering. We were almost hit from behind by another vehicle due to the SUV not picking up speed. This problem has progressively been getting worse and I am afraid to drive the vehicle anywhere. I could be driving as slow as 30mph and trying to speed up causes the SUV to shake and putter. Now, when this happens the A/C does not cool. It feels like the SUV will shut off while I am driving. Plus, now the Engine Start/Stop feature no longer works. We have 4 kids and I am scared to drive this SUV as I feel this may cause us to be in a car accident. This is a major safety issue that needs to be addressed.

The contact owns a 2019 Ford Expedition. The contact stated when she started the vehicle, she would hear rattling sound coming from the vehicle. The contact stated she had the Customer Satisfaction Program: 21B10-S2 service performed. The vehicle was taken to the dealer and the contact was informed that the failure was similar to Customer Satisfaction Program: 21N03 – Cam Phaser Replacement but the VIN was not included. The manufacturer was contacted and stated that the vehicle was not serviced in a timely manner, therefore the vehicle had to be repaired out-of-pocket. The failure mileage was 71,000. The consumer was never made aware of any recalls, consumer went to dealer for other parts but was informed to make an appointment for repairs. Ford was contacted several times but unwilling to resolve the issue.

The contact owns a 2019 Ford Expedition. The contact stated upon starting the vehicle, the engine emitted abnormal loud rattling sounds. There was no warning light illuminated. The contact stated while driving 60 MPH, the vehicle would not shift from first gear to the other gears automatically. The contact was able to continue driving. The vehicle was taken to the dealer who informed the contact that the Transmission Control Module (TCM) needed to be reprogrammed; however, the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA for assistance. The contact referenced Ford Customer Satisfaction Program Numbers: 21B10 21N03 and 21N08. The failure mileage was approximately 29,000.

The contact owns a 2019 Ford Expedition. The contact stated that while starting the vehicle, there was an abnormal rattling sound detected. There were no warning lights illuminated. The contact called the local dealer but the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure but no additional assistance was provided. The approximate failure mileage was 65,000.

The contact owns a 2019 Ford Expedition. The contact stated that every time he started the vehicle, the engine would rattle and make a loud noise. The contact stated no warning light was illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined there was manufacturer internal recall 21B10 that was to address a PCM Re-flash failure. The contact was advised by the dealer that his warranty did not cover the repair. The contact did not have the vehicle repaired. The manufacturer had been informed of the failure. The failure mileage was 70,236.

The 2019 Expedition 10 Speed Transmission went into neutral during acceleration from third gear, skipped 4th and finally reengaged in 5th with a huge jolt. This happened a second time after leaving the next stop sign. During the neutral period ( approx. 3 or 4 seconds) engine RPM's increased dramatically with loss of forward motion and speed. My reaction was to remove my foot from the gas pedal before the engine red-lined. This issue could have caused vehicles behind to rear end our 2019 Ford Expedition. The transmission was at full temperature as the expedition had been driven for approx. 30 minutes prior to the issues. We then parked the expedition for about an hour and then started the drive home and the neutral issue occurred once again. The transmission hard shifting issues were first noticed in March/April 2022 had been reprogramed in June, 2022 which didn't resolve the problem. It was then serviced late July 2022 by rebuilding a control module(?). We were told to drive the vehicle for a couple of weeks while the transmission learned how we drive and everything would return to normal. Currently have returned the Expedition to the dealer as this is a serious safety issue. Hard shifting or even jumping a gear with a jolt isn't going be a danger, but losing power and control of the Expedition could have caused an accident and possible injury to us and others.

The first incident I was travelling on the highway at approx 60-70 mph and attempting to overtake a slower car by switching lanes. As I changed lanes and hit the gas, my Expedition became stuck between gears and lost power until I let off the accelerator and the rpm's came down. This happened on several occasions with similar circumstances. The other times it's been stuck between gears are typically when I am turning left. The loss of power and basically being in neutral while on the highway or turning left is a specific safety hazard that needs prompt attention. I am dropping it off at the dealership tomorrow and I'm sure they will be "unable to recreate the problem" and I'll have to wait until the recall for it to be fixed.

The Sync 3 System (APIM module) is faulty. Causing phone to connect/disconnect constantly, radio controls are delayed for 30 sec pauses or greater, changing from radio to climate will superimpose both categories on top of one another. Navigation sometimes just loads and loads and never comes on. The steering wheel controls create an even longer delay. I went to my local Ford dealer and had a master reset done which did not change the issues and was told that one or both of the modules is not working right "Malfunctioning " Latest updates to both the Sync and Navigation were preformed after the factory reset with no improvement to the system. With new state laws requiring hands free phone usage having the phone connect/disconnect constantly poses a very large safety problem. Also not being able to rely on the system to preform basic functions in a reasonable period of time causes your eyes to leave the road unnecessarily while driving.

This vehicle has only 10300 miles and never driven off road and the struts have failed. An independent garage confirmed the drivers side front strut is leaking and both rear. My Ford dealer stated they would replace the front and one rear under warranty but the second rear strut is leaking within Ford's "tolerances". This is just Ford's way of avoiding a warranty claim and hoping the bad leaking doesn't start until after the customer's warranty expires so they can reap thousands of dollars in repair revenue. I was also told by the Ford dealership that the FoMoCo replacement struts often arrive at the dealership leaking and they would not call me in for an appointment to replace until they have confirmed they received replacement struts that are not defective. My research shows this is a common problem with this vehicle and the NHTSA should investigate and force a recall since failed struts can cause a serious accident.

My family received a notice of Customer Satisfaction Program 21N08 – PCM Reprogram Due to Engine Shudder – 2017-2020 Ford F-150, 2018-2020 Expedition, & 2018-2020 Lincoln Navigator. We immediate began trying to locate an authorized repair facility. It took several months to get an appointment. During this time, our vehicle shuddered, stopped, and even turned off completely while driving. The problem continued to increase in intensity. When we were able to get the vehicle into a Ford dealership, they suggested that we contact Ford for the repairs that we needed. A private repair facility told us that now, because the shudder issue was not resolved right away, they discovered VCT phasers, VCT solenoids, timing chains and tensioners - failed setting code P0021 and causing engine to run rough. There was a loud rattle on startup which is related. P0018 stored in history. We have received a $4,000 repair estimate. I contacted Ford Customer service. They suggested I bring it into Ford Dealership. I explained that it had taken months to get in the first time. Customer service refused to provide me with additional authorized Ford repair (non dealers) in my location. Customer service refused to provide me with information on the error codes above. Customer service refused to provide me with more information concerning the PCMC reprogram and the known problems related to failing to obtain the reprograming. Customer service was not able to help me at all. I believe that the “PCM reprogra

The vehicle only has 38K miles on it and all 4 struts have failed. This is apparently a very common problem for Ford. This creates control issues and an unsafe ride. I had the vehicle in for a different recall and the Ford dealership confirmed all 4 are leaking and need to be replaced, but Ford will not cover them.

Both the driver side and passenger side front struts have leaked oil and failed. The driver side occurred after 33,000 miles and the passenger side at 45,000 miles.

The ecoboost 3.5 engine has a common issue with the cam phasers. My vehicle has had oil changes done, every 9,000 miles and now needs the cam phasers to be replaces. It has 83,000 miles. I believe this is a known defect that Ford is trying to remedy with customer satisfaction campaigns, rather than a recall. Had the 21b10 tsb performed and which is a requirement and the car shudders and the transmission shifts poorly. Also, the driver's side seat best will not retract fully.

My vehicle started jumping gears. It felt like I was manually changed gear.

•Vechicle is a lemon car by definition and needs to be replaced due to safety issues and the amount of calls in the short duration I have had it in my position •My family and I have been leveraging other family vechicle along side putting the car dormant as much as we can to avoid further mechanical issues which is not acceptable •The request to ask for 4 to 6 weeks on a car repair without loaner is unacceptable as the loan payments are still due by me to the lender and are unable to utilize the car in any capacity •The issue has been open for about 10 months since reporting with NO resolution - unacceptable •Dealership purposely delayed and provided incorrect information and allowed the warranty period to expire as it would provide revenue of service to the business (recalls are free) Please see the attachment for a detailed timeline and supporting documents