2018 Ford Expedition complaints

My wife was driving home from a sports class with my kids in the car. She went to make a left turn against oncoming traffic and the car completely lost power. Pressing the gas did not give any power to the car and the car felt like it was in neutral. if the car did not have enough power at the time of the turn to make it through the oncoming lane, it would have been hit by the oncoming car endangering the lives of the occupants of both vehicles. Our vehicle continued to exhibit the same behavior and I drove it to the dealer. While on the way to the dealer it had 2 powertrain failures before I got it there (30 miles away). The dealership ran diagnostics and said it would be best to get a new tranny as opposed to overhaul since the vehicle only has 90,000 miles and is less than 7 years old. We ended up getting it towed to a local transmission shop who confirmed the diagnostic. They said the seal on the CDF drum plate failed and there was nothing that could be done to stop it. The tranny was rebuilt with all new parts, half a dozen of them upgraded parts from Ford. Upon researching the symptoms, I found this vehicle exhibited a neutral out condition and Ford wrote a technical service bulletin because this issue is so common. I'm frustrated because my family could have been seriously injured or killed because of a known issue that Ford knows about yet chooses to not fix even though this issue puts passengers in life threatening situations. I would not have known about this issue

The contact owns a 2018 Ford Expedition. The contact stated while driving at an undisclosed speed, there was a loud clanking sound coming from the vehicle with smoke coming from the engine compartment. The vehicle was taken to the dealer where it was diagnosed and determined that the heater hose and cam phaser had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 118,000.

The contact owns a 2018 Ford Expedition. The contact stated while the vehicle was parked, the gear shifter was shifted into drive; however, the vehicle failed to respond as intended. The contact stated that several unknown warning lights were illuminated. The vehicle was taken to the dealer where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 115,000.

I have had several issues with this vehicle throughout the years I have owned it. The current issues I am writing about include: transmission failure and replacement, rear passenger door no longer opening and continued issues with the Catalytic convertors. When it comes to the transmission it was unsafe to drive as the gears continued to slip while driving and cause the vehicle to temporarily loose power. This could have resulted in an accident. The vehicle is currently having the transmission replaced at a repair shop where they confirmed the issues. They will also be looking at the other two issues as well. The door not opening poses a huge safety concern as we are only able to use one rear door for entering and exiting.

See attached document for complaint.

2018 Ford Expedition Max 4wd; For the last 4 years I have consistently (1-2x a year) brought this car into a ford dealership for the transmission failing to go into gear at random times while driving under normal conditions. Even though multiple TSB's had been sent out, they "couldn't replicate" or "no codes found" or "the transmission tech is 4–6 weeks out"... nothing was done. Twice while merging into on coming traffic the transmission has been stuck in a gear, will not accelerate or go, and the entire dash illuminates with all the flashing symbols. I'm just glad my children were not in the car with me. It was terrifying. Now, the week of May 18, 2025, I'm back for my annual transmission issue as it stalled on 4/26/2025, and I almost was hit by an 18 wheeler, the ford dealership said "you need a transmission overhaul, TCM reprogram, and there is internal failure, the CDF drum comes apart and Ford is aware they have a faulty seal." The total to fix is $8,214.25 and guess what, NONE of it is covered. I have kept my vehical serviced and always taken care of it. But I will have to pay the price to fix it, or worse if there is a car accident.

The contact owns a 2018 Ford Expedition. The contact stated while driving at an undisclosed speed, the Check Engine warning light was illuminated. The vehicle was taken to a dealer, where it was diagnosed that the cam phasers needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 117,000.

The contact owns a 2018 Ford Expedition. The contact stated that occasionally while driving on the highway at 70 MPH, the vehicle lost motive power and failed to accelerate above 70 MPH. There was no warning light illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed, and the contact was informed that there was not fault found with the vehicle. The vehicle was not repaired. The contact referenced Emission Recall: 24E13; as probable cause for the failure. The manufacturer was notified of the failure. The approximate failure mileage was 80,000.

1. The issue involves the transmission and camshaft components of the vehicle. Despite the fact that both the transmission and camshaft were replaced by the Ford dealership after purchase in 2018, the vehicle continues to experience problems. These components have been inspected by the dealership, and the vehicle is available for further inspection upon request. 2. The vehicle’s loss of power during highway driving and while attempting to accelerate poses a significant safety risk. On several occasions, the vehicle has lost power while making turns or driving on the highway, nearly causing accidents with other vehicles. This has been a very frightening experience for us, as the sudden loss of power could have led to a collision. 3. Yes, the problem has been confirmed by the Ford dealership, which replaced the transmission and camshaft components. However, the vehicle continues to run roughly, indicating that the issues have not been fully resolved. These repairs were not covered under warranty, and we had to pay for them out of pocket. 4. The vehicle has been inspected by the Ford dealership multiple times. Despite the repairs, the problems persist. The vehicle has been regularly maintained and garage-kept. 5. There were no warning lamps, messages, or error codes indicating the problem before the failure. However, there has been a loud ticking sound when the vehicle is started and running, which started to occur after the initial repairs. The vehicle has had no other prior in

Cam phaser failure, yes, available for inspection. This disrupts the engine's timing and can lead to oil pressure issues as well as engine stalling or engine damage. Yes, confirmed by ford dealer. No, not been inspected by manufacturer or others. No warning lamps yet but the noise was the first indicator and it began about 6 weeks ago. My 2018 Ford Expedition is experiencing cam phaser failure. I had an extended warranty that i have not reached the mileage for yet but the date causes me not to be able to have it fixed under warranty. This is a very expensive repair and I am finding out more and more of these vehicles in this age range are having the same problems. I would ask that Ford be required to pay for this repair. I have reported this to Ford and received a case number of [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Defective daytime running light, passenger side, that does not fully illuminate. I’ve noticed this on several of the same make, model, and body style (with the same DTRLs).

The contact owns a 2018 Ford Expedition. The contact stated while driving at an undisclosed speed, the transmission unexpectedly downshifted without warning. The transmission also shifted hard, and the vehicle jerked while driving at various speeds. There were no warning lights illuminated. The vehicle was taken to the dealer who diagnosed the vehicle with transmission failure. The transmission was rebuilt. The following day while driving approximately 65 MPH, the transmission shifted hard, and the contact became aware that transmission fluid was leaking from the vehicle after exiting and inspecting the vehicle. The vehicle was towed to the dealer who diagnosed the vehicle with transmission failure and replaced the transmission. The contact stated that the transmission still shifted hard while driving and the message that the engine was overheating was displayed. The vehicle was returned to the dealer who had rebuilt the new transmission. After having the third repair, the failure recurred. The vehicle was returned to the dealer but was not yet diagnosed or repaired. The manufacturer was informed of the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The approximate failure mileage was 60,000.

The contact owns a 2018 Ford Expedition. The contact stated that while starting the vehicle, the engine made an abnormal sound. The check engine warning light was illuminated. Additionally, the vehicle failed to accelerate intermittently while driving. The vehicle was taken to the dealer, who related the failure to Customer Satisfaction Program: 21N03 (Cam Phaser Replacement); however, the VIN was not included. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 140,000.

Cam phaser and timing chain assembly is beginning to fail. Ford has a CSB out on this problem but is unwilling to repair or replace components. Transmission has had to be replaced be cause of failure at 100000 miles. I’ve had to replace the water pump twice on my Expedition. Driver side seat belt no longer retracts.

I cash purchased a 2018 Ford Expedition on [XXX] - I have a 90 day warranty and purchased an extended 2 year warranty. I've taken the vehicle back twice to Auto Nation in Denver Co for transmission issues. The transmissions slips and makes a horrible nose when it shift. I can't drive it due to it being unsafe to drive. I do not feel safe driving the vehicle. Auto Nation continues to declining to repair the vehicle. I've owned the vehicle for 2months and maybe drove it for only 100 miles due to the unsafety. Ford has know issues with these 10speed transmissions. I was never informed by the dealer of these know issues therefore was sold a lemon. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

In January 2025, we had issues with the transmission not shifting smoothly while out of town. While driving on the freeway at around 65MPH, in traffic, the transmission suddenly downshifted from 10th to either 3rd or 4th gear immediately slowing the vehicle. We almost got rear ended and tried to get over to the shoulder. By the time we could get over, which took about a minute, the transmission recovered itself and went back into the correct gear. We arrived home, took the truck in and was told the transmission needed to be rebuilt. There was a known issue with the transmission in these vehicles. We paid to have the transmission rebuilt. In April 2025, we heard rattling in the engine. We took it in and was told the Cam Phasers were bad and needed to be replaced. Another known issue. We have had the cam phasers replaced in 2020 under warranty. We had them reprogrammed again in 2022 for a recall. Now we are having to replace them again out of pocket. We again, paid for the repairs and got the vehicle back. I called Ford customer service and asked about any programs or reimbursement for these known issues. (Ref # [XXX]) I was told there are none at this time, despite Ford knowing they have issues. Ford has done nothing to correct the problems, but is obviously aware of the issues. Our vehicle only has about 50K miles and has had the most repairs on any vehicle that I've ever owned. We have already purchased the vehicle, and I'm having to "purchase" it a second time with the high

The contact owns a 2018 Ford Expedition. The contact stated that while starting the vehicle on several occasions, there was a fast-banging metallic sound coming from the engine compartment. The vehicle was taken to a dealer, where it was diagnosed that the cam phasers needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 110,000.

Driver side seat belt air bag popped while driving down the road and now the seat belt will not retract. shows that this is a known issue in my year model but this is not a recall for my specific vin.

Cam phasers are making a loud rattling noise.

The contact owns a 2018 Ford Expedition. The contact stated while starting the vehicle, there was a loud clanking sound coming from the vehicle. The check engine warning light was illuminated. The vehicle was taken to a dealer where it was diagnosed with cam phaser failure. The vehicle had been taken to the dealer two previous times for unknown repairs. The vehicle was not repaired for the most recent failure. The vehicle was taken to an independent mechanic and the repair was pending. The manufacturer was made aware of the failure. The failure mileage was approximately 25,000.

The contact owns a 2018 Ford Expedition Max. The contact stated that while driving at various speeds, the vehicle was jerking slightly. The vehicle was taken to the dealer, where the transmission computer software was updated; however, the failure recurred while driving. The vehicle was taken back to the dealer, where the contact was informed that the vehicle was attempting to learn the contact's driving pattern and was operating as designed. The contact stated that while driving approximately 55 MPH, the vehicle jerked and experienced an unintended transmission downshift into first gear. A message advising that the power train was disabled and to take the vehicle to the dealer was displayed. The contact stated that the failure recurred several times while driving, causing the contact to sustain whiplash and neck pain. The contact stated that she was already afflicted with osteoporosis on the neck and spine, and her husband was afflicted with heart disease. The contact was concerned that the failure could further damage their health. The vehicle was taken to the dealer, where it was diagnosed with transmission failure, and the dealer provided an estimated fee for the transmission replacement. The contact was informed that the vehicle was not covered under warranty. The vehicle was then taken to a transmission specialist, where the same assessment was made. The mechanic informed the contact that the vehicle could be repaired for a cheaper amount. The vehicle was not repaired.

The contact owns a 2018 Ford Expedition. The contact stated that the vehicle was making an abnormally loud ticking sound on cold starts, while idling, and while driving. The vehicle was taken to the dealer, where the sound was associated to a cam phaser failure; however, the vehicle was not diagnosed or repaired. The contact related the failure to Ford Campaign Number: 21B10. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to verify whether the vehicle was covered. The failure mileage was approximately 122,000.

Transmission issue: Vehicle will sometimes not go into gear. When I pull out into traffic sometimes vehicle will not go into gear. Mostly occurs with 2nd and 4th gear but has happened with other gears as well. Also when shifting g into gear sometimes it takes a while and sometimes he vehicle jerks during shifting.

The car will drop into neutral while on the highway. This happens mostly when trying to accelerate to merge into traffic, down shifting to pass someone etc. Once the car goes into neutral you lose all power. This presents a safety risk as you can be trying to pass someone or merge into traffic and your vehicle stops accelerating. This happened to me when trying to merge onto a busy freeway. I had to pull to the side to avoid getting into an accident. Then once on the side of the road i had to get the car back into gear and then work to merge from a dead stop. Apparently this is a known issue called a neutral out. Once this happened to me the transmission had to be rebuilt.

The transmission suddenly and violently knocked from drive into neutral while driving. I had the vehicle towed home, and have been driving it until the suspect part finally breaks for good.

The contact owns a 2018 Ford Expedition. The contact stated that while starting the vehicle, there was a loud clanking sound coming from the engine compartment. The check engine warning light was illuminated. The contact stated that while driving at an undisclosed speed, the failure recurred with the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed that the cam phasers had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 130,000.

The passenger side day time running light led halo is partially not working-Daytime Running Light defective. Several customers affected for the same reason all over internet.

I bought the vehicle used with 108,xxx miles on it in May of 2024. In July I had in the repair shop for one issue and noticed there was an issue with the Auto Start/Stop. When the Auto Start/Stop is engaged and the brake is depressed it jams into first gear like a standard vehicle when the clutch is released to early. Transmission fluid was checked to be low so it was refilled. I was told to change my driving habits, which is what I did. I no longer use it because it still has the issue. Move forward to December 2024. I was driving and realized it was skipping 2nd, 4th, and sometimes 6th gears. Upon further research I found that it was normal to happen. When I was driving it home on February 20 I lost 1st, 2nd, and 3rd gear. I was close enough home where I was able to get home. When I got home I restarted and still had no lower gears. I let it sit for a couple of hours and drove it again and I had the normal gear shift. I called the dealership and had an appointment scheduled. I was told from that appointment a brand new transmission was needed or a transmission overhaul was needed to fix the issue. I was told to contact Ford Customer Support to find out if there were any options about the warranties that may be out there or recalls about the 10-speed transmission. When I called Ford about the possibility of my 10-speed transmission being under the recall for the transmission I was told that because the VIN did not need to recalled. Upon further research I have found multiple

What component or system failed or malfunctioned TRANSMISSION, and is it available for inspection upon request YES How was your safety or the safety of others put at risk? I WAS DRIVING ON A MAJOR 8 LANE HIGHWAY AND COULD NOT EXCELERATE SAFTLY TO GET OUT OF THE WAY OF TRAFFIC Has the problem been reproduced or confirmed by a dealer or independent service center? YES Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? YES, MANUFACTURER FORD & AAMCO TRANSMISSION Were there any warning lamps, messages or other symptoms of the problem prior to the failure, NO and when did they first appear THE CHECK ENGINE LIGHT CAME ON RIGHT AFTER THE TRANSMISSION STOPPED WORKING PROPERLY. FIRST THE TRANSMISSION WOULD NOT EXCELERATE AND THEM THE CHECK ENGINE LIGHT CAME ON THIS TRANSMISSION HAS FAILED 3 TIMES KEEPS LEAVING ME STRANDED ON THE SIDE OF THE HIGHWAY. EVEN AFTER REPAIRS HAVE BEEN DONE WITH AAMCO PLEASE HELP ME I AM SCARED TO DRIVE MY TRUCK TRANSMISSION KEEPS FAILING

The truck suddenly loses power while driving. Then goes back to normal. Most recently but not only time I lost power on interstate, the dash blinks see manual. I was almost hit by vehicle behind me as i was unable to continue accelerating. Similar recalls for my year and make of vehicle include powertrain control module reprogram for cam phaser rattle and automatic engine idle shutdown.

The contact owns a 2018 Ford Expedition. The contact stated that the vehicle made an abnormally loud rattling sound during cold starts. The check engine warning light was illuminated. An unknown dealer was notified of the failure and provided an estimate for the repair. The vehicle was taken to Worldwide Automotive, where it was diagnosed with cam phaser failure. The mechanic replaced the cam phasers. The vehicle was repaired. The manufacturer was notified of the failure and informed the contact that the VIN was not included in a recall or Customer Satisfaction Program. The failure mileage was approximately 85,000.

The 10R80 transmission does not work. This is a know problem with Ford, would be nice for them to actually take action and fix the problem they know they have. They have replacement part that fixes the problem, would be nice for them to stand behind their car.

Daylight light led lighting is halfway off.

The contact owns 2018 Ford Expedition. The contact stated that while driving uphill at 35 MPH, the transmission struggled to shift into gear, and upon depressing the accelerator pedal the RPM became elevated, until the transmission shifted into gear allowing to vehicle to continue driving. The contact stated that the message "See Owner’s Manual" was displayed. The contact drove the vehicle to a local dealer where the vehicle was diagnosed, and the contact was informed that the transmission control module had failed and the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 122,000.

Ford had to rebuild rear differential. The transmission failed, too. Both unacceptable especially at 62k miles and zero utility usage including trailering or 4wd.

When it is below freezing and there is snow/condensation on the door windows the door lock can get stuck/frozen closed. Many times the door will unlock and open to get in but once I get to my destination I can't get the door open to get out of my car. This has happened on all the doors at different times. We get stuck and I have to crawl out another door that will unlock. There isn't a way to manually pull the door unlocked because the knob goes into a hole so you can't pull it up. Also, sometimes when I run remote start the door will not unlock and open to get into the car. I also have children in car seats, this would be a major safety issue in an emergency if we couldn't get out.

The service engine light has come on and off (and stayed on, in some instances) for a few years. The alert in the Ford app states that there is a problem with my vehicle's emissions and exhaust system. I have taken it to my local Ford dealership many, many times. When the vehicle is "throwing codes", as they call it, it has to do with the cam phasers. I have had the recall on the cam phasers done already, but they refuse to fix it again under the recall because "the part numbers have changed". Same cam phaser issue, but the same exact parts have different part numbers than they did 2 years ago, so now Ford doesn't have to fix it? The problem has been ongoing since 2020.

The wheel nuts on my vehicle are defective. The Ford Dealership had to replace all twenty-four of them for "swelling". Evidently, the design of these wheel nuts (Ford part number ACPZ 1012 M) makes it impossible to remove without destroying them because of their defective design. According to Ford Customer Care, these parts are considered wear items and are not covered under warranty. In my opinion, wheel nuts may be considered a safety item, should they fail or if they are not removeable with customary tools during roadside emergencies. I purchased this vehicle new in October 2018 and since then several Ford Dealerships have said they have issues installing and removing with these particular wheel nuts, and most are destroyed in the removal process. They have voiced their concerns to Ford with no remedy thus far. I am told these parts are also on various models of F-150 trucks. While I do not expect NHTSA to issue a recall for this issue, I would hope that a voluntary recall program could be enacted by Ford wherein these wheel nuts are replaced free of charge when service is performed requiring the wheels to be removed.

Transmission delays or goes into neutral when accelerating. I have had a couple close calls when making left hand turns across 2 way roads. Another close call during a merge where the vehicle seemed like it just decided not to go. I research the issue and found TSB23-2250. This should be a safety recall and not just a service bulletin. Ford knows they installed faulty products on the roads and could leave to very serious accidents. This TSB is not a wear and tear item, this is due to faulty programming and parts. GM uses the same transmissions on their products with out nearly as many issues as ford.

I am writing to express my dissatisfaction with the response I have received regarding the cam phaser replacement for my 2018 Ford Expedition. Why is my vehicle not covered under the Cam Phaser Customer Satisfaction Program 21N03, where 100% of the amount was covered under this program. I had my vehicle diagnosed from Malloy Ford with TSB 23-2148 VCTS replacement. My vehicle has extremely low mileage for being a 2018 with only 44,000 miles. After contacting Ford Motor Company’s Customer Service, I was informed that the faulty cam phasers on my vehicle are not showing under the Field Service Action report. I am aware that for the cam phasers to be marked as faulty within the Field Service Action (FSA) records, the issue must first be diagnosed and repaired under the 21B10 Powertrain Control Module (PCM) program for the Cam Phaser Rattle. Once this procedure has been performed, if the problem persists, the cam phasers can then be replaced under Customer Satisfaction Program 21N03 – Cam Phaser Replacement. Despite this clarification, I remain extremely dissatisfied with the outcome the NHTSA and Ford Motor Company has done to remedy this issue for millions of customers. I believe more can be done to address this issue promptly under the know Customer Satisfaction Program 21N03. The rattle from the cam phasers remains a persistent problem and has not been resolved. More needs to be done to help the millions of customers that are experiencing these issues and help them to avoid th

The passenger side headlight assembly has a led daytime running light strip that has burnt out and is a common issue with this model car

I was on a road trip of about 900 miles. My vehicle at the time had 103,000 miles. All maintenance service intervals had been complied with since I purchased vehicle new. About half way through the trip the transmission started acting up. I was on the highway between 75 and 80 mph when it suddenly downshifted in a jerk then it failed to accelerate. This whole time I was pressing the gas pedal and my speed continued to drop and the vehicle jerking forward and back. I was able to put it in “manual” selectable speed and regain control. I had the vehicle inspected at my destination and the dealer could find no fault codes and fluid check was good. My vehicle continued random jerky shift changes at the most dangerous times. I still got no check engine light or any such failure or service alerts. On my return trip home, it did it again. This time I was watching all the gauges. I noticed my engine coolant temp spike to 240 degrees and my transmission fluid temp spiked at 247degrees. Outside air temp was 40 degrees and it was three occupants and no towing involved. The dangerous jerking and random transmission shift changes continued. After about 30 minutes of reduced speed driving on the highway the temps dropped. However the shifting was hard and erratic. I took the vehicle to the dealer after returning home. I now need a whole new transmission. This situation was extremely dangerous as to the uncontrollability of the slam shifting of the gears causing a rapid change of speed. I am

Faulty Cam phasers The cam phasers in this vehicles makes an undesirable noise, such as a rattle when starting the engine or a knocking noise when idling. Vehicle has at times experiences Poor acceleration, Rough engine running, Tapping or rattling noise when the engine is idling and hot

The contact owns a 2018 Ford Expedition. The contact stated that there was an abnormal clunking sound while starting the vehicle. The contact stated that while driving a undisclosed speeds, the engine overheated. The contact stated that there was an extremely loud knocking sound coming from the vehicle. The check engine warning light was illuminated. The contact stated that the failure was related to Customer Satisfaction Program: 21N03. The vehicle was taken to an independent mechanic who determined the failure was related to the cam phasers. The vehicle was taken to the local dealer, who confirmed there were no associated recalls. The vehicle was diagnosed, and it was determined that the water pump needed to be replaced. The water pump was replaced. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 40,000.

When oil in the transmission is still cold, even when engine has wormed up to operation temperature, the transmission is shifting hard, specifically it shifts the hardest from 4th gear into 5th. For a moment car has no acceleration, and then it slams into a 5th gear. I also noticed that the transmission shifts from 4th into 1st, then into 5th. It lasts about 30 seconds. It casing a safety issue when I merge onto a busy road, and try to get up to speed, car would not respond for those 30 seconds causing traffic to catch up and slam on their brakes to avoid rear ending my vehicle.

Transmission Issue: We have experienced clicking with our transmission for years and have expressed our concerns to our Ford service department. Their response has always been that it was normal. Now our vehicle has started to lose power when shifting between 2 and 4 gear. The vehicle will lose all power, for anywhere between 3 and 7 seconds, and then violently shift into gear and launch forward. The RPM's will stay around 3-4 thousand for 2 to 3 seconds and then the transmission will operate normally. It is very infrequent, but it has happened on very dangerous roads such as [XXX] and [XXX] in California. It is very scary when it happens, and I fear that I will be rear ended because of it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Engine sound when car turns on. Took the car to personal mechanic and a Ford Dealership both confirmed sound of engine when started. Can hear a sound (ticking/clicking) when idling.

The contact owns a 2018 Ford Expedition. The contact stated that upon starting the vehicle, the vehicle made an abnormal rattling sound. There was no warning light illuminated. The contact related the failure to Ford Campaign Number: 21N03. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 67,000.

Since purchasing the vehicle we have had extensive issues with the driveability of the car. Leading up to the eventual full transmission replacement, we surfaced the issues below repeatedly for over a year and a half. Yet, we were always told "everything is fine" "we couldn't duplicate what you are describing" or "the vehicle has to learn how you drive". Biggest Issues: - Poor shifting of gears with sudden jerking and/or random accelerations - Vehicle not accelerating - acts stuck - Loss of 'power' vehicle does nothing - Eventually complete transmission failure in the middle of an intersection The transmission was completely replaced in Fall of 2023. Mind you this was only after I elevated my concerns to Ford Corporate who sent a specialist to investigate. Only then did Koons Ford acknowledge that yes there is a "big problem". Yet, since the repair the jerking and power issues have continued. When we followed up immediately after the repair we were told again "vehicle has to learn how you drive". So I waited 3000 miles and reached out again and was told I needed to go to the dealership and drive it with a technician in the car (yet again, not taking my word seriously). Then this summer the issues intensified and eventually the power boosters failed and needed to be replaced. This vehicle is NOT safe and Ford has misled me along the way. It has been a constant fight to get them to help us. Bottom line, this is our primary family vehicle as we have five children, four of whom I

The contact owns a 2018 Ford Expedition. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed, however, the vehicle failed to accelerate as intended. The contact stated that the vehicle was shaking and jerking. In addition, the contact stated that the vehicle misfired. The vehicle was taken to an independent mechanic where it was diagnosed with a failed transmission. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The dealer was made aware of the failure and advised the contact that the repair was not covered under any unknown recall. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 117,836.