2020 Ford Escape complaints

Door was creaking and making several popping noises when opening and closing. That went on for about a month, going from just a creak, to a pop, to several pops. Now there is very little sound, but the door occasionally resists closing completely. Took it in, and was told a piece inside had popped away from the door. They said it would require body work, but the warranty had run out to cover it. They will reach out to Ford for assistance. They stated that Ford has been "really good" about covering the repair, but could take up to 3 weeks to hear back from Ford. I was told it was ok to keep driving it in this condition, but to not roll the window down. Several articles I've found indicate this is a known problem, and that there's a possibility the door could open while driving. Please push Ford to issue a recall! This is very dangerous!

My drivers door arm receptor has broken free of its spot weld inside the door, causing severe safety issues. [see Car and Driver article BY ALESSANDRA KAESTNER PUBLISHED: JUL 14, 2023] Same issue. This happened to me today 09/20/2023. * I cannot fully open drivers window because of this defect. Major safety issue if my vehicle goes into water. * I cannot open the door from outside, if locked. Major issue to persons with disabilities who can't climb across the console or back seats. I pulled a leg muscle today doing so. My back hurts also. Ford spot-welded the door arm receptor on a piece of metal that is too thin to provide support. <I PICTURES IF NEEDED> This is enough for a recall. When will you do this? What is taking so long? Already tired of not being able to use drive thru because my window will not lower. A major inconvenience.

The front driver door is broken. It is about to fall off.

The contact owns a 2020 Ford Escape. The contact stated that the front driver's side door was making abnormal loud banging sounds while opening and closing. Additionally, the contact stated that the front driver's side window could only roll down half-way. The vehicle was taken to the dealer, where it was determined that the front driver's side doorstop was internally fractured and was hitting the front driver's side window runner. The dealer advised the contact to take the vehicle to an auto body shop. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 11,300. The contact stated Sprit Ford Collision in Dundee, Michigan putting on a new drivers side door, caused by faulty weld to the door stop at the owners expense. The contact wants to be reimbursed for the repairs.

On the dates of Saturday, September 9, 2023, Monday, September 11, 2023, and Sunday September 17, my car stopped (with Start/Stop activated) in traffic, rotated the gearshift to park, would no let me manually rotate the gearshift into neutral, nor could I restart the vehicle. I had the battery replaced on Saturday, September 9, 2023, towed to my local Ford Dealership on Monday, September 11, 2023. On Thursday, Septmeber 14, 2023 I received my car back, and my vehicle shut down for the third time on Sunday September 17.

Driver's side door is broken. Started with popping sounds, then just snapped. Door can open and close but automatic window cannot be used. I have a video of the sound the door makes currently but was unable to upload it.

Left front door hinge failure and door was unable to be closed. $2278 in repairs to resolve the door and damge caused to the left fender.

The contact owns a 2020 Ford Escape. The contact stated while exiting the front driver’s side door, the contact heard an abnormal sound coming from the door. Additionally, the window failed to roll down as needed. The vehicle was taken to an independent mechanic who stated that the door check arm was fractured. The vehicle was taken to the dealer and the contact was informed that the door needed to be repaired. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was 38,000.

Lift gate malfunction. Popping / sticking while opening & closing

Transmission dropped out of gear on the highway and would not accelerate. Had to coast to the side. Indicator stated shift system fault. Turned off and restarted and it worked again going forward but there was no reverse gear. Code states “ The powertrain control system has detected one of the transmission clutches did not apply within the expected time as expected. Some transmission gears may not being available resulting in delayed or harsh shifts into another gear. Additional alerts that may provide additional information may accompany this alert.” and also “ The powertrain control system has detected one of the transmission shift solenoids is not responding as expected or is stuck in the off position. Some transmission gears may not being available resulting in delayed or harsh shifts into another gear. Additional alerts that may provide additional information may accompany this alert.” The vehicle has not been inspected yet but does constantly show shift system fault and makes rattle and clicking noises when shifting.

SPOT WELDS ON THE DRIVERS DOOR ARE BROKEN.

The contact owns a 2020 Ford Escape. The contact stated that while closing the front driver’s side door, added pressure was needed why closing the door. The contact stated that she had to apply pressure to the front passenger’s side door to close the door securely. As a result, the front driver’s and passenger’s side windows rolled down halfway and failed to operate as designed. The vehicle as taken to the dealer where it was diagnosed that the front driver’s and passenger’s side spot welds had cracked, and the front driver’s and passenger’s side doors needed to be replaced. The contact was then informed by the dealer to take the vehicle to a local repair shop to have the door welded. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed that the mileage on the vehicle was over the warranty mileage coverage. The contact was advised to contact the NHTSA Hotline, but no further assistance was provided. The failure mileage was approximately 107,000.

The contact owns a 2020 Ford Escape. The contact stated while opening the front driver’s side door, there was an abnormal popping sound before the door separated from the hinges. The contact stated that the welds to the door had fractured. The vehicle was taken to the dealer and the contact was unformed that the door needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, and case was filed. The failure mileage was 21,200.

The pop weld on drivers side door is broken, door makes a cracking, popping sound when opening and closing. Window will not roll down on this door. Door opened during driving but no damage or injury occurred. Ford is refusing to fix problem due to being 4 months outside of warranty even though I am under 36,000 miles. Will cost upwards of 3,000 to fix

The contact owns a 2020 Ford Escape. The contact stated that upon entering the vehicle, the door latch made an abnormal screeching sound. The contact attempted to resolve the failure with WD40, but the screeching persisted. The vehicle was taken to the dealer, who diagnosed a failure with the door check arm attachment and advised that the entire door needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related it to NHTSA Action Number: PE23013 (Structure). The manufacturer was not notified of the failure. The failure mileage was 23,000.

The contact owns a 2020 Ford Escape. The contact stated that upon entering the vehicle, the door latch made an abnormal screeching sound and the contact had difficulty while closing the door. The vehicle was taken to the dealer, who diagnosed a failure with the door check arm attachment and advised that the entire door needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related it to NHTSA Action Number: PE23013 (Structure). The manufacturer was not notified of the failure. The failure mileage was 39,000.

The contact owns a 2020 Ford Escape. The contact stated that upon entering the vehicle, the door latch made an abnormal screeching sound and was it difficult to close the door. The vehicle was taken to the dealer, who diagnosed a failure with the door check arm attachment and advised that the door need to be replaced. The vehicle was not repaired. After investigating the failure, the contact related it to NHTSA Action Number: PE23013 (Structure). The manufacturer was notified of the failure but provided no assistance. The failure mileage was 65,000.

Cracked or broken spot welds in the left front door at the check arm attachment point, popping noise” when the door comes open and the door can be unable to latch when closed or can suddenly come open when it had been closed. Window would not go completely down

The driver door began making a loud popping noise when I would open and close it. About a week after I noticed the popping sound, the driver door wouldn’t close. Upon further inspection I realized that the spot welds on the door assembly bracket have broken. I had to position it carefully so that I could close my door all the way. My driver side window will only go down about 4 inches now. There were no lights indicating any issues with my door. If I open my door all the way then it won’t close again, the broken door assembly bracket prevents it from closing. As it is a Sunday morning, I have not had this issue inspected at the dealership yet, but I plan to call first thing in the morning to have it looked at.

On my 2020 Ford escape the drivers door pops when I open and close the door. It is at the point right now I must pull the door in very hard and push it out very hard to open.

Okay so on the first of September I noticed my driver's side door was squeaking and this thing you know couldn't shut it and my spot welds were gone and pretty much my doors just hang in there and I'm going to send pictures for you I can't drive my car I had to drive from south Carolina to West Virginia

Driver door hinge arm started cracking and popping when opened fully. Automatic window will not roll down. Car was a lease still under 36000 miles when reported. Purchased vehicle with knowledge that other of the same make model and year were recalled.

The weld that holds a mechanism for the door has broken loose. Making cracking sounds and hindering the door to close properly. Also the windows will not go down.

The contact leased a 2020 Ford Escape. The contact stated that whenever the driver’s side front door was opened or closed, there was an abnormal clunking sound coming from the door. The vehicle was taken to the dealer where it was diagnosed and determined that the front driver’s side door weld had fractured, and the front driver’s side door needed to be replaced. The contact was then informed by the dealer that the front driver’s side window might fail to open and close as needed due to the door weld fracture. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 25,000.

Spot welds on drivers door check arm failed completely leaving the check arm disconnected from the door. The window no longer opens and the door is hard to open and close

The drivers door made a loud pop when opening and it is now difficult to close and to open. it scrapes and pops out of place along the hinge and on the inside of the door. at one time it was not shutting at all. Hopefully it will not do this again, but something is broken. I was travelling when this happened with a passenger in my car and if m y door would not have shut at all i was far away from home and it would have been a huge inconvenience! I took my car to the dealer i bought it from in my town and he took a video of the noise it makes and the difficulty shutting and opening. He then called me the next day after talking to the techs that they are aware of this happening to some of the Escapes and i will have to seek a private shop to get a new door as he says this is not covered under warranty. This is preposterous and i cannot believe there is not a recall on this issue after i have read about this issue online and it is happening often. There was no warning, just a pop and immediately problems getting the door open and closed.

Welds holding door check to inside of the front driver side door broke.

I had a week of squeaking from my door, which I figured it come from the 3 digit high temperatures. The week afterwards I was headed to my car to leave out and my door wouldn't shut all the way and had a loud pop sound everytime I opened the door. My vehicle has never been hit and the research I did made me realize I am not the only one with this issue. It is a safety concern and Ford should consider this as a recall.

Spot welds on door check arm pulled out. is affecting operation of window.

While travelling we got a message on our dasboard stating that the AWD had a fault and needed to be serviced. We called the dealership and they said it was okay to continue to drive the vehicle. However, we made the soonest appointment available with the dealership, thinking we were still under warranty. We received other warning messages: hill assist not working, pre-collision assist not working, auto hold not working, advance auto trac needs servicing, see manual, get system serviced. The cruise, or speed control also stopped working. We drove 1,100 miles with all of this going on trying to get back home. We went to have it checked out at tje dealer on 9/5/2023. We found out it is not under warranty. It cost us $195 for the computer to tell us it is the AWD module and, Ford wants another $800 to fix it. We found an article at Customer Satisfaction Program 21B19 – AWD Module Replacement – 2020-2021 Ford Bronco Sport, Escape, & Lincoln Corsair – Ford https://ford.oemdtc.com/7846/customer-satisfaction-program-21b19-awd-module-replacement-2020-2021-ford-bronco-sport-escape-lincoln-corsair. What can we do? Help please.

On Sept.3, 2023 I went to my car and opened the driver's door, there was a creaking sound I never heard before, I thought someone had hit it in the parking lot but there was zero damage to the outside of the door. As I opened and closed it a few times, the sound got worse and after a few times, it hardly closed. When I went to shut it, I had to almost force it to close. This is a problem, and it came out of, nowhere. It is certainly a safety concern. On the morning of Sept. 4, 2023 I had my boyfriend look at it and he could see where the problem is, it's the hinge area on the driver's side towards the front of the door, where it attaches to the car.

There is a popping sound when opening and closing driver door. It appears some spot welding has broken. Also driver door window will not roll down all the way.

Opening driver side door heard a pop, door hinge sprung causing door to open and driver side window stuck Ford will not take responsibility and fix it. The whole door needs to be replaced and they're quoting me $3000.

Drivers side door brake spot welds have broken causing the door to be unstable, unable to open or close, or to not stay open or closed.

The contact owns a 2020 Ford Escape. The contact stated that the front driver's side window would not roll down and while exiting the front driver's side door the door would immediately close back. The contact indicated that the door had erroneously sprung back causing a contusion to the left leg upon contact. The same failure had occurred causing a contusion to the left arm of the son. No medical treatment was required. The cause of the failures were not determined. The manufacturer and local dealer were notified of the failure but no assistance was offered. The VIN was not available. The failure mileage was 45,000.

The contact owns a 2020 Ford Escape. The contact stated while opening the front driver’s side door, the contact heard a squeaking sound coming from the door and notice that the door weld had fractured. Additionally, while shutting the door, the door failed to lock. The vehicle was taken to the dealer who stated that the door needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, and case was filed. The contact was advised to contact the NHTSA Hotline for assistance. The failure mileage was 70,000.

Through normal use the drivers door spot welds have broken. Ford would cover $1500 of a $4000 fix. This is not my fault and I feel that they should cover the repair 100%

The contact owns a 2020 Ford Escape. The contact received notification of NHTSA Campaign Number: 22V859000 (Fuel System, Gasoline) however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2020 Ford Escape. The contact stated while opening the front driver’s side door, he heard a loud abnormal noise, and the front driver’s side door failed to close properly. The contact took the vehicle to the local dealer, where it was diagnosed with needing the front driver’s side door check strap to be replaced. The vehicle was repaired but the front passenger’s side door check strap became faulty. The contact took the vehicle to the local dealer, where it was diagnosed with needing the front passenger’s side door check strap to be replaced. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 30,000.

Driver side door started to make a noise while using it. Shortly after the door was hard to close and open at the same time and a pop sound happened and door could not close at all due to door arm breaking loose inside of door. I had to take the door apart and try to get the arm out which was a battle but I managed. Door swings open and closed way too easy now. Driver side window now has scratches from going up and down. I am taking my car in for a recall repair on September 15, 2023 and at that time the dealership will be looking into what they can do for me regarding the door arm repair since this happend just outside of the 36,000 mile warranty. The Ford Escape 2020 is at this moment at 38,525.

The contact owns a 2020 Ford Escape. The contact stated that upon opening the door to enter the vehicle, the door armrest made an abnormal sound. There was no warning light illuminated. The vehicle was taken to the dealer, who determined that the door check arm strap was defective. The vehicle was not repaired. The contact related the failure to NHTSA Action Number: PE23013 (Structure). The manufacturer was notified of the failure, and a case was opened. The failure mileage was 51,000.

The contact owns a 2020 Ford Escape. The contact stated that he was informed by his wife that upon opening the front driver’s side door, she heard a creaking sound. The contact then stated that upon inspecting the front driver’s side door, he noticed that the spot welds had fractured. The vehicle was taken to the dealer where it was diagnosed that the front driver's side door spot welds had fractured, and the front driver’s side door needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, and the contact was advised to call the NHTSA Hotline. The failure mileage was approximately 38,300.

The contact owns a 2020 Ford Escape. The contact stated that the front driver's side door became unsecured and failed to remain securely closed. The contact called the local dealer who acknowledged that the failure was a known issue with similar vehicles. The local dealer informed the contact that their facility did not have the ability to repair the vehicle. The manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 42,000.

While driving on the highway my dash kept flashing all these different errors , my car kept changing the way it was driving . I got off went to ford dealer ! They said probably a sensor can’t look at it for 10 days and yes it is fine to drive . I did not think so ! I brought to my mechanic , replaced AWD module ! Which has been found to be an issue in this vehicle ! I felt unsafe . There have been recalls on this issue ! They say had do be built on a certain date ! Really , not if you keep searching ! It should be covered under drive train. Safety issue ! The lights going off are a distraction in itself .

The contact owns a 2020 Ford Escape. The contact stated that an unknown fluid would leak from above both the brake and accelerator pedal which made both pedals slippery upon depression. The contact stated that while approaching a stop sign, the contact's foot slipped off the brake pedal as the vehicle nearly drifted into oncoming traffic. The dealer(dealer unknown) was notified of the failure and an appointment was made for an inspection. The manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 15,000. The VIN was not available.

The contact owns a 2020 Ford Escape. The contact stated that the front driver's side door had become unsecured and failed to remain securely closed. The vehicle was taken to the local dealer who diagnosed and determined that the front driver's side door welding assembly had failed and needed to be repaired. The vehicle was not yet repaired. The manufacturer was not yet contacted. The failure mileage was 38,000.

The contact owns a 2020 Ford Escape. The contact stated that while his wife was exiting the vehicle, she opened the front passenger’s side door and heard a clicking sound, and the front passenger’s side door extended open with force. The contact stated that upon entering the vehicle, he opened the front driver’s side door and heard a clicking sound. Upon inspecting the front driver’s and passenger’s side doors, he noticed that the spot welds had fractured. The vehicle was taken to the dealer where it was determined that the front driver's and passenger’s side doors needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was advised to call the NHTSA Hotline. The failure mileage was approximately 43,000.

Driver side door and power window malfunction

The driver's side door made popping or cracking noises when opening and closing. It eventually locked in place while open, and it could not be closed. I took it to the dealer where they initially said that the check strap needed to be replaced. After the part arrived and they disassembled the door, it was discovered that the welds on the component that holds the check strap in place were broken. The car was moved to the body/collision shop for further assessment. In the meantime, I've discovered this has happened with several other 2020 Escapes, but there is no recall as of yet. Obviously, this is a manufacturer defect that needs to be addressed in a more global and urgent manner.

Driver door - one day, without prior warning, when opening or closing the door, it makes a popping sound as if a hing of some sort is broken. The door does not remain in an open position when getting in our out. Consequently, the drive window only opens about 2 inches.