2018 Ford Edge complaints

Coolant intrusion into #2 cylinder of 2.0 eco-boost engine Confirmed by mechanic at Ford dealership are they diagnosis with pressure test and bore scope. i’ve read online of the inquiries for this and other Ford dungeons the 2018 Ford edge which led to recalls for the Ford fusion and escape, but did not include the Ford edge. I cannot understand why the Ford edge was not included in the recall since it has the same problems and same engine, Ford supervisor told me it may be because there was not enough complaints so I’m registering my complaint today. I have been in contact with Ford customer service. Please help me understand this situation. Is it possible there will be a recall on this engine sometime in the future?

The contact owns a 2018 Ford Edge. The contact stated while starting the vehicle, the engine was misfiring, and there was smoke coming out of the exhaust pipe. The check engine warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed with coolant intrusion into the engine. The dealer determined that the engine needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure and a case was opened. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 49,000.

CEL 1st appeared 8 days after car purchase, bought 5/9/24, CEL on 5/17. Avail 4 inspection. At risk possible fire hazard. 2 diagnostics done. Confirmed by 2 Ford dealers and auto store. Wouldnt pass emmissions. Coils and plug replaced CEL goes off. Drive approx 400 miles great. CEL and now coolant light on. Another diagnostic done. Coolant intrusion, research states possible fire hazard, needs engine replaced.

The contact owns a 2018 Ford Edge. The contact stated that when the vehicle was started and driving at various speeds, the check engine warning light was illuminated. Additionally, on several occasions the contact observed a burning odor inside the vehicle. The vehicle was taken to a dealer where it was diagnosed that the engine needed to be replaced due to coolant intrusion. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 160,000.

Check engine light and wrench light are both on. Checked by mechanic. Issue with power train:automatic torque converter. There is a recall on 2018 ford edge for this issue, but my VIN isn’t listed. Car has less than 60,000 miles on it.

Coolant is leaking into the cylinder causing engine failure

Coolant leaking into engine cylinders. Ford edge running a little rough with white exhaust smoke. MIL did not appear illuminated for some time after the appearance of white exhaust smoke.

Warning light appeared on dashboard. Vehicle eventually had a very difficult time moving forward and would not go more than 5 mph uphill. Took vehicle to Ford dealer service center for diagnosis. The report from dealer states, "Verified concern, scanned for fault codes and found codes P01229, P0301 SN P00012. Pressure tested coolant system and found coolant intrusion into the cylinders. The technician advised to correct condition the long block would need to be replaced." (Attaching a copy of the report). Subsequent internet searches demonstrate that this is a known problem with Ford engines.

2018 Ford Edge - 53000 miles. Missfire for #2, constantly for almost a year. Had coils and spark plugs replaced numerous times but keeps happening. Ford Service stated that coolant is leaking causing this and it is a manufacturer defect. Engine needs to be replaced, estimated cost $7500.

The contact owns a 2018 Ford Edge. The contact stated while driving at an undisclosed speed, the vehicle briefly hesitated before returning to normal functionality. The check engine warning light was illuminated. The vehicle was taken to the dealer, who observed a misfire in cylinder #2, due to coolant intrusion, resulting in engine damage. The contact was informed that the long block needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N12 (Short Block Replacement After Coolant Intrusion). The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 101,000.

The contact owns a 2018 Ford Edge. The contact stated while driving 30 MPH, the vehicle stalled with the check engine warning light illuminated. The contact also stated that the engine temperature warning light was illuminated. The vehicle was able to be restarted however, the failure recurred. The vehicle was taken to the dealer where the vehicle was diagnosed with coolant intrusion into the engine. The contact was informed that the engine block needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure, a case was opened, and the contact was referred to the NHSTA Hotline to report the failure. The failure mileage was approximately 135,000.

Engine failed because of coolant in cylinders. Engine must now be replaced. This is a known issue with 2018 Ford Edge with 2.0 eco boost engines.

Coolant leaked into the engine resulting in a total engine failure. Ford refused to cover the cost. The problem was caused by manufacturing defects. Ford has refused to take responsibility.

The contact owns a 2018 Ford Edge. The contact stated that while the vehicle was idling, the vehicle struggled to remain running. The contact stated that the failure persisted, and the check engine warning light illuminated. The contact took the vehicle to a dealer where it was discovered that there was coolant on the spark plugs, with coolant intrusion into cylinder #2. Due to the failure, the contact was informed that the engine needed to be replaced. The manufacturer was notified of the failure but offered no assistance. The contact was transferred to the NHTSA Hotline for assistance. The vehicle was not repaired. The failure mileage was approximately 50,000.

The contact owns a 2018 Ford Edge. The contact stated that while driving at an undisclosed speed, the vehicle stalled with the check engine warning light illuminated. The vehicle was able to restart; however, the failure recurred. The vehicle was taken to the dealer where it was diagnosed with coolant leaking into cylinder #3. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The failure mileage was approximately 61,000.

The contact owns a 2018 Ford Edge. The contact stated that the dashboard lights were abnormally dim. The contact stated that after the vehicle was parked, the vehicle failed to restart. After waiting for a while the contact was able to restart the vehicle with the Push to Start button. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the electrical wiring underneath the rear panel was damaged due to water leaking into the compartment. The rear panel was replaced to prevent further failure. The contact was unsure if the wiring had been replaced. The manufacturer was made aware of the failure and confirmed the VIN was not under recall. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 119,000.

The contact owns a 2018 Ford Edge. The contact stated that upon starting the vehicle, the vehicle was shaking abnormally with the check engine warning light illuminated. The contact took the vehicle to an independent mechanic where an OBD Scanner retrieved code for a misfire. The contact then had the spark plugs and ignition coils replaced; however, the failure persisted. The vehicle was then taken to another independent mechanic where it was discovered that there was coolant intrusion into cylinder #2. Upon investigation, the contact discovered Technical Service Bulletin: 22-2229. The dealer and the manufacturer were notified of the failure and informed the contact that there was no recall on the VIN. The vehicle was not repaired. The failure mileage was approximately 61,000.

100,000 Miles ad 2 months out of warranty -- dealer indicated the check engine light code of P0302 is a collant intrusion and the entire engine needs to be replaced for $10,454. This appears to be a reoccuring problem with Ford Edge Ecoboost.

The engine began having a misfire around 58k miles and low coolant levels. No coolant drips or leaks were detected on the exterior. After some research I found that the 2.0 Ecoboost used in these vehicles is prone to coolant intrusion due to a defective engine block. After a trip the car unexpectedly would not start, it would crank over but it would not start. After sending it to my dealer they confirmed coolant intrusion and explained the car needed a new engine. The car was bought certified used, every service was done on time at a Ford dealer. There was no way to avoid the defective engine in this car, no amount of preventative maintenance would stop this from happening. Ford has a bulletin out on these engines, so they know there's an issue. There's no reason for a low mileage well cared for vehicle to need a replacement engine at 60k miles.

The contact owns a 2018 Ford Edge. The contact stated while driving at an undisclosed speed, the engine misfired, and the check engine warning light illuminated. The contact also stated that the temperature gauge indicated that the engine was overheating. The contact checked the coolant level and discovered that the coolant level was low; however, the contact stated that there were no indications of a coolant leak. In addition, the contact stated that smoke was coming from the exhaust pipes. The vehicle was taken to an independent mechanic where the vehicle was diagnosed with a blown head gasket. The contact was informed that the head gasket needed to be replaced. The vehicle was being repaired. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 78,500.

While driving vehicle on [XXX] Ocala, FL engine spontaneously overheated, which caused an immediate loss of engine power and a temporary loss of directional control as the power steering no longer functioned. I had the vehicle first towed to my house, and then had it towed to Gary Yeomans Ford Ocala. Their diagnosis led them to insist that coolant is intruding into the cylinder through the block itself, and the recommended course of action (under a very well known TSB) is to replace the long-block assembly. Ford is refusing to acknowledge this is a serious manufacturing defect that impacts customer safety, exposing the driver and the driving public to the possibility of an engine fire due to overheating, an accident due to inability to maintain directional control of the vehicle in an overheat scenario, and myriad other potential life-safety issues. Ford is making zero effort to assist their customers - a long block and assembly is almost $8000 - I barely had the money to make the payments and this may very well send me into bankruptcy. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2018 Ford Edge. The contact stated that on several occasions while driving at various speeds, the check engine warning light illuminated. The contact stated that on one occasion the "Engine Overheating" message was displayed. The contact stated that the vehicle lost motive power and failed to accelerate as intended. The vehicle was pulled over to the side of the road and turned off for several minutes. The contact stated that coolant was added to the coolant reservoir. The vehicle was towed to an independent mechanic where it was diagnosed and determined that the engine needed to be replaced due to a coolant leak. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 69,000.

Faulty engine design (thin wall between coolant chamber and cylinders) allows for coolant to enter the cylinders. This leads to an overheating engine (that can catch fire) and ultimately creates a blown head gasket. This is a common issue in the Ford EcoBoost engines. There is a TSB on the 1.5 liter engines, but not the 2.0 on this model. There is currently a large lawsuit happening for this reason. Vehicles with under 60k miles are getting blown engines for this problem, most people still owe several thousand dollars on their vehicle when this happens.

Overheating: antifreeze leaked into engine caused a fire risk. Engine had to be replaced at a cost of over $7,300.

Brought vehicle to dealership for service on a shifter boot recall. The check engine light first came on when we gave the vehicle to the Dealership, and they said there was a misfire on Cylinder #2. Due to this, the entire engine was replaced with 85,000 miles as per a Technical Service Bulletin. This damage was due to a defective design and luckily, we did work with Ford corporate to get the price down since the vehicle was out of warranty. Never had any signs of an issue until one day in April 2024 when the engine started running rough when started up in the driveway. It was rocking the vehicle side to side. Just received the vehicle back this week with a new engine. Please let me know if any additional information is needed.

Coolant problem I was told blown head gasket and had to replace entire motor for 9,000

The contact owns a 2018 Ford Edge. The contact stated that while starting the vehicle, the engine was misfiring intermittently. The check engine warning light was illuminated. The vehicle was taken to the dealer where it was diagnosed that coolant was leaking into cylinder #2, causing the misfire and the engine to fail. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 80,000.

The contact owns a 2018 Ford Edge. The contact stated that while at a stop light, the engine started to overheat. The engine overheated warning light was illuminated. The contact had an independent mechanic check the vehicle and determine that the spark plugs were corroded. Additionally, coolant and water were added to the vehicle, but after driving for 10 to 15 minutes, the coolant level was low again. There was no indication of a leak. The mechanic informed the contact that oil was leaking into the engine. The contact called the local dealer, who informed her about a diagnostic test and that there were no open recalls on the VIN. The vehicle was not diagnosed or repaired. The manufacturer was contacted and opened a case, but no assistance was provided. The approximate failure mileage was 115,233.

My check engine light came on but it was driving fine and we checked all of the fluids and everything was okay and the light went off and then two days later I had a alert pop up while driving that my engine was hot and overheating pull over to find that I have no coolant randomly and we don’t know where it’s going. Had it looked at and they couldn’t figure out where it was going either. Two weeks pass and I’m driving on the highway and my car starts shaking and the check engine light is flashing while white smoke is blowing out from exhaust and from under my hood and had to call 911 because I thought my car had caught fire. Pulled over to find all of my oil all under my car and all on the ground. Had the car towed back home so I could take it to the shop as the incident happened on Memorial Day. The shop looked at it and figured it was my head gasket valve covers so I had that replaced just for oil to still be leaking and now come to find out that it’s seaming to be my cylinder has gone out along with multiple other issues. Finding out that ford knows about this issue with these vehicles irritates me even more. The car is still in shops a month later.

Lug nuts swelled

2018 Ford Edge 2.0l ecoboost engine exhibits a low coolant level, white exhaust smoke is white and/or a runs rough condition with illuminated malfunction code P300 Cylinder 3 misfiring. Level gets so low that the engine will overheat, and we shut the car down. After cooling we fill the over fill reservoir back up. This lasts for 1.5 to 2 weeks. No visible leaks anywhere.

The contact owns a 2018 Ford Edge. The contact took the vehicle to an independent mechanic where the mechanic discovered a coolant intrusion into cylinder #2. The mechanic replaced the high-volume injection pump and spark plugs; however, the failure persisted. The mechanic then pressurized the engine and discovered damages to the engine block. The manufacturer was notified of the failure and informed the contact that the vehicle was no longer under warranty. The contact was referred to the NHTSA Hotline for assistance. The vehicle was not repaired. The failure mileage was 61,000.

The contact owns a 2018 Ford Edge. The contact stated while attempting to start the vehicle, there was a misfire and the check engine warning light illuminated. The vehicle was taken to the dealer where it was first diagnosed that a tune-up was needed then the vehicle was diagnosed as a failure with oil leaking into the head gasket, and the engine needed to be repaired. The final diagnostic test determined that the engine block was cracked and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 72,000.

Coolant intrusion into cylinder number 2. Engine runs really rough and we cannot drive it until we get the engine replaced. A KNOWN issue that ford isn't covering even though they released a TSB stating it is a manufacturer defect because they made the cylinder walls too thin between cylindersnumber 2 and 3. Myself and who knows how many others are out $5000 to $9000 for repairs on vehicles we still owe a lot of money on. Some of these failures have lead to engine fires. Now I have a $40k car in my garage I can't drive for fear of fire and have to spend a fortune to fix. Please make ford own up to this and fix our vehicles!

Recently, I purchased a 2018 Ford Edge from an outside dealership. I have been dealing with a misfire since November of 2023. A few days after I got the car the engine light came on, the dealership I bought it from supposedly "fixed" the car three times. First time was a bad coil in cylinder 1 thought it was fixed a few days later engine light comes back on I go to O'reilly's to get a free diagnostic check and it says misfire cylinder 1 so i take it back to them they say someone over lubed some parts putting it back in, they fix it. Now after this second time around is when I start noticing my coolent is disappearing and then a few days go by engine light comes back on and now im starting to feel thw miafire slightly so i let them know thinking it could be why im having a misfire. so i take it back in this time it was a clogged full injector in cylinder 1 and then they also check my coolent but i got charged for that "seperate" diagnosis they couldnt find anything leaking or any back head gasket so thought it was all good to go then a week goes by and the engine light comes back on now this time i tell them and thwy have me take it do a different shop for a second opinion, and they found coolent leaking into my cylinder 1. I called Ford to let them know because I am aware that this particular 2.0L ecoboost engine is under recall in a lot of cars and when i looked it up it said that 2015-2018 forde ege models qualifyfor this 2020 ford ecoboist engine recall but the ford servic

Coolant leaking possibly into the cylinder 1 causing the engine to violently rough idle while in drive m

My check engine light came on and I got my car scanned & it said it was my ignition coils & my spark plugs which I got fixed check engine came on again and it looks like my coolant was low so I filled it up & it came on again now I have smoke coming out the back of my car so it seems to be leaking. I’ve read online about the coolant issues. My car only has 60,000 miles.

Check engine light came on and took to dealership. Diagnostic revealed that coolant was leaking onto the engine. Car is 6 years old and was told this was a known problem with Ford, who have since corrected it but is not offering anything for known problem in engine in older models.

The contact owns a 2018 Ford Edge. The contact stated while reversing out of the driveway at approximately 2 MPH, the steering wheel was very difficult to turn to the left or the right. The contact stated that the "Steering Fault - Service Required" and the "Service Advancetrac" warning lights were illuminated. The contact turned off and restarted the vehicle however, the power steering functionality was not regained. The contact had not taken the vehicle to a local dealer or independent mechanic to be diagnosed or repaired. The manufacturer was informed of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 15V340000 (Steering) however, the VIN was not included. The failure mileage was 56,272.

The contact owns a 2018 Ford Edge. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed with coolant intrusion in cylinder #3. The vehicle was not repaired. The contact stated that the failure was a known issue. The manufacturer was made aware of the failure and advised the contact to call the NHTSA Hotline for assistance. The failure mileage was 109,335.

The contact owns a 2018 Ford Edge. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to a dealer, where it was diagnosed with engine long block failure. The vehicle was not repaired. The contact was relating the failure to Technical Service Bulletin: 22-2229. The manufacturer was made aware of the failure and confirmed there was an unknown Customer Satisfaction Program Number; however, the VIN was not included. The contact was advised to call the NHTSA Hotline for assistance. The failure mileage was approximately 47,500.

The contact owns a 2018 Ford Edge. The contact stated while driving approximately 65 MPH, the check engine warning light illuminated. The contact arrived at his destination and checked the engine and noticed that the coolant level was low. The contact refilled the coolant reservoir and upon starting the vehicle noticed white smoke coming from the exhaust pipe. The contact drove the vehicle to an independent mechanic who diagnosed that the vehicle had a misfire and determined that the spark plugs needed to be replaced. The vehicle was repaired. The contact stated that the failure had reoccurred, and the check engine warning light illuminated, and a large amount of white smoke was coming from the exhaust pipes when the vehicle was started. The contact researched online and related the failure to coolant intrusion into the cylinder block. The contact had not taken the vehicle to a dealer or to an independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer was informed of the failure. The failure mileage was approximately 71,000.

Coolant is being used up but not leaking anywhere on the ground. It is mis-firing. It has run out of coolant - with NO leak found anywhere. Check engine light comes on and goes off. Looks like the Ford Fusion Recall Issue but there is no recall on my VIN. I cannot afford to repair this defect. Can you do anything to assist my 2018 Ford Edge with its internal coolant leak?

The contact owns a 2018 Ford Edge. The contact stated that after a visual inspection of the engine compartment, she observed that the coolant reservoir was abnormally low. The vehicle was taken to the dealer, who determined that coolant intrusion had damaged the long block, requiring that the engine be replaced. The vehicle was repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N12. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 106,000.

Transmission went to nurteal because it went out at 139k tow to repair shop who stated this the same transmission as escape called ford cs was told there a customer extended warranty placed on my transmission but covered it to 120k I was never notified of this ford said tuff but if it’s the same transmission as escaped they should warranty it

I have a 2018 Ford Edge SEL with 36,460 miles on it. Problem began a few months ago on startup, engine would shudder for a few seconds then clear up, no check engine light came on. A few weeks later I experienced the same issue but the engine light came on! The repair shop changed the ignition coil, the spark plugs and the #2 cylinder injector! Vehicle ran well for a few weeks. While driving on [XXX] in Virginia the engine misfired and the check engine light came on, I found a Ford Dealership nearby and had them do a diagnostic check on the engine! I was informed by the service manager that the problem was “coolant intrusion” in the #2 cylinder! He provided me with the technical service bulletin #22-2229 which clearly states that to correct the problem “the long block engine assembly” must be replaced! Price quoted for this repair was $7,000 plus labor! My local dealership filed a claim with Ford, waiting to hear back from them, not holding my breath! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2018 Ford Edge. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that there was a misfire in cylinder #2. The mechanic replaced the ignition coils and all four spark plugs. Additionally, the mechanic noticed that the coolant level was low and added coolant to the vehicle. The contact stated that three days later, the check engine warning light illuminated and there was no coolant in the coolant reservoir. The vehicle was taken to the dealer, where it was diagnosed that there was coolant intrusion in the engine. The dealer related the failure to TSB Number: 19-2346 and determined that the long block needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 62,000.

The contact owns a 2018 Ford Edge. The contact stated that while driving at an undisclosed speed, the message “Engine Coolant Over Temperature” was displayed and the check engine warning light illuminated. The vehicle was taken to a dealer, where it was diagnosed and confirmed with engine coolant over temperature failure. The vehicle was not repaired. The contact was relating the failure to an unknown recall. The manufacturer was made aware of the failure but confirmed that the vehicle was not included in a recall related to the failure. The failure mileage was 73,487.

Coolant is leaking into cylinder 1 causing the engine to fail and needing to be replaced

Engine light came on. Running rough. Low engine coolant. Dealer said code was a misfire in Cylinder #2 and coolant was leaking into cylinder #2. Said engine needs to be replaced for $8300.