2018 Ford Edge complaints

I own a 2018 Ford Edge Titanium with a 4 cylinder 2.0 Liter engine. After experiencing check engine light my local dealer stated I need a new engine because of a defect that causes coolant to leak into the engine’s cylinders, which can cause corrosion, oil dilution and contamination, and engine failure. The car does not run now and is parked. I HAVE READ SAFETY ISSUE REPORTS FROM MANY OTHER PEOPLE WITH THIS PROBLEM THAT HAS LEAD TO THE ENGINE MISFIRING BADLY CAUSING LOSS OF POWER AND CONTROL OF THE VEHICLE AND ALSO SOME CASES OF VEHICLE CATCHING FIRE.

The contact owns a 2018 Ford Edge. The contact stated that the vehicle failed to start. The contact stated that the pressure cap of the coolant reservoir was removed, and the vehicle restarted. The check engine warning light illuminated. Additionally, the contact stated that the engine was idling rough. The vehicle was taken to a dealer where it was diagnosed that the long block engine needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 108,000.

I have a 2018 Ford edge SEL with the 2.0 ecoboost engine in it that I just bought June 3rd, 2023. The engine light came on a couple weeks ago, so I took it to the dealership that I bought it from and found out the engine is bad because of coolant leaking into one of the cylinders. Upon further research I found that this is due to a design flaw in the engine by Ford but Ford has not recalled this engine. However Ford has recalled the 1.0 engines along with a couple others. I feel Ford should also recall the 2.0 ecoboost engine because this has been an ongoing issue for many people and the customers shouldn't have to pay for a new engine when it is a defective design that Ford even knows about but hasn't done anything

The contact owns a 2018 Ford Edge. The contact stated that while driving at an undisclosed speed, the steering wheel was shaking. An unknown message was displayed, and the check engine warning light was illuminated. The contact checked the coolant level and discovered that it was empty. The contact added coolant to the coolant reservoir; however, the failure recurred. The vehicle was taken to the dealer, where it was diagnosed with coolant intrusion into cylinder #4, and it was determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 42,800.

I had my car serviced. I drove less than a mile and noticed the check engine light was on. I called the dealer to see if they could check it as I had to drive 120 miles round trip for a doctor’s appointment that day. I was told it indicated a misfire but not to be concerned; I was told it was ok to drive. They cleared the error message and told me I was good to go. The check engine light came on sporadically for a week then stayed on permanently. I called on a Friday and got it in for diagnostics the following Monday (2 weeks from servicing date.) I was told after diagnostics that the coolant was low and they needed 2 hours to remove a spark plug and check cylinder 3. I was advised that they had seen this issue previously on other Ford vehicles and it was not a cheap fix if what they suspected was happening. The Service department later confirmed there was a coolant intrusion (coolant was leaking into cylinder 3.) I was told that this has been an issue for Ford and they have redesigned the block so this can no longer happen. It would just be a matter of time before the engine would be ruined on my vehicle (2018 Ford Edge with slightly over 52000 miles.) Ford knows they have a problem with the design of the engine of the 2018 Ford Edges but they are handling each vehicle individually instead of voluntarily fixing all of them. I do not have an extended warranty so they may offer some financial assistance for the repair but if I had warranty coverage it would be entirely covered

The contact owns a 2018 Ford Edge. The contact stated that while driving at an undisclosed speed, the engine overheated. The contact stated that the temperature gauge indicated that the engine had overheated. The vehicle was taken to the dealer where the vehicle was diagnosed, and the contact was informed that there was a hole in the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact was informed of an unknown recall however, the VIN was not included in the unknown recall. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to report the failure to the NHTSA Hotline. The failure mileage was approximately 78,000. The VIN information unavailable.

2018 Ford Edge, well maintained, 67k miles. Coolant is leaking into Cylinder 4 through is microhole that can cause the engine to explore. The dealership quoted me nearly $11,000 to fix. The car according to Kelley Blue Book is worth that much. This care should be recalled IMMEDIATELY. There is a class action lawsuit against for for this very problem. It is not safe and ford is totally scamming customers out of money based on a manufacturing defect.

The contact owns a 2018 Ford Edge. The contact stated while driving 5 MPH, the vehicle made an abnormal clicking sound. The vehicle was taken to the dealer, where it was diagnosed that the flex plate was fractured, and the engine short block was replaced. Additionally, the contact stated that the vehicle was experiencing rough starts and a rough idling. The check engine warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed that there was coolant intrusion in cylinder #1. The dealer determined that the engine long block needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and a case was opened. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 62,500.

Coolant system started to leak into the cylinders, causing both low-coolant and corrosion of the spark plugs. We contacted a Ford repair center and they said the only remedy is to replace the entire engine. Apparently this is a design flaw. The engine light started go go on in December 2024 and the problem has only gotten worse and worse since then.

The contact owns a 2018 Ford Edge. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed with coolant leaking into the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to call the NHTSA Hotline for assistance. The failure mileage was approximately 97,000.

Car began bucking at first and running rough about 82000 miles on it I changed plugs and shortly after it started again. It began to over heat when I drove from Maine to KY. I found it was low on Coolant. I had to fill it again a month or so later. Mechanic did not find any coolant leaks. I brought it to ford and they told me coolant was getting into the cylinders and I need an engine replacement. I am [XXX] drive like an old man and no reason engine should fail the way I drive I understand Ford recalled the 1.5 echo boost but not the 2.0 and they were made with the same defect. They are aware of this and redesigned the engine. It cost me 6.000 dollars to fix at a time I am nearing retirement. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Two days after I bought this car I took it back to the dealership and told them that there was something wrong with the car. It didn't drive right and when I would put the car in reverse I felt a "flutter" feeling. After they finally got me in to have it looked at, they told me that there was nothing wrong with it. A few months later I took it back to another local Ford dealership after I got a notice in the mail about the transmission. It was not a recall. They also told me there was nothing wrong with it. At this point it would shift hard every now and again. about a month and a half ago, I was driving and a wrench light showed up on my dash. I had a mechanic hook it up to the computer and it was giving me codes P0741-00. I took it to Ford and had them run a diagnostic on it and they called me and told me that I needed a transmission overhaul. If they had fixed it the first two times I had it in to be looked at I wouldn't be without a car right now. I have been in contact with Ford Motor Co also and they are now saying that I still have to pay out over $3200 that I don't have. They were supposed to reach back with me on Fri and still have not heard from them.

The contact owns a 2018 Ford Edge. The contact stated while attempting to start the vehicle, the vehicle failed to start. The contact had the vehicle jumpstarted; however, the check engine warning light was illuminated. The contact stated there was white smoke coming from the exhaust pipes. The contact took the vehicle to an independent mechanic who diagnosed the vehicle and determined that coolant was leaking into the engine, and the engine needed to be replaced. The manufacturer was made aware of the failure. The vehicle was not repaired. The failure mileage was approximately 67,000.

Coolant Leaking Into Cylinders. Ford had already noticed this issue that coolant intrusion into the cylinder with tons of 2015-2018 Edge and 2017-2019 Fusion/MKZ/Escape/MKC vehicles equipped with a 2.0L EcoBoost engine. They have never recall, replace, or even try to fix this issue. It very easily causes engine overheated which is a significant risk. Please consider to have them do a nationally recall and help people on the way to be safe! Thank you

The contact owns a 2018 Ford Edge. The contact stated that while driving at an undisclosed speed, the temperature gauge began to indicate that the engine was overheating, after which the vehicle lost motive power. The contact was able to pull to the shoulder of the roadway, where the failure persisted. The low-coolant warning light was illuminated. The vehicle was towed to an independent mechanic, who determined that coolant was leaking into the engine block. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N12. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 74,000.

The contact owns a 2018 Ford Edge. The contact stated that while driving at an undisclosed speed, the vehicle briefly jerked, after which the contact heard an abnormal sound emanating from underneath the vehicle. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the torque converter. The vehicle was not repaired. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 93,000.

Engine failed due to coolant intrusion on cylinder two! Been experiencing coolant loss with no evidence of where it was going. Have had multiple pressure tests performed with no results of a leak. Started experiencing a spurts of misfire when accelerating up hill or on a high at speeds of 60-75MPH, inconsistently. Happened again on 05/07/2024, called my local dealership and was advised to bring it in to have a tech take a drive. On that drive he was able to replicate misfire to the point a check engine light appeared while my edge was experiencing misfire. When misfire stopped engine light shut off. Once we were back the tech performed diagnostic measures and found coolant spewing into the engine. Resulting in the need of a new engine.

My car is only 6 years old. I have maintained my car for the past 5 years of ownership. My car now needs a complete engine replacement due to coolant leaking into the cylinders. This was looked at by my local Ford dealership. After reading through other reviews it appears that other owners have experienced the exact same issue. I also was told my the dealership that Ford Escapes experienced the exact same issue and there was a recall. My car shakes and rattles and is unsafe to drive. I was told my the dealership that I could still drive it, but it is unknown when the engine will completely fail. I am a mom of two children and I cannot drive a car that could just randomly fail! My check engine line appeared about 2 weeks ago before I could get an appointment to be seen.

The contact owns a 2018 Ford Edge. The contact stated while starting the vehicle, the contact became aware of an abnormally strong gasoline odor. Additionally, there was white smoke coming from the tailpipe. The contact stated that while inspecting the vehicle, the contact became aware that the engine was blown. No warning light was illuminated. The vehicle was towed to the dealer where it was diagnosed with low compression coming from the engine and a failure of the engine cylinders. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 42,000.

The contact owns a 2018 Ford Edge. The contact stated that while driving at an undisclosed speed, the vehicle was shaking abnormally. The check engine warning light was illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The contact related the failure to Technical Service Bulletin: 22-2133 (Coolant in Cylinders, White Exhaust Smoke, And/or Illuminated MIL); however, the vehicle was not covered under the TSB. The failure mileage was approximately 80,000.

While driving, engine went to full hot and shut down some cylinders, decreasing power, in traffic. causing the car to slow down and others had to avoid me. mechanic found the block is cracked, but this VIN # was not included in the recall. cost is $8000.00 to replace engine at less than 70,000 miles. Ford is no help. No warning lamps, until the event, then check engine light and temp gauge going full hot.

The contact owns a 2018 Ford Edge. The contact stated while starting the vehicle, the engine was misfiring. The check engine warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed that cylinder #2 was misfiring. The dealer replaced the coil pack; however, the failure persisted. The vehicle was taken back to the dealer, where it was diagnosed that there was a coolant intrusion in cylinder #2 and in the oil. The dealer determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 56,000.

The Ford Edge 2018 has a common issue with its transmission - it fails to start at low mileage, causing the car to lose power unexpectedly. This could lead to dangerous situations and potentially render the car completely uncontrollable. Ford dealers acknowledge that it's a common problem for this model, but they do nothing about it.

I had my 2018 Ford Edge in Gerald Jones Ford Lincoln dealership services department at Augusta, GA on [XXX] (soonest appointment schedule available) due to check engine light turning on that I detected on [XXX] According to their diagnosis, my vehicle is now in need of total engine rebuild/replace. On [XXX], 12 days prior to the check engine light turning on, my vehicle was at the dealership for its regular maintenance (oil change, tire pressure, top off fluid, etc.) that also included a multi-point inspection. There were no engine issues detected on the vehicle 12 days prior. All of a sudden, 12 days later, the vehicle's engine light turned on and now in need of serious repair. This vehicle has less than 40k mileage. I did some research and based on submitted complaints online from other vehicle owners, I became aware that there are known issues to the engine design causing misfires and coolant leaking into the combustion chamber/engine that is specific to my vehicle's make and model. Ford has not issued a recall but many have reported similar if not exact problems I am experiencing. I reached out to the dealership's General Manager on [XXX] regarding my concerns. I also called his number on [XXX] and left a voicemail message. It has been 3 business days and I have not received any email response or callback from the General Manager. At the moment, I have the vehicle in my possession while I am trying to deal with the current situation. fINFORMATION REDACTED PURSUANT TO THE

Right after I returned home from a 1500 mile trip on a Saturday, my car started having an issue starting. Once I got it started and drove to the store, the Service Engine Soon light came on so I returned home. I checked the owners manual & it said I could drive 50-100 miles so I did make some required stops on Sunday. Had an issue starting the car again. On Monday I called a repair shop & took it in to them on Tuesday morning. They diagnosed the problem as Engine Intrusion - an internal issue causing coolant getting into the engine. They found coolant on the pistons & the TSB says to replace the engine. I contacted Ford Customer service & they had me bring it to a Ford Dealer - who diagnosed the same issue. I have followed all of Ford's maintenance recommendations for my car. If the issue had happened while on my trip home, I would have hesitated to stop so could have risked my safety or others.

The contact owns a 2018 Ford Edge. The contact stated that while driving at an undisclosed speed, the check engine warning light was illuminated on the instrument panel. The vehicle was taken to the dealer, who determined that coolant intrusion into the cylinders had damaged the engine, and the engine needed to be replaced. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N12. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 73,000.

Due to a Ford design flaw my car has experienced what is called "coolant intrusion". TSB 19-2346. My check engine light appeared, solid in color and I brought it in for service/check on [XXX] at Apple Ford in Shakopee, MN. Diagnostics showed a P0302 Cylinder 2 misfire detected. The car was running rough on start-up and idle but once warm would run fine. Replaced all spark plugs & boots as it appeared some corrosion occurred on them. On [XXX] in the AM I was leaving my house to go to work. I pulled out from my townhouse complex onto the road and my car would not accelerate leaving me in the middle of the road. I had to shift my car into neutral and back into drive to be able to move from the middle of the road. Thankfully no other cars were coming at the time to avoid a collision. Once I was back in drive my car would accelerate but the check engine light came back on. I brought it into the dealership on [XXX] and the same code came up P0302 of a cylinder 2 misfire. I was unable to be without a vehicle so I continued to drive it. Thursday the check engine light was no longer illuminated. It did not come back on. I decided to still have it checked as I did not want to be stuck in the middle of the road again unable to accelerate with my child in the car. Dropped it back off Friday night for them to diagnostic again on Saturday AM. I was then called and told I was needing to replace the entire engine due to the design flaw of Ford. Coolant was leaking into cylinder 2 causing the

The contact owns a 2018 Ford Edge. The contact stated while driving from a complete stop, the vehicle shuddered, and the engine was misfiring. The contact stated that the failure had been recurring mostly during cold starts. The check engine warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed that there was coolant intrusion in the cylinders. The dealer determined that the long block needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the VIN was not included in an unknown recall. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 58,000.

In 2015 Ford Motor Company made an engine block modication on the 2.0 Liter Ecoboost (USA made) engines in an effort to keep the turbo boosted engine running cooler. The engine was used till 2019 in Edge and Escape models. For 2020 to current year the engines were redesigned ending the problem. At the end of 2023 I began experiencing a rough idle at times, check engine light displaying, white smoke from the exhaust and intermittent stalling. I was advised by a Ford dealer that I had coolant in my #3 cylinder indicating the problematic block. Ford's TSB (#19-2346 12/19/19) fix was a new engine assembly and also stated itcould result in a engine fire. A estimate roughly $8800.00. I purchased the Edge September 2022 with 32,000 miles. Ford would not extend any warranty coverage since the 5yr drivetrain warranty had passed. Currently the like new Edge (40K miles) sits in my driveway because my daughter is affraid to stall in traffic again with her 7 year old with her. I researched and found the NTSB made Ford perform a recall on 2012-2015 1.5 liter ecoboost engines due to similar problems.

The contact owns a 208 Ford Edge. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated on the instrument panel. After a visual inspection of the engine compartment, the contact observed that the coolant reservoir was abnormally low. No warning lights were illuminated. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N12. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 84,000.

The contact owns a 2018 Ford Edge. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, who determined that coolant intrusion had caused the engine to misfire, resulting in damage to the engine and requiring for the engine to be replaced. The vehicle was repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N12. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 74,000.

The contact owns a 2018 Ford Edge. The contact stated while starting the vehicle, the vehicle was shuddering with white smoke coming from the exhaust pipe. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who replaced the spark plugs; however, the failure recurred. The vehicle was then taken to the dealer, where it was diagnosed with coolant intrusion into cylinder #2 and determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The contact was advised to file a complaint with the NHTSA Hotline. The failure mileage was approximately 61,000.

On [XXX], at a little less than 80,000 miles, the service engine soon light came on one day and my car ran rough. However, it went off for the next day and ran fine, but went back on a few days later and ran rough once again. I took it the Liberty Ford in Parma, OH on [XXX]. They performed an electronic engine diagnostics and determined that the vehicle did run rough and that there was a miss fire in cylinder 3. Based on the Ford bulletin related to this engine, they followed procedure and performed a tune up and replaced the cylinder. I was advised that the bulletin also indicated that there could be a coolant intrusion into the engine assembly. However, Ford requires the service department to follow the process and that is why they did the cylinder replacement. If the engine light came on again in the next few hundred miles, it could be the engine and I should bring it back in. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2018 Ford Edge. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who diagnosed and determined that the head gasket was cracked, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 79,500.

The contact owns a 2018 Ford Edge. The contact stated that while idling, the vehicle was blowing cold air while the heater was activated. The contact then inspected the coolant level and discovered that it was low and added a gallon of antifreeze. No warning light illuminated. The contact mentioned that a gallon of antifreeze needed to be added every week. The vehicle was taken to an independent mechanic where it was diagnosed that there was a coolant leak and that the failure was related to TSB 22-2229. The dealer was contacted and it was confirmed that the VIN was not included in a related recall. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The manufacturer was notified of the failure and referred to the NHTSA Hotline. The failure mileage was 127,000. The contact is requesting her vehicle to be added to the recall.

When I got into my vehicle one morning after it had been parked outside overnight the panoramic sun/moonroof glass looked like it had big cracks throughout, but initially thought it was just puddled water outlines since we'd had a good rain event overnight. After vehicle dried later that day I still saw the lines and when I investigated I could feel the cracks/crevices in the outer glass but it had not cracked on the inner layer of glass. I am not certain if that cracking happened overnight in the rain and/or night cold temp fluctuations in WI, or whether it had started smaller earlier in the week and hadn't immediately noticed it. I am not aware of any stones or hail hitting it that could have pinpointed the cause & and the repair technicians did not find any indication of an impact point which could have been the starting point. I have been limiting my driving until I get it fixed to ensure it doesn't either crack all the way thru and let moisture inside and cause interier damage or completely break apart and fly off into roadway while I'm driving

The contact owns a 2018 Ford Edge. The contact stated that upon attempting to start the vehicle, the vehicle failed to start. No warning lights were illuminated. The vehicle was towed to the dealer, who determined that coolant had leaked into the cylinders, resulting in engine damage. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N12. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 107,000.

[XXX] 2018 FORD EDGE TITANTIUM: [XXX] Engine failure due to coolant intrusion into the cylinders of the Ecoboost 2.0 engine [XXX]. Coolant leaks into the cylinders which leads to corrosion of the piston, gasket, and other parts in the engine causing engine failures and misfires and eventually can trigger a full-blown fire. For this reason, there was a Ford ecoboost coolant leak recall. There has been no fire, but the Ford dealership states that the engine needs replacement due to coolant leaks into the cylinders. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2018 Ford Edge. The contact received notification of NHTSA Campaign Number: 22V413000 (Power Train). The contact stated that while driving at an undisclosed speed, the engine started to overheat. The contact was able to move the vehicle to the shoulder before taking the vehicle to the dealer. The dealer determined there was a crack in cylinder #3, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 88,000.

The contact owns a 2018 Ford Edge. The contact stated that while driving at slow speeds, the vehicle began to buck when the accelerator pedal was depressed. The vehicle was slow to respond when the accelerator pedal was depressed. There were no warning lights illuminated. The vehicle was taken to an independent mechanic, who informed the contact to add two bottles of fuel cleaner to the fuel. The mechanic was unable to duplicate the failure. The vehicle was taken to the local dealer, where it was diagnosed that the torque converter needed to be replaced. The contact was not repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 75,000. The VIN was not available.

The contact owns a 2018 Ford Edge. The contact stated that the vehicle was experiencing coolant intrusion in cylinder #2, causing the engine to misfire. The contact related the failure to TSB Number: 19-2346 with NHTSA ID Number 10169807 (Engine and Engine Cooling). The contact took the vehicle to the dealer where it was diagnosed that the engine had failed and confirmed it was because of a misfire within cylinder #2. The vehicle had not been repaired. The manufacturer was made aware of the failure, and it was confirmed the VIN was not included in a recall nor was the repair covered under warranty. The contact was referred to the NHTSA Hotline to file a complaint. The failure mileage was 86,000.

Adaptive steering fault and steering wheel is off center when driving. Ford dealer can’t figure out problem. A serious safety concern.

The contact owns a 2018 Ford Edge. The contact stated that while driving at an undisclosed speed, the Coolant Level Low message displayed, and there was white smoke coming from the exhaust pipe. The vehicle experienced rough idling. The contact pulled over and turned off the vehicle to cool down the engine. The vehicle was able to restart after several attempts. The vehicle was taken to the dealer, where it was diagnosed with coolant intrusion into the cylinders, and it was determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The contact related the failure to Technical Service Bulletin: 19-2346 (Coolant in Cylinders, White Exhaust Smoke, And/or Illuminated MIL); however, the vehicle was not covered under the TSB. The failure mileage was approximately 130,000.

Smelled gasoline under the hood? Technican ran test of engine and here is his report: "Checked the engine light found multilpe codes, I looked up the codes and they all said replace the engine. Did a headgasket test and found the headgasket is bad and that the coolant smells like fuel also." I was advised not to drive the vehicle! The car has only 58,208 miles on it, as senior citizen my acerage is less than 10,000 miles a year. I replaced the engine --$6,178.08. I have also been advised that I may have transmission problems. A search of the web to check for recallssrongly suggests I am not alone as this problem had been identified by other EDGE owners nation wide! I feel the Ford Motor Company has a major responsibilty for the defect.

Ford Ecoboost 2.0 engine in my 2018 Ford Edge failed at 71,945 miles due to cooling leaking into cylinder #2. Engine started rough for about two weeks but leveled out after about 5 seconds. When the check engine light came on while my wife was leaving home, we stopped driving the car until I could get an appt with Conway Heaton Ford in Bardstown KY. There the engine was found to have coolant leaking into the #2 cylinder. Dealer said the car was unsafe to drive and the engine needed to be replaced. They would not return the keys to me due to the safety hazard the car had become. Engine was replaced on [XXX] at a cost of $6916.00. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

In early 2023 I was driving on the highway and the engine shut down with a low coolant message on the dashboard. After a couple different trips to different mechanics, the local Ford dealer determined there was coolant intrusion in the engine block due to a cracked block. On approx 4/10/23 we ordered the vehicle to be fixed at a cost of $7329.04. Ford customer service was unwilling to help with the issue. This is a known issue among ecoboost Ford engines of this generation. So much so that there was a recall for the 1.5l engines(this is a 2.0l). We called Ford customer service who seemed like they were going to help at first but once the supervisor came on she told us she would not help and "if we truly cared about our vehicle we would have purchased an extended warranty". I personally know 4 other people who have been struck by the ecoboost bug and have had to replace their engines due to the coolant intrusion issue. This issue is a safety issue as the vehicle will shut down once it rears its head.

The contact owns a 2018 Ford Edge. The contact stated that upon start of the vehicle, the check engine warning light intermittently flashed on the instrument panel. The vehicle was taken to a dealer where a diagnostic test was performed, and it was discovered that there was coolant intrusion into cylinder #2. The vehicle was diagnosed with engine failure. The manufacturer was notified of the failure and the contact was informed that there were no recalls on the vehicle. The manufacturer referred the contact to the NHTSA Hotline. The vehicle was not repaired. The failure mileage was approximately 50,000.

First indication of an issue was when the check engine light illuminated (2/1/2024). I took car to an independent repair shop who identified the codes as PO304 - misfire cylinder 4 and P0316 - misfire on start up. Borescope revealed coolant leaking thru #4 cylinder wall & cylinder #1 showing stream of coolant from cylinder head gasket. Ford TSB recommends long block engine replacement due to coolant intrusion in the engine. The car remained parked from 2/2/24 to 3/13/2024. 3/13/2024. On 3/13 I took the car to the local Ford dealership whose service department confirmed the original diagnosis. Safety issue - coolant intrusion into the combustion chamber could induce an engine fire or cause the engine to seize up while being driven. The car is still at the Ford dealership. The mileage when the CELcame on was 72944 miles. Current mileage approximately 72960. Toatal cost to repaired quoted at $ 9,110.01.

2018 Ford Edge purched certified pre-owned in Novemeber 2023. In February, engine light displayed after diagnostic was ran, we were told that there is a coolant intrusion and we would need to replace the entire engine, approximately $8k. Ford Autonation, Valencia and Ford customer service directed us to contact you so we can report the coolant issue which is a known recall for Ford Edge. The VIN number doesn't fall within the recalled models, but since our vehicle is having the same issue, Ford told us to report this issue to you so that the VIN or Factory can be included in the recall. Ford case # CXH01736957. Car is currently at the Ford Autonation, Valencia Service dept.

The contact owns a 2018 Ford Edge. The contact stated while starting the vehicle, the vehicle was idling abnormally rough. The contact stated that the vehicle shuddered, and an abnormal odor was detected, and white smoke was observed coming from the exhaust. The check engine warning light was illuminated. The vehicle was taken to the dealer where it was diagnosed as coolant intrusion with coolant leaking into cylinder #3. The vehicle was not repaired due to the cost. The contact was informed of Customer Satisfaction Program: 21N12. The manufacturer was made aware of the failure and advised the contact to report the failure to the NHTSA Hotline. The failure mileage was approximately 100,000.