2002 Chevrolet Cavalier

Defect. SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Risk. DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy. SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Defect. DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.

Risk. IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy. DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.

Defect. K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Risk. WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy. K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.

Defect. CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.

Risk. FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.

Remedy. DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

Defect. CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk. WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy. PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

Was in a horrible car wreck yesterday and none of my airbag is avoid but yet my no check engine light none of my lights were on so I don't understand the problem you could have nearly killed me is what I got spent around three times and put back at the gas station that I left

Horn doesn't work..replaced fuse still not working..so I wonder if my air bag will work...how do I fix it no body know not even the dealer

JUST PURCHASED A 2002 CHEVY CAVALIER FOR OUR DAUGHTER AND HAVE BEEN TRYING TO FIND OUT IF ANY OF THE 5 RECALLS WERE PERFORMED ON THIS VEHICLE OR NOT. THE NHTSA RECALL PAGE ISN'T WORKING AT THIS TIME AND THE CHEVY LOCAL DEALERSHIP ISN'T WILLING TO HELP. CAN SOMEONE PLEASE PROVIDE SOME ASSISTANCE??

PROBLEM WITH ELECTRICAL SYSTEM THAT OPERATES REAR BLINKERS AND BRAKE LIGHTS. I HAVE CHANGED BULB WHICH ARE NOT THE PROBLEM. I HAVE CHANGED THE ELECTRICAL CONNECTORS. WORKS FINE FOR SHORT PERIOD OF TIME WHEN EITHER OF THESE ARE CHANGED BUT STILL NOT FIXED. STARTED WITH PASSENGER SIDE BUT NOW HAVING ISSUES WITH DRIVER'S SIDE. ONLINE FORUMS SUGGEST MANY OTHERS ARE HAVING THIS ISSUE AS WELL. CANT FIND A PERMANENT FIX. PLEASE HELP. IS NOT BLOWING THE BULBS, JUST STOPS WORKING FOR NO APPARENT REASON.

KEY GET STUCK IN IGNITION IN THE ON POSITION. CANNOT SHUT THE CAR OFF OR REMOVE THE KEY. MUST PULL IGNITION FUSE TO SHUT OFF ENGINE AND THEN DISCONNECT THE BATTERY. GM ACKNOWLEDGE THIS AS A PROBLEM IN 2014 BUT NEVER ISSUED A RECALL.

TL* THE CONTACT OWNS A 2002 CHEVROLET CAVALIER. THE CONTACT STATED THAT THE DASHBOARD OF THE VEHICLE WAS FRACTURED AND DETERIORATING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE DASHBOARD NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED DUE TO PARTS BEING UNAVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 60,000. UPDATED 01/25/17*LJ UPDATED 7/3/18*JB *TR

BRAKE LINES ARE CORRODED WAY TOO EARLY. BEGAN LEAKING. I'M TRYING TO REPLACE THEM MYSELF, BECAUSE I DON'T HAVE 1500-2000 DOLLARS FOR PARTS AND LABOR. LUCKILY THE BRAKES PEDALS WENT TO THE FLOOR IN THE DRIVEWAY WHEN I FOUND THE LEAKS. *TR

CAR WOULD JUST NOT TURN OVER. CAN NOT HEAR FUEL PUMP RUNNING. *TR

DRIVER WAS HEADING SOUTH ON I684, ON THE EXIT RAMP TO 287 WEST, IN HEAVY TRAFFIC. VEHICLE SUDDENLY APPEARED TO SHUT OFF, MAKING IT IMPOSSIBLE TO STEER AND BRAKE. DRIVER RAN OFF THE ROAD AND WENT NOSE FIRST INTO A DITCH, DAMAGING THE FRAME, RADIATOR, AIRCO AND NOSE OF VEHICLE. THE VEHICLE WAS TOTALED AS A RESULT. *TR

THE IGNITION SWITCH LOCKED AND WOULD NOT OPERATE. FIRST THERE WAS A PROBLEM WITH THE IGNITION TURNING ON AND SHUTTING OFF. THEN AFTER THE VEHICLE WAS PARKED, THE IGNITION WOULD NOT SWITCH ON. JUST LIKE THE INFORMATION DISSEMINATED ABOUT THE CHEVY COBALT, BUT A YEAR BEFORE THE ANNOUNCED RECALL. I CONTACTED GM BUT THEY INDICATED THAT MY MAKE, MODEL AND YEAR WAS NOT PART OF THE RECALL. HOWEVER, I HAD TO INSTALL A IGNITION CYLINDER AND KEY KIT ACCORDING TO MY REPAIR INVOICE. I BELIEVE THAT SHOULD A TOTAL REVIEW OF GM VEHICLES OF THE IGNITION PART AS A DEFECTIVE PRODUCT. *TR

WHILE ACCELERATING ON AN ON-RAMP ONTO AN INTERSTATE, I WAS USING MY MULTI-FUNCTION DEVICE (SIGNALING MY MERGE INTO TRAFFIC, THEN ONCE AT 65MPH SETTING CRUISE CONTROL) WHEN THE CAR LOST POWER. I WAS ABLE TO TURN THE STEERING WHEEL SLIGHTLY TO THE RIGHT BEFORE THE WHEEL LOCKED. I TURNED MY EMERGENCY FLASHERS ON AND COASTED/BRAKED MY WAY TO THE SHOULDER OF THE ROAD. THE CAR WAS TOWED TO A MECHANIC WHO TRIED TO FIND THE SOURCE OF THE PROBLEM. THE INCIDENT WAS ON A SATURDAY. ON MONDAY WHEN THE SHOP WAS OPEN FOR BUSINESS, THEY TRIED THE CAR AND IT STARTED/RAN JUST FINE. THEY COULDN'T DUPLICATE THE PROBLEM SO THEY CHARGED ME FOR THE TOW ONLY. PREVIOUSLY, THE CAR WOULD FAIL TO START. SIMILARLY DEAD. I HAVE BEEN TOLD IT WAS THE IGNITION - REPLACED THAT TWICE. I WAS TOLD IT WAS THE FUEL PUMP - REPLACED THAT. I WAS TOLD IT WAS THE MULTI-FUNCTION SWITCH-REPLACED THAT THREE TIMES. WINTER 2013 THE CAR STARTED FINE AND THEN A BLOCK FROM HOME ALL POWER WENT OUT AND ENGINE FAILED TO START UP AGAIN. TOWED CAR TO ELECTRICAL SPECIALIST. THEY RAN DIAGNOSTICS AND FOUND THAT THERE WAS A RUSTED OUT WIRE. REPLACED THE WIRE. IT HAPPENED AGAIN SIX MONTHS LATER. THEY REPLACED ANOTHER WIRE. I'VE NOTICE THE CAR WILL THINK A BLINKER IS OUT BEFORE THE WHOLE ELECTRICAL SYSTEM JUST FAILS. *TR

PURCHASED VEHICLE FROM DEALER 7/12/13 WITH THE FOLLOWING ISSUES: NON-WORKING ODOMETER, BLINKERS, BRAKE LIGHTS THAT FREQUENTLY "SHORT" OUT & A NON-WORKING WINDSHIELD FLUID FUNCTION. I WAS INFORMED BY THE DEALER TO TAKE VEHICLE HOME & RETURN IT THE FOLLOWING DAY FOR THE REPAIRS OF ALL THE ABOVE NOTATIONS THAT WERE DISCOVERED DURING A TEST DRIVE. UPON THE TIME OF RETURN, I WAS SADLY & RUDELY APPROACHED BY THE DEALER. HE STATED THAT HE DID NOT CLAIM TO FIX THESE ISSUES? ON 7/17/13, I FILED A "COMPLAINT" WITH THE BETTER BUSINESS BUREAU REGARDING THIS POOR BUSINESS TRANSACTION. ALL OF WHICH, I HAVE PROOF. DESPITE MY ENDLESS EFFORTS TO CORRECT THIS ISSUE, NOTHING SIGNIFICANT HAS BEEN DONE ON MY BEHALF. I HAVE BEEN PULLED OVER A NUMBER OF TIMES, BECAUSE OF MY FAILING BRAKE LIGHTS - WHICH HAVE BEEN REPLACED ON MULTIPLE OCCASIONS. I HAVE HAD CLOSE ENCOUNTERS OF POTENTIAL DANGEROUS SITUATIONS, WHERE MY BLINKERS HAVE FAILED & BEING STUCK "NOT" KNOWING HOW MUCH MILEAGE I HAVE ON MY CAR. THIS IS A MAJOR SAFETY ISSUE I CANNOT GET RESOLVED & AM HOPEFUL THAT YOU MAY ASSIST. *TR

I WAS DRIVING ON THE HIGHWAY AND A DRIVER TRAVELING WELL UNDER THE POSTED SPEED LIMIT CUT IN FRONT OF ME. I STEPPED ON THE BRAKES AND THE CAR STARTED SLIDING AND WHEN I ATTEMPTED TURN THE WHEEL TO AVOID COLLISION, THE WHEEL WAS LOCKED AND WOULD NOT TURN CAUSING ME TO HIT THE CAR SQUARE IN THE REAR. UPON IMPACT, BOTH AIRBAGS DEPLOYED. AIRBAGS NEVER TOUCHED ME, BUT THE DRIVER'S SIDE COVER SHATTERED THE WINDSHIELD AND THE PASSENGER SIDE COVER SHATTERED THE PASSENGER WINDOW. *JS

MY 2002 CHEVY CAVALIER WAS IN FOR FRONT BRAKES....MECHANIC PHONED AND TOLD ME THAT MY CAR'S SUBFRAME WAS CRACKED. MECHANIC TOLD ME THAT IT WAS COMMON WITH THIS MODEL CAR. CALLED GM AND THEY TOLD ME THAT BECAUSE OF THE AGE OF THE CAR (2002) AND MILEAGE (64,500) THAT THERE WAS NOTHING THAT THEY COULD DO. I TOLD GM THAT MY MECHANIC SAID THAT THIS IS A COMMON PROBLEM WITH THIS PARTICULAR CAR. STILL THEY TOLD ME NOTHING COULD BE DONE. I CALLED CONSUMER AFFAIRS AND THEY TOLD ME TO CONTACT THE ATTORNEY GENERAL'S OFFICE WHICH I DID. I WAS TOLD THAT THE ONLY WAY I COULD MAKE OTHER FOLKS AWARE OF THIS PROBLEM WAS TO CONTACT NHTSA. I BELIEVE THIS TO BE A SAFETY HAZARD FOR OTHER FOLKS THAT HAVE THIS TYPE OF CAR. I WOULD NOT HAVE KNOWN IF NOT FOR THE REPLACEMENT OF MY BRAKES. *TR

ENGINE CRADLE SUBFRAME HAS RUSTED THROUGH ON RIGHT SIDE. LOW MILEAGE, CAR IS PARKED IN A GARAGE, SO IT DOES NOT SIT OUTSIDE ALL DAY AND NIGHT. MY MECHANIC TELLS ME HE HAS SEEN THIS A LOT WITH CHEVYS. HE SAYS IT IS ESPECIALLY TRUE WITH GM CARS DRIVEN IN THE NORTH BECAUSE OF THE WEATHER...SO MUCH FOR BEING IMPORTED FROM DETROIT; ISN'T THAT IN THE NORTH? HE SAYS HE CAN ORDER A USED REPLACEMENT FROM THE SOUTHERN US. I KNOW A CAVALIER IS NOT A TOP-OF-THE-LINE CAR, BUT ISN'T THE FRAME SUPPOSED TO BE THE STROGEST PART? COME ON GM, FIX THIS ISSUE BEFORE SOMEBODY DIES! I WAS GOING TO LET MY 16 YEAR OLD KID DRIVE THE CAR, NOW I HAVE TO TELL HIM THAT HE CAN'T BECAUSE AN AFFORDABLE CAR MADE BY THE BIGGEST US AUTOMAKER IS CHEAPLY MADE AND UNSAFE!? *TR

TL* THE CONTACT OWNS A 2002 CHEVROLET CAVALIER. THE CONTACT WAS SITTING IDLE AT A TRAFFIC STOP WHEN A VEHICLE CRASHED INTO THE REAR OF HIS VECHILE. THE FRONT DRIVER AND PASSENGER SEATS ABNORMALLY COLLAPSED BACKWARD AND BOTH THE CONTACT AND A PASSENGER SUSTAINED INJURIES TO THE BACK. BOTH WERE TRANSPORTED TO THE HOSPITAL VIA AMBULANCE. THE POLICE WERE CONTACTED AND A REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DEEMED AS DESTROYED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND THE CURRENT MILEAGES WERE APPROXIMATELY 57,000.

MULTIPLE TIMES, THE WINDSHIELD WIPER FLUID WOULD NOT FLOW ONTO THE WINDSHIELD. I WOULD FILL THE WINDSHIELD WIPER FLUID TANK SEVERAL TIMES A MONTH. FINALLY, I NOTICED THAT THE DESIGN OF THE WINDSHIELD WIPER FLUIDS TUBING INTO THE WINDSHIELD WIPERS WAS FLAWED. THE TUBING IS ROUTED SO THAT IT PASSES THE WINDSHIELD WIPER TANK AND SEATS UP AGAINST THE HOT CAR BATTERY. AT THIS JUNCTURE, THE TUBING APPARENTLY HAD ROTTED AND MELTED, AND IT CREATED A HUGE HOLE IN THE TUBING. I DO NOT KNOW WHY GENERAL MOTORS DECIDED TO PASS THE WINDSHIELD WIPER TANK, AND SEAT THIS TUBING UP AGAINST THE BATTERY, AND THEN GO DOWN AGAIN, AND FINALLY FIT INTO THE BOTTOM VALVE OF THE WINDSHIELD WIPER TANK, BUT IT SEEMS POINTLESS AND STUPID AND A DEFINITE DESIGN FLAW!!! NOW, I HAVE TO PAY TO HAVE THIS TUBING REPAIRED AND PROBABLY REROUTED THE SIMPLER ROUTE, WHICH WOULD ALLOW IT TO BYPASS THE BATTERY, COMPLETELY, INSTEAD OF PRACTICALLY WRAPPING IT AROUND THE BATTERY!!! *TR

TL* THE CONTACT OWNS A 2002 CHEVROLET CAVALIER. WHILE DRIVING APPROXIMATELY 65 MPH, THE CONTACT APPLIED THE BRAKES AND SUDDENLY THE PEDAL TRAVELED TO THE FLOOR. THE CONTACT DOWNSHIFT AND ENGAGED THE PARKING BRAKE. THE VEHICLE CAME TO A STOP AND WAS DRIVEN TO HIS RESIDENCE WITH CAUTION. THE CONTACT DETECTED THAT THE REAR BRAKE LINE HAD COMPLETELY RUSTED. THE BRAKE LINE WAS REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 104,000. THE VIN WAS UNAVAILABLE.

WHEN THE CD PLAYER HAVE BEEN ON FOR A FEW MINUTES IT WILL STOP PLAYING BECAUSE IT HAVE GOT OVER HEATED. AN I CANNOT USED IT FOR A LONG TIME. *TR

MY 2002 CAVALIER HAD THE FUEL PUMP GO. WHEN THE GARAGE FIXED IT THEY SAID THE CLUSTER DOESN'T WORK. THEY KEPT TRYING TO IMPLY THAT IT WAS ALREADY BROKE BUT IT WASN'T. I HAD 2 LIGHT BULBS GONE BUT THAT'S IT. THEY REPLACED IT AND WITHIN A WEEK THE SAME 2 LIGHT BULBS ARE BURNT OUT AND THE ODOMETER NUMBERS NOW FLICKER CONSTANTLY. THERE MUST BE A WIRING PROBLEM. SEEING FIRES STARTING IN A COUPLE CAVALIARS MAKES ME REALLY CONCERNED. FOR A FEW YEARS NOW, THE RADIO CHANGES EVERYTIME I TURN THE CAR ON AND THE LIGHT BY THE HEATER CONTROL DOESN'T WORK UNLESS YOU TAP ON IT. SOMETHINGS NOT RIGHT AND I'M TRYING TO FIND A SOLUTION. I CAN'T AFFORD TO PAY A GARAGE TO TEAR MY CAR APART. *TR

TIMING CHAIN BROKE ON 2002 CHEVROLET CAVALIER LS CAUSING CATASTROPHIC ENGINE FAILURE. AUTOMOBILE ONLY HAS 70,000 MILES ON A WELL MAINTAINED MOTOR. GM INSTALLED FAULTY OIL NOZZLE AS WELL AS TIMING CHAIN TENSIONER IN MOTOR ORIGINALLY BUT REFUSES RESPONSIBILITY EVEN THOUGH CHECKED AT GM CERTIFIED SERVICE CENTER 4 MONTHS PRIOR COMPLAINING OF TIMING SYMPTOMS. NO REPAIR HAS BEEN DONE AT THIS TIME. AFTER MUCH RESEARCH IT SEEMS THAT THIS IS A COMMON PROBLEM IN ALL VEHICLES FROM 2002 AND 2003 THAT HAVE 2.2L ECOTEC MOTORS. *TR

I DROVE MY 02 CHEVY CAVALIER ON THURSDAY BACK FROM TAHOE,CA AND MY GAS PEDAL GOT STUCK DOWN AND KEPT INCREASING IN SPEED, SO I PRAYED AND THEN STARTED TO MESS WITH MY CRUISE CONTROL AND FINALLY CAME BACK UP, THIS MORNING SAME THING HAPPENED, SO I CALLED CHEVROLET CUSTOMER SERVICE AND THE REP-ERIC TOLD ME THAT I NEED TO PAY FOR A DIAGNOSES BEFORE I CAN GET ANY ANSWERS, HE CALLED UP THE CLOSEST DEALER AND THEY COULD NOT GIVE HIM A QUOTE, I WOULD RATHER BUY A NEW CAR IF I HAVE TO PAY MONEY FOR A DIAGNOSES. THIS INCIDENT IS A MECHANICAL PROBLEM WHICH OCCURS ON ITS OWN. I CANT AFFORD ANOTHER CAR AS OF RIGHT NOW AND AM STILL USING MY CAR FOR WORK. WHAT WOULD YOU SAY I SHOULD DO?? *TR

TL* THE CONTACT OWNS A 2002 CHEVROLET CAVALIER. THE CONTACT STATED THE VEHICLE HAD BEEN PARKED FOR APPROXIMATELY 4 HOURS WHEN A FIRE STARTED UNDER THE DASHBOARD. THE CONTACT STATED THE VEHICLE WAS REMOVED BY HIS INSURANCE COMPANY AND HE COULD NOT CONFIRM IF THE VEHICLE WAS DESTROYED OR WHAT STARTED THE FIRE. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 80,000. UPDATED EVOQ 06/08/10.*JB

THE ENGINE QUITS RUNNING WHILE DRIVING AT HIGHWAY SPEEDS WITHOUT ANY WARNING. AFTER PULLING OFF TO THE SIDE OF THE ROAD,THE ENGINE MAY RESTART IMMEDIATELY OR AFTER A FEW MINUTES. A TECHNICIAN DIAGNOSED THIS AS A FAULTY FUEL PUMP. *TR

I BOUGHT THIS CAR A 2002 CHEVY CAVALIER IN 2005, AND AT THE TIME THERE WAS 25K ORIGINAL MILES SO I WAS TOLD. SINCE THEN I HAVE FOUND OUT THERE HAS BEEN 5 RECALLS ON THIS CAR FOR VARIOUS SAFETY HAZARDS, NONE OF WHICH I WAS EVER TOLD ABOUT PRIOR OR DURING MY PURCHASE OF THIS VEHICLE. THE SIGNALS HAVE FAILED, I HAD TO PAY FOR THEM TO BE REPLACED, THE BEARINGS ON THE TIRES CAUSED DRY ROT AND I HAD TO PAY TO REPLACE THOSE, BOTH WERE ON THE RECALL LIST. THE ENGINE WOULD OVER HEAT IN THE IDLE POSITION, AND THEY REPLACED AN AIR FILTER SITTING THAT AS THE PROBLEM AND IT WASN'T. THE PEDAL STICKS WHEN I ACCELERATE AND SOMETIMES GETS STUCK, THE ROCKERARMS HAVE STARTED TO GO BAD AND IT HAS CAUSED THE VALVE STEMS TO BEND,THUS CAUSING THE OILPUMP TO SEIZE UP AND NOW MY CARS ENGINE HAS A BLOWN GASKET,THIS IS UNDER THE ENGINE COMPONENT SYSTEM RECALL, WHICH WAS REPORTED IN 2007. I WAS NEVER NOTIFIED. AND NOW IM PAYING 350 PER MONTH FOR A CAR THAT IS NOT RUNNING. *TR

TL*THE CONTACT OWNS A 2002 CHEVROLET CAVALIER. WHILE DRIVING APPROXIMATELY 50 MPH ON NORMAL ROAD CONDITIONS; THE STEERING COLUMN AND WHEEL EXHIBITED SEVERE LOOSENESS. IMMEDIATELY, THE VEHICLE SPEED RATE WAS REDUCED AND CONTINUED OPERATION WITH CAUTION. THERE WERE NO PRIOR WARNINGS OF THE FAILURES. THE DRIVER EXPERIENCED EXTREME DIFFICULTY STEERING THE VEHICLE. THE VEHICLE HAS NOT BEEN REPAIRED FOR THE MALFUNCTION AT THIS TIME. THE CONTACT HAD CONCERN OF THE SAFETY RISK INVOLVED. THE FAILURE AND CURRENT MILEAGES WERE 100,000.

TL*THE CONTACT OWNS A 2002 CHEVROLET CAVALIER. A LOCAL MECHANIC ADVISED THE CONTACT THAT HIS FUEL PUMP FAILED AND HE WAS RESPONSIBLE FOR PAYING $500 TO REPAIR IT. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 147,000.

MY 2002 CHEVY LOOKS LIKE IT NEEDS A FUEL PUMP. 3YEARS AGO I HAD THIS SAME PROBLEM AND THE TOW SAID IT WAS THE FUEL PUMP AND I HAD THE FUEL FILTER CHANGED NOW SINCE THEN IT RAN OK. I STILL EXPERIENCED HESITATION BUT AFTER HEARING THE COMPLAINS. I WANT TO ADD MY CONCERN. *TR

HELLO. I HAVE A 2002 CHEVY CAVALIER. I HAVE OWNED THE CAR SINCE 2003. I HAVE AROUND 75,500 MILES ON THE CAR. SINCE OWNING THE CAR MY 'TRAC OFF" LIGHT HAS COME ON FROM TIME TO TIME. WHEN THIS HAPPENS MY CAR JERKS EVERYTIME THE CAR SHIFTS GEARS. IN THE PAST MONTHS IT HAS BEEN HAPPENING MORE AND MORE FREQUENTLY AND IT NOW IS A DAILY OCCURRENCE. ON TWO RECENT OCCASIONS, WHEN THE LIGHT HAS COME ON, WHEN I WAS MAKING A TURN MY CAR SHUT OFF COMPLETELY AND MY STEERING WHEEL AND BRAKES LOCKED UP. ON BOTH OCCASIONS THERE WAS HEAVY TRAFFIC BUT LUCKILY IT DID NOT CAUSE AN ACCIDENT. I AM CONCERNED BECAUSE I HAVE GONE ONLINE AND READ ABOUT HUNDREDS OF OTHERS WHO HAVE HAD TO DEAL WITH THIS ISSUE. I HAVE CALLED CHEVROLET BUT THEY DID NOT SEEM THAT CONCERNED WITH THE ISSUE. I HAVE NOT HAD ANY WORK ON THE CAR DONE TO FIX THE PROBLEM. I AM A STUDENT TRYING TO PAY MY WAY THROUGH GRADUATE SCHOOL SO I CAN'T EXACTLY AFFORD TO TAKE IT TO THE DEALERSHIP TO HAVE IT FIXED. I WOULD NOT HAVE A PROBLEM PAYING TO GET IT FIXED BUT I FEEL THAT SINCE HUNDREDS OF PEOPLE ARE EFFECTED BY THIS THAT IT IS CHEVROLET'S RESPONSIBILITY TO GET THE DEFECTIVE CARS FIXED SO THAT OUR ROADS ARE SAFER. I APPRECIATE YOUR TIME. HOPEFULLY WE CAN GET THIS ISSUE RESOLVED SOON. *TR

I OWN A 2002 CHEVROLET CAVALIER. I RECENTLY FOUND OUT THAT THE CAR WAS NOT MADE WITH THE LATCH SYSTEM SPECIFICALLY THE LOWER ANCHORS IN THE FOLDS OF THE SEAT, SO I CAN INSTALL A CAR SEAT. THE CAR ALSO DOES NOT COME WITH THE CHILD LOCKING MECHANISM IN THE 3 POINT LAP AND SHOULDER BELT. AT THIS POINT I AM UNABLE TO USE MY VEHICLE TO TRANSPORT MY 2 CHILDREN WHO REQUIRE CAR SEATS AS THERE IS NO WAY TO SAFELY INSTALL THE CAR SEAT. I CALLED THE CHEVY DEALERSHIP WHO WAS UNABLE TO FIND THIS PART (LOWER ANCHOR OR SEATBELTS WITH CHILD LOCKING MECHANISM). I CALLED GM AND THEY ARE UNABLE TO SUPPLY THE PARTS AND I HAVE CALLED AFTERMARKET PARTS STORES WHO ARE UNABLE TO FIND PARTS. A SEARCH OF THE INTERNET I FOUND OTHER PEOPLE WITH THE SAME PROBLEM, BUT NO SOLUTION. I FEEL THIS IS VERY DANGEROUS. I AM THE ORIGINAL OWNER OF THE CAR AND I WAS NEVER MADE AWARE OF THIS PROBLEM. *TR

PURCHASED FOUR GOODYEAR TIRES 11/06. WHILE DRIVING 55-60 MPH, VALVE STEM ON LEFT REAR TIRE FAILED (4/16/09) CAUSING TIRE TO COME APART (TREAD SEPARATED FROM SIDEWALL). AFTER SPARE TIRE INSTALLED BY AAA, PROCEEDED TO STORE WHERE ORIGINALLY PURCHASED. GOODYEAR SERVICE CENTER STATED VALVE STEM HAD FAILED; I PURCHASED NEW TIRE AT PRO-RATED COST. SERVICE CENTER ALSO REPLACED VALVE STEMS ON THE OTHER TIRES BECAUSE THEY LOOKED BAD. IN RESPONSE TO A QUESTION FROM ANOTHER CUSTOMER ABOUT VALVE STEMS FROM CHINA, THE CLERK MENTIONED THOSE VALVE STEMS HAD BEEN REMOVED FROM THE CENTER'S INVENTORY. OLD PARTS NOT AVAILABLE. *TR

TL*THE CONTACT OWNS A 2002 CHEVROLET CAVALIER. THE CONTACT STATED THAT THE SEAT BELT WOULD NOT UNLATCH AND PULL OVER HIS SHOULDER. THE FAILURE OCCURS INTERMITTENTLY. THE DEALER HAS NOT YET BEEN NOTIFIED. THE FAILURE AND CURRENT MILEAGES WERE 65,000.UPDATED 03/10/09.*LJ UPDATED 03/11/09. *JB

TL*THE CONTACT OWNS A 2002 CHEVROLET CAVALIER. THE CONTACT STATED THAT HIS FRONT BRAKES WERE IN NEED OF REPLACEMENT AFTER 10,000 MILES. IN ADDITION, THE HYDRAULIC BRAKES CONTINUED TO LOCK ON THE VEHICLE WHILE DRIVING IN FORWARD OR REVERSE. THERE WERE NO WARNING INDICATORS THAT INDICATED THAT THE BRAKING SYSTEM FAILED. IT WAS LATER DISCOVERED THAT THE WARNING INDICATOR SYSTEM ALSO FAILED. THE DEALER INSTALLED AN ATS LIGHTING SYSTEM TO ENSURE THE WARNING PANEL WOULD ILLUMINATE IF THERE WERE ANY FURTHER FAILURES. THE FAILURE MILEAGE WAS LESS THAN 65,000 AND CURRENT MILEAGE WAS 76,500. UPDATED 02/10/09. *LJ THE DEALER REPLACED THE ABS SENSOR LIGHT. UPDATED 02/11/09. *JB

HEADLIGHTS FLICKERING WHEN THEY FLICKER THE HEATER LOSES PRESSURE. *TR

TL*THE CONTACT OWNS A 2002 CHEVROLET CAVALIER. OVER THE PAST TWO YEARS, THE BRAKES LOCK WHEN THE CONTACT DRIVES OVER A BUMP IN THE ROAD. HE WOULD HAVE TO PUMP THE BRAKES IN ORDER FOR THEM TO UNLOCK. HE TOOK THE VEHICLE TO ANOTHER DEALER FOR A DIAGNOSTIC AND WAS INFORMED THAT THERE WAS A SPRING IN THE REAR PASSENGER SIDE THAT CAUSED THE BRAKES TO LOCK. THE SPRING WOULD TRIP A SENSOR ON THE DASH AND THE VEHICLE WOULD STOP. THE DEALER IS REPAIRING THE FAILURE AND IS ALSO INSTALLING AN ABS SENSOR LIGHT FOR THE BRAKES. THE FAILURE MILEAGE WAS 76,000. UPDATED 02/05/09 *BF UPDATED 02/0909. *JB

TL*THE CONTACT OWNS A 2002 CHEVROLET CAVALIER. THE CONTACT PURCHASED THE VEHICLE AS IS WITHOUT A WARRANTY. THE VEHICLE HAS BEEN EMITTING STRONG FUMES REGARDLESS IF THE ENGINE IS RUNNING OR NOT. SHE STATED THAT THE FUMES MAKE HER ILL. SHE NOTIFIED THE DEALER ABOUT THE FUMES AND THEY STATED THAT THE SMELL WOULD GO AWAY, BUT IT STILL PERSISTS. THE POWERTRAIN WAS UNKNOWN. THE CURRENT MILEAGE WAS 100,788 AND FAILURE MILEAGE WAS 100,545.

THE WINDOW MOTORS HAVE BURNED OUT ON BOTH OF MY AUTOMATIC WINDOWS AT A LOW MILEAGE. THE PASSENGER SIDE MOTOR HAD TO BE REPLACED AT 35,000 MILES AND NOW THE DRIVER'S SIDE MUST BE REPLACED AT 60,000. I RARELY USE THE AUTOMATIC WINDOWS, SO I DON'T KNOW WHY THEY HAVE BOTH FAILED. *TR

2002 CHEVROLET CAVALIER STALLED WITHOUT WARNING. CONSUMER STATES THAT THE VEHICLE WAS NOT ABLE TO BE RESTARTED AND WAS TOWED TO A DEALER. THE DEALER STATED THAT THE FUEL PUMP HAD GONE OUT. *KB

BOUGHT A 2002 CHEVY CAVALIER OCT.2007, HAVE HAD THE CAR IN FOR REPAIRS TO THE TRANSMISSION A TOTAL OF 7 WEEKS. THE PROBLEM SEEMS TO BE ELECTRICAL AND CANNOT BE FIXED. EACH TIME I GET IT BACK IT WORKS FOR SOME TIME THEN FAILS AND IS TAKEN BACK. IT IS CURRENTLY AT THE HENNA CHEVY OLDS DEALERSHIP IN AIKEN, SC. *TR

TL*THE CONTACT OWNS A 2002 CHEVROLET CAVALIER. THE ENGINE LIGHT ILLUMINATED INTERMITTENTLY. THE DEALER WAS INFORMED THAT THE OXYGEN SENSOR NEEDED TO BE REPLACED. THE CONTACT WAS CHARGED $600 FOR THE REPAIR. SHE TOOK A LONG TRIP AND THE LIGHT DID NOT ILLUMINATE. ON A SHORTER TRIP, THE ENGINE LIGHT BEGAN ILLUMINATING INTERMITTENTLY AGAIN AND THE VEHICLE OVERHEATED. WHEN THE VEHICLE WAS TURNED OFF AND RESTARTED, IT OPERATED NORMALLY. WHILE DRIVING 10 MPH TO THE DEALER, THE ENGINE FAILED AND THE DEALER STATED THAT THE REPAIR WOULD COST $5,000 AND COULD NOT GUARANTEE THAT THE VEHICLE WOULD ACTUALLY BE REPAIRED. THE CONTACT LEARNED THAT THE HEAD FAILED BEFORE AT 28,000 MILES. SHE BELIEVES THAT HER VEHICLE WAS MIS-DIAGNOSED THE FIRST TIME. THE CURRENT AND FAILURE MILEAGES WERE 54,000. UPDATED 01-10-08. *KB 12/31/07. *JB

WHOLE VEHICLE FILLED WITH GAS FUMES. CHECK GAUGES LIGHT WENT ON AND FUEL GAUGE FAILED IN IDLE. REPLACED FUEL PUMP AT DEALERSHIP AT A COST OF 770.72. *TR

TL*THE CONTACT OWNS A 2002 CHEVROLET CAVALIER. WHILE DRIVING 17 MPH, THE ACCELERATOR PEDAL EXTENDED TO THE FLOOR WHEN IT WAS DEPRESSED. SHE DEPRESSED THE BRAKE PEDAL, BUT THE VEHICLE FAILED TO STOP. THE CONTACT DROVE INTO A DITCH TO AVOID BEING HIT BY A TRACTOR TRAILER THAT WAS TRAVELING 95 MPH. THE ENTIRE PASSENGER SIDE OF THE VEHICLE WAS DESTROYED FROM THE REAR TO THE FRONT END. THE AIR BAGS FAILED TO DEPLOY. FIVE PASSENGERS SUSTAINED INJURIES. A POLICE REPORT WAS FILED. THE CURRENT MILEAGE WAS 129,000 AND FAILURE MILEAGE WAS 100,000.

2002 CAVALIER- REAR RIGHT TURN SIGNAL AND STOP LIGHT BECOME INACTIVE- I THOUGHT THAT THE BULB BURNED OUT. WHEN I REPLACED THE BULB, IT STOPPED WORKING AGAIN AFTER A WHILE. I PUT ELECTRICAL GREASE INTO THE SOCKET AS ADVISED BY MY DEALER, BUT IT STOPPED WORKING NONETHELESS. WHEN I PULLED OUT THE BULB AND RE-INSERTED IT, IT WORKED AGAIN FOR SHORT TIME. I HAVE TO PULL OUT THE BULB TO BREAK THE CIRCUIT, AND THEN INSERT THE BULB BACK AGAIN EVERY FEW BLOCKS. THE TURN SIGNAL WILL WORK FOR A LITTLE BIT, BUT IT WILL STOP, ESPECIALLY WHEN I TURN ON MY DASHBOARD VENTILATION ON HIGH. I HAVE HAD MANY NEAR-MISSES OF BEING REAR-ENDED WHEN MAKING A TURN. APPARENTLY, THE DEFECTIVE BULB HOUSING HAS BEEN A RECALL ISSUE FOR THE 2001 AND 2003 CAVALIER DUE TO ACCIDENTS. THE BULB HOUSING IS THE SAME DESIGN AND PRODUCED BY THE SAME MANUFACTURER FROM 2001 TO 2003, BUT MY DEALERSHIP REFUSES TO ACKNOWLEDGE THAT THERE ARE ANY ISSUES WITH IT. *TR

TL*THE CONTACT OWNS A 2002 CHEVROLET CAVALIER. WHILE DRIVING IN REVERSE AT 15 MPH, THE CONTACT COULD NOT CONTROL THE VEHICLE'S STEERING WHEEL. THE STEERING WHEEL MOVED FROM SIDE TO SIDE. THE CONTACT WAS ABLE TO MOVE IT BY LIFTING UP THE WHEEL. THE DEALER WAS NOTIFIED, BUT ONLY STATED HOW MUCH IT WOULD COST TO REPAIR THE FAILURE. THE ENGINE SIZE AND TRANSMISSION TYPE WERE UNAVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE 72,810.

DRIVER'S SIDE FRONT POWER WINDOW NO LONGER WORKS. *AK

CD PLAYER STOPS WORKING WHEN IT GETS HOT. REPLACED CD PLAYER/RADIO-SAME PROBLEM. *AK

CHEVROLET CAVALIER, 4D SED....WHICH I TAKE VERY GOOD CARE OF 1.) RIGHT FRONT WINDOW WOULD NOT GO UP HAD TO HAVE RIGHT FRONT DOOR TRIM PANEL, MOVABLE GLASS R & I & REPLACE RIGHT FRONT DOOR POWER GLASS REGULATOR $399.48 (REPAIRED: 05/09/06) THEN 2.) LEFT RIGHT WINDOW WOULD NOT GO UP. ASKED SERVICE DEPT IS CHEVROLET AWARE OF THIS PROBLEM SINCE INTERNET SHOWING OTHERS WITH SAME PROBLEMS - THEY SAY NO! "C/S WINDOW INOP LEFT REAR, 60005 LR POWER WINDOW MOTOR INTERNAL PROBLEM 1.0 REMOVE & REPLACE LR POWER WINDOW MOTOR" $356.95. (REPAIRED: 01/13/07). NOW 3.) (02/12/07) THE FLT WINDOW IS STARTING TO STOP AGAIN, JUST AS THE LAST TWO REPAIRS STARTED....I'M NOT THE ONLY ONE WITH THIS PROBLEM... GO ON LINE SEE OTHERS WITH THE SAME PROBLEMS YET CHEVROLET SAYS THERE IS NOTHING WRONG.... WHY CAN'T MANUFACTURER'S STAND BEHIND THEIR PRODUCT. IF THIS WAS AN ISOLATED PROBLEM, I WOULD UNDERSTAND BUT SOMETHING IS WRONG SO THAT I CAN NOT TAKE THE CHANCE OF ROLLING DOWN MY WINDOW SINCE I CAN NOT AFFORD, AS A SINGLE PARENT WITH A DISABLED CHILD TO REPAIR ANOTHER WINDOW. PLEASE, DO SOMETHING. *JB

I WAS INVOLVED IN A MAJOR ACCIDENT WHICH RESULTED IN THE TOTALING OF MY 2002 CHEVROLET CAVALIER. ALTHOUGH THERE WAS CONSIDERABLE FRONT-END DAMAGE THE AIRBAGS DID NOT DEPLOY. *JB

BOTH REAR TAIL LIGHTS DO NOT FUNCTION PROPERLY. WHEN USING THE LEFT TURN SIGNAL IT WILL BLINK FOR A SHORT TIME THEN GO STATIONARY. NEW BULBS ARE PUT IN REGULARLY BUT THE SOCKET IS LOOSE AND WILL NOT HOLD THE BULB SECURELY RESULTING IN THE BLINKERS NOT WORKING MOST OF THE TIME. MY HUSBAND IS A MECHANIC SO I HAD HIM REPLACE THE BULBS WHEN IT FIRST HAPPENED, HE DID THIS IN THE EVENING, THE NEXT DAY I USED THE BLINKER IF WORKED FINE FOR MY FIRST TURN THEN THE SECOND TURN IT WAS A FAST BLINK WHICH INDICATES THAT ONE OR MORE BULBS ARE BURNED OUT WHICH WAS NOT THE CASE WHEN HE LOOKED AT THE BULBS AGAIN LATER THAT EVENING. I CAN'T TELL YOU HOW MANY TIMES WE HAVE CHANGED THESE BULBS AND STILL NOTHING IS WORKING. I AM AFRAID OF HAVING AN ACCIDENT DUE TO THE FACT THAT MOST PEOPLE DON'T RECOGNIZE HAND SIGNALS FOR LEFT AND RIGHT TURNS. I HAVE CALLED THE DEALERSHIP BUT THEY WANT OVER $100.00 FOR A NEW SOCKET. I DON'T FEEL LIKE I SHOULD HAVE TO REPLACE THEM AT MY COST WHEN THIS HAS TO BE SOME SORT OF MANUFACTURERS DEFECT. *NM

DT*: THE CONTACT STATED THE TAIL LIGHTS AND TURN SIGNALS WERE OBSERVED TO BE INOPERABLE. THE VEHICLE WAS DRIVEN TO THE DEALER WHO DETERMINED THE TAIL LIGHT CIRCUIT BOARD NEEDED TO BE REPLACED.