2019 Blue Bird Vision

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2019-2024 Vision and All American school buses. The emergency exit label operating instructions lettering is too small and may be difficult to read. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 217, "Bus Emergency Exits and Window Retention and Release."

Risk. An emergency exit label that is difficult to read can prevent or delay the use of the emergency exit, increasing the risk of injury.

Remedy. Dealers will replace the emergency exit label, free of charge. Owner notification letters were mailed December 9, 2024. Owners may contact Blue Bird Customer Service at 478-822-2242. Blue Bird's number for this recall is R23CK (SB).

Defect. Blue Bird Bus Company (Blue Bird) is recalling certain 2018-2021 Vision school buses equipped with 6.8L gasoline engines. The coating on the fuel lines may have been improperly applied, which can result in a fuel leak.

Risk. A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy. Dealers will inspect and replace the fuel lines as necessary, free of charge. Owner notification letters were mailed October 10, 2024. Owners may contact Blue Bird customer service at 1-478-822-2242.

Defect. Blue Bird Bus Company (Blue Bird) is recalling certain 2018-2021 Vision transit buses equipped with 6.8L gasoline engines. The coating on the fuel lines may have been improperly applied, which can result in a fuel leak.

Risk. A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy. Dealers will inspect and replace the fuel lines as necessary, free of charge. Owner notification letters were mailed October 10, 2024. Owners may contact Blue Bird customer service at 1-478-822-2242.

Defect. Blue Bird Bus Company (Blue Bird) is recalling certain 2019-2023 Vision, All American Front Engine, and All American Rear Engine school buses. An exterior roof joint may have been manufactured with insufficient strength that can allow the roof panels to separate in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 221, "School Bus Body Joint Strength."

Risk. Roof panels that separate during a crash can increase the risk of injury.

Remedy. Dealers will inspect the roof panel joints and install additional rivets as necessary, free of charge. Owner notification letters were mailed September 17, 2024. Owners may contact Blue Bird customer service at 1-478-822-2242.

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2018-2021 All American and Vision School Buses, equipped with PowerDrive 7000 electric drive systems. The System Control Module (SCM) may activate the anti-rollback feature, causing the vehicle to reverse faster than expected when the vehicle is in reverse and pointing downhill with the brake pedal not applied.

Risk. A vehicle reversing faster than expected can increase the risk of a crash.

Remedy. Dealers will update the SCM software calibration, free of charge. Owner notification letters were mailed May 10, 2023. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R23CG (SB)

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2013-2021 Vision school buses equipped with Ford 6.8L LPG engines. The LPG supply line may be damaged from contact with the RH park brake cable, which can result in a fuel leak.

Risk. A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy. Dealers will inspect and repair the fuel lines and the park brake cable, free of charge. Owner notification letters were mailed on November 18, 2022. Owners may contact Blue Bird's customer service at 1-478-822-2242. Blue Bird's number for this recall is R22CA-SB.

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2017-2023 Blue Bird Vision school buses equipped with Roush fuel return lines included in GEN 4 and GEN 5 LPG Conversion Systems that were installed on vehicles sold or registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, Washington D.C., West Virginia, and Wisconsin. The zinc-plating on the fuel return line may break away when contacted by road debris, causing two dissimilar metals on the fuel line to contact each other and corrode.

Risk. A corroded fuel line can leak fuel, increasing the risk of a fire.

Remedy. Dealers will replace the fuel return lines, free of charge. Owner notification letters were mailed May 24, 2023. Owners may contact Blue Bird's customer service at 1-478-822-2242. Blue Bird's number for this recall is R22BX-SB.

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2018-2023 Blue Bird Vision transit buses equipped with Roush fuel return lines included in GEN 4 and GEN 5 LPG Conversion Systems that were installed on vehicles sold or registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, Washington D.C., West Virginia, and Wisconsin. The zinc-plating on the fuel return line may break away when contacted by road debris, causing two dissimilar metals on the fuel line to contact each other and corrode.

Risk. A corroded fuel line can leak fuel, increasing the risk of a fire.

Remedy. Dealers will replace the fuel return lines, free of charge. Owner notification letters were mailed May 24, 2023. Owners may contact Blue Bird's customer service at 1-478-822-2242. Blue Bird's number for this recall is R22BX-NSB.

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2018-2022 All American and Vision school buses equipped with Cummins PD7000 Electric Drivetrains containing an electric air compressor. The air compressor housing is improperly grounded, causing electrical voltage greater than 50V AC during operation.

Risk. An improperly grounded air compressor can cause electric shock, increasing the risk of injury.

Remedy. Dealers will install an electrical ground strap between the compressor motor housing and vehicle chassis, free of charge. Owner notification letters were mailed February 6, 2023. Owners may contact Blue Bird's customer service at 1-478-822-2242. Blue Bird's number for this recall is R22BY-SB.

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2018-2021 Vision and All American school buses. The drivetrain may experience an electromagnetic noise on the Control Area Network (CAN) bus, which may cause a loss of electrical power to the power steering pump.

Risk. A loss of assisted power steering increases the risk of a crash.

Remedy. Cummins will replace the High Voltage Low Power Inverter Harness, and install an overlay harness, free of charge. Interim owner notification letters were mailed on May 22, 2021. Owner notification letters were mailed on October 25, 2021. Owners may contact Blue Bird customer service at 1-478-822-2242.

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2018-2021 Vision and All American school buses. The electric drive train cannot detect isolation faults when the high voltage contactors are closed.

Risk. An undetected high voltage isolation can expose service personnel to high voltage, increasing the risk of injury.

Remedy. Blue Bird will notify owners, and dealers will update the Vehicle Control Unit software or install a different combination of High Voltage Power Distribution Unit hardware, free of charge. The recall began on May 22, 2021. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R21BD-SB.

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2020-2022 Vision and All American buses. The seats with integrated 3-point seat belts may have been installed incorrectly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages."

Risk. An incorrectly installed seat can increase the risk of injury in the event of a crash.

Remedy. Blue Bird will notify owners, and dealers will inspect the seats and install any missing hardware, as necessary, free of charge. The recall is expected to begin April 9, 2021. Owner notification letters were mailed February 03, 2022. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R21BB-SB.

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2019-2021 Vision and All-American transit buses. The three-point seatbelt assembly may have been installed without reinforcing washers under the floor at the anchorage point, possibly preventing the assembly from remaining anchored in the event of a crash. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard number 210, "Seat Belt Assembly Anchorages."

Risk. In the event of a crash, seat belt anchorages that do not remain secured increase the risk of injury to those seat occupants.

Remedy. Blue Bird will notify owners, and dealers will inspect the seat belt anchorage point hardware and install any missing hardware as needed, free of charge. The recall began August 11, 2020. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R20AX-NSB.

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2018-2021 All-American and 2019-2021 Vision school buses. The three-point seatbelt assembly may have been installed without reinforcing washers under the floor at the anchorage point, possibly preventing the assembly from remaining anchored in the event of a crash. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard number 210, "Seat Belt Assembly Anchorages."

Risk. In the event of a crash, seat belt anchorages that do not remain secured increase the risk of injury to those seat occupants.

Remedy. Blue Bird will notify owners, and dealers will inspect the seat belt anchorage point hardware and install any missing hardware as needed, free of charge. This recall began August 11, 2020. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R20AX.

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2019-2021 Blue Bird Vision school buses powered by Compressed Natural Gas (CNG) or Liquefied Petroleum Gas (LPG). The castle nuts used to connect the steering drag link to the steering arm may have not been correctly tightened, potentially causing separation of the drag link.

Risk. If the drag link separates, loss of steering control my occur, increasing the risk of a crash.

Remedy. Blue Bird will notify owners, and will inspect the drag link assembly connection points, tightening them as necessary, free of charge. This recall began July 27, 2020. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R20AW-SB.

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2018-2021 Vision school buses equipped with Ford 6.8L gasoline engines with an optional right-hand mounted parking brake lever. Due to improper routing of the parking brake cables, the parking brake cable may contact and chafe the gasoline fuel line, potentially causing a fuel leak.

Risk. A fuel leak increases the risk of a fire.

Remedy. Blue Bird will notify owners, and dealers will inspect and secure the parking brake cable, as necessary, free of charge. The recall began May 28, 2020. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R20AQ-SB.

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2006-2021 Vision and 2007-2013 All American school buses. The floor-mounted parking brake may fail to hold the vehicle stationary on an incline when the vehicle is loaded to its maximum weight, due to an insufficient application force. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 105, "Hydraulic and Electric Brake Systems."

Risk. A parking brake system that is set to an insufficient application force may result in an increased possibility of unintended vehicle movement, which increases the risk of a crash.

Remedy. Blue Bird will notify owners, and dealers will inspect the floor mounted park brake application force hand lever assembly and correct the application force, as necessary, free of charge. The recall is expected to begin June 24, 2020. Owners may contact Blue Bird customer service at 478-822-2242. Blue Bird's number for this recall is R20AO-SB.

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2009-2019 Vision transit buses. The floor-mounted parking brake may fail to hold the vehicle stationary on an incline when the vehicle is loaded to its maximum weight, due to an insufficient application force. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 105 "Hydraulic and Electric Brake Systems."

Risk. A parking brake system that is set to an insufficient application force may result in an increased possibility of unintended vehicle movement, which increases the risk of injury to bystanders.

Remedy. Blue Bird will notify owners, and dealers will inspect the floor mounted park brake application force hand lever assembly and adjust the application force, as necessary, free of charge. The recall is expected to begin June 24, 2020. Owners may contact Blue Bird customer service at 478-822-2242. Blue Bird's number for this recall is R20AO-SB.

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2008-2021 Vision and All American school buses. The seat barrier behind the driver seat with an integrated 3-point seat belt may have been installed incorrectly and may be missing the reinforcing bracket. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 222, "School Bus Passenger Seating and Crash Protection."

Risk. In the event of a crash, the seat barrier may not adequately protect the occupant seated behind the seat barrier separating them from the driver seat with integrated 3-point seat belt, increasing the risk of injury.

Remedy. Blue Bird will notify owners, and dealers will inspect and properly install the seat barrier including adding reinforcing bracket, as necessary, free of charge. The recall is expected to begin April 23, 2020. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R20AM-SB.

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2018-2019 Vision and All American school buses equipped with 7000 EV electric drivetrain units. A connector within the wire harnesses may become unplugged causing loss of communication between control modules, resulting in sudden loss of drive power and power steering.

Risk. A sudden loss of drive power and loss of power steering increases the risk of a crash.

Remedy. Blue Bird will notify owners, and Cummins dealers will install a cable tie on the connector to maintain the connector locking tab in the locked position, free of charge. The recall began March 12, 2020. Owners may contact Blue Bird customer service at 1-478-822-2242 or Cummins customer service at 1-800-286-6467. Blue Bird's number for this recall is R20AL-SB.

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2013-2020 Vision transit buses equipped with Ford engines. The brake light switch mounting bracket may have caused the brake light switch to be incorrectly adjusted at installation and/or the brake light switch mounting bracket may deform when the driver allows the brake pedal to return forcibly. An incorrectly adjusted brake light switch or deformed brake light switch mounting bracket may cause the brake lights to illuminate continuously.

Risk. Improperly functioning brake lights could confuse following motorists and fail to warn them that the bus may be stopping, increasing the risk of a crash.

Remedy. Blue Bird issued owners an interim notification December 10, 2019. Dealers will install a new, redesigned brake light switch mounting bracket along with a new brake light switch, free of charge. The recall began March 6, 2020. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R19AI-NSB.

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2013-2020 Vision school buses equipped with Ford engines. The brake light switch mounting bracket may have caused the brake light switch to be incorrectly adjusted at installation and/or the brake light switch mounting bracket may deform when the driver allows the brake pedal to return forcibly. An incorrectly adjusted brake light switch or deformed brake light switch mounting bracket may cause the brake lights to illuminate continuously.

Risk. Improperly functioning brake lights could confuse following motorists and fail to warn them that the bus may be stopping, increasing the risk of a crash.

Remedy. Blue Bird distributed owners an interim notification on December 10, 2019. Dealers will install a new, redesigned brake light switch mounting bracket along with a new brake light switch, free of charge. The recall began March 6, 2020. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is S19AI-SB.

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2018-2019 Vision and All American school buses equipped with Cummins PowerDrive 7000 EV electric drivetrain units. Due to a software error, the VCU may activate the anti-roll back feature during slow moving or stop and go conditions, which can cause unexpected vehicle movement.

Risk. Unexpected vehicle movement can increase the risk of a crash.

Remedy. Blue Bird has notified owners, and Cummins dealers will update the VCU software, free of charge. The recall began October 30, 2019. Owners may contact Cummins customer service at 1-800-286-6467 or Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R19AJ-SB.

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2019-2021 All American and Vision school buses. An insufficient number of rivets were installed in the roof sheets, allowing the roof sheets to separate in the event of a severe impact. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 221, "School Bus Body Joint Strength."

Risk. In the event of a crash, if the roof sheets separate, there is an increased risk of injury.

Remedy. Blue Bird will notify owners, and dealers will inspect the roof joints and add the sufficient number of rivets, as necessary, free of charge. The recall began October 22, 2019. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R19AH.

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2018-2020 Vision and All American school buses equipped with Specialty Manufacturing Prolo roof emergency exit hatches. Due to a manufacturing issue, the roof hatch external handle may unexpectedly break under reasonable use. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 217, "Bus Emergency Exits and Window Retention and Release."

Risk. If the roof hatch external handle breaks, in the event of an emergency, the hatch cannot be easily opened from outside the vehicle, increasing the risk of injury.

Remedy. Blue Bird will notify owners, and Specialty dealers will replace the outer handle, free of charge. The recall began August 21, 2019. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R19AF - SB.

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2018-2019 Vision and All American school buses equipped with PowerDrive 7000 EV electric drivetrains. The Vehicle Control Unit (VCU) may unexpectedly shut down the high voltage contactors, resulting in loss of all systems powered by high voltage, including the traction drive system and power steering.

Risk. An unexpected loss of drive and power steering may increase the risk of a crash.

Remedy. Cummins will notify Blue Bird owners and will update the VCU software with a revised version, free of charge. The recall began July 24, 2019. Owners may contact Cummins customer service at 1-800-286-6467 or Blue Bird at 1-478-822-2242. Blue Bird's number for this recall is R19AE (SB).

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2015-2020 Vision and All American school buses equipped with Bendix ADB22X air brakes. The driver side rear brakes may drag.

Risk. A dragging brake may cause damage to the brake components, which may activate the ABS warning light. The warning light may cause the driver to immediately stop the vehicle and transfer occupants. Additionally, the high temperatures at the wheel end can increase the risk of a fire. Either condition increases the risk of injury.

Remedy. Blue Bird will notify owners, and dealers will install a new caliper with an updated clearance adjustment mechanism, free of charge. Blue Bird issued owners interim notification on July 18, 2019. The recall began August 28, 2019. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R19AA - SB.

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2016-2020 Vision and 2015-2020 All American non-school buses equipped with ADB22X disc brakes. The driver side rear brakes may drag.

Risk. A dragging brake may cause damage to the brake components, which may activate the ABS warning light. The warning light may cause the driver to immediately stop the vehicle and transfer occupants. Additionally, the high temperatures at the wheel end can increasing the risk of a fire. Either condition increases the risk of injury.

Remedy. Blue Bird will notify owners, and dealers will install a new caliper with an updated clearance adjustment mechanism, free of charge. Blue Bird issued owners interim notification on July 18, 2019. The recall began August 28, 2019. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R19AA - NSB.

Defect. Blue Bird Body Company (Blue Bird) is recalling one 2019 Blue Bird Vision bus equipped with a Ricon S-Series Titanium Wheelchair lift. The wheelchair lift positioning input cam may fail while the lift is in use, allowing the platform to travel higher than the vehicle's floor height. As such, this vehicle fails to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 403, "Platform Lift Systems."

Risk. If the wheelchair lift platform raises above the height of the vehicle floor, the wheelchair user could fall inwards toward the vehicle, increasing their risk of injury.

Remedy. Blue Bird has notified the owner and Ricon will replace the wheelchair lift positioning input cam, free of charge. The recall began March 4, 2019. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R19ZP-NSB.

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2015-2019 Vision and All American school buses equipped with Ricon S-Series Titanium Wheelchair lifts. The wheelchair lift positioning input cam may fail while the lift is in use, allowing the platform to travel higher than the vehicle's floor height. As such, this vehicle fails to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 403, "Platform Lift Systems."

Risk. If the wheelchair lift platform raises above the height of the vehicle floor, the wheelchair user could fall inwards toward the vehicle, increasing their risk of injury.

Remedy. Blue Bird will notify owners, and Ricon dealers will replace the wheelchair lift positioning input cam, free of charge. The recall began March 4, 2019. Owners may contact Ricon customer service at 1-800-322-2884. Blue Bird's number for this recall is R19ZP-SB.

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2017-2019 Vision school buses equipped with Cummins ISV5.0 diesel engines with optional CP80009 air compressors. The air compressor belt may slip, reducing air output, which may result in the parking brake automatically applying.

Risk. If the parking brake applies while the vehicle is being driven, it can increase the risk of a crash.

Remedy. Blue Bird has notified owners, and dealers will replace the existing air compressor belt with a new shorter air compressor belt, free of charge. The recall began February 1, 2019. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R19ZW-SB.

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2013-2020 Blue Bird Vision school buses equipped with the Ford 6.8L V10 engines. The hydraulic brake lines or transmission shifter cable may have been improperly routed, causing the brake line to be exposed to excessive heat, and leak hydraulic brake fluid. Additionally, the transmission shifter cable could contact the gasoline fuel supply line to the engine which may result in a fuel leak.

Risk. A hydraulic brake fluid leak or a fuel line failure can increase the risk of a fire.

Remedy. Blue Bird will notify owners, and dealers will install a bracket which will insulate the brake lines from excessive heat, control routing of the brake lines, and secure the transmission shifter cable away from the fuel line, free of charge. The recall began February 7, 2019. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R19ZV-SB.

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2016-2020 Blue Bird Vision transit buses equipped with the Ford 6.8L V10 engines. The hydraulic brake lines or transmission shifter cable may have been improperly routed, causing the brake line to be exposed to excessive heat, and leak hydraulic brake fluid. Additionally, the transmission shifter cable could contact the gasoline fuel supply line to the engine which may result in a fuel leak.

Risk. A hydraulic brake fluid leak or a fuel line failure can increase the risk of a fire.

Remedy. Blue Bird will notify owners, and dealers will install a bracket which will insulate the brake lines from excessive heat, control routing of the brake lines, and secure the transmission shifter cable away from the fuel line, free of charge. The recall began February 7, 2019. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R19ZV-NSB.

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2019 Blue Bird All American and Vision school buses. The parking brake cable may disengage from the foot pedal assembly, possibly allowing the bus to unintentionally move. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 105, "Hydraulic and Electric Brake Systems."

Risk. Unintended movement can increase the risk of a crash.

Remedy. Blue Bird will notify owners and dealers will install a clevis cable retention clip and cable-end return spring, free of charge. The recall began February 6, 2019. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R19ZU-SB.

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2019 Blue Bird All American and Vision transit buses. The parking brake cable may disengage from the foot pedal assembly, possibly allowing the bus to unintentionally move. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 105, "Hydraulic and Electric Brake Systems."

Risk. Unintended movement can increase the risk of a crash.

Remedy. Blue Bird will notify owners and dealers will install a clevis cable retention clip and cable-end return spring, free of charge. The recall began February 6, 2019. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R19ZU-NSB.

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2020 Blue Bird All American and 2019-2020 Blue Bird Vision school buses, equipped with certain HSM NextGen 45" 3PT school bus seats, part number GenQ3-45 LH. There may be an insufficient number of bolts attaching the seat to the bus floor, allowing the seat to detach from the bus floor in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages."

Risk. In the event of a crash, if the bus seat detaches from the floor, it can increase the risk of injury.

Remedy. Blue Bird will notify owners, and dealers will install a secondary floor mounting brace, free of charge. The recall began December 12, 2018. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R18ZT-SB.

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2017-2019 Vision school buses with Ford 6.8L Gen IV LPG, Gasoline, or CNG engines. The alternator cables may not be routed correctly and may contact and chafe against the air conditioning support bracket or a firewall reinforcement.

Risk. A damaged alternator cable could cause result in an electrical short, increasing the risk of a fire.

Remedy. Blue Bird will notify owners, and dealers will verify that the air conditioning bracket and the alternator cables are properly installed, repairing them as necessary, free of charge. The recall is expected to begin December 06, 2018. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Birds recall number is R18ZO-SB.

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2019 Blue Bird All American and 2019-2020 Blue Bird Vision school buses, equipped with certain NextGen School Bus seats with Integrated Child Restraint Systems. These seats may be missing a warning label on the lower restraint strap. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 213, "Child Restraint Systems."

Risk. Without a warning label, the seat may be used improperly, increasing the risk of injury.

Remedy. Blue Bird will notify owners, and dealers will install a warning label to the lower restraint strap portion of the Restraint Belt System, free of charge. The recall began September 26, 2018. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R18ZN-SB.

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2018-2019 Blue Bird All American and Vision transit buses. The primary and secondary air brake gauges on the instrument cluster may intermittently indicate "0 PSI" instead of the correct air pressure in the tanks. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 121, "Air Brake Systems."

Risk. If the gauges do not correctly display the air pressure that is in the tanks, the operator will not be able to know when the air pressure is actually dropping, increasing the risk of a crash.

Remedy. Blue Bird will notify owners, and dealers will update the display software, free of charge. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R18ZE-NSB.

Defect. Blue Bird Body Company (Blue Bird) is recalling certain 2018-2019 Blue Bird All American and Vision school buses. The primary and secondary air brake gauges on the instrument cluster may intermittently indicate "0 PSI" instead of the correct air pressure in the tanks. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 121, "Air Brake Systems."

Risk. If the gauges do not correctly display the air pressure that is in the tanks, the operator will not be able to know when the air pressure is actually dropping, increasing the risk of a crash.

Remedy. Blue Bird will notify owners, and dealers will update the display software, free of charge. The recall began on August 1, 2018. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R18ZE-SB.

Defect. Blue Bird Body Company (Blue Bird) is recalling certain model year 2015-2019 Vision and model year 2016 All American school buses equipped with certain QS11 series convertible school bus seats supplied by CE White/HSM Solutions. The integral D-Ring mounting stud located in the upper area of the seat back frame does not provide an adequate padding surface between the seat occupant and the D-Ring mounting stud.

Risk. In a rear crash event, the occupant's head may contact the D-Ring mounting stud, resulting in a head injury or even death.

Remedy. Blue Bird will notify owners, and dealers will equip the Integra D-Ring mounting studs with the proper padding, free of charge. The recall began on September 15, 2017. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R17ZB-SB.