1994 Audi S4

Defect. VEHICLE DESCRIPTION: PASSENGER VEHICLES. A FUEL FEED LINE CONNECTING THE FUEL FILTER TO THE ENGINE CAN PREMATURELY AGE AND SHRINK THROUGH EXPOSURE TO HIGH UNDER HOOD TEMPERATURE CAUSED BY THE TURBOCHARGER.

Risk. THIS CAN RESULT IN FUEL SEEPAGE AT THE CONNECTION.

Remedy. DEALERS WILL REPLACE THE ENTIRE FUEL FEED LINE FROM THE FUEL FILTER TO THE ENGINE WITH A FUEL LINE OF SHRINKAGE-PROOF MATERIAL.

Defect. DEFECTIVE IGNITION SWITCHES WERE IMPROPERLY MANUFACTURED AND CAN CAUSE SOME ELECTRICAL ACCESSORIES TO MALFUNCTION.

Risk. SOME ELECTRICAL ACCESSORIES, SUCH AS, TURN SIGNALS, WINDSHIELD WIPERS, LAMPS, POWER WIND0WS AND AIR CONDITIONERS CAN MALFUNCTION WHEN THE CAR IS STARTED.

Remedy. DEALERS WILL REPLACE THE IGNITION SWITCH.

THERE IS A SEVERE SAFETY PROBLEM ASSOCIATED WITH THE AUDI 94S4, OTHER MODEL YEAR S CARS AND OTHER AUDI CARS WITH THE 100 BODY. WHEN THE PLASTIC PART THAT CONNECTS THE THROTTLE BODY TO THE THROTTLE CABLE BREAKS, THE ENGINE GOES UP TO 7000 RPM (OVER RED LINE). IF IN HEAVILY CONGESTED TRAFFIC AS I WAS, THE OWNER RISKS HIS LIFE OR HIS ENGINE. SINCE I DECIDED MY LIFE AND THAT OF MY PASSENGERS WAS MORE IMPORTANT THAN THE ENGINE, I LET THE ENGINE RACE AND USED THE BRAKE TO CONTROL SPEED UNTIL I COULD SAFELY GET OFF THE BELTWAY AND ONTO A SIDE ROAD. ONCE THERE, I SAW THAT MY EXHAUST MANIFOLD HAD GOTTEN CHERRY RED WITH AND COULD HAVE CAUSED A FIRE. THESE CARS NEED IMMEDIATE RECALL AS A SAFETY MEASURE AND THE PART REPLACED WITH METAL. FAILURE WAS WITHOUT WARNING, CAR''S SPEED BEGAN TO INCREASE WITHOUT WARNING AND THROTTLE PRESSURE HAD NO IMPACT WHATSOEVER. LESS SKILLFUL PERSON WOULD HAVE PANICKED AND CAUSED SEVERE PILE-UP IN RUSH HOUR TRAFFIC. MANY OTHER AUDI OWNERS HAVE REPORTED THE PROBLEM ON THE VARIOUS COMPUTER LISTS AND WEB SITES USED BY AUDI OWNERS. CALL OR WRITE FOR DETAILS. AUDI DEALER WAS UNCONCERNED ABOUT PROBLEM AND PART IS NOT LISTED NOR CAN BE PURCHASED SEPARATELY. MUST PURCHASE ENTIRE THROTTLE BODY AT COST OF OVER $800. *NM

BRAKES ARE NOT WORKING PROPERLY. DEALER HAS REDONE BRAKES TWICE.*AK

RECALL OOV068000; KY CONSUMER CONTACTED T MANUFACTURER, MANUFACTURER STATED THIS VEHICLE NOT INCLUDED DUE TO VIN. CONSUMER NOTED IN COLD WEATHER FUEL LEAKS AT THE LINE, LINES ARE VERY WET. ALSO, A GAS SMELL IN PASSENGER'S COMPARTMENT. *AK

INTERMITTENT FUEL LINE LEAK NEAR EXHAUST MANIFOLD AND TURBOCHARGER. *AK

WHILE TRAVELING SMELLED FUEL INSIDE VEHICLE. DEALER STATED FUEL LINE HAD A LEAK. PLEASE PROVIDE FURTHER INFORMATION. *AK

FUEL SUPPLY LINE LEAKS. *AK

THE FUEL LINE WAS FOUND TO BE LEAKING GASOLINE RATHER HEAVILY. THE LEAK OCCURED IN CLOSE PROXIMITY TO THE EXHAUST AND TURBOCHARGER. THE FAILED FULE LINE WAS PREVIOUSLY REPLACED IN JANUARY 1997 AT ABOUT 61,622 MILES FOR THE SAME FAILURE. THE CAR WAS EXAMINED BY DEALER PERSONNEL FOR COMPLAINTS OF GASOLINE SMELL AND LEAKING FUEL LINE ON TWO PRIOR OCCASIONS IN 1996. THE INITIAL FAILURE WAS REPAIRED UNDER AN EXTENDED WARRANTY. THE SECOND FAILURE (1999) WAS REPAIRED AT THE MANUFACTURER'S EXPENSE, AS I UNDERSTAND IT.