2005 Volvo V70

Defect. Volvo Cars USA, LLC (Volvo Car) is recalling certain 2001-2007 V70 and XC70 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Risk. An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy. Dealers will replace the driver's air bag, free of charge. Owner notification letters were mailed December 14, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10136.

Defect. VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.

Risk. AN OVERHEATED BATTERY COULD LEAD TO A FIRE.

Remedy. VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.

Defect. CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.

Risk. LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy. CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.

Defect. CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE LABEL DENOTING THE TIRE AND LOADING PRESSURE INFORMATION IS INCORRECT.

Risk. A MISPRINTED LABEL WOULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.

Remedy. DEALERS WILL MAIL THE CORRECT LABELS FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 18, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

Volvo do not want to replace the recall airbag with the same original logo on the airbag. This logo is the “R” on the airbag. The airbag without the “R” is for a regular Volvo.

TL* THE CONTACT OWNS A 2005 VOLVO V70. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE THROTTLE BODY MODULATOR FAILED. THE VEHICLE WAS REPAIRED BUT THE FAILURE CONTINUED TO OCCUR. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHO DIAGNOSED THAT THE FUEL SENSOR GAUGE FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 124,000.

TL* THE CONTACT OWNS A 2005 VOLVO V70. WHILE THE VEHICLE WAS UNDERGOING MAINTENANCE, IT WAS DISCOVERED THAT THE FUEL LINES WERE HANGING AND THE PLASTIC COVER HAD DETACHED. THE DEALER RECOMMENDED REPLACING THE FUEL LINE COVER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 81,000. UPDATED 10/07/14*LJ THE CONSUMER STATED PRIOR MODEL YEARS WERE RECALLED. UPDATED 3/24/2015*JS

CAR STALLS DIES IN TRAFFIC. *TR

TL* THE CONTACT OWNS A 2005 VOLVO V70. THE CONTACT STATED THAT WHILE TRAVELING 35 MPH, THE EMERGENCY BRAKE ENGAGED, CAUSING THE REAR DRIVER SIDE WHEEL TO SEIZE. THE VEHICLE WAS LATER TOWED TO A PRIVATE MECHANIC WHERE IT WAS CONFIRMED THAT THE PARKING BRAKE FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE 91,000.

TL* THE CONTACT OWNS A 2005 VOLVO V70. THE CONTACT STATED THAT RADIATOR FLUID WOULD LEAK INTO THE TRANSMISSION, CAUSING THE VEHICLE TO JERK AND PERFORM SLUGGISH. THE DEALER DIAGNOSED THAT THE CONTACT WOULD NEED A NEW TRANSMISSION. THE MANUFACTURER WAS NOT CONTACTED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 100,000 AND THE CURRENT MILEAGE WAS 103,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2005 VOLVO V70. THE CONTACT STATED THAT THE VEHICLE WOULD EXHIBIT A LOUD BANGING WHEN CHANGING GEARS WHILE DRIVING 25 MPH AND ABOVE. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THE DEALER ADVISED THAT THE TRANSMISSION FLUID WOULD NEED REPLACING AND THE COMPUTER WOULD NEED A SOFTWARE UPGRADE. THE DEALER MADE THE REPAIRS BUT TO NO AVAIL. THE FAILURE MILEAGE WAS 100,000.

TL*THE CONTACT OWNS A 2005 VOLVO V70. THE CONTACT STATED THAT WHILE AT A COMPLETE STOP SHE ENGAGED THE ACCELERATOR PEDAL; HOWEVER, THE VEHICLE HESITATED AND DID NOT RESPOND. THE VEHICLE RESPONDED WITHIN A FEW MINUTES ALTHOUGH THE FAILURE OCCURRED SEVEN ADDITIONAL TIMES. THE DEALER WAS INFORMED ABOUT THE FAILURE AND STATED THAT THE VEHICLE NEEDED A NEW TRANSMISSION. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 79000. THE CURRENT MILEAGE WAS 85000.

BRAKE FAILURE DURING SLOW-TO-STOP WHILE MOVING VEHICLE INTO GARAGE. BRAKES WENT STIFF WITH LITTLE BRAKING ACTION. LIFTED AND REPLANTED ON PEDAL REGAINED BRAKING ABILITY. *TR

TL*THE CONTACT OWNS A 2005 VOLVO V70R. THE CONTACT STATED THAT HIS VEHICLE WOULD LOSE POWER WHEN ACCELERATING. THE ACCELERATION WOULD "DROP OUT" AND PICK BACK UP FOR A SECOND OR TWO. IT APPEARED AS IF THE BRAKES HAD BEEN APPLIED, BUT NO BRAKE LIGHTS WOULD ILLUMINATE. AS A RESULT, OTHER DRIVERS COULD NOT BE FOREWARNED ABOUT THE DECELERATION, POTENTIALLY CAUSING THE RISK FOR A CRASH. THE FAILURE OCCURRED WHILE DRIVING 40 MPH OR WHILE ACCELERATING TO SOME EXTENT. HE TOOK THE VEHICLE TO THE DEALER AND THEY ACKNOWLEDGED NHTSA CAMPAIGN ID NUMBER 07V226000 (ENGINE AND ENGINE COOLING) FOR MODEL YEARS 2003-2004, BUT THEY WOULD NOT ASSIST BECAUSE NO CODES APPEARED DURING THE DIAGNOSTIC. IN ADDITION, HIS MODEL YEAR WAS NOT INCLUDED IN THE RECALL. THE DEALER STATED THAT THE 2005 MODEL YEAR WAS THE SAME AS THE 2003 AND 2004 YEARS INCLUDED IN THE RECALL. THE CURRENT MILEAGE WAS 42,000 AND FAILURE MILEAGE WAS APPROXIMATELY 30,000.

CLEAR PLASTIC BUBBLED UP IN FRONT OF SPEEDOMETER CAUSING BLURRY VIEW OF SPEED AND OTHER INFORMATION. *TR

TL*THE CONTACT OWNS A 2005 VOLVO V70. THE CONTACT STATED THAT THE VEHICLE CONSTANTLY STALLS. ON ONE OCCASION, THE VEHICLE STALLED WHILE DRIVING 60 MPH AND THE CHECK ENGINE LIGHT ILLUMINATED. THE CONTACT NOTICED THAT WHEN SHE KEPT THE FUEL AMOUNT AT HALF A TANK, THE VEHICLE WOULD NOT STALL. THE DEALER STATED THAT THE FUEL SENSOR PRESSURE WAS CAUSING THE FAILURE. THE MANUFACTURER STATED THAT THEY WERE AWARE OF THE FAILURE; HOWEVER, HER VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 07V226000 (ENGINE AND ENGINE COOLING). THE VEHICLE WAS REPAIRED AT THE COST OF $392. THE ENGINE SIZE WAS UNKNOWN. THE CURRENT MILEAGE WAS 69,734 AND FAILURE MILEAGE WAS 67,000.

CONSUMER COMPLAINT FOR MICHELIN ENERGY TIRES. SHE STATES IN THE PAST 2.5 YEARS SHE HAS HAD 6 SIDEWALL BLOWOUTS WITH THESE TIRES. SHE IS CONCERNED FOR THE SAFETY OF HER SELF AND CHILDREN AND WANTS THEM RECALLED. *KB THE CONSUMER STATED HAS 2.5 YEARS LEFT ON THE WARRANTY OF THIS TIRE AND WOULD LIKE TO HAVE A DIFFERENT TIRE FOR THE VEHICLE. THE CHECK ENGINE LIGHT ILLUMINATED DUE TO AN EVAPORATOR LEAK *TR

TL*THE CONTACT OWNS A 2005 VOLVO V70. WHILE APPROACHING A STOP SIGN AT 55 MPH, THE VEHICLE BEGAN SMOKING UNDER THE HOOD. THE CONTACT EXITED THE VEHICLE RIGHT BEFORE IT BURST INTO FLAMES. THE FIRE DEPARTMENT ARRIVED AT THE SCENE AND A REPORT WAS FILED. THE VEHICLE WAS DESTROYED AND TOWED TO A REPAIR SHOP. THE FIRE INSPECTORS STATED THAT THE FIRE WAS CAUSED BY A LEAK IN THE FUEL INJECTION PIPE. THE CURRENT AND FAILURE MILEAGES WERE 9,000. UPDATED 10/23/07 *TR

AFTER SEVERAL REPAIR EFFORTS, THE PASSENGER SEAT AIR BAG SENSOR DOES NOT OPERATE PROPERLY. WHEN PERSONS ARE RIDING IN THE PASSENGER SEAT, THE PASSENGER AIRBAG OFF LIGHT IS LIT. *NM

SINCE MID JULY, 05 CAR HAS HAD AN INTERMITTENT STALLING PROBLEM. WHEN YOU STOP, AFTER THE CAR IS AT OPERATING TEMP. IT WILL SEEK IDLE, RUN UP TO ABOUT 1,000 RPM & EITHER DROP TO BELOW 500 RPM OR STALL OUT. IT DOES THIS ON SEVERAL MAKES OF PREMIUM GAS, MOBIL, SHELL, TEXICO/AMACO, AND OR MARATHON. IT WILL RESTART EASILY AND THEN DOES NOT LOSE IDLE AGAIN FOR SOME TIME. I HAD IT CHECKED BY DEALERSHIP, AND THEY FIND THE MASS AIR SENSOR AND THROTTLE MODULE ARE BAD. COST TO CURE IS $1,500. I DO NOT THINK A CAR WITH 64K MILES SHOULD NEED THIS TYPE OF EXPENSE. I THINK A CAR THAT STALLS IN TRAFFIC WITHOUT ANY WARNING IS A HAZARD. I HAVE CONTACTED VOLVO, AND THEY ARE SORRY BUT CAN DO NOTHING ABOUT IT AT THIS TIME. THEY ARE REPLACING OR MAKING ADJUSTMENT TO COST IN SWEDEN AT THIS TIME PER "BRICKBOARD" THE VOLVO WEB SITE ON THROTTLE MODULES. I HAVE ASKED FOR ORIGINAL PARTS, AND WILL SAVE THEM. *NM

MY CAR IS A 2005 VOLVO V70R PURCHASED NEW IN JULY 2005. THREE WEEKS AGO, WITH NO WARNING, THE CAR SUDDENLY LOST POWER, BUT KEPT RUNNING WITH GREAT HESITATION (I WAS DRIVING AT ONLY 30 MPH AT THE TIME). TOWED TO DEALER AND THROTTLE SENSOR REPLACED UNDER WARRANTY. YESTERDAY (9/15), THE SAME THING HAPPENED AGAIN, AFTER ONLY ABOUT 250 MILES OF DRIVING. CAR WAS TOWED TO DEALER AGAIN AM I AWAITING WORD. IN BOTH CASES AN ERROR MESSAGE "DECREASED ENGINE PERFORMANCE" WAS DISPLAYED. THERE WAS NO ADVANCE WARNING. IN BOTH CASES, I WAS DRIVING AT ABOUT 30 MPH ON A SECONDARY ROAD. THESE 2 INSTANCES HAVE CAUSED ME TO LOSE CONFIDENCE IN THE CAR, ESPECIALLY TO DRIVE ON HIGHWAY.*JB

WE PURCHASED A 2005 VOLVO V70 NEW. WE HAVE TAKEN THE CAR BACK TO THE DEALER 3 TIMES BECAUSE THE PASSANGER AIRBAG DEACTIVATES WHEN AN ADULT IN THE SEAT SEEMS TO MOVE AROUND . THE FIRST TIME THE DEALEAR RECALIBRATED THE COMPUTER. THE SECOND TIME THEY CHANGED THE SEAT. THE THIRD TIME THEY HAD A FIELD REP DRIVE THE CAR WITH AN ADULT IN THE SEAT, WHILE THE LIGHT DID COME ON THE REP SAID THAT IT WAS OPERATING NORMAL. I WOULD LIKE TO FIND OUT IF THIS IS NORMAL AND IF IT IS TO RAISE A CONCERN FOR THE SAFETY OF THE PASANGER.

THE VEHICLE IS A 2000 VOLVO AWD CROSS COUNTRY. THE CAR WHILE AT HIGHWAY SPEED DECELERATED ABRUPTLY AND NEARLY CAUSED A REAR END IMPACT ON THE BACK OF MY CAR. THIS ALSO HAPPENED EARLIER ON A VACATION TRIP IN MAY 2005. I WAS TOLD BY A FRIEND AND THE DEALERSHIP THAT SOLD US THE CAR TO US (NEW) THAT THERE WAS A CLASS ACTION SUIT FOR THE REASONS CAUSING OUR PROBLEM REGARDING THE ATC COMPUTER /THROTTLE CONTROL. HAVING SPENT OVER 1500 DOLLARS FOR THE REPAIR IT APPEARS THAT THE DEALER WILL NOT REIMBURSE US FOR THE RECALL COSTS AND ALSO DID NOT INDICATE OR ASSURE US THAT THE CAUSE OF THE PROBLEM WOULD BE TAKEN CARE OF BY THE REPAIR. THE CAR PROBLEMS WE EXPERIENCED WHERE DESCRIBED IN AN ISSUE OF VOLVO CLUB MAGAZINE. *NM

UNEXPECTED AND INTERMITENT BRAKE FAILURE. DISCUSSED AT LENGTH ON VOLVO FORUM. HERE IS THE LINK: HTTP://FORUMS.SWEDESPEED.COM/ZEROTHREAD?ID=32551